- No category
advertisement
GARDENA
®
4800 S Art. 1776
DK
Brugsanvisning
Dykpumpe
GB
Operating Instructions
Submersible Pump www.devicemanuals.eu
8
GARDENA Submersible Pump 4800 S
2. For Your Safety
Welcome to the garden of GARDENA ...
Please read these operating instructions carefully and observe the notes given. Use the instructions to familiarise yourself with the submersible pump, its correct use, and the notes on safety.
For safety reasons, children under 16 as well as persons not familiar with these operating instructions should not use this submersible pump.
Residual-current device
According to DIN VDE (German Electrical
Engineers’ Associa-tion) 0100, submersible pumps may only be used in swimming pools, garden ponds, and fountains if the pump is operated via a residual-current device with a residual-current rating of
≤
30 mA. The pump must not be operated when there are persons in the swimming pool or garden pond.
Contents v
Keep these operating instructions in a safe place.
1. Applications Range of Your GARDENA Submersible Pump
. . . .
8
2. For Your Safety
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
9
3. Initial Operation
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
4. Operation
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11
5. Cleaning
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11
6. Trouble-Shooting
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
12
7. Storage
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
12
8. Technical Data
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
13
9. Service
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
14
For safety reasons we recommend that you always operate the submersible pump via a residual-current device (DIN VDE 0100-702 and 0100-738).
v
Please contact your electrician.
Mains power
According to DIN VDE (German Electrical
Engineers’ Associa-tion) 0620, mains power cables must not have a smaller cross-section than the rubber-sheathed cables of the designation H05 RNF. The cable length must be at least 10 m.
1. Applications Range of Your GARDENA Submersible Pump
Intended use
Liquids to be pumped
Please note
Data indicated on the type plate must match technical data of the mains supply.
v
Take care that the electrical connections
GARDENA Submersible Pumps have been designed for private are made within dry area, protected from use around your house and garden. They are predominantly destiflooding.
nated for drainage after flooding, transfer of liquids, draining con-
Protect plug and power cable from heat, oil tainers, taking water from wells and shafts, draining boats and and sharp edges.
yachts as well as for water aeration and circulation for a limited period of time.
v
Don’t use the power cable for plugging off.
The power cable or the float switch must not
Liquids which can be handled by the GARDENA Submersible be used for mounting or relocating the pump.
Pump are the following: clean and slightly contaminated water For submerging or lifting / securing the pump,
(max. particle size 5 mm), swimming pool water (prerequisite
Corrosive, easily combustible or explosive substances fix a rope to the pump’s carrying handle.
is the recommended dosage of additives) and soapy water.
spondingly by such operation.
v
Extension cables must meet the require-
The pump is fully submersible (waterproof sealed) and can be immersed in the liquid down to a depth of 9 m.
The GARDENA Submersible Pumps are not designed for continuous operation (e.g. continuous circulating operation) in a pond. Your pump’s life will be shortened correv ments of DIN VDE 0620.
a visual check, if there is any damage of the pump (esp. regarding power cable and plug).
v
Observe the minimum water level and
(e.g. gasoline, petroleum, nitro thinner), fats, oils, salt-water the max. delivery height (see 8. Technical and waste water of toilets and urinals must not be pumped.
Data).
The temperature of the liquid handled should not exceed
35 °C.
A damaged pump must not be used.
v
In case of damage, please have the pump checked by our GARDENA Service Centre.
Manual operation
During manual operation, the pump must be switched off as soon as all the liquid has been pumped away.
v
Observe the pump at all times during manual operation.
Notes on use v
Clear the outlet line before use.
Dry-running operation causes increased wear and is to be avoided. Therefore, in manual operation the pump must be immediately unplugged when water fails to flow.
Avoid running of the pump for more than
10 min. against closed delivery side of the pump.
Sand and other abrasive substances cause increased wear and reduce the pump’s output.
Take care that the pump is located where the inlet openings at the suction base are obstructed neither completely nor partly.
Stand the pump on a brick if using in a pond.
Thermal motor protector
The pump is automatically switched off on overheating by the built-in thermal motor protector. After having cooled down, the motor automatically switches on again (see
6. Trouble Shooting).
Automatic deaerating valve v
The automatic deaerating valve eliminates any air pockets in the pump. If the water level drops below the vent valve, some water flows penetrates outside through the vent valve 4 .
This is not a defect of your pump, but serves to deaerate the pump.
4
9
10
3. Initial Operation
Hose diameter a b
Hose connection of universal fitting 7
Hose connection
7
Connecting the hose :
7
4. Operation
13 mm (1/ 2 ” )
15 mm (5 / 8 ” )
19 mm (3 /4 ” )
25 mm (1 ” ) 38 mm (1 1/ 2 ” )
Automatic operation :
1
3
2
Cut off topmost nipple at a .
Do not cut off any nipples.
Cut off top two nipples at b .
The following connection kits are required for 13 mm to 19 mm connections:
13 mm (1/ 2 ” ): GARDENA Pump Connection Set, Art. No. 1750
15 mm (5/ 8 ” ): GARDENA Tap Connector, Art. No. 902, and
Standard Hose Connector, Art. No. 916
19 mm (3 /4 ” ): GARDENA Pump Connection Set, Art. No. 1752
Best results in delivery capacity are achieved when using 38 mm
(1 1/ 2 ” ) hoses.
4
5
5
6
Manual operation :
The universal fitting 7 allows you to connect all the hoses listed in the previous table.
1. Cut off nipples of the universal fitting 7 , which are not needed, to match the hose connection.
2. Screw the universal fitting 7 onto the pump.
3. Connect the hose to the universal fitting 7 .
We recommend that you secure 32 mm (5 /4 ” ) and 25 mm (1 ” ) hoses additionally with a GARDENA Hose Clip Art. No. 1591.
1
2
Only for 13 mm (1/ 2 ” ) hose :
The universal fitting 7 can also be equipped with a GARDENA
Regulator Valve Art. No. 977 so that the contents of the outlet line do not flow back through the pump after pumping.
www.devicemanuals.eu
7
To ensure that the pump draws the water out, the water to be drained must be at least 45 mm deep.
The float switch 5 turns the pump on automatically when the water level exceeds the cut-in height and the water is pumped out.
The float switch 5 turns the pump off again as soon as the water level falls below the cut-out height.
1. Stand the pump on a firm surface – or – use a rope attached to the carrying handle 2 to immerse the pump in a well or shaft.
During automatic operation, ensure that the float switch 5 can move freely.
2. Plug the power cable 1 into a mains socket.
Adjusting the Cut-in and Cut-out Height :
The maximum cut-in height and minimum cut-out height (see
8. Technical Data) can be adjusted.
v
Push the cable of the float switch 5 into the float switch lock 3 .
Do not select a cable length that is too long or short to ensure that the float switch can turn on and off properly.
•
The shorter the length of cable between the float switch 5 and the float switch lock 3 , the lower the cut-in height and the higher the cut-out height.
The pump remains in constant operation because the float switch is bypassed.
1. Stand the pump on a firm surface – or – use a rope attached to the carrying handle 2 to immerse the pump in a well or shaft.
2. Plug the power cable 1 into a mains socket.
3. Fix float switch 5 vertically above the pump (with the cable at the bottom).
As long as the float switch is positioned vertically above the pump, the pump will operate regardless of the water level.
The residual water height of approx. 5 mm is only reached during manual operation since the float switch turns off the pump during automatic operation before this water level is reached.
Flushing the Pump :
Cleaning the suction base and turbine :
The pumps are virtually maintenance-free.
After having pumped chlorinated swimming pool water or other liquids leaving residues, the pump should be rinsed with clear water.
Warning ! Electric shock !
A
Risk of injury due to electric shock.
V
Disconnect the pump from the mains before cleaning the suction base and turbine.
11
12
9 6 8
Air cannot escape, since pressure line is closed.
Air locks in the suction base.
v
Open pressure line
(e.g. kinked pressure pipe).
v
Wait for max. 60 seconds until the pump deaerates automatically over the vent valve. If necessary, switch off and start it again.
v
Disconnect plug and clean turbine (see 5. Cleaning).
v
Submerge pump deeper.
8. Technical Data
6. Trouble-Shooting
Problem
Pump is running, but doesn’t deliver.
Pump doesn’t start or suddenly stops during operation.
1. Unscrew the 3 Phillips screws 8 and pull the suction base 6 off the pump.
2. Clean the suction base 6 and the turbine 9 .
3. Reinstall the suction base 6 and screw in the Phillips screws 8 .
For safety reasons a damaged turbine 9 can only be exchanged by the GARDENA Service Centre.
Probable cause
Turbine clogged.
When starting the pump, water height falls below the min. water level.
Thermal overload switch has switched the pump off due to overheating.
No power.
Dirt particles are jammed in the suction base.
Remedy v
Disconnect plug and clean turbine (see 5. Cleaning).
Observe max. media temperature of 35 °C.
v
Check fuses and electric connections.
v
Disconnect plug and clean suction base (see 5. Cleaning).
Type
Rated power
Max. delivery capacity
Max. pressure
Max. delivery height
Max. submersion depth
Flat suction down to approx.
Contaminated water with particle size of max.
4800 S (Art. No. 1776-24)
190 W
4,800 l / h
0.5 bar
5 m
9 m
5 mm
5 mm
Power cable
Pump connection
10 m H05 RNF
38 mm (1 1/ 2 ” ) / 25 mm (1 ” ) graduated nipple, option GARDENA Water hose Plug-in-system
Min. water level for operation 45 mm
Weight approx.
4.0 kg
35 °C Max. media temperature
Mains voltage / mains frequency
Min.cut-in height
230 V / 50 Hz
380 mm
Min./ max. cut-out height
Noise level L
WA
1)
1) Measuring method according to EN 60335 -1
100 mm / 140 mm
46 dB (A)
Cut-in / Cut-out height
Suction base is clogged.
v
Disconnect plug and clean suction base (see 5. Clean-
Performance characteristics
Pump runs, but output suddenly decreases.
Attention !
GARDENA Service Centres.
ing).
www.devicemanuals.eu
If you have any problems with your Pump, please contact our Service.
The cut-in and cut-out height varies.
The residual water depth (draining in the flat position down to approx. 5 mm) is only reached during manual operation
(see 4. Operation).
m
5
4
3
4800 S
2
7. Storage
1 bar
0,5
0,4
0,3
0,2
0,1
Store the pump away from frost before the first frost sets in.
Frost-free storage 0
0 1000 2000 3000 4000 5000 l / t
13
14
9. Service
Warranty GARDENA guarantees this product for 2 years (from date of purchase). This guarantee covers all serious defects of the unit that can be proved to be material or manufacturing faults. Under warranty we will either replace the unit or repair it free of charge if the following conditions apply:
•
The unit must have been handled properly and in keeping with the requirements of the operating instructions.
•
Neither the purchaser or a non-authorised third party have attempted to repair the unit.
The turbine is a wearing part and is not covered by the guarantee.
This manufacturer’s guarantee does not affect the user’s existing warranty claims against the dealer / seller.
If you have any problems with your pump, please contact our
Customer Service or return the defective unit together with a short description of the problem directly to one of the
GARDENA Service Centres listed on the back of this leaflet.
K
G
Produktansvar
Product Liability
Vi gør udtrykkeligt opmærksom på, at i henhold til produktansvarslovgivningen er vi ikke ansvarlige for skader forårsaget af produktet, hvis skaden sker på grund af uautoriserede reparationer, eller hvis dele er skiftet ud og der ikke er anvendt originale GARDENA dele eller dele godkendt af os, eller hvis reparationerne ikke er udført af GARDENA service eller en autoriseret fagmand. Det samme gælder for ekstraudstyr og tilbehør.
We expressly point out that, in accordance with the product liability law, we are not liable for any damage caused by our units if it is due to improper repair or if parts exchanged are not original GARDENA parts or parts approved by us, and, if the repairs were not carried out by a
GARDENA Service Centre or an authorised specialist. The same applies to spare parts and accessories.
K EU Overensstemmelse certificat
Undertegnede GARDENA Kress + Kastner GmbH, Hans-Lorenser-Str. 40,
D-89079 Ulm bekræfter hermed, at enheder listet herunder, ved afsendelse fra fabrikken, er i overensstemmelse med harmoniserede EU retningslinier,
EU sikkerhedsstandarder og produktspecifikationsstandarder. Dette certifikat træder ud af kraft hvis enhederne er ændret uden vor godkendelse.
G
EU Certificate of Conformity
The undersigned GARDENA Kress + Kastner GmbH, Hans-Lorenser-Str. 40,
D-89079 Ulm, hereby certifies that, when leaving our factory, the unit indicated below is in accordance with the harmonised EU guidelines, EU standards of safety and product specific standards. This certificate becomes void if the unit is modified without our approval.
Beskrivelse af enhederne :
Description of the unit :
Type :
Type :
4800 S
EU direktiv :
EU directives :
CE-Mærkningsår :
Year of CE marking :
Dykpumpe
Submersible Pump
Varenr. :
Art. No.:
1776-24
98 / 37/ EC
89 / 336 / EC
73 / 23 / EC
93 / 68 / EC
2002
Ulm, 10.12.2002
Ulm, 10.12.2002
Thomas Heinl
Teknisk direktør
Technical Dept. Manager www.devicemanuals.eu
15
Deutschland
GARDENA Kress + Kastner GmbH
GARDENA Service
Hans-Lorenser-Straße 40
D-89079 Ulm
Produktfragen: (07 31) 490 - 123
Reparaturen: (07 31) 490 - 290
Finland
Habitec Oy
Martinkyläntie 52
01720 Vantaa
France
GARDENA France
Service Après-Vente
BP 50080
95948 ROISSY CDG Cedex
Norway
GARDENA Norge A / S
Postboks 214
2013 Skjetten
Poland
GARDENA Polska Sp. z o.o.
Szymanów 9 d
05 - 532 Baniocha Argentina
Argensem S.A.
Venezuela 1075
(1618) El Talar - Buenos Aires
Australia
NYLEX Consumer Division
76 - 88 Mills Road
P.O. Box 722
Braeside 3195
Melbourne, Victoria
Great Britain
GARDENA UK Ltd.
27- 28 Brenkley Way
Blezard Business Park
Seaton Burn
Newcastle upon Tyne NE13 6DS
Greece
Agrokip G. Psomadopoulos & Co.
33 a, Ifestou str.
Koropi 194 00
Athens
Portugal
GARDENA, Lda.
Recta da Granja do Marquês
Edif. GARDENA
Algueirão
2725-596 Mem Martins
Rus sia / Россия
АО АМИДА ТТЦ ул. Моcфилмовcкая 66
117330 Моcква Austria
GARDENA Österreich Ges. m.b.H.
Stettnerweg 11-15
2100 Korneuburg
Belgium
MARKT (Belgium) NV/ SA
Sterrebeekstraat 163
Hungary
GARDENA Magyarország Kft.
Késmárk utca 22
1158 Budapest
Singapore
Variware
Holland Road Shopping Centre
227-A 1st Fl., Unit 29
Holland Avenue
Singapore 1027
1930 Zaventem
Slowenia / Croatia
Brazil
M. Cassab
Iceland
Heimilistaeki hf
Saetun 8
Silk d.o.o. Trgovina
Brodišče 15
1236 Trzin Av. das Nações Unidas, 20.882
Santo Amaro, CEP 04795-000
São Paulo - S.P.
P.O. Box 5340
125 Reykjavik
Republic of Ireland
South Africa
GARDENA South Africa (Pty.) Ltd.
P.O. Box 11534 Bulgaria / България
ДЕНЕКС ООД
Бул. ”Г.М.Димитров” 16 ет.4
София 1797
Michael McLoughlin & Sons
Hardware Limited
Long Mile Road
Dublin 12
Vorna Valley 1686
Spain
Canada Italy
GARDENA Italia S.r.l.
ANMI Andreu y Miriam S.A.
Calle Pere IV, 111
08018 Barcelona GARDENA Canada Ltd.
100 Summerlea Road
Brampton, Ontario
Via Donizetti 22
20020 Lainate (Mi)
Canada L6T 4X3
Sweden
GARDENA Svenska AB
Box 9003 Japan
KAKUDAI Mfg. Co. Ltd.
Chile 20039 Malmö
Antonio Martinic Y CIA. LTDA.
1- 4 - 4, Itachibori Nishi-ku
Switzerland
Gilberto Fuenzalida 185 Loc.
Osaka 550
GARDENA Kress + Kastner AG
Las Condes - Santiago de Chile
Luxembourg Bitziberg 1
Costa Rica
Compania Exim www.devicemanuals.eu
San José
Magasins Jules Neuberg
Grand Rue 30
Case Postale No. 12
Luxembourg 2010
Netherlands
GARDENA Nederland B.V.
8184 Bachenbülach
Ukraine / Украина
АОЗТ АЛЬЦЕСТ ул. Гайдара 50 г. Киев 01033
Turkey
Cyprus Postbus 50176
Dost Diþ Ticaret Mümessillik A.Þ.
FARMOKIPIKI LTD 1305 AD ALMERE
Yeþilbaðlar Mah. Baþkent
P.O. Box 7098
Neth. Antilles Cad. No. 26
74, Digeni Akrita Ave.
Jonka Enterprises N.V.
Pendik - Ýstanbul
1641 Nicosia
Sta. Rosa Weg 196
USA
Czech Republic P.O. Box 8200
GARDENA
GARDENA spol. s.r.o.
Curaçao
3085 Shawnee Drive
Шнpskб 20 a, и .p. 1153
New Zealand Winchester, VA 22604
62700 Brno
NYLEX New Zealand Limited
Denmark
GARDENA Danmark A / S
Naverland 8
2600 Glostrup
Private Bag 94001
South Auckland Mail Centre
10 Offenhauser Drive
East Tamaki, Manukau
1776 -24.960.01/ 0021
© GARDENA Kress + Kastner GmbH
Postfach 27 47, D - 89070 Ulm http: //www.gardena.com
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project