MSDS TEMP-COAT 101

MSDS TEMP-COAT 101
General Information: Containers can build up pressure if exposed to heat
MATERIAL SAFETY DATA SHEET
Section 1 - Chemical Product and Company Identification
MSDS Name: TEMP-COAT®
101
Synonyms: None
TEMP-COAT® Brand Products, LLC
301 W. Airline Hwy., Ste 100
LaPlace, LA 70068
Emergency Phone #: 985-651-2911
Information Phone #: 985-651-2911
Date Prepared: August 2001
Date Revised: March 2009 (updated)
Section 2 - Composition, Information on Ingredients
The following ingredients are subject to the reporting requirements of section 313 of Title
III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR part 372.
CAS
Hazardous Ingredients
(%)
OSHA PEL
and/or fire. As in any fire, wear a self-contained breathing apparatus and full
protective gear. During a fire, irritating and highly toxic gases may be
generated by thermal decomposition or combustion. Use water spray to keep
fire exposed containers cool.
Extinguishing Media: For small fires, use dry chemical, carbon dioxide or
alcohol foam. For large fires, use water spray, fog or alcohol foam. Use water
spray to coo! fire exposed containers. DO NOT use straight streams of water.
Flash Point:
None
Autoignition: None
Temperature:
Explosion limits:
None
NFPA Rating: (estimated) Health: 1; Flammability: 0; Reactivity: 0
Unusual Fire and
Product will not bum but may spatter if temperature
Explosion Hazards: exceeds boiling point. Extreme heat may cause
closed containers to burst. Dried films of product are capable of burning, giving
off oxides of carbon/nitrogen.
ACGIH TLV
Section 6 - Accidental Release Measures
None
General Information: Use proper personal protective equipment as indicated
Section 3 - Hazards Identification EMERGENCY OVERVIEW
Appearance: Viscous.
Flash Point: None
Nuisance dust.
Target Organs: None
Potential Health Effects
Skin: None known
Eye: Produces irritation.
Ingestion: May cause irritation of the digestive tract.
Inhalation: May cause irritation.
Chronic: No long term effects from repeated exposure have been observed.
in section 8.
Spills/leaks:
Section 7 - Handling and Storage
Handling:
Section 4 - First Aid Measures
Eye: Flush eyes with plenty of water for at least 15 minutes, occasionally lifting
the upper and lower eyelids. Get medical aid if irritation persists.
Skin: Flush skin with plenty of soap and water for at least 15 minutes, while
removing contaminated clothing and shoes. Get medical aid if irritation develops
or persists. Wash clothing before reuse.
Ingestion: Induce vomiting by giving syrup of ipecac. Get medical attention
immediately.
Inhalation: Remove from exposure to fresh air immediately. If not breathing,
give artificial respiration.
Absorb spill with inert material (e.g. vermiculite, sand or earth),
then place it in suitable container. Avoid runoff into storm
sewers and ditches which lead to waterways. Wear appropriate
protective clothing to minimize contact with skin.
Storage:
Wash thoroughly after handling. Remove contaminated clothing
and wash before reuse. Avoid contact with eyes, skin and
clothing. Empty containers contain product residue and can be
dangerous. Avoid ingestion and inhalation. Use only with
adequate ventilation
Store in a tightly closed container. Store in a cool, dry, wellventilated area away from incompatible substances.
Section 8 - Exposure Controls, Personal Protection
Engineering Controls: Facilities storing or utilizing this material should be
equipped with an eyewash facility and a safety shower. Use adequate or
general local exhaust ventilation if airborne dust concentrations exceed 15
3
mg/M .
Section 5 - Fire Fighting Measures
Exposure Limits:
TEMP-COAT® “101” MSDS Page 2
Chemical Name
ACGIH
None
TEMP-COAT®
OSHA - Final PELs
None
NIOSH
None
Personal Protective Equipment
Eyes: Wear chemical goggles.
Skin: Wear appropriate protective gloves to prevent skin exposure.
Clothing: Wear appropriate protective clothing to prevent skin exposure.
Respirators: Follow the OSHA respirator regulations found in 29CFR
1910.134. Always use a NIOSH approved respirator when necessary.
Section 12 - Ecological Information
Ecotoxicity: N/A
Environmental: N/A
Section 9 - Physical and Chemical Properties
Physical State:
Appearance:
Odor:
Vapor Pressure (mm Hg):
Vapor Density (Air = 1):
Evaporation Rate: (Butyl Acetate = 1):
Viscosity:
Boiling Point:
Melting Point:
Total Volatile Matter (weight Percent)
VOC, Expressed per EPA Method 24
Solubility in water:
Specific Gravity (H2O = 1):
Liquid
This material is viscous
solution of ceramic and acrylic
latex.
Slight ammonia odor.
o
20 @ 25 C
<1
<1
N/A
o
212 F
N/A
45.26
0.0099
Chemical Stability: Stable at room temperature in closed containers
under normal storage and handling conditions.
Conditions to Avoid: High temperatures.
Incompatibilities with Other Materials: Strong oxidants, strong acids
Hazardous Decomposition Products: Carbon monoxide, carbon dioxide,
irritating and toxic fumes and
gases.
Hazardous Polymerization: Has not been reported.
Section 11 – Toxicological Information
RTECS#: None
Carcinogenicity:
CAS#: None
LD50/LC50: N/A
The constituents within this product are not known to
separate from the product, it is a part of a specific
polymer.
Physical: N/A
Section 13 - Disposal Considerations
Waste Disposal Methods: Waste from this material is not hazardous as
defined under the Resource Conversation & Recovery
Act (RCRA) 40 CFR 261. Dispose of in accordance with
Federal, State, and Local regulations.
Section 14 - Transport Information
Shipping Name:
Hazard Class:
UN Number:
Packing Group:
Soluble
0.622
Section 10 - Stability and Reactivity
Teratogenicity: N/A
Neurotoxicity: NfA
Epidemiology: N/A
Reproductive Effects: N/A
Mutagenicity: N/A
Non-regulated Material
None
None
None
Section 15 - Regulatory Information
SARA Section 302 Extremely Hazardous Substances
None of the chemicals in this product have a TPQ
Section 313
No chemicals are reportable under Section 313
Clean Air Act:
This material does not contain any hazardous air pollutants.
Clean Water Act:
None of the chemicals in this product are listed as Hazardous Substances under
the CWA.
OSHA:
None of the chemicals in this product are considered highly hazardous by OSHA.
Section 16 - Additional Information
No additional information available
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement