Cres Cor H137S96BC Operation Manual
Cres Cor H137S96BC
The Cres Cor H137S96BC is an insulated banquet cabinet designed to keep food warm and ready to serve. It has a capacity of 96 12-inch x 20-inch x 2-1/2-inch steam table pans. The cabinet is constructed of stainless steel and has a foamed-in-place polyurethane insulation for maximum heat retention.
The H137S96BC has a temperature range of 130°F to 185°F, which is adjustable in 10°F increments. It also has a built-in humidity control system to prevent food from drying out.
The cabinet is easy to use, with a simple on/off switch and a thermostat. It also has a built-in light to illuminate the interior.
Advertisement
Advertisement
Insulated
Banquet Cabinet
Rev. 6 (6/08)
FL-2258
Page 1 of 4
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H137S96BC Series Banquet Cabinet
ELECTRICAL SPECIFICATIONS:
Model No.
H137S96BC
USA only
H137S96BC CAN
USA / CAN
H137S96BC 208
USA / CAN
H137S96BC 240
USA / CAN
Volts
120
120
208
240
Watts
1500
1500
2000
2000
Amps
12.5
12.5
9.6
8.3
Hertz
60
60
60
60
Phase
1
1
1
1
NEMA
5-15P
5-20P
6-15P
6-15P
Note: The above model numbers are basic models. They may be followed by letters L, D, or ending with an S.
HOW TO INSTALL UNIT:
1.
2.
Place cabinet on level fl oor.
Plug cord end into proper wall outlet.
2.
3.
4.
5.
HOW TO START UNIT:
1. Turn the POWER switch on. The yellow light will turn on.
Turn thermostat to #7.
Preheat cabinet for 60 minutes.
Put food into cabinet.
Turn thermostat to #8 and close door.
No. 8 setting = approx. 185°F (85°C)
No. 6 setting = approx. 160°F (71°C)
No. 4 setting = approx. 130°F (54°C)
Proper food holding temperature is 140°F (60°C) or higher.
TO TURN OFF UNIT:
Push the POWER switch off.
The yellow light will go out.
WARNING
RISK OF FIRE OR ELECTRIC SHOCK
DO NOT OPEN
WARNING: TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK,
DO NOT REMOVE COVER (OR BACK)
NO USER-SERVICEABLE PARTS INSIDE
REPAIR SHOULD BE DONE BY AUTHORIZED SERVICE
PERSONNEL ONLY
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Insulated
Banquet Cabinet
Rev. 6 (6/08)
FL-2258
Page 2 of 4
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H137S96BC Series Banquet Cabinet
HOW TO CLEAN THE CABINET:
WARNING
BEFORE cleaning the cabinet:
1. Allow cabinet to cool.
Cleaning Notes:
1. Wipe up spills as soon as possible.
2. Clean cabinet regularly to avoid heavy dirt build-up.
3. Make a test spot with cleaner.
2. Remove Hot unit from cabinet.
4. Follow manufacturer’s directions on cleaner.
3. Do NOT use abrasives or harsh chemicals.
5. Do not mix cleaners.
6. Avoid drips and splashes.
HOW TO CLEAN THE UNIT:
STAINLESS
STEEL
BANQUET
CABINET
SOIL CLEANER
Mild detergent* and hot water, or mild abrasive cleaner.
METHOD
1. Use soft, damp cloth.
2. Rinse with hot water.
3. Wipe dry.
DIRT
Steam (no strong alkaline additive)
1. Rinse after steam cleaning.
2. Wipe dry.
FINGERPRINTS,
Chemical oven cleaner for aluminum.
Follow oven cleaner manufacturer’s directions.
GREASE OIL Mild abrasive cleaner;
Apply with soft, clean cloth.
oily or waxy cleaner.
1. Wipe with damp cloth.
WATER SPOTS Mild abrasive cleaner.
2. Rinse and dry.
* Mild detergents include soaps and non-abrasive cleaners
NOTE: Gaskets are removable for cleaning.
TROUBLE-SHOOTING CHART:
FAILURE
1. Yellow light at switch does NOT light
2. Unit does not heat.
3. Unit gets too hot or won’t shut off.
4. Blower does not work or make noise.
POSSIBLE CAUSE
1a. Circuit breaker/fuse to wall outlet is blown.
1b. Cord is unplugged from wall outlet.
1c. Switch is “OFF”.
2a. Thermostat set too low or is “OFF”.
2b. Switch is “OFF”.
3a. Defective electrical parts. UNPLUG UNIT
FROM WALL OUTLET.
4a. Defective blower.
If cause is none of the above, refer to our list of Authorized Service Centers, FL-1400.
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Insulated
Banquet Cabinet
Rev. 6 (6/08)
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H137S96BC Series Banquet Cabinet
FL-2258
Page 3 of 4
REPLACEMENT PARTS: H137S96BC Series Banquet Cabinets
Description
Power Unit
Canada/USA
USA only
Blower Kit
1500w/20A
1500w/15A
Heater Kit
High Limit
Terminal Block
Thermometer -analog
Thermometer -digital
Transformer (digital thermometer)
Thermostat
Power Cord
-analog
-1500w USA only
-1500w Canada/USA
Power Switch
Power Light
Vent fan
120 Volt
0675-011
0675-006
0769-180-K
0811-265
0848-060
0852-091
5238-030
5238-034-K
0769-159
0848-062-K
0810-029-02
0810-029-03
0808-116
0766-094
0769-165
208 Volt
0675-010
0675-010
0769-182-K
0811-269
0848-060
0852-091
5238-030
5238-034-K
0769-159
0848-062-K
0810-039-02
0810-039-02
0808-116
0766-095
0769-174
240 Volt
0675-010
0675-010
0769-182-K
0811-270
0848-060
0852-091
5238-030
5238-034-K
0769-159
0848-062-K
0810-039-02
0810-039-02
0808-116
0766-095
0769-174
Door, complete
Door, gasket
Door Gasket, Complete
Door Hinge
Door Latch
-corner
-sides; long
-sides; short
1221-528
0861-071
0861-238
0861-239
0861-238-K
0519-084
1006-143-K
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com
Insulated
Banquet Cabinet
Rev. 6 (6/08)
FL-2258
Page 4 of 4
5925 Heisley Road • Mentor, OH 44060-1833
OPERATING and MAINTENANCE INSTRUCTIONS
Model: H137S96BC Series Banquet Cabinet
WIRING DIAGRAM:
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com

Public link updated
The public link to your chat has been updated.
Advertisement