418msds

418msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: July 8, 2009
DATE OF ISSUE: July 8, 2009
I - Product Identification
Super Solv #2
PRODUCT CODE: 0418
CHEMICAL FORMULATION: Water based alkaline cleaner.
NFPA HAZARD IDENTIFICATION SYSTEM:
HEALTH: 2
FLAMMABILITY: 0
HAZARD RATING:
4 - Extreme;
3 - High;
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
2-Butoxyethanol
Modified Coco Diethanolamide
Sodium Xylene Sulfonate
Key:
Values reported as TWA unless noted.
APPROX
EPA 40 CFR:
OSHA
ACGIH
%
PEL
TLV
302
355
372
10.0-20.0
50 ppm (skin)
20 ppm (skin)
N
N
Y
5.0-10.0
N/E
N/E
N
N
N
1.00-3.00
N/E
N/E
N
N
N
CAS #
111-76-2
67785-13-1
1300-72-7
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value
C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY: 1.02
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): 10.0-20.0
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): ~1.00
SOLUBILITY IN WATER: Soluble
pH: 12.75-13.75
APPEARANCE AND ODOR: Clear, purple liquid; detergent odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): N/A
(TEST METHOD): N/A
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/A
LOWER: N/A
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool drums in vicinity of fire with water fog. Fire fighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None.
PRODUCT NAME: Super Solv #2
PRODUCT CODE: 0418
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong acids.
CONDITIONS TO AVOID: None
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION: X
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Severe irritation, redness, tearing. Possible corneal injury.
IF ON SKIN: Moderate to severe irritation, chapping and dermatitis.
IF SWALLOWED: Irritation to mucous membranes, nausea, cramps, diarrhea.
IF INHALED: Irritation to respiratory tract, dizziness, headache.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Call a physician immediately and continue
flushing until medical attention is obtained.
IF ON SKIN: Remove contaminated clothing and launder before reuse. Flush with plenty of cool water for at least 15 minutes. Obtain
medical attention, if irritation persists.
IF SWALLOWED: Contact physician or poison center immediately. Rinse mouth with water. Give person one to two glasses of water. Do
not induce vomiting unless told to do so by a physician or poison control center. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air. Call a physician if irritation persists.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Contain spill. Soak up spilled material with
inert absorbent material and place in a properly labeled closed container for proper disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH
approved respirator, following manufacturer's recommendations.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or chemical goggles.
OTHER PROTECTIVE EQUIPMENT: Protective clothing, eyewash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool dry area, away from acids. Do not mix with any
other cleaning chemical. Rinse container before discarding. Keep container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT ID NUMBER: NA1760
DOT CLASS: 8
DOT PROPER SHIPPING NAME: Compounds, cleaning liquid (sodium hydroxide)
DOT PACKING GROUP: III
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping
name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further intended,
different shipping names and labeling may apply.
REVISION DATE: July 8, 2009
Prepared by: Technical Dept.
DATE OF ISSUE: July 8, 2009
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the
results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties
caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement