MATERIAL SAFETY DATA SHEET Total Solutions P.O. Box 240014 Milwaukee, WI 53224 GENERAL INFORMATION NUMBER: (414) 354-6417 CHEMTREC: (800) 424-9300 REVISION DATE: November 7, 2004 DATE OF ISSUE: November 9, 2004 I - Product Identification Clear Cut PRODUCT CODE: 1718 CHEMICAL FORMULATION: Water based alkaline detergent/cleaner. NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 2 HAZARD RATING: 4 - Extreme; 3 - High; FLAMMABILITY: 0 2 - Moderate; 1 - Slight; REACTIVITY: 0 0 - Insignificant II - Hazardous Ingredients SUBSTANCE 2-Butoxyethanol Monoethanolamine Cocodiethanolamide Trisodium Phosphate Key: Values reported as TWA unless noted. APPROX OSHA ACGIH EPA 40 CFR: % PEL TLV 302 355 372 1.00-10.0 25 ppm (skin) 25 ppm (skin) N N Y 1.00-10.0 3 ppm 3 ppm N N N 1.00-3.00 N/E N/E N N N 1.00-3.00 N/E N/E N N N CAS # 111-76-2 141-43-5 120-40-1 7601-54-9 PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No 302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4). 355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355). 372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372). III - Physical Data BOILING POINT (°F): N/D SPECIFIC GRAVITY (WATER = 1): 1.00 VAPOR PRESSURE (mm Hg): N/D VOC CONTENT (% by weight): 5.00-15.0 VAPOR DENSITY (AIR = 1): N/D EVAPORATION RATE (WATER = 1): N/D SOLUBILITY IN WATER: Soluble pH: 11.5-12.5 APPEARANCE AND ODOR: Clear, colorless to slight yellow liquid; mild detergent odor. IV - Fire and Explosion Hazard Data FLASH POINT (°F): None (TEST METHOD): Closed cup FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: N/A LOWER: N/A EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical. SPECIAL FIRE FIGHTING PROCEDURES: Cool drums in vicinity of fire with water fog. Firefighters should be equipped with full protective gear including self-contained breathing apparatus. UNUSUAL FIRE AND EXPLOSION HAZARD: None. PRODUCT NAME: Clear Cut PRODUCT CODE: 1718 V - Reactivity Data STABILITY: Stable INCOMPATIBILITY: Strong acids. CONDITIONS TO AVOID: None HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon. HAZARDOUS POLYMERIZATION: Will not occur. CONDITIONS TO AVOID: None VI - Health Hazard Data ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None. EFFECTS OF OVEREXPOSURE IF IN EYES: Moderate irritation and redness. IF ON SKIN: Slight to moderate irritation with prolonged or repeated contact. IF SWALLOWED: May cause burns to mucous membranes, nausea, diarrhea. IF INHALED: Irritation of respiratory tract, headache. EMERGENCY AND FIRST AID PROCEDURES IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Obtain medical attention. IF ON SKIN: Flush skin with water for 15 minutes while removing contaminated clothing. Obtain medical attention if irritation persists. Launder clothing separately before re-use. IF SWALLOWED: Contact physician or poison control center immediately. Do not induce vomiting unless told to do so by a poison control center or doctor. Rinse mouth with water and give affected person one to two glasses of water. Never give anything by mouth to an unconscious person. IF INHALED: Remove person to fresh air. If breathing stops, adminis ter artificial respiration. If breathing is difficult, give oxygen. VII - Spill or Leak Protection STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Contain spill and ventilate area. Soak up on inert absorbent material and place in a properly labeled closed container for disposal. WASTE DISPOSAL METHOD: Consult local environmental authorities. VIII - Special Protection Information RESPIRATORY PROTECTION: Use with adequate ventilation. Do not breathe vapors or mists. If recommended Exposure Limits are exceeded wear a NIOSH approved respirator, following manufacturer’s recommendations. VENTILATION LOCAL: Recommended MECHANICAL: Not required PROTECTIVE GLOVES: Chemical resistant. EYE PROTECTION: Safety glasses or chemical goggles. OTHER PROTECTIVE EQUIPMENT: Protective clothing and eye wash station. PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from acids. Do not mix with other cleaning chemicals. Keep container tightly closed when not in use. OTHER PRECAUTIONS: Keep out of reach of children. IX - Transportation Information (ground transportation only) DOT PROPER SHIPPING NAME: None DOT CLASS: None DOT ID NUMBER: None DOT PACKING GROUP: None The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further intended, different shipping names and labeling may apply. REVISION DATE: November 7, 2004 Prepared by: PMR DATE OF ISSUE: November 9, 2004 This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties caused by the material such vendees or users assume all risks associated with the use of this material.
* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project