Chevrolet | Tavera | Specifications | Chevrolet Tavera Specifications

BS4
General Motors India Pvt. Ltd.
All information, illustrations and specifications contained in this Owner's Manual are based on
the latest production information available at the time of publication. The right is reserved to
make changes at any time without notice.
24 Hr. Helpline at 1800 3000 8080
Part No. : 28283507
Revision No. 04
Revision Date
01/2014/1,000
BS4 (Neo3)
Regd. Office : Chandrapura Industrial Estate, Halol - 389 351
Dist. Panchmahals, Gujarat, India. Phone : 91 2676 221000
Customer Assistance Center : Plot No. 15, Echelon Institutional Area,
Sector 32, Gurgaon - 122 001, Haryana, India. Tel.: 91 124 3080000
Works : A-16, MIDC Talegaon Industrial Area (Phase-II),
Near Floriculture Park, Talegaon Navlakh Umbhre Village Road, Tehsil-Maval,
Pune - 410 507, Maharashtra, India. Tel: 91 2114 663939
BS4
General Motors India Pvt. Ltd.
All information, illustrations and specifications contained in this Owner's Manual are based on
the latest production information available at the time of publication. The right is reserved to
make changes at any time without notice.
24 Hr. Helpline at 1800 3000 8080
Part No. : 28283507
Revision No. 04
Revision Date
01/2014/1,000
BS4 (Neo3)
Regd. Office : Chandrapura Industrial Estate, Halol - 389 351
Dist. Panchmahals, Gujarat, India. Phone : 91 2676 221000
Customer Assistance Center : Plot No. 15, Echelon Institutional Area,
Sector 32, Gurgaon - 122 001, Haryana, India. Tel.: 91 124 3080000
Works : A-16, MIDC Talegaon Industrial Area (Phase-II),
Near Floriculture Park, Talegaon Navlakh Umbhre Village Road, Tehsil-Maval,
Pune - 410 507, Maharashtra, India. Tel: 91 2114 663939
BS4
General Motors India Pvt. Ltd.
All information, illustrations and specifications contained in this Owner's Manual are based on
the latest production information available at the time of publication. The right is reserved to
make changes at any time without notice.
24 Hr. Helpline at 1800 3000 8080
Part No. : 28283507
Revision No. 04
Revision Date
01/2014/1,000
BS4 (Neo3)
Regd. Office : Chandrapura Industrial Estate, Halol - 389 351
Dist. Panchmahals, Gujarat, India. Phone : 91 2676 221000
Customer Assistance Center : Plot No. 15, Echelon Institutional Area,
Sector 32, Gurgaon - 122 001, Haryana, India. Tel.: 91 124 3080000
Works : A-16, MIDC Talegaon Industrial Area (Phase-II),
Near Floriculture Park, Talegaon Navlakh Umbhre Village Road, Tehsil-Maval,
Pune - 410 507, Maharashtra, India. Tel: 91 2114 663939
BS4
General Motors India Pvt. Ltd.
All information, illustrations and specifications contained in this Owner's Manual are based on
the latest production information available at the time of publication. The right is reserved to
make changes at any time without notice.
24 Hr. Helpline at 1800 3000 8080
Part No. : 28283507
Revision No. 04
Revision Date
01/2014/1,000
BS4 (Neo3)
Regd. Office : Chandrapura Industrial Estate, Halol - 389 351
Dist. Panchmahals, Gujarat, India. Phone : 91 2676 221000
Customer Assistance Center : Plot No. 15, Echelon Institutional Area,
Sector 32, Gurgaon - 122 001, Haryana, India. Tel.: 91 124 3080000
Works : A-16, MIDC Talegaon Industrial Area (Phase-II),
Near Floriculture Park, Talegaon Navlakh Umbhre Village Road, Tehsil-Maval,
Pune - 410 507, Maharashtra, India. Tel: 91 2114 663939
"#"
&
"
!%!
$
)*'
!
(!
"'
(!
"
!
Dear Customer,
Welcome to the Chevrolet family. We wish to thank you for choosing Chevrolet Tavera.
It is our constant endeavor to provide you with products that offer excellent performance through out their ownership period. Which is
why, in addition to offering great cars, we have also set up an extensive, and very well equipped network of retailers and authorized service
centres across the country.
Naturally, these Chevrolet retailers knows everything there is to know about your car, and provides you with the best service possible. In
fact, every retailer is equipped with the most advanced technology, technicians specially trained by us, and genuine spares. Needless to
say, they are also committed to ensure your complete satisfaction.
So, please contact a Chevrolet retailer for any servicing need and make sure that only genuine spares are used for your car.
This manual will familiarize you with the operation and maintenance of your new vehicle. It will also provide you with important safety
information. Please do read it carefully and follow the recommendations. In fact, the manual is like a permanent part of your car. And it
would go a long way in ensuring a safe and trouble-free operation for your car.
Should you have any query please feel free to call our 24 hr. Helpline at 1800 3000 8080 or email us at : gmi.cac@gm.com.
Happy Motoring
IMPORTANT NOTICE
Please read this manual and follow the instructions carefully.
Throughout this manual you will find special notations:
• Warning • Caution • Note
WARNING
WARNING indicates a potentially hazardous situation which, if not
avoided, could result in serious injury or death.
CAUTION
CAUTION indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate injuries, or damage to your
vehicle or other property.
NOTE
NOTE indicates information which will assist you with maintenance or
other instructions concerning your vehicle.
ABBREVIATIONS USED IN THIS MANUAL
V
D
or * .....................Variation (optional on some models).
..........................For diesel engine models only.
MT ..........................For manual transmission models only.
PS
..........................For power steering models only.
V or * : The asterisk and V in this manual,
signify an item of equipment that is not included on
all vehicles. Such items include engine options,
model variations specific to one country, and
optional equipment.
All information, illustrations, and specifications in
this manual are based on the latest product
information available at the time of publication.
General Motors India Pvt. Ltd. (GMI) reserves the
right to change specifications or designs at any
time without notice and without incurring
obligation.
This vehicle may not comply with the standards or
regulations of other countries. Before attempting
to register this vehicle in any other country, check
all applicable regulations and make any necessary
modifications.
This manual describes the options and trims
available at the time of publication. Some of the
items covered may not apply to your vehicle.
Contact your CHEVROLET retailer for information
on option and trim availability.
Non-GMI Genuine parts and accessories have not
been examined or approved by GMI. We can
certify neither the suitability nor the safety of NonGMI genuine parts and accessories and are not
liable for damage caused by their use.
TABLE OF CONTENTS
SECTION
PAGE
SECTION
PAGE
IMPORTANT INFORMATION...........................................1
Starting engine ................................................................85
Location of chassis and engine number............................1
Before driving off .............................................................87
Overloading.......................................................................2
Stopping engine ..............................................................89
Operation of new vehicle...................................................3
Parking ............................................................................89
Operation and care of vehicle ...........................................5
Driving precautions .........................................................90
Maintenance......................................................................5
Driving for economy MT ................................................96
CONTROLS AND INSTRUMENTS...................................6
In case of emergency......................................................99
Steering column controls...................................................7
SERVICE AND MAINTENANCE...................................110
Instrument panel and controls.........................................14
Maintenance schedule ..................................................111
Floor controls ..................................................................30
Maintenance guide........................................................117
Others .............................................................................32
Recommended lubricants and diesel fuels ...................141
BEFORE DRIVING YOUR VEHICLE..............................55
Lubrication.....................................................................143
Operation of controls.......................................................55
Lubrication guide...........................................................146
Driver's check list (Regular inspection) ...........................75
MAIN DATA AND SPECIFICATIONS ...........................151
DRIVING .........................................................................85
SERVICE AND WARRANTY ........................................155
Preparation for starting engine........................................85
CHEVROLET SALES INDIA
SALES AND SERVICE NETWORK..............................180
The following information is important for the proper care and economical operation of your CHEVROLET vehicle and
should be thoroughly understood before placing it into service.
It is advisable to write down the chassis and engine number as they are required
when contacting your CHEVROLET retailer for repair services.
Chassis number is stamped on the left hand side of the chassis member behind
rear left wheel as indicated by arrow.
LOCATION OF VIN (Vehicle Identification Number) PLATE
The VIN plate is fixed on the surface of front end upper panel as indicated by
arrow.
1
Engine number D
The engine number is stamped / punched on the right side of the cylinder
block adjacent to oil filter.
123456740
OVERLOADING
WARNING
Overloading not only shortens the service life of your vehicle, but also creates
serious potential safety hazards.
2
OPERATION OF NEW VEHICLE
The subsequent performance and the life of your vehicle are directly influenced
by the care and treatment that your vehicle receives during the initial break-in
period. It is therefore recommended that during the initial 1,000 km. break-in
period, the following few simple precautions be carefully observed.
1. It is recommended that speed during the initial 1,000 km be
confined to the following.
Maximum allowable speed in each gear during break-in period.
Gear position
1st
2nd
3rd
4th/5th
Speed (km/h)
25
40
65
100
3
2.
After starting the engine, let it run for about 1 to 2 minutes with idle speed (avoid
acceleration or driving off the vehicle).
3.
Avoid engine racing, abrupt starting and needless hard stops. This will allow your
brakes to bed-in properly.
4
OPERATION AND CARE OF VEHICLE
Every component and system of your vehicle should be checked according to
“CONTROLS AND INSTRUMENTS”, “BEFORE DRIVING YOUR VEHICLE”
and “DRIVING” sections.
MAINTENANCE
In order to maintain safe and dependable vehicle operation, inspection and
adjustment should be performed as outlined in “SERVICE AND
MAINTENANCE”. Your CHEVROLET retailer is willing to perform regular
maintenance operation on your vehicle.
5
QUICK VIEW - CONTROLS AND INSTRUMENTS
1 Side Vent
8 Cigarette Lighter
15 Brake Pedal
2 Center Vent
9 Ashtray
16 Accelerator Pedal
3 Wiper & Washer Control Lever
10 Audio V
17 Hazard Warning Flasher Switch
4 Exterior Lights Control Lever
11 Hood Release
18 Head Lamp Leveling Device
5 Instrument panel
12 Transmission Shift Lever
19 Rear Deffoger Switch
6 Glove Box
13 Steering Wheel and Horn Button
7 Heating and Air Conditioning System 14 Clutch Pedal
6
20 Passenger IP Glove Box
V
STEERING COLUMN CONTROLS
Steering wheel and horn button
The horn button on the steering wheel operates the horn.
CAUTION
Avoid turning the steering wheel while the vehicle is stationary.
NEVER move the vehicle with the steering locked, or damage to the steering
assembly will result.
Starter switch
The switch has five position as shown in the figure.
“LOCK” : The key can be inserted or removed only when the switch is in this
position.
“OFF”
: The engine is shut off in this position.
“ACC”
: In this position, electrical circuits for accessories are on.
“ON”
: This position is for driving.
7
“START” : Turning the key to this position will start the engine.
The key returns to the “ON” position when released.
WARNING
NEVER attempt to turn the switch to LOCK while driving.
This will cause the steering wheel to lock.
If it is difficult to turn the key from LOCK to OFF, turn the steering wheel slightly in
either direction while turning the key.
Combination light control switch
The switch controls the light switch, turn signal switch, dimmer switch, passing
light switch and fog lamp.
OFF
OFF
8
Light switch
To turn on the clearance lights, tail lights, license plate lights, instrument panel
lights, turn the switch knob clockwise. To turn on the headlights and other lights,
turn the switch knob clockwise to definite stop.
OFF
OFF
OFF
OFF
Turn signal switch
Move the switch lever in the direction of the turn to be made so that the signal
lights operate, causing the turn signal indicator light on the instrument panel to
flash. The switch lever returns automatically to the neutral position when the
steering wheel is returned to a straight ahead position (Specific angle
dependent).
When changing lanes, move the turn signal lever part way and hold it there. When
you release the lever, it will return to its normal position.
9
Dimmer switch
The headlight beam is alternately switched from high to low or from low to high
each time the lever is raised. The headlight high beam indicator on the instrument
panel lights up when the headlights are in high beam.
OFF
OFF
CAUTION
Always switch the high beam headlamps to low beam when you approach
oncoming vehicles or when other vehicles are ahead.
OFF
OFF
Passing light switch
The headlight high beam turns on and goes out each time the lever is raised
and released with the light switch in either the “OFF”, or the “1st” stop position.
To signal overtaking, operate the lever repeatedly so that the headlights flash
in daytime, and the high and low beams flash alternately at night.
10
MIST
OFF
INT
LO
HI
Windshield Wipers
To operate the windshield wiper, turn the ignition ON and move the windshield
wiper / washer lever downward. The windshield wipers operate in the following
four position :
MIST
ON
REAR
OFF
OFF
INT
LO
HI
PULL
OFF
INT
LO
HI
:
:
:
:
System off. Default position.
Intermittent operation. Lever down one level.
Continuous wipe, slow speed. Lever down two levels.
Continuous wipe, fast speed. Lever down three levels.
CAUTION
Do not operate the wipers when the windshield is dry. It may scratch the windshield
glass. Check blades are not frozen to windows before operating in cold weather. This
can damage the wiper motor.
Dust on windshield or on blade reduces the wiper blade life significantly and may
cause streak marks on windshield during wiping. In case the vehicle is not used for
more than a week or if dust is accumulated on windshield or wiper, clean the
windshield and blade before using the vehicle. To clean the blade lift the blade to
service position and wipe the lip of rubber element with clean soft cloth.
Mist Function
To operate the windshield wiper once in case of light rain or mist, lightly move the
windshield wiper / washer level towards the MIST position.
The wipers will operate through one cycle.
11
MIST
OFF
INT
ON
REAR
OFF
LO
PULL
HI
Windshield Washer
To spray the washer fluid on the windshield.
Ÿ Turn the Ign. switch ON.
Ÿ Pull the windshield wiper / washer lever towards you.
The lever will return automatically to its normal position when released.
CAUTION
Do not operate the windshield washer continuously for more than 10 seconds, or
when the washer fluid tank is empty. This can cause the washer motor to
overheat resulting in costly repairs.
Rear Wiper and Washer
To operate the rear wiper, turn the rear wiper switch to ON position. To spray the
washer fluid, turn the rear wiper switch to extreme top position. The washer fluid
will spray as long as you hold the rear wiper switch to above mentioned position.
MIST
ON
REAR
OFF
OFF
INT
LO
PULL
HI
12
Windshield washer tank
The tank should be filled only with plain water, GMI genuine washer solution or
equivalent.
In cold weather, do not fill the windshield washer fluid reservoir more than three
quarters full. Washer fluid can freeze and expand in cold temperatures. Filling the
reservoir too much does not allow enough expansion room to prevent possible
damage to the reservoir.
CAUTION
Do not put radiator antifreeze in the windshield washer reservoir. Radiator
antifreeze can damage windshield washer system and vehicle paint.
Insert the lower portion of the cover first while re-fitting
Back door side
W
DO R
WINSHE
WA
13
OFF
6
TE/LOG
Front fog light switch V
Fog lamps provide:
• Extra illumination to the sides of the road ahead.
• Improved visibility in fog or snow.
To turn the fog lamps on:
• Make sure that the parking lamp or headlamps are on.
• Turn the ring on the middle of the combination switch lever to
To turn the fog lamps off, turn the ring to the OFF position.
OFF
position.
INSTRUMENT PANEL AND CONTROLS
FLDR
SCAN/AS
SECURITY
0
Push
2 to
operate
Hazard warning flasher switch
When the switch button is pushed in, all signal lights flash regardless of the turn
signal switch position. To turn off the flashers, push button again.
CAUTION
Use the warning flasher to warn other drivers anytime your vehicle becomes a
traffic hazard, day or night.
14
6
TE/LOG
FLDR
SCAN/AS
SECURITY
0
2 to
Push
operate
Rear window defogger switch V
With the key turned on, push the rear window defogger switch to use the rear
window defroster and defogger. The indicator light will turn on when this switch is
in use. Turn off by pushing the switch again when the rear window is clear.
NOTE
If the switch is left on, the battery may run down.
CAUTION
Do not use sharp instruments or abrasive window cleaners on your vehicle’s back
door glass.
0
Head lamp leveling device
Adjust the headlight beam level with the following switch positions according to
the number of passengers and load conditions:
10 seater
Seating Position
Sr. No.
1.
2.
Vehicle unladen and one person in the driver seat
Vehicle in laden condition
15
Specification
0
4
9 seater
Seating Position
Sr. No.
0
1.
2.
3.
4.
5.
6.
One person in the driver seat
The driver, plus one passenger in the front seat farthest from
the driver
The driver, one passenger in the front seat farthest from the
driver, all the seats farthest to the rear occupied
All the seats occupied
All the seats occupied, plus an evenly distributed load in the
luggage boot, in order to obtain the permissible load.
Driver plus an evenly distributed load in the boot
Specification
0
0
2
3
3
4
8 seater
Seating Position
Sr. No.
1.
2.
3.
4.
5.
6.
One person in the driver seat
The driver, plus one passenger in the front seat farthest from
the driver
The driver, one passenger in the front seat farthest from the
driver, all the seats farthest to the rear occupied
All the seats occupied
All the seats occupied, plus an evenly distributed load in the
luggage boot, in order to obtain the permissible load.
Driver plus an evenly distributed load in the boot
Specification
0
0
2
3
3
4
7 seater
Seating Position
Sr. No.
1.
2.
3.
4.
5.
6.
One person in the driver seat
The driver, plus one passenger in the front seat farthest from
the driver
The driver, one passenger in the front seat farthest from the
driver, all the seats farthest to the rear occupied
All the seats occupied
All the seats occupied, plus an evenly distributed load in the
luggage boot, in order to obtain the permissible load.
Driver plus an evenly distributed load in the boot
Specification
0
0
2
3
3
4
For any other loading condition, adjust the switch to a position so as not to
be dazzle oncoming traffic/other vehicles ahead.
16
METERS AND INDICATOR LIGHTS
16
16
15
15
MIL
MIL
18
17
18
17
1
Temperature gauge
8
Engine tachometer V
2
Turn signal indicator lights
9
Oil pressure indicator light
3
Odometer
10 Generator indicator light
16 Malfunction indicator lamp
4
Speedometer
11 Brake system indicator light
17 Water separator indicator light
5
Fuel gauge
12 Glow plug indicator lamp
18 Low fuel warning lamp
6
Trip counter
13 Door open warning lamp
7
Reset knob
14 High beam indicator light
17
15 Engine coolant temperature
warning lamp
Speedometer
The speedometer indicates the vehicle speed in kilometers per hour (km/h).
Odometer
The odometer registers the accumulated distance in kilometers. The figure on
the extreme right indicates 1 kilometer.
18
Trip counter and reset knob
A reset knob for the trip counter is located on the lower section of the meter. To
reset the trip counter, push the knob in. The trip odometer is used when you want
to know point-to-point distance and running kilometers reached in a certain
period of time. Further, the trip odometer can indicate two kinds of point-to-point
distance. Push the reset knob for approximately one second or less, and the
indication will be changed in order of odometer, trip meter A, trip meter B, and
odometer. Continue to push the knob for approximately one second or more
when the meter (trip A, trip B) is indicated, and the indication will return to 0 (zero).
Temperature gauge
The temperature gauge indicates the temperature of engine coolant when the
starter switch is “ON”. When the gauge needle is within the thick line on the scale
while driving, coolant temperature is normal.
CAUTION
If the gauge indicates overheating condition, stop the vehicle and keep the
engine idling until coolant temperature lowers to a normal level. Do not drive the
vehicle until problem has been solved. Consult your CHEVROLET retailer.
19
Fuel gauge
The fuel gauge indicates the level of fuel within the fuel tank when the starter
switch is “ON”.
The letters “F” and “E” represent “Full” and “Empty” respectively. When the key is
turned to the “OFF” position the needle does not return to the (empty) mark but
remains to indicate the approximate fuel level. Movement of the fuel within the
fuel tank causes the fuel gauge pointer to move when you brake, accelerate or
turn. The indication is not linear and only indicative.
NOTE
When the ignition is switched “ON” fuel gauge needle goes to E level
and then returns to show the fuel level.
Engine tachometer V
The engine tachometer indicates the engine speed in rpm. The red colored zone
represents critical engine speed.
CAUTION
X 1000 r/min
Never operate the vehicle with the tachometer needle in the red zone. Continued
operation with the tachometer needle in the red zone can lead to serious engine
damage.
NOTE
All gauges will self test by deflecting initially when ignition is switched on.
20
Turn signal indicator lights
When the turn signal switch or hazard warning flasher switch is turned on, the turn
signal indicator light flashes to indicate operation of the turn signal lights or hazard
warning lights.
CAUTION
These indicators are required for safe driving. Immediately replace any burned out
bulbs in your turn signal and hazard warning flasher indicators.
High beam indicator light
The high beam indicator light comes on when the high beams are in use.
21
Water separator indicator light D
The water separator indicator light illuminates when the water level in the fuel filter
exceeds a certain level. The accumulated water in the fuel filter should be drained
immediately to avoid damage to the fuel system. The warning light will go off when the
draining is completed.
CAUTION
If water separator requires frequent draining, have the fuel tank drained at your
CHEVROLET retailer.
NOTE
If the light comes on and remains on with the engine running, it indicates the need
for draining of the water separator.
22
Oil pressure indicator light
The oil pressure indicator light comes on when the starter switch is “ON”. The
lamp should go out after engine starts.
CAUTION
If the light comes on while driving, it indicates that the oil pressure is dangerously
low. Stop the engine immediately and check the level of the oil in the engine
crankcase after waiting for few minutes. If the oil level is normal, have the
lubricating system checked at your nearest CHEVROLET retailer. Do not run the
engine with the light illuminated.
Generator indicator light
The generator indicator light comes on when the starter switch is turned
to “ON” and goes off when the engine is started.
NOTE
If the light comes on while driving, have the generator circuit checked at your
nearest CHEVROLET retailer.
23
Brake system indicator light
The brake system indicator light comes on when the parking brake lever is pulled
with the starter switch “ON”, or the brake fluid in the reservoir is lower than the
specified level with the parking brake lever released.
WARNING
If the light turns on while driving, stop the vehicle immediately and check the level
of brake fluid in the reservoir. If the level is too low, have the vehicle towed in for
repairs.
Driving with malfunctioning brakes can lead to collision resulting in personal
injuries and damage to your vehicle and other property.
Low fuel warning lamp
This warning lamp comes on when the fuel tank is low on fuel. Fill up the fuel tank
as soon as possible when warning lamp comes on.
CAUTION
Do not let your vehicle to run out of fuel. This can lead to temporary air trap in fuel
system which will affect your next start after refueling.
24
MIL
Malfunction indicator lamp (MIL)
The MIL illuminates briefly as you turn the ignition ON, before you start the
engine. This means that the indicator bulb is operating properly. The lamp should
go out after the engine is started.
The MIL will illuminate if a fault exists in the emission related components or
related sub systems.
MIL light will stay on as long as the Electronic Control Module (ECM) detects the
fault. Consult a CHEVROLET retailer to repair the problem as soon as possible.
CAUTION
Do not drive with the malfunction indicator lamp on.
The indicator lamp signals that your vehicle has problem that requires attention.
Driving with the malfunction indicator lamp on can damage the emissions control
system and can affect the fuel economy and driveability of your vehicle.
25
Engine coolant temperature warning lamp
This lamp illuminates when the engine coolant gets overheated.
If you have been operating your vehicle under normal driving conditions, you
should pull off the road, stop your vehicle and let the engine idle for a few minutes.
If the lamp does not go out, you should switch the engine off and consult your
CHEVROLET retailer as soon as possible.
Door open warning lamp
Illuminates when a door is open or not securely latched.
26
Glow plug indicator lamp
The glow plug indicator illuminates if there is a temperature and ambient pressure
conditions demand when the ignition is switched ON. Do not crank the engine
when the glow plug indicator is ON to avoid excessive load on battery and to
ensure effective starting.
CAUTION
When the glow plug indicator comes on while driving or the engine cannot be
started properly, you should consult your CHEVROLET retailer to repair the
problem as soon as possible.
Dash panel parking brake V
To set the parking brake, pull the handle as far as possible toward you. To
release, pull the handle slightly toward you, turn the lever counterclockwise, and
then push it all the way forward.
CAUTION
Never drive with the parking brake set as this may overheat or otherwise damage
the parking brake mechanism.
27
(1)
(2)
(3)
Floor mounted parking brake V
The parking brake acts on the rear wheels.
The parking brake lever is located between the front seats.
To set the parking brake, stop the vehicle, press the brake pedal and pull the lever
up firmly.
To release the parking brake, press the brake pedal and;
1. Pull the lever up slightly.
2. Push the button on the tip of the lever.
3. Lower the lever while holding the button in.
CAUTION
Never drive with the parking brake set as this may overheat or otherwise damage
the parking brake mechanism.
Cigarette lighter V
To operate, push the knob in and allow a few seconds for heating. The knob pops
out when heated and ready for use.
NOTE
If the lighter does not spring back after 18 seconds, it is not operating and must
be pulled out to the normal position by hand. Trying to operate a malfunctioning
lighter can be dangerous. Consult you CHEVROLET retailer.
CAUTION
The barrel of an operating cigarette lighter can become very hot. Do not touch the
barrel of the cigarette lighter.
28
Ash tray V
CAUTION
After using the ash tray, push it back in completely. If not, the flame of the
cigarette may cause other cigarette butts to burn, resulting in a fire.
Pull out to use. To clean, remove the tray by pulling it while pushing down the
retainer spring.
APO – Auxiliary Power Output V
The APO is installed on the rear side of the center console.
29
135
1 3 6
2 4 R
N
2 4R
FLOOR CONTROLS
Transmission gearshift lever MT
The transmission gearshift lever controls fully-synchronized transmission. The
gearshift pattern is shown on the lever knob.
NOTE
Allow the vehicle to stop completely before shifting into reverse, no sooner than
three seconds after declutching. The back-up lights operate when shifted into
reverse with the starter switch “ON”.
Accelerator pedal
To avoid unnecessary increase in fuel consumption, the accelerator pedal should
be operated smoothly and reasonably.
30
Brake pedal
Avoid stopping hard by operating the foot brake pedal in a smooth manner. When
descending a slope, it is always advisable to use the foot brake in combination
with the engine braking effect.
WARNING
If the brake pedal can be pressed further than normal, the brakes may be in need
of repairs. Consult your CHEVROLET retailer immediately.
NOTE
Disc brake wear indicators:
Front disc brakes have built-in wear indicators which are designed to make a high
pitched squealing or cricket-like warning sound when the brake lining is worn to
where new linings are needed. The sound will come and go, or be heard all the
time when the wheels are rolling, but may stop when the brake pedal is pushed
down firmly. Extensive damage can result if the linings are not replaced when
needed.
CAUTION
Do not drive with your foot resting on the brake pedal.
Footrest/ Dead pedal:
This is an additional feature for drivers comfort, driver can rest his left foot on the
footrest, If the clutch not in use while driving. The footrest is ergonomically
designed to give maximum comfort to the drivers foot.
31
Clutch pedal MT
The clutch pedal should be fully depressed when disengaging. Not doing so,
may result in grating of the gears.
NOTE
Do not allow your foot to rest on the pedal when not using clutch.
OTHERS
Ventilators
A pair of center air outlets is located in the center part of the instrument panel. The
side air outlets are located at each end of the instrument panel.
32
Center vents
Two center vents are provided on the instrument panel.
The knobs at the center part of the grille controls direction of air flow vertically and
horizontally.
Side vents
A side vent is located at each end of the instrument panel.
The knob at the center part of the grille controls direction of air flow vertically and
horizontally.
33
Dome light V
Front and rear side
The dome light is operative at any starter switch position.
“OFF”
“ON”
OFF
: The light stays off regardless of the door position.
: The light will turn on and stay on regardless of the door position.
ON
When the dome light switch is at center position, the light will turn on while either*
door is opened.
Antenna V
Pull out the antenna to gain sensitivity.
34
Assist grip with coat hook V
Each assist grip is attached to the roof above the side window of assist seat and
rear seat. The grip above the Rear RH side door includes the coat hook.
Additional assist grips* provided on selected variants (10 Seater) to assist
occupants on driving conditions.
CAUTION
Hanging items on your vehicle’s assist grips can obstruct the driver’s view. Do not
hang anything on the assist grips. Obstructing the driver’s view can lead to an
accident resulting in personal injuries and damage to your vehicle and other
property.
Radio Frequency Identification (RFID) Tag *
This vehicle is equipped with Radio Frequency Identification (RFID) tag*, which can
be used for Electronic Toll Collection (ETC) or any other applications as decided by
the Regulatory authority. The RFID tag is located on inside the windshield. Data for
necessary applications will be added by the agency authorized by the Regulatory
authority, from time to time. Take proper care during washing or cleaning of windshield so as to avoid any damage to the RFID tag. In case of any damage or malfunction of RFID tag, or in case of windshield replacement, contact your
CHEVROLET retailer or agency authorized by the Regulatory authority for the installation of new RFID tag.
CAUTION
Do not touch or peel off. Do not place any sticker or other metallic components
over the RFID tag neither from inside nor from outside of the windshield. Avoid
exposure to chemicals or liquid solvents. This will impair the function of RFID tag.
The RFID tag is tamperproof and will not function once removed from windshield.
35
HEATER-DEFROSTER AND AIR CONDITIONING V
5
1
2
3
AC
4
1 Air distribution mode knob
3 Temperature control knob
2 Fan control knob
4 Air conditioning (AC) switch
36
5 Air source select lever
Air distribution mode knob
The knob regulates air flow from the heater, defroster and air conditioning or
ventilating outlets.
1. FACE OUTLET (Air to your face)
2. BI-LEVEL (Air to your face and feet)
3. FOOT OUTLET (Air to your foot)
4. FOOT OUTLET & DEFROSTER (Air to your foot and windshield)
5. DEFROSTER (Air to windshield)
Face outlet
Air is discharged from the upper outlets. This position is used for most air
conditioning situations.
37
BI-level
Air is discharged from the upper air outlets and the floor air outlets.
Foot outlet
Air is delivered from the foot outlet.
38
Foot outlet and defroster
Air is delivered from the foot outlet with a small amount from the defroster outlets
and the side window defroster outlets.
Defroster
Air is delivered from the defroster outlets with a small amount delivered from the
side window defroster outlets. This position is recommended for conditions of
severe fogging and icing only.
OPERATING TIPS - The windshield defrosting and defogging system assist in
providing good visibility through the critical area of the windshield under most
inclement weather conditions. The windshield should be scraped clear, if coated
with ice or snow.
39
To defog glass:
• Set air distribution mode knob to DEFROST. If set to FOOT/DEFROST, air
will be sent to feet simultaneously with defogging. (Since airflow to glass is
decreased, defogging capacity becomes lower than DEFROST.)
To defog glass more quickly:
• Operate A/C* (Turn on the A/C switch).
• Increase airflow (Operate fan control knob).
• Set a higher temperature* (Operate temperature control knob).
NOTE
If air-source selector lever is set to INSIDE AIR, air can be conditioned quickly,
but the glass is easy to fog. Therefore, set the lever to OUTSIDE AIR in the
situation where the glass is foggy.
Air source select lever
The intake of outside air (2) and the circulation of inside air (1) is controlled by
sliding this lever left or right.
NOTE
Circulating only inside air for an extended period of time may cause windshield
clouding. For good ventilation, switch to outside air as soon as possible.
2
1
40
Temperature control knob V
The temperature control knob controls the temperature of the air that comes
through the air vents.
Turn the knob to the blue area to get cool air and to the red area to get warm air .
Max.
Cool
Max.
Hot
NOTE
! Prolonged maximum heating usage may cause window fogging, which may
!
!
!
create poor visibility. Maximum heating should be regulated and be used for a
limited time.
After long hours of parking under the sun, be sure to open the windows and
doors to release the interior heat before starting the air conditioner (A/C).
Prolonged maximum cooling usage may require changing the air
intake/circulation lever to outside air intake to allow fresh air into the cabin.
Sometimes mist may appear to come out of the air vents during air
conditioning cooling operation, this is due to the presence of moist air in the
vehicle. This is normal.
41
Fan control knob V
You may control the rate of airflow coming from the system by turning the fan
speed control knob. Turn the knob clockwise to increase the fan speed and
counterclockwise to decrease the fan speed.
Adjust the fan control knob from step 1 to step 4 as you wish.
NOTE
!
Long-time maximum heating may cause fogged glass and poor visibility ahead.
So, please do not use maximum heating for a long time.
!
After long hours of parking under the blazing sun, be sure to open the windows and
doors to release the interior heat before starting the air conditioner (A/C).
!
Long-time maximum cooling pollutes the room air. Slide the Air intake/circulation
lever to intake outside air or open the windows for ventilation as required.
!
During cooling, the moist air is quickly cooled and it may look like mist from the air
outlet. This is normal.
!
Even when the air conditioner is not used, periodically operate the air conditioner
for several minutes with the engine idling so that the system does not run out of oil.
42
AC
Air conditioning (AC) switch V
Push this switch to operate the air conditioning system. The light-emitting diode in this
switch lights up as the system is operating. To turn off the air conditioning push this
switch in again. Air conditioning will not operate without the fan control knob in one of
ON position.
43
WHEN REMOVING FROST AND FOG FROM THE FRONT AND SIDE
GLASSES
Turn the Air distribution mode knob to the "DEFROSTING" position.
NOTE
When operating the air conditioner with the Air distribution mode knob set to the
"DEFROSTING" position, do not set the air conditioner to the "MAXIMUM
COOLING" position. Otherwise the outside of the glass could fog and cause poor
visibility ahead.
QUICK DEFROSTING MEASURE
Turn the temperature control knob clockwise until it stops. Turn the Air
distribution mode knob to the "DEFROSTING" position. Slide the Air
intake/circulation changeover lever to circulate air.
NOTE
Continuous defrosting operation in the circulation status may cause fogged glass
and poor visibility. On completion of defrosting, be sure to change to the air intake
status.
44
Rear cooler control lever V
By sliding this lever, cool air is delivered from the cooler outlets, when the AC &
Blower switch is in ON position. Air flow can be controlled in 3 steps.
NOTE
The rear cooler operates only when the front cooler is in operation. The switch is
located on the center of duct.
Rear cooler vent V
Rear cooler delivers air from the vents at the ceiling.
The knob at the center part of the grille controls direction of air flow vertically and
horizontally.
45
Sun Visors
Your vehicle is equipped with sun visors to protect the driver and passenger* from
glare.
You can swing the sun visors up and down, and to the side.
Vanity Mirror V
The vanity mirror has been provided on the back of co-driver sun visor.
46
ON
AUTO
OFF
Power window V
Windows on either side of the vehicle can be opened or closed with the switch at
the driver’s side. The windows operate only when the starter switch is “ON”.
To open any of the passenger’s windows, push down on the switch and hold it
down until the window reaches the desired position.
To close the window, pull back on the switch. Release the switch when the
window reaches to the position you want.
AUTO* - To open the driver’s window fully, push the switch firmly down till a click
is heard and release it.
When the lock switch of driver’s side is in “ON” position the passengers' window
control switch can not be operated even from driver's side. Press the lock switch
once again, and the power window will be unlocked.
The window on the passenger side can also be controlled with the switch on the
passenger side.
47
WARNING
•
To assure the safety of children and others, make sure that all passengers
have their hands, etc. inside the vehicle before opening and closing the
windows.
•
Remove the key when leaving the vehicle to avoid unintentional window
operation by children.
•
Make sure the door lock switch is in the “ON” position (depressed) when
children are in the vehicle.
Regulator handle V
Turn the window regulator handle to raise or lower the door window.
WARNING
Unattended vehicle with open windows can assist car crime. Close all windows
when leaving vehicle.
48
Glove compartment
The glove compartment is located on the passenger's side end of the instrument
panel.
To lock
: Insert the key and turn it clockwise 90 degrees.
To open : Insert the key and turn it counterclockwise 90 degrees. If the glove
compartment is not locked (simply closed), it can be opened by pulling
the handle.
CAUTION
In the case of a collision or a sudden stop, an open glove box presents a hazard.
Do not drive with glove box open.
49
Spare wheel hanger
The spare wheel is secured to the rear part of the chassis frame by chain. To
lower the spare wheel, open the back door and take out the plug. Then insert the
handle into the hole in the rear face of the vehicle to engage the catch and turn
the handle counterclockwise. To raise, turn the handle clockwise until it stops,
then give an additional turn to securely hold the spare wheel in position.
Please see “In case of emergency” about tool location.
50
External lights
Front side
1 Headlights and clearance lights
2 Front turn signal lights
3 Fog lights V
Rear side
1 Turn signal lights
2 Back up lights
3 Tail and stop lights
4 Reflector
51
Tilt Quarter Window V
1. Pull the handle inward to unlock the window.
2. Push the handle outwards to open the window.
3. To hold the window in the open position,
secure the handle in lock position by pushing it
in the direction as shown.
4. For closing the window, un secure the handle
and pull the handle inwards to close the window.
5. To lock the window in closed position, press the
handle till the click sound is heard.
52
Engine hood release lever
To raise the engine hood, unlock the hood lock by pulling the release lever under
the instrument panel on the driver's side and unlock the safety catch under the
engine hood. Raise the hood all the way up.
To make the hood stay in position, be sure the support rod end engages in the
hole in the hood reinforcement. To close, remove the support rod end from the
hole in the hood reinforcement and put the support rod back into the clip on the
deflector panel. Then lower the engine hood, allowing it to drop from a height.
Make sure the hood is locked firmly in place.
WARNING
Pull on the front edge of the hood to make sure it is latched securely before you
drive your vehicle.
Do not pull the hood release handle while your vehicle is moving.
Do not move your vehicle with the hood open. An open hood will obscure the
driver’s vision.
53
Fuel tank filler cap
The vehicle is equipped with a fuel door release mechanism.
Pull up on fuel filler door release lever located on the floor, right front side of
driver’s seat. Turn the fuel filler cap counter clockwise to open the fuel filler cap.
To close the filler cap, turn clockwise until a clicking sound is heard (at least 3
clicks)
NOTE
Diesel engine:
Use diesel fuel at 48 cetane rating or higher.
Open
54
BEFORE DRIVING YOUR VEHICLE
OPERATION OF CONTROLS
Key
Two keys are provided with your new CHEVROLET. The key number is stamped
on the key number plate. Record the key number and keep it in a safe place such
as your wallet.
NOT IN THE VEHICLE.
NOTE
In the event the master keys are lost, duplicates can be made by your
CHEVROLET retailer using the key code information.
Lift to open
Outside door handle/Door lock (outside)
The door can be opened by pulling the outside door handle.
It can be locked by inserting the starter key in the door lock and turning it.
Unlock
Lock
NOTE
Be careful not to lock your keys in the vehicle.
55
Inside door handle/Door lock (inside)
The door can be opened by pulling the inside door lock lever.
Lock
The door can be locked by pushing in the door lock knob after closing it.
NOTE
Before driving, be sure that the doors are closed and locked, especially when
young children are in the vehicle.
Unlock
Power door locks V
Power door locks on all vehicle doors can be controlled from the driver's seat with
the door lock knob. This knob operates independently of the starter switch
position.
Locking and unlocking the power lock doors from the outside
Unlock
Lock
Insert the key in the driver's door key cylinder. Turn the key clockwise to lock all
the doors and counterclockwise to unlock them.
56
Locking and unlocking the power lock doors from the inside
Push the driver's side door lock to lock all the vehicle doors and pull to unlock
Lock
them.
Individual door locks can also be locked or unlocked by the passengers' side.
Unlock
Back door
Lift to open
Unlock
The back door can be opened by pulling the outside door handle.
Door can be locked by inserting the starter key into the back door and turning it.
Lock
57
Back door inner handle V
The back door can be opened by pulling the back door inner handle.
Back door lock (Inside) V
The back door can be locked by pushing in the door lock knob after closing it.
Lock
NOTE
Before driving, make sure that the door is closed and locked, especially when young
children are in the vehicle.
Unlock
58
Child-proof door locks
Rear doors can be locked by closing the door with the child-proof lever pushed
towards arrow. Rear doors can not be opened from inside regardless of the
position of the lock button.
L
O
C
K
To unlock the child-proof lock, open the door from the outside and slide lever
away from the arrow.
Driver's seat
Seat adjuster
The driver's seat can be moved forward or backward for your comfort.
Pull the seat adjuster at the front lower part of the seat upward, so that the seat can
be moved forward or backward as desired.
After adjusting the seat position, push the seat forward and backward to make sure
the seat adjuster has latched.
WARNING
Do not adjust the driver's seat while the vehicle is moving.
The movement of the seat could cause the driver to lose control of the vehicle.
59
Captain seat's with arm rest - Front and second row seat's only V
Seat slide adjustment V
To move the seat forward or backward :
1.
Pull up and hold the lever located under the front lower part of the seat.
2.
Slide the seat to the desired position.
3.
Release the lever.
Seat reclining adjustment
To tilt seat back or forward, lift the adjust lever on the door side of the seat cushion
until seat back is adjusted to the desired position.
Seat lumbar support
To adjust the seat lumbar support, turn the lever on the door side of the seatback
up or down until the desired support is achieved.
60
Seat back
Front seat back inclination angle can be adjusted by raising the adjust lever on
door side of seat.
WARNING
• To reduce the risk of injury and to ensure maximum seat belt effectiveness
during a collision or a sudden stop, the seat should not be reclined any more
than needed for comfort. The seatback and seat belts work best only when the
occupant is sitting well back and straight up in seat. If the seat is reclined, you
may slide under the lap belt, causing force to be applied to your abdomen, or
you may not be fully restrained, depending on the nature of the accident,
increasing the likelihood of injuries.
• Do not adjust the driver's seatback while the vehicle is in motion. The seatback
could move unexpectedly and cause the driver to lose control of the vehicle.
61
Head restraint V
Height adjustment
The head restraints are adjusted for height. You need both hands to adjust the
restraint. Press the release button and move the restraint up and down, so that
your head is nearly centered on the head restraint.
LOCK
WARNING
• Do not attempt to adjust the driver's head restraint while the vehicle is in motion,
because it could cause a loss of control of the vehicle.
• Do not operate the vehicle with the head restraint removed, since it will increase
the risk of neck injury in the event of an accident.
62
Folding type second seat V
Folding the second seat
The second seat can be folded forward to provide additional luggage space.
1. Pull any of the lever upward on the either side of backrest and fold the seat back
forward.
2. Lift the entire seat and push it forward.
63
Folding type second seat V
Unfolding the second seat
1. Lift the entire seat. Some variants require pulling of lever as illustrated.
2. Raise the seat back.
CAUTION
Ensure that the latch area is clear of any objects.
Center armrest V
The center armrest can be pulled out when there are only 1 or 2 second row seat
passenger.
64
Folding type jump seat V
Folding the jump seat
1. Tilt seat cushion (1) upward.
2. Tilt seat trigger (2) downward.
3. Secure the seat lock strap (3) to the seat back mounted hook.
Unfolding the jump seat
1. Raise the seat trigger (2).
2. Release the seat lock strap (1) from the hook and fix the strap to the seat
cushion.
3. Lower the seat cushion (3).
65
Folding type third seat V
Folding the third seat
The third seat can be folded forward to provide additional luggage space.
1. Press the head rest sleeve knob to push the head rest down.
2. Pull the Strap (Black colour) down provide on the rear side of the back seat.
3. Fold the seat back rest forward.
66
4. Pull the seat latch lever towards your side to detach the seat latch.
5. Lift the entire seat with rod and push the seat assembly forward.
CAUTION
Do not use seat latch lever to lift the seat.
67
6.
Attach the band (with hook) provided below the third seat to clasp on to the
head rest of the second seat back.
Removing the third seat V
To remove the seat assembly, rotate the wheel knob in anti clockwise direction
and pull the seat out.
The seat an be put back and tighten with the wheel knob in clockwise direction.
68
Folding type third seat V
Unfolding the third seat
1. Remove the clasping band from the headrest rod of the second seat back.
2. Lower the third seat, then raise the seat back.
3. Drop the seat assembly from height of about 200mm with backrest straight.
4. Confirm proper locking of the seat latch and push the latch lever inside.
CAUTION
Ensure that the latch area is clear of any objects.
200 mm
69
Front seat and rear seat lap/shoulder belts
The front seat is equipped with a 3-point seat belt which features one buckle for
the lap and shoulder belt.
How to use the belt system properly in your vehicle is as follows:
1. Adjust the front seat as needed and sit straight up and well back in the seat.
2. Take hold of the seat belt latch plate (L) and pull the lap/shoulder belt across
the body, and slide the latch plate along the belt until it reaches the buckle
(B). Push the latch plate into the buckle until it clicks.
WARNING
A low, and snug position is essential in order that force exerted by the lap belt
in a collision will be spread over the strong hip bone structure and not across
the abdominal area, which in an accident could result in serious injury.
(Continued)
70
(Continued)
Position the lap portion of the belt across the lap by the hips as low as possible.
Then adjust to a snug fit by holding the shoulder portion of the front seat belt and
pulling it upward through the latch plate, until the lap portion is snug across the
lap. This reduces the risk of sliding under the belt during an accident.
WARNING
To lessen the chance of injury in the event of an accident, never use the same belt
for more than one person at a time and make sure to avoid twisting the belts.
Avoid getting the belt pinched between the seat structural (metallic) members or
in the door.
(Continued)
71
(Continued)
The shoulder portion of the front seat belt has an “Emergency locking retractor”
which is designed to lock during a sudden stop or impact. At other times, it is
designed to move freely with the seat occupant. To unfasten the belts, push in the
center of the buckle.
When not in use, seat belts can be stowed by letting them rewound in their
retractors. If needed, move the keeper along the belt to let the belt retract fully.
This will also put the latch plate within easy reach on the door pillar.
Lap belts
Bring the latch plate adjuster across your body and clip it into the buckle. When this is
done correctly you will hear a “click”.
Adjust the belt length by pulling the belt end. Make sure the belts are fitted firmly
across your waist.
72
Seat belt inspection and care
• Periodically inspect belts, buckles, latch plates, retractors, and anchors for
damage that could lessen the effectiveness of the restraint system.
• Keep sharp edges and damaging objects away from belts.
• Replace belts if cut, weakened, frayed, or subjected to collision loads.
• Check that anchor mounting bolts are tightly fastened to the floor.
• Have questionable parts replaced.
• Keep seat belts clean and dry.
• Clean only with mild soap solution and lukewarm water.
• Do not bleach or dye belts since this may weaken belts.
Mirrors
Inside rearview mirror
To adjust move the mirror right or left and up or down.
73
Inside rearview mirror: day and night V
To adjust, move the mirror right or left and up or down.
Switch the mirror to the night operation position to reduce the glare from following
headlights.
Outside rearview mirror
Adjust the outside rear view mirrors so that you can see the each side of your
vehicle in the portion of the mirror closest to your vehicle. This helps you to
determine your position relative to objects seen in the mirror.
74
DRIVER'S CHECK LIST
(REGULAR INSPECTION)
The following checks should be performed to maintain safe and dependable
vehicle operation. If any abnormal condition of the vehicle is found, consult your
nearest CHEVROLET retailer.
NOTE
Refer to “MAINTENANCE GUIDE” for proper check-up procedures.
Exterior
1. Check tires for inflation pressure and damage.
75
2. Check wheel nuts for looseness.
Wheel nut torque: 118N·m
3. Check chassis springs for damage.
76
4. Check operation of lights.
5. Check level of electrolyte in each cell of the battery.
Not required in vehicles fitted with maintenance free batteries.
6. Check for any oil, water, fuel and brake fluid leakage.
77
7. Check the setting angle of the rearview mirrors.
8. Check operation of the door locking mechanism.
Lock
Unlock
78
9. Check clutch pedal free play, height and function.
Within engine compartment
1. Check engine oil level.
79
2. Check that the level of the power steering fluid is within “MAX” and “MIN”
level. PS
3. Check the tension of the power steering / fan drive belt.
80
4. Check that the level of the windshield washer solution in reservoir tank is
within “MAX” and “MIN” level.
Back door side
W
DO R
WINSHE
WA
81
5. Check that the level of the engine coolant in reservoir tank is within “MAX”
and “MIN” level.
WARNING
Coolant level check or replenishment should be made at the reservoir tank and the
coolant pressure cap should not be removed unless necessary.
6. Check that the level of brake and clutch (MT) fluid in the reservoir is within
“MAX” and “MIN” level.
82
After starting engine
1. With the engine running, check that oil pressure indicator light, generator
indicator light, water separator indicator light, malfunction indicator light and
glow plug indicator light go off and remain off .
MIL
2. Check brake pedal free play, height and function.
83
3. Check for abnormal engine noise and color of exhaust gases.
84
DRIVING
Proper care and operation will not only extend the life of your vehicle but also improve oil and fuel economy
PREPARATION FOR STARTING ENGINE
1.
Set the parking brake firmly.
2.
Place the transmission in neutral.
STARTING ENGINE
1.
Turn the key to "ON." See if the oil pressure indicator light, generator
indicator light, brake system indicator light, water separator indicator light
and malfunction indicator light comes on.
CAUTION
Do not leave the key in the ACC or ON position for extended periods while the engine
is not running . This will discharge the battery.
Do not turn the key to OFF or LOCK position while driving. Driver could lose control of
vehicle and brake power assistance would be cancelled, causing vehicle damage,
personal injury or possibly death.
85
2. Crank up the engine by turning the starter switch key fully clockwise. Release
the key as soon as the engine starts. The key will return automatically to
"ON."
CAUTION
Do not keep the starter engaged for more than 30 seconds at a time. If the starter
is operated repeatedly, but the engine does not start, check the fuel system and
electrical system. During repeated cranking, it is absolutely necessary to have
brief periods of recovery time (about 30 seconds) to conserve the battery.
3. After starting the engine, let it run for about 1 to 2 minutes with idle speed
(avoid acceleration or driving off the vehicle) . This allows oil to circulate and
lubricate the turbocharger. Then depress the accelerator pedal part way
down.
NOTE
At low ambient temperature or when the vehicle has not been used for a long period,
normal engine oil pressure and flow is affected. Under these conditions the engine
should be started and allowed to idle for a few minutes before operating at higher rpm.
86
BEFORE DRIVING OFF
Lock
1.
Lock the doors.
2. Adjust the seat position.
87
3. Adjust the inside and outside mirrors.
4.
Fasten the seat belt.
88
STOPPING ENGINE
Turn the starter switch to the “ACC” or “OFF” position.
Your vehicle is powered by a turbo diesel engine. Before turning the engine OFF,
allow the engine to run for about 1 to 2 minutes at idle speed.
PARKING
When leaving your vehicle unattended:
l
1 3 5
2 4R
l
1
N
l
R
Set the parking brake.
When parking a vehicle equipped with a manual transmission on an
upward slope, place the shift lever in the “1st” position.
When parking a vehicle equipped with a manual transmission on a
downward slope, place the shift lever in the “R” (Reverse) position.
l
Turn the ignition switch to the “LOCK” position.
l
Remove the key.
l
Close all windows and lock all doors.
l
Check to make certain lights are turned off.
89
WARNING
Do not park your vehicle over combustible materials, such as dry grass or leaves.
They could touch the hot exhaust system and ignite.
CAUTION
Do not leave your vehicle unattended with the engine running. If the engine might
overheat, you would not be there to react to the temperature warning light or gauge.
This could result in costly damage to your vehicle and its contents.
DRIVING PRECAUTIONS
1. Avoid over-running the engine.
When descending a slope pay close attention to prevent engine overrunning, particularly when down shifting, as the engine becomes liable to
over-run.
90
2. If abnormal noise or smell becomes noticeable while driving, stop the engine
and check to locate the cause of trouble.
3. If the indicator lights or instruments give an indication of abnormal condition
while driving, stop the engine and check to locate the cause of trouble.
91
4. Avoid needless hard acceleration and hard stops.
5. Do not drive with your foot resting on the clutch pedal as it produces a partly
disengaged condition, causing premature wear of clutch facing.
92
6. Allow the vehicle to stop completely before shifting to reverse or to first gear
after reversing.
When starting the vehicle from rest, it is always advisable to use 1st gear not
only on slopes but also paved roads.
7. When climbing a slope, shift to a lower gear to relieve the engine from
overload before engine begins to strain.
93
8. When descending a slope, shift to a lower gear to gain retardation effect of
the engine.
9. Repeated use of the foot brake on a long downgrade will cause the brakes
to lose their effectiveness.
94
10. When driving across a shallow river or patch of water, extreme care must be
exercised or water may enter the air duct causing serious engine damage.
After driving across water, check gear oil in rear axle, and transmission case
for presence of water. If any water is present, drain and refill with the specified
oil.
11. Drive carefully after running in heavy rain or driving across a shallow river as
wet brakes cause temporary reduction in brake force.
95
12. Front disk brake wear indicators
The brakes are provided with wear indicator device which produces a
metallic frictional sound (squeal) while driving when the brake pads or linings
have worn down near to the serviceable limit.
If such a sound is produced, have the brake pads or linings replaced at your
CHEVROLET retailer.
DRIVING FOR ECONOMY MT
1. Needless high-speed driving and slow driving in high gears will result in
excessive fuel consumption.
96
2. After accelerating, shift to a higher gear and engage the clutch smoothly.
3. After shifting to top or overdrive, maintain your speed constant as possible.
97
4. Always drive with the coolant temperature within the normal
range.
5. Under-inflated tires cause deterioration in fuel economy.
98
IN CASE OF EMERGENCY
Emergency stop
1. If you must stop your vehicle on the road for some reason, pull your vehicle
over to the left side of the road as far as possible and try not to park in a driving
lane.
2. Make certain to apply the parking brake and use hazard warning lights, day or
night.
99
Emergency starting
WARNING
Never tow the vehicle to start the engine because when the engine starts it could
cause a collision with the towing vehicle.
WARNING
Exercise extreme care when handling the battery to avoid serious personal injury
and damage to your vehicle which might result from battery explosion, acid
burns, electrical burns, or damaged electric components.
Start the engine using the battery of the other vehicle through the booster cable,
following the next steps:
1.
2.
3.
Make sure that the other vehicle uses the same voltage (12V).
Connect the booster cable as shown in the illustration.
Start the engine on the other vehicle.
100
4.
5.
Increase the idling speed of the engine on the other vehicle a little and start
the engine on the damaged vehicle.
If the engine starts, disconnect the cable following the above procedure in
reverse.
CAUTION
Never connect the cable between the positive and negative terminals.
Do not remove the battery cables from the terminals while the engine is running. It
may result in troubles in the electrical system.
Power brake system
* If the power assist is lost because of a stalled engine or other reasons, the
brakes can normally still be applied with the power assist at least one time
by using reserve vacuum.
* The system is designed to bring the vehicle to a full stop on reserve
vacuum if the brake pedal is applied once and held down. However, the
reserve vacuum is partly used up each time the brake pedal is applied and
released.
(Continued)
101
WARNING
Do not pump the brakes when the power assist has been lost, except when
necessary to maintain steering control on slippery surfaces.
*
Without the power assist, the vehicle can still be stopped by pushing harder
on the brake pedal. However, the stopping distance may be longer, even
though the brakes themselves remain fully operational.
Towing
Proper equipment must be used to prevent damage to vehicles during any
towing. When towing, the driveline, axle, transmission and steering system must
be in operating condition. Use only towing equipment specifically designed for
this purpose, following the instructions of the equipment manufacturer. A
separate safety chain must be used. For towing the vehicle, the parking brake
must be released, the transmission placed in neutral and the key turned to the
“OFF” position. Attachment must be made to the front tow hook only.
CAUTION
Do not attach to bumpers or associated brackets. Remember that the power
brake assist will not be available when the engine is inoperative.
102
Front wheels off the ground
1. Transmission in Neutral.
2. Maximum speed: 60km/h.
3. Maximum distance: 80km.
NOTE
For distances over 80km disconnect the rear propeller shaft at rear axle carrier
and secure it in a safe position.
Rear wheels off the ground
1. Transmission in Neutral.
2. Maximum speed: 60 km/h.
3. Maximum distance: 80 km.
NOTE
!
!
When towing a vehicle in this position, the steering wheel should be secured
to keep the front wheels in a straight ahead position.
The starter key must be in the OFF position.
All four wheels on ground
1. Transmission in Neutral.
2. Maximum speed: 60 km/h.
3. Maximum distance: 80 km.
NOTE
For distances or speeds greater than the above, disconnect the rear propeller
shaft at rear axle carrier and secure it in a safe position.
103
Bleeding of fuel system
If the fuel tank is emptied, air might be allowed to go into the fuel system. With air
in the fuel system, smooth flow of fuel into the engine is interrupted. To prevent
this, bleed the fuel system.
1. Refill the fuel tank with diesel.
2. Switch ON the ignition 3 times for 30 seconds.
3. Operate the hand pump on the water separator if required to bleed the fuel
system air into the injection pump.
4. Start the engine with starter switch, when the bleeding has been finished.
5. If the engine failed to start, seek the assistance from CHEVROLET retailer.
Draining of Water Separator
When the water separator indicator light in the instrument panel is continuously
ON, take your vehicle to the CHEVROLET retailer for draining the water in the
separator.
WARNING
Engine high pressure fuel system will get damaged severely, If water from the
water separator is not drained on time.
CAUTION
If water separator requires frequent draining, have the fuel tank drained at your
CHEVROLET retailer.
104
Jacking instructions and changing a flat tire
Vehicle front side
The common tool and jack (1) are stored under the front passenger seat.
The jack bar (2) is stored under the 2nd row seat assembly on selected variants.
1
2
Jack Bar storage (on selected variants) V
Insert the Jack Bar in velcro pocket given on left side of cushion of 3rd row front
facing seat.
Fix the Jack Bar by remaining velcro pockets given on center and right side of
cushion of 3rd row front facing seat.
Velcro pocket
Jack Bar
105
SCISSOR TYPE JACK ASSEMBLY
Jack
Store the jack and common tool in toolkit bag and securely strap them under the
front passenger seat.
CAUTION
Do not store jack, spare tyre or other equipment other than specified location. In
sudden stop or collision, loose equipment can be thrown around inside your
vehicle and cause personal injuries.
Preparation
1. Park on a level surface and set the parking brake firmly.
2. Set the transmission to “REVERSE”.
3. Turn the hazard indicator lights on.
4. Turn off the ignition.
5. Block the wheel diagonally opposite the jacking position.
6. Loosen but do not remove wheel nuts.
NOTE
The wheel nuts on the wheels have right-hand threads.
106
7. Place the jack at correct jacking point.
Front : Concave position on bottom surface of attachment bracket under the side
frame.
Rear: Under the Rear Axle Tube.
107
WARNING
Do not jack up the vehicle on a slope or a soft ground. It is very dangerous. Do not
jack up on any points other than specified jack points.
!
Never use a jack designed for another vehicle to lift your vehicle, or use your
jack to lift another vehicle.
!
!
!
!
Never get beneath the vehicle when it is only supported by the jack.
Do not start or run the engine while the vehicle is only supported by the jack.
All passengers should be out of the vehicle when it is being jacked.
Use only for lifting your vehicle when changing a wheel or binding / unbinding
a tire with a chain.
Wheel replacement
1. Jack up the wheel, remove the wheel nuts, then install the spare wheel.
108
2. Install and semi-tighten the wheel nuts and lower the wheel to the ground.
3. With the wheel wrench, tighten the wheel nuts in sequence as shown in the
figure.
Wheel nut torque: 118N·m (12 kgf-m/87 ib-ft)
WARNING
Make sure to use proper nuts or bolts tightened to the proper torque. Using
incorrect parts or improperly tightened wheel nuts or bolts can cause wheel to
come off the vehicle.
109
SERVICE AND MAINTENANCE
In order to maintain safety and economical operation, it is suggested that periodic inspection and maintenance be performed
regularly according to the recommendations outlined in this section.
MAINTENANCE SCHEDULE
To ensure driving safety and maximum economical operation, periodic inspection and maintenance should be performed at
your CHEVROLET retailer according to the maintenance schedule.
For service operations which call for disassembly or specialized instruments, contact your CHEVROLET retailer.
Maintenance operations
I : Inspect and correct or replace as necessary
A : Adjust
R : Replace or change
T : Tighten to specified torque
L : Lubricate
When performing checks on the following items, regular inspection items should also be checked.
* Marks : Under severe driving conditions, more frequent maintenance is required. Refer to “Maintenance schedule under
severe driving conditions”.
CAUTION
Chevrolet recommends to consult authorized CHEVROLET retailer for instructions and vehicle health check-up before
setting out a long journey.
ADDITIONAL OPERATIONS
The time allowance for additional operations, such as wheel alignment, tyre balancing, hub bearing greasing are not included
in the standard scope of service labour and are charged separately. It is nevertheless advisable to have such work done as a
part of service check/inspection, since the time allowance are not high as would be if the work was carried out separately.
110
Maintenance schedule
I: Inspect and correct or replace as necessary
A: Adjust
R: Replace or change
T: Tighten to specified torque
L: Lubricate
x 1,000 km
SERVICE INTERVAL:
(Use odometer reading or months, whichever comes first)
102 108 114 120
Power steering / Fan belt
Alternator / AC belt
Timing belt tension (Front & Rear)
Timing belt (Front & Rear)
*Air cleaner element
Fuel filters
Replace every 60,000 Kms or 2 years whichever is earlier
Inspect every 5000 kms or 6 months whichever comes first or when **service
indicator shows red band. Replace every 40000 kms or 2 years whichever comes
first or when **service indicator shows red band even after cleaning the element.
R
R
* Under severe conditions, additional maintenance is required.
**Service indicator working properly.
Refer to "Maintenance schedule under severe conditions"
111
R
R
R
R
R
R
R
R
Maintenance schedule
I: Inspect and correct or replace as necessary
R: Replace or change
A: Adjust
T: Tighten to specified torque
x 1,000 km
(Use odometer reading or months, whichever comes first)
L: Lubricate
102 108 114 120
* Under severe conditions, additional maintenance is required
Refer to "Maintenance schedule under severe conditions"
112
102 108 114 120
113
Maintenance schedule
I: Inspect and correct or replace as necessary
R: Replace or change
A: Adjust
T: Tighten to specified torque
x 1,000 km
SERVICE INTERVAL:
(Use odometer reading or months, whichever comes first)
L: Lubricate
102 108 114 120
* Under severe conditions, additional maintenance is required
Refer to "Maintenance schedule under severe conditions"
114
Maintenance schedule
I: Inspect and correct or replace as necessary
A: Adjust
R: Replace or change
T: Tighten to specified torque
x 1,000 km
SERVICE INTERVAL:
(Use odometer reading or months, whichever comes first)
Wheel Alignment and Wheel Balancing
L: Lubricate
102108 114 120
As and when required or as suggested by CHEVROLET retailer
* Under severe conditions, additional maintenance is required Refer to "Maintenance schedule under severe conditions"
115
Maintenance schedule under severe driving conditions
Severe driving conditions
A:
B:
C:
D:
Repeated short trips
Driving on rough roads
Driving on dusty roads
Driving in extremely cold weather and/or on salted roads
Item
Interval
Engine oil
Engine oil filter
Change every 5,000 km
Replace every 5,000 km
Exhaust pipes and mounting
Inspect every 5,000 km
Air cleaner element
Inspect every 3000 kms or 6 months whichever comes
first or when **service indicator shows red band.
Replace every 20000 kms or when **service indicator
shows red band even after cleaning the element.
Steering system for looseness or damage
Inspect every 5,000 km
Universal joints and sleeves
Inspect for wear and lubricate every 5,000 km
Transmission oil
Change every 20,000 km after changing at
initial 10,000 km
Differential oil
Change every 20, 000 km after changing at initial
10,000 km
Front brake pads and discs
Inspect every 5,000 km
Rear brake lining and drum wear
Inspect every 5,000 km
116
Condition
A
B
C
D
A+D
MAINTENANCE GUIDE
REGULAR INSPECTION
Engine oil level
Pull out the level gauge rod (oil dipstick).
Wipe clean it and reinsert.
Again pull it out and check that oil level is within high and low level marks. Also
check the oil on the gauge rod for contamination.
NOTE
Engine oil level should be checked with the vehicle parked on level ground
(before the operation of engine).
If the engine is running, stop the engine and allow 15 minutes for the oil to settle
down before checking the oil level.
CAUTION
Do not overfill engine oil on turbo charged engine. Keep engine oil level between
Max. and Minimum. Excessive overfill causes serious damage on the engine. Do
not dispose off used engine oil and filter with your household waste. Use your
local, authorized waste management facility. Used engine oil and filter contain
harmful elements that may be unhealthy to you and threat to the environment.
117
Engine Exhaust
Engine exhaust gases contain carbon monoxide (CO) which is colourless and
odourless. Prolonged exposure to CO can lead to unconsciousness and death.
Whenever you suspect that exhaust gases are entering the vehicle, immediately
take your vehicle to your CHEVROLET retailer.
WARNING
To protect against CO entering the vehicle, inspect the exhaust system and body
according to the following recommendations :
Ÿ At each oil change.
Ÿ Whenever you notice a change in sound of exhaust system.
Ÿ If exhaust system, underbody or rear of vehicle is damaged or becomes
corroded.
Ÿ Do not run the engine in confined or closed areas, such as garages. Move
vehicle to an open area.
118
Catalytic Converter
The catalytic converter reduces the amount of harmful substances in the exhaust
gas.
The catalytic converter requires the use of ultra low sulfur diesel only. Usage of
high sulfur diesel will damage the converter. Under Normal operating conditions,
the converter will not require maintenance. However, it is important to keep the
engine properly tuned to ensure proper operation and prevent possible converter
damage.
In the event of misfiring, uneven engine running, a reduction in engine
performance or other unusual problem, have the cause of the fault rectified by a
CHEVROLET retailer as soon as possible. In an emergency, driving can be
continued for a short period, keeping vehicle speed and engine speed low.
CAUTION
Damage to the converter can result if your vehicle is not kept in proper operating
condition. In the event of engine malfunction, particularly involving engine misfire
or loss of performance, have your vehicle serviced promptly. Continued operation
of your vehicle with a severe malfunction could cause the converter to overheat,
resulting in possible damage to the converter and vehicle.
Unburnt fuel will overheat and damage the catalytic converter. Therefore avoid
excessive use of starter, running the fuel tank dry and starting the engine by
pushing or towing.
119
Power steering / Fan drive belt
Check that the tension of Power steering / Fan drive belt is in the below specified
range when measured at the middle part of the belt.
Power steering / Fan belt : 110Hz - 144Hz.
Non Power steering / Fan belt : 140Hz - 198Hz.
Also check the belt for cracks and damage.
CAUTION
Do not leave the key in the ignition while checking the drive belts. Moving parts of
an operating engine can cause serious injuries.
120
Coolant level
WARNING
When the coolant is heated to a high temperature, be sure not to loosen or
remove the coolant pressure cap. Otherwise you might get scalded by hot
vapor or boiling water. To open the coolant pressure cap, put a piece of thick
cloth on the cap and loosen the cap slowly to reduce the pressure or when the
coolant has become cooler.
Check the level of the coolant and replenish the coolant reservoir tank as
necessary. If the level of coolant in the coolant reservoir tank is found to be
lower than the “MIN” line, check the cooling system for leaks, then replenish
to bring the level up to the “MAX” line.
CAUTION
Do not overfill the coolant reservoir tank. The coolant pressure cap should not be
removed unless necessary. The coolant level should be checked when the engine is
cold. Supplement inhibitors or additives claiming to provide increase in cooling
capability that have not been specifically approved by GMI are not recommended for
addition to the cooling system. Coolant can be hazardous material. Avoid repeated or
prolonged contact with coolant. Clean your skin and nails with soap and water after
coming in contact with coolant. Keep out of reach of children. Coolant can irritate the
skin and can cause illness or death if swallowed.
NOTE
!
Water draining from the air conditioning is normal when it is in use.
121
Steering wheel
Check the steering parts for excessive play and looseness. The standard steering
wheel play is about 10 to 30 mm. (0.4 to 1.2 in). Also check the steering for
abnormal conditions such as shimmy, pull to one side, hard-steering, etc.
NOTE
If the steering parts have excess play or looseness or if any abnormal condition is
noted, have your CHEVROLET retailer check the steering system immediately.
Parking brake lever travel
Dash panel parking brake lever travel must be 8 to 12 notches (When pulled with a
force of 30 kg.)
For floor mounted parking brake, lever travel must be 7~10 notches, with a force of
approximately 20 kgf.
122
Brake and clutch (MT) fluid level
Check that the brake and clutch fluid reservoir is filled up to the level mark. If the
level is too low, replenish with the recommended hydraulic brake fluid.
WARNING
If the brake indicator light comes on while driving, the fluid reservoir should be
filled to the level mark with the recommended hydraulic brake fluid.
CAUTION
Do not dispose off used brake/clutch fluid with your household waste.
Use your local, authorized waste management facility.
Used brake/clutch fluid and their containers are hazardous.
They can damage your health and the environment.
123
Windshield washer solution level
Check that the washer tank is filled sufficiently with solution. Also check the
operating condition of the windshield washer.
Back door side
CAUTION
Insert the lever portion of the cover first while re-fitting to prevent any damage to the
same.
W
DO R
WINSHE
WA
124
Vehicle Storage
Storage for a long period of time. If the vehicle is to be stored for several months:
Ÿ Wash and wax the vehicle.
Ÿ Have the wax in the engine compartment and underbody checked.
Ÿ Clean and preserve rubber seals.
Ÿ Change engine oil.
Ÿ Drain washer fluid reservoir.
Ÿ Check coolant anti-freeze and corrosion protection.
Ÿ Adjust tyre pressure to the value specified for full load.
Ÿ Park vehicle in dry, well ventilated place. Engage first or reverse gear. Prevent
the vehicle from rolling.
Ÿ Do not apply parking brake.
Ÿ Open bonnet, close all doors and lock the vehicle.
Ÿ Disconnect the clamp form the negative terminal of the vehicle battery.
Putting back into operation
When the Vehicle is to be put back into operation:
Connect the clamp to the negative terminal of the vehicle battery.
Check tyre pressure.
Fill up the washer fluid reservoir.
Check the engine oil level.
Check the coolant level.
Ÿ
Ÿ
Ÿ
Ÿ
Ÿ
Ÿ
CAUTION
Do not wash the engine compartment with high pressure water as it could damage the
electrical connectors by water entry.
Never wash the engine while it is running, as water in the running engine may cause
internal damage.
125
Clutch pedal free play and height
Standard value
: mm
(1) Free play
: 5-15
(2) Height
: 168-178
(3) Clutch diameter : D260
Brake pedal free play, height and allowance
Standard value : mm
(1) Free play
: 6-10
(2) Height
: 164-174
(3) Allowance
: More than 55
(When depressed with a force of the 50 kg)
126
PERIODIC MAINTENANCE
Air cleaner
Use of fouled air cleaner element not only cause a deterioration in the engine
output but also give a raise in fuel consumption and dark exhaust smoke.
CAUTION
The cover should be reinstalled after aligning the setting marks to prevent dust
from entering. It is strongly advisable to use the GMI genuine air cleaner element
at the time of replacement.
The engine air cleaner should be installed at all times unless temporary removal
is necessary during repair or maintenance of the vehicle, because in the absence
of the air cleaner, backfiring could cause fire in the engine compartment.
127
Engine Oil Filter
Loosen the oil filter by tuning it counterclockwise with a filter wrench.
With a rag, wipe the fitting face of the oil pump clean so that the new oil filter can be
seated properly.
Lightly oil the O-ring and turn the oil filter until the sealing face is fitted against the
O-ring. Turn one full turn further with the filter wrench.
CAUTION
Check level of oil in the engine and replenish to specified level as necessary.
Start the engine and check for leaks in the oil filter. It is strongly advisable to use
the GMI genuine oil filter assembly for replacement.
The manufacturer strongly recommends against the addition of any additives
(Other than leak detection dyes) to the engine oil.
128
Parking and service brake
All brakes are self-adjusting.
Brakes are adjusted by repeated stepping on the brake pedal.
The dash panel parking brake adjustment should be performed as follows:
(1) Release the parking brake lever fully.
(2) Loosen the lock nut (A).
(3) Repeat stepping the brake pedal firmly, and releasing it until the rear brake
auto-adjuster completes the function.
(4) Rotate the adjust nut (B) until all slack disappears from the cable.
(5) Set the lock nut.
The parking brake lever travel is normal when the lever comes out 8 to 12 notches
when pulled with a force of 30 kg (66 lbs).
129
(1)
(2)
To check the floor mounted parking brake stroke, do the following:
1. Turn engine off.
2. Apply parking brake, counting notch clicks you hear. If the number of clicks
differs from the specification (7 ~ 10 notches), have your CHEVROLET
retailer adjust the parking brake.
(3)
Tire rotation
When the front and rear tires are the same size, rotate the wheels as shown in the
figure.
CAUTION
After rotation, adjust the front and rear tire pressure and be sure to check wheel nut
tightness.
130
Tire inflation pressure
Standard inflation pressure for tires are listed below.
NOTE
Check tire pressure when the tires are cold (after the vehicle has been
inoperative for more than 3 hours or driven less than 1.6 km.
2
Tire
205/65R15 99S
205/65R15 99S PS
Tire Pressure-kg/cm (PSI)
Front
Rear
2.2 (32)
2.4 (35)
1.8 (26)
2.4 (35)
CAUTION
Always dispose off worn tires according to local environment regulations.
Use of tyres of a size other than originally fitted to your vehicle may cause interference
between tyres and vehicle components and may result in tyre and vehicle damage.
Do not drive with worn or damaged tyres. Such tyres can cause you to loose control of
the vehicle and a collision resulting in injuries and damage to your vehicle and other
property.
131
Tire pressure label
The tire pressure label is located on the frame of driver's side.
Specific gravity of battery electrolyte
If your new vehicle has a maintenance-free battery, you will never have to add
water, instead install a new battery.
Do not try to jumpstart the vehicle or charge it or test the battery if the fluid level is
below the lower level line on side of the battery.
132
Cleaning of battery
If the external part of the battery is fouled, clean with tepid water. Apply a thin coat
of vaseline or grease onto the battery terminals to prevent corrosion.
WARNING
When reconnecting the cable to the battery be careful to ensure the clamps are
fully seated, then tighten the retaining bolts so that clamps will not vibrate loose.
Be sure to attach the red cable to the positive (+) battery terminal and the black
cable to the negative (-) battery terminal.
NOTE
Be sure to keep in mind that the positive terminal (+) is first when connecting and
the negative terminal (-) is first when dis-connecting.
CAUTION
Batteries contain toxic material. Used batteries can be hazardous to health and
environment. Do not dispose off battery with household waste. Use locally authorized
automotive waste disposal facilities only.
133
Headlights
Proper aiming of the headlights is most important in ensuring sufficient
illumination on the highway without blinding other motorists. When light aiming is
necessary it is advisable to contact an authorized retailer who has special
equipment for this purpose.
NOTE
When replacing a bulb, make sure the light switch is “OFF”. Use only bulbs
with the same wattage rating.
CAUTION
Clean your halogen bulbs with alcohol or mineral spirits and a lint free cloth. Be sure
not to touch them with bare hands. Finger prints may drastically shorten the effective
life of halogen bulbs.
Front combination light
Unscrew the top screw securing the lens.
134
Rear combination light
Unscrew each of the two screws securing the lens
License plate light
Unscrew the two screws securing the lens.
135
Dome light
The lens can be removed easily by hand then remove the bulb from the socket by
pulling it.
OFF
ON
Replacing light bulbs
When replacing a bulb, make sure the light switch is “OFF”.
Use only bulbs with the same wattage rating. The standard bulb wattage ratings
are given below.
WARNING
Wear eye protection when working with bulbs. Protect the bulb from abrasions
and scratches.
When the bulb is illuminated and is not in a sealed installations, protect the bulb
from contact with liquids.
Only illuminate the bulb when it is installed in a lamp.
Replace a cracked or damaged headlamp.
Keep the bulbs away from children.
Dispose off used bulbs with care, otherwise the bulbs can explode.
136
BULB SPECIFICATION
Bulb
Front
Rear
Dome
Wattage x Quantity
Remark
60/55W x 2
Halogen
1
Headlamp (High/Low)
2
Parking Lamp
5W x 2
3
Turn Signal Lamp
21W x 2
4
Turn Signal Lamp (LT)
21W x 2
Amber
5
Fog Lamp (LT)
27W x 2
Halogen
6
Side Turn Signal Lamp
5W x 2
Amber
7
Turn Signal Lamp
21W x 2
Amber
8
Brake/Taillamp
21/5W x 2
9
Backup Lamp
21W x 2
10
High Mounted Stop Lamp
5W x 5
11
License Plate Lamp
5W x 2
12
Dome Lamp
10W x 2
Ÿ Bulb specification in some models can be different from the above table. See the wattage printed on the bulb before
replacing burnt bulbs.
WARNING
The same rating of the bulb to be used during replacement and any usage of higher wattage bulbs can cause thermal issues
such as melting of lamp housing and its surrounding parts.
Warranty would be void if higher wattage bulbs are being used.
137
Fuse junction block
The fuse junction blocks are installed under the instrument panel on the drivers
side and in the engine compartment.
The cover can be removed easily by hand. A list of the main fuse circuits and their
amperage is attached to the junction block cover.
The spare fuses (10, 15, and 20A) and removal tool (white) is installed on the
backside of fuse junction block cover, which is in engine compartment.
The drawing at the left illustrates a burned out fuse.
Use a spare fuse of the same amperage for replacement.
NOTE
Normal
Burned out
*
When replacing a fuse, it is important to use a spare fuse of the amperage
shown on the fuse junction block cover.
*
If the spare fuse also burns out, have the circuit checked at your nearest
CHEVROLET retailer.
138
Fuse Box: Engine Room D
30 A
COND
FAN
(
30 A
30 A
(P / W)
(ECU)
REV LP
20A
8
LAMP
LAMP
LAMP
13
8
11
3
8
7
9
LAMP
LAMP
HORN
15
COND
LAMP
6
DIMMER
4
10
(PW WND)
(REV LP)
5
2
1
RR DEF
P. NO
28285369
USE SPECIFIED FUSES ONLY.
UNSPECIFIED FUSES CAN CAUSE FIRE AND
MALFUNCTION OF EQUIPMENT.
IF BRAKE OIL ETC, SPILLS OVER THIS COVER
WIPE WITH A CLOTH.
139
Fuse Box : Instrument Panel D
Fuse No.
Capacity
C-2
15A
C-3
20A
FT. WIPER
C-4
10A
RR. WIPER
C-5
15A
TURN, BACK
C-6
15A
AUDIO (ACC), CIGAR
Function
RR. Defog, I/P Cluster,
FT. Wiper Washer
Auxiliary Fuse Box
FUEL PUMP
RELAY
12V/30A
A/C CONT.
RELAY
12V/30A
GLOW PLUG
RELAY
12V/70A
ECU
RELAY
12V/40A
FN1-15A
EGR, TURBO
FN2-15A
PCV, VCV
FN3-15A
ECU
FN4-5A
ENG-DIAG
FN5-5A
ECU
FN6-15A
FUEL PUMP
140
RECOMMENDED LUBRICANTS AND DIESEL FUELS
In order to obtain maximum performance and longest service life from your CHEVROLET vehicle, it is very important to use
lubricants and diesel fuels selected and listed in the chart. The lubrication intervals in the maintenance schedule and
application of the New Vehicle Warranty are based on the use of recommended lubricants as given in the chart, which will
serve as a guide for selecting lubricants of proper grade.
LUBRICANTS
LUBRICANTS
TYPE OF LUBRICANTS
Diesel engine crankcase
GMI Genuine API 15W40 CI4
Manual transmission case
GMI Genuine 15W30
Power steering circuit
GMI Genuine Dexron III
Steering gear box
GMI Genuine 80W90 GL-5
Differential gear
GMI Genuine 80W90 GL-5
Hydraulic brake and clutch system
GMI Genuine Dot 3
Wheel bearing
L2 grease
Grease fitting
MP grease
Engine cooling system
GMI Genuine LLC
141
DIESEL FUELS
Diesel engine must be operated only on commercially available diesel fuel meeting specifications of Cetane no. 48 & above.
Only use diesel fuel that complies with DIN EN 590. The fuel must have low sulphur content (max. 50 ppm). Equivalent standardised
fuels with a biodiesel (= FAME according to EN 14214) content of max. 7% by volume (like DIN 51628 or equivalent standards) may
be used.
Do not use marine diesel oils, heating oils or entirely or partially plant-based diesel fuels, such as rape seed oil or bio diesel,
Aquazole and similar diesel-water emulsions.
The flow and filterability of diesel fuel are temperature-dependent. When temperatures are low, refuel with diesel fuel with
guaranteed winter properties.
CAUTION
If you use inappropriate grade fuel or put incorrect fuel additives into the fuel tank, the engine and catalytic converter may seriously be
damaged.
Do not let any gasoline or water enter the tank. This would make it necessary to drain it out and to bleed the lines to avoid jamming of
injection pump & damage to engine.
142
LUBRICATION
Lubricants should be carefully selected according to the lubrication chart. It is also important to select viscosity of lubricants
according to the ambient temperature by referring to the following table.
OIL VISCOSITY CHART FOR DIESEL ENGINE
143
OIL VISCOSITY CHART FOR REAR AXLE
144
OIL VISCOSITY CHART FOR TRANSMISSION CASE
145
LUBRICATION GUIDE
Changing engine oil
Drain the engine crankcase completely by removing the drain plug on the lower part of
the oil pan while the engine is hot and then install the drain plug.
Next fill the engine crankcase from the filler port with new engine oil of the
specified grade.
NOTE
When the engine crankcase is filled to the high level mark on the oil dipstick, start
and let the engine idle for a few minutes, then stop the engine and recheck the oil
level and replenish, if necessary.
146
Changing transmission oil
Drain the transmission case by removing the drain plug (D) on the lower face of
the transmission case. Fill the transmission case to the level with the specified oil
through the level plug hole (L).
MT
(L)
(D)
CAUTION
Make sure the transmission is cool before you attempt this procedure.
Do not overfill the manual transmission fluid.
(L)
Changing differential oil
Drain the rear axle case by removing the drain plug (D). Fill the rear axle case to
the level with the specified gear oil through the level plug hole (L).
CAUTION
(D)
Replace the drain plug washer with new one every time plug is removed.
147
Changing power steering fluid PS
Draining
1. Jack up the front wheels until they are clear of the ground.
2. Remove the fluid hose between the steering unit and the fluid reservoir.
3. When draining is completed, remove remaining fluid within hydraulic system
by turning the steering wheel fully in both directions several times.
Refilling
1. Install the fluid hose securely and fill the fluid reservoir with the specified
steering fluid.
CAUTION
Do not operate vehicle without the required amount of power steering fluid. Doing
so can damage power steering system of your vehicle, leading to costly repairs.
An overflow of the fluid may cause the fluid to burn or discolour paintwork. Do not
overfill the reservoir.
148
2.
With the engine stationary, turn the steering wheel fully in both directions
several times.
NOTE
While bleeding check the fluid level and replenish if necessary.
3.
With the engine idling turn the steering wheel fully several times in both
directions
CAUTION
Avoid turning steering wheel to lock and holding it there for more than 5 seconds,
or the fluid temperature will increase sharply.
4.
Lower the vehicle to the ground and turn the steering wheel fully in both
directions several times, with the engine idling
149
5.
6.
Bring the steering wheel to the straight-ahead position, stop the engine, and
check that the level of fluid in the fluid reservoir does not rise. If the fluid level
rises sharply, air is not completely removed from the system and the
operations outlined under step 4 must be repeated.
Check level of fluid in the fluid reservoir, then check joints for leakage.
RE-PACKING FRONT HUB BEARING WITH GREASE
It is suggested that the vehicle be taken to your CHEVROLET retailer when the
above operation becomes necessary as the operation calls for disassembly and
reassembly.
150
MAIN DATA AND SPECIFICATIONS
DIMENSION
Length
Width
Height (Unladen)
Wheel Base
Wheel Track
Front
Rear
Min. Ground Clearance
WEIGHT
Gross Vehicle Mass (8, 9, 10 Seater)
Gross Vehicle Mass (7 Seater)
mm
mm
mm
mm
4435
1680
1765
2685
mm
mm
mm
1445
1420
185
kg
kg
2550
2510
ENGINE
Model and type
Compression ratio
Piston displacement
Bore x stroke
Max. power
Max. torque
Idle Speed
Firing order
G2 & 4 Stroke/DI/TCIC/CRDFi four cylinder water cooled inline
cylinder engine with piezo technology fuel injection
17.5 ± 0.5
1994
84.45 x 88.95
78.30@4000
261@2500
825 ± 25
(to 1)
cc
mm
Kw@RPM
Nm@RPM
rpm
1-3-4-2
151
Service change engine oil capacity
(with filter changes)
liters
4.5~5.5
(without filter changes)
liters
4.0~5.0
Coolant capacity
liters
7.0
Fuel tank capacity
liters
55
Oil pan drain plug torque
kg.m
2.55
CLUTCH
Type
Diameter
Pedal free play
Hydraulic control, dry single plate with diaphragm springs
mm
D 260
mm
5-15
TRANSMISSION
Model and type
TR-2450 : 5-speed, fully synchronized manual transmission
with a constant mesh type reverse gear
Gear ratio
Lubricant capacity
(to 1)
position
1st
2nd
3rd
TR-2450
4.201
2.328
1.421
liters
4th
5th
Reverse
1.00
0.765
3.759
2.8
152
MAIN DATA AND SPECIFICATIONS
REAR AXLE
Type
Gear ratio
Spiral bevel & hypoid gear, semi-floating
(to 1)
Gear ratio 4.1
Oil capacity
liters
1.8L
Filler & drain plug torque
kg.m
2.75 - 4.18
STEERING
Type
Steering wheel free play
Recirculating ball
mm
10-30
Wheel alignment
Toe-in
mm
Camber
(degrees)
0 30' ± 60'
Caster
(degrees)
10 30' ± 45'(Long)
King pin angle
(degrees)
100 ± 60'
Turning radius
m
2±2
0
5.62
SERVICE BRAKE
Type
Hydraulic disc in front, self-adjustment drum
brake in rear with vacuum servo.
Pedal free play
mm
6-10
Booster - tandem
mm
230
153
PARKING BRAKE
Mechanical internal-expanding, action on rear wheels.
Type
Brake lever travel
(notches)
IP mounted
8-12 (when pulled with force of 30kg)
Floor mounted
7-10 (when pulled with force of 20kg)
WHEEL AND TIRE
Tire size
205/65R15 99S
Wheel dimension
Tire pressure
6JJ X 15
Kg/cm
2
2.2/2.4 (Front/Rear) or 1.8/2.4 (Front/Rear) PS
SUSPENSION
Type
Front
Independent wishbone arms, torsion bar spring with
stabilizer bar with double-action gas filled shock absorbers
Semi-elliptic, alloy steel leaf spring, with
Rear
double-action gas filled shock absorbers
ELECTRICAL
12 volt system with negative polarity ground.
Type
Battery
volt/Ah
D 80D26L (12V/65Ah)
Starter
volt/kw
12/2.2
AC generator
volt/amp.
D 12/120
A/C
Refrigerant Specified Amount (R134a)
SINGLE 725
DUAL 875
gms
154
25
25
Service and Warranty
155
156
Service Certificate
1st Owner
3rd Owner
Customer name
Customer name
Registration no.
Registration no.
2nd Owner
Customer name
Registration no.
157
Predelivery Inspection and
Vehicle Delivery
Before delivering the vehicle we carried out a thorough predelivery
inspection in order to ensure that your CHEVROLET vehicle is in a faultfree condition. Accompanying this appropriately filled out service
booklet are the owner's manual, the tool kit and your vehicle
documents.
You have been informed of the service intervals and necessary service
checks.
City, date
CHEVROLET Retailer’s / ASO’s Stamp and Signature
158
Owner’s
Statement of Acceptance
I hereby certify that the vehicle has been delivered in an orderly and
proper operating condition, including keys, owner's manual, service
booklet and tool kit. I have read and understood the terms and
conditions pertaining to the New Vehicle Warranty and agree to
abide by the same.
I have been informed of the service intervals and necessary service
checks, including under extreme operating conditions.
Date of delivery :
City, date
Name and signature of customer
This sheet must be detached prior to vehicle delivery and placed with the vehicle file after it has been signed by the customer.
159
160
1000Km/30 days Reassurance check-up
VIN no. :
PDI no. :
Date of service
Dear Customer,
Date of delivery
We are confident that you and your family would be enjoying the
safe and comfortable drive of the Chevrolet Tavera.
We would like to undertake a thorough check-up of the vehicle at
1000 kms or 30 days, whichever occurs earlier. This will also allow
us to re-emphasise the salient features of the Tavera to you.
Retailer code
Customer's name
Customer's tel no. :
I confirm that the vehicle has been inspected and delivered to my
satisfaction.
In the unlikely event of an emergency assistance, please call
your nearest CHEVROLET retailer as mentioned in this booklet
or please feel free to call our 24 hr. helpline at 1800 3000 8080.
Customer signature
161
1000 kms Reassurance check-up
General Status review
Check closing efforts of doors,
key less entry system, sunroof
& other functions
Under hood
Visually check routing, leaks &
damage
— Check fluid levels
— Engine oil level
— Brake / Clutch oil level
— Coolant level
— Power steering oil
Windscreen washer level &
add washer fluid
Check & adjust belt tension
Underbody, wheels
Visually check routing, leaks &
damage
Check tyre pressure
Electrical Checks
Engine check lamp
Charging lamp
Oil pressure lamp
Hazard indicator & all other
telltale lamp
Cigarette lighter/rear defogger
auto cut off
Check lighting system
Horn/Radio/OutsideMirrors/
auto parking mode
High/Low beam/Hazard
signal
Turn signal / Flash to pass
signal
Front/Rear fog lamps/Tail
lamps
Stop lamp/Reversing lamp/
Trunk lamp
Dynamic Evaluation
Steering function/noise/
abnormal drag
Clutch & gear shifting
function/noise
Accelerating & braking
function/noise
Parking brake lamp/indicator
Check tyres
High beam/Turn signal
Any other abnormal noise
162
CHEVROLET Inspection
CHEVROLET Inspection
2nd Service Check One Year /10000 kms whichever occurs
earlier
1st Service Check Six months /5000 kms whichever occurs
earlier
VIN
VIN
Regn. No:
Regn. No:
Delivery Date
Delivery Date
Date :
Date :
Kms:
Kms:
I confirm that the job has been attended to my satisfaction.
I confirm that the job has been attended to my satisfaction.
Customer's Signature
Labour is free & parts are chargeable
Customer's Signature
Labour is free & parts are chargeable
(Retain with Job card)
(Retain with Job card)
163
Delivering retailer's stamp & date
Delivering retailer's stamp & date
I hereby certify that the work has been carried out as per the
schedule.
I hereby certify that the work has been carried out as per the
schedule.
Servicing retailer's / ASO stamp & date
Servicing retailer's / ASO stamp & date
164
CHEVROLET Inspection
CHEVROLET Inspection
4th Service Check Two Years /20000 kms whichever occurs
earlier
3rd Service Check Eighteen months/15000 kms whichever
occurs earlier
VIN
VIN
Regn. No:
Regn. No:
Delivery Date
Delivery Date
Date :
Date :
Kms:
Kms:
I confirm that the job has been attended to my satisfaction.
I confirm that the job has been attended to my satisfaction.
Customer's Signature
Labour & parts are chargeable
Customer's Signature
Labour & parts are chargeable
(Retain with Job card)
(Retain with Job card)
165
Delivering retailer's stamp & date
Delivering retailer's stamp & date
I hereby certify that the work has been carried out as per the
schedule.
I hereby certify that the work has been carried out as per the
schedule.
Servicing retailer's / ASO stamp & date
Servicing retailer's / ASO stamp & date
166
MAINTENANCE RECORD SHEET
(Repair category - Free Service/Paid Service/Running Repair/Acc. Repair)
Repair
Date
R.O. No.
Kms.
Repair
Category
Details of Repair Done
167
Name of Servicing
Retailer
Service
Adv. Sign.
Retailer Stamp
MAINTENANCE RECORD SHEET
(Repair category - Free Service/Paid Service/Running Repair/Acc. Repair)
Repair
Date
R.O. No.
Kms.
Repair
Category
Details of Repair Done
168
Name of Servicing
Retailer
Service
Adv. Sign.
Retailer Stamp
Battery
n
Battery type :
Defects arising out of faulty vehicle electrical systems, negligent
maintenance, incorrect charging or improper filling of the battery
by unauthorised dealers/auto electricians are not covered by
warranty.
Battery make :
n
Consequent liabilities are not covered by this warranty policy.
Battery number :
n
Get Battery checked every 3 months.
Important Instructions
n
n
n
n
n
n
n
n
The battery must be fitted firmly in the cradle.
Connecting cables and connectors must be fastened securely
on to the battery.
Connections must be made in the right polarity.
Terminals must be kept coated with petroleum jelly/vaseline.
DO NOT USE GREASE.
Battery top & vent plugs must always be kept clean & dry .
Electrolyte level must always be maintained in line with the
bottom of the vent hole. In case of any drop in electrolyte level,
add pure distilled water. NEVER ADD ACID.
CHEVROLET Retailer’s
Stamp
Battery is warranted for a period of one year only.
Liability under this warranty is limited to defects arising out of
faulty material or workmanship developing under proper use
and NOT when the battery is merely discharged.
169
Battery Service Record
Date
Specific Gravity
Voltage
170
Remarks
Retailer stamp &
signature
Standard limited warranty coverage
1. SCOPE
General Motors India Private Limited, a private limited company incorporated in India under the Companies Act 1956 and having its
Works/Registered office at Chandrapura Industrial Estate, Halol, District Panchmahals, Gujarat 389351 (“General Motors India”) warrants that
your new Chevrolet Tavera (“Vehicle”) is free from defect in material or workmanship, subject to your compliance with the following terms and
conditions mentioned hereunder and other vehicle maintenance norms as mentioned elsewhere in this service booklet.
Only an authorized CHEVROLET Retailer as mentioned in this booklet will make the necessary repairs, using new, re-conditioned or remanufactured parts with a view to correcting any defect covered by this New Vehicle Warranty.
2. WHAT IS COVERED
Time and distance limits for "New Vehicle Warranty" coverage.
Warranty Type
A : General
Warranty Limits
OTHER WARRANTIES
Three(3) years or 1,00,000 kms
(whichever is earlier from the date of
delivery by a Chevrolet authorized
retailer or the date of first registration
of the motor vehicle, whichever occurs
first.
These parts are covered by other warranties :
1. Battery (one (1) year) (covered by the Battery manufacturer*)
2. Tires (one (1) year) (covered by the tire manufacturer*)
3. Audio/Radio (one (1) year)
* Service / warranty shall be provided by the concerned equipment manufacturer
171
(covered by the Audio/Radio manufacturer*)
l
The obligation under this New Vehicle Warranty is limited to the repair of the new motor vehicle at no charge by the CHEVROLET
authorized retailer during the New Vehicle Warranty period. For parts replaced during such repair the same warranty applies until the
end of the New Vehicle Warranty period as stipulated herein. All warranty claims expire at the end of the New Vehicle Warranty period
as specified under Clause 2. The Owner is responsible for any repair or replacement which are not covered by this warranty.
l
Liability of General Motors India under this New Vehicle Warranty is limited to the value of the service, repairs/ replacement of parts
found to be defective within the warranty period. Beyond servicing and/or repairing defective parts in the vehicle, General Motors India
does not undertake to replace the vehicle / or reimburse the purchaser by payment of any money in respect of the vehicle purchased by
them.
l
Under the terms of New Vehicle Warranty, installation, free service will be provided only within the municipal limits of the cities/towns
where General Motors India has its service network, as elaborated elsewhere in this Service booklet. This list of authorised
Chevrolet retailers is subject to change/modification without prior notice. Service outside the municipal limits specified above will
be provided after charging the actual to and fro traveling and incidental expenses, as prevailing from time to time.
l
Necessary care and caution is taken in manufacturing of the vehicle, however, General Motors India shall not be liable for any loss or
damage caused to any article, property, death or disability caused to any human life arising out of fire, electric fault, short circuit,
accidental handling or negligent use of the vehicle. The maximum liability in monetary terms shall be restricted to the value of the
defective parts and / or value of services rendered only. Furthermore, the New Vehicle Warranty, in no case, shall extend to the payment
of any monetary consideration whatsoever, of the replacement or return of the vehicle as a whole.
l
The decision of General Motors India will be final and binding on all matters arising out of this New Vehicle Warranty.
l
The owner should preserve the original Invoice for necessary verification and produce the same, as and when required.
l
The optimum performance of the vehicle is under standard test conditions.
This New Vehicle Warranty is issued at Halol, district Panchmahals, Gujarat and competent courts shall have exclusive jurisdiction over
matters by or following from this New Vehicle Warranty. All disputes shall be decided as per the Indian laws that may be prevalent from
time to time.
172
3.
(regarding paint or body damage, specially stone throw, air-borne
rust, industrial fall out, damage to catalytic converter due to use of
wrong/bad quality fuel) acting on the vehicle
i.
Damage caused by normal wear (for instance brake-pad, etc.) or
exposure to the elements such as discoloring or deformation of
any interior, plastic, chrome or painted part or surface.
j
Sensory complaint by the owner against symptoms such as noise,
vibration or oil stains which do not affect performance.
k
Damage which should have been detected during normal usage
but became serious when left unattended to and/or the owner of
the vehicle having failed to claim and having rectified a defect
which was already apparent during vehicle delivery, immediately
after delivery or a defect which becomes apparent at a later date
immediately after it became apparent.
l
Failure of the owner to adhere to the requirements outlined in
Clause 4.
m. Fuel system damage caused by water or other foreign matter in
the fuel system.
n. Damage caused by the installation of accessories or equipment
after the vehicle has been purchased from the Chevrolet
authorized retailer such as radio, car telephone, CD radio set, or
cargo carrier and / or other activities of a similar nature.
o. Consumptive parts and oil/grease and other fluids.
(See the following tables of consumptive parts and oil/grease and
other fluids.)
p. Adjustments, cleaning, inspection, or required periodic
maintenance.
q Parts designated as requiring periodic replacement.
r. Warranty repair not performed by a Chevrolet authorized retailer.
s. Charges or fees for telephone, tow, transportation charges of the
vehicle to the nearest Chevrolet authorized retailer, rental car, and
WHAT IS NOT COVERED
Please read the followings carefully;
a.
Failure to have the required periodic inspection and required
service performed as mandated elsewhere in this service booklet.
b.
Improper or wrong maintenance and in deviation with guidelines
mentioned in this service booklet.
c.
Any modification, alterations made to the vehicle such as
including but not restricted to adding lights, changing engine
specifications to increase horsepower, or using wide tires, and or
any other modification in the vehicle that may likely to have an
effect on the performance of the vehicle. (e.g.: a defect caused by
the installation of non homologated wheels and tires are not
covered by the warranty.
d.
Failure to use genuine parts, /fluids (oil, coolant, gas) and / or
other accessories / consumables recommended or approved by
General Motors India.
e.
Use of the vehicle for purposes or in a manner other than the one
mentioned in the owner's manual. Exceeding specified capacities
such as loading weight, passenger, speed, use as a commercial
vehicle and rpm limitations.
f.
Damage caused by driving the vehicle under severe conditions
such as un-pliable or water-logged roads, in races or
rallies..
g.
Damage caused by natural disasters including but not restricted to
earthquakes, storms, floods, fire and accidents. The owners are
recommended to keep their vehicle insurance valid at all times.
h.
Damage caused by smoke, chemicals, bird-droppings, salt, stone
chipping, scratches, iron dust or any other extraneous
circumstances like external mechanical or chemical influences
173
u.
v.
so forth; compensation for inconvenience or commercial
losses; all other consequential costs relating to the owner being
unable to use the vehicle
Damage to the engine while driving in water logged conditions
or entry of water in to the engine.
Any accident, damage, loss or destruction due to negligent,
careless use of vehicle.
Consumptive Parts
Belt
Air cleaner element
Fuel filter
Oil filter
Clutch disk, clutch parts
Brush holders (for ECVT)
Brake linings
Brake disks
Brake drums
Wiper blades
Light bulbs
Motor brushes
Hoses
Fuses, etc.
Spring bushing
4.
a
b
Oil/Grease and other fluids:
Engine oil
Transmission oil
Differential oil
Brake/clutch fluid
Coolant
Grease
Washer fluid
Battery fluid
Diesel
Air conditioner refrigerant
Other lubricants, etc.
c
5.
a.
b.
c.
6.
No warranty repair shall be made if it is found that the vehicle
Identification number like chassis / engine number, odometer or the
warranty & service booklet, have been tampered with. This list is
neither exclusive nor exhaustive and the decision of General Motors
India shall be final and binding
174
WHAT THE OWNER MUST DO
In order to keep this warranty valid you must:
Use your vehicle as instructed in the owner’s manual.
Have your vehicle inspected according to this schedule.
The cost of the service is borne by the owner. If the services are not
performed within the specified time limits, the general and any
other warranty as referred to under Clause 2 above, shall be
rendered null and void and shall not be reinstated by a subsequent
service.
Keep the warranty & service booklet and all receipts in a safe place to
present to the Chevrolet authorized retailer at regular maintenance
visits and when repair work is required.
PARTS COVERED BY OTHER WARRANTY CONDITION
Battery : The coverage period is 1 year from the date of new vehicle
registration regardless of the distance traveled. This warranty is
covered by Battery manufacturer.
Tires : The coverage period is 1 year from the date of new vehicle
registration. This warranty is covered by the tire manufacturer.
Audio/Radio : The coverage period is 1 year from the date of new
vehicle registration. This warranty is covered by the audio/radio
manufacturer.
MAKING THE WARRANTY EFFECTIVE
The warranty goes into effect after Chevrolet authorized Retailer fills
in the appropriate information about your vehicle and places the
retailer's official seal and signature in the warranty & service booklet.
11. The following requisite document should be presented to the
Chevrolet Retailer at the time of making a claim under New
Vehicle Warranty:
7.
REQUIREMENTS FOR WARRANTY WORK
To have warranty work carried out, present the warranty &
service booklet to the authorized Chevrolet Retailer as
mentioned in this booklet. If the warranty & service booklet is lost
or incomplete, work to be carried out with respect to the standard
warranty shall be refused.
8. CHANGE OF OWNERSHIP
If the vehicle is sold during the warranty period, please deliver
the warranty & service booklet to the new owner.
The new owner will need to complete the change of address or
subsequent ownership notification card located elsewhere in this
booklet in order for the coverage to be transferred.
9. EXPENSES ASSOCIATED WITH WARRANTY WORK
The expenses of repair work and parts of your Chevrolet will be
covered by Chevrolet standard limited warranty in accordance
with the WARRANTY & SERVICE BOOKLET. Other expenses
that are not covered by the Chevrolet Standard Limited Warranty
must be covered by the owner.
10. General Motors India Private Limited is launching the Chevrolet
Tavera in different cities in a phased manner. The Chevrolet
retailer responsible for delivering your Tavera is qualified to
provide all Tavera related services within the city where the
dealership is located. As other Chevrolet retailers become
operational to handle the Tavera, they will also be able to provide
similar Tavera related services. IN ORDER FOR THE
WARRANTY ON YOUR VEHICLE TO APPLY, IT IS
IMPERATIVE THAT YOUR TAVERA BE SERVICED,
HANDLED AND ATTENDED TO ONLY BY CHEVROLET
RETAILERS AS SET FORTH IN THIS BOOKLET.
l
l
l
175
Original invoice issued by a CHEVROLET Retailer.
This warranty and service booklet Service / maintenance record
Any other document deemed to be necessary by CHEVROLET
retailer and/or General Motors India
Emission Warranty
( Applicable in NCR Delhi,
Chennai, Kolkata and Mumbai )
Subject to other terms of the warranty policy
and the conditions and obligations laid down
hereunder, General Motors India Pvt. Ltd.,
hereafter called GMI, certifies that the
components liable to affect the emission of
the gaseous pollutants in the vehicle in the
normal use despite the use to which it may
be subjected, comply with the provisions of
Rule 115 (2) of the Central Motor Vehicle
Rules, 1989,and further warrants that if on
examination by a service center duly
authorized by the GMI, the vehicle is
discovered to be failing to meet the emission
standard as specified in the said rule, our
authorized service center shall take such
corrective measures as may be necessary and
shall at its sole discretion either repair or
replace free of charge such components of
emission control system as are specified in
Annexure II hereof.
The definitions of various terms used in
Emission Warranty proposal are given in
Annexure –I. These definitions shall be in line
with the definition of the existing product
Warranty definition.
Conditions :
1. This warranty will be in addition to and will
run concurrently and parallel to the product
warranty and will apply only in respect to
components as mentioned in Annexure-II.
2. The period of the vehicle’s warranty shall
commence from the date of the vehicle
sale.
2.1 Warranty period - 1,00,000 kms or 3 years
whichever occurs earlier, from date of the
vehicle sale.
3 The warranty claim will be accepted only
after examination carried out by Authorised
Service Centers leading to a firm conclusion
that none of the original settings /specifications have been tampered with and that the
components (s) as mentioned in Annexure
– II has/have a manufacturing defect, and
/or, that the vehicle is unable to meet the Inuse emission standard, as described in Sr.
No. 3 above with the instructions in the
Owner ‘s Manual (OM).
4. The methods of examination to determine the
warrantable condition of the components will
be at sole discretion of GMI and or its
authorised service centers and results of
such examination will be final and binding. If,
on examination, the warrantable condition is
not established, GMI will have the right to
charge full, or part, of the cost of such
examination and resulting repairs /
rectification
5. In case of acceptance of the warranty under
Emission Warranty, GMI will replace, at
Authorized Service Centers, free of charge,
the components which are covered as
mentioned in Annexure-II, but the
consumables as mentioned in OM shall be
charged as per actual applicable rates.
176
6. In case of a vehicle in which the components
covered under Emission Warranty or the
associated parts, are not independently
replaceable, on account of their being
integral parts of a complete assembly, GMI
will have the sole discretion to replace either
the entire assembly or by using some of the
parts of the system through suitable repairs
or modifications.
7. Any consequential repairs or replacement of
parts which may be found necessary to
establish compliance to In-use emission
standards, in addition to the replacement of
the components covered under Emission
Warranty, will not be made free of cost
unless such parts are also found to be in a
warrantable condition within the scope and
limit of the product Warranty (Chevrolet
Tavera-3 years / 1,00,000 kms, whichever is
earlier). The consumables and labour shall
be charged per actual during such repairs or
replacement of parts.
8. All the parts removed for replacement under
warranty will be the property of GMI.
9. GMI will not be responsible for the cost of
transportation of the vehicle to the nearest
Authorized Service Center or any loss due to
non-availability of the vehicle during the
period of a warranty claim and examination
by GMI/Authorised Service Centers and
repairs.
10. GMI will not be responsible for any fines,
penalties that may be charged by Statutory
or Regulatory authorities on account of
failure of the vehicle to comply with the
In-use emission standards on the vehicle
not meeting any such given legal/
regulatory requirement, during inspection
by such authorities.
11. Emission Warranty will be applicable
irrespective of the change of ownership of
the vehicle provided all the conditions as
laid down in this document are met from
the date of original sale of the vehicle.
This Emission Warranty will be applicable
only if the customer :
(i) Observes all the important instructions and
any other precautions listed in the OM for
use of the vehicle.
(ii) Under all circumstances uses lubricants and
fuel as recommended by manufacturer.
(iii) Regularly obtains and carries out
maintenance at GMI Authorised Service
Centers as per the list in this booklet only,
in accordance with GMI guidelines and
enters the details in the Logbook/Service
Book.
(iv) Immediately approaches the nearest
Authorized Service Center as per the list in
this booklet upon discovery of failure to
comply with the In-use emission standard
inspite of having maintained and used the
vehicle in accordance with the instructions
in the OM and having carried out such
repairs and adjustments as may be
required with a view to establish such
compliance.
(v) Produces the ‘Pollution Under Control
(PUC)’ certificate valid for the period
immediately preceding the test during
which the failure is discovered, the test
having been carried out either for
obtaining a new certificate, or pursuant
upon being directed by an officer as
referred to in sub –rule (2) of Rule 116 of
the Central Motor Vehicles Rules,
(vi) Produces the Logbook provided with OM
and all relevant bills for verification of
details.
(vii) Produces receipts covering maintenance
of the vehicle as specified in the OM from
the date of original purchase of the
vehicle.
(viii) Produces valid certificate of insurance
& RTO registration.
Conditions under which warranty is NOT
applicable:
1. Non production/availability of a valid
‘Pollution under Control’ certificates as
described in customer obligation (V).
2. In case the vehicle is not serviced by GMI
Authorised Service Centers as per the list
in this booklet as per the service schedule
described in the maintenance chart given in
the OM.
3. A vehicle, which has been subjected to
abnormal use, abuses, neglect and
improper maintenance or has met with an
accident.
4. Use of such replacement parts, which are
not specified and approved by GMI.
5. If the vehicle or parts thereof, have been
altered, tampered with or modified or
replaced in an unauthorized manner.
177
6. A vehicle on which the odometer is not
functioning or the odometer has been
changed or the reading of which has been
changed / tampered with so that the actual
mileage cannot be readily determined.
7. A vehicle, which has been used, for
competitions, races, rallies or for the
purpose of establishing records.
8. Examination by GMI or our Authorized
Service Centers as per the list in this booklet
of the vehicle shows that any of
the conditions stipulated in the OM with
regard to use and maintenance have
been violated.
9. A vehicle, which has been run on
adulterated fuel or lubricant or fuels/
lubricants other than those, specified by
GMI.
Scope and Limits:
1. This emission warranty is in addition to the
product warranty for the vehicle as per the
scope and limit described in the OM and all
conditions described therein will apply, in
addition to those exclusively stipulated in
this warranty.
2. The emission warranty covers only
compliance with the emission standard as
specified in sub rule (2) of Rule 115 of CMVR.
It does not cover any other performance of
these parts or routine test and consequent
maintenance or adjustments to establish
compliance to the in-use emission standard
as applicable to the state, in which the vehicle
is registered and is in use.
Annexure-I
Definitions:
1. Vehicle : The Motor Vehicle approved for sale within India under the provisions of Central Motor Vehicle Rules, 1989 or any subsequent
amendment or substitution thereof.
2. Owner Manual (OM) : A document given to the customer at the time of sale of the vehicle giving guidelines on use and maintenance of the vehicle
including the terms and conditions of Warranty
3. Maintenance : Maintenance as per the schedule provided in the owner’s manual by GMI including inspection, verification check, adjustment and
replacement, if necessary.
4. Logbook : The scheduled service record book, which shall be issued at the time of first sale to the customer.
5. Abnormal Use : The situations when the vehicle is put to use other than that intended by GMI such as racing, overloading or use of adulterated
fuel or fuel not recommended by GMI.
6. Manufacturing Defect : Means deficiency or deviation from normal production tolerance in design, material, or workmanship in a device or
system which affects any parameter, performance, or component belonging to emission control system.
7. Product Warranty : The manufacturer warranty as provided by GMI, which covers failure of various parts and systems as per the OM.
3 years / 1,00,000 kms (Whichever is earlier).
8. Emission Warranty : Warranty for emission performance of the vehicle as determined by sub-rule (2) of rule no 115 of the Central Motor Vehicles
Rules, 1989.
9. Authorized Service Centers : Any service facilities authorised by GMI to perform warranty repairs. This shall include all of GMI dealerships that
are recognised for service of subject vehicles or any other service center duly authorised by GMI.
10. Warrantable Condition : Warrantable condition means any condition of a vehicle, which triggers the responsibility of GMI to take corrective action
within the framework of Emission Warranty. This however shall not include any statutory or regulatory fines or penalties.
11. Warranted Parts : Those components, listed as per Annexure –II.
178
Annexure - II
List of Components Covered under Emission Warranty
S. No.
Part name
1
Catalytic Converter***
2
Exhaust manifold gasket
3
Electronic Control Module
4.
Manifold Absolute Pressure Sensor
5.
Mass Air Flow Sensor
6.
Accelerator Pedal Position Sensor
7.
Air Temp. Sensor
8.
Coolant Temperature Sensor
9.
Injectors
10.
Fuel Pressure Regulator Valve
11.
Exhaust Gas Re-circulation Valve
12.
Fuel Pump
13.
High Pressure Pump
14.
Glow Plugs
*** Catalytic Converter is covered only for emission related failures as provided under th warranty statement. Replacements if any shall not be
applicable for breakage and noise problems
Note : All the above mentioned parts are covered only if the car fails to meet the prescribed Emission norms. Any other performance problems
shall be treated as not relevant to the Emission Warranty. All the above parts may not be part of the vehicle and depend on engine type.
179
CHEVROLET SALES INDIA
SALES AND SERVICE NETWORK
North Zone .................................... 181
West Zone .................................... 187
South Zone ................................... 192
East Zone ..................................... 198
International ................................. 201
L Indicates Retailer (Sales and Service)
m Indicates Chevrolet Authorized Service Center
Authorized Service Center (ASC) are authorized to carry out Periodic Maintenance (Free/Paid, Minor Running Repair) Only.
The list of authorized Retailers / ASC are mentioned herein as of April, 2014. For any change in authorized Retailers /ASC, please visit
www.chevrolet.co.in.
180
NORTH ZONE
L
STATE - DELHI
L
L
Auto Vikas Sales & Service Pvt. Ltd.
Workshop :
12-A, Shivaji Marg, Najafgarh Road,
New Delhi - 110015
Tel. : 011 - 42070707, 42070788
Fax : 011 - 25451004, 42070735
L
Workshop :
B-31, Jhilmil Industrial Area, Behind Jhilmil Metro
Station, New Delhi - 110095
Tel. : 011 - 43388888
L
L
Arya Automobiles
Showroom :
Plot No. 193, Metro Pillar No. 543,
Main Rohtak Road, Mundka, New Delhi - 110041
Tel. : 011 - 8743030301 / 302
Fax : 011 - 28342887
Go Auto Pvt. Ltd.
Showroom :
A 231, Okhla Industrial Area, Phase-1,
New Delhi - 110020
Tel. : 011 - 41855500, 9015444555
Workshop :
B-25, Okhla Industrial Area, Phase-1,
New Delhi - 110020
Tel. : 011 - 41955500, 9015777888
Metro Motors Pvt. Ltd.
Showroom & Workshop :
Bawa Potteries Industrial Complex,
Aruna Asaf Ali Marg, Vasant Kunj - 110 070
Tel. : 011 - 41761717, 46156666
L
Showroom 2 :
A-2/6, Safdarganj Enclave,
Africa Avenue, New Delhi - 110 029
Tel. : 011 - 46146666 / 75
L
Triumph Motors
Showroom :
A-9/3 Wazirpur Industrial Area, Near Richi Rich,
New Delhi - 110052
Tel. : 011 - 47444666
Fax : 011 - 42475584
Workshop 2 :
G-14, Udyog Nagar, Rohtak Road, Peeragarhi,
Delhi-110041
Tel. : 011 - 42010101
Fax : 011 - 42010132
181
FARIDABAD
Regent Automobiles Ltd.
Showroom :
14/3 , Mathura Road, Faridabad - 121 003, Haryana
Tel. : 0129 - 4088530 / 31
Fax : 0129 - 2252304
GURGAON
Bhanu Motors Pvt. Ltd.
Showroom:
Shop No. 4, Omaxe Wedding Mall, Main Sohna Road,
Near Subhash Chowk, Gurgaon - 122001
Tel. : 0124 - 4757777
Workshop:
Plot No. 541, Sector-37, Part-II, Gurgaon - 122001
Tel. : 0124 - 4598888
STATE - HARYANA
AMBALA
Ambala Automobiles India Ltd.
Showroom :
Ramgarh, Near Central Jail Bridge, Chandigarh Road,
Baldev Nagar, Ambala City - 134 003
Tel. : 0171 - 2543010
Fax : 0171 - 2543510
DADRI
Shailesh Automobiles
Showroom & Workshop :
Near Loharu Chowk, Bhiwani Road, Dadri - 127 306
Tel. : 9253660069/70
Workshop 2 :
Plot No.57, Sector-27C, Opp. Crown Interiorz Mall,
13/1, Mathura Road, Faridabad - 121 003
Tel.: 0129 - 2577777
L
L
BHIWANI
Shailesh Automobiles
Showroom & Workshop :
Rohtak Road, Bhiwani - 127021
Tel. : 01664 -204006/008
Workshop 1 :
14/5, Main Mathura Road, Faridabad - 121 003
Tel. : 0129 - 2252151 - 55, 4261200
Workshop 1:
C-13, Plot No. 65, SMA Industrial Area, GTK Road,
Opp. Jahangir Puri, Azadpur, New Delhi - 110 033
Tel. : 011 - 47444777
Workshop :
KH-82/21/2 &22/2, Phirni Road,
Udyog Nagar Industrial Area,
Near Mundka Metro Pillar No.547,
New Delhi - 110 041
Tel. : 011 - 28342884
L
Workshop :
Barwala, Naraingarh Road, Ambala City - 134 003
Tel.: 0171 - 2678013
L
Ganganagar Automobiles Pvt. Ltd.
(Aarav Chevrolet)
Showroom :
11 - A, Shivaji Marg, Moti Nagar,
Opp. L & T Building, New Delhi - 110015
Tel. : 011 - 41238888
Workshop:
56, Rama Road, Opposite Radha Palace Banquet Hall,
New Delhi -110 015
Tel. : 011 - 41238888, 8826292810, 8826292815
Globus Motocorp Pvt. Ltd.
Showroom :
ZB-43 & 44/487, Zulphe Bengal, Main GT Road,
Dilshad Garden, Delhi - 110095
Tel. : 011 - 43355555
L
Gentech Toolings Pvt. Ltd.
Showroom & Workshop :
Plot No. 66, IDC, Opp. Sector - 14
Mehrauli - Gurgaon Road, Gurgaon - 122 001
Tel. : 0124 - 4638751 - 54, 4368787
Fax : 0124 - 4638700
m
L
L
L
L
L
L
Orix Auto Infrastructure Services Ltd.
Workshop :
7B, Sector - 18, Maruti Industrial Area,
Gurgaon - 122 015
Tel. : 0124 - 3014700 / 701 / 719
Fax : 0124 - 3014702
YAMUNA NAGAR
Oberoi Automobiles
Showroom & Workshop :
Aggarsain Chowk, Near Gupta Palace,
Jagadhri - 135 003
Tel. : 01732 - 212030, 212010
KURUKSHETRA
VPS Speciality Papers
Showroom & Workshop :
Plot No.145 &146, Industrial Area, Sector 2,
Kurukshetra - 136 118
Telefax : 01744 - 231050
HISSAR
Ashwani Automotors
Showroom & Workshop :
9 km Stone, OP Jindal Marg, Hissar - 125 044
Tel. : 01662 - 220710 / 11 / 12
JHAJJAR
Shailesh Automobiles
Showroom & Workshop :
Tehsil Road Jhajjar, Haryana - 124 001
Tel. : 9253660066 / 9254171300
JIND
Lekh Raj Motors Pvt. Ltd
Showroom & Workshop:
Safidon Road, opp. Brahmin Dharamsala, Jind.
Tel. : 9992900082
KAITHAL
Lekh Raj Motors Pvt. Ltd.
Showroom & Workshop :
Ambala Road, Kaithal, Haryana - 136027
Tel. : 0174 - 6226827
L
L
L
L
L
L
KARNAL
Aryaman Automobiles
Showroom & Workshop :
117/6, K.M. Milestone, Near Hotel New
World, G. T. Road, Karnal - 132 001
Tel. : 0184 - 2220011, 2220325
TeleFax : 0184 - 2220025
PANIPAT
Aryaman Motors
Showroom & Workshop :
Plot No 64, Sector -25, Huda Industrial Area Phase 1,
Panipat - 132103
Tel. : 0180 - 2666222 / 2666800
ROHTAK
Badhwar Automobiles Pvt. Ltd.
Showroom & Workshop :
Sonepat Road, Rohtak - 124 001
Telefax : 01262 - 256666
REWARI
Vardhman Automobiles Pvt. Ltd.
Showroom & Workshop :
Opp. Gurudwara, Jhajhar Road, Rewari - 123 401
Tel. : 01274 - 250440 / 251188
Fax : 01274 - 255966
SONIPAT
Malwa Motors Sales Pvt. Ltd.
Showroom & Workshop :
NH-1, 31 Km Stone, G.T. Road, Kundli,
Sonipat - 131 001, Haryana
Tel. : 0130 - 2219384 - 85, 2370386, 2371386
Fax : 0130 - 2219384
SIRSA
Padam Motors Pvt. Ltd.
Showroom & Workshop :
Hisar Road, Opp Traffic Police Post, Sirsa - 125055
Tel. : 01666 - 244445
Fax : 01666 - 244442
182
STATE - HIMACHAL PRADESH
L
L
L
L
L
L
KANGRA
Himachal Autowheels Pvt. Ltd.
(Platinum Chevrolet)
Showroom & Workshop :
N.H 20 Kachhiary, Kangra - 176001
Tel. : 01892 - 260600/260601
MANDI
Ram Hari Motors Pvt. Ltd.
Showroom & Workshop :
Rani Ki Bain, Gutkar, Mandi - 175 021
Tel. : 01905 - 225692
Fax : 01905 - 221691
MANALI
Ram Hari Motors Pvt. Ltd.
Showroom & Workshop :
Rotang Road, Village Vishisht Vihal, PO Vashisht,
Tehsil - Manali, Distt - Kullu, Manali - 175131
Tel. : 01902 - 254001
SIMLA
Rajvir Motors
Showroom & Workshop :
Byepass Road, Parasdass Garden, Simla - 171 001
Tel. : 0177 - 2674284 - 6
Fax : 0177 - 2674287
SOLAN
Rajvir Motors
Showroom & Workshop :
Kalka Shimla Road, Near Mehta Market,
Kumarhatti, Solan, Himachal Pradesh - 173 229
Telefax : 01792 - 266338
UNA
Bhagat Ram Motorways Pvt. Ltd.
Showroom & Workshop :
Una Nangal Road, Rakkar Colony, Una - 174 303
Tel. : 01975 - 238799
Fax : 01975 - 238699
STATE - PUNJAB
L
AMRITSAR
S V Motors
Showroom :
Near Amritsar Gate, GT Road, Amritsar - 143001
Tel. : 0183 - 2700102
Fax : 0183 - 2700101
L
L
Workshop :
Main GT Road, Opp. ITBP Office, Amritsar - 143001
Tel. : 0183 - 2700201
L
L
L
L
BATALA
Kashmir Autmobiles Pvt. Ltd. (Platinum Chevrolet)
Showroom & Workshop:
Opp. Cambridge International School, Saidmubarak,
Amritsar Road, Batala - 143505
Tel.: 01871 - 241024
BHATINDA
Padam Cars Pvt. Ltd.
Showroom & Workshop :
Goniana Road, 8th Mile Stone, NH-10,
Bhatinda - 151 005
Tel. : 0164 - 27601111 / 9216350205
Telefax : 0164 - 2760153
JALANDHAR
Aakriti World
Showroom :
Ground Floor, Vasal Tower, Police Lines,
Opp. President Hotel, Jalandhar - 144001
Telefax : 0181 - 5003333
Workshop :
1746 Ladowali Road, Near BSF Chowk,
Jalandhar - 144001
Tel. : 0181 - 5057777
L
L
CHANDIGARH
RSA Motors Pvt. Ltd.
Showroom:
Plot No.5, Industrial Area, Phase-I,
Chandigarh - 160 002
Tel. : 0172 – 5033333,9914110606
Fax. : 0172 - 5033338
L
Work Shop:
Plot No. 2, Industrial Area, Phase-I,
Chandigarh – 160 002
Tel. : 0172 – 5039999,5041233,9814106962
Fax. : 0172 - 5039939
L
Padam Motors Pvt. Ltd.
Showroom:
182/2, Industrial Area, Phase 1, Chandigarh - 160002
Tel. : 0172 - 5212900
HOSHIARPUR
Bedi Automobiles
Showroom & Workshop :
Piplawala, Jalandhar Road, Hoshiarpur - 146 022
Tel. : 01882 - 329696
Fax : 01882 - 253763
LUDHIANA
Padam Cars Pvt. Ltd.
Showroom & Workshop :
Khasra No. 279/3, G.T. Road,
Dhandari Kalan, Ludhiana
Tel. : 0161 - 2510014
Telefax : 0161 - 2510015
Omni Wheels Pvt. Ltd.
Showroom & Workshop :
Plot No 73, New Kuldeep Nagar,
Basti Jodhewal Chowk, Ludhiana - 141 007
Tel. : 0161 - 5055900
Fax : 0161 - 5055911
L
L
L
L
L
183
PATHANKOT
Kashmir Automobiles Pvt. Ltd.
Showroom & Workshop :
Simbel Chowk, Dalhousie Road, Pathankot - 145 001
Tel. : 0186 - 2257022 - 24
SANGRUR
Padam Cars Pvt. Ltd.
Showroom & Workshop :
College Road, Opp. Kamal Palace, Sangrur - 148001
Tel. : 9216350134, 9216911461
AJMER
Rajdeep Autowheels (P) Ltd.
Showroom :
12-15, ASC Road, Vaishali Nagar, Ajmer - 305001
Tel. : 0145 - 2628989 / 2625116
Workshop :
Khasara No-319 Kankarda Bhunaboy, NH-8,
Jaipur Road, Ajmer - 305001
Tel. : 0145 - 2788192 / 93 / 2788222 / 23
L
L
Workshop :
185, Industrial Area, Phase 1, Chandigarh -160002
Tel. : 0172 - 5212999
PATIALA
Padam Cars Pvt. Ltd.
Showroom & Workshop :
Main Patiala - Rajpura Road,
Opp. Caspa Resort, Bahadurgarh, Patiala - 147 001
Tel. : 0175 - 2663813 - 14, 9217100905 - 9
Fax : 0175 - 2663828
STATE - RAJASTHAN
ROPAR
Padam Cars Pvt. Ltd.
Showroom & Workshop :
Chandigarh Road, Nangal Chowk, Ropar - 140 001
Telefax : 01881 - 500099
MOGA
Padam Cars Pvt. Ltd.
Showroom & Workshop :
Near Majestic Resorts, Ferozepur Road,
Moga - 142 001
Tel. : 01636 - 225755
NAWASHAHAR
Aakriti World
Showroom & Workshop :
Chandigarh Road, Nawashahar, Punjab - 144 514
Tel. : 01823 - 285656
Telefax : 01823 - 285858
ALWAR
Triumph Motors
Showroom & Workshop :
Old Delhi Road, Near Jhankar Hotel, Alwar - 301 001
Telefax : 0144 - 3047571 - 78
BHILWARA
Rajdeep Autowheels (P) Ltd.
Showroom & Workshop :
Payal Resort, Ajmer Road, Bhilwara - 311001
Tel. : 01482 - 265164
L
L
L
BIKANER
Sunehri Cars
Showroom & Workshop :
Plot No. 15, Transport Nagar,
NH-15, Ganganagar Road, Bikaner - 334 001
Tel. : 8003399060 / 66 / 69
L
Workshop 2 :
E-12B, Vishwakarma Ind. Area, Road No. 01,
Jaipur - 302013
Tel. : 0141 - 4255555
BANSWARA
Atharva Motors Pvt. Ltd.
Workshop :
Janamedi, Udaipur Road, Banswara - 327001
Tel. : 02962 - 250227
CHITTORGARH
Atharva Motors Pvt. Ltd.
Showroom :
Plot No. 86, Kabir Colony, Bhilwara Road,
Chittorgarh - 312001
Tel. : 01472 - 247598
Fax : 01472 - 247598
Workshop :
Near Saint Paul's School, Opp. Rajasthan State
Seed Corp., Nimbhera Road, Chittorgarh - 312001
Tel. : 01472 - 240598
L
Workshop 1 :
G-109A, Sitapura Industrial Area, Jaipur - 302 004
Tel. : 0141 - 5122333, 5113636, 5143737,
5122797, 5122798, 5143636, 4090409
Fax : 0141 - 5122552
Showroom 2 :
C7D, Sawai Jai Singh Highway,
Bani Park, Jaipur - 302016
Tel. : 0141 - 4122222
Fax : 0141 - 4122233
L
Workshop 3 :
E1 - 2295, Ramchandrapura Industrial Area,
Sitapura Ext, Jaipur - 302022
Tel. : 0141 - 4090409
L
L
L
CHOMU
Triumph Motors
Showroom & Workshop :
Near Radha Soami Bagh, Jaipur Road,
Chomu - 303702
Tel. : 0142 - 3304000
JAIPUR
Triumph Motors
Showroom 1 :
Corporate Tower, A-1, Jawahar Lal Marg,
Jaipur - 302015
Tel. : 0141 - 4057575
Fax : 0141 - 4057500
L
JHUNJUNU
Triumph Motors
Showroom & Workshop :
G1-8, 9 & H1-16,17, Phase – 2, RIICO Industrial Area,
Jhunjhunu – 333001
Tel. : 01592 -203163, 250001-3, 250145, 250146
JODHPUR
Atharva Motors Pvt. Ltd.
Showroom :
27/27A, Light Industrial Area,
Near Shastri Circle, ITI Road, Jodhpur - 342 003
Tel. : 0291 - 3048491
Workshop :
E-711, Mia Bsni, IInd Phase,
Behind Krishna Dharam Kanta, Jodhpur - 342 005
Tel. : 0291 - 3048217 - 22
Fax : 0291 - 3048223
L
L
184
SRI GANGANAGAR
Sunehri Cars
Showroom & Workshop :
6th Km Stone, Surat Garh Road, NH-15,
Sri Ganganagar
Tel. : 8003399070 / 71
UDAIPUR
Atharva Motors Pvt. Ltd.
Showroom & Workshop :
A-83, Mewar Industrial Area, Madri, NH-8,
Ahmedabad Bye Pass, Udaipur - 313 002
Tel. : 0294 - 3002730, 3002769
Fax : 0294 - 2490108
STATE - UTTAR PRADESH
L
L
KOTA
Triumph Motors
Showroom & Workshop :
E - 137C, Road No. 5,
Indraprastha Industrial Area, Kota
Tel. : 0744 - 2372333, 2372666
PALI
Atharva Motors Pvt. Ltd.
Showroom & Workshop :
Opp. Krishi Mandi, Jodhpur Road, Pali - 306401
Tel. : 9414060104
SIKAR
Triumph Motors
Showroom & Workshop :
Near Circuit House, NH-11, Jaipur Sikar Road,
Sikar - 332001
Tel. : 01572 - 245971
ALIGARH
Jattari Automobile
Showroom & Workshop :
300 Mtr. From, Bharat Petrol Pump,
Khair By Pass Road, Aligarh - 202001
Tel. : 8938802229, 8938802214
ALLAHABAD
Eldee Motors
Showroom :
Eldee Enclave, 2, S.P. Marg, Civil Lines,
Allahabad-211 001
Tel. : 0532 - 2560743, 44
Workshop :
Kanodia Mill Compound 1, Luker Ganj,
Allahabad - 211 001
Tel. : 0532 - 2616368
L
AGRA
Kalyan Auto Sales
Showroom & Workshop :
Opp. Bhagwati Dhaba, Near New Sabji Mandi,
Sikandra, Agra - 282 007
Tel. : 0562 - 2640460 / 62 / 63
Fax : 0562 - 2640461
L
L
L
BAREILLY
VAT Motors Pvt. Ltd.
Showroom & Workshop :
4.5 KM, Rampur Road, CB Ganj, Bareilly - 243 001
Tel. : 0581 - 2560741
Fax : 0581 - 2560731
FAIZABAD
Megha Auto (I) Pvt. Ltd.
Showroom & Workshop :
Lucknow Byepass Road, Sahadatganj,
Faizabad - 224 001
Tel. : 09839099210
GORAKHPUR
United Motors
Showroom :
Kasia By-pass Road, Near Dr. Riyaz Ortho Hospital,
Mohaddipur, Gorakhpur -273001
Tel.: 0551-2201667
Fax.: 0551-2338299
Workshop 1 :
C-15A, Panki Industrial Area, Site-1, Kanpur - 208012
Tel.: 0512 - 2691293, 2691377
Workshop 2 :
122/236, A-1 & C-1, Fazalganj,
Near Sangam Talkies, Kanpur - 208012
Tel.: 8009461111
L
Workshop :
Saryu Nahar Colony, Singharia,
Gorakhpur-Deoria Road, Gorakhpur - 273008
Tel.: 0551-2270231
L
GHAZIABAD
Shiva Motors
Showroom & Workshop :
28/3/5, Site - IV, Industrial Area,
Sahibabad, Ghaziabad
Tel.: 0120 - 3008600 / 605 / 631 / 632 / 635 / 636
Fax: 0120 - 3008643 / 45 / 48 / 49 / 50
L
JHANSI
Sri Venkateshwar Autocare Pvt. Ltd.
Showroom & Workshop :
Jhansi Kanpur Road, Goramachhiya, Jhansi - 284001
Tel. : 0510 - 2371144, 6450158
KANPUR
Cross Road Auto Pvt. Ltd.
Showroom :
40, Government Industrial Estate,
Opp. Sindhi Colony, Fazal Ganj, Kanpur - 208 012
Tel.: 0512 - 2221276 / 2220043
L
L
L
L
L
LUCKNOW
Megha Auto (I) Pvt. Ltd.
Showroom & Workshop :
10/CP/5, Ring Road, Vikasnagar,
Opp. Jagrani Hospital, Lucknow - 226 020
Tel. : 0522 - 4057999 / 4007977 / 2330180
L
MATHURA
Kalyan Auto Sales
Showroom :
NH-2, Agra-Matura Road, Mathura
Tel. : 9927000967
MEERUT
Vardajyoti Automobiles Pvt. Ltd.
Showroom & Workshop :
Madhuban Cinema Bldg., Madhuban Colony,
Baghpath Road, Meerut - 250 002
Tel. : 0121 - 2404005 - 08
Fax : 0121 - 2404009
MORADABAD
Siggma Motors Pvt. Ltd.
Showroom & Workshop :
Near Radhakrishna Mandir,
Delhi Road, Moradabad - 244001
Tel. : 0591-2550100-05, 7351007701-05, 7351003805
185
MIRZAPUR
Saraswati Industries
Showroom & Workshop :
Pili Kothi, Station Road, Mirzapur - 231001
Tel. : 05442 - 223923
NOIDA
Shiva Motors
Showroom :
G-24, Sector 11, Noida - 210301
Tel. : 0120 - 3920150 / 158
Workshop :
C-80/81A, Sector - 8, Noida
Tel. : 0120 - 3359807 / 813
Workshop 2:
Mishipur Depot, Near Sanatan Cold
Storage, Kursi Road, Lucknow - 226 026
Tel. : 0522 - 2890631
Workshop 2 :
58/3, Site 04, Sahibabad, Ghaziabad - 200300
Tel. : 0120 - 4558765
L
L
Romi Motors Pvt. Ltd.
Showroom :
14/63, Civil Lines, Kanpur - 208 001
Tel.: 0512 - 3224703
Workshop :
120/192 (4), Lajpat Nagar,
Near Mariampur Crossing, Kanpur - 208 012
Tel. : 0512 - 3224701 / 3224702
L
L
SAHARANPUR
DPM Autosales
Workshop :
Ambala Road, Near Badi Nahar, Saharanpur
Tel. : 0135 - 2640877
SHAHJAHANPUR
VAT Motors Pvt. Ltd.,
Showroom & Workshop :
Axis Chevrolet, 4.5 Km, Bareilly Road, Mauzampur,
Shahjahanpur - 242001
Tel. : 8795030111
VARANASI
Vinayak Automotive Pvt. Ltd. (Vinayak Chevrolet)
Showroom & Workshop :
Adjacent to Essar Petrol Pump, Jagatpur, Rohania,
Varanasi - 221313
Tel. : 7703003320, 7703003330, 7703003321,
7703003333
STATE - UTTARAKHAND
L
DEHRADUN
DPM Autosales
Showroom & Workshop :
Mohabewala Industrial Area,
Saharanpur Road, Dehradun
Tel. : 0135 - 2642051 / 52 / 53
Fax : 0135 - 2642054
L
HALDWANI
Analysis Motors
Showroom :
Rampur Road, Near Sushila Tewari Hospital,
Haldwani - 263139, Distt. Nainital
Tel.: 9258071041,9258071009
Workshop :
7.5km Stone, Gora Padav, Bareilly Road,
Haldwani-263641
Tel. : 05946 - 232050
L
RUDRAPUR
Analysis Motors
Showroom :
Near Axis Bank, Nanital Road, Rudrapur - 263 153
Tel. : 9258071011
Workshop:
Industrial Area Kiccha Bypass Road,
B-27, Rudrapur - 263153
Tel:. 05944 - 243836
STATE - JAMMU & KASHMIR
L
L
L
JAMMU
K. C. Motors
Showroom & Workshop :
NH-1, Byepass Road, Jammu - 180 004
Tel. : 0191 - 2465769 / 59, 2460829
Fax : 0191 - 2476660
RS PURA
K. C. Motors
Showroom & Workshop :
Bagha Marh, RS Pura, Jammu
Tel. : 01923 - 252809
Fax : 01923 - 252809
SRINAGAR
K. C. Motors
Showroom & Workshop :
By Pass Road, Hyderpora, Srinagar - 190 014
Tel. : 0194 - 2443188
186
WEST ZONE
L
STATE - GOA
L
VASCO-DA-GAMA
Subrai Motors Pvt. Ltd.
Showroom & Workshop :
F L Gomes Road, Vasco-Da-Gama, Goa - 403 802
Tel. : 0832 - 2517421 / 22
Fax : 0832 - 2513924
L
STATE - GUJARAT
L
AHMEDABAD
Gallops Motors Pvt. Ltd.
Showroom & Workshop :
Near JCB Service Station, S.G. Highway,
Sarkhej, Ahmedabad - 380 015
Tel. : 079 - 2474346, 39835544, 39835501
Fax : 079 - 39835588
Showroom 2 :
A/8,9,10,11,12,13 & 14, Radhe Shopping Mall,
Khokhra, Maninagar, Ahmedabad
Tel. : 079 - 32941862 / 32440235
Showroom 3 :
Vedas Ground Floor, Opp SBI Saijpur Branch,
NH 8 Naroda, Patia Cross Road, Ahmedabad - 382325
Tel. : 079 - 22820106
L
L
ANAND
Shree Gopinathji Agencies
Workshop :
Survey No. 570 - A/2, Near Indira Statue,
Lambhavel Road, Anand - 388 001
Tel. : 02692 - 247979 / 247878
BHAVNAGAR
V Raj Motors
Showroom & Workshop :
Plot No. 150, Near Press Quarter,
Opp. Maruti Showroom, Bhavnagar-Rajkot Road,
Chitra, Bhavnagar - 364 003
Tel. : 0218 - 2444590, 2444445
BHUJ
Cargo Motors
Showroom & Workshop :
Plot No. 10, Survey No. 29/1,
Bhuj - Mirzapur Road, Bhuj - 370001
Tel. : 02832 - 654191 / 654192
L
L
L
L
GANDHIDHAM
Cargo Motors
Showroom & Workshop :
NH-8A, Kandla Port Road, Gandhidham - 370 201
Tel. : 02833 - 654370, 653317, 9825611692
L
L
GODHRA
Shree Gopinathji Agencies
Showroom & Workshop :
Moonlight Cinema Compount, Vavdi,
Godhra - 389 001
Tel. : 02672 - 645828, 265270, 265271
GANDHI NAGAR
Gallops Motors Pvt. Ltd.
Showroom & Workshop :
Near Nigam Petrol Pump, Rajshree Cinema Road,
Sector-21, Gandhinagar - 382 010
Tel. : 0232 - 30516107
HIMMATNAGAR
Gallops Motors Pvt. Ltd.
Showroom & Workshop :
Near Motipura Circle, Opp. S.T. Workshop,
Shamlaji Highway, Himmatnagar - 383 001
Tel. : 02772 - 229525, 229524, 308000, 308001
187
JAM NAGAR
Gallops Motors Pvt. Ltd.
Showroom :
Jamnagar - Rajkot Highway, Hapa,
Opp. Tata IB Motors, Jamnagar
Tel. : 0288 - 3216060
Workshop :
Jamnagar to Rajkot Highway, 8 - Happa,
Jamnagar - 320 120
Tel. : 0288 - 3921194 - 98
L
Workshop 2 :
Opp. Amraivadi Post Office, Near Hatkeswar Circle,
Maninagar, Ahmedabad - 380 026
Tel. : 079 - 30486501 / 02 / 03
L
BHARUCH
Shree Gopinathji Agencies
Showroom & Workshop :
Beside K.U & Company Petrol Pump,
NH-8, Village Vadadala, Bharuch - 392 015
Tel. : 02642 - 654245, 291303, 654845
Telefax : 02642 - 231584
L
MEHSANA
Gallops Motors Pvt. Ltd.
Showroom & Workshop :
Opp. Wide Angle, Nagalpur Highway,
Mehsana - 384 002
Tel. : 02762 - 241010, 302401 / 02 / 06
Fax : 02762 - 245151
NAVSARI
Monarch Motors
Showroom & Workshop :
Mahalaxmi Estate, Near Bhana Petrol Pump,
Near Grid Char Rasta, N.H. No. 8, Navsari - 396424
Tel. : 02637 - 265788 / 265599
PALANPUR
Gallops Motors Pvt. Ltd.
Showroom & Workshop :
Survey No. 525/1, Palanpur – Delhi Highway,
Near Palanpur - Deesa Char Rasta, Palanpur - 385001
RAJKOT
Gallops Motors Pvt. Ltd.
Showroom & Workshop :
Survey No. 219/220, Opp. Parin furniture,
Next to Jay Ganesh, AT & PO,
Kotharia Gondal Highway, Rajkot - 360 003
Tel. : 0281 - 3205151, 2370006 / 8 / 9 / 10,
3983400, 3983407
Showroom 2:
Ground Floor, Fortune Square, Jalaram Street,
Near Kotecha Circle, Kotecha, Rajkot - 360001
Tel. : 9909992033
L
L
SURAT
Empire Cars Pvt. Ltd.
Showroom & Workshop :
Plot No. 3, Near Rangoli Hotel, Rundh,
Dumas Road, Surat - 395007
Tel. : 0261 - 6713300 / 33
L
Nanavati Motors
Showroom:
Orchid Tower, Opp Intercity Township,
Puna Kumbharia road, Surat-395010
Tel.: 9879114447
Workshop :
Opp. SBI Bank, Puna Patiya,
Puna Kumbhariya Road, Surat-395010
Tel. : 0261-6456449/429/430
Fax : 0261-2647771
L
L
SURENDRA NAGAR
Gallops Motors Pvt. Ltd.
Showroom & Workshop :
Plot No. 267, GIDC Vadhvan, Opp. Market Yards,
Near Rekha Bearings, Surendra Nagar
Tel. : 02752 - 321542 - 43
VAPI
Desai Automobiles
Showroom & Workshop :
At & Po : Balitha, Near Woodland Hotel,
National Highway No. 8,
Taluka Pardi, Vapi, Valsad - 395 015
Tel. : 0260 - 6531783, 2400250 - 51
Fax : 0260 - 2426525
L
Showroom & Workshop 2 :
R. S. No. 7, Opp. Atladra Railway Station,
Atladra, Vadodara - 390 012
Tel. : 0265 - 2681050, 1060, 0187, 1010, 1020
Fax : 0265 - 2681050, 2354984
Monarch Cars Pvt. Ltd.
Showroom:
Umiya Nagar Society,
Near Shree Choshath Joganiyo Mata Mandir,
Udhna Magdalla Road, Surat-394210
Tel.: 0261-2720481, 2720482, 09825274707
Showroom & Workshop 3 :
3/A, Sahajanand Industrial Estate,
Munjmahuda, Akota, Vadodara - 390 020
Tel. : 0265 - 2681010, 2681020, 2359898, 2334109
Fax : 0265 - 2681050, 2681060
Workshop :
Next To Sameeti School, Patel Nagar Circle,
Udhna Gam, Surat - 394210
Tel.: 0261-3091001
L
VADODARA
Shree Gopinathji Agencies
Showroom & Workshop :
Opp. Gujarat Elec. Board Sub Station,
(Near Prakuti Resort), Chhani, Baroda - 390002
Tel. : 0265 - 2761105 / 06
Workshop :
49, United Compound, Iasudiya Mori,
Dewas Naka, Indore
Tel. : 0731 - 470055, 56, 57
Fax : 0731 - 470054
L
STATE - MADHYA PRADESH
L
L
BHOPAL
Super Cars Ltd.
Showroom & Workshop :
Plot No. 21 Sector G, Govindpura Industrial Area,
J.K. Road, Bhopal - 462 021
Tel. : 0755 - 4028400, 4228201
Fax : 0755 - 4228203
L
L
L
L
GWALIOR
Sumedha Vehicles Pvt. Ltd.
Showroom & Workshop :
Opp. Jhansi Road Police Station,
Jhansi Road, Gwalior - 474 009
Tel. : 0751 - 2422067, 4015789, 3291856
Fax : 0751 - 2348024
188
Chhabra Autolink Pvt. Ltd.
Showroom :
Plot no.-10 Vishnupuri Main, Near Medisquare
Hospital, Indore - 452001
Tel : 0731- 4267800
Workshop :
Plot no.- 11/11,11/12, Survey no.- 26, Gram Palada,
Khandwa Road, Indore - 452011
Tel : 0731 - 6656000
Varenayam Motors
Showroom & Workshop :
189, Angoori Bagh, Jinsi Road, Bhopal - 462008
Tel. : 0755 - 2575288 / 299 / 300
Fax : 0755 - 2579918
CHHINDWARA
Sunshine Motors
Showroom & Workshop :
College Road, Lalbagh, Chhindwara- 480001
Tel. : 0716 - 244125, 244129, 244193 / 194
Fax : 0716 - 244126
INDORE
Super Cars Ltd.
Showroom :
Saket Tower - 3A, Ratlam Kothi,
Near Geeta Bhavan Square, AB Road, Indore - 452 001
Tel. : 0731 - 4700053, 54
Telefax : 0731 - 4700052
L
JABALPUR
Oriental Motors
Showroom & Workshop :
497, Karmeta, Near Padwar Kala,
Katangee Bye Pass Road, Jabalpur - 482 003
Tel. : 0761 - 3250007, 3260002, 3250003, 3290001
Fax : 0761 - 4027011
KHANDWA
Bedi Motors
Showroom & Workshop :
Gram Rehmapur, Indore Road, Khandwa - 450 001
Tel. : 0733-2244075
RATLAM
Super Cars Ltd.
Showroom & Workshop :
Jaora Road, Near RTO Office, Ratlam - 457 001
Tel. : 07412 - 260040
L
SATNA
Oriental Motors
Showroom :
Virat Nagar Colony, Pateri, Panna Road, Satna - 485 001
Tel. : 07672 - 229495
Workshop :
27, Industrial Area Near Union Floor, Rewa Road,
Satna - 485001
Tel. : 7672 -252763
L
L
STATE - MAHARASHTRA
L
L
L
L
AHMEDNAGAR
Saideep Cars Pvt. Ltd.
Showroom & Workshop :
Survey No. 55/1B/2/1, Nagar Manmad Road,
Ahmednagar - 414 111
Tel. : 0241 - 2779225 - 7
Fax : 0241 - 2779228
AKOLA
Star Motors
Showroom & Workshop :
9/1, Geeta Nagar Near, Alankar Petrol Pump,
Akola - 444 005
Tel. : 07242800087 / 7350008428
AMRAVATI
Star Motors
Showroom & Workshop :
Plot No. 8, Navathe Square Bandnera Road, Amravati
Tel. : 0721 - 2510199, 9921008861, 7350008426
L
L
L
AURANGABAD
Soham Motors Pvt. Ltd.
Showroom & Workshop :
Plot No. 2 & 3, N-2, Mukundwadi, Airport Road,
Aurangabad - 431 003
Tel. : 0240 - 6603769, 6503769
Workshop 2 :
Plot No. 28 & 29, MIDC Chikalthana, Aurangabad
Tel. : 0240 - 2489411, 2474342 - 6
BARAMATI
Mota Automotive Pvt. Ltd.
Showroom & Workshop :
41 / 1 / B / 17, Nira Road, Kasba, Tehsil - Baramati,
Dist - Pune - 413102
Tel. : 02112 - 222212, 220212
CHANDRAPUR
ND Cars Pvt. Ltd.
Showroom & Workshop :
Gajanan Maharaj Mandir Square, Bapat Nagar,
Nagpur Road, Chandrapur - 442401
Tel.: 07172 - 646344/22
MUMBAI
Ashtavinayak Auto Pvt. Ltd.
Showroom :
D Mall, Off Veera Desai Road, Andheri (West),
Mumbai - 400 053
Tel. : 022 - 66488888
Fax : 022 - 66488880
Workshop :
Ram Mandir Road, Somani Gram,
Next to Central Warehouse Corporation,
Oshiwara, Goregaon (West), Mumbai - 400 051
Tel. : 022 - 26765555
DHULE
Jitendra Wheels Pvt. Ltd.
Showroom & Workshop :
P-62, Behind Hotel Manas, MIDC Avdhan,
Dhule - 424 001
Tel. : 02562 - 281222 / 232
L
AVK Automart Pvt. Ltd.
Workshop :
Fida Hussain Industrial Estate,
Near Samrat Hotel, Pandurang Wadi Road,
Mira Road (West), Mumbai - 401 104
Tel. : 022 - 28453178, 28455507, 28453564
JALGAON
Soham Motors Pvt. Ltd.
Showroom & Workshop :
93/1, MIDC, RL Square Aurangabad Road,
Jalgaon - 425003
Tel. : 0257-2211151, 2270085
L
Nikhil Automobiles Pvt. Ltd.
Showroom & Workshop 1 :
A 70, TTC Industry Area, Thane Belapur Road,
Kharghar, Near ICI Color Company,
Khoparkaine West, Navi Mumbai - 400 709
Tel. : 022 - 27780801, 40708888
Fax : 022 - 40708899, 27780805
KOLHAPUR
Unique Automobiles
Showroom & Workshop :
122/1, Pulachi Shiroli, Opp. Sangli Phata,
Kolhapur - 416 122
Tel. : 0230 - 2461518 - 19
Fax : 0230 - 2461520
Showroom 2 :
Ayodhya Park, Opp. Sangam Talkies,
Kavala Naka, Kolhapur - 416 001
Tel. : 0231 - 2535315, 2535425
Fax : 0231 - 2535615
L
L
LATUR
Ajinkya Cars Pvt. Ltd.
Showroom & Workshop :
Barshi Road, Near Bidave Engineering College,
Beside Pramod Petrol Pump, Latur - 413531
Tel. : 02382 - 222600
189
Showroom 2 :
264-265, Vaswani Chambers, Opp. Old Passport
Office, Pravhadevi, Mumbai - 400 025
Tel. : 022 - 434594444, 24221711-12
Fax : 022 - 24222713
Workshop 2 :
C/o Bharat Tiles & Marbles Ltd.,
Jaibhimnagar, Dharukhana Road, Reay Road (East),
Near Sujala Hotel, Mumbai - 400 010
Tel. : 022 - 64560303, 23774514 / 15 / 16
Fax : 022 - 23774505
Workshop 3 :
Plot No. D - 238 - A, TTC Industrial Area,
MIDC Shiravane, Nerul, Navi Mumbai - 400 706
Tel. : 022 - 43448800
Workshop 4:
RC 27 F - O/W/P23, Brick Bunder Sewri,
Haybunder Road, Kala Chowki, Mumbai - 400033
Tel.: 022 - 64560303
L
JMD VFM Cars India Pvt. Ltd.
Showroom :
471 A- 1st Floor KK Square, Adjoining Solitaire
Corporate Park, Near P&G Plaza Andheri (East),
Mumbai - 400099
Tel : 022- 28565900/02/03
L
L
Workshop :
Plot No. 48-A,Khairani Road, Opp. Gundecha
Chambers off, Sakivihar Road, Sakinaka Andheri
(East), Mumbai - 400072
Tel : 022- 28565900/01/02
L
L
L
NASIK
Jitendra Wheels Pvt. Ltd.
Showroom & Workshop :
B-88, Arihant Plaza, MIDC, Ambad, Next to Hotel Taj,
Mumbai - Agra Highway, Nasik - 422 010
Tel. : 0253 - 2384432 / 632 / 832, 6636666, 6637777
Fax : 0253 - 2384532
PUNE
Platinum Chevrolet
Showroom & Workshop 1 :
Sr No 45/1/B/A, Shankarseth Road, Gutkewadi,
Pune - 411037
Tel. : 020 - 26440029
L
L
L
L
Workshop 1 :
Reality Warehousing Pvt. Ltd., Gate No. 1337 / 1,
Pune Nagar, Wagholi, Pune - 412 307
Tel. : 020 - 46609999
Tajshree Motors Pvt. Ltd.
Showroom :
Plot No. 1 Hindustan Colony, Wardha Road,
Nagpur - 440 002
Tel. : 0712 - 2250242 / 2250243 / 2250244
L
190
YAVATMAL
SARAS MOTORS
Pobaru Marketing & Agencies Pvt. Ltd.
Showroom :
Shop No. 5,6,7,8 Udhyog Bhavan,
Dharwha Road, Yavatmal - 445 001
Tel. : 07232 - 255991
Fax : 07232 - 255992
Workshop :
Block No. B-16 MIDC (Lohara), Yavatmal - 445001
Tel. : 07798883816
Fax : 07232 - 255992
Workshop 2 :
Patel Tiles Compound, Sr.No. 42/1, Shivaji Nagar,
Behind ST Bus Stand, Pune - 411005
Tel. : 020 - 32424202, 65270809, 7774010500
SATARA
Unique Automobiles
Showroom & Workshop :
41, Mutha Colony, Sadar Bazar, Satara - 416 002
Tel. : 09623225299
SANGLI
Unique Automobiles
Showroom :
442-3, Kulkarni Complex, 100 feet road,
South Sivaji Nagar, Sangli - 416 416
Tel. : 0233 - 2326544
Fax : 0233 - 2326594
Workshop :
Kulkarni Complex, 100 Feet Road,
Near MSEB Sub-Station, Sangli - 416 416
Tel. : 0233 - 2326544
Fax : 0233 - 2326594
Singh Cycle & Motor Co.
Showroom 1 :
S. No. 38/4, Krishna Complex, Hadapsar Bypass
Road, Near Radisson Hotel, Kharadi, Pune - 411 014
Tel. : 020 - 32419385 / 32319526
Showroom 2 :
ICC Trade Centre, Showroom No. 4, Survey No. 403
A/2, Senepati Bapat Road, Pune - 411016
Tel. : 020 - 25666941 / 2 / 3 / 4
SOLAPUR
Gandhi Wheels
Showroom :
163/1, Railway Lines, Solapur - 413 001
Telefax : 0217 - 2629400
Workshop :
Vale, Pune Road, Solapur - 413 001
Tel. : 0217 - 2500800
Showroom & Workshop 2 :
Survey No 5/4, Najhate Nagar, kalewadi Main Road,
Thergaon, Pune - 411033
Tel. : 020 - 66326600, 66326632, 66326666
NAGPUR
Star Motors
Showroom & Workshop :
44 / 4, Wahajara, Kamptee Road,
NH - 7, Nagpur - 440 026
Tel. : 0712 - 6507836/37, 6507916, 6461503 / 04
Fax : 0712 - 2632429
Workshop :
Plot No. 679, Ghat Road,
Near Cotton Market Square, Nagpur - 440 018
Tel. : 0712 - 2734466 / 2734467
NANDED
Bafna Automotives
Showroom & Workshop :
Gut No. 235, Pimpalgaon (Mahadeo),
Nanded – Akola Road, Nanded - 431 607
Tel. : 02462 - 274069 / 652099, 311102
L
THANE
SC Auto Corporation
Showroom:
Modi House, Opp. to LIC Building, Naupada,
Eastern Express Highway, Thane (West),
Thane - 400 602
Tel. : 022 - 67610000
Fax : 022 - 67610209
Workshop :
Pioneer Estate Corporation, 133-134,
Pokhran Road No.2, Opp. Oswal Park,
Thane (West) - 400601
Tel. : 022 - 66040000
Fax : 022 - 66040102
L
Angel Auto World Pvt. Ltd.
Showroom & Workshop 1 :
Grishma garden, Gokhivare, Vasai East, Thane,
Mumbai (Vasai) - 401208
Tel :0250-6453030 /6061777
Showroom & Workshop 2 :
J-176, MIDC, Tarapur Road,
Boisar (West) - 401505
Tel. : 02525 - 655454 / 655353
L
Nikhil Automobiles Pvt. Ltd.
Showroom & Workshop :
Survey No.6, Hissa No.6, Manpada Gaon,
Kalyan Shill Road, Dombivali (East) - 421204.
Tel. : 0251-3048888/3048899
STATE - CHATTISGARH
L
L
BILASPUR
Vardhaman Motors
Showroom & Workshop :
Near Uslapur Railway Crossing, Mungeli Road,
Sakri, Bilaspur
Tel. : 07752 - 217934 / 217935
RAIPUR
Vardhaman Motors
Showroom & Workshop :
9/1, Mahoba Bazar, GE Road, NH-6,
Kumhari Dist. - Durg, Raipur - 492 001
Tel. : 7489177999, 7883221999
Showroom 2 :
Ashoka Millenium, Ring Road,
Raipur - 492 0011
Tel. : 7714030104, 7712410008
191
SOUTH ZONE
L
STATE - ANDAMAN & NICOBAR
L
PORTBLAIR
Group Engineers
Showroom :
Prem Nagar Junction, (SY No 1394/1),
Haddo Post Port Blair - 744102
Tel. : 03192 - 230301, 242901
L
Showroom 3 :
Plot No.3 & 4, Ravi Colony, Main Road,
Kondapur, Hyderabad - 500084
Tel. : 040 - 45469999 / 89 / 79 / 69
Fax : 040 - 45469959
L
ANANTPUR
Dheeraj Motors
Showroom & Workshop :
Survey No. 239/2C & 241/1C, Kakkapali Gram
Panchayat, Opp. Sakshi News Paper Office,
Anantapur - 515 001
Workshop 2 :
1-8-670, Azamabad, RTC 'X' Road, Hyderabad-500020
Tel. : 040 - 27668678 / 27668761
Fax : 040 - 27668632
Workshop 3 :
Plot No. 21, Mini Industrial Estate,
Hafeezpet Road, Kondapur, Hyderabad - 500049
Tel. : 040 - 31906677
BHIMAVARAM
Orange Auto Pvt. Ltd.
Showroom & Workshop :
Door No. 2-25, # 6, Near Bharath petroleum bunk,
Undi Road, Bhimavaram - 534 202
Tel. : 9052781234 / 905224678
CHITTOOR
M.G. Brothers Automobiles (P) Limited
Showroom & Workshop :
NH 4, Near Iruvaram Check Post, Chittoor - 517 001
Tel.: 92470 00003, 9247000027
GUNTUR
Fusion Motors
Showroom & Workshop :
Plot No. 296 & 297, Opp. Sarvani Diesel Enginnering,
Autonagar Main Road, Autonagar, Guntur - 522001
Tel. : 0863 - 6454545
Showroom & Workshop 3 :
A2, Balanagar Techno Craft Industrial Estate,
Balanagar, Hyderabad - 500 037
Tel. : 040 - 23721111
Fax : 040 - 23729999
L
STATE - ANDHRA PRADESH
L
Showroom & Workshop 2 :
16-2-705/1/1, Malakpet, Opp. Srukrupa Market,
Hyderabad - 500 036
Tel. : 040 - 66815555
Fax : 040 - 66179999
Showroom 2 :
House No. 1-3-1045, Viceroy Hotel Lane,
Kawadiguda Road, Hyderabad - 500 080
Tel. : 040 - 27532385 - 89
Fax : 040 - 27532384
Workshop :
Opp Womens Working Hostel, Dollygunj,
Port Blair, Junglighat Post, Portblair - 744103
Tel. : 03192 - 253044 / 253011
L
HYDERABAD
Kun Automobiles (P) Ltd.
Showroom & Workshop 1 :
Plot No. 74, Snehapuri Colony, Near Andhra Bank,
Nagole Main Road, Nagole, Hyderabad – 500 035
Tel. : 040 - 24220013, 44886666, 44886767/700/701
Fax : 040 - 24220313
L
L
Workshop 4 :
Plot No.37, Survey No.45,Vignan Junior College
Road, Kundapur, Hyderabad - 500081
Tel. : 040 - 31906699
L
L
192
KHAMMAM
Fusion Motors
Showroom & Workshop :
Plot No. 11, Sri Sri Circle, Opp. Reliance Petrol Bunk,
Rotary Nagar, Bypass Road, Khammam - 507 002
Tel.: 9247623666, 8096991122
KURNOOL
Dheeraj Motors
Showroom :
Survey No. 133/1a & 131/1, NH-7,
Near Eenadu Press Office, Kurnool - 518 004
Tel. : 08518 - 253777
Fax : 08518 - 251777
Workshop :
NH-7 Road, Near APSP 2nd Battalian,
Ballary Chowrasta, Kurnool - 518 004
Tel. : 8518 - 253777
Orange Auto Pvt. Ltd.
Showroom 1 :
6-3-249/3, Abhinandan Towers, Road No. 1,
Banjara Hills, Hyderabad - 500 034
Tel. : 040 - 66515555
Fax : 040 - 66469999
Workshop 1 :
B-45/46, Industrial Estate, Near Andhra Bank
Sanatnagar, Hyderabad - 500 018
Tel. : 040 - 66265555 / 66269999
KARIMNAGAR
Kun Automobiles (P) Ltd.
Showroom & Workshop :
M.No.8-6-128, Kothi Rampur, Hyderabad Highway
Road, Karim Nagar - 505 001
Tel. : 0878 - 2276633 / 9885520022
Fax : 0878 - 2276633
NELLORE
M.G. Brothers Automobiles (P) Limited
Showroom:
26-2-1777, Near Ayyappa Temple, Vedayapalem Area,
Nellore-524004
Tel:. 9247000000
Workshop :
Plot No. 95 & 96, Wood Complex,
Near Ayyappa Temple, Nellore - 524004
Tel. : 9247000022
L
L
RAJAHMUNDRY
Orange Auto Pvt. Ltd.
Showroom & Workshop :
D. No. 82-10-2, Venkateswara Nagar,
Near Lalacheruvu, Near ONGC Complex, NH-5 Road,
Rajahmundry - 533 103
Tel. : 0883 - 6575555 / 6580888
TIRUPATHI
M.G. Brothers Automobiles (P) Limited
Showroom:
11-46/A, Renigunta Road, Tirupathi - 517501
Tel.: 9299999970
Workshop :
Plot No: 254, Auto Nagar,
Near Vinayaka Temple, Renigunta Road,
Tirupathi - 517506
Tel.: 9247000024
L
L
WARANGAL
Kun Automobiles (P) Ltd.
Showroom :
Door No. 15-2-4-1-1 & 15-2-4,
Mulugu Cross, Warangal - 506 007
Tel. : 0870 - 2421955
Fax : 0870 - 2421955
Showroom 3 :
14, Langford Avenue, Langford Road,
Bangalore - 560 025
Tel. : 080 - 4330300
Showroom 4 :
No. 300 A - 70, 36th Cross, 10th Main,
5th Block, Jay Nagar, Bangalore - 560 041
Tel. : 080 - 42542999
Showroom 5 :
# 95/3, Doddanekundi Village, Karthik Nagar,
Marathahalli, Bangalore - 560037
Tel. : 080-30651404
STATE - KARNATAKA
L
VISHAKHAPATNAM
Orange Auto Pvt. Ltd.
Showroom & Workshop :
D. No.38-22-87, Varun Avenue, NH-5, Murali Nagar,
NH. Birla Junction, Vishakhapatnam - 530 075
Tel.: 0891 - 2572222, 9052402345
VIJAYWADA
Fusion Motors
Showroom :
Fusion Towers, 36-12-2, Opposite to Siddartha
Public School, Moghul Rajapuram,
Vijayawada - 520 010
Tel. : 0866 - 6645555 / 9603123666
Fax : 0866 - 6645592
Showroom & Workshop 2 :
No. 122/1, C. Shankar Reddy Layout, Kalyana Nagar,
Outer Ring Road, Bangalore - 560 043
Tel. : 080 - 43430300, 43430500
Fax : 080 - 43430308, 43430517
Workshop :
H. No. 23-6-132, Hunter Road,
Opp. Citizens Club, Warangal
Tel. : 0870 - 2523377 / 88 / 99
Fax : 0870 - 2523399
BANGALORE
Kropex India Ltd.
Showroom & Workshop :
49/1, Singasandara, Hosur Main Road,
Bangalore - 560 068
Tel. : 080 - 43574357
Fax : 080 - 43574353
Workshop 3 :
No. 558/1,60 ft Road, 9th Cross, HAL 2nd Stage,
Old Airport Road, Behind Leela Palace,
Kodihalli, Indiranagar, Bangalore - 560008
Tel. : 080 - 49155858
L
Showroom 2 :
#7/1, Binnamangala, 100 Feet Road, 1st Stage,
Indira Nagar, Bangalore, Karnataka - 560 038
Tel. : 080 - 42019013
Fax : 080 - 42019216
Showroom 2 :
D. No. 4-46-12, G. K. Mansiom, Pedawaltier,
Vishakhapatnam - 530 017
Tel.: 0891 - 2572222, 4444
Fax: 0891 - 6645555
L
Workshop :
Opposite to Fusion Towers, 36-12-2,
Near Siddartha Public School, Moghul Rajapuram,
Vijayawada - 520 010
Tel. : 0866 - 6645593 / 94, 9603123777
Workshop 2 :
Sy. No. 26, Hanumareddy Layout,
Chinnapanahalli Main Road, Marathahalli Post,
Bangalore - 560037
Tel. : 9663388812
L
Trident Automobiles Pvt. Ltd.
Showroom & Workshop :
SY. No, 18/1B, (Old No 18/1C), Nayanda Halli Grama,
Kengeri Hobli, Bangalore - 560038
Tel. :080 - 67149191/292, 67149001
193
K.H.T. Chevrolet (A Division Of Morzaria Real
Tech Private Limited)
Showroom :
No: 725, West of Cord Road, Rajajinagar,
1st Stage, Mahalakshmi Layout, Bangalore - 560 086
Tel. : 080 - 49363636
Workshop :
No. 305, 5th Main Road, 2nd Cross, 4th Phase,
Peenya Industrial Area, Bangalore - 560 058
Tel. : 080 - 49353637
L
BELGAUM
Bellad Enterprises Pvt. Ltd.
Showroom & Workshop :
Shri Krishna Weaving Mill Compound,
Venguaral Road, Vijaya Nagar, Belgaum - 591 108
Tel. : 0831 - 2449556 / 557, 6514911
Fax : 0831 - 2472209
L
L
L
L
BELLARY
Bellad Enterprises Pvt. Ltd.
Showroom & Workshop :
Near Bellary Rolling Mills, Anantpur Road,
Bellary - 583 101
Tel. : 08392 - 261234 / 5
Fax : 08392 - 261235
DAVANGERE
Modi Motors
Showroom & Workshop :
#869/1-2, PB Road, Opposite Sai International Hotel,
Davangere - 577006
Tel. : 08192 - 233896
L
L
GULBARGA
VKG Motor World
Showroom & Workshop :
Plot - 1&2, Survey No. 116/2, Behind Mahendrakar
Complex, Kapnoor Humnabad Road, Gulbarga - 585104
Tel. : 08472 - 224555
Fax : 08472 - 258019
HUBLI
Bellad Enterprises Pvt. Ltd.
Showroom & Workshop :
Opp. NGEF, Rayapura, Dharwad,
P. B. Road, Hubli-580025
Tel .: 0836 - 2218338 / 39
Telefax : 0836 - 2218337
STATE - KERALA
L
MANGALORE
Frontline Automobiles
Showroom & Workshop :
NH-17, Kullur, Mangalore - 575 013
Tel. : 0824 - 2453091, 2453162, 2453092
Telefax : 0824 - 2459391
MYSORE
Dyuthi Motors Pvt. Ltd.
Showroom & Workshop :
No. 201 / 1 & 2, Hunsur Road, Hinkal Village,
Mysore -570017
Tel. : 0821 - 4240500 - 16
Fax : 0821 - 4241899
L
Workshop :
NH-17, Behind IOCL Fuel Station,
Katapady, Udupi - 574 105
ALLEPPEY
Geeyam Motors Pvt. Ltd.
Showroom :
Koorayil Annex, Opp. Bhattathiripurayidom,
Near MCH Junction, Alappuzha, Alleppey - 688 001
Tel. : 0477 - 2238501
L
CALICUT
German Motors
Showroom & Workshop :
118-A, Chungam Junction, West Hill, Calicut - 673005
Tel. : 0495 - 2383680 / 81, 2383770 / 71
Fax : 0495 - 3041100, 2381909
L
L
L
L
UDUPI
Frontline Automobiles
Showroom :
Shekinah Manor, D. No. 10-47-A1,
Near Laxmi Venkatesh Temple, NH-17,
Ambagilu, Puttur, Santhekatte Post, Udupi - 576 105
Tel. : 0820 - 2581999
Fax : 0820 - 2583801
L
L
L
L
SHIMOGA
Frontline Automobiles
Showroom & Workshop :
Shankar Mutth Road, Shimoga - 577 201
Tel. : 08182 - 229099
Fax : 08182 - 229098
COCHIN
Geeyem Motors Pvt. Ltd.
Showroom & Workshop :
11/336, NH-47 Bye Pass, Nettor P.O.,
Ernakulam, Cochin - 682 304
Tel. : 0484 - 2703245 - 49, 3097100, 3097101
Fax : 0484 - 2703244
Showroom 2 :
33/2440B, Geetanjali Junction, NH Byepass
Chakkaraparambu, Cochin - 682 032
Tel. : 0484 - 2343146
194
L
CHALAKKUDY
Geeyem Motors Pvt. Ltd.
Showroom :
IX/461A, B, Panampilly College, NH-47, Potta,
Chalakkudy - 680722
Tel. : 0480 - 2705125, 2705123
KANJRAPALLI
Geeyem Motors Pvt. Ltd.
Showroom :
Near A K J M School, K K Road, Kanjirappally
(Kottayam Dt.)
Tel. : 0482 - 8201616
KANNUR
German Motors
Showroom & Workshop :
BP6-14A, Valapattanam, Kannur - 670 010
Tel. : 0497 - 2774466 - 67, 3057200
Fax : 0497 - 27744666, 3057200
KASARGOD
German Motors
Showroom & Workshop :
15/89B, Citizen Nagar, Chengala, Kasargod - 671123
Tel. : 04994 - 302200 - 10
Fax : 04994 - 302211
KAYAKULAM
Geeyam Motors Pvt. Ltd.
Showroom & Workshop :
NH-47, Near MSM College, Kayakulam - 690 502
Telefax : 0479 - 2446650
KODANGULUR
Geeyem Motors Pvt. Ltd.
Showroom :
XII/ 121-122, Opp. Medicare Hospital,
Kottapuram PO, TKS Puram, Kodungalur - 680 667
Tel. : 0480 - 2803561 / 62
KOTAYYAM
Geeyam Motors Pvt. Ltd.
Showroom & Workshop :
Karithas Junction, Thellakom P.O., Kotayyam-686016
Tel. : 0481 - 2792203
Fax : 0481 - 2792383
L
KOLLAM
Deedi Motors
Showroom :
Post Office Junction, Pallimukku, Kollam - 691 010
Tel. : 0474 - 3257777 / 2725959
Fax : 0474 - 2725900
Workshop :
Cantonment, North Nagar, Pullikada, Kollam - 691001
Tel. : 0474 - 2750010 / 11
L
L
L
KOTTAKKAL
German Motors
Showroom & Workshop :
260A, Palathara, Cherusola P.O., Kottakkal,
Malappuram
Tel. : 0494 - 2611666
L
L
MUVATTUPUZHA
Geeyam Motors Pvt. Ltd.
Showroom :
Mackar Plaza, EEC Market Road, PNB Junction,
Muvattupuzha - 686 673
Tel. : 0485 - 606600, 2835272 / 73
Fax : 0485 - 2832554
L
Workshop :
902/903,Opp. Mackar Plaza, EEC Market Road,
PNB Junction, Muvattupuzha - 686 673
Tel. : 0485 - 2835272 / 73
Fax : 0485 - 2832554
L
L
MUTTUM
Geeyem Motors
Showroom & Workshop :
SY NO: 70/15, 71/10, Thai Kkattukara P.O, N H Road,
Distt. Aluva, Muttum, Cochin - 683106
Tel. : 0484 - 2632193 / 94 / 95 / 96 / 97
PERINTHALMANNA
German Motors
Showroom & Workshop :
AP-IV 664F, Opp. ITC, Tirurkad,
Perinthalmanna - 679 531
Tel. : 04933 - 325060, 237000, 239878
Telefax : 04933 - 2737000
PALAKKAD
Geeyam Motors
Showroom & Workshop :
Door No. 8/1198, NH Bypass Road,
Chandra Nagar, Palakkad - 678 007
Tel. : 0491 - 2504133
Fax : 0491 - 2504143
PATHANAMTHITTA
Deedi Motors Pvt. Ltd.
Showroom & Workshop :
Kumbazhethu Buildings, Churulicode P.O.,
Kozhencherry Road, Pathanamthitta - 689 645
Tel. : 0468 - 2272079, 2272080
Fax : 0468 - 2272078
L
STATE - PONDICHERRY
L
THIRUVALLA
Deedi Motors Pvt. Ltd.
Showroom :
No. 54/2, Kurusumoottil Buildings,
M C Road, Mazhuvangad, Thiruvalla - 689 101
Tel. : 0469 - 2740800
THRISSUR
Geeyem Motors Pvt. Ltd.
Showroom :
14/3-A1, Guruvayoor Road Puzhakkal,
Ayyanthole P.O., Thrissur - 680 003
Tel. : 0487 - 2388945 - 46, 2388851 - 52
Fax : 0487 - 2388851
TRIVENDRUM
Deedi Motors Pvt. Ltd.
Showroom / Workshop :
Erumalathopu, N.H. Bye Pass Road, Venpalvattom,
Anayara P.O., Trivendrum - 695 029
Tel. : 0471 - 2556006, 3257777, 2558599, 2558499
Fax : 0471 - 2551020
PONDICHERRY
Aakash Auto Pvt. Ltd.
Showroom :
No. 1, Sounderrajan, 100 ft. Road, Sounder Rajan
Nagar, Mudaliarpet, Pondicherry - 605 004
Tel. : 0413 - 2204400
Fax : 0413 - 2204033
Workshop :
No. 23, 9th Cross, Metupallyam,
Industrial Estate, Pondicherry - 605 009
Tel. : 0413 - 2279900
STATE - TAMIL NADU
L
CHENNAI
Sundaram Motors
Showroom & Workshop :
180, Anna salai Road, Chennai - 600 006
Tel. : 044 - 28579203 / 28 / 32
Fax : 044 - 28579210
Workshop 2:
116/4 Mahalakshmi Nagar Extention,
Numbal Village Thirverkadu Post, Chennai - 600077
Tel.: 044 - 26493020/21
Workshop :
Near Boating Station, Puzhakkal Post Office,
Thrissur - 680553
Tel. : 0487 - 2225100, 2225101
L
WAYNAD
German Motors
Showroom / Workshop :
Muttil - Post, North Kalpetta, Waynad - 673 122
Tel. : 04936 - 304200 / 202414
Fax : 04936 - 304201
L
KLN Motors Agencies Pvt. Ltd.
Showroom 1 :
Old No. 861, New No. 232, Poonamallee High Road,
Kilpauk, Chennai - 600 010
Tel : 044 - 23452937 / 38
Telefax : 044 - 23452936
Workshop 1 :
Shop No. 50, SIDCO Industrial Area,
Ambattur, Chennai - 600 058
Tel. : 044 - 23452930 - 32
195
Showroom & Workshop 2 :
No. 8-NP, Developed Plot, Guindy Industrial Estate,
Ekkattuthangal, Near Kasi Theatre, Chennai - 600097
Tel. : 044 - 23458941 / 42
L
L
CUDDALORE
Aakash Auto Pvt. Ltd.
Showroom & Workshop:
RS No.155/11, Vadalur Main Road, Periamedu,
Karaikadu Village, Cuddalore Taluk,
Cuddalore - 607005
Tel.: 04142-297997, 7373299933, 7373599933
COIMBATORE
Anamallais Agencies (P) Ltd.
Showroom :
252, Mettupalayam Road, Coimbatore - 641 043
Tel. : 0422 - 2435555 / 2432999
Fax : 0422 - 2446151
Workshop :
2/2, 1E, Balaji Nagar, Rayakottai Road,
Opp. to LUK India, Hosur - 635109
Tel. : 04344 - 291033
L
L
Workshop :
249A, Mettupalayam Bye Pass Road,
Coimbatore - 641043
Tel. : 0422 - 2433444
L
Pressana Automobile
Showroom :
No. 1987, Trichy Main Road, LCT Complex,
Coimbatore - 641005
Tel. : 0422 - 4041111
L
Workshop :
505/1, Sowaripalayam Main Road,
Ramanathapuram, Coimbatore - 641045
Tel. : 0422 - 4051111
L
L
ERODE
Pressana Automobile
Showroom & Workshop :
No.1, ChinnaKadu Thottam,
Veerapampalayam, Dhindal P.O., Erode - 638 012
Tel. : 0424 - 2276046 / 47
Fax : 0424 - 2276048
HOSUR
Thriive Cars
Showroom :
2, Rajappa Mudaliar Building,
NH-7, Krishnagiri, Bangalore Byepass Road, Hosur
Tel. : 04344 - 644588
L
KARUR
Pressana Automobile
Showroom & Workshop :
No.3, Salem Byepass Road, Kulathupalayam,
Karur - 635 006
Tel. : 04324 - 222301
Fax : 04324 - 222302
MADURAI
A.R.A.S. Motors (P) Ltd.
Showroom :
35/1, Dindigul National Highway,
Near A. R. C. Parcel Service, Villangudi,
Madurai - 625018
Tel. : 0452 - 2669617, 3091917
Fax : 0452 - 2669618
L
L
L
Workshop :
Plot No. 64 & 68, Thiruvalavayanallur Post,
National Highway No. 7, Opp Arokya Milk
Processing Unit, Nagari, Madurai - 625 221
Tel. : 0452 - 2463612 / 13 / 14
L
NAGERCOIL
A.R.A.S. Motors (P) Ltd.
Showroom & Workshop:
2/86, Tirunelveli Main road,
Ozhuginasery, Nagercoil - 629 001
Tel. : 04652 - 644664 (Showroom)
04652 - 272443 (Workshop)
L
NAMAKAL
Thriive Cars
Showroom :
5/58, Salem Main Road, Namakal
Tel. : 04286 - 275603
L
Workshop :
276/85, Tiruchengode Main Road,
Opp. Old Lakshmi Kalyana Mandapam,
Namakkak - 637 001
L
196
PUDUKOTTAI
Jayaraj Karz
Showroom & Workshop :
5915/1, Khalif Nagar, Thirumayam Road,
Pudukottai - 622 001
Tel. : 04322 - 262223
PERAMBALUR
Jayaraj Karz
Showroom & Workshop :
No. 36, Trichy to Chennai Highway, Eraiyur,
Veppanthattai, Perambalur, Tamilnadu - 621 133
Tel. : 9244222728
SALEM
Thriive Cars
Showroom & Workshop :
1116, Salem Chennai Highway Road,
Near Holy Cross, Hr. Sec. School,
Ammapet, Salem - 636 014
Tel. : 0427 - 2242603
Fax : 0427 - 2242604
TRICHY
Jayaraj Karz
Showroom & Workshop :
Madurai Main Road, Panjapur, Trichy - 620 012
Tel. : 0431 - 2906420 / 6541207
Fax : 0431 - 2202187
THIRUNELVELLI
A.R.A.S. Motors (P) Ltd.
Showroom & Workshop :
1183/3, National Highway Jothipuram,
Konganthanparai, Thirunelvelli - 627 007
Tel. : 0462 - 2551070, 3269638
Fax : 0462 - 2554111
TIRUPUR
Anamallais Agencies Pvt. Ltd.
Showroom & Workshop :
396/6, Kamaraj Road, Palladam Road,
Tirupur - 641 604
Tel. : 0421 - 2918999
THANJAVUR
Jayaraj Karz
Showroom & Workshop :
Pudukottai Bye - Pass Road, Thanjavur
Tel. : 04362 - 226452
L
VELLORE
Sayar Cars
Showroom & Workshop :
S.F. No. 3004, New By Pass Road,
Near Collectorate, Vellore - 632004
Tel.: 0416 - 2222017
197
EAST ZONE
L
STATE - ARUNACHHAL PRADESH
L
ITANAGAR
Sango Motors
Showroom & Workshop :
NH-52A, Near Shiv Mandir, 6 Km
Between Nahalagun, Dist. Papumpare
Itanagar, Arunachal Pradesh - 791 110
Tel. : 0360 - 2001166 / 67, 2033153
STATE - ASSAM
L
L
L
L
L
BONGAIGAON
Raj N Dibyani Automobiles
Showroom & Workshop :
Near Lower Assam Hospital, Chapaguri Road,
North Bongaigaon, Bongaigaon
Tel.: 03664 - 231890, 230545
DIBRUGARH
Pashupati Traders
Showroom & Workshop :
P. N. Road, Chiring Chapori, Dibrugarh - 786 001
Tel. : 0373 - 2323281
Telefax : 0373 - 2323296
GUWAHATI
Srishti Automobiles Pvt. Ltd.
Showroom :
Opp. Pantaloons, G S Road, Rukminigaon,
Guwahati, Assam - 781 022
Tel. : 0361 - 2223666
Fax : 0361 - 2223888
L
NAGAON
LB Motor (A Unit of Borah & Sons Pvt. Ltd)
Showroom & Workshop:
AT Road, Dimarguri, Nagaon - 782003
Tel.: 03672- 253157
TEZPUR
GNB Motors
Showroom :
P.O. Nikamul, Beside Udyanpath,
Tezpur - 784001
Tel. : 03712 - 255999
Workshop :
P.O. Nikamul, Udyanpath,
Tezpur - 784001
Tel. : 03712 - 255998
L
TINSUKIA
Dhansri Motors
Showroom & Workshop :
Opposite New Tinsukia Railway Junction,
A.T. Road, Hijuguri, Tinsukia - 786125.
Tel. : 0374 - 2311397
Workshop :
Bhootnath Road, Sahadurpur, PS Agamkuan,
Patna - 800 020
Tel. : 0612 - 2341151
L
L
L
L
L
L
MUZAFARPUR
Pandey Motors Pvt. Ltd.
Showroom & Workshop :
Mithila Body Builders, NH-18,
Bhagwanpur, Muzafarpur - 842 001
Tel. : 0621 - 2252762
PATNA
Pandey Motors Pvt. Ltd.
Showroom :
Pandey Plaza, Exhibition Road, Patna - 800 001
Tel. : 0612 - 2205195, 3955491
Fax : 0612 - 2205196
198
GAYA
Brijnandan Automobile Pvt. Ltd.
Showroom & Workshop :
727 Old 1026 / New No. NH - 83,
Near BMP - 3, Gaya - 823004
Tel. : 0631 -2200131
PURNEA
Hare Krishna Motors Pvt. Ltd.
Showroom & Workshop :
Damka Chowk, NH - 31, Gulabbagh, Purnea - 854326
Tel. : 9234323211
STATE - JHARKHAND
STATE - BIHAR
Workshop :
Radha Nagar, VIP Road, Six mile, Guwahati,
Assam - 781 022
SHIBSAGAR
Pashupati Traders
Showroom & Workshop :
KPM Chariali, Shivasagar, Shivasagar - 785 640
Tel. : 03772 - 220082 / 88
SILCHAR
Smart Motors Pvt. Ltd.
Showroom & Workshop :
NH-54, Ramnagar, Silchar - 788 008
Tel. : 03842 - 268701, 9207042806
BOKARO
Power Motors
Showroom & Workshop :
N-1, City Centre, Sector - 4,
Bokaro Steel City, Bokaro - 827004
Tel. : 0654 2- 233555 / 232977
Fax : 06542 - 232988
DHANBAD
Sorabh Automobile
Showroom :
Indramani Palace, Opp Flair Bajaj, Saraidhela,
Dhanbad - 826001
Tel. : 0326 - 2201366
Workshop :
Tilakraidih, Govindpur Road, Dhanbad - 826001
Tel. : 9470580855
L
HAZARIBAGH
Laxmi Auto
Showroom & Workshop :
Zulu Park Road, Near SBI Main Branch,
Hazaribagh - 825301
Tel. : 06546 - 222929
L
L
JAMSHEDPUR
Narbheram Motors Pvt. Ltd.
Showroom & Workshop :
M-4, Phase-VI, Adityapur Industrial Area,
P.O. Gamaria, Jamshedpur - 832 108
Tel. : 0657 - 3293612, 3297763, 3290649, 6510531
Telefax : 0657 - 2200532
RANCHI
Rahul Automobiles Pvt. Ltd.
Showroom 1 :
Piska More, Ratu Road, Ranchi - 834 005
Tel. : 0651 - 2510251 / 52
Showroom 2 :
Line Tank Road, MR Tower, Ranchi - 834 001
Tel. : 0651 - 3298436
Fax : 0651 - 2510252
L
L
L
Workshop :
Ratu Road, Near Kamre Ashram, Ranchi - 834 005
Tel. : 0651 - 2511558 / 564, 3241206
STATE - ORISSA
L
L
L
BALASORE
Venus Auto Works Pvt. Ltd.
Showroom & Workshop:
NH - 5, Remuna Golai, Januganj,
Near Bhatter Mill, Balasore -756 019
Tel. : 06782 - 244013, 244014
BHUBANESWAR
Venus Auto Works Pvt. Ltd.
Showroom & Workshop :
A/62, Nayapalli, Bhubaneswar - 751 003
Tel. : 0674 - 3019999 (Showroom)
0674 - 3019900, 3270444, 9337070444
(Workshop)
Telefax : 0674 - 3019908
Super Sales Automobiles Pvt. Ltd.
Showroom & Workshop :
Plot No. 644/2148, NH-5, Pahal,
Bhubneswar, Dist - khurda - 752 101
Tel. : 0674 - 2463913, 2463914, 6543010 / 11
CUTTACK
Super Sales Automobiles Pvt. Ltd.
Showroom :
Rudrapur, NH - 5, Pratap Nagri, Cuttack - 753 011
Tel. : 0671 - 2686878
Fax : 0671 - 2686889
L
SAMBALPUR
Bharat Motors Ltd.
Showroom & Workshop :
9, Industrial Estate, Near Central School,
Bareipali, Sambalpur - 768 006
Tel. : 0663 - 2402736, 2405286
Fax : 0663 - 2585894
ROURKELA
Balaram Motors
Showroom & Workshop :
Opposite Pahadi Kanta, Vedvyash, Rourkela - 769 041
Workshop 1 :
241/2B, APC Road, Opp. Khanna Cinema,
Kolkata - 700 004
Tel. : 033 - 25551370 / 72 / 73 / 74, 25552509
Workshop 2 :
108 F, Nilgunge Road, Agarpara, Kolkata - 700058
Tel. : 033 - 25552509
L
STATE - WEST BENGAL
L
L
ASANSOL
Shaila Autotech
Showroom & Workshop :
NH-2, Chanda More, Asansol - 713 339
Telefax : 0341 - 2343704 / 705
HOWRAH
Priti Motor Udyog (P) Ltd.
Showroom :
NH-6, Bombay Howrah Highway, Howrah
KOLKATA
OSL Autotech Pvt. Ltd.
Showroom :
2/1A, Sarat Bose Road, Lansdowne Towers,
Kolkata - 700 020
Tel. : 033 - 66270400
Workshop :
49 E, Topsia Road South, Kolkata - 700 046
Tel. : 033 - 66270500
199
Dulichand Motors Pvt. Ltd.
Showroom :
"Shrachi Towers", 686 Anandapur,
E.M. Bypass, Near Ruby Hospital, Kolkatta - 700 107
Tel. : 033 - 24431801 - 02, 40141616
Fax : 033 - 40141624
Workshop :
5/51, Jagatipota, Ahalya Nagar,
Opp. Jagatipota Kisan Market, Kolkatta - 700 099
Tel. : 033 - 40161718, 24264224, 24264214
m
Workshop :
Khejurtala Kolkata Truck Terminal,
Khejurtala, NH-6, Howrah - 711403.
Tel. : 033 - 65002070/71/72
L
Speed Autotech
Showroom :
"The Meridian", Kazi Nazrul Islam Sarani,
(VIP Road), Kolkata - 700 059
Tel. : 033 - 25007915 - 9
Fax : 033 - 40150824
Longia Motors Pvt. Ltd.
Workshop 1 :
15/1D, Sahanagar Road, (Near Rashbehari Avenue
Crossing), Kolkatta - 700 026
Tel. : 033 - 66270100 / 119
Fax : 033 - 66270121
Workshop 2 :
Budge Budge Trunk Road, Rampur, P.O. : Gobindopur,
P.S. : Maheshtala, Kolkata - 700 141
Tel. : 033 - 66270222/223/205
Fax : 033 - 66270208
L
SILIGURI
Kaysons Automotive Pvt. Ltd.
Showroom & Workshop :
IIIrd Mile, Checkpost,
Opp. New Eastern Bypass Road,
Sevoke Road, Siliguri - 734 401
Tel. : 0353 - 2544533 - 35, 2777723
Fax : 0353 - 2544456
STATE - MANIPUR
L
IMPHAL
Rajpri Enterprise
Showroom & Workshop :
Chigmeirong Mamang Leikai,
Imphal East, Imphal - 795 001
Tel. : 0385 - 2421183
STATE - MIZORAM
L
AIZAWL
Highland
Showroom & Workshop :
A-L Road, Zemabawk, Aizawl - 796017
Tel. : 0389 - 2351916
STATE - NAGALAND
L
DIMAPUR
Urban Station
Showroom & Workshop :
NSC Petrol Pump, NH-39, 6th Mile, Kohima Road,
Dimapur, Nagaland - 797 112
Tel. : 03862 - 240994, 240992
STATE - TRIPURA
L
AGARTALA
Sri Krishna Automobiles
Showroom & Workshop :
Plot No. 4612 & 4615, Shanihani,
Airport Road, Agartala, Tripura West - 799 001
Tel. : 0381 - 2342566
STATE - MEGHALAYA
L
SHILLONG
DH Royal Cars
Showroom & Workshop :
Parkview, Fire Brigade,
Shillong - 793 014
Tel. : 0364 - 2520481, 2520477
STATE - SIKKIM
L
GANGTOK
GEN X Motors
Showroom :
5th Mile, Jhordhara, Tadong, Gangtok - 737 102
Tel. : 03592 - 202515
Fax : 03592 - 203171
Workshop :
C/o Garima Enterprise, P.S. Road, Gangtok - 737 101
Tel. : 03592 - 202515
200
INTERNATIONAL
L
L
SRI LANKA
Mag City Motor Company Pvt. Ltd.
Showroom & Workshop :
No. 320A, Darley Road,
Colombo - 10, Sri Lanka
Tel. : 0094777410407
BHUTAN
Global Trade
Showroom :
Lkahilham, Changgankha,
Thimphu, Bhutan
Workshop :
Post Box No. 1037, Olarongcchu,
Thimphu, Bhutann
m
NEPAL
SPG Automobiles Pvt. Ltd.
Workshop :
GPO Box 2544, Khumaltar, Lalitpur,
Kathmandu, Nepal
Tel.: 00977-1-4100543
201
202
!""" #$%&'( #! "(#!(")#*# +"#*,%#"
-# !. /012
"##34. #2
55
/"#.
6"
3*1
0,. )2
15'.-)*. 7#1..8
9"+)*+#:(#;* )#1'
1'##. )2
5522
!""#$%&&'&&&%&%&
Download PDF