Network Cordsets - PROFIBUS-DP

Network Cordsets - PROFIBUS-DP
Return to Main Selection Guide
DP Physical Media Connectivity
PROFIBUS-DP Cable
P3
Part Number Key
P5
Cordsets
P7
Receptacles
P15
Field Wireables
P19
DP Connectivity
Industrial
nPROFIBUS
PROFIBUS
Features
• Cables that meet the requirements of EN 50170 for communication
•
•
•
•
•
www.turck.us
•
1-800-544-7769 •
up to 12 MBAUD
PLTC rated cable (CSA FT4)
Oil RES II and sunlight resistant
M12 reverse keyed connectors
Up to 4A and 250V rated
IP67/IP69K rated
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - s[email protected] - www.stevenengineering.com
B2007
P1
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS ®-DP System Description
PROFIBUS-DP is an industrial network protocol that connects field I/O devices in order to eliminate hard wiring. The network
connection increases device-level diagnostic capabilities, while also providing high-speed communication between devices.
PROFIBUS-DP is based on the RS-485 serial data transfer standard. In most cases, the termination and physical media rules for
PROFIBUS-DP are the same as those required for RS-485 communication. A PROFIBUS-DP network supports up to 126 nodes
and virtually an unlimited amount of I/O. The bus uses a trunkline/dropline topology. Power and communication are
provided via separate cables, allowing easy segmentation of the power structure to avoid overloading.
PROFIBUS-DP is capable of running at data rates as high as 12 Mbaud. When used at high data rates, the cable drop length
from the trunk to a node is severely limited. For example, when used at 12 Mbaud, nodes must be directly connected to the
trunk, with no drop length allowed.
Typical System Configuration
BL20 I/O System
PROFIBUS Cable
FLDP-IOM-88-0002-ST
Power Supply
E
D
E
Valve
PLC & PB Master Controller
E
A
RSSW RKSW 455-1M
RSM RKM 50-1M
RSM 2RKM 50
E
Sensor
E
E
RSM RKM 50-1M
C
VB2
C
C
C
RSSW RKSW 455-1M
RKSW D9T 455-1M
FLDP IOM-32-0001
RKSW 45-TR
FLDP IOM-88-0001
BL67 I/O System
Basic Parts List
A typical PROFIBUS-DP system consists of the following parts:
• A - Master
• B - Slaves
• C - Communication cable
• D - Power supply
• E - Power cable
PROFIBUS-DP stations require a network master (also called a scanner) to interface the stations to the host controller. TURCK
PROFIBUS-DP stations are designed to be fully compatible with PROFIBUS-DP equipment from other manufacturers.
P2
B2007
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
Cordsets
TURCK offers a complete line of molded PROFIBUS-DP cordsets to facilitate network installation, resulting in a faster start-up
and fewer wiring errors. The bus and drop cables are specially designed foil-shielded, high-flex cables with very low
inductance and capacitance to minimize propagation delay time. PROFIBUS-DP cables consist of a shielded and twisted data
pair with a bare drain wire.
In most cases, connections of the bus cable to the stations are made using 5-pin reverse-key eurofast ® (M12) connectors. A
variety of stations are also available that support D9 type connections. Power for most stations is provided through one or
two 5-pin minifast ® (7/8-16UN) connectors.
TURCK cordsets for the PROFIBUS-DP system are available in standard lengths. Please contact your local sales representative
to order custom lengths.
Diagnostics
TURCK network stations provide increased diagnostics over using traditional hard-wired I/O systems. TURCK stations also
serve as a buffer between I/O devices and the PROFIBUS-DP network by detecting short circuits without disrupting
communication.
Addressing
The valid range of PROFIBUS-DP node addresses is 0 to 125. TURCK station's addresses are usually set via rotary dials or
switches on the node. Changes to the address settings take effect when the station power is cycled or when the station
receives a software reset. Care must be taken to prevent the same address from being assigned to more than one node in a
system. Bihl+Wiedemann PROFIBUS-DP to AS-I gateways addresses are set in software using the on-unit display.
Communication Rate/Cycle Time
PROFIBUS-DP specifications define multiple transmission speeds ranging from 9.6 kbaud to 12 Mbaud. All nodes on a network
must communicate at the same rate.
The complete cycle time of a PROFIBUS-DP system is affected by several factors:
• Number of nodes being scanned
• Amount of data produced and consumed by the nodes
• Network communication rate
• Cycle time of the control program
All of these factors must be considered when calculating the cycle time of a particular network.
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
B2007
P3
PROFIBUS
DP Connectivity
The PROFIBUS-DP system includes a provision for special diagnostic data messages. These messages are triggered when a
fault occurs at the station (for example a short circuit on a sensor). When the master asks the station for data, the station
responds and includes a flag to indicate that diagnostic data is present. The master then asks for the diagnostic data, which is
mapped to a special location in the controller's memory.
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
GSD Files
GSD files contain detailed information about a PROFIBUS-DP device, including I/O data size and the devices configurable
parameters. The information in an GSD file, when used with a PROFIBUS-DP configuration tool, guides a user through the
steps necessary to configure a device. GSD files are available on the TURCK website (www.turck.com).
Maximum Ratings
The PROFIBUS-DP bus uses a trunkline/dropline topology. The trunk is the main communication cable and requires the
appropriate RS-485 termination at both ends of the trunk. Terminating resistors are available as plug-in eurofast ® modules or
can be built into the D9 connectors. The length of the trunk depends on the communication rate. Drops or branches off the
trunk are allowed, but are greatly limited as the communication rate increases. The table shows the maximum ratings for a
trunk at different communication rates.
P4
B2007
Communication Rate
Max. Segment
Length
9.6 kbps
1200 m
19.2 kbps
1200 m
93.75 kbps
1200 m
187.5 kbps
1000 m
500 kbps
400 m
1.5 Mbps
200 m
12 Mbps
100 m
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
eurofast® Cordset Part Number Key
Part Number Keys are to assist in IDENTIFICATION ONLY. Consult factory for catalog items not identified.
R S C W V
45x -
*M
M12x1 (eurofast)
Length in Meters (*)
R = Straight
W = Right Angle
Consult factory for other lengths.
Gender
Cable Type (x)
K = Female Connector, Female Threads
S = Male Connector, Male Threads
45 = PROFIBUS®-DP
48 = PROFIBUS®-PA
Plug Body
Coupling Nut Material
C = Large Plug Body
G = Robust Large Plug Body
S = Shielded to Coupling Nut
T = Small Plug Body
(Blank) = Nickel Plated Brass
K = Nylon
U = PVDF
V = Stainless Steel
Keying Options
DP Connectivity
(Blank) = Standard Key
D = D-coding Key
W = Reverse Key
F S F V
45x -
PROFIBUS
eurofast Receptacle Part Number Key
*M
M12x1 (eurofast)
Length in Meters (*)
Consult factory for other lengths.
Gender
Cable Type (x)
K = Female Connector, Female Threads
S = Male Connector, Male Threads
45 = PROFIBUS®-DP
48 = PROFIBUS®-PA
Housing Style
(Blank) = Front Mount
F = Standard
FD = Standard Back Panel Mount
S = Shielded to Receptacle Housing
SDE = Shielded Back Panel Mount, Large Body
Keying Options
(Blank) = Standard Key
D = D-coding Key
W = Reverse Key
Coupling Nut Material
(Blank) = Nickel Plated Brass
V = Stainless Steel
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
B2007
P5
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, Cable Specifications
Braided Shield
• Cable that Meets the Requirements of
Jacket
EN50170-2-2:1996 for Communications Up to
12 Mbaud
Drain Wire
White
Blue
Green
Red
Figure B
Mylar Tape
Aluminum Mylar Foil Shielded
Jacket
Inner Jacket
Jacket
Drain Wire
Drain Wire
Red
Figure A
Figure C
Red
Green
Green
Foil Shield
Foil Shield
Aluminum Armor
Braided Shield
Baud Rate (k baud)
9.6
19.2
93.75
187.5
500
1500
1200
Maximum Trunk Length
1200 meters
1200 meters
1200 meters
1000 meters
400 meters
200 meters
100 meters
Data Pair
Type
455
AWM 2464
75°C 300 Volts
456
AWM 20233
80°C 300 Volts
457
75°C 300 Volts
458
AWM 20233
80°C 300 Volts
4511
AWM 2464
75°C 300 Volts
4510A
75°C 300 Volts
4515
80°C 300 Volts
4516
105° 300 Volt
590
AWM 2464
75°C 300 Volts
2nd Data Pair
Outer Jacket
Shields
Bulk Cable
Part Number / Figure
Weight/300 M
Approvals
AWG
Color Code
DCR (/1000
feet)
Insulation
AWG
Color
Code
DCR (/1000
feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
NEC PLTC
CEC AWM-I/II A/B FT4
2/22 AWG
RD/GN
16.5 Ohms
PE
None
N/A
PVC Purple
8.5 mm (.335 in)
Foil/Braid
22 AWG
RB50672-*M
62 lbs.
A
NEC AWM
CEC AWM-I/II A/B FT4
2/22 AWG
RD/GN
16.5 Ohms
PE
None
N/A
TPU Purple
7.9 mm (.310 in)
Foil/Braid
22 AWG
RB50683-*M
48 lbs.
A
NEC CMX
2/22 AWG
RD/GN
solid
16.5 Ohms
PE
None
N/A
TPU Purple
8.0 mm (0.315 in)
Foil/Braid
No Drain
RB50708-*M
51 lbs.
A
NEC AWM
CEC AWM-I/II A/B FT4
2/22 AWG
RD/GN
16.5 Ohms
PE
None
N/A
TPU Plum
8.5 mm (0.335 in)
Foil/Braid
22 AWG
RB50692-*M
58 lbs.
flexlife-10 ®
A
NEC PLTC
CEC AWM-I/II A/B FT4
2/22 AWG
RD/GN
16.5 Ohms
PE
None
N/A
PVC Purple
8.5 mm (.319 in)
Foil/Braid
22 AWG
RB50881-*M
64 lbs.
flexlife-10
A
NEC PLTC
CEC CM-CMG
HL ABCD
2/22 AWG
RD/GN
16.5 Ohms
PE
None
N/A
Aluminum
Armor/PVC
15.4 mm (.605 in)
Foil/Braid
22 AWG
RB50875-*M
112 lbs.
armorfast ®
C
IEC-60332-3
IEC-60754-1
EN 50267-2-2
2/22 AWG
RD/GN
16.5 Ohms
PE
N/A
TPU Purple
7.5 mm (0.295 in)
Foil/Braid
22 AWG
NEC PLTC/ISO
Open Wiring
CEC CMG
2/22 AWG
RD/GN
16.5 Ohms
PE
None
N/A
PVC Purple
11.1 mm (.435 in)
Foil/Braid
22 AWG
RB51259-*M
93 lbs.
A
NEC PLTC
CEC AWM-I/II A/B FT4
2/22 AWG
RD/GN
16.5 Ohms
PE
2/22 AWG
BU/WH
16.5 Ohms
PE
PVC Purple
9.6 mm (.380 in)
Foil/Braid
22 AWG
RB51057-*M
75 lbs.
B
None
RB51225-*M
42 lbs.
Halogen-Free
A
††
* Indicates length in meters.
Standard spool lengths are 30, 75, 100, 150, 200, 225, 300 meters. Consult factory for other lengths.
†† Zero Halogen: to DIN VDE 0472 part 815 + IEC 60754-1
P6
B2007
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, (M12x1) eurofast ®Cable and Cordset Selection Matrix
eurofast
Pin (Male)
5
Socket (Female)
1
6
2
4
3
RSAW
RSSW
WSSW
RKAW
RKSW
WKSW
RSAW 45x-*M
RSSW 45x-*M
WSSW 45x-*M
RKAW 45x-*M
RKSW 45x-*M
WKSW 45x-*M
RSSW WSSW 45x-*M
RSSW RKSW 45x-*M
RSSW WKSW 45x-*M
WSSW WSSW 45x-*M
WSSW RKSW 45x-*M
WSSW WKSW 45x-*M
RKSW RKSW 45x-*M
RKSW WKSW 45x-*M
Bare
RSAW RSAW 45x-*M
5
RSAW RKAW 45x-*M
RSSW RSSW 45x-*M
1
RSSW
2
WSSW
6
RKAW
3
RKSW
WKSW WKSW 45x-*M
4
WKSW
See page P8 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Standard cable lengths are 1, 2, 4, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSSW...RSSWV.
Pinouts
eurofast
Male
www.turck.us
•
1-800-544-7769 •
45 series pinout
59 series pinout
1. N/C
2. Green (TxD)
3. N/C
4. Red (RxD)
5. Bare (Shield Drain Wire)
1. Blue (TxD_1)
2. Green (TxD)
3. White (RxD_1)
4. Red (RxD)
5. Bare (Shield Drain Wire)
Fax: (763) 553-0708 •
eurofast
Female
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
B2007
P7
DP Connectivity
RKAW RKAW 45x-*M
PROFIBUS
Socket (Female)
eurofast
Pin (Male)
RSAW
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, (M12x1) eurofast ® Cable and Cordsets
Specifications
Overmold:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
TPU
Nickel Plated CuZn or Stainless Steel
TPU or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +75°C (-22° to +167°F)
1
RSSW ..
2
Page P7
WSSW ..
Page P7
3
RKSW ..
4
Page P7
WKSW ..
Page P7
5
RSAW ..
6
Page P7
RKAW ..
Page P7
7
FSSDWE ..
P8
B2007
8
FKSDWE ..
Page P9
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
Page P9
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, (M12x1) eurofast ® Cable and Cordset Selection Matrix
eurofast
Pin (Male)
Terminator
10
12
2
3
4
Pin (Male)
Socket (Female)
7
8
Bare
RSSW
WSSW
RKSW
WKSW
FSSDWE
FKSDWE
D9S/T 45x-*M
RSSW D9S/T
45x-*M
WSSW D9S/T
45x-*M
RKSW D9S/T
45x-*M
WKSW D9S/T
45x-*M
FSSDWE D9S/T
45x-*M
FKSDWE D9S/T
45x-*M
D9SM/T 45x-*M
RSSW D9SM/T
45x-*M
WSSW D9SM/T
45x-*M
RKSW D9SM/T
45x-*M
WKSW D9SM/T
45x-*M
FSSDWE D9SM/T
45x-*M
FKSDWE D9SM/T
45x-*M
SD9S/T 45x-*M
RSSW SD9S/T
45x-*M
WSSW SD9S/T
45x-*M
RKSW SD9S/T
45x-*M
WKSW SD9S/T
45x-*M
FSSDWE SD9S/T
45x-*M
FKSDWE SD9S/T
45x-*M
D9S/T
Master
9-Pin Sub D Connector
1
Socket (Female)
D9SM/T
11
SD9S/T
PROFIBUS
DP Connectivity
See page P8 and P11 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Standard cable lengths are 1, 2, 4, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSSW...RSSWV.
Extension Example:
RSSW D9S/T 455-0.3M
Pinouts
eurofast
Male
www.turck.us
•
1-800-544-7769 •
45 series pinout
1. N/C
2. Green (TxD)
3. N/C
4. Red (RxD)
5. Bare (Shield Drain Wire)
Fax: (763) 553-0708 •
eurofast
D9
Female
Male
D9 pinout
1 = N/C
2 = N/C
3 = RD (RXD)
4 = N/C
5 = N/C
6 = N/C
7 = N/C
8 = GN (TXD)
9 = N/C
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
B2007
P9
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, (M12x1) eurofast ® Cable and Cordset Selection Matrix
eurofast
Pin (Male)
1
Node
Bare
10
Socket (Female)
2
3
RSSW
WSSW
7
4
RKSW
Pin (Male)
WKSW
Socket (Female)
8
FSSDWE
FKSDWE
D9S 45x-*M
RSSW D9S RSSW WSSW D9S WSSW RKSW D9S RKSW WKSW D9S WKSW FSSDWE D9S FSSDWE FKSDWE D9S FKSDWE
45x-*M-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
SD9S 45x-*M
RSSW SD9S RSSW WSSW SD9S WSSW RKSW SD9S RKSW WKSW SD9S WKSW FSSDWE SD9S FSSDWE FKSDWE SD9S FKSDWE
45x-*M-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
D9SM 45x-*M
RSSW D9SM RSSW WSSW D9SM WSSW RKSW D9SM RKSW WKSW D9SM WKSW FSSDWE D9SM FSSDWE FKSDWE D9S FKSDWE
45x-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
45x-*M-*M
Straight
D9S
11
SD9S
12
D9SM
eurofast
Pin (Male)
1
2
3
Node
Socket (Female)
7
Bare
RSSW/RKSW
WSSW/WKSW
8
FSSDWE/FKSDWE
D9S 45x-*M
RSSW D9S RKSW
45x-*M-*M
WSSW D9S WKSW
45x-*M-*M
FSSDWE D9S FKSDWE
45x-*M-*M
SD9S 45x-*M
RSSW SD9S RKSW
45x-*M-*M
WSSW SD9S WKSW
45x-*M-*M
FSSDWE SD9S FKSDWE
45x-*M-*M
D9SM 45x-*M
RSSW D9SM RKSW
45x-*M-*M
WSSW D9SM WKSW
45x-*M-*M
FSSDWE D9SM FKSDWE
45x-*M-*M
10
4
Straight
D9S
11
SD9S
12
D9SM
See page P8 and P11-P12 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Standard cable lengths are 1, 2, 4, 6, 8, 10, 15, and in +5 meter increments from there. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSSW...RSSWV.
See previous page for pinouts.
P10
B2007
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, Field Wireable D9 Connectors
• Provides Connection to Master or Node in the
Housing Style
Part Number
Connector,PDP,D9S
Features
Pinouts
-25° to +80°C, right angle,
terminating switch
-25° to +80°C, straight,
terminating switch
Connector,PDP,D9SM
-25° to +80°C, right angle,
master, terminating switch
N/C
N/C
RED (Bus_B)
N/C
N/C
N/C
N/C
Green (Bus_A)
N/C
Male
PROFIBUS
Connector,PDP,SD9S
1.
2.
3.
4.
5.
6.
7.
8.
9.
DP Connectivity
•
field
Maximum Cable O.D. is 8.5 mm
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
B2007
P11
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, Field Wireable D9 Connectors
Specifications - (D9)
Terminating Switch:
Protection:
Rated Voltage:
Rated Current:
Temperature Rating:
Specifications (FKSDWE .. FSFDWE)
Overmold:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Temperature
Rating:
Yes
IEC IP 20
4.75-5.25 VDC
5 mA
-25° to +60°C
*Max. Cable diameter: 8.5 mm
TPU
Nickel Plated CuZn or Stainless Steel
TPU or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
250 V
4A
-40° to +75°C
10
11
Connector, PDP, SD9S
Connector, PDP, D9S
Page P10
Page P10
12
Note: Part numbers are for ordering connector only.
Cable must be ordered separately.
Connector, PDP, D9SM
P12
B2007
Page P10
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP (M12x1), eurofast ® Retractile Cordsets
• Single or Double Ended
• Available in 1, 2, 5 Meter Extended Lengths
Part Number
Features
TPU , 250 V, 4 A, -40° to +80°C, (M12x1) eurofast male connector, 1 M extended
length, .25 M retracted length
RSSW 456SP-1M
Pinouts
1.
2.
3.
4.
5.
NC
GN
NC
RD
Drain
PROFIBUS
DP Connectivity
Single ended cordset part numbers shown. Also available in double ended (M12x1) eurofast connectors.
Different lengths available upon request.
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
B2007
P13
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, Terminating Resistors
• Terminating Resistors Stabilize and Minimize
•
Reflections on the Bus Line
A Terminating Resistor is Required at the
Beginning and End of the Main Bus Line
Housing Style
Part Number
RSSW 45-TR
1.
2.
3.
4.
5.
N/C
GN
N/C
RD
BARE
See Below
RKSW 45-TR
Nickel plated brass, 250 V, 4 A, -40°
to +75°C, internal resistor, female
eurofast connector, reverse keyed
1.
2.
3.
4.
5.
N/C
GN
N/C
RD
BARE
See Below
1.
2.
3.
4.
5.
N/C
BUS_A
N/C
BUS_B
N/C
See Below
1.
2.
3.
4.
5.
N/C
GND
N/C
UI=24 VDC
N/C
Nickel plated brass, 250 V, 4 A, -40°
to +75°C, active terminating
resistor, external power supply
minifast ® and eurofast connector,
LED signal for power status
Pinout Diagram, RKSW 45-TR
Ω
Ω
eurofast Male Connector
B2007
Male
Pinout Diagram, PDP-TRA
Ω
Ω
P14
Pinouts
Nickel plated brass, 250 V, 4 A, -40°
to +75°C, internal resistor, male
eurofast connector, reverse keyed
PDP-TRA
Pinout Diagram, RSSW 45-TR
Features
Ω
Ω
eurofast Female Connector
www.turck.us
•
1-800-544-7769 •
eurofast Male Connector
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, Circuit Board Connectors and OEM Receptacles
• Provides (M12x1) eurofast ® Connection to
Field Devices
Housing
Female Part Number
Male Part Number
Application
Pinouts
FKFDW 45..
FKFDW 45-PCB
FSFDW 45-PCB
Nickel plated CuZn or
stainless Steel, 250 V,
4 A, -40° to +75°C,
male eurofast PCB
pins
FSFDLW 45
Nickel plated CuZn or
stainless Steel, 250 V,
4 A, -40° to +75°C,
male eurofast solder
cups
FSFDW 45..
Female
FKFDLW 45
1.
2.
3.
4.
5.
DP Connectivity
FKFDLW 45..
N/C
GN
N/C
RD
BARE
PROFIBUS
FSFDLW 45..
Male
Nickel plated CuZn or
stainless Steel, 250 V,
4 A, -40° to +75°C,
male eurofast right
angle PCB pins
WFSW 45..
WFSW 45-PCB
Standard housing material is nickel plated brass "FKFD .."; "FKFDV .." indicates 316 stainless steel.
Panel Cutout
FKFD … FSFD
www.turck.us
•
1-800-544-7769 •
Board Layout (reference only)
FKFD … FSFD
Fax: (763) 553-0708 •
Panel Cutout
WFS
Board Layout (reference only)
WFS
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
B2007
P15
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, Circuit Board Connectors and OEM Receptacles
• Provides (M12x1) eurofast ® Connection to
Field Devices
Housing
Female Part Number
Male Part Number
Application
Pinouts
FKW 45 PCB KIT
Female
FKW 45-PCB KIT
FSW 45-PCB KIT
FSW 45 PCB KIT
Nickel plated CuZn or
stainless steel, 250 V,
4 A, -30° to +75°C, male
eurofast with mounting
kit, Reverse key
1.
2.
3.
4.
5.
N/C
GN
N/C
RD
BARE
Male
FK 45 PCB
FK 45-PCB
FSW 45-PCB
Nickel plated CuZn or
stainless steel, 250 V,
4 A, -30° to +75°C, male
eurofast, reverse key
FSW 45 PCB
Standard housing material is nickel plated brass "FKFD .."; "FKFDV .." indicates 316 stainless steel.
Board Layout (reference only)
FK … FS
P16
B2007
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, eurofast ® Feed Through Receptacle
• Provides Bulkhead Panel Mount Connection
Housing Style
Part Number
FKW FSW 45/M12
Features
Pinouts
Nickel plated brass or stainless steel, 250 V, 4 A, -40° to
+75°C, straight male/female connector, for pre-molded
reverse keyed eurofast cables
PROFIBUS
DP Connectivity
For stainless steel change part number to FKWV FSWV 45/M12
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
B2007
P17
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, eurofast ® Bus Tees
• Creates a Branch from the Main Bus Line
Housing Style
Part Number
Features
Wiring Diagrams
TPU, Nickel plated brass, 250 V, 4 A, -40° to
+75°C, male eurofast drop connector, fully
shielded eurofast tee, passive termination
RKSW 2RSSW 45
* RKSW 2RSSW 45-0001
VB2/FSW/FKW/FSW 45
TPU, Nickel plated brass, 250 V, 4 A, -40° to
+75°C, Male eurofast connector, fully
shielded eurofast tee
TPU, Nickel plated brass, 250 V, 4 A, -40° to +75°C,
Y Junction, fully shielded eurofast connectors
YBZ2-FSW/FKW/FSW 45
TPU, Nickel plated brass, 250 V, 4 A, -40° to +75°C
YBZ2-FKM/FKW/FSW 45
TPU, Nickel plated brass, 250 V, 4 A, -40° to +75°C
Pinouts
eurofast
Male
P18
B2007
www.turck.us
Female
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
PROFIBUS®-DP, eurofast ® Field Wireable Connectors with Labels
• Allows for Quick Connection when
•
•
Pre-Molded Cables not Available
Available for Male and Female Connectors
Color Coded Wire Connection for
PROFIBUS-DP
Housing Style
Female Part Number
Male Part Number
Features
Pinouts
BMWS 81..
Female
BMSWS 8151-8.5/PDP
Nickel plated brass, PG 9 cable gland,
accepts 4-9 mm cable diameter, screw
terminals, accepts up to 18 AWG
conductors 85°C, 125 V, 4 A, mates with
reverse key, 5-pin cordsets and
receptacles, metal, fully shielded
BMSWS 8251-8.5/PDP
Nickel plated brass, PG 9 cable gland,
accepts 4-9 mm cable diameter, screw
terminals, accepts up to 18 AWG
conductors 85°C, 125 V, 4 A, mates with
reverse key, 5-pin cordsets and
receptacles, metal, fully shielded
BMSWS 81..
BMWS 8151-8.5/PDP
Male
BMWS 8251-8.5/PDP
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
PROFIBUS
BMSWS 82..
DP Connectivity
BMWS 82..
B2007
P19
Return to Main Selection Guide
PROFIBUS
DP Physical Media Connectivity
Notes:
P20
B2007
www.turck.us
•
1-800-544-7769 •
Fax: (763) 553-0708 •
TURCK Inc. Minneapolis, MN 55441
Courtesy of Steven Engineering, Inc. - (800) 258-9200 - [email protected] - www.stevenengineering.com
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement