DeviceNet

DeviceNet
TURCK
Network Media Products
DeviceNet™
B1
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™ General Specifications
DeviceNet is a low-cost communications link connecting industrial devices such as limit switches, photoelectric sensors,
valve manifolds, motor starters, process sensors, bar code readers, variable frequency drives, panel displays and operator
interfaces to a network. The direct connectivity provides improved communication between devices as well as important
device-level diagnostics not easily accessible or available through hand-wired I/O interfaces.
DeviceNet is based on Controller Area Network (CAN) which uses CSMA/BA for bus arbitration. CSMA/BA assures that the
highest priority message always gets transmitted. The DeviceNet protocol further defines that I/O messages are given top
priority and configuration messages have lower priority.
DeviceNet supports up to 64 nodes and an unlimited amount of I/O. The bus uses a trunkline-dropline (tree) topology.
Bus power and communication are supplied on a single cable.
DeviceNet allows for peer-to-peer data exchanges and master/slaves operations.
Topology - How the Data Lines Connect the Nodes Together
Power Supply
RSMCBC5 5711-1M
BL20 I/O System
PC
RKM 46-1M
PLC
RSC CBC5 572-1M
RSM 57-TR2
JBBS-57-SM01
RSM RKM 5711-1M
FDNQ-S0400-T
RSM RSM 5711-2M
RSM2RKM 57
FDN20-4S-4XSG-E
RKM RKC 5711-1M
FDNP-S0404G-TT
BL67 I/O System
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B2
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Selection Guide
B3
Cables
Flat Cable Connectors
Terminating Resistors
B4 - B20
B14
B21
Feed Through Connectors
Junctions
Conduit Adapters
B22
B23 - B38
B39 - B40
Tees
Gender Changers
Receptacles
B41 - B44
B45 - B46
B47 - B60
Field Wireable Connectors
Power Taps
Daisy Chain Cordsets
B61 - B62
B63 - B64
B65 - B66
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Thin Cable Specifications
• Cable that Meets the Requirements of ODVA Thin or Type 1 Cable
• Commonly used as Drop Cable to a Maximum Length of 6 Meters (20 Feet)
or Trunk Cable in Networks up to a Maximum Length of 100 Meters (328 Feet)
Jacket
Drain Wire
Blue
White
Black
Red
Data
Power
Foil Shield
Overall Foil Shield
Braid Shield
Drop Length
Data Rate
Maximum Trunk Length
Maximum
125 Kbaud
100 meters (328 feet)
250 Kbaud
100 meters (328 feet)
500 Kbaud
100 meters (328 feet)
156 meters (512 feet)
6 meters (20 feet)
572
AWM 2464
75°C 300 Volts
577
AWM 2464
75°C 300 Volts
578
AWM 2464
75°C 300 Volts
5715
AWM 2095
80°C 300 Volts
Data Pair
Outer Jacket
Shields
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
2/22 AWG
BU/WH
16.5 Ohms
PE
PVC Light Grey
7.3 mm (.285 in)
Foil
22 AWG
RB50603-*M
44 lbs.
16.5 Ohms
PVC
2/22 AWG
BU/WH
16.5 Ohms
PE
PVC Light Grey
8.4 mm (.330 in)
Foil/Braid
22 AWG
RB50629-*M
65 lbs.
flexlife-10 ® †
2/22 AWG
BK/RD
16.5 Ohms
PVC
2/22 AWG
BU/WH
16.5 Ohms
PE
PVC Light Grey
7.4 mm (.290 in)
Foil/Braid
22 AWG
RB50651-*M
51 lbs.
NEC AWM
CEC AWM-I/II A/B FT1
2/22 AWG
BK/RD
16.5 Ohms
PVC
2/22 AWG
BU/WH
16.5 Ohms
PE
PVC Light Grey
6.0 mm (.235 in)
Foil (Data Only)
22 AWG
RB50764-*M
26 lbs.
NEC AWM
2/22 AWG
BK/RD
16.5 Ohms
PE
2/24 AWG
BU/WH
27.7 Ohms
PE
PUR Violet
7.1 mm (.280 in)
Foil/Braid
22 AWG
RB50994-*M
50 lbs.
Halogen-Free ††
Approvals
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
NEC PLTC
CEC AWM-I/II A/B FT4
2/22 AWG
BK/RD
16.5 Ohms
PVC
NEC PLTC
CEC AWM-I/II A/B FT4
2/22 AWG
BK/RD
NEC PLTC/CL2
CEC CMG
5725
AWM 21080
75°C 300 Volts
78 meters (feet)
39 meters (feet)
Power Pair
Type
Cumulative
* Indicates length in meters.
®
† See page A5 for flexlife performance.
†† Zero Halogen: to DIN VDE 0472 part 815 + IEC 60754-1
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B4
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Mid Cable Specifications
• Cable that Meets the Requirements
Jacket
Drain Wire
of ODVA Mid or Type III Cable
• Provides more Flexibility when used
Blue
White
Black
Red
Figure A
as a Trunk Cable up to a Maximum
Length of 300 Meters (984 Feet)
Data
Power
Foil Shield
Braid Shield
Aluminum Armor
Jacket
Inner Jacket
Drain Wire
Blue
White
Black
Red
Figure B
Data
Power
Foil Shield
Data Rate
Maximum Trunk Length
125 Kbaud
300 meters (984 feet)
250 Kbaud
250 meters (820 feet)
500 Kbaud
100 meters (328 feet)
Overall Foil Shield
Power Pair
Type
5711
AWM 2464
80°C 300 Volts
5722
AWM 2464
75°C 300 Volts
5723
AWM 20233
80°C 300 Volts
5721A
75°C 300 Volts
5731
AWM 20626
80°C 300 Volts
Data Pair
Outer Jacket
Shields
Bulk Cable
Approvals
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Part Number / Figure
Type
Drain Wire Weight/300 M
NEC PLTC
CEC AWM-I/II A/B FT4
2/16 AWG
BK/RD
4.1 Ohms
PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
PVC Light Grey
8.4 mm (.330 in)
Foil
20 AWG
RB50721-*M
65 lbs.
A
NEC PLTC
CEC AWM-I/II A/B FT4
2/17 AWG
BK/RD
5.2 Ohms
SR-PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
PVC Light Grey
8.9 mm (.350 in)
Foil
20 AWG
RB50876-*M
71 lbs.
flexlife-10 ® †
A
NEC AWM
CEC AWM-I/II A/B FT1
2/17 AWG
BK/RD
5.2 Ohms
PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
PUR Light Grey
8.4 mm (.330 in)
Foil
20 AWG
RB50877-*M
60 lbs.
flexlife-10 †
A
NEC PLTC/CM
CEC CMG HL ABCD
2/18 AWG
BK/RD
6.7 Ohms
PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
PVC Light Grey
13.5 mm (.530 in)
Aluminum Armor
Foil/Armor
20 AWG
RB50859-*M
101 lbs.
armorfast ®
B
NEC AWM
CEC AWM-I/II A/B FT1
2/16 AWG
BK/RD
4.1 Ohms
PVC
2/20 AWG
BU/WH
10.4 Ohms
PE
TPE Charcoal Grey
10 mm (.394 in)
Foil/Spiral
None
RB51235-*M
95 lbs.
flexlife-10 †
weldlife™ †
A
* Indicates length in meters.
®
† See page A5 for flexlife and weldlife performance.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
B5
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Thick Cable Specifications
• Cable that Meets the Requirements of ODVA Thick or Type II Cable
• It Provides the most Power to a Network when used as a Trunk Cable up to a Maximum
Standard Cable Length of 500 Meters (1640 Feet)
Jacket
Drain Wire
Blue
White
Black
Red
Data
Power
Foil Shield
Overall Foil Shield
Data Rate
Maximum
Trunk Length
Maximum Trunk Length
(5720)
125 Kbaud
500 meters (1640 feet)
420 meters (1378 feet)
250 Kbaud
250 meters (820 feet)
200 meters (656 feet)
500 Kbaud
100 meters (328 feet)
100 meters (328 feet)
Power Pair
Type
575
AWM 20233
80°C 300 Volts
579
AWM 2570
75°C 300 Volts
5720
75°C 600 Volts
Outer Jacket
Shields
Approvals
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
NEC AWM
CEC AWM-I/II A/B FT1
2/15 AWG
BK/RD
3.5 Ohms
PVC
2/18 AWG
BU/WH
6.5 Ohms
PE
PUR Light Grey
10.4 mm (.409 in)
Foil/Braid
18 AWG
RB50633-*M
94 lbs.
NEC PLTC/CL2
CEC CMG
2/15 AWG
BK/RD
3.2 Ohms
PVC
2/18 AWG
BU/WH
6.5 Ohms
PE
PVC Light Grey
11.3 mm (.445 in)
Foil/Braid
18 AWG
RB50652-*M
122 lbs.
NEC TC
2/16 AWG
BK/RD
3.6 Ohms
PVC
2/18 AWG
BU/WH
6.9 Ohms
PE
PVC Light Grey
13 mm (.515 in)
Foil/Braid
18 AWG
RB50793-*M
168 lbs.
NEC AWM
2/15 AWG
BK/RD
3.2 Ohms
PE
2/18 AWG
BU/WH
6.9 Ohms
PE
PUR Violet
11.4 mm (.449 in)
Foil/Braid
18 AWG
RB51038-*M
150 lbs.
Halogen-Free ††
NEC PLTC
CEC AWM-I/II A/B FT4
2/15 AWG
BK/RD
3.2 Ohms
PVC
2/18 AWG
BU/WH
6.5 Ohms
PE
PVC Light Grey
13.7 mm (.540 in)
Foil/Spiral
None
RB51106-*M
157 lbs
flexlife-10 ® †
NEC AWM
CEC AWM-I/II A/B FT1
2/15 AWG
BK/RD
3.2 Ohms
PVC
2/18 AWG
BU/WH
6.5 Ohms
PE
TPE Grey
11.3 mm (.445 in)
Foil/Braid
18 AWG
RB51231-*M
110 lbs.
flexlife-10 †
weldlife™ †
5726
AWM 21080
70°C 300 Volts
5727
75°C 300 Volts
5730
AWM 20626
80°C 300 Volts
Data Pair
* Indicates length in meters.
† See page A5 for flexlife and weldlife performance.
†† Zero Halogen: to DIN VDE 0472 part 815 + IEC 60754-1
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B6
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Cable/Cordset Selection Matrix
minifast ®
Pin (Male)
1
eurofast ® (Thin/Mid Only)
Pin (Male)
Socket (Female)
2
3
4
5
RSM
WSM
RKM
WKM
RSC
RSM 57x-*M
WSM 57x-*M
RKM 57x-*M
WKM 57x-*M
RSC 57x-*M
RSM RSM 57x-*M
RSM WSM 57x-*M
RSM RKM 57x-*M
RSM WKM 57x-*M
RSM RSC 57x-*M
WSM WSM 57x-*M
WSM RKM 57x-*M
WSM WKM 57x-*M
WSM RSC 57x-*M
RKM RKM 57x-*M
RKM WKM 57x-*M
RKM RSC 57x-*M
WKM WKM 57x-*M
WKM RSC 57x-*M
Bare
RSM
2
minifast
Pin (Male)
1
Socket (Female)
WSM
3
RKM
4
WKM
Pin (Male)
RSC RSC 57x-*M
RSC
6
WSC
Socket (Female)
eurofast (Thin/Mid Only)
5
7
RKC
8
WKC
See pages B11 - B12 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM ... to RSV, WSM ... to WSV.
minifast
Male
B7
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Cable/Cordset Selection Matrix
Pin (Male)
eurofast ® (Thin/Mid Only)
Socket (Female)
6
7
minifast ® Bulkhead
Pin (Male)
Socket (Female)
8
9
10
eurofast Bulkhead (Thin Only)
Pin (Male)
Socket (Female)
11
12
WSC
RKC
WKC
RSFP
RKFP
FSFD
FKFD
WSC 57x-*M
RKC 57x-*M
WKC 57x-*M
RSFP 57x-*M
RKFP 57x-*M
FSFD 57x-*M
FKFD 57x-*M
RSM WSC 57x-*M
RSM RKC 57x-*M
RSM WKC 57x-*M
RSM RSFP 57x-*M
RSM RKFP 57x-*M
RSM FSFD 57x-*M
RSM FKFD 57x-*M
WSM WSC 57x-*M
WSM RKC 57x-*M
WSM WKC 57x-*M
WSM RSFP 57x-*M
WSM RKFP 57x-*M
WSM FSFD 57x-*M
WSM FKFD 57x-*M
RKM WSC 57x-*M
RKM RKC 57x-*M
RKM WKC 57x-*M
RKM RSFP 57x-*M
RKM RKFP 57x-*M
RKM FSFD 57x-*M
RKM FKFD 57x-*M
WKM WSC 57x-*M
WKM RKC 57x-*M
WKM WKC 57x-*M
WKM RSFP 57x-*M
WKM RKFP 57x-*M
WKM FSFD 57x-*M
WKM FKFD 57x-*M
RSC WSC 57x-*M
RSC RKC 57x-*M
RSC WKC 57x-*M
RSC RSFP 57x-*M
RSC RKFP 57x-*M
RSC FSFD 57x-*M
RSC FKFD 57x-*M
WSC WSC 57x-*M
WSC RKC 57x-*M
WSC WKC 57x-*M
WSC RSFP 57x-*M
WSC RKFP 57x-*M
WSC FSFD 57x-*M
WSC FKFD 57x-*M
RKC RKC 57x-*M
RKC WKC 57x-*M
RKC RSFP 57x-*M
RKC RKFP 57x-*M
RKC FSFD 57x-*M
RKC FKFD 57x-*M
WKC WKC 57x-*M
WKC RSFP 57x-*M
WKC RKFP 57x-*M
WKC FSFD 57x-*M
WKC FKFD 57x-*M
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B8
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Open Connector Cordset Selection Matrix
minifast ®
Pin (Male)
1
eurofast ®
Pin (Male)
Socket (Female)
2
3
4
5
RSM
WSM
RKM
WKM
RSC
CBC5 57x-*M
RSM CBC5 57x-*M
WSM CBC5 57x-*M
RKM CBC5 57x-*M
WKM CBC5 57x-*M
RSC CBC5 57x-*M
BK52C 57x-*M
RSM BK52C 57x-*M
WSM BK52C 57x-*M
RKM BK52C 57x-*M
WKM BK52C 57x-*M
RSC BK52C 57x-*M
13
CBC5
14
BK52C
Thin, Mid and Thick Cable
Thin Cable Only
See pages B10 - B12 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
For stainless steel coupling nut: Change part number (RSM ... to RSV, RSC ... to RSCV).
minifast
Male
B9
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Open Connector Cordset Selection Matrix
eurofast ®
Socket (Female)
Pin (Male)
6
7
minifast ® Bulkhead
Pin (Male)
Socket (Female)
8
9
10
eurofast Bulkhead
Pin (Male)
Socket (Female)
11
12
WSC
RKC
WKC
RSFP
RKFP
FSFD
FKFD
WSC CBC5 57x-*M
RKC CBC5 57x-*M
WKC CBC5 57x-*M
RSFP CBC5 57x-*M
RKFP CBC5 57x-*M
FSFD CBC5 57x-*M
FKFD CBC5 57x-*M
WSC BK52C 57x-*M
RKC BK52C 57x-*M
WKC BK52C 57x-*M
RSFP BK52C 57x-*M RKFP BK52C 57x-*M FSFD BK52C 57x-*M FKFD BK52C 57x-*M
Thin and Mid Cable Only
Thin, Mid and Thick Cable
Thin Cable Only
See pages B11 - B12 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
Specifications
Housing:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PA (Nylon)
NEMA 1, and IEC IP 20
250 V
12 A
-30°C to +75°C
13
CBC5 ..
14
BK52C ..
Page B9
CBC5
5 4 3 2 1
Pinouts
1 = Black (- Voltage)
2 = Blue (CAN_L)
3 = Bare (Shield Drain)
4 = White (CAN_H)
5 = Red (+ Voltage)
Page B9
BK52C
5 4 3 2 1
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B10
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Cordset and Receptacle Connector Dimensions
Specifications
Overmold:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (polyurethane)
Nickel-Plated CuZn or Stainless Steel
PUR (polyurethane)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
300 V
9A
-30°C to +75°C
1
RSM ..
3
Pages B7 - B10
RKM ..
2
WSM ..
4
Pages B7 - B10
WKM ..
9
RSFP ..
B11
Pages B7 - B10
Pages B7 - B10
10
Pages B7 - B10
RKFP ..
Pages B7 - B10
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Cordset and Receptacle Connector Dimensions
Specifications
Overmold:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (polyurethane)
Nickel-Plated CuZn or Stainless Steel
PUR (polyurethane) or POM (Nylon)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-30°C to +75°C
5
RSC ..
7
Page B7 - B10
RKC ..
6
WSC ..
8
Pages B7 - B10
WKC ..
11
FSFD ..
Page B7 - B10
Pages B7 - B10
12
Pages B7 - B10
FKFD ..
Pages B7 - B10
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B12
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Flat Cable Specifications
• Cable that Meets the Requirements of ODVA Thick or Type II Cable
• Uses Insulation Displacement Connectors as Device Taps
Jacket
Red
White
Blue
Black
Data Rate
Maximum Trunk Length
125 Kbaud
420 meters (1378 feet)
250 Kbaud
200 meters (656 feet)
500 Kbaud
100 meters (328 feet)
Power Pair
Data Pair
Type
Approvals
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
5713
NEC CL2
CEC AWM-I/II A/B FT4
2/16 AWG
BK/RD
4.1
PE
2/16 AWG
BU/WH
75°C 300 Volts
Outer Jacket
Shields
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
4.1
PE
PVC Light Grey
Flat Profile††
None
Bulk Cable
Part Number /
Weight/300 M
RB50787-*M
116 lbs.
* Indicates length in meters.
†† Flat cable profile is 19.3 mm (0.760 in) x 5.3 mm (0.210 in).
Flat Cable Profile
B13
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Flat Cable Connectors
• Provides a minifast ® or eurofast ® Drop Connector from Flat Cable
Housing
Part Number
Application
(7/8-16UN) minifast Flat
Cable Connector
RKF 57-IDC
•
Pinouts
Female
Flat cable connector to
female (7/8-16UN)
minifast drop
Female
RKF 40-IDC
(7/8-16UN) minifast Auxiliary
Power Connector
(M12x1) eurofast Flat Cable
Connector
FK 57-IDC
•
Female
Flat cable connector to
female (M12x1)
eurofast drop
FK 57-IDC ET
RKF 57-IDC ET
Includes connector, end termination, and splice kit
RKF 40-IDC ET
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
POM (Nylon)
Nickel-Plated CuZn or Stainless Steel
Nylon
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4 A (eurofast), 9 A (minifast)
-30°C to +75°C
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B14
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Notes
B15
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Pico Cable Specifications
• Cable that Meets the Electrical Requirements of ODVA Thin Cable (Data Pair Only)
• Pico Cable has 24 AWG Conductors Which May be Used with picofast ® Connectors
• Submittal to ODVA - Pending
Jacket
Blue
White
Black
Red
Data
Power
Foil Shield
Overall Foil Shield
DeviceNet - Pico Cable 5724
DeviceNet - Thin Cable 5715
Data Rate
Maximum Trunk Length
Data Rate
Maximum Trunk Length
125 Kbaud
35 meters (115 feet)
125 Kbaud
100 meters (984 feet)
250 Kbaud
35 meters (115 feet)
250 Kbaud
100 meters (820 feet)
500 Kbaud
35 meters (115 feet)
500 Kbaud
100 meters (328 feet)
Power Pair
Type
5724
AWM 2464
80°C 300 Volts
5715
AWM 2464
80°C 300 Volts
Approvals
Data Pair
AWG
DCR (/1000 feet)
AWG
DCR (/1000 feet)
Color Code
Insulation
Color Code
Insulation
Outer Jacket
Shields
Material Color
Nominal O.D.
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
NEC AWM
CEC AWM-I/II A/B FT1
2/24 AWG
BK/RD
24.9
PVC
2/24 AWG
BU/WH
24.9
PE
PVC Light Grey
5.7 mm (.224 in)
Foil (Data Only)
22 AWG
RB51045-*M
27 lbs.
NEC AWM
CEC AWM-I/II A/B FT1
2/22 AWG
BK/RD
16.5
PVC
2/22 AWG
BU/WH
16.5
PE
PVC Light Grey
6.0 mm (.235 in)
Foil (Data Only)
22 AWG
RB50764-*M
26 lbs.
* Indicates length in meters.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B16
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Cable/Cordsets Selection Matrix - Threaded
picofast ® (5724 Cable Only)
Socket (Female)
15
Pin (Male)
16
13
14
PKGM
PKWM
PSGM
PSWM
PKGM 57x-*M
PKWM 57x-*M
PSGM 57x-*M
PSWM 57x-*M
RST PKGM 57x-*M
RST PKWM 57x-*M
RST PSGM 57x-*M
RST PSWM 57x-*M
WST PKGM 57x-*M
WST PKWM 57x-*M
WST PSGM 57x-*M
WST PSWM 57x-*M
RKT PKGM 57x-*M
RKT PKWM 57x-*M
RKT PSGM 57x-*M
RKT PSWM 57x-*M
WKT PKGM 57x-*M
WKT PKWM 57x-*M
WKT PSGM 57x-*M
WKT PSWM 57x-*M
PKGM PKGM 57x-*M
PKGM PKWM 57x-*M
PKGM PSGM 57x-*M
PKGM PSWM 57x-*M
PKWM PKWM 57x-*M
PKWM PSGM 57x-*M
PKWM PSWM 57x-*M
PSGM PSGM 57x-*M
PSGZ PSWM 57x-*M
Bare
eurofast ®
Pin (Male)
17
RST
18
Socket (Female)
WST
19
RKT
20
Socket (Female)
15
PKGM
16
PKWM
Pin (Male)
picofast (5724 Cable Only)
WKT
13
PSGM
14
PSWM PSWM 57x-*M
PSWM
See pages B19 - B20 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Type 5715 cable can be used with RST, WST, RKT and WKT smaller body styles. Consult factory for part numbers.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
picofast
Male
B17
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
6. N/C (picofast only)
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Cable/Cordsets Selection Matrix - Snap Lock
picofast ®
Socket (Female)
18
Pin (Male)
17
PKGZ
PSG
PKGZ 57x-*M
PSG 57x-*M
RST PKGZ 57x-*M
RST PSG 57x-*M
WST PKGZ 57x-*M
WST PSG 57x-*M
RKT PKGZ 57x-*M
RKT PSG 57x-*M
WKT PKGZ 57x-*M
WKT PSG 57x-*M
PKGM PKGZ 57x-*M
PKGZ PSG 57x-*M
Bare
eurofast ®
Pin (Male)
17
RST
18
Socket (Female)
WST
19
RKT
20
Pin (Male)
Socket (Female)
picofast
WKT
15
PKGZ
16
PSG PSG 57x-*M
PSG
See pages B19 - B20 for dimensional drawings.
* Indicates length in meters.
x Indicates cable type.
Type 5715 cable can be used with RST, WST, RKT and WKT smaller body styles. Consult factory for part numbers.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 Meters. Consult factory for other lengths.
picofast
Male
Pinouts
Female
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
6. N/C (picofast only)
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B18
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Cable/Cordsets Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (polyurethane)
Nickel-Plated CuZn or Stainless Steel
PUR (polyurethane)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-30°C to +75°C
19
RST ..
20
Pages B17 - B18
RKT ..
21
WST ..
B19
Pages B17 - B18
22
Pages B17 - B18
WKT ..
Pages B17 - B18
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, picofast ® Cable/Cordsets Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (polyurethane)
Nickel-Plated CuZn or Stainless Steel (thread), Nylon (snap lock)
PUR (polyurethane) or POM (Nylon)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
30 V
1.5 A
-30°C to +75°C
13
PSGM ..
15
Page B17
PKGM ..
14
PSWM ..
16
Page B17
PKWM ..
17
PSG ..
Page B17
Page B17
18
Page B18
PKGZ ..
Page B18
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B20
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Terminating Resistors
• Terminating Resistors Stabilize and Minimize Reflections on the Bus Line
• A Terminating Resistor is Required at the Beginning and End of the Main Bus Line
Housing
Part Number
RSM 57-TR2
Specs
Nickel Plated Brass or
Stainless Steel
300 V, 9 A
-30°C to +75°C
IP 67
Application
minifast ® Terminating Resistor
•
•
RSM 57VM-TR2
RKM 57-TR2
120 Ohms, 1/4 W
internal resistance
RSE 57-TR2
RKE 57-TR2
B21
•
•
Male minifast connector
•
120 Ohms, 1/4 W
internal resistance
minifast Terminating Resistor
Nickel Plated CuZn or
Stainless Steel
250 V, 4 A
-30°C to +75°C
IP 67
eurofast ® Terminating Resistor
Nickel Plated CuZn or
Stainless Steel
250 V, 4 A
-30°C to +75°C
IP 67
eurofast Terminating Resistor
•
•
Male
Led indication:
Red - reverse polarity
Green-okay
Nickel Plated Brass or
Stainless Steel
250 V, 4 A
-30°C to +75°C
IP 67
•
•
Male
Male minifast connector
minifast Terminating Resistor with
Voltage Monitoring
Nickel Plated Brass or
Stainless Steel
300 V, 9 A
-30°C to +75°C
IP 67
Pinouts
Female
Female minifast connector
120 Ohms, 1/4 W
internal resistance
Male
Male eurofast connector
120 Ohms, 1/4 W
internal resistance
Female
•
•
Female eurofast connector
120 Ohms, 1/4 W
internal resistance
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
5 DeviceNet™, Receptacles
• Receptacles Provide Transition from Male to Female Connectors
• Available for Bulkhead and Feed Through Applications
Housing
Part Number
RSF RKF 57/22
FKM FS 57/M12
Specs
Nickel Plated CuZn
or Stainless Steel
300 V, 9 A
-30°C to +75°C
IP 67
Nickel Plated CuZn
or Stainless Steel
250 V, 4 A
-30°C to +75°C
IP 67
Application
minifast ® Bulkhead
Receptacle
•
Male
Female
Male
Female
Straight
male/female
feed through
eurofast ® Bulkhead
Receptacle
•
Pinouts
Straight
male/female
feed through
Standard housing material is nickel plated brass. "RSF RKF.."; "RSFV RKFV.." indicates stainless steel housing.
Panel Cutout
RSF RKF 57/22
Panel Cutout
FKM FS 57/M12
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B22
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Junctions
• Multi-port Junction Boxes for Connecting I/O in Concentrated Areas
• Available in Standard and Voltage Monitoring
Part Number
Application
Wiring Diagram
8-port Junction with Voltage Monitoring
JBBS-57-E811
•
•
•
Bus in/bus out connections (7/8-16UN) minifast ®
Eight (M12x1) eurofast connectors for field connectors
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
8-port Junction
JBBS-57-E812
B23
•
•
Bus in/bus out connections (7/8-16UN) minifast
Eight (M12x1) eurofast connectors for field connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
POM (Nylon)
Nickel-Plated CuZn or Stainless Steel
Nylon
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-30°C to +75°C
Dimensions
8-port
Pinouts
minifast
Male
eurofast
Female
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B24
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, picofast ® Junctions, 4-port
• Multi-port Passive Junction Box in Small Compact Housing
• Accepts (M8x1) Snap Lock or Threaded Connectors
• Available in Standard and Voltage Monitoring
Part Number
Application
Wiring Diagram
4-port Junction Tee
JBBS-57-FS-P424Z
•
•
(M12x1) eurofast ® drop connector
Four (M8x1) picofast snap lock connectors
4-port Junction Tee
JBBS-57-FS-P424M
•
•
(M12x1) eurofast drop connector
Four (M8x1) picofast threaded connectors
4-port Junction Tee
JBBS-57-FS/VM-P424Z
•
•
•
(M12x1) eurofast drop connector
Four (M8x1) picofast snap lock connectors
Voltage monitoring provides low voltage (12.9 V) and high voltage
(25.6) indication
LED Indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
4-port Junction Tee
JBBS-57-FS/VM-P424M
•
•
•
(M12x1) eurofast drop connector
Four (M8x1) picofast threaded connectors
Voltage monitoring provides low voltage (12.9 V) and high
voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
B25
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
POM (Nylon)
Nickel-Plated CuZn or Stainless Steel
PUR (polyurethane) or POM (Nylon)-picofast ®, POM (Nylon)-eurofast ®
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
30 V
1.5 A
-30°C to +75°C
JBBS-57-FS-P424Z
JBBS-57-FS-P424M
picofast
Male
Pinouts
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
6. N/C (picofast only)
picofast
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B26
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, picofast ® Junctions, 8-port
• Multi-port Passive Junction Box in Small Compact Housing
• Accepts (M8x1) Snap Lock or Threaded Connectors
• Available in Standard and Voltage Monitoring
Part Number
Application
Wiring Diagrams
8-port Junction Tee
JBBS-57-FS-P824Z
•
•
(M12x1) eurofast ® drop connector
Eight (M8x1) picofast snap lock connectors
8-port Junction Tee
JBBS-57-FS-P824M
•
•
(M12x1) eurofast drop connector
Eight (M8x1) picofast threaded connectors
8-port Junction Tee
JBBS-57-FS/VM-P824Z
•
•
•
(M12x1) eurofast drop connector
Eight (M8x1) picofast snap lock connectors
Voltage monitoring provides low voltage (12.9 V)
and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
8-port Junction Tee
JBBS-57-FS/VM-P824M
•
•
•
(M12x1) eurofast drop connector
Eight (M8x1) picofast threaded connectors
Voltage monitoring provides low voltage (12.9 V)
and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
B27
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
POM (Nylon)
Nickel-Plated CuZn or Stainless Steel
PUR (polyurethane) or POM (Nylon)-picofast ®, POM (Nylon)-eurofast ®
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
30 V
1.5 A
-30°C to +75°C
JBBS-57-FS-P824Z
JBBS-57-FS-P824M
picofast
Male
Pinouts
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
6. N/C (picofast only)
picofast
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B28
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Passive Multiport Junctions
• Rugged, Fully Encapsulated Enclosure
• For Connecting I/O in Concentrated Areas
• Bus-In / Bus-Out Eliminates Need for Splitter Tee
• Suitable for Outdoor Applications
Part Number
Specs
Application
Wiring Diagram
4-port Junction
JBBS-57-M401
•
Bus in/bus out straight (7/8-16UN) minifast ®
through ports
•
Four device ports with (7/8-16UN) minifast
connectors
6-port Junction
JBBS-57-M601
Die-cast aluminum
enclosure.
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Six device ports with (7/8-16UN) minifast
connectors
8-port Junction
JBBS-57-M801
B29
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Eight device ports with (7/8-16UN) minifast
connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Anodized Aluminum
Nickel-Plated CuZn or Stainless Steel
TPU (polyurethane) or POM (Nylon)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-30°C to +75°C
Dimensions
8-Port
6-Port
4-Port
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B30
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Passive Multiport Junctions
• Rugged, Fully Encapsulated Enclosure
• For Connecting I/O in Concentrated Areas
• Bus-In / Bus-Out Eliminates Need for Splitter Tee
• Suitable for Outdoor Applications
Part Number
Specs
Application
Wiring Diagram
4-port Junction
JBBS-57-E401
•
Bus in/bus out straight (7/8-16UN) minifast ®
through ports
•
Four device ports with (M12x1) eurofast
connectors
6-port Junction
JBBS-57-E601
Die-cast aluminum
enclosure.
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Six device ports with (M12x1) eurofast
connectors
8-port Junction
JBBS-57-E801
B31
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Eight device ports with (M12x1) eurofast
connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Anodized Aluminum
Nickel-Plated CuZn or Stainless Steel
TPU (polyurethane) or POM (Nylon)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-30°C to +75°C
Dimensions
8-Port
6-Port
4-Port
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B32
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Junction Tee
• Indoor Use Only (for outdoor applications use JBBS family)
• Multi-port Junction Provides a Rugged Connection to Network Devices
• Bus-in/Bus-out Feature Eliminates Need for Splitter Tee
• Short-Circuit Protection Available
Part Number
Application
Wiring Diagrams
4-port Junction Tee
JTBS 57-M433
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Four (7/8-16UN) minifast device ports
For nickel plated brass connectors change part number to JTBS 57-M434
4-port Junction Tee
JTBS 57VM-M433
•
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Four (7/8-16UN) minifast device ports
For nickel plated brass connectors change part number to JTBS 57VM-M434
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
•
CL 1, Div 2; Groups A-D see TURCK drawing N1-2.400 T6, Ta = 70°C
6-port Junction Tee
JTBS 57-M633
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Six (7/8-16UN) minifast device ports
For nickel plated brass connectors change part number to JTBS 57-M634
6-port Junction Tee
JTBS 57VM-M633
•
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Six (7/8-16UN) minifast device ports
For nickel plated brass connectors change part number to JTBS 57VM-M634
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
•
B33
CL 1, Div 2; Groups A-D see TURCK drawing N1-2.400 T6, Ta = 70°C
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (polyurethane)
Nickel-Plated CuZn or Stainless Steel
PUR (polyurethane or POM (Nylon)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
300 V
9A
-30°C to +75°C
Dimensions
6-port
4-port
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B34
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Junction Tee
• Indoor Use Only (for outdoor applications use JBBS family)
• Multi-port Junction Provides a Rugged Connection to Network Devices
• Bus-in/Bus-out Feature Eliminates Need for Splitter Tee
• Short-Circuit Protection Available
Part Number
Application
Wiring Diagrams
4-port Junction Tee
JTBS 57-E433
•
•
•
(7/8-16UN) minifast ® bus in/bus out connections
Four (M12x1) eurofast device ports
For nickel plated brass connectors change part number to JTBS 57-E434
4-port Junction Tee
JTBS 57VM-E433
•
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Four (M12x1) eurofast device ports
For nickel plated brass connectors change part number to JTBS 57VM-E434
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9 - 25.6 V Green
(Hi) > 25.6 V Amber
•
CL 1, Div 2; Groups A-D see TURCK drawing N1-2.400 T6, Ta = 70°C
6-port Junction Tee
JTBS 57-E633
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Six (M12x1) eurofast device ports
For nickel plated brass connectors change part number to JTBS 57-E634
6-port Junction Tee
JTBS 57VM-E633
•
•
•
•
(7/8-16UN) minifast bus in/bus out connections
Six (M12x1) eurofast device ports
For nickel plated brass connectors change part number to JTBS 57VM-E634
Voltage monitoring provides low voltage (12.9 V) and high voltage (25.6) indication
LED indication:
(Lo) < 12.9 V Amber
(Ok) 12.9-25.6 V Green
(Hi) > 25.6 V Amber
•
B35
CL 1, Div 2; Groups A-D see TURCK drawing N1-2.400 T6, Ta = 70°C
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (polyurethane)
Nickel-Plated CuZn or Stainless Steel
POM (Nylon)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-30°C to +75°C
Dimensions
4-port
6-port
Pinouts
minifast
Male
eurofast
Female
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B36
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Drop Junctions
• Creates a Drop or Branch from the Main Bus Line
• Cable Drop Lengths Available Up to a Maximum of 6 Meters
Housing
Part Number
Application
Wiring Diagrams
VB2 Junction
VB2-FKM/FKM/FSM 57
•
Ready for eurofast drop and trunk
cordsets
•
Maximum six meter drop
VB2 Junction with Trunk Line
VB2-RKC 57x-*M-FKM FSM
•
•
Ready for eurofast trunk line
Maximum six meter drop
VB2 Junction with Trunk Line
VB2-FKM/RKC RSC 57x-*M/*M
•
•
Ready for eurofast drop cordsets
Maximum six meter branch
* Indicates length in meters.
x Indicates cable type.
B37
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (polyurethane)
Nickel-Plated CuZn or Stainless Steel
PUR (polyurethane) or POM (Nylon)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-30°C to +75°C
Stainless steel coupling nut add “V” to part number (RS to RSV, RK to RKV).
Nylon coupling nut add “K” to part number (RS to RSK, RK to RKK).
Right angle connectors, change part number (RS to WS, RK to WK).
Mounting: Mounting hole accepts #8 screw.
VB2-FKM/FKM/FSM 57
VB2-RKC 57x-*M-FKM FSM
VB2-FKM/RKC RSC 57x-*M/*M
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B38
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Conduit Adapters
• Gasket and Mounting Screws Provided
• Same Housing Style for Single or Double Port
Housing
Part Number
Specs
Application
Pinout
Attaches to standard conduit
body* for transition to 5-wire
(7/8-16UN) minifast
connector
BCA 57-M123
*Crouse-Hinds 3/4" Form 8,
Mark 9 or equivalent.
Female
Nylon Housing
Stainless Steel
Receptacle Housing
300 V, 9 A
-30°C to +75°C
BCA 57-M223
Attaches to standard conduit
body* for transition to 5-wire
(7/8-16UN) minifast
connector
*Crouse-Hinds 3/4" Form 8,
Mark 9 or equivalent.
Standard receptacle housing material is stainless steel, for nickel plated brass change part number from ... M223 to ... M224.
1-port Wiring Diagram
B39
2-port Wiring Diagram
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Conduit Adapters
• Gasket and Mounting Screws Provided
• Same Housing Style for Single or Double Port
Housing
Part Number
Specs
Application
Pinout
Attaches to standard conduit
body* for transition to 5-wire
(M12x1) eurofast connector
BCA 57-E123
*Crouse-Hinds 3/4" Form 8,
Mark 9 or equivalent.
Female
Nylon Housing
Stainless Steel
Receptacle Housing
250 V, 4 A
-30°C to +75°C
BCA 57-E223
Attaches to standard conduit
body* for transition to 5-wire
(M12x1) eurofast connector
*Crouse-Hinds 3/4" Form 8,
Mark 9 or equivalent.
Standard receptacle housing material is stainless steel, for nickel plated brass change part number from ... M223 to ... M224.
1-port Wiring Diagram
2-port Wiring Diagram
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B40
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Bus Drop and Diagnostic Tees
• Creates a Drop or Branch from the Main Bus Line
• (7/8-16UN) minifast ® Connectors on Bus and Drop Lines
• Available in Three Keyway Options
Housing
Part Number
Specs
Application
Wiring Diagrams
minifast Drop Off
Bus Line
•
Full power and
data drop
•
Maximum six
meter branch
•
Standard keyway
RSM 2RKM 57
minifast Drop Off
Bus Line
RSM 2RKM 57-KF
PUR (polyurethane)
300 V, 9 A
-30°C to +75°C
•
Full power and
data drop
•
Maximum six
meter branch
•
Keyway facing
female
minifast Drop Off
Bus Line
RSM 2RKM 57-KM
•
Full power and
data drop
•
Maximum six
meter branch
•
Keyway facing
male
Pinouts
minifast
Male
B41
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Power and Diagnostic Tees
• Provide a Drop to Insert Power or Diagnostic Equipment
• (7/8-16UN) minifast ® Connectors on Bus and Drop Lines
• Reverse Current Protection on Power Tap
Part Number
Housing
Specs
Application
Wiring Diagrams
Bus Power
RSM RKM 57 WSM 40 PST
•
Tee provides
segment power
•
Includes reverse
current protection
PUR
(polyurethane)
300 V, 9 A
-30°C to +75°C
Bus Diagnostic Tee
•
Provides easy
connection for
diagnostic tools
•
Tap protected
with cover when
not in use
(not shown)
RSC 2RKM 57 DGT
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B42
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Bus Tees
• Creates a Drop or Branch from the Main Bus Line
• Cable Drop can be up to a Maximum of 6 Meters
• eurofast ® Drop Connector or Extension Cordset
Part Number
Housing
Specs
Application
Wiring Diagrams
eurofast Drop
•
•
RSM-FKM-RKM 57
minifast ® to eurofast
Bus power and
data drop
PUR (polyurethane)
250 V, 4 A
-30°C to +75°C
eurofast Drop Cordset
RSM RKC 57x-*M
RKM 57
•
minifast to eurofast
cordset
•
Bus power and
data drop
Pinouts
minifast
Male
B43
eurofast
Female
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Bus Tees
• Creates a Drop or Branch from the Main Bus Line
• Cable Drop Can Be Up to a Maximum of 6 Meters
• eurofast Drop Connector
Housing
Part Number
Specs
Application
Wiring Diagram
eurofast Tee
RSC 2RKC 57
RSC 2RKC 57/KS
•
eurofast trunk and
drop
PUR (polyurethane)
eurofast Tee
250 V, 4 A
-30°C to +75°C
• eurofast trunk and
drop
•
Keyway aligns tee
in-line on (M8x1)
piconet ® boxes
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B44
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Gender Changers and Elbow Connectors
• Allows Quick and Easy Changes from Male to Female Connectors
• Available in Straight and Right Angle Styles with minifast ® Connectors
Housing
Part Number
Specs
Application
Male minifast Gender Changer
RSM RSM 57
•
Changes female cordset to male cordset
Female minifast Gender Changer
RKM RKM 57
PUR (polyurethane)
300 V, 9 A
-30°C to +75°C
•
•
Changes male cordset to female cordset
Changes straight male or female cordset
to right angle cordset
minifast Elbow
WSM RKM 57
•
Right angle male to female connector
Pinouts
minifast
Male
B45
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, Gender Changers and Elbow Connectors
• Allows Quick and Easy Changes from Male to Female and
minifast ® to eurofast ® Connectors
Housing
Specs
Part Number
RSM 57-FK 4.5
Nickel Plated CuZn or
Stainless Steel
250 V, 4 A
-30°C to +75°C
Application
Wiring Diagram
Female eurofast to male
minifast adapter
Pinouts
minifast
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B46
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, (7/8-16UN) minifast ® Male Receptacles
• Provides Quick Connection to Field Devices or Enclosures
• Available for 1/2-14NPT, 1/2-14NPSM, 3/4-14NPT and M20 Threads
Housing
Part Number
Specs
Application
Pinouts
23
RSF 57-*M/14.5
1/2-14NPT full length
threads
RSF 57-*M/14.75
3/4-14NPT full length
threads
25
24
RSF 57-*M/M20
Nickel Plated CuZn
or Stainless Steel
300 V, 9 A
-30°C to +75°C
M20x1.5 threads
1.
2.
3.
4.
5.
GY
RD
BK
WH
BU
Male
26
RSF 57-*M
1/2-14NPSM threads
RSF 57-*M/NPT
1/2-14NPT modified
length threads
27
See page B55 for dimensional drawings.
Standard cable length is 0.3 Meters. Consult factory for other lengths.
Receptacles require a 13/16" (21 mm) clearance hole for panel mounting.
Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
For locknuts to be included, add "W/LN" to the end of the part number.
B47
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, (7/8-16UN) minifast ® Female Receptacles
• Provides Quick Connection to Field Devices or Enclosures
• Available for 1/2-14NPT, 1/2-14NPSM, 3/4-14NPT and M20 Threads
Housing
Part Number
Specs
Application
Pinouts
28
RKF 57-*M/14.5
1/2-14NPT full
length threads
RKF 57-*M/14.75
3/4-14NPT full
length threads
30
Female
29
RKF 57-*M/M20
Nickel Plated CuZn
or Stainless Steel
300 V, 9 A
-30°C to +75°C
M20x1.5 threads
1.
2.
3.
4.
5.
GY
RD
BK
WH
BU
31
RKF 57-*M
1/2-14NPSM
threads
32
RKF 57-*M/NPT
1/2-14NPT
modified length
threads
See page B56 for dimensional drawings.
Standard cable length is 0.3 Meters. Consult factory for other lengths.
Receptacles require a 13/16" (21 mm) clearance hole for panel mounting.
Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
For locknuts to be included, add "W/LN" to the end of the part number.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B48
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, (M12x1) eurofast ® Male Receptacles
• Provides Quick Connection to Field Devices
• Available for 1/2-14NPT, 1/2-14NPSM, 3/4-14NPT and M20 Threads
Housing
Part Number
Specs
Application
Pinout
33
FS 57-*M/14.5
1/2-14NPT full length
threads
FS 57-*M/14.75
3/4-14NPT full length
threads
35
34
Male
FS 57-*M/M20
Nickel Plated CuZn
or Stainless Steel
250 V, 4 A
-30°C to +75°C
M20x1.5 threads
1.
2.
3.
4.
5.
GY
RD
BK
WH
BU
36
FS 57-*M
PG 9 threads
37
FS 57-*M/NPT
1/2-14NPT modified
length threads
See page B57 for dimensional drawings.
Standard cable length is 0.3 Meters. Consult factory for other lengths.
Receptacles require a 13/16" (21 mm) clearance hole for panel mounting.
Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
B49
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, (M12x1) eurofast ® Female Receptacles
• Mounted for Quick Connection to Enclosures
• Available for 1/2-14NPT, 1/2-14NPSM, 3/4-14NPT and M20 Threads
Housing
Part Number
Specs
Application
Pinouts
38
FK 57-*M/14.5
1/2-14NPT full
length threads
FK 57-*M/14.75
3/4-14NPT full
length threads
40
39
Female
FK 57-*M/M20
Nickel Plated CuZn
or Stainless Steel
250 V, 4 A
-30°C to +75°C
M20x1.5 threads
1.
2.
3.
4.
5.
GY
RD
BK
WH
BU
41
FK 57-*M
PG 9 threads
42
FK 57-*M/NPT
1/2-14NPT
modified length
threads
See page B58 for dimensional drawings.
Standard cable length is 0.3 Meters. Consult factory for other lengths.
Receptacles require a 13/16" (21 mm) clearance hole for panel mounting.
Standard housing material is nickel plated brass. "RKF .."; "RKFV .." indicates 316 stainless steel housing.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B50
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® PCB and Solder Cup Receptacles
• Provides (7/8-16UN) minifast Connection to Field Devices
Housing
Part Number
Specs
Application
Pinouts
43
Male minifast PCB pins
RSF 57 PCB
Male
45
Male minifast solder
cups
RSF 57
1.
2.
3.
4.
5.
Nickel Plated CuZn or
Stainless Steel
300 V, 9 A
-30°C to +75°C
44
RKF 57 PCB
BARE
RD
BK
WH
BU
Female minifast PCB
pins
Female
46
RKF 57
Female minifast solder
cups
See page B59 for dimensional drawings.
Standard housing material is nickel plated brass "RSFV .."; "RKFV .." indicates 316 stainless steel.
Panel Cutout
FK ... FS
B51
Board Layout (reference only)
FK ... FS
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® PCB and Solder Cup Receptacles
• Provides (M12x1) eurofast Connection to Field Devices
Housing
Part Number
Specs
Application
Pinouts
50
Male eurofast with
mounting kit
FS 57 PCB KIT
Male
51
Male eurofast
FS 57 PCB
1.
2.
3.
4.
5.
Nickel Plated CuZn or
Stainless Steel
250 V, 4 A
-30°C to +75°C
54
FK 57 PCB KIT
Female eurofast with
mounting kit
BARE
RD
BK
WH
BU
Female
55
FK 57 PCB
Female eurofast
See page B60 for dimensional drawings.
Standard housing material is nickel plated brass "FSV .."; "FKV .." indicates 316 stainless steel.
Board Layout (reference only)
FK ... FS
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B52
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® PCB Pins and Solder Cup Receptacles
• Provides (M12x1) eurofast Connection to Field Devices
Housing
Part Number
Specs
Application
Pinouts
49
Male eurofast PCB
pins
FSFD 57 PCB
Male
48
Male eurofast solder
cups
FSFDL 57
47
WFS 57 PCB
Nickel Plated CuZn or
Stainless Steel
250 V, 4 A
-30°C to +75°C
Male eurofast right
angle PCB pins
1.
2.
3.
4.
5.
BARE
RD
BK
WH
BU
53
FKFD 57 PCB
Female eurofast PCB
pins
FKFDL 57
Male eurofast solder
cups
Female
52
See pages B59 - B60 for dimensional drawings.
Standard housing material is nickel plated brass "FKFD .."; "FKFDV .." indicates 316 stainless steel.
Panel Cutout
FKFD ... FSFD
B53
Board Layout (reference only)
FKFD ... FSFD
Panel Cutout
WFS
Board Layout (reference only)
WFS
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Notes
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B54
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
minifast ® Male Receptacles
23
RSF ..1/2-14NPT
25
Page B47
RSF ..3/4-14NPT
24
RSF .. M20x1.5
Page B47
26
Page B47
RSF .. 1/2-14NPSM
Page B47
27
RSF .. 1/2-14NPT
B55
Page B47
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
minifast ® Female Receptacles
28
RKF .. 1/2-14NPT
30
Page B48
RKF .. 3/4-14NPT
29
RKF .. M20x1.5
Page B48
31
Page B48
RKF .. 1/2-14NPSM
Page B48
32
RKF .. 1/2-14NPT
Page B48
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B56
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
eurofast ® Male Receptacles
33
FS .. 1/2-14NPT
35
Page B49
FS .. 3/4-14NPT
34
FS .. M20x1.5
Page B49
36
Page B49
FS .. PG 9
Page B49
37
FS .. 1/2-14NPT
B57
Page B49
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
eurofast ® Female Receptacles
38
FK .. 1/2-14NPT
40
Page B50
FK .. 3/4-14NPT
39
FK .. M20x1.5
Page B50
41
Page B50
FK .. PG 9
Page B50
42
FK .. 1/2-14NPT
Page B50
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B58
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
minifast ® PCB Mount Male and Female Receptacles
43
RSF ..PCB
45
Page B51
RSF ..
44
RKF ..PCB
Page B51
46
Page B51
RKF ..
Page B51
eurofast ® PCB Mount Male and Female Receptacles
47
WFS ..PCB
B59
Page B53
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
eurofast ® PCB Mount Male and Female Receptacles
48
FSFDL ..
52
Page B53
FKFDL ..
49
FSFD ..PCB
53
Page B53
FKFD ..PCB
50
FS ..PCB KIT
Page B53
54
Page B52
FK ..PCB KIT
51
FS ..PCB KIT
Page B53
Page B52
55
Page B52
FK ..PCB KIT
Page B52
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B60
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, minifast ® Field Wireable Connectors
• Allows for Quick Connection when Pre-Molded Cables not Available
• Available for Male and Female Connectors
Housing
Part Number
BS 4151-0/9
BS 4151-0/13.5
B 4151-0/9
B 4151-0/13.5
B61
Cable
Application
Glass filled nylon
PG 9 cable gland
accepts 6-8 mm cable diameter
Screw terminals
85°C
250 V, 9 A
Glass filled nylon
PG 13.5 cable gland
accepts 10-12 mm cable diameter
Screw terminals
85°C
250 V, 9 A
Glass filled nylon
PG 9 cable gland
accepts 6-8 mm cable diameter
Screw terminals
85°C
250 V, 9 A
Pinouts
Male
Mates with all 5-pin
cordsets and receptacles
Female
Glass filled nylon
PG 13.5 cable gland
accepts 10-12 mm cable diameter
Screw terminals
85°C
250 V, 9 A
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Field Wireable Connectors
• Allows for Quick Connection when Pre-Molded Cables not Available
• Available for Male and Female Connectors in Straight or
Right-Angle Configurations
Housing
Part Number
B 8251-0
BS 8251-0
Cable
Application
PBT, Black
PG 7 cable gland
accepts 4-8 mm cable diameter
Screw terminals
85°C
125 V, 4 A
Pinouts
Male
PBT, Black
PG 7 cable gland
accepts 4-8 mm cable diameter
Screw terminals
85°C
125 V, 4 A
Mates with 5-pin cordsets
and receptacles
B 8151-0
BS 8151-0
PBT, Black
PG 7 cable gland
accepts 4-6 mm cable diameter
Screw terminals
85°C
250 V, 4 A
Female
PBT, Black
PG 7 cable gland
accepts 4-6 mm cable diameter
Screw terminals
85°C
250 V, 4 A
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B62
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, Power Taps
• Allows Connection to Bus Line for Bringing in 12 VDC Power
• Available with minifast ® Bus Line and Drop Connectors or
Terminal Connectors
Part Number
Application
Wiring Diagrams
Power Tap with minifast Connectors
SPTC1
•
•
(7/8-16UN) minifast male to female bus connector
(7/8-16UN) minifast female power connector
Power Tap with minifast Connectors
SPTC2
•
•
(7/8-16UN) minifast female to female bus connector
(7/8-16UN) minifast female power connector
Power Tap with Terminal Connectors
SPTT1
B63
•
•
Terminal strip bus connectors
Terminal strip power connector
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Anodized Aluminum
Nickel-Plated CuZn or Stainless Steel
PUR (polyurethane)
Gold-Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
300 V
9A
-30°C to +75°C
Dimensions
SPTC1
SPTC2
SPTT1
Pinouts
minifast - Bus Line
Female
1. Bare (Shield)
2. Red (+ Voltage)
3. Black (- Voltage)
4. White (CAN_H)
5. Blue (CAN_L)
minifast - Auxiliary Power
Male
1. + Voltage
2. - Voltage
3. + Voltage
4. - Voltage
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B64
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
DeviceNet™, eurofast ® Daisy Chain Configurations
• Multi-drop Harnesses Designed for OEM Applications
• Provides Cost Effective Solution vs. Single Tees and Drops
Specs
Part Number
WSC-2VBWK-WKC-5724-DCL-1138
Application
(M12x1) eurofast Trunk and Drop Harness
PUR (polyurethane)
250 V, 4 A
-30°C to +75°C
•
Available in custom configurations including length, number of drops
and end connector styles
Consult factory for other designs.
Pinouts
eurofast
Male
B65
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
DeviceNet™, eurofast ® Daisy Chain Configurations
• Multi-drop Harnesses Designed for OEM Applications
• Provides Cost Effective Solution vs. Single Tees and Drops
Specs
Part Number
RSC-8VBRK-RKC-5724-DCL
Application
(M12x1) eurofast Trunk and Drop Harness
PUR (polyurethane)
250 V, 4 A
-30°C to +75°C
•
Available in custom configurations including length, number of
drops and end connector styles
Consult factory for other designs.
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
B66
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement