SMART SHOCK

SMART SHOCK
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
The recipient of this Safety Data Sheet is urged to study it carefully to become aware of hazards, if any, of the product involved. In the
interest of safety you should (1) notify your employees, agents and contractors of the information on this sheet,(2) furnish a copy to each of
your customers for the product, and (3) request your customers to inform their employees and customers as well.
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Product name:
BioGuard® Mainatin Smart Shock®
Product Use Description:
Recreational Water Product
EPA Registration Number:
5185-493
Company:
Bio-Lab, Inc.
BioGuard
P.O. Box 300002
Lawrenceville, GA
30049-1002
Emergency telephone:
CHEMTREC (US Transportation) :
(800) 424-9300
(703) 527-3887
Poison Control Center (Medical) :
(877) 800-5553
Customer Service:
(800) 859-7946
Prepared by:
Product Safety Department
(US) +1 866-430-2775
(EU) +44 (0) 1753.603.000
Email: [email protected]
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
DANGER!
Corrosive
Oxidizer
Causes severe eye damage.
Causes skin burns.
Causes respiratory tract irritation.
Harmful if absorbed through skin.
May be fatal if swallowed.
MSDS Number: BIOG_4500121
Form:
granules
Colour:
blue green to blue
Odour:
Chlorine
OSHA Hazards:
THIS MATERIAL IS HAZARDOUS UNDER THE
CRITERIA OF THE FEDERAL OSHA HAZARD
COMMUNICATION STANDARD 29CFR 1910.1200.
1 of 12
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
Avoid breathing dust or vapor.
Do not get in eyes, on skin, or on clothing.
Potential Health Effects
Primary Routes of Entry
:
Inhalation
Eye contact
Skin contact
Ingestion
Inhalation
:
Causes respiratory tract irritation.
Skin
:
Harmful if absorbed through skin.
Causes skin irritation.
On contact with moisture, this material readily hydrolyzes to acid which may
result in burns if not promptly removed.
May cause allergic skin reaction.
Eyes
:
Causes severe eye damage.
Ingestion
:
May be fatal if swallowed.
Chronic Exposure
:
This product contains a boron compound. This boron compound when fed to
test animals at very high doses, has shown reproductive and developmental
toxicity. When this product is used according to label directions, the boron
compound in this product does not represent a practical risk to man.
SECTION 3.COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
Component
CAS-No.
Concentration
Sodium dichloro-s-triazinetrione
Inorganic salt
Trade Secret 001
Trade Secret 016
Proprietary additive 123
COPPER CITRATE
2893-78-9
63.05 %
< 25 %
< 10 %
<5%
<5%
<1%
10402-15-0
Note: Available Chlorine: 39%., Copper derived from copper citrate.
SECTION 4. FIRST AID MEASURES
First aid procedures
Inhalation
MSDS Number: BIOG_4500121
:
Remove to fresh air.
If person is not breathing, call 911 or an ambulance, then give artificial
2 of 12
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
respiration, preferably mouth-to-mouth, if possible.
Call a POISON CENTRE or doctor/physician.
Skin contact
:
Remove contaminated clothing and shoes.
Rinse immediately with plenty of water for at least 15 minutes.
Call a POISON CENTRE or doctor/physician.
Eye contact
:
Rinse immediately with plenty of water, also under the eyelids, for at least 15
minutes.
Remove contact lenses, if present, after 5 minutes, then continue rinsing eye.
Call a POISON CENTRE or doctor/physician.
Ingestion
:
Call a physician or poison control centre immediately.
Have person sip a glass of water if able to swallow.
Do not induce vomiting unless told to do so by the poison control center or
doctor.
Do not give anything by mouth to an unconscious person.
:
Probable mucosal damage may contraindicate the use of gastric lavage.
Notes to physician
Treatment
SECTION 5. FIRE-FIGHTING MEASURES
Flammable properties
Flash point
:
not applicable
Protective equipment and precautions for firefighters
Suitable extinguishing media
:
Flood with large volumes of water.
Unsuitable extinguishing
media
:
ABC powder
Dry powder
Risk of violent reaction.
Hazardous decomposition
products
Hazardous combustion
products
:
Chlorine containing gases can be produced.
Further information
:
Do not let fire burn.
Specific hazards during fire
fighting
:
Under extreme heat (greater than 400F), this product will evolve noxious chlorine
containing gases.
Special protective equipment
for fire-fighters
:
In the event of fire, wear self-contained breathing apparatus.
Thoroughly decontaminate fire fighting equipment including all fire fighting wearing
apparel after the incident.
Chlorine containing gases can be produced.
Further information
MSDS Number: BIOG_4500121
3 of 12
BioGuard® Mainatin Smart Shock®
NFPA Classification
:
Health Hazard: 3
Fire Hazard: 0
Reactivity Hazard: 1
Specific hazards: OX Class
1 Oxidizer.
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
0
3
1
OX
Additional advice : Nitrogen trichloride can be generated slowly by the reaction of small quantities of water with a high
concentration of this product. Nitrogen trichloride can present an explosion hazard. Immediately after a fire has been
extinguished, check for wet or damp material. Any spilled material from burned or broken containers should be assumed
contaminated. Neutralize to a non-oxidizing material for safe disposal. Do not attempt to re-close broken containers, even
for movement to the disposal area. They should be left open to disperse any nitrogen trichloride that may form. Material
which appears undamaged except for being damp on the outside, should be opened and inspected immediately. If the
plastic liner (where applicable) of the container is damaged or the material is damp, the material should be chemically
treated if allowable, to a non-oxidizing material for safe disposal. Bulging containers require extreme care. Contact the fire
department.
SECTION 6. ACCIDENTAL RELEASE MEASURES
Environmental precautions
:
Do not flush into surface water or sanitary sewer system.
Methods for containment /
Methods for cleaning up
:
Clean-up methods - small spillage
In case of spills, scoop up and place product in pool or spa water, then flood
spilled area with large volumes of water.
Clean-up methods - large spillage
Using appropriate protective clothing and safety equipment, contain spilled
material.
Do not add water to spilled material.
Using clean dedicated equipment, sweep and scoop all spilled material,
contaminated soil, and other contaminated material and place into clean dry
containers for disposal.
Do not close containers containing wet or damp material. They should be left
open to disperse any hazardous gases that may form.
Additional advice
:
Do not use floor sweeping compounds to clean up spills.
Do not transport wet or damp material.
Treat recovered material as described in the section "Disposal considerations".
Do not contaminate water, food or feed by storage or disposal or cleaning of
equipment.
SECTION 7. HANDLING AND STORAGE
Handling
Advice on safe handling
MSDS Number: BIOG_4500121
:
Avoid contact with skin, eyes and clothing.
Avoid breathing dust.
Avoid breathing vapors.
Avoid creating dust.
Do not mix with other chemicals.
Mix only with water.
4 of 12
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
Never add water to this product.
Contamination with moisture, organic matter or other chemicals may start a
chemical reaction and generate heat, hazardous gas, possible fire and
explosion.
Do not add this product to any dispensing devices containing remnants of any
other product. Such use may cause a violent reaction leading to fire or
explosion.
In case of contamination or decomposition, do not reseal container.
If possible, isolate container in open air or well ventilated area.
Always add product to large quantities of water.
Flood with large volumes of water.
Wash hands thoroughly with soap and water after handling and before eating,
drinking or using tobacco.
Do not handle until all safety precautions have been read and understood.
Storage
Requirements for storage
areas and containers
:
Keep this product dry in its original container.
Keep containers tightly closed in a dry, cool and well-ventilated place.
For bags: Store dry product in its original unopened bag until use. For partially
used bags, fold over top of bag and secure with adhesive tape.
For bottles: Store dry product in orginal tightly closed container when not in
use.
Keep out of reach of children.
Keep away from animals.
SECTION 8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Exposure Guidelines
Components with workplace control parameters
Components / CAS-No.
Value - Basis Update
Control
parameters
Further information
Inorganic salt
TWA ; ACGIH
1996-05-18
0.1 mg/m3
1996 Adoption
Exposure Guidelines
Components with workplace control parameters
Components / CAS-No.
Value - Basis Update
Control
parameters
Trade Secret 016
TWA ; OSHA PO
1989-03-01
10 mg/m3
Trade Secret 016
TWA ; ACGIH
2005-01-01
2 mg/m3
Trade Secret 016
STEL ; ACGIH
2005-01-01
6 mg/m3
Further information
A4: The agent (mixture, or exposure circumstance) is not
classifiable as to its carcinogenicity to humans.
Inhalable fraction. See Appendix C, paragraph A. Inhalable
Particulate Mass TLVs (IPM-TLVs) for those materials that are
hazardous when deposited anywhere in the respiratory tract.
A4: The agent (mixture, or exposure circumstance) is not
classifiable as to its carcinogenicity to humans.
Inhalable fraction. See Appendix C, paragraph A. Inhalable
Particulate Mass TLVs (IPM-TLVs) for those materials that are
hazardous when deposited anywhere in the respiratory tract.
Exposure Guidelines
Components with workplace control parameters
MSDS Number: BIOG_4500121
5 of 12
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
Components / CAS-No.
Value - Basis Update
Control
parameters
Further information
Trade Secret 001
TWA ; OSHA PO
1989-03-01
2 mg/m3
Calculated as Al
Trade Secret 001
TWA ; ACGIH
1994-09-01
2 mg/m3
Calculated as Alsoluble
Engineering measures
Engineering measures
:
Use with adequate ventilation.
Ensure that eyewash stations and safety showers are close to the workstation
location.
Personal protective equipment
Eye protection
:
Safety glasses with side-shields
Hand protection
:
Wear rubber gloves.
Respiratory protection
:
No personal respiratory protective equipment normally required.
If product is used in an area with poor ventilation and mist or vapor is expected, a
respirator that meets OSHA/ANSI standards may be required.
Hygiene measures
:
Wash contaminated clothing before reuse.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Form
:
granules
Colour
:
blue green
to
blue
Odour
:
Chlorine
Flash point
:
not applicable
pH
:
4.6 - 4.8
1% Solution
Melting point/range
:
522 °F (272 °C)
Decomposes
Boiling point/boiling range
:
not applicable
Vapour pressure
:
Not Available
Safety data
MSDS Number: BIOG_4500121
6 of 12
BioGuard® Mainatin Smart Shock®
Density
:
1.02 - 1.04 g/cm3
Water solubility
:
250 g/l
Relative vapour density
:
Not Available
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
SECTION 10. STABILITY AND REACTIVITY
Conditions to avoid
:
Moisture/high humidity.
Poor ventilation.
High temperatures.
Contamination
Materials to avoid
:
Avoid contact with water on concentrated material in the container. Avoid
contact with easily oxidizable material; ammonia, urea, or similar nitrogen
containing compounds; inorganic reducing compounds; floor sweeping
compounds; calcium hypochlorite; other swimming pool/spa chemicals in their
concentrated form; alkalis. Avoid contact with all other chemicals.
Hazardous decomposition
products
:
Type: Hazardous decomposition products
Chlorine containing gases can be produced.
Type: Hazardous combustion products
Chlorine containing gases can be produced.
Hazardous reactions
:
Hazardous polymerisation does not occur.
SECTION 11. TOXICOLOGICAL INFORMATION
Acute oral toxicity
:
LD50 rat
Dose: 497 - 678 mg/kg
Acute dermal toxicity
:
LD50 rat
Dose: > 2,000 mg/kg
Acute inhalation toxicity
:
This material in the form as sold is not expected to produce respiratory effects.
If ground or otherwise in a powdered form, effects similar to a corrosive substance may
occur.
May cause severe irritation of the respiratory tract with coughing, choking, pain and possibly
burns of the mucous membranes.
Skin irritation
:
Direct contact with wet material or moist skin may cause severe irritation, pain and possibly
burns.
Eye irritation
:
Corrosive - causes irreversible eye damage.
Sensitisation
:
Repeated or prolonged skin contact may cause allergic reactions with susceptible persons.
MSDS Number: BIOG_4500121
7 of 12
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
SECTION 12. ECOLOGICAL INFORMATION
Additional ecological information
:
Toxic to fish.
Toxic to aquatic organisms.
Do not discharge effluent containing this product into lakes, streams, ponds or
estuaries, oceans, or other waters unless in accordance with the requirements
of a National Pollutant Discharge Elimination System (NPDES) permit and the
permitting authority has been notified in writing prior to discharge. Do not
discharge effluent containing this product to sewer systems without previously
notifying the local sewage treatment plant authority. For guidance contact your
State Water Board or Regional Office of the EPA.
SECTION 13. DISPOSAL CONSIDERATIONS
Further information
:
Dispose of waste material in compliance with all federal, state, and local
regulations.
Do not put product, spilled product, or filled or partially filled containers into
the trash or waste compactor.
If these wastes cannot be disposed of by use according to label instructions,
contact your Environmental Control Agency or the Hazardous Waste
Representative at the nearest EPA Regional Office for guidance. For
registered pesticides, contact your State Pesticide Agency.
Do not contaminate ponds, waterways or ditches with chemical or used
container.
Contact with incompatible materials could cause a reaction or fire.
Improper disposal of excess product, spray mixture or rinsate is a violation of
Federal Law.
Contaminated packaging
:
Do not re-use empty containers.
Rinse thoroughly before discarding in trash.
Offer rinsed packaging material to local recycling facilities.
SECTION 14. TRANSPORT INFORMATION
DOT
IATA
UN-Number
Proper shipping name
Proper technical name
: 1759
: Corrosive solids, n.o.s.
Class
Packing group
(Contains SODIUM DICHLORO-STRIAZINETRIONE, COPPER CITRATE)
: 8
: III
UN-Number
: 1759
MSDS Number: BIOG_4500121
8 of 12
BioGuard® Mainatin Smart Shock®
Proper shipping name
Proper technical name
Class
Packing group
IMDG
UN-Number
Proper shipping name
Proper technical name
Class
Packing group
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
: Corrosive solid n.o.s.
(Contains SODIUM DICHLORO-STRIAZINETRIONE, COPPER CITRATE)
: 8
: III
: 1759
: CORROSIVE SOLID, N.O.S.
(Contains SODIUM DICHLORO-STRIAZINETRIONE, COPPER CITRATE)
: 8
: III
ORM-D Consumer Commodity exemption possible
Limited Quantity exemption possible
MSDS Number: BIOG_4500121
9 of 12
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
SECTION 15. REGULATORY INFORMATION
National regulatory information
OSHA Hazards
:
This material is hazardous under the criteria of the Federal OSHA Hazard
Communication Standard 29CFR 1910.1200.
SARA Hazard category
:
Acute Health Hazard
Fire Hazard
Reactivity Hazard
US. EPA CERCLA
(Product)
:
US. EPA CERCLA Hazardous Substances (40 CFR 302)
Listed
US CERCLA
(Component)
:
US. Environmental Protection Agency (EPA); The 1980 Comprehensive
Environmental Response, Compensation, and Liability Act (CERCLA).
Reportable quantity: 5,000 lbs
Trade Secret 001
< 10 %
Listed, No RQ is being assigned to this generic or broad class.
Proprietary additive 123
US State Regulations
US MA RTK
(Component)
:
<5%
US. The Commonwealth of Massachusetts Department of Public Health;
Massachusetts Right-to-know law,The Massachusetts Substance List,
105 CMR 670.000
Massachusetts hazardous substance
Sodium dichloro-striazinetrione
2893-78-9
63.05
%
Massachusetts hazardous substance
Trade Secret 001
MSDS Number: BIOG_4500121
< 10 %
10 of 12
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
Massachusetts hazardous substance
Trade Secret 016
US NJ RTK
(Component)
:
<5%
US. New Jersey Department of Environmental Protection -; Bureau of
Hazardous Substances New Jersey Right to Know Law, Hazardous
Substance List [P.L. 1983, C. 315, NJSA 34:5A-1 et seq]
hazardous substance
Sodium dichloro-striazinetrione
2893-78-9
63.05
%
hazardous substance
Inorganic salt
< 25 %
hazardous substance
Trade Secret 001
< 10 %
hazardous substance
Proprietary additive 123
US PA RTK
(Component)
:
<5%
US. Commonwealth of Pennsylvania - Department of Labor and Industry;
Pennsylvania Code Title 34, Labor and Industry Chapter 323
hazardous substance
Sodium dichloro-striazinetrione
2893-78-9
63.05
%
environmental hazard, hazardous substance
Trade Secret 001
< 10 %
environmental hazard, hazardous substance
MSDS Number: BIOG_4500121
11 of 12
BioGuard® Mainatin Smart Shock®
Version:
1.0
Revision Date:
04/25/2008
Print Date:
01/26/2009
Proprietary additive 123
<5%
The components of this product are reported in the following inventories:
TSCA
Additional advice :
FIFRA (Federal Insecticide, Fungicide, Rodenticide Act): This product is a registered pesticide.
SECTION 16. OTHER INFORMATION
Further information
NFPA Classification
:
Health Hazard: 3
Fire Hazard: 0
Reactivity Hazard: 1
Specific hazards: OX Class 1
Oxidizer.
0
3
1
OX
HMIS Classification
:
Health Hazard: 3
Flammability: 0
Physical and chemical hazards: 1
PPI:Ask supervisor or safety specialist for handling instructions
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its
publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and
release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and
may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. Since the use
of this information and of these opinions and the conditions of use of this product are not within the control of the seller, it is the user's
obligation to determine the conditions of safe use of the products.
MSDS Number: BIOG_4500121
12 of 12
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement