664macmsds

664macmsds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: April 15, 2009
DATE OF ISSUE: April 21, 2009
I - Product Identification
Machine Dish Detergent
PRODUCT CODE: 0664
CHEMICAL FORMULATION: Powder detergent.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 2
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 0
2 - Moderate;
1 - Slight;
REACTIVITY: 1
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
Sodium carbonate
Sodium metasilicate
Sodium dichloroisocyanurate
APPROX
%
40.0-50.0
10.0-20.0
1.0-2.0
Values reported as TWA unless noted.
EPA 40 CFR:
OSHA
ACGIH
PEL
TLV
302
355
372
5 mg/m3 *
3 mg/ m3 *
N
N
N
3
3
5 mg/m *
3 mg/ m *
N
N
N
5 mg/m3 *
3 mg/ m3 *
N
N
N
CAS #
497-19-8
6834-92-0
51580-86-0
* respirable dust - 8-hr TWA
Key:
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): N/A
BOILING POINT (°F): N/A
VAPOR PRESSURE (mm Hg): N/A
VOC CONTENT (% by weight): <2.0
VAPOR DENSITY (AIR = 1): N/A
EVAPORATION RATE (WATER = 1): N/A
SOLUBILITY IN WATER: Soluble
pH: N/A
APPEARANCE AND ODOR: Fine, white powder; slight chlorine odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): N/A
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/A
LOWER: N/A
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus. Fire may produce hazardous fumes.
UNUSUAL FIRE AND EXPLOSION HAZARD: Powder may produce chlorine gas when wet.
PRODUCT NAME: Machine Dish Detergent
PRODUCT CODE: 0664
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Acidic and reducing material.
CONDITIONS TO AVOID: None
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon and chlorine gas.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: Mild to moderate irritation, redness tearing.
IF ON SKIN: Irritation, with prolonged or repeated exposure. May aggravate existing skin conditions.
IF SWALLOWED: Nausea, cramps, and diarrhea.
IF INHALED: Irritation to upper respiratory tract.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water, for at least 15 minutes and obtain medical attention.
IF ON SKIN: Flush with water for at least 15 minutes. Remove contaminated clothing and launder before re-use. If irritation persists,
obtain medical attention.
IF SWALLOWED: Contact physician or poison control center immediately. Rinse mouth with water. Give affected person 1 to 2
glasses of water. Do not induce vomiting unless instructed by a physician or poison control center. Never give anything to an
unconscious person.
IF INHALED: Remove person to fresh air. Call physician immediately.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Contain spill. Scoop up material for reuse or
place in a labeled vented container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. Do not breathe dusts.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Chemical goggles or safety glasses.
OTHER PROTECTIVE EQUIPMENT: Emergency eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place, away from acids. Keep container
tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT ID NUMBER: UN 3262
DOT CLASS: 8
DOT PROPER SHIPPING NAME: Corrosive solid, basic, inorganic, n.o.s. (sodium
metasilicate, anhydrous)
DOT PACKING GROUP: III
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: April 15, 2009
Prepared by: Technical Dept.
DATE OF ISSUE: April 21, 2009
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the
results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties
caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement