159MsdsStain Sorb
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: September 19, 2012
DATE OF ISSUE: October 9, 2012
I - Product Identification
Stain-Sorb
PRODUCT CODE: 0159
CHEMICAL FORMULATION: Water based solution
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 0
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
Key:
Values reported as TWA unless noted.
APPROX
OSHA
ACGIH
EPA 40 CFR:
302
355
372
%
PEL
TLV
Contains no hazardous components as defined in 29 CFR 1910.1200
CAS #
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): 1.07
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): < 1.0
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Soluble
pH: 9.0 – 11.0
APPEARANCE AND ODOR: Opaque, off white liquid, mild odor
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): None
(TEST METHOD): N/A
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/A
LOWER: N/A
EXTINGUISHING MEDIA: Water fog, alcohol foam and dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Firefighters must use full protective gear and self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: None
PRODUCT NAME: Stain-Sorb
PRODUCT CODE: 0159
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizing agents.
CONDITIONS TO AVOID: None
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon, oxides of nitrogen,
hydrogen chloride and methyl chloride.
HAZARDOUS POLYMERIZATION: Will not occur.
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION:
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: May cause severe irritation.
IF ON SKIN: May cause irritation, drying defatting and dermatitis with prolonged or repeated contact.
IF SWALLOWED: Nausea, diarrhea vomiting cramps, headache and gastrointestinal irritation.
IF INHALED: No hazards under normal use. Dried material may cause irritation.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes holding eyelids open during flushing. If
irritation persists, repeat flushing and obtain medical attention immediately.
IF ON SKIN: Flush exposed area with soap and water for at least 10 minutes. If irritation persists obtain medical attention. Remove
contaminated clothing and launder separately before re-use.
IF SWALLOWED: Do not induce vomiting. If person is conscious, rinse mouth with water and give one drink 1 glass of water.
Obtain immediate medical attention. Never give anything to an unconscious person or a person that is rapidly losing consciousness, or
is convulsing.
IF INHALED: Remove person to fresh air. Obtain medical attention is symptoms persist.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Soak up spilled material with inert
absorbent material or flush effected area with water.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If dusting occurs, wear an approved dust respirator.
VENTILATION
LOCAL: Not required
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or goggles.
OTHER PROTECTIVE EQUIPMENT: None.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place. Keep container tightly closed when
not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT ID NUMBER: None
DOT CLASS: None
DOT PROPER SHIPPING NAME: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: September 19, 2012
Prepared by: Technical Dept.
DATE OF ISSUE: October 9, 2012
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or
the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third
parties caused by the material. Such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement