L190765

L190765
PORCELAIN
Tile Cleaner
DESCRIPTION
This product is an extra strength clinging bowl, tile, and porcelain
cleaner and deodorizer designed to remove heavy build-up of
water scale, soap scum, urinary salts, and rust from hard surfaces.
Can be used to clean and deodorize wash basins, bath tubs,
shower stalls, drinking fountains, toilet bowls, urinals, and sinks.
Its clinging formula controls run-off for effective usage. Contains
no harmful hydrochloric or sulfuric acids.
DIRECTIONS
TOILET BOWLS: Remove water by forcing it over the trap with the
swab mop. Saturate swab with the cleaner and wet all surfaces
thoroughly. It is most important to swab under the rim of the bowl to
clean water outlets. Allow cleaner to remain for at least 10 minutes
until all rust, scale, and stains are loosened. Rinse by flushing.
URINALS: Place clean mop over trap in urinal and saturate with
bowl cleaner. Swab urinal thoroughly. Remove screen at urinal
trap and pour approximately 6 to 8 ounces of concentrate into
and around drain opening. Allow to soak a few minutes. Replace
screen and flush well.
TILE, WASHSTANDS, SHOWERS, FIBERGLASS, STAINLESS
STEEL: Always dilute product by adding 1 quart of product per
gallon of water. Using a swab mop, sponge, brush or cloth; apply
to wet all surfaces thoroughly. Rinse thoroughly with clear water
after several minutes. Do not use on any surface, such as marble,
that can be damaged by acidic materials. Many surfaces are not
resistant to acid.
PRODUCT SPECIFICATIONS
Acid Content:
Color:
Odor:
Base:
pH:
Viscosity:
Abrasives:
Solubility:
Detergency:
Rinsability:
Fumes:
Flash Point:
Hard Water Tolerance:
Biodegradability:
Storage/Stability:
Weight per Gallon:
Freeze / Thaw Stability:
20.0±0.5%
Pink
Cherry
Phosphoric acid
1.0 - 1.5
Thick and clinging
None
Complete with water
Excellent
Excellent
None
None
Excellent
Complete
2 years
8.49 lbs./gal.
Keep from freezing
Reorder#
19-0765
2011 N. High St., Lansing, MI 48906 • Phone: 800-331-3339 • www.Michco.com
R
MATERIAL SAFETY DATA SHEET
BIJ
Prepared by: Regulatory Affairs Dept.
(Prepared According to 29 CFR 1910.1200)
N/A=Not Applicable
Effective Date: 1/09 Revision: n/a
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer’s
Name:
Product
Name: Porcelain Tile Cleaner
Misco Products
Corporation
Generic
Name: Porcelain Tile Cleaner
Manufacturer’s Address:
Chemical Family: Acid Detergent Blend
1048 Stinson Drive Reading, PA 19605
Formula: Proprietary
Manufacturer’s Phone #: (610) 926-4106
Product Name: Big John
Suppliers Name:Supplier’s
MichcoName:
Generic Name: Heavy Duty Clinging Bowl, Tile,
Suppliers Address:
2011 Address:
N. High St., Lansing, MI 48906
Supplier’s
& Porcelain Cleaner
Chemical Family: Acid Detergent Blend
Suppliers Website: www.Michco.com
Supplier’s Phone #:
Formula: Proprietary
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME
Water
Phosphoric Acid
Nonionic Surfactant
Dimethyl Benzyl Ammonium Chloride
Xanthan Gum
Perfume Oil
CAS NO.
7732-18-5
7664-38-2
9016-45-9
8001-54-5
11138-66-2
N/A
SECTION 3-PHYSICAL DATA
WT. %
to 100
20 to 25
0 to 5
0 to 5
0 to 5
0 to 5
PEL
TWA-TLV
STEL-TLV
1mg/M3
1mg/M3
3mg/M3
SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (°F): 210 F.
Specific Gravity: 1.139
Vapor Pressure: <20mm Hg @ 68 F.
Vapor Density (Air=1): >1
% Volatile: 65+
pH: 1.0-1.5
Solubility in Water: Complete
Evaporation Rate (Water=1): <1
Physical Description: Thick pink liquid with pleasant odor.
Flash Point (Method Used): None
Upper Explosion Limit: N/A
Lower Explosion Limit: N/A
Extinguishing Media: N/A
Special Firefighting Procedures: Non Flammable
Unusual Fire and Explosion Hazards: N/A
SECTION 5-REACTIVITY DATA
Stability: Stable
Hazards Decomposition Products: Phosphoric oxide vapors in a fire.
Hazardous Polymerization: None
Incompatibility (Materials to Avoid): Strong alkalis.
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER. Corrosive to eyes. Severe skin irritant. Avoid contact with eyes, skin and clothing. Keep out of reach of children. For use by trained personnel only. Keep
container closed during storage. For institutional and industrial use only. Wear rubber gloves and protective eyewear when using. Avoid breathing of vapors. Use in
well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID
Effects of Overexposure:
Skin: Severe skin irritant. Prolonged or repeated contact can cause chemical burns
or dermatitis.
Eyes: Severe eye irritant. Liquid and mists may burn or injure eyes, causing corneal
damage.
Inhalation: May be irritating to mucous membranes of the nose, throat, and lungs.
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache,
nausea, abdominal pain, vomiting, and diarrhea. Excessive amounts may cause
collapse.
First Aid Procedures:
Skin: Flush exposed area with large quantities of water. Seek medical attention if
irritation persists.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
attention if irritation persists.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
attention immediately.
SECTION 8-SPECIAL PROTECTION INFORMATION
Respiratory Protection: Use in well-ventilated area.
Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 ingredients below acceptable limit.
Protective Gloves: Acid proof rubber or neoprene.
Eye Protection: chemical splash goggles.
Other Protective Equipment: Eyewash should be available nearby.
SECTION 9-SPILL OR LEAK PROCEDURES
Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal
laws. Best method is to recycle or reuse for intended purpose. Consult local
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
river or to ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories:
Shipping Information:
HMIS Hazardous Materials
No - Fire Hazard
FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid
Identification System
No - Sudden Release of Pressure Hazard
(phosphoric acid), 8, NA-1760, PGIII
Health
No - Reactivity Hazard
FOR 1 GALLON CONTAINERS: Compounds, cleaning liquid
Flammability
Yes - Immediate (acute) Health Hazard
(phosphoric acid), 8, NA-1760, PGIII (Limited Quantity)
Reactivity
No - Delayed (chronic) Health Hazard
FOR CONTAINERS < 1 GALLON: ORM-D
Personal Protection
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924
(24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS#
Chemical Name
Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS#
Chemical Name
Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product
2
0
0
D
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement