MATERIAL SAFETY DATA SHEET Total Solutions P.O. Box 240014 Milwaukee, WI 53224 GENERAL INFORMATION NUMBER: (414) 354-6417 CHEMTREC: (800) 424-9300 REVISION DATE: April 1, 2010 DATE OF ISSUE: April 2, 2010 I - Product Identification Clean Cut PRODUCT CODE: 0422 CHEMICAL FORMULATION: Water based alkaline cleaner. NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1 HAZARD RATING: 4 - Extreme; 3 - High; FLAMMABILITY: 0 2 - Moderate; 1 - Slight; REACTIVITY: 0 0 - Insignificant II - Hazardous Ingredients SUBSTANCE Trisodium Phosphate 2-Butoxyethanol Key: Values reported as TWA unless noted. EPA 40 CFR: OSHA ACGIH PEL TLV 355 372 302 1.00-3.00 N/E N/E N N N < 2.00 50 ppm (skin) 20 ppm (skin) N N Y APPROX % CAS # 7601-54-9 111-76-2 PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No 302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4). 355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355). 372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372). III - Physical Data SPECIFIC GRAVITY (WATER = 1): 1.0 BOILING POINT (°F): N/D VAPOR PRESSURE (mm Hg): N/D VOC CONTENT (% by weight): < 2.00 VAPOR DENSITY (AIR = 1): N/D EVAPORATION RATE (WATER = 1): N/D SOLUBILITY IN WATER: Soluble pH: 11.50-12.50 APPEARANCE AND ODOR: Clear, yellow liquid; detergent odor. IV - Fire and Explosion Hazard Data FLASH POINT (°F): None (TEST METHOD): Closed cup FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: N/D LOWER: N/D EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical. SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full protective gear including self-contained breathing apparatus. UNUSUAL FIRE AND EXPLOSION HAZARD: None. PRODUCT NAME: Clean Cut PRODUCT CODE: 0422 V - Reactivity Data STABILITY: Stable INCOMPATIBILITY: Strong acids. CONDITIONS TO AVOID: None. HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon. HAZARDOUS POLYMERIZATION: Will not occur. VI - Health Hazard Data ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None. EFFECTS OF OVEREXPOSURE IF IN EYES: Mild irritation and redness. IF ON SKIN: Redness, dryness and irritation, with prolonged or repeated exposure. IF SWALLOWED: Gastrointestinal irritation, nausea, cramps, vomiting. IF INHALED: Irritation to upper respiratory tract. EMERGENCY AND FIRST AID PROCEDURES IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical attention. IF ON SKIN: Wash with soap and water. Remove contaminated clothing and launder separately before reuse. If irritation persists, obtain medical attention. IF SWALLOWED: Contact physician or poison control center immediately. Give affected person several glasses of water. Do not induce vomiting unless told to do so by a physician or poison control center. Never give anything to an unconscious person. IF INHALED: Remove person to fresh air. VII - Spill or Leak Protection STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Contain spill and soak up spilled material with inert absorbent material and place in a properly marked closed container for proper disposal. WASTE DISPOSAL METHOD: Consult local environmental authorities. VIII - Special Protection Information RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH approved respirator, following manufacturer’s recommendations. VENTILATION LOCAL: Recommended MECHANICAL: Not required PROTECTIVE GLOVES: Chemical resistant. EYE PROTECTION: Safety glasses or chemical goggles OTHER PROTECTIVE EQUIPMENT: Eye wash station. PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place. Keep container tightly closed when not in use. OTHER PRECAUTIONS: Keep out of reach of children. IX - Transportation Information (ground transportation only) DOT ID NUMBER: None DOT CLASS: None DOT PROPER SHIPPING NAME: None DOT PACKING GROUP: None The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further intended, different shipping names and labeling may apply. REVISION DATE: April 1, 2010 Prepared by: Technical Dept. DATE OF ISSUE: April 2, 2010 This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third parties caused by the material such vendees or users assume all risks associated with the use of this material.
* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project