HITACHI E57 generator Manuale supplementare

English
SUPPLEMENTARY INSTRUCTION MANUAL
MODEL: E57 (Cell starter Type)
Thank you for purchasing HITACHI Generator.
This supplementary Instruction manual has been prepared to introduce the operation for Cell starter type.
Please read and understand this supplementary together with the enclosed owner’s manual before operating
the machine.
HOW TO INSTALL THE BATTERY
CAUTION:
䢇 The battery shall be handled in the well ventilated
area avoiding fire or flammable material.
䢇 Special attention shall be paid to the battery fluid not
stuck to the eye or skin.
䢇 The temperature of the battery fluid shall be
maintained to 45˚C or less, because of prevention for
functional deterioration.
䢇 Be sure the battery is installed on the battery base
securely.
䢇 Clamp the wire of red sign to the positive (+) terminal
and the black wire to the negative (-) terminal on the
battery. Take care of the correct wiring.
Recommended
battery specification:
䡲12V, 12Ah
Battery Base
Frame
Wire Detail
NOTE: The battery base is assembled into the frame at
the factory.
Black sign (color)
Red Sign
Red sign (color)
The key for the engine switch is put
here at the factory.
Battery position
612
Code No.C99163691
Printed in Japan
Mfg.Code-KN55085AA
1
1
hitachi_E-KN55085AA
Page 1
07.3.16, 1:23 PM
Adobe PageMaker 6.5J/PPC
English
OPERATION
STARTING GENERATOR
WARNING: Before starting the generator, be sure that you read and understand all the safety and
operating instructions of the Generator Instruction manual.
1. Disconnect all electrical loads from the generator and
place the AC no fuse breaker in the OFF (“OPEN”)
position.
OPEN
2. Open the fuel cock.
3. Set the choke lever to “CLOSE” (arrow mark).
Not necessary if the engine is warm.
CLOSE
4. Turn the engine switch to “START” position, and hold it
there until the engine starts.
When the engine starts, release the key, allowing the
switch to return to the “RUN (I)” position.
If the engine fails to start within 5 seconds, release the
key, and wait at least 10 seconds before operating the
starter again.
OFF
RUN
START
NOTE: Use short starting cycles (15 seconds per
minute) to prolong starter motor life. Extended
cranking can damage starter motor.
5. After the engine started, return the choke lever gradually
to “OPEN” position.
6. Warm up the engine without a load for a few minutes..
OPEN
NOTE: If the oil level in the engine is low, the engine will not start. If the engine does not start, check the
oil level and add oil as needed.
NOTE: To ensure maximum oil lubrication, place the generator on a level surface.
2
hitachi_E-KN55085AA
2
Page 2
07.3.16, 1:23 PM
Adobe PageMaker 6.5J/PPC
English
STOPPING THE GENERATOR
1. Unplug the cord from receptacle of the generator and
turn off the AC no fuse breaker.
OFF
Unplug
2. Allow the engine about 3 minutes to cool down at noload before stopping.
3. Turn the engine switch to “OFF (0) ” position.
4. Close (stop) the fuel cock.
Close
3
3
hitachi_E-KN55085AA
Page 3
07.3.16, 1:23 PM
Adobe PageMaker 6.5J/PPC
English
WIRING DIAGRAM
C-BOX
E/G
to OSU
SM
BK
BK
2PCoupler
+M
BK
BL / W
GR
/Y
ST
GR / Y
-M
GR / Y
L
SW
B
R
SR
CB
GR
GR / W
CC
R
R
BK
GR / W
GR
REG
GR
BK
OR
BAT
GR / Y
ET
Symbol
Parts Name
Symbol
Parts Name
BAT
Battery
OSU
Oil sensor unit
CB
CB DC circuit protector
REG
Regulator
CC
Charging coil
SM
Starter motor
C-BOX
Control box
SR
Starter relay
ET
Ground terminal
SW
Engine switch
E/G
Engine
Wire Colors
BK : Black
R : Red
GR : Green
W : White
OR : Orange Y : Yellow
Diagram of ENGINE SWITCH
-M
+M
L
B
ST
OFF
RUN
START
4
hitachi_E-KN55085AA
Spring Return
4
Page 4
07.3.16, 1:23 PM
Adobe PageMaker 6.5J/PPC
PìCCKàâ
èêàãéÜÖçàÖ ä êìäéÇéÑëíÇì èé ùäëèãìÄíÄñàà
åéÑÖãú: Ö57 (ë ùãÖäíêàóÖëäàå ëíÄêíÖêéå)
ëÔ‡ÒË·Ó Á‡ ÚÓ, ˜ÚÓ Ç˚ ÔËÓ·ÂÎË „ÂÌÂ‡ÚÓ˚ HITACHI.
Ç ‰‡ÌÌÓÏ èËÎÓÊÂÌËË ÓÔËÒ˚‚‡ÂÚÒfl ÔË̈ËÔ ‡·ÓÚ˚ „ÂÌÂ‡ÚÓ‡ Ò ˝ÎÂÍÚ˘ÂÒÍËÏ ÒÚ‡ÚÂÓÏ.
èÂ‰ ̇˜‡ÎÓÏ ‡·ÓÚ˚ ‚ÌËχÚÂθÌÓ ÓÁ̇ÍÓϸÚÂÒ¸ Ò êÛÍÓ‚Ó‰ÒÚ‚ÓÏ ÔÓ ˝ÍÒÔÎÛ‡Ú‡ˆËË Ë Ò ‰‡ÌÌ˚Ï
ÔËÎÓÊÂÌËÂÏ.
ìëíÄçéÇäÄ ÄääìåìãüíéêÄ.
ÇçàåÄçàÖ:
䢇 Tã˛·˚ χÌËÔÛÎflˆËË Ò ‡ÍÍÛÏÛÎflÚÓÓÏ
ÒΉÛÂÚ ÔÓËÁ‚Ó‰ËÚ¸ ‚ ıÓÓ¯Ó
ÔÓ‚ÂÚË‚‡ÂÏÓÏ ÔÓÏ¢ÂÌËË, ̇ ‡ÒÒÚÓflÌËË ÓÚ
Ó„Ìfl ËÎË Î„ÍÓ‚ÓÒÔ·ÏÂÌfl˛˘ËıÒfl χÚÂˇÎÓ‚.
䢇 çÂÓ·ıÓ‰ËÏÓ ËÁ·Â„‡Ú¸ ÔÓÔ‡‰‡ÌËfl ÊˉÍÓÒÚË
‡ÍÍÛÏÛÎflÚÓ‡ ‚ „·Á‡ ËÎË Ì‡ ÍÓÊÛ.
䢇 ÑÎfl Ô‡‚ËθÌÓÈ ‡·ÓÚ˚ „ÂÌÂ‡ÚÓ‡
ÚÂÏÔÂ‡ÚÛ‡ ‡ÍÍÛÏÛÎflÚÓ‡ Ì ‰ÓÎÊ̇
Ô‚˚¯‡Ú¸ 45°ë.
䢇 ì·Â‰ËÚÂÒ¸, ˜ÚÓ ‡ÍÍÛÏÛÎflÚÓ ÔÎÓÚÌÓ ÛÒÚ‡ÌÓ‚ÎÂÌ
̇ ÔÓ‰ÒÚ‡‚ÍÛ.
èÓ‰Íβ˜ËÚ Í‡ÒÌ˚È ÔÓ‚Ó‰ Í Á̇ÍÛ (+),
˜ÂÌ˚È – Í (-) ·‡Ú‡ÂË. ÇÌËχÚÂθÌÓ
Òӷ≇ÈÚ ÔÓÎflÌÓÒÚ¸.
êÂÍÓÏẨÛÂχfl
ÒÔˆËÙË͇ˆËfl
‡ÍÍÛÏÛÎflÚÓ‡:
䡲12B 12A/˜
èÓ‰ÒÚ‡‚͇
‡ÍÍÛÏÛÎflÚÓ‡
ê‡Ï‡
èÓ‚Ó‰‡
óÂÌ˚È
èêàåÖóÄçàÖ: èÓ‰ÒÚ‡‚͇ ‡ÍÍÛÏÛÎflÚÓ‡
ÛÒڇ̇‚ÎË‚‡ÂÚÒfl ̇ ‡ÏÛ
„ÂÌÂ‡ÚÓ‡ ̇ Á‡‚Ó‰Â.
ä‡ÒÌ˚È
ä‡ÒÌ˚È
Ç˚Íβ˜‡ÚÂθ „ÂÌÂ‡ÚÓ‡
ÄÍÍÛÏÛÎflÚÓ
KN55085AA
2007/4
5
5
hitachi_R-KN55085AA
Page 5
07.3.15, 4:59 PM
Adobe PageMaker 6.5J/PPC
PìCCKàâ
èéêüÑéä êÄÅéíõ
áÄèìëä ÉÖçÖêÄíéêÄ
ÇçàåÄçàÖ: èÂ‰ Á‡ÔÛÒÍÓÏ „ÂÌÂ‡ÚÓ‡ ‚ÌËχÚÂθÌÓ ÓÁ̇ÍÓϸÚÂÒ¸ Ò ËÌÒÚÛ͈ËflÏË ÔÓ
·ÂÁÓÔ‡ÒÌÓÒÚË Ë ˝ÍÒÔÎÛÚ‡ˆËË.
1. ìÒÚ‡ÌÓ‚ËÚ ‚˚Íβ˜‡ÚÂθ ‰‚Ë„‡ÚÂÎfl ‚ ÔÓÎÓÊÂÌËÂ
ON (‚ÍÎ.). Ç˚Íβ˜ËÚ ÔÂÂÍβ˜‡ÚÂÎË NFB Ë IDLE
SW (ÂÒÎË ÓÌË ËϲÚÒfl).
éíäêõíé
2. éÚÍÓÈÚ Í‡Ì ÚÓÔÎË‚ÌÓ„Ó ·‡Í‡.
3. ìÒÚ‡ÌÓ‚ËÚ Á‡ÒÎÓÌÍÛ Í‡·˛‡ÚÓ‡ ‚ ÔÓÎÓÊÂÌËÂ
CLOSE (Á‡Í˚ÚÓ). ç Ú·ÛÂÚÒfl, ÂÒÎË ‰‚Ë„‡ÚÂθ
ÔÓ„ÂÚ.
á‡ÍÓÈÚÂ
4. ìÒÚ‡ÌÓ‚ËÚ ‚˚Íβ˜‡ÚÂθ ‚ ÔÓÎÓÊÂÌË START Ë
Û‰ÂÊË‚‡ÈÚ ‚ ˝ÚÓÏ ÔÓÎÓÊÂÌËË, ÔÓ͇ ‰‚Ë„‡ÚÂθ ÌÂ
·Û‰ÂÚ Á‡ÔÛ˘ÂÌ. èÓÒΠÁ‡ÔÛÒ͇ ‰‚Ë„‡ÚÂÎfl ‚ÂÌËÚÂ
‚˚Íβ˜‡ÚÂθ ‚ ÔÓÎÓÊÂÌË RUN. ÖÒÎË ‰‚Ë„‡ÚÂθ ÌÂ
Á‡ÔÛÒ͇ÂÚÒfl ‚ Ú˜ÂÌË 5 ÒÂÍÛ̉, ÓÚÔÛÒÚËÚÂ
‚˚Íβ˜‡ÚÂθ Ë ÔÓ‰ÓʉËÚ Ì ÏÂÌ 10 ÒÂÍÛ̉
ÔÂ‰ ÚÂÏ, Í‡Í ÒÌÓ‚‡ Á‡ÔÛÒÚËÚ¸ ‰‚Ë„‡ÚÂθ.
Çõäã
Çäã
çÄóÄãé
èêàåÖóÄçàÖ: èË Á‡ÔÛÒÍ ‰‚Ë„‡ÚÂÎfl Ò ÔÓÏÓ˘¸˛
˝ÎÂÍÚ˘ÂÒÍÓ„Ó ÒÚ‡ÚÂ‡,
ËÒÔÓθÁÛÈÚ Í‡ÚÍÓ‚ÂÏÂÌÌ˚È
ˆËÍÎ (Ì ·ÓΠ15 ÒÂÍ.). ùÚÓ
ÔÓÏÓÊÂÚ ÒÓı‡ÌËÚ¸ ÒÓÍ ÒÎÛÊ·˚
ÒÚ‡ÚÂ‡.
ÅÓΠ‰ÎËÌÌ˚ ˆËÍÎ˚ Á‡ÔÛÒ͇
ÏÓ„ÛÚ ÔÓ‚‰ËÚ¸ ÒÚ‡ÚÂ..
5. èÓÒÚÂÔÂÌÌÓ ‚ÂÌËÚ Á‡ÒÎÓÌÍÛ Í‡·˛‡ÚÓ‡ ‚
ÔÓÎÓÊÂÌË OPEN (ÓÚÍ˚ÚÓ) ÔÓÒΠÚÓ„Ó͇Í
‰‚Ë„‡ÚÂθ Á‡ÔÛ˘ÂÌ.
6. чÈÚ ‰‚Ë„‡ÚÂβ ‡ÁÓ„ÂÚ¸Òfl ‚ Ú˜ÂÌË ÌÂÒÍÓθÍËı
ÏËÌÛÚ ·ÂÁ ÔÓ‰Íβ˜ÂÌËfl Í ÌÂÏÛ ÔÓÚ·ËÚÂÎÂÈ.
éíäêõíé
èêàåÖóÄçàÖ: Ñ‚Ë„‡ÚÂθ Ì Á‡ÔÛÒÚËÚÒfl, ÂÒÎË ÛÓ‚Â̸ χÒ· ÌËÁÍËÈ. ÖÒÎË ‰‚Ë„‡ÚÂθ ÌÂ
Á‡ÔÛÒ͇ÂÚÒfl, ÔÓ‚Â¸Ú ÛÓ‚Â̸ χÒ· Ë ÔË ÌÂÓ·ıÓ‰ËÏÓÒÚË ‰ÓÎÂÈÚ ‰Ó
ÌÛÊÌÓ„Ó ÛÓ‚Ìfl.
èêàåÖóÄçàÖ: ÑÎfl Ó·ÂÒÔ˜ÂÌËfl ‰ÓÒÚ‡ÚÓ˜ÌÓ Û‚Î‡ÊÌÂÌËfl ‰‚Ë„‡ÚÂÎfl χÒÎÓÏ ÛÒÚ‡ÌÓ‚ËÚÂ
„ÂÌÂ‡ÚÓ ̇ Ó‚ÌÓÈ „ÓËÁÓÌڇθÌÓÈ ÔÓ‚ÂıÌÓÒÚË..
6
6
hitachi_R-KN55085AA
Page 6
07.3.15, 4:59 PM
Adobe PageMaker 6.5J/PPC
PìCCKàâ
ÇõäãûóÖçàÖ ÉÖçÖêÄíéêÄ
1. Ç˚Íβ˜ËÚ ÔÓÚ·ËÚÂÎË Ë ‚˚̸Ú ÔÓ‚Ó‰‡ ËÁ
ÓÁÂÚÓÍ „ÂÌÂ‡ÚÓ‡.
‚˚ÍÎ
Ç˚Íβ˜ËÚÂ
2. чÈÚ ‰‚Ë„‡ÚÂβ ÔÓ‡·ÓÚ‡Ú¸ ÓÍÓÎÓ 3 ÏËÌÛÚ ·ÂÁ
‰ÓÔÓÎÌËÚÂθÌÓÈ Ì‡„ÛÁÍË..
3. ìÒÚ‡ÌÓ‚ËÚ ‚˚Íβ˜‡ÚÂθ ‚ ÔÓÎÓÊÂÌË OFF (‚˚ÍÎ.).
4. á‡ÍÓÈÚ Í‡Ì ÚÓÔÎË‚ÌÓ„Ó ·‡Í‡.
á‡ÍÓÈÚÂ
7
7
hitachi_R-KN55085AA
Page 7
07.3.15, 4:59 PM
Adobe PageMaker 6.5J/PPC
PìCCKàâ
ëïÖåÄ ëéÖÑàçÖçàâ
C-BOX
E/G
Í OSU
SM
BK
BK
Ñ‚ÛıÔ‡Ì˚È
ÚÂÏË̇Î
+M
BK
BL /W
GR
/Y
ST
GR /Y
-M
GR /Y
L
SW
B
R
SR
CB
GR
GR /W
CC
R
R
BK
GR /W
GR
REG
GR
BK
OR
BAT
GR /Y
ET
ëËÏ‚ÓÎ
ÑÂڇθ
ëËÏ‚ÓÎ
ÑÂڇθ
BAT
ÄÍÍÛÏÛÎflÚÓ
OSU
чژËÍ Ï‡Ò·
CB
è‰Óı‡ÌËÚÂθ
REG
ê„ÛÎflÚÓ
CC
ä‡Úۯ͇
SM
ëÚ‡ÚÂ
C-BOX
è‡ÌÂθ ÛÔ‡‚ÎÂÌËfl
SR
êÂΠÒÚ‡ÚÂ‡
ET
íӘ͇ Á‡ÁÂÏÎÂÌËfl
SW
Ç˚Íβ˜‡ÚÂθ
E/G
Ñ‚Ë„‡ÚÂθ
èÓ‚Ó‰Ì˚ ñ‚ÂÚ‡
BK : óÂÌ˚È
R : ä‡ÒÌ˚È
GR : áÂÎÂÌ˚È W : ÅÂÎ˚È
OR : é‡ÌÊ‚˚È Y : ÜÂÎÚ˚È
Ñˇ„‡Ïχ ÇõäãûóÄíÖãü ÑÇàÉÄíÖãü
-M
+M
L
B
ST
Çõäã
Çäã
çÄóÄãé
8
8
hitachi_R-KN55085AA
‚ÓÁ‚‡Ú̇fl
ÔÛÊË̇
Page 8
07.3.15, 4:59 PM
Adobe PageMaker 6.5J/PPC