Safety Data Sheet Spartan Chemical Company, Inc. 1. PRODUCT AND COMPANY IDENTIFICATION

Safety Data Sheet Spartan Chemical Company, Inc. 1. PRODUCT AND COMPANY IDENTIFICATION
Safety Data Sheet
Spartan Chemical Company, Inc.
Revision Date: 24-Feb-2015
1. PRODUCT AND COMPANY IDENTIFICATION
Product Identifier
Product Name:
CLEAN ON THE GO THE DEGREASER [6]
Product Number:
Recommended Use:
Uses Advised Against:
4734
Cleaning agent
For Industrial and Institutional Use Only
Manufacturer/Supplier:
Spartan Chemical Company, Inc.
1110 Spartan Drive
Maumee, Ohio 43537 USA
800-537-8990 (Business hours)
www.spartanchemical.com
24 Hour Emergency Phone Numbers:
Medical Emergency/Information: 888-314-6171
CHEMTREC 800-424-9300
Transportation/Spill/Leak:
2. HAZARDS IDENTIFICATION
GHS Classification
Skin Corrosion/Irritation:
Serious Eye Damage/Eye Irritation:
Skin Sensitization:
Category 2
Category 1
Category 1A
GHS Label Elements
Signal Word:
Danger
Hazard Statements:
Precautionary Statements:
Prevention:
Response:
-Eyes
Causes serious eye damage
Causes skin irritation.
May cause an allergic skin reaction
Do not breathe mist, vapors or spray.
Wash hands and any exposed skin thoroughly after handling.
Wear eye / face protection
Wear protective gloves
Contaminated work clothing should not be allowed out of the workplace
-Specific Treatment:
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. IMMEDIATELY CALL A POISON CENTER OR
PHYSICIAN.
IF ON SKIN (or hair): Wash with plenty of soap and water. Take off contaminated clothing
and wash before reuse. If skin irritation or rash occurs: Get medical attention.
See Safety Data Sheet Section 4: "FIRST AID MEASURES" for additional information.
Storage:
Not Applicable
-Skin
_____________________________________________________________________________________________
Page 1 /
Revision Date: 24-Feb-2015
4734 - CLEAN ON THE GO THE DEGREASER [6]
_____________________________________________________________________________________________
Hazards Not Otherwise Classified:
Not Applicable
Other Information:
3. COMPOSITION/INFORMATION ON INGREDIENTS
Chemical Name
water
alcohol ethoxylate
sodium xylene sulfonate
sodium carbonate
phosphated castor oil
CAS No
7732-18-5
84133-50-6
1300-72-7
497-19-8
68308-61-2
Weight-%
60-100
7-13
5-10
1-5
1-5
Specific chemical identity and/or exact percentage of composition has been withheld as a trade secret.
4. FIRST AID MEASURES
-Eye Contact:
-Skin Contact:
-Inhalation:
-Ingestion:
Note to Physicians:
Rinse cautiously with water for at least 15 minutes. Remove contact lenses, if present and
easy to do. Continue rinsing. IMMEDIATELY CALL A POISON CENTER OR PHYSICIAN.
Wash with plenty of soap and water. If skin irritation or rash occurs: Get medical attention.
Wash contaminated clothing before reuse.
Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a
poison control center or physician if you feel unwell.
Rinse mouth. Do NOT induce vomiting. Never give anything by mouth to an unconscious
person. Get medical attention if you feel unwell.
Treat symptomatically.
5. FIRE-FIGHTING MEASURES
Suitable Extinguishing Media:
Specific Hazards Arising from the
Chemical:
Hazardous Combustion Products:
Protective Equipment and
Precautions for Firefighters:
Product does not support combustion, Use extinguishing agent suitable for type of
surrounding fire
Dried product is capable of burning. Combustion products are toxic.
May include Carbon monoxide Carbon dioxide and other toxic gases or vapors.
Wear MSHA/NIOSH approved self-contained breathing apparatus (SCBA) and full
protective gear. Cool fire-exposed containers with water spray.
6. ACCIDENTAL RELEASE MEASURES
Personal Precautions:
Environmental Precautions:
Methods for Clean-Up:
Avoid contact with skin, eyes or clothing. Use personal protective equipment as required.
Do not rinse spill onto the ground, into storm sewers or bodies of water.
Prevent further leakage or spillage if safe to do so. Contain and collect spillage with
non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite)
and place in container for disposal according to local / national regulations (see Section 13).
7. HANDLING AND STORAGE
Advice on Safe Handling:
Storage Conditions:
Handle in accordance with good industrial hygiene and safety practice. Wash thoroughly
after handling.
Keep containers tightly closed in a dry, cool and well-ventilated place. Keep out of the reach
of children. Keep from freezing.
_____________________________________________________________________________________________
Page 2 / 5
Revision Date: 24-Feb-2015
4734 - CLEAN ON THE GO THE DEGREASER [6]
_____________________________________________________________________________________________
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Occupational Exposure Limits:
None established.
Engineering Controls:
Provide good general ventilation.
If work practices generate dust, fumes, gas, vapors or mists which expose workers to
chemicals above the occupational exposure limits, local exhaust ventilation or other
engineering controls should be considered.
Eye wash stations and shower facilities should be readily accessible in areas where the
product is handled.
Personal Protective Equipment
Eye/Face Protection:
Skin and Body Protection:
Respiratory Protection:
Wear splash goggles.
Wear rubber or other chemical-resistant gloves.
Not required with expected use.
If occupational exposure limits are exceeded or respiratory irritation occurs, use of a
NIOSH/MSHA approved respirator suitable for the use-conditions and chemicals in Section
3 should be considered.
Wash hands and any exposed skin thoroughly after handling.
See 29 CFR 1910.132-138 for further guidance.
General Hygiene Considerations:
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance/Physical State:
Color:
Odor:
pH:
Melting Point / Freezing Point:
Boiling Point / Boiling Range:
Flash Point:
Evaporation Rate:
Flammability (solid, gas)
Upper Flammability Limit:
Lower Flammability Limit:
Vapor Pressure:
Vapor Density:
Specific Gravity:
Solubility(ies):
Partition Coefficient:
Autoignition Temperature:
Decomposition Temperature:
Viscosity:
Liquid
Purple
Mild
12.0-12.6
No information available.
100 °C / 212 °F
> 100 °C / > 212 °F ASTM D56
> 1 (Butyl acetate = 1)
No information available.
No information available.
No information available.
No information available.
No information available.
1.07
Soluble in water
No information available.
No information available.
No information available.
No information available.
10. STABILITY AND REACTIVITY
Reactivity:
Chemical Stability:
Possibility of Hazardous Reactions:
Conditions to Avoid:
Incompatible Materials:
Hazardous Decomposition
Products:
This material is considered to be non-reactive under normal conditions of use.
Stable under normal conditions.
Not expected to occur with normal handling and storage.
Extremes of temperature and direct sunlight.
Strong oxidizing agents. Strong acids.
May include carbon monoxide, carbon dioxide (CO2) and other toxic gases or vapors.
11. TOXICOLOGICAL INFORMATION
Likely Routes of Exposure:
Symptoms of Exposure:
-Eye Contact:
-Skin Contact:
Eyes, Skin, Ingestion, Inhalation.
Pain, redness, swelling of the conjunctiva and tissue damage. Eye contact may cause
permanent damage.
Pain, redness and cracking of the skin.
_____________________________________________________________________________________________
Page 3 / 5
Revision Date: 24-Feb-2015
4734 - CLEAN ON THE GO THE DEGREASER [6]
_____________________________________________________________________________________________
Nasal discomfort and coughing.
-Inhalation:
Pain, nausea, vomiting and diarrhea.
-Ingestion:
Immediate, Delayed, Chronic Effects
Product Information:
Data not available or insufficient for classification.
Numerical Measures of Toxicity
The following acute toxicity estimates (ATE) are calculated based on the GHS document.
.
ATEmix (oral):
16588 mg/kg
ATEmix (dermal):
23891 mg/kg
ATEmix (inhalation-dust/mist):
50.1 mg/l
Component Acute Toxicity Information
Chemical Name
water
7732-18-5
sodium xylene sulfonate
1300-72-7
sodium carbonate
497-19-8
Oral LD50
> 90 mL/kg ( Rat )
Dermal LD50
Not Available
Inhalation LC50
Not Available
= 7200 mg/kg ( Rat )
Not Available
Not Available
= 4090 mg/kg ( Rat )
Not Available
Not Available
Carcinogenicity: No components present at 0.1% or greater are listed as to being carcinogens by ACGIH, IARC, NTP or OSHA.
12. ECOLOGICAL INFORMATION
Ecotoxicity
Chemical Name
Algae/Aquatic Plants
Fish
alcohol ethoxylate
84133-50-6
sodium carbonate
497-19-8
Not Available
3.2: 96 h Pimephales
promelas mg/L LC50
300: 96 h Lepomis
macrochirus mg/L LC50
static 310 - 1220: 96 h
Pimephales promelas mg/L
LC50 static
242: 120 h Nitzschia mg/L
EC50
Persistence and Degradability:
Bioaccumulation:
No information available.
No information available.
Other Adverse Effects:
No information available.
Toxicity to
Microorganisms
Not Available
Not Available
Crustacea
3.2: 48 h water flea mg/L
EC50
265: 48 h Daphnia magna
mg/L EC50
13. DISPOSAL CONSIDERATIONS
Disposal of Wastes:
Contaminated Packaging:
Dispose of in accordance with federal, state and local regulations.
Dispose of in accordance with federal, state and local regulations.
14. TRANSPORT INFORMATION
DOT:
Proper Shipping Name:
Not Regulated
Non-Hazardous Product
15. REGULATORY INFORMATION
TSCA Status: (Toxic Substance Control Act Section 8(b) Inventory)
All chemical substances in this product are included on or exempted from listing on the TSCA Inventory of Chemical Substances.
SARA 313
This product does not contain listed substances above the "de minimus" level
SARA 311/312 Hazard Categories
Acute Health Hazard:
Yes
_____________________________________________________________________________________________
Page 4 / 5
Revision Date: 24-Feb-2015
4734 - CLEAN ON THE GO THE DEGREASER [6]
_____________________________________________________________________________________________
No
No
No
No
Chronic Health Hazard:
Fire Hazard:
Sudden release of pressure hazard:
Reactive Hazard:
California Proposition 65
This product contains the following Proposition 65 chemicals
Chemical Name
acetaldehyde - 75-07-0
formaldehyde - 50-00-0
dioxane - 123-91-1
chloromethane - 74-87-3
California Proposition 65
Carcinogen
Carcinogen
Carcinogen
Developmental
Male Reproductive
WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm.
WARNING: This product contains a chemical known to the State of California to cause cancer.
16. OTHER INFORMATION
NFPA
HMIS
Revision Date:
Reasons for Revision:
Health Hazards: 2
Health Hazards: 2
Flammability: 0
Flammability: 0
Instability: 0
Physical Hazards: 0
Special: N/A
24-Feb-2015
No information available.
Disclaimer:
The information provided in this Material Safety Data Sheet is correct to the best of our knowledge, information and belief
at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing,
storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The
information relates only to the specific material designated and may not be valid for such material used in combination
with any other materials or in any process, unless specified in the text.
End of Safety Data Sheet
_____________________________________________________________________________________________
Page 5 / 5
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Related manuals

Download PDF

advertising