Amcor | D950E | Instruction manual | Amcor D950E Instruction manual

DEHUMIDIFIER
D850E D950E
GB
Instruction manual
GB
THANK YOU!
Thank you for choosing this innovative Amcor dehumidifier.
The instruction manual describes the many benefits and advanced features that
this unique product has to offer.
The Amcor dehumidifier is a large capacity unit designed to run highly efficiently
in places such as: restaurants, bars, printing presses, indoor swimming pools,
jacuzzis, garages, animal enclosures, cellars, stores, boat sheds, weekend cottages,
archives, etc.
For over 50 years, Amcor has specialised in complete indoor environment control,
manufacturing: dehumidifiers, portable air conditioners, coolers, air purifiers/
ionisers and aromatherapy products. These world class products incorporate
the latest technological developments and are designed to create a quality
environment.
It is important that you read these instructions before using your new dehumidifier
and we strongly recommend keeping them in a safe place for future reference.
The first time that you use this dehumidifier please ensure that it has been standing
for 24 hours in an upright position before it is switched on.
SAFETY
For safety reasons, read this information carefully before operating. Persons who
are not familiar with this type of product must not use it. We strongly recommend
keeping this information in a safe place for future reference.
This appliance must be earthed and should only be connected to an earthed
220 – 240 V / 50 Hz mains. The installation must be in accordance with the
regulations of the country where the unit is used.
The unit is designated for indoor operation.
• The dehumidifier is safe.
However, as with other electrical appliance, use it with care.
• Keep out of reach of children.
• Do not clean the dehumidifier by spraying it or immersing it in water.
• Do not insert any object into the opening of the dehumidifier.
• Disconnect from the mains before cleaning the unit or any of its components.
• Never connect to an electrical outlet using an extension cord. If an outlet is not
available, one should be installed by a licenced electrician.
• Any service other than regular cleaning or filter replacement should be
performed by an authorized service representative. Failure to do so could result
in a loss of warranty.
2
GB
Your Amcor dehumidifier is supplied with an electrical cable and an earthed plug.
Should it be necessary to replace this plug at any time, you must use an earthed
electrical plug.
Warning! Never operate this appliance if it has a damaged cord or plug.
If the supply cord is damaged, it must be replaced by an approved service
representative or a similar qualified person in order to avoid any hazards.
There should be direct access to the electrical plug after connecting the power!
Do not use your dehumidifier under the following conditions:
If the power cable
wires are frayed
or cut
Where the power
cable may be
damaged
If an extension
cord is needed to
reach an outlet
Close to a heat
source
This product is not
made for DIY repair
When small
children may be
left unattended
If there is a risk of
liquid falling on
the unit
Where it may
be damaged by
chemicals
Where there is a
risk of interference
by foreign objects
Reminder:
Waste electrical products must not be disposed of with household waste.
This product should be taken to your local recycling centre for safe treatment.
HOW IT WORKS
See page 4, fig. 3
Your Amcor dehumidifier controls the Relative Humidity by passing the air through
the unit forcing the excess moisture to condensate over the cooling elements.
This condensate water then flows safely into a fixed drain.
The dried air then passes through a final heat exchanger where it is slightly warmed
and re-enters the area at a slightly elevated temperature.
The level of demoistering is set with the humidistat control.
3
GB
PARTS
➡
➡
4
Filter
Fig. 2
3
Fig. 1
2
5
6
3
4
3
1
2
Fan
Dry air
Fig. 4
Back cover
Moist air
4
3
1
2
Wall
Cooling
elements
Compressor
Fig. 3
4
Drainage
outlet
5
Fig. 5
GB
POSITIONING THE DEHUMDIFIER
There must be free space of at least 30 cm between any other object and the front
and the top of the unit.
Your Amcor dehumidifier can be installed in any area with a too high relative
humidity, such as cellar, playing area, shed, archive or swimming pool.
The dehumidifier will begin to protect from the harmful effects of excess moisture
as soon as it is plugged in and switched on.
When positioning your Amcor dehumidifier, ensure that it is placed on a level
surface.
Best results are obtained when windows and doors are closed, thus preventing the
possible influx of fresh, too humid, air.
When the unit is placed in a (swimming) pool, connect to the mains via a
transformer or a breaking switch, conform the local regulations regarding electrical
installations.
When the dehumidifier is in operation, open outside doors and windows only when
necessary.
WALL MOUNTING
See page 4, fig. 5
The unit can stand on the floor or hung on a wall. All necessary items for wall
mounting are supplied in the plastic bag.
• Fix the supporting bracket with at least 5 screws horizontally to the wall, use the
plugs for better fastening.
• Hang the unit on the bracket, the two tongues fit into the slots on the unit’s rear
panel.
• Make sure the two rubber pads (3) on the tongues and the two rubber
supports (4) on the lower part of the rear panel are properly placed.
5
GB
CONTROLS
See page 4, fig. 4
ON/OFF (1)
The unit is switched on and off by pressing the ON/OFF button (1). When the unit
is on, the fan runs in the set speed.
Humidity (2)
Press the HUMIDITY button (2) repeatedly to choose the desired level of relative
humidity in the area. The corresponding control lights (2) will indicate the selected
percentage. The yellow CNT control light (5) indicates that the unit is running
continuously, disregarding the relative humidity level in the area.
Ventilator speed (3)
Press the SPEED button (3) to select low or high speed. The corresponding control
light (3) will indicate this, Lo=low or Hi=high.
Digital display (4)
The digital display (4) will show the measured relative humidity in the area.
Compressor (6)
The COMP control light (6) will be on when the compressor is running. An
automatic time delay of five minutes before the compressor can (re-)start working
is a safegarde against damage.
IMPORTANT:
This dehumidifier should not be used in temperatures below 7 °C or above 35 °C.
Defrost Control
The dehumidifier is equipped with an automatic de-icing mode to defrost the
refrigeration coil during low temperature operation. The compressor is switched off
whilst the ventilator continues to run.
6
GB
DRAINAGE
There are four optional outlets for the drainage tube. To change the outlet of the
drainage tube the rear panel should be dismounted.
When remounting the rear panel care should be taken to return all the screws and
washers to their original location.
Connecting the permanent outlet
• Connect the pipe to an outlet tube with the correct diameter.
• Push the other end of the tube into a drain, making sure that the tubing cannot
be twisted or folded.
• The entire length of the tube must be slightly inclined.
• Ensure that the outlet of the drainage pipe is not under the water level in the
drain.
NOTE: In very cold weather conditions precautions should be taken to prevent the
drainage pipe from freezing.
CLEANING
Disconnect from the mains before cleaning the unit or any of its components.
See page 4, fig. 2
Cleaning the air filter
Air circulation is impeded and the efficiency of the dehumidifying and air purifying
functions decreases when the filter is dirty. It is therefore good practice to clean the
filter at regular intervals. The precise intervals depend on the room in which the
appliance operates and on how frequently it is used.
• Remove the filter (4) by sliding it out.
• Clean the filter or wash in tap water.
• Dry the filter before inserting it back.
Housing
Wipe regularly clean with a moist cloth and mild household detergent.
Servicing
Have your dehumidifier once a year serviced by a qualified engineer.
7
GB
MOISTURE REMOVAL
For reference purposes only
WIRING DIAGRAM
8
GB
TROUBLE SHOOTING
If the dehumidifier does not operate:
• Make sure the unit is plugged in.
• Ensure the humidistat control is turned on.
If the unit is noisy:
• Make sure the dehumidifier is standing solidly and level.
If the unit is leaking:
• Check the drainage tube for correct fitting.
• Check for twists and bends in the drainage tube.
• Check the drainage tube for a sufficient slope.
• Check and make sure that the outlet of the drainage pipe is not under the waterlevel in the drain.
TECHNICAL DATA
Model
D850E
Mains
D950E
230 V / 50 Hz
Power consumption
W
850
1200
Current (operation)
A
4.5
6
Current (at start)
A
18
24
L/24h
45
Water extraction at 32 °C, 90 % RH
Refrigerating agent
Airflow (at high fan speed)
Operating temperature
Dimensions w x h x d
Weight (net)
Meets EEC directive 73/23/CE (LVD).
60
R407C
m3/h
500
680
°C
7 – 35
mm
660 x 750 x 345
kg
39
44
Specifications may change without prior notice.
9
Hong Kong
Amcor Ltd
Suite 2007, Tower 6, The Gateway,
Harbour City, 9 Canton Road,
Tsim Sha Tsui, Kowloon,
Hong Kong
Tel: +852 2997 6865
Fax: +852 2997 6091
Email: amcorhk@amcorgroup.com
United Kingdom
Amcor Ltd
9 Ryan Drive, West Cross Centre,
Great West Road, Brentford,
Middlesex, TW8 9ER,
United Kingdom
Tel: +44 20 8560 4141
Fax: +44 20 8232 8814
Email: amcoruk@amcorgroup.com
USA
Amcor Inc.
685A Gotham Parkway, Carlstadt,
New Jersey 07072,
United States of America
Tel: +1 201 460 8100
Fax: +1 201 460 9481
Email: amcorusa@amcorgroup.com
The Netherlands
Amcor B.V.
Anton Philipsweg 9-11,
1422 AL Uithoorn,
The Netherlands
Tel: +31 297 560 079
Fax: +31 297 523 062
Email: amcorex@amcorgroup.com
Israel
Amcor International Ltd
1 Sapir St.,
P.O. Box 12001,
Hertzelia Pituach,
Israel
Tel: +972 9 951 5351
Fax: +972 9 958 5650
Email: amcoril@amcorgroup.com
Singapore
Amcor Investments (Singapore) Pte Ltd
545 Orchard Road,
#13-02, Far East Shopping Centre,
Singapore 238882
Tel: +65 6297 9881
Fax: +65 6297 8891
Email: amcorsg@amcorgroup.com
China
Shan Xia Industrial Development Zone,
Heng Li Town, Dongguan City,
Guangdong Province, China
Plant One - Amcor (China) Ltd
Tel: +86 769 8372 1090
Fax: +86 769 8372 1790
Email: amcorcn@amcorgroup.com
Plant Two - Amcor Appliances Ltd
Tel: +86 769 8372 1970
Fax: +86 769 8372 1790
Email: amcorappl@amcorgroup.com
Download PDF