NLB2140

NLB2140
Emergency Contact: Chemtrec (800) 424-9300
Or Norco (208) 336-1643
1125 West Amity Road
Boise, ID 83705
Nitric Oxide 0.0001% to 1.0% in Nitrogen
(208) 336-1643
MATERIAL SAFETY DATA SHEET
Identification
Product Name: Nitric Oxide 0.0001% to 1.0% (1 PPM to 1.0%) in Nitrogen
Revision Date: 07/31/03
CAS Number: N/A
Last Review Date: 02/21/07
Chemical Family:
Gas Mixture
Chemical Formula:
NO in N2
Synonyms:
Calibration Gas Mixture, Cal Gas, NOx Gas Mix, Nitric Oxide Protocol Mix
MSDS Identification Code/Number: 2140
Prepared By:
Quality Dept.
Composition, Information on Ingredients
Exposure Limits1:
INGREDIENT
Nitric Oxide
Formula: NO
CAS: 10102-43-9
RTECS#: QX0525000
Nitrogen
Formula: N2
CAS: 7727-37-9
RTECS#: QW9700000
% VOLUME
PEL-OSHA2
TLV-ACGIH3
0.0001% to 1.0%
25 ppm
25 ppm TWA
99.0% to
99.9999%
None Established
Simple Asphyxiant
LD50 or LC50
Route/Species
LC50: 115 ppm
Inhalation/rat
(1 hr. as NO2, CGA P20, 2003)
Not Available
1
Refer to individual state or provincial regulations, as applicable, for limits that may be more stringent than those listed here.
As stated in 29 CFR 1910, Subpart Z (revised July 1, 1993).
3
As stated in the ACGIH 2006 Threshold Limit Values for Chemical Substances and Physical Agents.
2
IDLH (Nitric Oxide):
100 ppm
OSHA Regulatory Status: This material is classified as hazardous under OSHA regulations.
Hazards Identification
Emergency Overview:
Colorless non-flammable gas. May cause skin, eye, and respiratory irritation. This product contains nitric oxide which is toxic at
relatively low concentrations. Symptoms are dependent upon concentration of nitric oxide and duration of exposure and may be
delayed. If respiratory, skin or eye irritation occurs when working with this product, inhalation exposure may have already occurred.
Nitric oxide can cause chemical pneumonitis, retention of body fluid and swelling in the lungs (edema) or cyanosis. Prompt medical
attention is mandatory in all cases of overexposure. Nitrogen acts as a simple asphyxiant by displacing oxygen necessary to support
life. Contents under pressure. Use and store below 125O F (52O C).
NorLab Material Safety Data Sheet # 2140, Nitric Oxide 0.0001% to 1.0% in Nitrogen, Page 2 of 6
Hazards Identification Cont.
Route of Entry:
Skin Contact
Yes
Skin Absorption
No
Health Effects:
Exposure Limits
Yes
Teratogen
No
Synergistic Effects
None reported
Carcinogenicity:
NTP: No
Eye Contact
Yes
Inhalation
Yes
Irritant
Yes
Reproductive Hazard
No
IARC: No
Ingestion
No
Sensitization
No
Mutagen
No
OSHA: No
Eye Effects:
May cause irritation. Contact with rapidly expanding gas near the point of release may cause frostbite.
Skin Effects:
May cause skin irritation. Contact with rapidly expanding gas near the point of release may cause frostbite with redness, skin color
change to gray or white, and blistering.
Ingestion Effects:
Ingestion is unlikely. Product is a gas at room temperature.
Inhalation Effects:
The toxicity of this gas mixture depends upon the amount of nitric oxide present. Generally the only symptoms occurring at the time
of exposure are slight cough, fatigue, and nausea. Very concentrated fumes may cause coughing, choking, nausea, headache,
abdominal pain and tightness, and burning in the chest. Severe symptoms may be delayed (possibly for several hours) and include
cyanosis, increased difficulty in breathing (from hypoxia), irregular respiration, lassitude and eventual death due to pulmonary edema
in untreated cases.
Nitrogen acts as a simple asphyxiant. Accumulation of high concentrations can displace oxygen content in the air necessary to
support life.
Chronic Effects:
Repeated exposure to nitric oxide may cause a permanent decrease in pulmonary function (Silo Filler’s Disease) or chronic irritation
of the respiratory tract with cough, headache, loss of appetite, dyspepsia, tooth corrosion and gradual loss of strength.
Medical Conditions Aggravated by Exposure:
Pre-existing respiratory, dental, skin and eye conditions may be aggravated by overexposure to this gas mixture.
NFPA Hazard Codes
HMIS Hazard Codes
Ratings System
Health:
Flammability:
Reactivity:
Health:
1
Flammability:
0
Physical Hazard: 3
0 = No Hazard
1 = Slight hazard
2 = Moderate Hazard
3 = Serious Hazard
4 = Severe Hazard
1
0
0
Hazard ratings were assigned in accordance with Compressed Gas Association (CGA) guidelines as published in CGA Pamphlet P19-2004, CGA Recommended Hazard Ratings for Compressed Gases, 2nd Edition.
NorLab Material Safety Data Sheet # 2140, Nitric Oxide 0.0001% to 1.0% in Nitrogen, Page 3 of 6
First Aid Measures
Eye:
PERSONS WITH POTENTIAL EXPOSURE TO NITRIC OXIDE SHOULD NOT WEAR CONTACT LENSES. Flush eyes with
large amounts of water for at least 15 minutes, holding eyelids open to ensure adequate rinsing. Seek immediate medical attention as
soon as possible.
Skin:
Remove contaminated clothing and flush affected area with large quantities of water. For frostbite immerse skin in lukewarm water.
DO NOT USE HOT WATER. If irritation persists or frostbite occurs, seek medical attention.
Ingestion:
Not anticipated; product is a gas.
Inhalation:
PROMPT REMOVAL FROM THE CONTAMINATED AREA AND IMMEDIATE MEDICAL ATTENTION IS MANDATORY
IN ALL CASES OF OVEREXPOSURE. RESCUE PERSONNEL SHOULD BE EQUIPPED WITH SELF-CONTAINED
BREATHING APPARATUS.
Delayed onset of life-threatening symptoms is likely to occur. Victim(s) must be taken for medical attention.
Victims should be carried (not assisted) to an uncontaminated area and inhale fresh air supplemented with oxygen. Quick removal
from the contaminated area is most important. Keep patient warm, quiet and under competent medical observation until the danger of
delayed pulmonary edema has passed (at least 72 hours). Any physical exertion during this period should be discouraged as it may
increase the severity of the pulmonary edema or chemical pneumonitis. Bed rest is indicated. Unconscious persons should be moved
to an uncontaminated area, given artificial resuscitation and supplemental oxygen. Once respiration has been restored, they should be
treated as above.
Fire Fighting Measures
Conditions of Flammability: Not flammable
Flash point: None
Method:
Not Applicable
LEL (%): Not Applicable
Hazardous combustion products: Nitrogen compounds
Sensitivity to mechanical shock: None
Sensitivity to static discharge: None
Autoignition Temperature:
None
UEL (%): Not Applicable
Fire and Explosion Hazards:
Nonflammable. Cylinders may vent rapidly or rupture violently from pressure when involved in a fire situation. Nitric oxide may
vigorously accelerate combustion. Nitric oxide will support or initiate combustion/explosion of organic matter and other oxidizable
material.
Extinguishing Media:
Use media suitable for surrounding combustible or flammable materials. Nitric oxide can slowly react with water to form a corrosive
solution of nitric acid. Nitric acid is corrosive to skin and metal.
Fire Fighting Instructions:
Stop the flow of gas if it can be done without risk. Use water spray to cool surrounding containers. Continue to cool surrounding
containers until well after flames are extinguished. Firefighters should wear a full-face piece, NIOSH/MSHA-approved self-contained
breathing apparatus (SCBA) operated in positive pressure mode and full turnout gear.
NorLab Material Safety Data Sheet # 2140, Nitric Oxide 0.0001% to 1.0% in Nitrogen, Page 4 of 6
Accidental Release Measures
Isolate hazard area, evacuate personnel and deny entry to unauthorized/unprotected individuals. Extinguish all ignition sources and
ventilate closed spaces and low areas. Personnel entering area should wear appropriate protective equipment, including respiratory
protection suitable for unknown concentrations. Personnel should not re-enter an area until nitric oxide has sufficiently dispersed and
adequate oxygen re-established. If a leak is in user’s equipment, be certain to purge piping with an inert gas prior to attempting
repairs. If leak is in container valve, contact the appropriate emergency telephone number listed in Section 1or call your closest
Norco/NorLab location.
Handling and Storage
Electrical classification:
Non-hazardous
Use only in well-ventilated areas. Valve protection caps must remain in place on refillable cylinders unless cylinder is secured with
valve outlet piped to use point. Do not drag, slide or roll cylinders. Use a suitable hand truck for cylinder movement. Use a pressure
reducing regulator when connecting cylinder to lower pressure piping or systems. Do not heat cylinder by any means to increase the
discharge rate of product from the cylinder. Use a check valve or trap in the discharge line to prevent hazardous back flow into the
cylinder.
Protect cylinders from physical damage. Store in cool, dry, well-ventilated area of non-combustible construction away from heavy
traffic areas and emergency exits. Do not allow the temperature where cylinders are stored to exceed 125O F. Cylinders should be
stored upright and firmly secured to prevent falling or being knocked over. Use a “first in-first out” inventory system to prevent full
cylinders being stored for excessive periods of time.
For additional recommendations, consult Compressed Gas Association Pamphlet P-1.
Never carry a compressed gas cylinder or a container of a gas in cryogenic liquid form in an enclosed space such as a car trunk, van or
station wagon. A leak can result in a fire, explosion, asphyxiation or a toxic exposure.
Exposure Controls, Personal Protection
Engineering Controls:
Use a laboratory hood with forced ventilation for handling small quantities. Use local exhaust to prevent accumulation above the
exposure limit.
Eye/Face Protection:
Chemical safety goggles with full faceshield.
Skin Protection:
Protective gloves as appropriate for the job.
Respiratory Protection:
A NIOSH/MSHA-approved full-facepiece SCBA operated in positive mode and/or any supplied air respirator with a full-facepiece
and operated in a positive pressure mode in combination with an auxiliary self contained breathing apparatus operated in positive
pressure mode should be used for high or unknown concentrations. Respirators should be stored in an area not likely to be
contaminated.
Other/General Protection:
Safety shoes, safety showers and an emergency eyewash station should be available.
NorLab Material Safety Data Sheet # 2140, Nitric Oxide 0.0001% to 1.0% in Nitrogen, Page 5 of 6
Physical and Chemical Properties
PARAMETER
Physical state (gas, liquid, solid)
Vapor pressure
Vapor density (Air = 1)
Evaporation point
Boiling point
Freezing point
pH
Specific gravity
Oil/water partition coefficient
Solubility (H2O) vol/vol @0O C (32OF) and 1 atm.
Odor threshold
Odor and appearance
VALUE
: Gas
: Not Available
: Not Available
: Not Available
: Not Available
: Not Available
: Not Available
: Not Available
: Not Available
: Not Available
: Not Available
: Very slight
: Not Applicable
: Colorless gas
UNITS
O
F
C
O
F
O
C
O
Stability and Reactivity
Stability:
Stable under normal conditions.
Incompatible Materials:
Oxidizing agents, halides, hydrocarbons, and oxygen. Reacts vigorously with fluorine, fluorine oxides and chlorine in the presence of
moisture.
Hazardous Decomposition Products:
Nitric oxide oxidizes in air to from nitrogen dioxide, which is extremely reactive and a strong oxidizer. Nitric oxide reacts with
moisture and oxygen to form nitrous and nitric acids.
Hazardous Polymerization:
Will not occur.
Toxicological Information
Nitric oxide is highly toxic and hazardous because of its ability to cause delayed chemical pneumonitis and pulmonary edema.
Chronic or repeated exposure may cause permanent decrements in pulmonary function (silo filler’s disease). The absence of marked
acute irritation of nitric oxide limits its warning properties.
LC50 (Rat), Inhalation of 115 PPM for 1 hour.
There is unspecified mutagenic data for nitric oxide (SAX/RTECS).
Ecological Information
Environmental Fate:
This gas mixture will be dissipated rapidly in well-ventilated areas. Nitric oxide is involved in a series of atmospheric chemical
reactions which lead to the formation of photochemical smog.
Nitric oxide hydrolyzes to nitric acid when in contact with water.
Product does not contain Class I or Class II ozone depleting substances.
NorLab Material Safety Data Sheet # 2140, Nitric Oxide 0.0001% to 1.0% in Nitrogen, Page 6 of 6
Disposal Considerations
Do not attempt to dispose of waste or unused quantities in returnable cylinders. Return in the shipping container, properly labeled,
with any valve outlet plugs or caps secure and valve protection cap in place to NorLab for proper disposal. Non-refillable containers
should be vented in a well-ventilated area then disposed of in compliance with local regulations, or returned to NorLab.
Transportation Information
Parameter
Proper Shipping Name:
Hazard Class:
Identification Number:
Shipping Label:
United States DOT
Compressed gas, N.O.S.,
(nitric oxide, nitrogen)
2.2
UN 1956
Non Flammable Gas
Canada TDG
Compressed gas, N.O.S.
2.2
UN 1956
Non Flammable Gas
Regulatory Information
SARA Title III Notifications and Information:
Releases of
Releases of nitric oxide in quantities equal to or greater than the reportable quantity (RQ) of 100 pounds are subject to reporting to the
National Response Center under CERCLA, Section 304 SARA Title III.
Nitric oxide is listed under Section 302 as an extremely hazardous Substance (EHS). The presence of nitric oxide in quantities in
excess of the threshold planning quantity (TPQ) of 100 pounds requires certain emergency planning activities to be conducted.
SARA Title III – Hazard Classes:
Acute Health Hazard
Chronic Health Hazard
Sudden Release of Pressure Hazard
SARA Title III – Section 313 Supplier Notification
This product does not contain toxic chemicals subject to the reporting requirements of section 313 of the Emergency Planning and
Community Right-To-Know Act (EPCRA) of 1986 and 40 CFR 372:
California Proposition 65: This product does not contain ingredient(s) known to the State of California to cause cancer or
reproductive toxicity.
Other Information
Compressed gas cylinders must not be refilled without the express written permission of the owner. Shipment of a compressed gas
cylinder which has not been filled by the owner or with his/her (written) consent is a violation of transportation regulations.
Disclaimer of expressed and implied warranties:
Although reasonable care has been taken in the preparation of this document, we extend no warranties and make no representations as
to the accuracy or completeness of the information contained herein, and assume no responsibility regarding the suitability of this
information for the user’s intended purposes or for the consequences of its use. Each individual should make a determination as to the
suitability of the information for their particular purpose(s).
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement