Aiwa | TN-F205 | . xiaoyu163. com QQ376315150 99 28 94 29 8

http://www.xiaoyu163.com
TN-F205
QQ 376315150 892498299
AEZ
TEL
TEL
MODEL CODE : 86HR8-0117(B)
86HR8-1111(W)
86HR8-4444(L)
86HR8-8888(ST)
S/M Code No. 09-99A-335-8R1
http://www.xiaoyu163.com
SIO
DA
TA
xiaoy u163. com
VI
.
RE
www
N
This Service Manual is the "Revision Publishing" and replaces "Simple Manual"
(S/M Code No. 09-99A-335-8T1).
376315150 892498299
376315150 892498299
CORDLESS TELEPHONE
QQ
QQ
376315150 892498299
13942296513
13942296513
SERVICEQQMANUAL
TEL 13942296513
http://www.xiaoyu163.com
SPECIFICATIONS
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
ACCESSORIES/PACKAGE LIST
REF. NO
!
!
1
2
3
3
4
PART NO.
KANRI
DESCRIPTION
NO.
S0-112-290-000
APA-EI35EN 230V 12VDC
S0-109-090-000
APA-EI35EN 230V 9VDC
S8-PCD-910-820
INSTRUCTION BOOK(TN-F205AEZ1-E
S8-PCD-910-920
INSTRUCTION BOOK(TN-F205AEZ1-S
S4-360-070-000
BATT IN-CD 3.6V
www
.
xiaoy u163. com
2
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
Design and specifications are subject to change without
notice
QQ
QQ
QQ 376315150 892498299
•
TEL 13942296513
.
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0
ELECTRICAL MAIN PARTS LIST
REF. NO
PART NO.
KANRI
NO.
DESCRIPTION
REF. NO
IC
88-PCD-605-010
S8-331-000-000
S0-106-201-034
S2-309-024-040
S0-391-340-010
IC,TB31224F
IC,TA31002P/H31002P/HA31002P
IC,TEA1062
IC,LTV817
IC,W91340N
87-A21-136-040
87-A20-751-010
S9-570-290-000
IC,AT24C01A-10SC 8P
IC,L7805CV
IC,KIA7029F
PART NO.
KANRI
NO.
DESCRIPTION
SW3
T1
VAR1
VR1
VR3
S1-300-001-000
S0-004-500-180
S3-300-700-000
S1-030-850-000
S1-030-850-000
SW,SLIDE 1P3T
CER,FILTER LTW33-450E
VARISTOR SAS-331KD07 330V
SFR,10K
SFR,10K
X1
X2
X3
S6-111-504-000
S0-001-070-010
S6-003-580-010
X’TAL,11.15MHz HC49/U
CER,FILTER
CER,RESO CSA3.58MG
8 9 2 4 9 8 2 9 9
• Regarding connectors, they are not stocked as they are not the initial order items.
The connectors are available after they are supplied from connector manufacturers upon the order is received.
CHIP RESISTOR PART CODE
Chip Resistor Part Coding
8 8
A
KEY C.B
TRANSISTOR
TR,KSP43
TR,SST3906
TR,2SA1037AKQ
TR,KTC3880Y
DIODE
82-135-799-010
S0-100-331-220
S0-100-561-230
S0-100-621-210
DIODE,IN4148
ZENER,3.3V 1/2W BZX55-C3V3 SEM
ZENER,BZX55-C5V6 5.6V
ZENER,BZX55-C6V2 6.2V
S0-471-100-3K0
87-010-545-010
87-010-546-080
87-010-546-080
S1-474-112-500
CAP,CER 470PF-3000V
CAP,E 0.22-50V
CAP,E 0.33-50V
CAP,E 0.33-50V
CAP,M 0.47-250V
C132
C142
C143
CON2
DX1
87-010-053-810
S0-471-115-000
S0-471-115-000
S2-101-302-000
S3-001-640-000
CAP,E 1-50V
CAP,CER 470PF-/500
CAP,CER 470PF-/500
CONN,21P 2.0MM
DUPLEXER 31/40MHZ
IFT1
IFT2
IFT3
IFT4
IFT5
S0-039-300-070
S0-075-600-070
S0-008-450-070
S0-039-200-070
S0-039-400-070
IFT KY393N
IFT,7MM 455KHZ
IFT,KY845R
IFT KY392N
IFT KY394N
J2
J3
L1
L2
L3
S0-022-020-000
S1-004-700-040
87-003-133-010
87-005-166-010
87-005-189-080
JACK,TEL MINI L/P 6P2C
POWER JACK DC HEC0470-01-250
INDUCTOR,0.22UH
INDUCTOR,1.2UH
INDUCTOR,2.7UH
L4
L6
L7
L9
L10
8Z-PC6-636-080
87-003-139-080
87-005-696-080
87-005-696-080
87-003-097-010
INDUCTOR,2.2UH
INDUCTOR,0.56UH
COIL,100UH
COIL,100UH
COIL,1UH
L11
L12
L13
L14
L15
87-003-097-010
87-003-097-010
87-003-097-010
87-005-696-080
87-005-696-080
COIL,1UH
COIL,1UH
COIL,1UH
COIL,100UH
COIL,100UH
87-005-696-080
S0-222-500-120
S2-201-220-000
S2-200-000-040
COIL,100UH
RES,2.2K-1/2W
SW,HOOK 2P2T
SW,SLIDE 2P2T
www
CAP,E
CAP,E
CAP,E
CAP,E
CAP,E
Wattage
1/16W
10-16V
47-16V
2.2-50V
0.22-50V
10-16V
C30
C33
C65
C85
C87
87-015-696-080
87-010-380-010
87-010-400-010
87-010-380-010
87-010-264-040
CAP,E
CAP,E
CAP,E
CAP,E
CAP,E
DX1
IFT1
IFT2
IFT3
IFT4
S3-001-650-000
S0-002-860-070
S0-075-600-070
S0-002-760-070
S0-002-741-070
DUPLEXER 31/40MHZ
IFT,KL286N
IFT,7MM 455KHZ
IFT,KL276N
IFT,KL274N
IFT5
J1
L1
L2
L3
S0-002-770-070
S0-200-2P1-500
87-003-106-010
87-005-166-010
87-005-674-080
IFT,KL277N
HEADER KINDTECH 15P
INDUCTOR,0.33UH
INDUCTOR,1.2UH
INDUCTOR,1.5UH
L4
L5
T1
VR1
VR3
S0-100-152-010
87-003-133-010
S0-004-500-180
S1-030-850-000
S1-030-850-000
INDUCTOR,10UH
INDUCTOR,0.22UH
CER,FILTER LTW33-450E
SFR,10K
SFR,10K
X1
X2
X3
S6-111-501-000
S0-001-070-010
S3-327-681-000
X’TAL,11.15MHZ
CER,FILTER
X’TAL,32.768KHZ
1 3 9 4 2 2 9 6 5 1 3
C47
C65
C76
C106
C118
2.2-50V
47-16V
0.47-50V
47-16V
100-10V
QQ
Type
1005
Symbol
CJ
Tolerance
5%
1/16W
1/10W
1608
2125
5%
5%
CJ
CJ
1/8W
3216
5%
CJ
3 7 6 3 1 5 1 5 0
Form
L
C
SB-2BE-HA0-200
87-003-150-080
87-003-150-080
S0-321-610-010
S0-321-610-010
HEADER JST 2PIN
INDUCTOR 68UH
INDUCTOR 68UH
C-LED,3.2-1.6(RED)
C-LED,3.2-1.6(RED)
LED3
LED4
LED5
LED6
S0-049-410-030
S0-049-410-030
S0-049-410-030
S0-049-410-030
LED,3MM(GRN)
LED,3MM(GRN)
LED,3MM(GRN)
LED,3MM(GRN)
87-070-106-010
LED,SE3001 RED
S1-004-700-020
S0-271-500-010
JACK,POWER DC470/MSC
RES,270-1W
ECB
EBC
2SC2714
KTC3195
KSP42
KSP43
KSP92
E
2SA1037
KTC3880
MMBT3904
SST3906
LED C.B
CHG C.B
.
x ia o y u 1 6 3
BU-SP C.B
3
.
c o
m
4
http://www.xiaoyu163.com
t
W
B
B1
L1
L2
LED1
LED2
J901
R902
W
t
:A
Resistor Code : A
1.0
0.5
0.35
104
1.6
0.8
0.45
108
2
1.25
0.45
118
3.2
1.6
0.55
128
8 9 2 4 9 8 2 9 9
TRANSISTOR ILLUSTRATION
HAND KEY C.B
LED901
L
Dimensions (mm)
87-010-075-040
87-010-380-010
87-015-696-080
87-010-545-010
87-010-075-040
376315150 892498299
376315150 892498299
DIODE,SVC251SPA
RECTIFIER IN-4004
ZENER,27V 1/2W BZX55-C27 SEMTE
ZENER,8.2V 1/2W BZX55-C8V2 SEM
ZENER,BZX55-C5V1 5.1V
MAIN C.B
L16
R40
SW1
SW2
Chip resistor
QQ
QQ
87-A40-226-080
87-017-781-080
S0-102-701-220
S0-100-821-240
87-A40-587-080
TEL
Value of resistor
HS-RF C.B
C12
C15
C16
C19
C24
Figure
Resistor Code
LED,SE3001 RED
LED,SE3001 RED
LED,SE3001 RED
13942296513
13942296513
S8-004-300-000
SA-039-060-010
SA-010-372-000
SA-038-800-250
C-TR,MMBT3904
TR,KTC3195Y
TR,KSP92
TR,KSP42
C-TR,2SC2714Y
87-070-106-010
87-070-106-010
87-070-106-010
TEL
TEL
SA-039-040-000
S3-146-319-525
S8-009-200-010
S8-004-200-000
89-327-143-010
LED5
LED6
LED7
http://www.xiaoyu163.com
WIRING-1 (BU MAIN)
QQ 3 7 6 3 1 5 1 5 0
14
13
12
11
10
9
8
6
7
8 9 2 4 9 8 2 9 9
4
5
3
2
1
A
MAIN C.B (CHIP PARTS)
B
C
TEL
TEL
E
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
F
G
38
25
24
39
48
H
15
1
14
I
www
x ia o y u 1 6 3
.
5
.
c o
m
6
http://www.xiaoyu163.com
J
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
TEL
13942296513
13942296513
D
http://www.xiaoyu163.com
QQ 3 7 6 3 1 5 1 5 0
1
2
3
4
5
6
7
9
BLK
MAIN C.B (INSERTED PARTS)
10
12
13
14
TO/FROM MAIN C.B
VDD2
GRN
YEL
BLK
TO/FROM KEY C.B
CON1
RED
A
11
8 9 2 4 9 8 2 9 9
8
B
1
5
10
15
1
C
SW1
(HOOK)
20 21
18
SW2
TONE/PULSE
TEL
TEL
13942296513
9
10
2 1
3
E
1
1
9
16
4
28
1 3 9 4 2 2 9 6 5 1 3
14
OFF
QQ
4
1
5
8
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
15
3
4
G
2
1
J2
TEL. LINE
H
J3
DC 9V
I
www
RED
J
.
x ia o y u 1 6 3
ANT1 (BASE UNIT ANTENNA)
7
.
c o
m
8
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
F
8
SW3
RINGER
HIGH
LOW
QQ
QQ
TEL
TO/FROM MAIN C.B
VDD1
13942296513
D
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-1 (MAIN 1/4)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
U2
TA31002P/H31002P/HA31002P
TEL
TEL
13942296513
13942296513
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
C998
2200p
QQ
www
x ia o y u 1 6 3
.
9
.
c o
m
10
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
TEL
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-2 (MAIN 2/4)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
QQ
3 7 6 3 1 5 1 5 0
x ia o y u 1 6 3
11
.
c o
8 9 2 4 9 8 2 9 9
m
12
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
TEL
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-3 (MAIN 3/4)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
QQ
3 7 6 3 1 5 1 5 0
x ia o y u 1 6 3
.
13
.
c o
m
14
http://www.xiaoyu163.com
8 9 2 4 9 8 2 9 9
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
TEL
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-4 (MAIN 4/4)
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
15
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
WIRING-2 (KEY)
QQ 376315150 892498299
1
2
3
4
5
6
7
KEY C.B
SW2
SW1
CON1
BZ2
SW6
SW4
TEL
TEL
SW5
C
TO/FROM MAIN C.B
C0N2
B
SW3
21
A
13942296513
SW9
SW8
SW7
1
RED
BLK
E
SW11
SW10
RED
SW12
SW13
BZ3
SW17
G
SW14
SW15
LED7
SW16
SW18
LED6
LED5
H
I
SW1
1
SW2
2
SW3
3
SW4
4
SW5
5
SW6
6
SW7
7
SW8
8
SW9
9
SW10
SW14
FLASH
J
K
www
LED7
HOLD
SW11
0
SW15
MEMORY
SW12
#
SW13
STORE
xiaoy u163. com
SW16
REDIAL/PAUSE
.
SW17
HOLD
SW18
PAGE
LED5
IN-USE
16
http://www.xiaoyu163.com
LED6
POWER
376315150 892498299
376315150 892498299
F
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
BLK
13942296513
D
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-5 (KEY)
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
17
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
WIRING-3 (HAND KEY)
QQ 376315150 892498299
1
2
3
4
5
6
7
TO/FROM HS-RF C.B
CON1
A
HAND-KEY C.B
R9
CON1
15
1
R6
R10
R11
B
E C
R5
R4
R3
R2
R1
B
R8
R7
R12
R15
R14
SW15
SW1
LED2
TALK
LED1
BATT. LOW
SW15
TALK
SW1
MEMORY
TEL
TEL
LED2
C
LED1
R13
D5
Q1
SW17
SW18
SW17
1
SW19
SW18
2
SW19
3
E
SW12
SW13
QQ 376315150 892498299
SW7
SW8
F
SW14
SW12
4
SW13
5
SW14
6
SW9
SW7
7
SW8
8
SW9
9
G
LED3,4,5,6
(KEY BACK LIGHT)
LED5
SW2
1
2
2
SW3
B1 SW11
SW6
SW5
SW20
C5
D1
D3
I
C1
D2
K
www
.
SW11
R/P
SW10
VOL
SW3
0
SW6
FLASH
SW4
#
SW5
STORE
SW16
CH
SW9
PASE INT
C2
C4
ZD2
ZD1
L2
J
Nickel-Cadmium Battery
3.6V DC
SW16
D4
SW10
SW2
SW4
L1
1
BLK
RED
H
LED6
xiaoy u163. com
CHG2
CHG1
TO/FROM LED C.B
18
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
LED3
QQ
QQ
LED4
13942296513
13942296513
D
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-6 (HAND KEY)
TEL
TEL
3.2-1.6
3.2-1.6
QQ 376315150 892498299
LED
DRIVER
13942296513
13942296513
3MM
19
http://www.xiaoyu163.com
Ni-cd
BATTERY
3.6V
3MM
3MM
3MM
xiaoy u163. com
TO/FROM LED C.B
.
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
http://www.xiaoyu163.com
WIRING-4 (HS-RF: COMPONENT)
QQ 376315150 892498299
7
6
4
5
3
2
1
A
HS-RF C.B (COMPONENT SIDE)
B
34 33
23
22
44
1
C
4
5
11 12
BLK
15
E
14
25
F
38
1
39
48
G
M1
HANDSET
MICROPHONE
H
DX1
I
L5
www
.
L3
xiaoy u163. com
20
http://www.xiaoyu163.com
J
376315150 892498299
376315150 892498299
QQ 376315150 892498299
TEL 13942296513
QQ
QQ
24
RED
D
13942296513
13942296513
8
TEL
TEL
1
http://www.xiaoyu163.com
WIRING-5 (HS-RF: CONDUCTOR)
WIRING-6 (CHG/LED)
QQ 3 7 6 3 1 5 1 5 0
2
1
4
3
5
6
7
HS-RF C.B (CONDUCTOR SIDE)
A
1
A
TO/FROM
HAND KEY C.B
HANDSET
ANTENNA
1
15
2
3
4
5
6
8 9 2 4 9 8 2 9 9
7
B
B
RED
C
C
TEL
RED
3
D
BLK
D
BZ1
(HANDSET RINGER)
E
SP1
HANDSET
RECIVER
F
G
G
H
H
I
I
J
www
TO/FROM HAND KEY C.B
J
.
8 9 2 4 9 8 2 9 9
R901
3 7 6 3 1 5 1 5 0
F
x ia o y u 1 6 3
K
21
.
c o
m
22
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
TEL
R902
E
13942296513
13942296513
1
TEL
J901
BLK
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-7 (HS-RF 1/3)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
1
5
QQ
3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
OSC
SWITCH
www
x ia o y u 1 6 3
.
23
.
c o
m
24
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
TEL
13942296513
13942296513
15
TEL
TEL
10
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-8 (HS-RF 2/3)
QQ 3 7 6 3 1 5 1 5 0
8 9 2 4 9 8 2 9 9
TEL
TEL
13942296513
13942296513
www
.
QQ
3 7 6 3 1 5 1 5 0
x ia o y u 1 6 3
25
.
c o
8 9 2 4 9 8 2 9 9
m
26
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
QQ
QQ
TEL
http://www.xiaoyu163.com
SCHEMATIC DIAGRAM-9 (HS-RF 3/3)
QQ 3 7 6 3 1 5 1 5 0
IC BLOCK DIAGRAM
IC, AT24C01A-10SC
8 9 2 4 9 8 2 9 9
TEL
TEL
IC, TA31002P/H31002P/HA31002P
R2
7
C2
3 7 6 3 1 5 1 5 0
HYSTERESIS)
2
8 9 2 4 9 8 2 9 9
Note: R1, R2, C1 and C2 are parts externally mounted.
IC, TEA1062
www
x ia o y u 1 6 3
.
27
.
c o
m
28
http://www.xiaoyu163.com
8
POWER SUPPLY
(WITH
5
AMP
- +
C1
QQ
1
6
376315150 892498299
376315150 892498299
1 3 9 4 2 2 9 6 5 1 3
HIGH
f
OSC
4
QQ
QQ
TEL
LOW
f
OSC
- +
3
13942296513
13942296513
R1
http://www.xiaoyu163.com
IC DESCRIPTION
IC, TMP87C408N (BASE UNIT)
QQ 376315150 892498299
Pin No.
Pin Name
I/O
Description
1
XOUT
O
Oscillator out
2
XIN
I
Oscillator in
3
TEST
I
Tied low
Hook control output (for corded phone): 0 = OFF HOOK, 1 = ON HOOK
HOOK CONT
4
O
For ZPC-6: this pin is used as Speaker Amp, IC Mute Control)
(the Mic Mute control is controlled by hardware: unmute mic when Speaker is unmute
SPK MUTE
and charge not detected)
Received Signal Strength Indicator: (TB31224F SIG OUT pin)
5
SIG OUT
CHAG DET
I/O
0 = Rx unlock, 1 = Rx lock
Rx LOCK DETECT
0 = Tx unlock, 1 = Tx lock
Tx LOCK DETECT
Charge detect: 0 = charging, 1 = not charging.
Clock of EEPROM
7
DTMF4
O
DTMF data pin 4 (Most Significant Bit)
8-10
DTMF3-DTMF1
O
DTMF data pin 3-1
DTMF0
11
I/O
COUNTRY S2
RING OFF
12
DTMF data pin 0 (Least Significant Bit)
Country option select 2.
I/O
Country option select 1
QQ 376315150 892498299
PAGE KEY
I
14
GND
—
Ground
15
PLL STB
O
Combo chip strobe signal (TB31224F)
PLL DATA
16
O
U LED
PLL CK
17
TL RELAY
TL MUTE
19
Combo chip data signal (TB31224F).
In-use LED: 1 = ON, 0 = OFF.
I/O
DO EEPROM DI EEPROM
18
PAGE key: 1 = PAGE ON, 0 = STANDBY
Combo chip clk signal (TB31224F).
Data Input/Output of EEPROM.
O
I/O
M B SEL
Line seize: 1 = line seize, 0 = off-hook
Telephone Line Mute Control: 1 = MUTE.
Make/Break Ratio Select 1 = 33.3%, 0 = 40%
Hook detect input (for Corded Phone). 1 = ON HOOK, 0 = OFF HOOK
20
HOOK DET
I
REMARK: this pin is always PULL-HIGH for ZPC-7 or ZPC-6 (I. e. just imagine
Corded phone is Always ON HOOK)
TX PWR
21
I/O
SCRET OPT
22
TX DATA
BUZZER
23
Tx power control: 0 = ON, 1 = OFF. Secret function option: 1 = YES, 0 = NO
REMARK: this PULL LOW for ZPC-7 or ZPC-6 (I. e. Secret opt is DISABLED)
O
I/O
T P SEL
Transmit data output
Buzzer signal (key tone and paging sound ONLY)
Tone/Pulse selection: 1 = Pulse, 0 = Tone
24
RX DATA
I
Received data input
25
RING DET
I
Ring detect input: 1 = OFF, 0 = RING COME (MC34012)
www
26
27
28
xiaoy u163. com
BAND
.
I/O
SQ SELECTION
Shunt capacitor for U.S. Frequency Higher Band: 1 = shunt Cap, OUT OF RANGE
FUNCTION: 1 = YES, 0 = NO
____________
RESET
I
POWER
—
Normally High, Low to reset MCU
Power (VCC)
29
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
13
QQ
QQ
COUNTRY S1
Control the shunt resistor: 1 = shunt a resistor (For U, K ONLY)
13942296513
13942296513
CLK EEPROM
0 = carrier present, 1 = carrier absent NOISE DETECT
TEL
TEL
6
I
http://www.xiaoyu163.com
QQ 376315150 892498299
IC, W91340N
Pin No.
Pin Name
I/O
Description
The keyboard inputs may be used with either a standard 5 x 4 keyboard or an
1-4
C1-C4
I
inexpensive single contact (Form A) keyboard. Electronic input from a µC can also be
used. A valid key is defined as a single row being connected to a single column.
5
H/P MUTE
O
The H/P MUTE is a conventional inverter output. During pulse dialing, flash break or
hold period, this output is active high; otherwise, it remains in low state.
6
VSS
—
7, 8
___
XT, XT
I/O
9
______
T/P MUTE
Power input pins.
A built-in inverter provides oscillation with an inexpensive 3.579545 MHz crystal or
ceramic resonator.
______
The T/P MUTE is a conventional CMOS N-channel open drain output.
O
The output transistor is switched on during dialing sequence and flash break time.
____
HKS
I
11
___
DP
O
either tone mode or pulse mode.
In pulse mode, this pin remains in low state at all times. In the tone mode, it will output
Actual
Error %
697
QQ 376315150 892498299
699
+ 0.28
12
DTMF
O
R2
770
766
- 0.52
R3
852
848
- 0.47
R4
941
948
+ 0.74
C1
1209
1216
+ 0.57
C2
1336
1332
- 0.30
C3
1477
1472
- 0.34
Pulling mode pin to VSS places the dialer in tone mode. Pulling mode pin to VDD
places the dialer in pulse mode with M/B ratio of 40 : 60 (10 ppS, except for
13
MODE
I
W91342N/W91342AN = 20ppS)
Floating mode pin places the dialer in pulse mode with M/B ratio of 33.3 : 66.7
(10 ppS, except for W91342N/W91342AN = 20 ppS.)
14
VDD
—
Power input pins.
The keyboard inputs may be used with either a standard 5 x 4 keyboard or an
15-18
R1-R4
I
inexpensive single contact (Form A) keyboard. Electronic input from a µC can also be
used. A valid key is defined as a single row being connected to a single column.
www
.
xiaoy u163. com
30
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
Specified
R1
TEL 13942296513
Output Frequency
QQ
QQ
a dual or single tone.
13942296513
13942296513
10
Hook switch input.
____
HKS = VDD: On-hook state. Chip in sleeping mode, no operation.
____
HKS = VSS: Off-hook state. Chip is enabled for normal operation.
____
HKS pin is pulled to VDD by an internal resistor.
___
N-channel open drain dialing pulse output. Flash key will cause DP to be active in
TEL
TEL
Otherwise, it is switched off.
http://www.xiaoyu163.com
QQ 376315150 892498299
IC, TB31224F
Pin No.
Pin Name
I/O
1
TX-IN
I
2
VCC3
—
Description
Input terminal of TX VCO oscillation signal.
Power supply terminal.
LOCAL OSCILLATOR input and output terminals. Colpitts oscillator is formed by
3, 4
LO-1, LO-2
O
internal emitter follower and external X’tal. And external injection is possible from pin
3.
5
SIG OUT
O
Output terminal of detection signal. It is the open drain output.
6
CLK
I
Input terminal of clock.
7
DATA
I
Input terminal of serial data.
8
STB
I
Input terminal of strobe signal.
9
FIL-OUT
O
Output of FILTER AMP.
TEL
10
FIL-IN
I
Input of FILTER AMP.
11
COMP-OUT
O
Output of COMPRESSOR.
13942296513
12
C-NF
—
Feedback circuit of T type is formed by external capacitor with SUM AMP.
13
MIC-OUT
O
Output of MIC AMP and connected directly to input of SUM AMP.
14
MIC-IN
I
Input terminal of MIC AMP.
15
PRE-IN
I
Inverted input of PRE AMP.
16
PRE-OUT
O
Output of PRE AMP. Connected directly to EXPANDER.
17
EXP-OUT
O
Input the serial data for controlling IC.
RECE-IN
I
Inverted input of RECEIVER AMP.
19
RO1
O
Receiving output for a dynamic receiver.
20
RO2
O
Used for BTL output type with RO1 terminal when a ceramic receiver is used.
BATTERY ALARM terminals. When VCC decrease VBAT-L, This terminal outputs
21
BAT-ALM
O
“H” level. Detection voltage is controlled by data bit. This terminal is open collector
output.
22
RSS1
O
This terminal outputs DC level according to input signal level to IF AMP. Dynamic
range is around 70dB.
23
DATA-OUT
O
24
D-COMP-IN
I
Output terminal for wave form shaping. This terminal is open collector output.
DATA COMPARATOR input terminal. This terminal input demodulation signal of
DATA.
25
N FIL-IN
I
NOISE FILTER input and output terminals. BPF is composed of external capacitors
26
N FIL-OUT
O
and resistors. Connected internally to rectifier circuit by coupling capacitor.
27
AF-OUT
O
Demodulated signal output terminal. Carrier leak is small as LPF is built-in. Output
impedance is around 360Ω.
28
QUAD
I
Phase shift signal input terminal of FM demodulator.
29
IF-OUT
O
Output terminal of IF AMP.
30
GND1
—
GND terminal.
31
xiaoy u163. com
DEC
I
32
IF-IN
I
33
VCC1
—
Power supply terminal.
2ND MIX-OUT
O
MIX output terminal. Output impedance is around 1.5kΩ.
www
34
.
2nd IF input and decoupling for bias. Input impedance is around 1.5kΩ.
31
http://www.xiaoyu163.com
376315150 892498299
QQ 376315150 892498299
18
QQ
376315150 892498299
TEL 13942296513
13942296513
QQ
amp.
TEL
Output of SUM AMP at EXPANDER. The signal from gain cell is gained by inverted
http://www.xiaoyu163.com
QQ 376315150 892498299
Pin No.
Pin Name
I/O
35
N-REC
O
Description
After output of NOISE FILTER amplified around 20dB, noise signal is rectified by
external capacitor.
2ND MIX-IN
I
1st IF signal input terminal. Input impedance is around 4.7kΩ at 10.695MHz.
37
E-RECT
O
Connected capacitor for full-wave rectifier circuit of EXPANDER.
38
1ST MIX-OUT
O
MIX output terminals. Externally connects filters. Output impedance is 330Ω. (Typ.)
39
VREF
—
Reference terminal through internal buffer of compander block.
40
1ST MIX-IN
I
MIX input terminal. Double-balance MIX.
41
VCC2
—
Regulator terminal. Output voltage is 2.0V.
42
VCO-CONT
I
Voltage control terminal of RX-VCO.
43, 44
VCO-1, VCO-2
I
They are resonance terminals of RX-VCO.
45
C-RECT
—
Terminal for rectifier of COMPRESSOR. Almost the same circuit as E-RECT
terminal.
RX-OUT
O
Output terminal of CHARGE PUMP. CHARGE PUMP is constant current output
47
TX-OUT
O
circuit, and output current is varied by input serial data.
48
GND2
—
GND terminal.
www
.
QQ 376315150 892498299
xiaoy u163. com
32
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
1. General description
TB31224F is controlled by serial parts pin 6, 7, 8, and makes all situations by these serial bits for RF part in 46/49MHz cordless
telephone such as intermittent receiving state.
Not only 46/49MHz cordless telephone but CT0 cordless phone that has frequency spec. between about 20MHz and 60MHz can
be also set up TB31224F.
13942296513
13942296513
46
TEL
TEL
36
http://www.xiaoyu163.com
QQ 376315150 892498299
IC, TMP87C807U (HS-RF)
Pin No.
Pin Name
I/O
Description
1
SQ SELECTION
I
OUT OF RANGE FUNCTION: 1 = YES, 0 = NO
2
TX DATA
O
Transmitted data
3
CHARGE DET
I
Charge detect: 1 = charging, 0 = not charging
4
RX DATA
I
Received data (INT3/TC3)
5
LB LED
O
Low battery led (High current port): 1 = ON
6
TALK LED
O
Talk led (High current port): 0 = ON
7
PC13 ZPC7
I
Power save mode. Hi: NO, Lo = YES
8
KEY LED
O
Keypad LED: 0 = ON
9
BATT ALARM
I
Battery low detect: 0 = battery ok, 1 = battery low (3.25 V).
(Use COMBO chip TB31224F battery detect function)
Not connected.
11
CLK EEPROM
O
Clock of EEPROM
13942296513
12
RX PWR
O
Rx power control : 0 = ON, 1 = OFF.
13
—
Tied to low
14
TEST
______
RESET
I
Normally High, low to reset MCU.
15
XIN
I
Resonator in (3.58 MHz)
16
XOUT
O
Resonator out (3.58 MHz)
17
GND
—
Ground
QQ
18
N.C.
—
Not connected.
19
PLL STB
O
PLL DATA
20
DI EEPROM
I/O
DO EEPROM
QQ 376315150 892498299
Combo chip strobe signal input.
Combo chip data signal input.
Data input of EEPROM.
Data output of EEPROM.
21
PLL CK
O
Combo chip clock signal output.
22
BAND
O
Shunt capacitor for U.S. frequency high band: 1 = shunt capacitor.
23, 24
COUNTRY S1, S2
I
Country channel table selection 1, 2.
25
TX PWR
O
TX power control : 0 = ON, 1 = OFF.
26
RING VOL
O
Ringer volume control
27, 28
N.C.
—
Not connected.
29-32
ROW0-ROW3
O
Keypad column output #0-#3
33
BUZZER OUT
O
Buzzer signal
Received signal strength indicator: (TB31224F SIG OUT Pin)
34
SIG OUT
I
0 = carrier present, 1 = carrier absent
0 = Rx unlock, 1 = Rx lock
0 = Tx unlock, 1 = Tx lock
35
VOL LO
O
Receiver volume control 1 (Lo)
36
VOL HI
O
Receiver volume control 2 (Hi)
www
xiaoy u163. com
37
FN COL
I
Function key column input (INT5)
38
XTIN
I
32.768 kHz crystal
39
XTOUT
O
32.768 kHz crystal
VDD
—
Power (VCC)
COL3-COL0
I
40
41-44
.
Keypad column input #0-#3
33
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
—
13942296513
N.C.
TEL
TEL
10
http://www.xiaoyu163.com
VOLTAGE CHART
QQ 376315150 892498299
< B/U-MAIN >
IC-U2 (RINGER)
IC-U6 (DIALER)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
0
2.8
1
48
0
0
2
3.5
0
2.8
2
46.5
0
0
3
3.5
0
2.8
3
45.4
0
0
4
3.5
0
2.8
4
46.1
0
0
5
0
0
0
5
46.5
0
0
6
0
0
0
6
46.1
0
0
7
0
0
0
7
44.4
0
0
8
3.5
3.5
2.8
8
46.1
0
0
9
0
1.2
1.1
10
0.4
0.1
2.8
11
3.4
0.6
0.03
13942296513
12
0
0
0
13
0
0
0
14
3.5
3.5
2.8
15
3.5
3.5
2.8
16
3.5
3.5
2.8
17
3.5
3.5
2.8
QQ
18
3.5
3.5
2.8
xiaoy u163. com
34
http://www.xiaoyu163.com
376315150 892498299
.
QQ 376315150 892498299
QQ
www
13942296513
376315150 892498299
TEL 13942296513
TEL
3.5
TEL
1
http://www.xiaoyu163.com
QQ 376315150 892498299
IC-U3 (SPEACH)
IC-U7 (MCU)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
1
2.1
2.1
2.1
2
0.2
2
2
2
2.1
2.1
2.1
3
0.2
2
2
3
0
0
0
4
0.3
2
1.6
4
0.01
0.01
4.8
5
0.3
2
1.6
5
4.8
4.8
0.02
6
0.1
2
1.6
6
0.01
0.01
0.01
7
0.1
2
1.6
7
0.01
0.01
0.01
8
0
0.04
0.04
8
0.01
0.01
0.01
9
0
0
0
9
0.01
0.01
0.01
10
0.1
1.3
1.3
10
0.01
0.01
0.01
11
0.1
2
1.6
11
0.03
0.03
0.03
12
0.1
0
0
12
0
0
0
13
0
4
3.2
13
0
0
0
14
0
2
2
14
0
0
0
15
0
0.8
0.8
15
0
0
0
16
0
0.8
0.8
16
0.03
0.03
4.2
17
0.05
0.05
0.03
18
0
0
4.8
19
4.8
4.8
4.8
20
4.8
0.1
4.8
21
4.8
4.8
0
22
0
0
0
23
0.2
0.2
0.2
24
2.2
2.2
0.04
25
4.8
4.8
4.8
26
4.8
4.8
4.8
27
4.8
4.8
4.8
28
4.8
4.8
4.8
TEL 13942296513
www
.
QQ 376315150 892498299
xiaoy u163. com
35
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
4.5
QQ
QQ
4.5
13942296513
13942296513
0
TEL
TEL
1
http://www.xiaoyu163.com
QQ 376315150 892498299
IC-U1 (RF)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
37
1.1
1.1
0.6
2
4.8
4.8
4.8
38
3.4
3.4
3.4
3
4.8
4.8
4.8
39
1.5
1.5
1.5
4
4.5
4.5
4.5
40
1
1
1
5
4.8
4.8
0.02
41
2
2
2
6
0.06
0.06
0.03
42
0.3
0.3
0.3
7
0.03
0.03
4.2
43
4.8
4.8
4.8
8
0
0
0
44
4.8
4.8
4.8
9
0.1
0.1
1.5
45
0.3
0.3
0.7
10
0.1
0.1
1.5
46
2.3
2.4
2.5
11
0.3
0.6
1.5
47
0.06
0.1
1.7
12
0.3
0.6
1.5
48
0
0
0
13
0.3
0.6
1.5
14
0.3
0.6
1.5
15
1.5
1.5
1.5
16
1.5
1.5
1.5
17
1.5
1.5
1.5
18
1.2
1.2
1.2
19
1.2
1.2
1.2
20
1.2
1.2
1.2
0
0
0
0.2
0.2
0.8
23
2.2
2.3
4.8
24
0.7
0.7
0.7
25
0.7
0.7
0.7
26
0.7
0.7
0.7
27
0.6
0.6
0.6
28
4.8
4.8
4.8
29
4
4
4
30
0
0
0
31
4.5
4.5
4.5
32
4.5
4.5
4.5
33
4.8
4.8
4.8
34
3.5
4.8
3.5
35
1.3
1.3
0.05
36
1
1
1
21
22
TEL 13942296513
www
.
IC-U8 (EEPROM)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
1
4.8
4.8
4.8
QQ 376315150 892498299
2
0
0
0
3
4.8
4.8
4.8
4
0
0
0
5
0.05
0.05
0.03
6
0.01
0.01
0.01
7
0
0
0
8
4.8
4.8
4.8
xiaoy u163. com
36
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
4.8
QQ
QQ
4.8
13942296513
13942296513
4.8
TEL
TEL
1
http://www.xiaoyu163.com
QQ 376315150 892498299
Q4
Q12
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
51
6.1
6
E
0
0
0
C
0.03
5.9
5.9
C
0
0.01
2.7
B
49
5.3
5.2
B
0
0.5
0.07
Q5
Q14
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
49
5.3
5.3
E
0
0
0
C
0
5.3
5.3
C
0
0.07
0.07
B
51
4.6
4.6
B
0.1
0.8
0.6
Q6
Q15
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
0
0
0
E
0
0
0
C
49
0.1
4.6
C
0
0.06
3.2
B
0
0.6
0.03
B
0
0.6
0.06
Q3
Q17
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
1.2
1.2
1.2
E
0
0
0
C
4.5
4.5
4.5
C
0.6
4.6
4.6
B
1.9
1.9
1.9
Q8
QQ
376315150 892498299
B
0.3
0.3
0.3
Q18
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
0
0
0
E
0
5.2
5.1
C
51
4.6
0.03
C
0
1.6
1.5
B
0
0
0.6
B
0.4
4.7
4.6
Q19
Q10
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
0
0
0
E
0
0
0
C
0
0.1
0.1
C
4.8
0.1
4.8
B
0
0.6
0.4
B
0
0
0
Q20
Q11
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
0
0
0
E
3.6
5.1
5.1
C
0
5.2
5.2
C
3.5
0
2.8
B
0
0.1
0.1
B
3.1
4.1
4.1
www
.
xiaoy u163. com
37
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
E
13942296513
13942296513
E
TEL
TEL
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
http://www.xiaoyu163.com
QQ 376315150 892498299
Q21
Q9
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
0
0
0
E
0
0
0
C
0
0.6
0.03
C
0.3
0.3
4.8
B
0.01
0.01
0.6
B
0.3
0.3
0.6
Q22
Q1
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
0
0
0
E
0
0
0.6
C
0
0.1
0.1
C
0.3
0.3
4.4
B
0
0.4
0.6
B
0.3
0.3
1.3
Q28
Q2
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
0
0
0
E
0
0
3.6
C
4.8
0.1
4.8
C
0.3
0.3
4.6
B
0
0.6
0
B
0.3
0.3
4
Q25
Q23
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
0
0
0
E
4.8
4.8
4.8
C
0
3.1
0
C
0
0
0
B
0.6
0.6
0.6
QQ
B
376315150 892498299
4.3
4.3
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
0
0
0
C
4.8
4.8
4.8
B
0
0
0
Q27
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
E
4.9
4.9
4.9
C
0.3
0.3
4.9
B
4.9
4.9
4.2
www
.
xiaoy u163. com
38
http://www.xiaoyu163.com
4.3
376315150 892498299
376315150 892498299
Q24
TEL 13942296513
QQ
QQ
E
13942296513
13942296513
E
TEL
TEL
WAITING (V) B/U TALIKING (V) H/S TALIKIG (V)
http://www.xiaoyu163.com
QQ 376315150 892498299
< H/S-RF >
IC-U3 (EEPROM)
IC-U4 (RESET)
WAITING (V)
TALIKING (V) CHARGING (V)
WAITING (V)
TALIKING (V) CHARGING (V)
1
3.8
3.8
3.8
1
3.8
3.8
3.8
2
0
0
0
2
0
0
0
3
3.8
3.8
3.8
3
3.8
3.8
3.8
4
0
0
0
5
3.8
3.8
3.8
6
0
0
0
7
0
0
0
8
3.8
3.8
3.8
TEL
TEL
WAITING (V)
WAITING (V)
TALIKING (V) CHARGING (V)
TALIKING (V) CHARGING (V)
0
0
25
3.8
0.04
4.1
2
0
0
0
26
3.8
3.8
4.1
3
0
0
4.4
27
1.5
1.5
0-0.01
4
3.8
0-2.8
1.8
28
1.5
1.5
0-0.01
5
3.8
3.8
4.1
29
0
0
0
6
0
3.5
0
30
0
0
0
7
3.8
3.8
4.1
31
0
0
0
8
3.8
3.8
4.1
32
0
0
0
9
3.8
0.02
0.02
33
0
0
0
10
1.8
1.5
0
34
3.8
3.8
4.1
11
0
0
0
35
0
3.8
0
12
3.8
0.02
0.02
36
3.8
0
4.1
13
0
0
0
37
3.8
3.8
4.1
14
3.8
3.8
4.1
38
1.3
1.3
1.5
15
0-3
1.2
1.4
39
2
2
2.2
16
3.8
1.5
1.6
40
3.8
3.8
4.1
17
0
0
0
41
3.8
3.8
4.1
18
1.5
1.4
0-0.01
42
3.8
3.8
4.1
19
0
0
0
43
3.8
3.8
4.1
20
3.8
3.8
4.1
44
3.8
3.8
4.1
21
0
0
0
TEL 13942296513
www
22
0
23
0
24
3.8
.
QQ 376315150 892498299
xiaoy u163. com
0
0-2.1
0
0.04
3.8
4.1
39
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
0
QQ
QQ
1
13942296513
13942296513
IC-U2 (MCU)
http://www.xiaoyu163.com
QQ 376315150 892498299
IC-U1 (RF)
WAITING (V)
TALIKING (V) CHARGING (V)
WAITING (V)
TALIKING (V) CHARGING (V)
0.1-1.2
3.8
4
2
3.8
3.7
3.9
34
0.1-0.9
2.4
2.7
3
0-1.4
3.7
3.9
35
0
0.05
1.3
4
0-1.4
3.3
3.5
36
0.01-0.4
1
1
5
3.8
0.03
4
37
0.3
0.7
0.3
6
0
0
0.04
38
0.1-0.8
2.3
2.6
7
3.8
3.8
4
39
0.3
1.4
0.3
8
0
0
0
40
0-0.1
1
1
9
0.1
1.4
0.1
41
0.3-1.8
2
2
10
0.1
1.4
0.1
42
0-0.6
0.02
0-0.6
TEL
11
0.3
1.4
0.3
43
0.1-1.1
3.8
4
12
0.3
1.4
0.3
44
0-0.1
3.8
4
13942296513
13
0.3
1.4
0.3
45
0.3
0.6
0.3
14
0.3
1.4
0.3
46
0-0.8
1.1
2.3
15
0-0.2
1.4
0.01-0.2
47
0.07
2.2
0.2
16
0-0.2
1.4
0.01-0.2
48
0
0
0
17
0.1
1.4
0.1
18
0.01-0.1
1.2
0.1
19
0.01-0.1
1.2
0.1
20
0.01-0.1
1.2
0.1
0-3.8
0
0.02
0
1
0.2
23
0-3.8
0.01-1.8
1.8
24
0-0.06
0.7
0.7
25
0
0.7
0.7
26
0
0.7
0.7
27
0.01-0.8
0.7
1
28
0.1-1.1
3.8
4
29
0.1-1
2.8
3.1
30
0
0
0
31
0.1-1.2
3.4
3.6
32
0.1-1.2
3.4
3.6
376315150 892498299
21
22
TEL 13942296513
www
.
QQ 376315150 892498299
xiaoy u163. com
40
http://www.xiaoyu163.com
376315150 892498299
33
QQ
3.9
13942296513
3.7
TEL
3.8
QQ
1
http://www.xiaoyu163.com
QQ 376315150 892498299
Q3
Q2
WAITING (V)
TALIKING (V) CHARGING (V)
WAITING (V)
TALIKING (V) CHARGING (V)
E
0-0.2
0.8
0.8
E
0
1.3
0
C
0.1-1.2
3.5
3.5
C
0.2
2.6
0.1
B
0.5-1.5
1.5
1.5
B
0.2
2
0.1
Q7
Q1
WAITING (V)
TALIKING (V) CHARGING (V)
WAITING (V)
TALIKING (V) CHARGING (V)
E
3.8
3.8
3.9
E
0
0.2
0
C
0.1-1.8
3.7
3.8
C
0.2
3.4
0.1
B
3.8
3.1
3.2
B
0.2
1
0.1
Q5
Q9
TALIKING (V) CHARGING (V)
WAITING (V)
TALIKING (V) CHARGING (V)
0
0
0
E
0
0
0
C
0.02
0.02
0.02
C
0.2
3.5
0.1
B
0
0.5
0
B
0.2
0.7
0.1
Q1
Q6
WAITING (V)
WAITING (V)
TALIKING (V) CHARGING (V)
TALIKING (V) CHARGING (V)
0
0
0
E
3.8
1.5
4
C
3.8
3.8
3.9
C
0
0
0
B
0
0
0
Q10
WAITING (V)
QQ
376315150 892498299
B
3.8
3.8
TALIKING (V) CHARGING (V)
E
3.8
3.8
3.9
C
0.2
3.7
0.1
B
3.8
3.1
3.9
Q8
WAITING (V)
TALIKING (V) CHARGING (V)
E
3.8
3.8
3.9
C
3.8
3.8
3.9
B
3.8
3.8
3.9
Q4
WAITING (V)
TALIKING (V) CHARGING (V)
E
0
0
0
C
0.04
0.04
0.04
B
0.6
0
0.6
www
.
xiaoy u163. com
41
http://www.xiaoyu163.com
4.1
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
E
13942296513
13942296513
E
TEL
TEL
WAITING (V)
http://www.xiaoyu163.com
MECHANICAL EXPLODED VIEW 1/2
QQ 376315150 892498299
1
2
3
6
17
18
B
9
7
C
10
14
P.C.B
WEIGHT
PLATE
C
4
5
C
C
C
C
A
15
P.C.B
16
11
B
B
www
12
xiaoy u163. com
12
.
42
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
P.C.B
TEL 13942296513
QQ
QQ
CUSHION
13942296513
13942296513
8
TEL
TEL
13
http://www.xiaoyu163.com
QQ 376315150 892498299
MECHANICAL PARTS LIST 1/2
REF. NO
PART NO.
S8-PCD-070-020
S3-351-000-010
S1-291-000-580
S0-251-100-000
S8-PCD-010-600
6
6
7
8
9
9
9
10
11
11
PART NO.
11
12
13
13
13
KANRI
DESCRIPTION
NO.
S8-PCD-480-020
BASE BOTTOM<5EZL>
S0-251-520-000
RUBBER FOOT
S8-PCD-090-030
HANDSET BACK<5EZG>
S8-PCD-090-020
HANDSET BACK<5EZL>
S8-PCD-090-010
HANDSET BACK<5EZB>
KNOB,SW HOOK<5EZL>
PIEZO BUZZER 35MM LF35B-29FB
MIC CONDENSER
MIC HOLDER (BLK)
BASE TOP<5EZB>
14
15
15
15
16
S1-000-301-530
S8-PCD-080-010
S8-PCD-080-020
S8-PCD-080-030
S1-010-002-910
DYNAMIC RECEIVER SD-153B
HANDSET FRONT<5EZB>
HANDSET FRONT<5EZL>
HANDSET FRONT<5EZG>
TELCORD-C04USPP2.2UL<5EZB>
S8-PCD-010-900
S8-PCD-010-800
S0-111-030-000
S8-PCD-040-200
S8-PCD-050-020
BASE TOP<5EZG>
BASE TOP<5EZL>
ANT,ROD TELESCOPIC
KEY,DIAL NO
KEY,FUNCTION<5EZL>
16
16
17
18
A
S1-010-003-110
S1-010-003-210
S3-120-000-000
SB-032-065-450
87-352-095-010
TELCORD-CO4USPP 2.2UL<5EZG>
TELCORD-CO4USPP2.2UL<5EZL>
BUZZER,12MM
INTERNAL LOCK WASHER 3.2-6.5-0
SCREW,ST3-8
S8-PCD-050-010
S8-PCD-050-030
S8-PCD-200-000
S8-PCD-480-030
S8-PCD-480-010
KEY,FUNCTION<5EZB>
KEY,FUNCTION<5EZG>
RUBBER KEYPAD 116.5-84.5
BASE BOTTOM<5EZG>
BASE BOTTOM<5EZB>
B 87-741-096-410
C 87-743-073-410
SCREW,ST3-10MM
SCREW,ST2.6-6MM
COLOR NAME TABLE
www
.
QQ 376315150 892498299
xiaoy u163. com
43
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TEL 13942296513
QQ
QQ
Basic color symbol
Color
Basic color symbol
Color
Basic color symbol
Color
B
Black
C
Cream
D
Orange
G
Green
H
Gray
L
Blue
LT
Transparent Blue
N
Gold
P
Pink
R
Red
S
Silver
ST
Titan Silver
T
Brown
V
Violet
W
White
WT
Transparent White
Y
Yellow
YT
Transparent Yellow
LM
Metallic Blue
LL
Light Blue
GT
Transparent Green
LD
Dark Blue
DT
Transparent Orange
13942296513
13942296513
2
3
4
5
6
REF. NO
TEL
TEL
1
1
1
2
2
KANRI
DESCRIPTION
NO.
S8-PCD-060-020
KNOB,HANGER<5EZL>
S8-PCD-060-010
KNOB,HANGER<5EZB>
S8-PCD-060-030
KNOB,HANGER<5EZG>
S8-PCD-070-010
KNOB,HOOK SWITCH<5EZB>
S8-PCD-070-030
KNOB,SW HOOK<5EZG>
http://www.xiaoyu163.com
MECHANICAL EXPLODED VIEW 2/2
QQ 376315150 892498299
1
E
6
3
2
P.C.B
4
A
A
5
TEL
TEL
20
SHEET
A
13942296513
13942296513
B
A
P.C.B
9
15
QQ 376315150 892498299
CUSHION
SHEET
11
12
13
P.C.B
C
P.C.B
14
CHARGE,
TERMINAL
PLATE
C
17
www
D
xiaoy u163. com
18
.
44
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
TE8L 13942296513
16
10
QQ
QQ
7
http://www.xiaoyu163.com
QQ 376315150 892498299
MECHANICAL PARTS LIST 2/2
REF. NO
PART NO.
1
1
1
2
2
KANRI
DESCRIPTION
NO.
S8-PCD-120-010
DOOR,BATT<5EZB>
S8-PCD-120-040
DOOR,BATT<5EZL>
S8-PCD-120-050
DOOR,BATT<5EZG>
S8-PCD-110-600
H/S BACK<5EZB>
S8-PCD-111-000
H/S BACK<5EZG>
2
3
4
5
6
S8-PCD-110-900
S8-PCD-170-010
S0-111-070-000
S8-PCD-440-000
S3-120-000-010
7
8
9
10
10
REF. NO
PART NO.
17
17
17
18
19
S8-PCD-190-020
S8-PCD-190-010
S8-PCD-190-030
S0-251-520-000
S1-500-271-500
CHARGE CAB BOTTOM<5EZL>
CHARGE CAB BOTTOM(BLK)<5EZB>
CHARGE CAB BOTTOM(GN)<5EZG>
RUBBER FOOT
CONN,15P 1.5MM
S8-PCD-210-000
S8-PCD-130-100
S0-301-500-030
S8-PCD-140-020
S8-PCD-140-010
RUBBER KEYPAD 107.5-44
KEY,DIAL NO(H/S)
DYNAMIC RECEIVER 38-21
BTN,TALK<5EZL>
BTN,TALK<5EZB>
20
A
B
C
D
SB-022-048-300
S0-502-000-520
87-263-033-210
87-743-073-410
87-353-076-210
INTERNAL LOCK WASHER 2.2-4.8-0
SCREW,ST2-5
SCREW,2x4
SCREW,ST2.6-6MM
SCREW,+2.6-12
10
11
11
11
12
S8-PCD-140-030
S8-PCD-160-020
S8-PCD-160-030
S8-PCD-160-010
S1-291-000-640
BTN,TALK<5EZG>
KEY,FUNCTION<5EZL>
KEY,FUNCTION<5EZG>
KEY,FUNCTION<5EZB>
MIC CONDENSER CMT64
13
14
14
14
15
S0-251-100-000
S8-PCD-100-500
S8-PCD-101-000
S8-PCD-100-900
S8-PCD-060-030
MIC HOLDER (BLK)
HANDSET FRONT<5EZB>
H/S FRONT<5EZG>
H/S FRONT(H/S-BL)<5EZL>
KNOB,HANGER<5EZG>
E 87-743-036-410
SCREW,ST2-8
13942296513
13942296513
H/S BACK(H/S-BL)<5EZL>
KNOB,CAP ANT
TELESCOPIC ROD ANTENNA
ANT,HOLDER H/S
BUZZER,LF12G-1WC 12MM
www
.
xiaoy u163. com
45
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
QQ 376315150 892498299
Basic color symbol
Color
Basic color symbol
Color
Basic color symbol
Color
B
Black
C
Cream
D
Orange
G
Green
H
Gray
L
Blue
LT
Transparent Blue
N
Gold
P
Pink
R
Red
S
Silver
ST
Titan Silver
T
Brown
V
Violet
W
White
WT
Transparent White
Y
Yellow
YT
Transparent Yellow
LM
Metallic Blue
LL
Light Blue
GT
Transparent Green
LD
Dark Blue
DT
Transparent Orange
QQ
QQ
COLOR NAME TABLE
TEL 13942296513
TEL
TEL
15
15
16
16
16
KANRI
DESCRIPTION
NO.
S8-PCD-060-020
KNOB,HANGER<5EZL>
S8-PCD-060-010
KNOB,HANGER<5EZB>
S8-PCD-180-300
CHARGE CAB TOP<5EZL>
S8-PCD-180-200
CHARGE CAB TOP(BLK)<5EZB>
S8-PCD-180-400
CHARGE CAB TOP(GN)<5EZG>
http://www.xiaoyu163.com
QQ 376315150 892498299
TEL
TEL
13942296513
13942296513
.
xiaoy u163. com
2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111
Printed in Singapore
737004
http://www.xiaoyu163.com
376315150 892498299
376315150 892498299
www
QQ 376315150 892498299
QQ
QQ
TEL 13942296513
Download PDF