119msds 1

119msds 1
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: January 20, 2012
DATE OF ISSUE: January 20, 2012
I - Product Identification
RP-7
PRODUCT CODE: 0119
CHEMICAL FORMULATION: Water based cleaner/wax.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 1
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX
%
OSHA
PEL
ACGIH
TLV
EPA 40 CFR:
CAS #
302
355
372
Isoparaffinic Hydrocarbon
5.0-10.0
5 mg/m3
5 mg/m3
N
N
N
64742-47-8
1.0-3.0
N/E
N/E
N
N
N
d-Limonene
5989-27-5
Morpholine
1.0-3.0
20 ppm (skin)
20 ppm (skin)
N
N
N
5989-27-5
Oleic Acid
1.0-3.0
N/E
N/E
N
N
N
112-80-1
Key:
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
SUBSTANCE
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): 1.02
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): <5.0
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Miscible
pH: 8.5-9.0
APPEARANCE AND ODOR: White, opaque liquid, slight orange odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): >200
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/D
LOWER: N/D
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Firefighters must use full protective gear and self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Use water spray to cool fire-exposed containers. Protect from sources of ignition.
PRODUCT NAME: RP-7
PRODUCT CODE: 0119
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizing agents.
CONDITIONS TO AVOID: Excess heat and open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: May cause irritation
IF ON SKIN: May cause irritation, drying with prolonged or repeated exposure.
IF SWALLOWED: Gastrointestinal irritation, nausea, vomiting. Aspiration may be a hazard.
IF INHALED: Respiratory tract irritation, dizziness, headache.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical
attention.
IF ON SKIN: Remove contaminated clothing and launder separately before re-use. Wash with soap and water. If irritation persists,
obtain medical attention.
IF SWALLOWED: Contact physician or poison control center immediately. Give affected person 1 to 2 glasses of water. Do not
induce vomiting unless told to do so by a physician or poison control center. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air. Obtain medical assistance, if irritation persists.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and extinguish all sources of ignition. Soak
up spilled material with inert absorbent material and place in closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH
approved respirator, following manufacturer’s recommendations.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: None required with short usage, otherwise chemical resistant.
EYE PROTECTION: None required with short usage, otherwise safety glasses or goggles.
OTHER PROTECTIVE EQUIPMENT: Eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat of open flame.
Keep container tightly closed when not in use.
OTHER PRECAUTIONS: Wash hands and skin thoroughly after use. Keep out of reach of children. Do not cut or weld on empty
container as they may contain combustible residues.
IX - Transportation Information (ground transportation only)
DOT ID NUMBER: None
DOT CLASS: None
DOT PROPER SHIPPING NAME: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, and mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: January 20, 2012
Prepared by: Technical Dept.
DATE OF ISSUE: January 20, 2012
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this
data or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee,
users or third parties caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement