435msds

435msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: December 14, 2009
DATE OF ISSUE: December 15, 2009
I - Product Identification
Ultra Orange Squirt Concentrate
PRODUCT CODE: 0435
CHEMICAL FORMULATION: Citrus based concentrated cleaner.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 2
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
Values reported as TWA unless noted.
APPROX
EPA 40 CFR:
OSHA
ACGIH
%
PEL
TLV
302
355
372
CAS #
d-Limonene
5.00-15.0
N/E
N/E
N
N
N
5989-27-5
Triethanolamine
< 3.00
N/E
5 mg/m3
N
N
N
102-71-6
Ethoxylated Alkyl Amine
< 3.00
N/E
N/E
N
N
N
68478-95-5
Diethanolamine
< 2.00
N/E
2.0 mg/m3
Y
N
Y
111-42-2
Sodium Metasilicate
< 2.00
N/E
N/E
N
N
N
6834-92-0
Poly(oxyethylene) nonylphenol
< 2.00
N/E
N/E
N
N
N
9016-45-9
Key:
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): 0.99
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): 5.00 – 15.0
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Soluble
pH: 10.0-11.0
APPEARANCE AND ODOR: Clear, dark orange liquid; citrus odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): 133
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/D
LOWER: N/D
EXTINGUISHING MEDIA: Water spray, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Firefighters should be equipped with full protective gear including self-contained breathing
apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Use water spray to cool fire-exposed containers.
PRODUCT NAME: Ultra Orange Squirt Concentrate
PRODUCT CODE: 0435
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizers and acids.
CONDITIONS TO AVOID: Heat, sparks and open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may yield oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION:
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate to severe irritation, redness, tearing.
IF ON SKIN: Irritation, chapping and possible dermatitis with repeated or prolonged contact. Contains a possible sensitizer.
IF SWALLOWED: Gastrointestinal irritation, nausea, vomiting, diarrhea.
IF INHALED: Irritation of respiratory tract.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical attention.
IF ON SKIN: Flush area with cool water while removing contaminated clothing. Launder clothing separately before re-use. If
irritation persists, obtain medical attention.
IF SWALLOWED: Call a physician or poison control center immediately. Give one to two glasses of water. Do not induce vomiting
unless instructed by a physician or poison control center. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air. If breathing has stopped, administer artificial respiration.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and extinguish all sources of ignition. Soak up
with inert absorbent and place in a properly labeled closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Chemical goggles or safety glasses.
OTHER PROTECTIVE EQUIPMENT: Eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place, away from heat or open flame. Keep
container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children. Do not cut or weld on empty containers as they may contain combustible
residue.
IX - Transportation Information (ground transportation only)
DOT ID NUMBER: None
DOT CLASS: None
DOT PROPER SHIPPING NAME: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping
name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further intended,
different shipping names and labeling may apply.
REVISION DATE: December 14, 2009
Prepared by: Technical Dept.
DATE OF ISSUE: December 15, 2009
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data
or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or
third parties caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement