Margaritaville | NBMGLG1000 | User manual | Margaritaville NBMGLG1000 User manual

Tailgating Tabletop
Grill
The Best Cheeseburgers In Paradise
Come From Margaritaville
®
Model NBMGLG1000 & NBMGLG1900
User Manual
-A-
Welcome TO
M A R G A R I TAV I L L E ®
Margaritaville® isn’t a place, it’s a state of mind …
it is an escape from the everyday! The Margaritaville® Tailgating Tabletop Grill
makes it a short trip from here to there, where you can put on your no-worries
attitude and enjoy perfectly grilled food on the go.
The Tailgating Tabletop Grill instruction manual was developed to help quickly familiarize you
with your grill. You’re just a few short steps away from Margaritaville®, enjoying perfectly
grilled food. To learn more or to purchase other Margaritaville® products, please visit us at
www.margaritavillecargo.com
ANSI Z21.89a-2008/
CSA 1.18a-2008
Outdoor Cooking Specialty
Gas Appliances
CONSUMER/USER: This instruction manual contains important information necessary for the
proper assembly and safe use of the appliance. Read and follow all warnings and instructions before
assembling and using the appliance. Follow all warnings and instructions when using the appliance.
Keep this manual for future reference. Failure to follow these warnings and instructions may cause
death, personal injury, or property damage.
If you have questions or need advice regarding your grill or its safe operation, please visit www. margaritavillecargo.com
or call 1-877-689-2737.
Technical Characteristics
Input: 20,000 BTU/H
Category: Pressure regulated propane
Fuel: 16.4 oz. disposable propane cylinders
Regulator: RJ-B
FOR OUTDOOR USE ONLY
Contents
General Safety Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3
Portable L.P. (Propane) Gas Barbecue Cylinders . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
DANGER
DANGER indicates an imminently hazardous situation which,
if not avoided, will result in death or serious injury.
Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Cooking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Grill Performance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Attaching The Propane Cylinder. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Removing The Propane Cylinder. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Annual Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
General Maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
WARNING
WARNING indicates a potentially hazardous situation which,
if not avoided, could result in death or serious injury.
CAUTION
CAUTION indicates a potentially hazardous situation which,
if not avoided, may result in minor or moderate personal
injury, or property damage.
Storage, Transport And/Or Non-Use. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Replacement Parts List. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Accessories. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
General Safety Information
This manual contains important information about the assembly,
operation and maintenance of this product and system. General
safety information is presented in these first few pages and is also
located throughout the manual. Particular attention should be paid to
DANGER”,
information accompanied by the safety alert symbols: “
“ WARNING”, “ CAUTION”.
Keep this manual for future reference and to educate new users of this
product. This manual should be read in conjunction with the labeling on
the product.
Safety precautions are essential when any mechanical or propane
fueled equipment is involved. These precautions are necessary when
using, storing, transporting, and servicing. Using this equipment with
the respect and caution demanded will reduce the possibilities of death,
personal injury or property damage.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the appliance
and immediately call your gas supplier or your
fire department.
Failure to follow these instructions could result
in fire or explosion which could cause property
damage, personal injury or death.
The following symbols shown next are used extensively throughout this
manual. Always heed these precautions, as they are essential when
using any mechanical or fueled equipment.
-1-
DANGER
1. Never operate this appliance unattended. Keep
children and pets away from the appliance at
all times.
2. Never operate this appliance within 10 feet
(3.05 m) of any other gas cylinder.
3. Never operate this appliance within 25 feet
(7.5 m) of any flammable liquid.
4. Heated liquids remain at scalding temperatures
long after the cooking process. Never touch
cooking appliance until liquids have cooled to
115°F (45°C) or less.
5. If a fire should occur, keep away from the
appliance and immediately call your fire
department. Do not attempt to extinguish an oil
or grease fire with water.
Failure to follow these instructions could result in
fire, explosion or burn hazard, which could cause
property damage, personal injury or death.
Only persons who can understand and follow the instructions should use
or service this outdoor grill.
If you need assistance or outdoor grill information such as an instruction
manual or labels, visit www.margaritavillecargo.com.
DANGER
carbon monoxide hazard
• This appliance can produce carbon monoxide
which has no odor.
• Using it in an enclosed space can kill you.
• Never use this appliance in an enclosed space
such as a camper, tent, car or home.
• For outdoor use only.
-2-
CAUTION
• The use of alcohol, prescription or non-prescription drugs may impair your
ability to properly assemble or safely operate the appliance.
• When cooking with oil or grease, always have a Type BC or ABC fire
extinguisher readily available. In the event of an oil or grease fire, do not
attempt to extinguish with water. Immediately call the fire department.
A Type BC or ABC fire extinguisher may, in some circumstances, contain
the fire.
• When cooking, the appliance must be on a level, stable surface in an area
clear of combustible material. An asphalt surface (blacktop) may not be
acceptable for this purpose.
• Do not leave the appliance unattended. Keep children and pets away from
the appliance at all times.
• Do not move the appliance when in use.
• This appliance is not intended for and should never be used as a heater.
DANGER
EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open flames, pilot lights, direct sunlight,
other ignition sources or where temperatures exceed 120 degrees F (49°C).
• Propane gas is heavier than air and leaking propane will sink to the lowest
level possible. It can ignite by ignition sources including matches, lighters,
sparks or open flames of any kind many feet away from the original leak. If
you smell gas, leave the area immediately.
• Never install or remove propane tank while outdoor grill is lighted, near
flame, pilot lights, other ignition sources or while outdoor grill is hot to
touch.
• During operation, this product can be a source of ignition. Never use the
grill in or near areas that contain or may contain volatile or airborne
combustibles, or products such as gasoline, solvents, paint thinner, dust
particles or unknown chemicals. Minimum distance from sides and back of
unit to walls or railings is 12 inches (30.5 cm). Do not use under overhead
unprotected combustible construction.
• Provide adequate clearances around air openings into the combustion
chamber.
• DO NOT use gas grill indoors or in garages, breezeways, sheds, enclosed
areas or a covered porch or patio.
• Do not obstruct the flow of combustion and ventilation air.
• DO NOT put grill in storage or travel mode immediately after use. Allow grill
to cool to touch before moving or storing. Failure to do so could result in fire
resulting in property damage, personal injury, or death.
WARNING
We cannot foresee every use which may be made of our products. Check with
your local fire safety authority if you have questions about use.
Other standards govern the use of fuel gases and heat producing products for
specific uses.Your local authorities can advise you about these.
• Never refill disposable cylinders.
• Use the preset regulator that came with the grill. Do not attempt to adjust.
• The installation and use must conform with local codes or, in absence
of local codes, with the National Fuel Gas Code, ANSI Z223.1/NFPA 54,
Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58 or
CSA B149.1, Natural Gas and Propane Installation Code.
• This appliance is not intended to be installed in or on boats.
• Propane gas should be stored or used in compliance with local ordinances and
codes or with ANSI/NFPA 58 and with the American Boat and Yacht Council
(ABYC) Standards A-1 (9), Marine Liquefied Petroleum gas (LPG) Systems.
• Turn off propane and disconnect cylinder when not in use.
• Cylinders must be stored out of reach of children.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and byproducts of combustion of this fuel, contain
chemicals known to the state of California to cause cancer, birth defects or
other reproductive harm.
WARNING
BURN hazard
• This appliance is not intended for commercial use.
• Never leave grill unattended when hot or in use.
• DO NOT use this appliance under extended awnings. Failure to comply
could result in a fire or personal injury.
• Keep out of reach of children.
DANGER
carbon monoxide hazard
• For outdoor use only.
• Never use inside house, camper, tent, vehicle or other unventilated
or enclosed areas. This grill consumes air (oxygen) and produces
carbon monoxide. Do not use in unventilated or enclosed areas to avoid
endangering your life.
• This grill is a combustion appliance. All combustion appliances produce
carbon monoxide (CO) during the combustion process. Do not block air flow
into or out of the grill.
• Carbon Monoxide (CO) poisoning produces flu-like symptoms, watery eyes,
headaches, dizziness, fatigue and possibly death. You can’t see it and you
can’t smell it. It’s an invisible killer. If these symptoms are present during
operation of this product get fresh air immediately!
WARNING
• This product is fueled by propane gas. Propane gas is invisible, odorless,
and flammable. An odorant is normally added to help detect leaks and can
be described as a ”rotten egg” smell. The odorant can fade over time so
leaking gas is not always detectable by smell alone.
• Use only propane gas set up for vapor withdrawal.
CAUTION
SERVICE SAFETY
• Keep all connections and fittings clean. Inspect propane cylinder and grill
propane connections for damage before attaching.
• During set up, check all connections and fittings for leaks using soapy water.
Never use a flame. Bubbles indicate a leak. Check that the connection is not
cross-threaded and that it is tight. Perform another leak check. If there is
still a leak, remove the cylinder and contact Jarden Consumer Solutions for
service or repairs.
• Use as a cooking appliance only. Never alter in any way or use with any
device or part not expressly approved by Jarden Consumer Solutions.
• Clean grill frequently to avoid grease accumulation and possible grease fires.
• Only use the pressure regulator and hose assembly provided with the unit.
Replacement pressure regulators and hose assemblies must be those
specified by by Jarden Consumer Solutions (see replacement parts /
accessories)
Portable L.P. (Propane) Gas Barbecue Cylinders
Liquefied Petroleum Gas (abbreviated L.P. gas or propane) is highly flammable.
It becomes liquid when stored under high pressure inside a cylinder and
vaporizes when released. L.P. gas is heavier than air and tends to collect in low
areas. It is important that there are no leaking connections on your gas grill
that could cause a fire or explosion (see the section titled “LEAK CHECK”).
-3-
A S S E M B LY
Install legs using the 6 provided
screws and a Phillips Head
Screwdriver.
Snap Grease
Vaporizer into
the 4 mounting
clips.
Battery Installation: Remove
battery (AAA) from shipping
packet and install in battery
compartment. The battery
compartment is located behind
the electronic igniter push button
on the control panel. Rotate the
push button counter-clockwise to
expose the battery compartment.
When replacing the battery
be sure to attach positive and
negative ends correctly. Check
the igniter by pressing the
button. You should hear a
“clicking spark”
sound.
-4-
Operating INSTRUCTIONS
C O O K I N G – TA B L E TO P
Fold down the condiment holder
to expose the electronic igniter
and burner control knob. Make
sure that the burner control
knob is in the OFF position.
Fold out the propane
cylinder hook on the
right side of the grill.
Unlatch the hood latch and
open the grill hood.
Attach a 1 lb. propane
cylinder. See the instructions
listed in this manual under
“Attaching the Propane
Cylinder”.
DO NOT
OVERTIGHTEN
THE PROPANE
CYLINDER.
MAKE SURE
THAT YOU DO
NOT CROSS
THREAD THE
CONNECTION.
Fold out both side tables,
slide drip pan into holder on
the underside of the grill.
To light the grill:
Refer to the Lighting instructions in this owner’s manual
and printed on the control panel of your grill. Never light
the grill without first folding out the side tables.
To preheat the grill:
Light the grill according to the lighting instructions in this
owner’s manual. Close the lid and turn the burner control
knob to Start/Hi. Preheat the grill for 5-10 minutes
(depending on conditions such as air temperature and
wind). Once the grill is preheated, set the burner control
knob to the setting specified in the recipe.
Note: Wind and weather may require adjustment of
the burner control knob to obtain the correct cooking
temperature. If the burner goes out during cooking, open
the lid, turn off the burner, and wait five minutes before
relighting.
Drippings and grease: Excess drippings and grease
will collect in the disposable drip pan. (Located on the
underside of the grill). Use a new pan before each use
and dispose of used pans properly.
WARNINGS
Check the drip pan and the bottom of the grill for
grease build-up before each use. Remove excess
grease to avoid a fire in the bottom of the grill.
Do not move the grill when operating or while the
grill is hot.
Wait for the grill to cool before folding up the
fold-out side tables.
Wait for the grill to cool before closing the
arm assembly.
Grill Performance:
The burners are located toward the back of the grill. For
indirect heat to keep food warm or cook slower, move
food toward the front of the grill.
Attaching the P ropane
C ylinder
Use 1 lb. propane cylinders. Use propane cylinders that
are approximately 4 inches in diameter and 8 inches
in length. The propane cylinder must fit through the
cylinder hook.
Note: Your new grill is designed to be operated with 16.4
oz. disposable propane gas cylinders. The L.P. gas supply
cylinder to be used must be constructed and marked in
accordance with the specifications for L.P. gas cylinders of
the U.S. Department of Transportation (DOT) or the National
Standard of Canada. CAN/CSA B339, Cylinders, Spheres
and Tubes for the Transportation of Dangerous Goods.
CAUTION: Use cylinders that are marked
“Propane Fuel” only. Prior to installing the cylinder,
check to make sure its fitting is not damaged or bent.
If the propane cylinder is damaged, DO NOT install it
on your grill.
Check for gas leaks:
When installing the cylinder, be sure that it screws in
securely in a smooth and straight manner.
DO NOT CROSS THREAD.
The propane cylinder must be removed prior to storing
or transporting your grill. Do not carry or drive with the
cylinder attached.
5) Note: All factory-made connections have been
thoroughly checked for gas leaks. The burners have
been flame tested.
Push control knob in and turn counterclockwise to START/HI. (Figure below).
6) Push the electronic igniter button (you should hear
a clicking sound). Burner should ignite.
7) Check that the burner is lit by looking down
through the cooking grate. You should see a flame.
Perform these leak checks even though your grill has
been pre-assembled.
Do not ignite burner while checking for leaks.
Check connections:
1) WARNING: Do not use a wrench to tighten the
connection. Using a wrench could damage the
regulator coupling and could cause a leak.
WARNING: CHECK FOR GAS LEAKS BY
WETTING THE CONNECTIONS WITH A SOAP
AND WATER SOLUTION AND WATCHING
FOR BUBBLES. IF BUBBLES FORM OR IF A
BUBBLE GROWS, THERE IS A LEAK.
WARNINGS
You should check for gas leaks every time you
disconnect and reconnect a gas fitting.
As a safety precaution check all fittings for leaks before
using your Grill. Shipping and handling may have
loosened or damaged a gas fitting.
Slide propane cylinder through cylinder hook, (Figure
below). While holding carrying handle closest to propane
cylinder with one hand, push propane cylinder into
regulator and turn clockwise until tight.
Regulator to propane cylinder connection.
WARNING: If there is a leak at connection, remove
propane cylinder. Do not operate grill. Use a different
propane cylinder and recheck for leaks with soap and
water solution. If a leak persists after retightening the
propane cylinder, turn OFF the gas.
DO NOT OPERATE THE GRILL.
2) WARNING: Do not lean over the open grill. Keep your
face and body at least one foot away from the grate
when lighting the grill.
WARNING: If the burner does not light, turn the burner
control knob to OFF and wait 5 minutes to let the gas
clear before you try again or try to light with a match.
WARNING: DO NOT LEAN OVER THE OPEN
GRILL. KEEP YOUR FACE AND BODY AT
LEAST ONE FOOT AWAY FROM THE GRATE
WHEN LIGHTING THE GRILL.
Valve-to-regulator connections.
WARNINGS
If there is a leak at the valve-to-regulator connection
turn OFF the gas. DO NOT OPERATE THE GRILL.
NOTE: ALL CONNECTIONS SHOULD BE
RINSED WITH CLEAN WATER AFTER
CHECKING FOR LEAKS.
When leak checks are complete, turn gas supply OFF at
the source and rinse connections with water.
DANGER Do not use an open flame to check for gas
leaks.
DANGER Be sure there are no sparks or open flames
in the area while you check for leaks. Sparks or flames
may result in a fire or explosion, which can cause
serious bodily injury or death, and damage to property.
DANGER Do not store a spare L.P. gas cylinder under or
near this appliance. 1 lb. cylinders are not refillable. If
the instructions are not followed exactly, a fire causing
death or serious injury may occur.
LIGHTING
A summary of the lighting instructions is printed on the
control panel.
1) Fold down the condiment holder to expose the
burner control knob and electronic igniter button.
To Extinguish:
2) Make sure the burner control knob is turned OFF.
(Push control knob in and turn clockwise to ensure
that it is in the OFF position.)
Push in and turn burner control knob clockwise to the
OFF position.
3) Open the lid.
4) Unfold the side tables.
Remove propane cylinder after use and before
transporting.
CAUTION: Do not fold in side tables until grill is cold.
-5-
Manual Lighting:
DANGER Failure to open the lid while igniting the
grill’s burner, or not waiting 5 minutes to allow the
gas to clear if the grill does not light, may result in an
explosive flame-up, which can cause serious bodily
injury or death.
1) Fold down condiment holder to expose burner
control knob.
2) Open the lid.
3) Unfold the side tables.
4) Make sure the burner control knob is turned OFF.
5) Strike a match and put the flame into the
matchlight hole on the right side of the lower
grill basin.
6) Push burner control knob in and turn to START/HI.
7) Check that the burner is lit by looking down
through the cooking grate. You should see a flame.
To Properly Remove the
Gas Cylinder for Cleaning,
Transport, or Storage:
1)
Make sure the burner knob is turned OFF. Push
control knob in and turn clockwise to ensure that
it is in the OFF position.
2)
While holding the handle closest to the propane
cylinder with one hand, turn cylinder counterclockwise until removed.
A nnual M aintenance
After a period of nonuse, we recommend that you
perform the following maintenance procedures for your
safety. Inspect and clean the burner tube. Inspect the
burner for correct flame pattern. Clean if necessary,
following the procedures outlined in the “General
Maintenance” section of this manual. Check all gas
fittings for leaks following the instructions listed in this
manual under “Check for gas Leaks”.
Inspection and cleaning of
Burner Tube:
Your grill, as well as any outdoor gas appliance, is a target
for spiders and other insects. They can nest in the venturi
section of the burner tube. This blocks the normal gas flow,
and can cause the gas to flow back out of the air shutter.
This could result in a fire in and around the air shutter,
causing serious damage to your grill.
WARNING: If the burner does not light, turn the burner
control knob to OFF and wait 5 minutes to let the gas
clear before you try attempting to re-light.
WARNING: DO NOT LEAN OVER THE OPEN
GRILL. KEEP YOUR FACE AND BODY AT
LEAST ONE FOOT AWAY FROM
THE GRATE WHEN LIGHTING
THE GRILL.
Venturi Section
C leaning
WARNING: Turn your grill OFF and wait for it to cool
before cleaning.
For availability of replacement cooking grate go to
margaritavillecargo.com or call Margaritaville® Cargo
directly at 1-877-689-2737.
Outside surfaces: Use a warm soapy water solution to
clean, then rinse with water.
Cooking grate: Clean with a soft brass bristle brush. As
needed, remove from grill and wash with warm soapy
water then rinse with water.
Drip pan: A disposable drip pan is included with the
grill. Foil pot pie pans (4 3/8”) are available at most
grocery stores or replacements can be ordered at
margaritavillecargo.com or call 1-877-689-2737. To clean
the tray, wash with warm soapy water, then rinse.
Inside grill basin: Wash inside of grill basin with warm
soapy water and a water rinse.
Inside Lid: While lid is warm, wipe inside with paper
towel to prevent grease build-up.
Fold out side tables: Wash with a soft cloth and a soap
and water solution. Do not use cleaners that contain acid
or mineral spirits. Rinse well after cleaning.
Fold out side tables are not to be used as cutting boards.
-6-
To inspect the burner tube, look up from directly
below the burner control knob. If there is dust or dirt
in the tube, remove the burner tube for cleaning.
CAUTION: Do not clean the burner tube with
hard or sharp tools.
Lightly tap the burner tube to get debris and dirt out.
Once burner tube is clean replace it in the grill. If the
burner tube becomes damaged or cannot be cleaned,
visit www.margaritavillecargo.com or call
1-877-689-2737 for replacement parts.
1) The smell of gas in conjunction with the burner
flames appearing yellow and lazy.
2) Grill does not reach temperature.
3) Grill heats unevenly.
4) Burner does not ignite.
DANGER Failure to correct the above mentioned
symptoms may result in a fire, which can cause
serious bodily injury or death, and cause damage to
property.
Main Burner Flame Pattern:
The grill’s burner has been factory set for the correct air
and gas mixture. The correct flame pattern is shown:
Removing Burner Tube:
1) Your grill must be OFF and cool.
2) Tips occasionally
flicker yellow
Unscrew and remove propane cylinder from the
valve/regulator assembly.
3) Open the lid.
Light blue
4) Remove cooking grate.
5) Remove the drip vaporizer.
6) Unscrew and remove the (3) 1/4” screws that hold
the burner tube inside grill basin.
7) Carefully slide the burner tube out from the grill
basin.
8) To reinstall the burner, reverse the above steps.
Check proper assembly before fastening burner
tube in place.
Dark blue
If the flames do not appear to be uniform throughout the
burner tube, follow the instructions listed in this manual
under “Main Burner Cleaning Procedure”.
Air Mixture Adjustment:
The air mixer sleeve for the burner has been pre-set at
the factory for gas conditions at sea level. However, if
the burner flame is too yellow (this may occur at higher
altitudes) open the air mix sleeve slightly until the flame
turns blue.
S t o r a g e , Tr a n s p o r t a n d /
or Non-use
When the grill is not in use or is being transported,
the propane cylinder must be DISCONNECTED and the
propane cylinder stored in a well-ventilated space.
DO NOT DRIVE WITH THE CYLINDER ATTACHED!
The grill should be checked for gas leaks and any
obstructions in the burner tubes before using.
(See Sections: “General Maintenance and Annual
Maintenance.”) The burner tube should also be
checked for any obstructions. (See Section: “Annual
Maintenance.”)
If grill is to be stored for a long time, remove battery
from electronic igniter.
DANGER EXPLOSION - FIRE HAZARD
CAUTION: The burner opening must be positioned properly over the valve orifice.
Ignition System Operations:
This appliance has an electronic igniter that uses a
triple A battery (AAA – V.), (battery should be checked
periodically). The grill can also be lit using a match, via
the flame view window. Follow the lighting instructions
exactly when lighting the grill.
Never store propane near high heat, open flames, pilot
lights, direct sunlight, other ignition sources or where
temperatures exceed 120 degrees F (49°C).
The cylinder must be disconnected when the grill is in
storage.
Do not store a spare L.P. gas cylinder under or near
this appliance. Failure to follow the above instructions
exactly may result in fire causing death or serious
injury.
Battery Check:
GENERAL MAINTENANCE
Main Burner Cleaning Procedure:
Turn off the gas supply. Remove the burner. (See below)
Look inside the burner with a flashlight. Clean the inside
of the burner with a wire. (A straightened-out coat
hanger will work)
Check and clean the opening at the end of the burner.
Check and clean the valve orifice at the base of the valve.
Use a Steel bristle brush to clean outside of burner. This
is to make sure all the burner ports are fully open.
The battery compartment is located behind the
electronic igniter push button on the
control panel. Rotate the push button
counter-clockwise to expose the
battery compartment. When
replacing the battery be sure
to attach positive and
negative ends correctly.
Check the igniter by
pressing the button.
You should hear a
“clicking spark”
sound.
CAUTION: Do not enlarge the burner ports when
cleaning.
-7-
PA R T S C A L LO U T L I S T - L G 1 0 0 0 & L G 1 9 0 0 S e r i e s
A C C E S S O R I E S ( S o l d S e p a r a t e ly )
- LG 1 0 0 0 & LG 1 9 0 0 S e r i e s
Top grate
Grill Cover
grill
S.
7.
Grease
vaporizer
NLY.
Temperature gauge
(incorporated into
grill hood)
Grill head:
Side handles
Rain/
Windshield
Side tables
0
e,
Grill Hood
Burner tube
e
Condiment
holder
Propane
cylinder hook
Leg
assembly:
Leg assembly screws
and washers
Drip pan
Collar knob
Temporary license
plate bracket
Padlock tab
Swing away arm
assembly:
Slam-latch
Hinge spring lock
-8-
Electronic igniter
button and Burner
control knob
Cap A swing arm
Cap B
swing
arm
REPLACEMENT PARTS LIST
Description
Part #
Instruction Manual
134912
Top Cooking Grate
134891
Grease Vaporizer
134893
Grill Hood
134910
Temperature Gauge Set
134894
Rain/Wind Shield
134895
Side Shelf/Table (2)
134902
Side Handle Assembly (2)
134903
SS Burner Tube Assembly
134897
Condiment Holder
134904
Electronic Igniter Electrode Set
134892
Burner Control Knob
134898
Propane Cylinder Hook
134899
Hitch Pin Lock
20# Tank SS Braided
Adapter Hose
Grill Legs (2)
134906
Drip Pan
134896
Collar Knob
134900
Stabilizer Bolt and Cotter Pin
134907
License Plate Bracket Assembly
134901
Plastic End Cap - A Swing Arm
134908
Grill Cover
Plastic End Cap - B Support Arm
134909
Hitch Pin Lock
Swing Away Arm Assembly
136562
20# Tank SS Braided Adapter Hose
Description
To order replacement parts or accessories, visit
www.margaritavillecargo.com
Part #
134905
26130
100714-A00
T roubleshooting
3 Year Limited Warranty
PROBLEM OBSERVED
POSSIBLE CAUSE
CORRECTIVE MEASURE
• Gas odor during set up.
• Gas leak.
• Refer back to Page 1 “DANGER If you
smell gas”. Check all gas connections.
• Gas odor before first ignition.
• Gas leak.
• Refer back to Page 1 “DANGER If you
smell gas”. Check all gas connections.
• When ignition button is pressed,
there is no spark at burner electrode.
• Battery dead or missing.
• Igniter electrode or switch wires
not connected or damaged.
• Broken electrode or switch wires.
• Electrode positioned improperly.
• Faulty electronic igniter.
• Electronic ignition is wet.
• Replace battery.
• Reconnect or replace
electrode wires.
• Replace broken electrode or wires.
• Reposition electrode - 3/16” clearance.
• Replace electronic igniter.
• Keep ignition system dry.
• When igniter button is pressed,
there is spark at the electrode,
but no ignition.
• Gas supply not turned on.
• Burner control knob not in
HIGH ON position.
• Air in gas lines not fully bled from system.
• Low gas pressure.
• Faulty Regulator.
• Electrode positioned improperly.
• Turn on gas supply.
• Follow Operational
Instructions.
• Bleed air from system.
• Check gas supply pressure.
• Replace regulator.
• Reposition electrode - 3/16” clearance.
• Delayed ignition.
• Low gas pressure.
• Clogged or dirty burner ports.
• Blocked orifice.
• Faulty valve.
• Check gas supply pressure.
• Clean burner ports - see manual section.
• Check orifice opening.
• Replace valve.
• Burner lights but does not stay lit.
• Out of gas.
• Low gas pressure.
• Faulty valve.
• Clogged or dirty burner ports.
• Faulty regulator.
• Windy conditions.
• Replace propane cylinder.
• Check gas supply pressure.
• If using the hose adaptor, refer to
lighting instructions enclosed with
the hose adaptor.
• Replace valve.
• Clean burner ports - see manual section.
• Replace regulator.
• Shield from wind.
• Out of gas.
• Incorrect gas supply or pressure.
• Incorrect primary air mix.
• Blocked orifice.
• Clogged or dirty burner ports.
• Faulty valve.
• Faulty regulator.
• High altitude.
• Replace propane cylinder.
• Check gas supply pressure.
• Adjust air mixer - see manual section.
• Check orifice opening.
• Clean burner ports - see manual section.
• Replace valve.
• Replace regulator.
• Adjust orifice size for altitude.
• Blocked orifice.
• Clogged or dirty burner ports.
• Incorrect primary air mix.
• Check orifice opening.
• Clean burner ports - see manual section.
• Adjust air mixer - see manual section.
• Incorrect burner flame.
• Backfire of burner.
Sunbeam Products, Inc., doing business as Jarden Consumer
Solutions or if in Canada, Sunbeam Corporation (Canada) Limited
doing business as Jarden Consumer Solutions (collectively “Jarden
Consumer Solutions”) warrants that for a period of three years
from the date of purchase, this product will be free from defects
in material and workmanship. Jarden Consumer Solutions, at
its option, will repair or replace this product or any component
of the product found to be defective during the warranty period.
Replacement will be made with a new or remanufactured product or
component. If the product is no longer available, replacement may
be made with a similar product of equal or greater value. This is your
exclusive warranty.
This warranty is valid for the original retail purchaser from the date
of initial retail purchase and is not transferable. Keep the original
sales receipt. Proof of purchase is required to obtain warranty
performance. Jarden Consumer Solutions dealers, service centers,
or retail stores selling Jarden Consumer Solutions products do not
have the right to alter, modify or in any way change the terms and
conditions of this warranty.
This warranty does not cover normal wear of parts or damage
resulting from any of the following: negligent use or misuse of
the product, road hazards, exposure to the elements and weather,
use contrary to the operating instructions, disassembly, repair or
alteration by anyone other than Jarden Consumer Solutions or an
authorized Jarden Consumer Solutions service center. Further, the
warranty does not cover: Acts of God, such as fire, flood, hurricanes
and tornadoes.
What are the Limits on Jarden Consumer Solutions’ Liability?
Jarden Consumer Solutions shall not be liable for any incidental or
consequential damages caused by the breach of any express, implied
or statutory warranty or condition.
Except to the extent prohibited by applicable law, any implied
warranty or condition of merchantability or fitness for a particular
purpose is limited in duration to the duration of the above warranty.
Jarden Consumer Solutions disclaims all other warranties,
conditions or representations, express, implied, statutory or
otherwise.
Jarden Consumer Solutions shall not be liable for any damages of
any kind resulting from the purchase, use or misuse of, or inability
to use the product including incidental, special, consequential or
similar damages or loss of profits, or for any breach of contract,
fundamental or otherwise, or for any claim brought against
purchaser by any other party.
Some provinces, states or jurisdictions do not allow the exclusion
or limitation of incidental or consequential damages or limitations
on how long an implied warranty lasts, so the above limitations or
exclusions may not apply to you.
This warranty gives you specific legal rights, and you may also have
other rights that vary from province to province, state to state or
jurisdiction to jurisdiction.
How to Obtain Warranty Service
If you have any question regarding this warranty or would like
to obtain warranty service, please call 1-877-689-2737 and a
convenient service center address will be provided to you.
In the U.S.A., this warranty is offered by Sunbeam Products, Inc.,
doing business as Jarden Consumer Solutions, located in Boca
Raton, Florida 33431.
PLEASE DO NOT RETURN THIS PRODUCT TO ANY OF THESE
ADDRESSES OR TO THE PLACE OF PURCHASE.
134912 Rev SUB
-9-
DO NOT RETURN THIS PRODUCT TO THE PLACE OF PURCHASE
For product questions:
Jarden Consumer Services U.S.A.
1-877-689-2737
www.margaritavillecargo.com
© 2009 Sunbeam Products, Inc. doing business as Jarden Consumer Solutions.
All rights reserved. Distributed by Sunbeam Products, Inc. doing business as
Jarden Consumer Solutions, Boca Raton, Florida 33431
Margaritaville® is a registered trademark of Margaritaville®.
Printed in China
CSDW 060509
134912 Rev SUB
Download PDF