1720msds

1720msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: June 25, 2004
DATE OF ISSUE: November 8, 2004
I - Product Identification
Diamond
PRODUCT CODE: 1720
CHEMICAL FORMULATION: Cross-linked acrylic solution.
NFPA HAZARD IDENTIFICATION SYSTEM:
HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 1
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
Diethylene Glycol Methyl Ether
N-Methyl Pyrrolidone
Dibutyl Phthalate
Tributoxyethyl Phosphate
Key:
Values reported as TWA unless noted.
APPROX
OSHA
ACGIH
EPA 40 CFR:
%
PEL
TLV
302
355
372
1.00-3.00
N/E
N/E
Y
N
Y
1.00-3.00
N/E
N/E
N
N
Y
1.00-3.00
N/E
N/E
Y
N
Y
1.00-3.00
N/E
N/E
N
N
N
CAS #
111-77-3
872-50-4
84-74-2
78-51-3
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value
C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VAPOR DENSITY (AIR = 1): N/D
SOLUBILITY IN WATER: Emulsifiable
APPEARANCE AND ODOR: White, opaque emulsion; mild odor.
SPECIFIC GRAVITY (WATER = 1): 1.02
VOC CONTENT (% by weight): N/D
EVAPORATION RATE (WATER = 1): N/D
pH: 8.00 - 9.00
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): > 200
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/A
LOWER: N/A
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Firefighters should be equipped with full protective gear including self-contained breathing
apparatus. Fire may produce hazardous vapors.
UNUSUAL FIRE AND EXPLOSION HAZARD: None.
PRODUCT NAME: Diamond
PRODUCT CODE: 1720
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong acids and oxidizing agents.
CONDITIONS TO AVOID: None
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION: X
EYE CONTACT: X
SKIN CONTACT:
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: Mild to moderate irritation.
IF ON SKIN: Prolonged or repeated contact can lead to mild irritation.
IF SWALLOWED: Gastrointestinal irritation, nausea, diarrhea.
IF INHALED: Dizziness, headache, nausea.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Obtain medical attention if irritation persists.
IF ON SKIN: Flush area with water while removing contaminated clothing. Wash area with soap and water. Launder clothing separately
before re-use. If irritation persists, obtain medical attention.
IF SWALLOWED: Contact physician or poison control center immediately. Do not induce vomiting unless told to do so by a poison
control center or doctor. Rinse mouth with water and give affected person one to two glasses of water. Never give anything by mouth to
an unconscious person.
IF INHALED: Remove person to fresh air. If breathing stops, administer artificial respiration.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and contain spill. Soak up on absorbent material and
place in a properly labeled closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or chemical goggles.
OTHER PROTECTIVE EQUIPMENT: Protective clothing, eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place. Keep container tightly closed when not in
use. Do not freeze. Wash thoroughly after handling.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: None
DOT CLASS: None
DOT ID NUMBER: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is
further intended, different shipping names and labeling may apply.
REVISION DATE: June 25, 2004
Prepared by: PMR
DATE OF ISSUE: November 8, 2004
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this
data or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee,
users or third parties caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement