Flowline EchoSpan LU80 Ultrasonic Level Transmitter Specs

Flowline EchoSpan LU80 Ultrasonic Level Transmitter Specs
Prices as of April 27, 2016. Check Web site for most current prices.
Echotouch™, EchoSpan® &
EchoSwitch® Ultrasonic Liquid
Level Sensors
The Echotouch, EchoSpan and EchoSwitch are innovative
ultrasonic liquid level sensor families that replace float,
conductance and pressure sensors that fail due to contact with
dirty, sticky and scaling media in small, medium and large
capacity tanks. Applied in chemical, water and wastewater
applications, these general purpose non-contact sensors are
available with single and multi-function capabilities including
continuous level measurement, switching and control.
For input to a PLC or other controller, measurement outputs
include current, voltage and frequency. Models with three
relays can be configured for level alarms and/or stand-alone
level control such as automatic fill or empty functions using the
embedded level controller. Units are easily configured using
built -in pushbuttons.
Range
$883.00
$646.00
Pressure
LU83-5101
LU84-5101
LU77-5004
LU74-5004
LU78-5004
$739.00
$832.00
$925.00
$739.00
$785.00
$832.00
EchoSpan
Intrinsically safe
6 in to 18 ft
(15 cm to 5.5m)
EchoSwitch
General Purpose (non-hazardous)
4 in to 9.8 ft
(10 cm to 3m)
Output Types
Install
Mounting
Relays
Configuration
Ambient
Temperature
Process
Temperature
LU81-5101
Echotouch
8 in to 18 ft
(20 cm to 5.5m)
8 in to 26.2 ft
(20 cm to 8m)
12 in to 32.8 ft
(30 cm to 10m)
4 in to 9.8 ft
(10 cm to 3m)
8 in to 18 ft
(20 cm to 5.5m)
8 in to 26.2 ft
(20 cm to 8m)
(1) SPDT relay, (2) SPST relays
4-20 mA, two-wire
4-20 mA, two-wire
1 in MNPT
2 in MNPT
1 in MNPT
No relay
2 in MNPT
Pushbutton / LCD
-40° to 160°F (-40° to 71°C)
-40° to 140°F
(-40° to 60°C)
-4° to 140°F (-20° to 60°C)
30 PSI (2 bar) @
25°C, derated @
1.667 psi (0.113
bar) per °C above
25°C (77°F)
30 PSI (2 bar) MAX
Motion: Servos
and Steppers
Motor Controls
Sensors:
Proximity
Sensors:
Photoelectric
Sensors:
Encoders
Sensors:
Limit Switches
Sensors:
Current
Sensors:
Temperature
Sensors:
Level
Sensors:
Flow
Pushbuttons
and Lights
Signal
Devices
(1) SPDT relay, (2) SPST relays
-4° to 140°F
(-20° to 60°C)
Pushbutton Configuration
Motors
Stacklights
Vertical, top of tank
2 in MNPT
Soft Starters
Sensors:
Pressure
Echotouch, EchoSpan & EchoSwitch Ultrasonic Liquid Level Sensors General Specifications
LU20-5001-IS LU80-5101
Drives
Power
Transmission
Overview
Model
Price
Type
Class
Company
Information
Process
Relays and
Timers
Pneumatics:
Air Prep
Pneumatics:
Directional Control
Valves
Example - EchoSpan Display and Menu
With no software or PC required, the Echotouch, EchoSpan, and
EchoSwitch ultrasonic level sensors are easily configured using
integral pushbuttons and LCD digital display. Configuration
parameters are organized in a simple menu structure so that
parameter values are easily accessed and set or changed as
needed. Parameters are stored in non-volatile memory so the
setting values are not lost when the sensor is powered down,
allowing configuration before installation in the field.
Pneumatics:
Tubing
Pneumatics:
Air Fittings
Appendix
Book 2
Terms and
Conditions
Book 2 (14.3)
www.automationdirect.com/ultrasonic-level-sensors
Pneumatics:
Cylinders
Level Sensors
eLE-15
Prices as of April 27, 2016. Check Web site for most current prices.
EchoSpan® LU Series Ultrasonic
Level Transmitters
Overview
Features
• 4 measurement ranges from 9.8 ft (3m) to 32.8 ft (10m)
• Configuration is simple via integral pushbutton display module
• LCD display indicates level in inches, centimeters and percentages
• Narrow 2 inch or 3 inch beam width for applications with limited
measurement space
• Fail-safe intelligence and diagnostic feedback for simple
troubleshooting
• PVDF transducer and NEMA 4X / IP65 polycarbonate enclosure for
corrosive liquids
• Automatic temperature compensation for accurate measurement
• Made in the USA
The EchoSpan LU series ultrasonic level transmitters provide
continuous level measurement up to 32.8 ft (10m) with a 4-20 mA
signal output, and is configured via its integral pushbutton display
module. This non-contact liquid level sensor is ideally suited for
corrosive, ultrapure, sticky or dirty liquids, and is broadly selected
for bulk storage, day tank, lift station and process tank level
applications.
Part No. LU80-5101
Part No. LU81-/83/84-5101
LU80 Series Technical Specifications
Model
Price
Range
Accuracy
Resolution
Sensing Dead Band*
Beam Width
Configuration
Memory
Display Type
Display Units
Supply Voltage
Loop Resistance
Signal Output
Signal Invert
Signal Fail-Safe
Terminal Block
Process Temperature
Temp. Compensation
Ambient Temperature
Pressure
Enclosure Rating
Enclosure Material
Enclosure Hardware
Enclosure Vent
Conduit Entrance
Transducer Material
LU80-5101
LU81-5101
LU83-5101
$646.00
$739.00
$832.00
LU84-5101
$925.00
4 in to 9.8 ft (10 cm to 3m)
8 in to 18 ft (20 cm to 5.5m)
8 in to 26.2 ft (20 cm to 8m)
12 in to 32.8 ft (30 cm to 10m)
± 0.2% of range
0.019 in (0.5 mm)
0.039 in (1 mm)
4 in (10 cm)
8 in (20 cm)
2 in (5.1 cm)
0.078 in (2 mm)
12 in (30 cm)
3 in (7.6 cm)
Pushbutton / LCD
Non-volatile
LCD, 6-digit
Inch, cm and percent
12 - 28 VDC**
500Ω @ 24 VDC
4-20 mA, two-wire
4-20 mA or 20-4 mA
4 mA, 20 mA, 21 mA, 22 mA or hold last
26-12 AWG (tighten torque, 0.5 Nm)
-4° to 140°F (-20° to 60°C)
Automatic
-40° to 160°F (-40° to 71°C)
30 PSI (2 bar) MAX
NEMA Type 4X (IP65)
Polycarbonate
Brass & stainless steel
Water tight membrane
Dual, 1/2 in FNPT
Polyvinylidene Flouride
Process Mount
1 in MNPT (See accessories for
installation fittings)
2 in MNPT (See accessories for installation fittings)
Mount Gasket
Viton (included, replacement part
number 200128)
Viton (included, replacement part number 200129)
Weight (lbs)
Classification
Compliance
1.5
1.9
General purpose
CE, RoHS
* Dead band is the minimum distance the sensor must be mounted above the max liquid level.
** If supply exceeds 28 VDC damage to the transmitter may occur.
Book 2 (14.3)
eLE-18
Level Sensors
1-800-633-0405
Prices as of April 27, 2016. Check Web site for most current prices.
EchoSpan® LU Series Ultrasonic
Level Transmitters
Dimensions
Configuration
LU80 Series
The transmitter is configured using
the three buttons (UP, DOWN and
SELECT) and the transmitter’s LCD
on the transmitters face.
inches [mm]
Company
Information
Drives
Soft Starters
Motors
Power
Transmission
Motion: Servos
and Steppers
More information about configuring
the LU series sensors can be found at
www.AutomationDirect.com
Motor Controls
Sensors:
Proximity
Sensors:
Photoelectric
Sensors:
Encoders
Sensors:
Limit Switches
Sensors:
Current
Sensors:
Pressure
Sensors:
Temperature
Sensors:
Level
Sensors:
Flow
Dimensions
LU80
LU81, 83 & 84
A
B
C
3.90 [99.1] 4.10 [104.1] 5.20 [132.1]
5.50 [139.6] 4.10 104.1] 5.20 [132.1]
D
E
F
G
H
3.10 [78.8]
3.10 [78.8]
2.80 [71.1]
2.80 [71.1]
1.90 [48.3]
3.40 [86.4]
1.25 [31.8]
2.70 [68.6]
1 in MNPT
2 in MNPT
Pushbuttons
and Lights
Stacklights
When installing the 1 inch NPT level sensors care should be used to mechanically isolate the sensor housing from the tank. This
can easily be done by using any of the Flowline mounting accessories which are designed to provide the isolation needed.
Signal
Devices
Wiring
Process
Typical Loop Powered Display
Typical Generic PLC
Relays and
Timers
Pneumatics:
Air Prep
Pneumatics:
Directional Control
Valves
C
4
3
Pneumatics:
Cylinders
2
1
Pneumatics:
Tubing
Pneumatics:
Air Fittings
EchoSpan
Appendix
Book 2
EchoSpan
Terms and
Conditions
Book 2 (14.3)
www.automationdirect.com/ultrasonic-level-sensors
Level Sensors
eLE-19
Prices as of April 27, 2016. Check Web site for most current prices.
Ultrasonic Liquid Level Sensor
Accessories
Ultrasonic Liquid Level Sensor Accessories
Part No.
Item Photo
Description
Quantity
Weight
Price
LI40-1001
Flowline PodView general purpose digital indicator, displays tank level or volume and sensor relay status,
6-digit LCD display with four relay status indicators, 3-button user interface, polycarbonate panel mount
enclosure with NEMA 4 (IP65) faceplate, 6-foot (1.8-meter) 22AWG 4-conductor cable, compatible with
any Flowline EchoPod series ultrasonic level sensor with firmware V50 or later
1
0.6
$181.00
LM50-1001
Flowline side mount bracket, 2 inch NPT female threads, polypropylene (PP), for use with Flowline DL34,
LU20, LU23, LU28, LU29, LU74, LU78, LU81, LU83, and LU84 series ultrasonic level sensors
1
0.4
$32.00
LM50-1001-1
Flowline side mount bracket, 2 inch NPT female threads, polypropylene (PP), and 2 inch NPT male x 1
inch NPT female reducer bushing (PVC), for use with Flowline DL14, DL24, DS14, DL10, DX10, LU27,
LU77, and LU80 series ultrasonic level sensors
1
0.6
$41.00
LM52-1400
Flowline reducer bushing, 2 inch NPT male x 1 inch NPT female threads, PVC, for use with Flowline DL14,
DL24, DS14, DL10, DX10, LU27, LU77, and LU80 series ultrasonic level sensors
1
0.2
$13.00
LM52-2400
Flowline reducer bushing, 3 inch NPT male x 2 inch NPT female threads, PVC, for use with Flowline DL34,
LU20, LU23, LU28, LU29, LU74, LU78, LU81, LU83, and LU84 series ultrasonic level sensors
1
0.6
$29.00
LM52-1890
Flowline low-profile bulkhead fitting, 1 inch NPT female x slip socket, with mounting nut, PVC, for use with
Flowline DL14, DL24, DS14, DL10, DX10, LU27, LU77 and LU80 series ultrasonic level sensors
1
0.5
$41.00
LM52-2890
Flowline low-profile bulkhead fitting, 2 inch NPT female x slip socket, with mounting nut, PVC, for use
with Flowline DL34, LU20, LU23, LU28, LU29, LU74, LU78, LU81, LU83, and LU84 series ultrasonic level
sensors
1
1.2
$69.00
LM52-1850
Flowline mounting flange, 1 inch NPT female threads, PVC, for use with Flowline DL14, DL24, DS14,
DL10, DX10, LU27, LU77, and LU80 series ultrasonic level sensors
1
0.5
$41.00
LM52-2850
Flowline mounting flange, 2 inch NPT female threads, PVC, for use with Flowline DL34, LU20, LU23,
LU28, LU29, LU74, LU78, LU81, LU83, and LU84 series ultrasonic level sensors
1
1.0
$60.00
204038
Replacement mounting gasket, for use with Flowline DL14, DL10, DX10, and DS14 series ultrasonic level
sensors
1
0.1
$5.00
200128
Replacement mounting gasket, for use with Flowline DL24, LU27, LU77, and LU80 series ultrasonic level
sensors
1
0.1
$9.00
200129
Replacement mounting gasket, for use with Flowline DL34, LU23, LU28, LU29, LU74, LU78, LU81, LU83,
and LU84 series ultrasonic level sensors
1
0.1
$13.00
When installing the 1” NPT level sensors care should be used to mechanically isolate the sensor housing from the tank. This can easily
be done by using any of the Flowline mounting accessories which are designed to provide the isolation needed.
Dimensions
inches [mm]
LM50-1001
LM50-1001-1
Book 2 (14.3)
eLE-22
Level Sensors
1-800-633-0405
Prices as of April 27, 2016. Check Web site for most current prices.
Ultrasonic Liquid Level Sensor
Accessories
Dimensions
Drives
Soft Starters
Motors
inches [mm]
LM52-1400
Company
Information
Power
Transmission
LM52-2400
Motion: Servos
and Steppers
Motor Controls
Sensors:
Proximity
Sensors:
Photoelectric
Sensors:
Encoders
Sensors:
Limit Switches
Sensors:
Current
LM52-1890
Sensors:
Pressure
LM52-2890
Sensors:
Temperature
Sensors:
Level
Sensors:
Flow
Pushbuttons
and Lights
Stacklights
Signal
Devices
Process
Relays and
Timers
LM52-1850
LM52-2850
Pneumatics:
Air Prep
Pneumatics:
Directional Control
Valves
Pneumatics:
Cylinders
Pneumatics:
Tubing
Pneumatics:
Air Fittings
Appendix
Book 2
Terms and
Conditions
Book 2 (14.3)
www.automationdirect.com/ultrasonic-level-sensors
Level Sensors
eLE-23
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement