Magic Chef MCIM30SST Instruction manual

Magic Chef MCIM30SST Instruction manual
COUNTER TOP ICE MAKER
INSTRUCTION MANUAL
Model No.:
MCIM30SST
To ensure proper use of this appliance and your safety, please read the following
instructions completely before operating this appliance.
TABLE OF CONTENTS
BEFORE PUTTING INTO USE ………………………………………………………………. 2
SPECIFICATIONS ……………………………………………………………………………… 2
IMPORTANT SAFETY INSTRUCTIONS
IMPORTANT SAFETY TIPS …………………………………………………………….…….. 3
NAME OF THE PARTS …………………………………………………………………………4
OPERATING PROCEDURES & MAINTENANCE
UNPACKING YOUR ICE MAKER …..…………………………………………………….…. 5
CONNECTING YOUR ICE MAKER ………………………………………………….……… 5
HOW TO CLEAN ………………………………………………………………………………. 6
CARE AND MAINTENANCE ……………………………..…………………………………… 6
USING YOUR ICE MAKER …………………………………………………………………… 7
TROUBLESHOOTING ……………………………………………………………….…….…. 8
ICE MAKER WARRANTY ……………………………………………………….…………… 9
1
BEFORE PUTTING INTO USE
Before connecting the appliance to the power supply, let the unit stand upright for 4 hours,
which will reduce the possibility of the cooling system malfunctioning due to improper
handling.
Clean your unit thoroughly before putting into use. (See “How to Clean”)
Use the parts diagram on page 4 to insure proper positioning of internal components.
SPECIFICATIONS
Product Description
Stainless Steel Counter top Ice Maker
Model No.
Unit Dimensions
(Inches)
Net Weight
MCIM30SST
Width
15.7"
Ice Making Capacity for
the medium ice cubes
Height
16.9"
38 (lbs)
Depth
14.0"
Up to 30 lbs / 24hrs
2
TABLE OF CONTENTS
IMPORTANT
SAFETY INSTRUCTIONS
IMPORTANT SAFETY TIPS
When using electrical appliances, basic safety precautions should be followed to reduce the risk of
fire, electric shock, and injury to persons or property. Read all instructions before using any
appliance.
Do not operate this or any other appliance with a damaged cord.
Connect to properly polarized outlets only. No other appliance should be plugged into the same
outlet. Be sure that the plug is fully inserted into the receptacle.
Do not run cord over carpeting or other heat insulators. Do not cover the cord. Keep cord away
from traffic areas, and do not submerge in water.
We do not recommend the use of an extension cord, as it may overheat and become a risk of
fire. If you must use an extension cord, use No.14 AWG minimum size and rated no less than
1875 watts, also the cord should not exceed 10 meters in length.
Unplug the ice maker before cleaning or making repairs.
Exercise caution and use reasonable supervision when appliance is used near children.
Do not clean your ice maker with flammable fluids. The fumes can create a fire hazard or
explosion.
Do not tip over.
If the ice maker is brought indoors from outdoors during the wintertime, give it a few hours to
adjust to room temperature before plugging it in.
3
NAME OF THE PARTS
1. Lid:
2. Inner Liner
3. Ice basket
4. Control Panel:
5. Ice shovel
6. Ice Sensor
7 Water Drain Cap:
With a transparent window to allow interior visibility.
Easy to use ,visible functions and 1-touch display setting.
A) Select ice cube size
B) Start ice making cycle
C) Stop ice making cycle
For draining water from water reservoir.
4
OPERATING PROCEDURES & MAINTENANCE
UNPACKING YOUR ICE MAKER
1. Remove all exterior and interior packaging. Check that ice basket and ice scoop is included. If
any part or accessory is missing, please contact our customer service dept at 888-775-0202.
2. Clean the interior with lukewarm water and a soft cloth. Remove the ice basket and wash it in
warm water.
3. Find a location for your ice maker that is protected from direct sunlight and other sources of heat
(i.e.: stove, furnace, radiator). Place the ice maker on a level surface. Make sure that there is at
least 5 inches of space between the back and sides of your ice maker and the wall.
4. Allow one hour for the refrigerant fluid to settle before plugging in the unit.
5. The appliance must be positioned so that the plug is accessible.
CONNECTING YOUR ICE MAKER
! DANGER
* Improper use of the grounded plug can result in the risk of electrical shock. If the power
cord is damaged please call our customer dept at 888-775-0202.
1. This unit should be properly grounded for your safety. The power cord of this appliance is
equipped with a three-prong plug which connects with standard three prong wall outlets to
minimize the possibility of electric shock.
2. Plug your appliance into an exclusive, properly installed, grounded wall outlet. Do not under any
circumstances, cut or remove the third (ground) prong from the power cord. Any questions
concerning power and/or grounding should be directed toward a certified electrician.
3. This appliance requires a standard 115 volt, 60Hz electrical outlet with three-prong ground.
Before using your ice maker, it is strongly recommended to clean it thoroughly.
The ice maker is not designed to be installed in an outside area such as
a garage or a porch.
Ambient temperatures of below 45 or above 90
will hinder the performance of the appliance.
5
HOW TO CLEAN
Remove the ice basket.
1. Turn the drain cap counter-clockwise to drain out the
. water
2. Clean the interior with diluted detergent, warm water and a soft cloth.
3. The outside of the ice maker should be cleaned regularly with a mild detergent solution and
warm water.
4. Dry the interior and exterior with a soft cloth.
5. Close the drain cap.
6. When the machine is not in use, open water drain cap to drain water completely from water
reservoir.
CARE AND MAINTENANCE
The ice maker should be cleaned on a regular basis. (See: “HOW TO CLEAN”)
It is necessary to have adequate ventilation space around the ice maker in order to
sustain proper performance, dissipation of heat, maintain efficiency, and low power
consumption. Clearance of minimum 5 inches should be maintained at the rear and sides
of the unit and 8 inches at the top of the unit.
To attain proper performance, be sure to plug the appliance into a properly grounded
115V/60 Hz outlet.
Do not modify the power cord under any circumstances to allow the unit to be plugged
into a non-grounded outlet. To avoid heat damage to the power cord, please ensure that it
does not come in proximity or in direct contact with the compressor of the ice maker.
Please avoid installing the ice maker in a location where the appliance will come in
contact with water or moisture to minimize rusting of metal parts.
The ice maker should not be installed near any heat source or in a location where it will
come in direct contact with the sunlight.
6
USING YOUR ICE MAKER
1. Clean your ice maker thoroughly.
2. Open the lid, remove the ice basket and pour normal tap water into tank.
Keep water level below the bottom of the ice basket.
3. Plug in the unit and the medium ice cubes indicator light will blink.
4. Press “Start” on the control panel to begin the ice making cycle. The medium ice cube indicator
light will light.
5. Select the size of the ice cube by pressing the “Select” button. If ambient temperature is below
60°F, it is recommended to select small or medium size to avoid ice sticking together.
6. The ice making cycle lasts 7 to 14 minutes, depending on the ambient temperature and the size
of the ice cube selection.
7.
While the ice maker is on , if there is low water in the water tank , the ice maker will stop working
and the “Add water” indicator light will be on. Fill the water storage tank with water the ice maker
will start to work automatically.
8. The ice maker automatically stops working when the ice basket is. full and the “Ice” indicator will
be illuminated.
9. Change water in the water reservoir every 24 hours to ensure a reasonable hygiene level.
If unit is not in use, drain all water in the tank reservoir.
10. When reinstalling the basket, push it downward to its original position to ensure the temperature
sensor is above the basket so as to ensure the machine works properly.
7
TROUBLESHOOTING
PROBLEM
POSSIBLE CAUSE
SOLUTION
Water is low.
Fill the water storage tank with water,
the ice maker will start to work
automatically.
“Ice” indicator is on.
Ice basket is full.
Remove ice from ice basket.
“Add water” and “Ice”
indicator are both blinking.
Ice shovel is stuck.
Check if ice shovel is blocked by ice.
If yes, please take out the ice cubes
and restart.
“Add water” indicator is on.
Stop the ice maker, and restart
Ice cubes stick together.
Ice making cycle is normal
but no ice is made.
Ice making cycle is too long.
when the ice blocks melt. Select the
small ice size.
Water temperature in inner
Change the water in the reservoir.
tank is too low.
Use water between 45 -90°F.
Ambient temperature or
Please operate the ice maker below
water temperature in inner
ambient temperature of 90°F and
tank is too high.
use cold water.
Refrigerant liquid leakage.
Consult a qualified technician.
Pipe in the cooling system is
blocked.
8
Consult a qualified technician.
Counter Top Ice Maker Warranty
MC Appliance Corp. warrants each new Ice Maker to be free from defects in material and workmanship and
agrees to remedy any such defect or to furnish a new part(s) (at the company’s option) for any part(s) of the unit
that has failed during the warranty period. Parts and labor expenses are covered on this unit for a period of one
year after the date of purchase. In addition, MC Appliance Corp. warrants the compressor (parts only) to be free
from defects in material and workmanship for a period of 5 years. The consumer is responsible for all labor and
transportation expenses related to the diagnosis and replacement of the compressor after the initial one- year
warranty has expired. If in the event the unit requires replacement or refund under the terms of this warranty the
consumer is responsible for all transportation expenses to return the unit to our factory prior to receiving a
replacement unit or refund. A copy of the dated sales receipt / invoice is required to receive warranty
service.
This warranty covers appliances in use within the continental United States, Puerto Rico and Hawaii. The
warranty does not cover the following:
Damages due to shipping damage or improper installation.
Damages due to misuse or abuse.
Content losses due to failure of the unit.
Punctures to the evaporator system due to improper defrosting of the unit.
Repairs performed by unauthorized service agents.
Service calls that do not involve defects in material and workmanship such as instruction on proper
use of the product, door reversal or improper installation.
Replacement or resetting of house fuses or circuit breakers.
Failure of this product if used for other than its intended purpose.
Disposal costs of failed units not returned to our factory.
Any delivery costs incurred as the result of a unit that fails to perform as specified.
The consumer is responsible for a $35.00 delivery charge for all replacement units provided under
warranty.
This warranty is in lieu of all warranties expressed or implied and no representative or person is authorized to
assume for us any other liability in connection with the sale of this product. Under no circumstances is the
consumer permitted to return this unit to the factory without prior written consent from MC Appliance Corp.
Model
Parts
Labor
Compressor (Part Only)
Type of Service
MCIM30SST
One- Year
One- Year
Five Years
Carry In
For Service or Assistance please call 888 775-0202 or visit us on the web at www.mcappliance.com.
9
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement