HOG_500/1000_(Echelon)_Technical_Manual

HOG_500/1000_(Echelon)_Technical_Manual
+2*
(FKHORQ
Contents
ii
EMC COMPLIANCE
This product is approved for use in Europe and Australia/New Zealand and conforms to the following
standards:
European Norms
Australian / New Zealand
Standards
EN 55103-1
AS/NZS 4251.1
EN 55103-2
AS/NZS 4252.1
EN 60065
AS/NZS 3260
To ensure continued compliance with EMC Directive 89/336 and the Australian Radio communications
Act 1992, use only high quality data cables with continuous shield, and connectors with conductive back
shells. Examples of such cables are:
DMX, MIDI, Keyboard cables:
Belden 8102
100% Aluminium foil screen, 65% Copper braid.
Video, Printer:
Amtron FR2651
Flat round cable, woven shield.

JANDS ELECTRONICS PTY LTD 1999
All rights reserved
DISCLAIMER
Information contained in this manual is subject to change without notice and does not represent a
commitment on the part of the vendor. JANDS ELECTRONICS P/L shall not be liable for any loss or
damage whatsoever arising from the use of information or any error contained in this manual.
It is recommended that all service and repairs on this product be carried out by JANDS
ELECTRONICS P/L or it’s authorised service agents.
JANDS lighting consoles must only be used for the purpose they were intended by the manufacturer
and in conjunction with the operating manual.
JANDS ELECTRONICS P/L cannot accept any liability whatsoever for any loss or damage caused by
service, maintenance or repair by unauthorised personnel, or by use other than that intended by the
manufacturer.
Manufactured in Australia by:
JANDS Electronics Pty Ltd
40 Kent Rd
(Locked Bag 15)
MASCOT NSW 2020
Sydney Australia
PHONE:
+61-2-9582-0909
FAX:
+61-2-9582-0999
EMAIL:
jandsinfo@jands.com.au
Revision 3 - 11 April 2000
ACN 001 187 837
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Contents
iii
Table of Contents
Table of Contents
1.0 Introduction
2.0 Equipment Description
2.0.1 Tools ...................................................................................................... 2-1
2.0.2 Disassembly............................................................................................ 2-1
2.0.3 Re-assembly............................................................................................ 2-2
2.1 Precautions and Installation Notes .......................................................................... 2-2
3.0 Circuit Notes
3.1
Processor Card.................................................................................................... 3-1
3.1.1 Boot ROM, FLASH, and RAM .............................................................. 3-1
3.1.2 Trim procedure....................................................................................... 3-2
3.1.3 Battery.................................................................................................... 3-2
3.1.4 Logic ...................................................................................................... 3-2
3.1.5 Desk Lamp Dimmer................................................................................ 3-2
3.1.6 DMX Outputs......................................................................................... 3-3
3.1.7 Keyboard ................................................................................................ 3-3
3.1.8 Expansion Bus ........................................................................................ 3-3
3.2
Front Panel Cards................................................................................................ 3-3
3.2.1 Card Select Jumpers ............................................................................... 3-3
3.2.2 LCDs...................................................................................................... 3-3
4.0 DIP Switch Settings for normal operation
5.0 Boot ROM in-built menu, self tests, setups, etc
5.1
Entering the Boot Menu...................................................................................... 5-1
5.2
Menu Usage........................................................................................................ 5-1
5.3
Boot Menu.......................................................................................................... 5-1
5.3.1 Clean Start.............................................................................................. 5-1
5.3.2 Reload Software ..................................................................................... 5-1
5.3.3 Settings and Test .................................................................................... 5-2
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Contents
iv
6.0 Fault Finding Table
7.0 Maintenance
8.0 Technical Data and Specifications
9.0 Glossary of Terms
Appendix A History of Modifications
Appendix B Connector Pinouts
Appendix C Spare Parts
Appendix D DMX / MIDI adaptors
Appendix E Circuit diagrams and overlays
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Introduction
1-1
1.0 Introduction
This manual covers servicing of the Jands Echelon and HOG 1000/500 lighting control
consoles. Both console types are physically and electrically similar. The Echelon 1k has
moulded rubber end cheeks and armrest. References to HOG consoles may be assumed
to apply to Echelon consoles as well.
The HOG 1000/500 lighting control console is designed for stage, theatre, corporate,
and live music applications. It has been designed to control all equipment with a DMX512 input, however the front panel controls have been optimised for use with moving
light fixtures. New fixture types can be added by modifying the fixture library disk if
they are not available on the existing release library.
The console has been designed with the capability for users to upgrade the software
without removing the base. This is achieved by inserting a diskette with the new
operating system, and selecting the appropriate options in the “boot menu”. The boot
menu also provides other functions, including console self tests and setups.
Note that static sensitive devices are used throughout the console, and normal handling
precautions should be applied during service. Note also that connections should never be
made with the power switched on.
Metric fasteners are used throughout the console.
The HOG 1000/500 Operating Manual should be consulted for a description of desk
operation.
Jands recommends that all service procedures be performed by a Factory Authorised
Service Centre, or that the product be returned to Jands Electronics Service Department.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Equipment Description
2-1
2.0 Equipment Description
The HOG 1000/500 is constructed using a rolled steel chassis, covered with a reverse
screened lexan. The wooden sides are made from plantation timber and the front armrest
is covered with soft leather. The Echelon 1k has moulded rubber end cheeks and armrest.
A pair of front to back struts reduce flex and ensure front to back spacing is consistent
with the base.
A separate assembly is used to hold the PSU and CPU cards. This bracket is removable
as a complete pre-wired unit. Backpanel vents adjacent to the CPU card are removable
from the inside and will be used to add options when available.
2.0.1
Tools
With the exception of the base screws and D-connector mounting nuts, metric hardware
is used throughout the console. The following tools are recommended:
2.0.2
•
7mm nut driver
•
5mm nut driver
•
#3 Posidrive screwdriver
•
#2 Posidrive screwdriver
Disassembly
Access to the console is through the base. To remove the base place the console face
down onto soft padding. Using the #2 posidrive screwdriver remove all (and only) silver
screws, leaving the four black screws. The base can then be lifted away.
To remove the PSU/CPU assembly, disconnect all cables to the CPU and PSU, and use
the 7mm nut driver to undo:
•
three nuts next to the power inlet socket,
•
two nuts between the PSU and CPU,
•
two nuts adjacent to the MIDI connectors,
•
three nuts between the CPU card and the vent/option panel.
The assembly can then be removed by sliding it toward the front until it is clear of the
studs, then lifting it out of the chassis.
Note that the CPU card can be removed from the console without removing the
complete assembly. The CPU card is mounted on standoffs on the bracket assembly. To
remove the CPU card from the assembly:
•
Remove all connections to the card;
•
Using the 5mm nut driver undo the D-connector nuts;
•
Using the posidrive screwdriver, undo the nine screws holding the CPU card to the
CPU bracket and lift the card off.
The remaining PCBs may be removed by undoing the relevant screws, however attention
should be made to the following points:
•
Faders should be pushed to their mid position before their knobs are removed;
•
The position of the address jumpers on the menu and playback cards should be noted
when they are removed so they can be correctly set during re-assembly.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Equipment Description
2.0.3
2-2
Re-assembly
Attention should be paid to the following during reassembly:
•
LCDs and their windows should be wiped on the inside with a lint-free cloth before
assembly.
•
Ensure the address jumper on menu and playback cards are set correctly. Note all
cards should only ever have one (1) address jumper installed. Refer to section 3.2.1
for further information on the card select jumper settings.
•
When fitting the CPU ensure all connectors are properly installed, including the
DMX output connector.
•
The CPU trim procedure should be followed if either the CPU or power supply have
been changed, or if the trim has been inadvertently adjusted. Refer to section 3.1.2.
•
Test the console fully before installing the base. This includes the disk drive, desk
lamps, back lights, and DMX outputs.
•
Double check all flatcable latch connectors are closed before the base is installed.
•
Do not overtighten the base screws.
2.1 Precautions and Installation Notes
The HOG 1000/500 should be installed in a position which allows sufficient ventilation
around the back panel vents – there should be at least 100mm clear space around the
back panel.
The HOG 1000/500 has been manufactured to comply with all FCC/CE/C-Tick
regulations, and uses plated panels to ensure minimal radiation emanates from the
chassis. In order to maintain compliance:
•
all panels and covers should attached using every screw;
•
all connections should be made using the recommended cable type;
•
all back shells should be connected to the cable shield.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Circuit Notes
3.0
3-1
Circuit Notes
The HOG 1000/500 uses a main CPU to provide all processing functions. The CPU
communicates with the front panel PCBs via the front panel card bus. The main LCD is
connected directly to the CPU card.
3.1
Processor Card
The major functional blocks are as follows:
Function
3.1.1
IC Number
Core CPU
IC1-8, IC33, IC30, OSC1
Boot EPROM
IC25
FLASH ROM
IC11-13
RAM Bank 1
IC16-19
RAM Bank 2
IC20-23
FDD, RS232, Printer
IC48, IC44, IC47
DMX output
IC53, IC38, IC39, IC50, IC51
MIDI
IC48, IC35, IC52
VGA output
IC6, IC57-60, IC66
Graphics LCD output
IC67, IC61-64, IC55
Reset/power fail/RAM power
IC15
Real time clock
IC31
Front Panel Card bus
IC9, IC10
Expansion bus
IC24, IC26-29
Boot ROM, FLASH, and RAM
The CPU memory consists of a Boot EPROM (IC25), four FLASH ROMs (IC11, IC12,
IC13, IC14), and eight static RAMs (IC16-23).
The CPU card has the capacity to be fitted with a maximum of 2MBytes program
memory (four x 29F040 devices) and 4MBytes show memory (eight x 512Kbyte
devices). However the initial release has 1MByte program (four x 28F020 devices) and
2MByte show memory (four x 512Kbyte devices). DIP switches #1 and #2 set how
much SRAM has been fitted to the PCB. Refer to section 4.0.
Only 512Kbyte SRAMs can be used, and four at a time must be installed.
Only AMD brand 28F020 FLASH devices should be used with the present software
version.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Circuit Notes
3.1.2
3-2
Trim procedure
The trimpot (T1) on the CPU card adjusts the point where the CPU is informed that
power is failing. If a console is dropping its memory, T1 may be out of adjustment and
should be adjusted as follows:
1. Save any necessary console information to diskette;
2. Turn T1 fully anticlockwise;
3. Place a shunt across J1;
4. Switch console on and wait until it has completely started up;
5. Slowly adjust T1 until L3 lights;
6. Switch off console;
7. Remove shunt across J1.
This procedure should be performed whenever either a new CPU or PSU is installed.
3.1.3
Battery
The lithium battery should last approximately 5 years from the date the battery was
made - note that a 4 year life from date of product sale would not be unexpected when
delivery and manufacturing times are allowed for. The battery should be considered flat if
its terminal voltage measures below 2.9 volts.
CAUTION
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type
recommended by the battery manufacturer. Dispose of
used batteries according to the battery manufacturer’s
instructions.
3.1.4
Logic
The logic requirements for the board are contained in two logic devices, IC33 and IC55.
These are in-circuit programmable, and are programmed by connecting an appropriate
header to CONN3. If it becomes necessary to reprogram these devices in the field,
follow the instructions supplied with the kit.
CAUTION
Damage to the main LCD may result if the logic is reprogrammed while the LCD is
connected. Disconnect the flat cable from the CPU to the front panel PCBs and
LCD before proceeding.
3.1.5
Desk Lamp Dimmer
The desk lamp dimmer circuit consists of a PWM switching circuit protected by a PTC
polyswitch. The polyswitch will trip under overload conditions – when it does LED L6
will extinguish. Due to the nature of the polyswitch it is necessary to either disconnect all
desk lamps or switch the console off for a minute in order for it to reset.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Circuit Notes
3.1.6
3-3
DMX Outputs
The DMX outputs are not opto-isolated, however a protection network decouples the
driver ICs from high voltages which may be applied during external mains faults. After a
fault has been removed these devices may take up to a minute to reset, and during this
time the output cables should be disconnected or the console switched off.
3.1.7
Keyboard
The console is protected against excessive load current through the keyboard connector
by a polyswitch. After a fault has been removed this device may take up to a minute to
reset, and during this time the keyboard should be disconnected or the console switched
off.
3.1.8
Expansion Bus
The expansion bus is provided to allow for options to be added in the future. The
expansion bus is a buffered extension of the system CPU bus. It is not compatible with
Jandshog, Event, or ESP2 type expansion bus option panels, and they should not ever
be installed.
3.2
Front Panel Cards
All front panel cards follow a design similar to that of other Jands consoles. A
multiplexed 8 bit data/address bus is used to exchange bytes of information between the
CPU and the front panel cards. The pin connections however are not compatible and
under no circumstances should any Event, ESP2, or Jandshog type front panel circuit
boards ever be connected to a HOG 1000/500 CPU card. Damage may result.
Note that the Graphics LCD module on the Program card is connected directly to the
main CPU card. Brightness and contrast for this display are controlled from DACs on the
Program card.
3.2.1
Card Select Jumpers
A jumper on each menu and playback card selects the address of the card in the system.
When replacing cards ensure that the replacement card has its jumper in the same
position as the card it is replacing.
The correct jumper position for a menu or playback card is equal to its position from the
left, eg. the left-most menu and playback cards have their jumpers set to 0, the next have
it set to 1, etc. Program cards have no address jumper.
3.2.2
LCDs
The character LCD modules use a single backlight driver circuit to deliver the high
voltage required for all of the electroluminescent (EL) backlights. This is the function of
the EL driver board, mounted near the power supply. This board receives its power and
an analogue control from the CPU card.
Note that intensity of the character LCD backlights reduces with age. This is normal and
to minimise this reduction, the backlights are deactivated if the console hasn’t been used
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Circuit Notes
3-4
for a preset time. The backlights are immediately reactivated when any front panel button
is pressed.
The graphics LCD should maintain its brightness throughout its lifetime. Note also that a
faint tone may be audible from the displays when run at or near full brightness.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
DIP Switch Settings for normal operation
4.0
4-1
DIP Switch Settings for normal
operation
NOTE: At present all DIP switches except 1 and 2 should be off for normal console operation.
DIP Switches 1 and 2 are always used to configure the RAM size as fitted to the console as
shown below in Table 1:
IC16,17,18,19
IC20,21,22,23
Total RAM
SW2
SW1
Fitted
Not fitted
2M Byte
Off
On
Fitted
Fitted
4M Byte
On
On
Table 1:
DIP switch settings for normal operation
Dip SW3 - no function
Dip SW4 - no function
Dip SW5 - no function
Dip SW6 - no function
Dip SW7 - no function
Dip SW8 - Test mode enable
When SW8 is set to ON, the console enters test mode at startup as defined in section 5.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5-1
5.0 Boot ROM in-built menu, self tests,
setups, etc
The Boot ROM contains software that can be used to test, setup, and configure the
console. Note that the software is subject to change depending on the boot software
version.
5.1
Entering the Boot Menu
The boot menu is accessed by holding down the “Enter” button on the keypad while
turning power on. Release the Enter button when the opening menu is displayed.
5.2
Menu Usage
Each menu offers a number of options. In all menus except the “Auxiliary Tests” menu,
an option is selected by typing the number on the left of the text description. Pressing
Enter returns to the level above. To activate an Auxiliary Test option, type the number
and press enter, or press 0 and then Enter to return to the previous menu.
5.3
Boot Menu
The following menu options are available in the opening menu
5.3.1
1
Clean start;
2
Reload Software;
3
Setup and test.
Clean Start
Use this option to reset the show memory of the console when a new show is to be
programmed from scratch. Note that use of this option clears the fixture libraries, and so
a diskette with these libraries must be available to use the console.
5.3.2
Reload Software
Pressing “2” on the keypad at the Boot menu initiates the software reload sequence from
diskette. Ensure you have a HOG 1000/500 software diskette with the file “JNT2.BIN in
the drive and follow the instructions on the LCD. Note that this facility should be used
with caution and it is not recommended that software be reloaded at a critical time, eg.
just before the start of a show.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5.3.3
5-2
Settings and Test
The following menu options are available in the Settings and Test menu:
5.3.3.1
1
Reload Software
2
Configuration Display
3
Setup Menu
4
Native Menu
5
Auxiliary Tests
6
Full Stress Test
7
Toggle Cache
8
Restart
Reload Software
Use this option to reload the operating software in the same way as section 5.3.2
5.3.3.2
Configuration Display
When activated, this option displays the current configuration of the console as seen by
the CPU. Use this option to verify that the console is setup as expected, eg. the front
panel card jumpers are correct, etc.
5.3.3.3
Setup Menu
Use this option to access system soft setups, including the Real Time clock, individual
LCD contrasts, LCD Backlights, and Desklamp intensity. The following menu options
are available in the Setup menu:
1
Reset Clock
2
Set Contrast
3
Set Backlight and Desklamp
4
Reset Contrast and Brightness
5
Erase Flash
5.3.3.3.1 Reset Clock
The Real Time clock may require resetting when the battery has gone flat or has been
disconnected. When reset, the console time will advance from 12:00.00 1 Jan 1997.
5.3.3.3.2 Set Contrast
The LCD modules may be individually configured with different contrast settings as
necessary depending on the display characteristics. The up and down cursor keys are
used in conjunction with the wheels to adjust the contrast of the displays. Follow the
instructions on the main LCD.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5-3
5.3.3.3.3 Set Backlight and Desklamp
The desklamp intensity, the backlighting for the main display, and the backlighting for the
character LCDs may be adjusted as required using the wheels. Follow the instructions on
the main LCD.
5.3.3.3.4 Reset Contrast and Brightness
Use this function to reset all of the contrast and brightness levels to the factory defaults.
5.3.3.3.5 Erase FLASH
The FLASH devices may be erased to aid in console diagnosis.
5.3.3.4
Native Tests
The Native tests include high level tests that can be used to exercise sections of the
console. In general the results of the exercise are shown on the main LCD. The following
menu options are available in the Native Tests menu:
1
Keyboard Test
2
Floppy Test
3
MIDI & Mouse Test
4
Polled Printer Test
5
IRQ Printer Test
6
Clock Test
5.3.3.4.1 Keyboard Test
The data received from an external keyboard plugged into the keyboard input is
displayed on the main LCD. Pressing and releasing the “ESC” button on the keyboard
will result in the following display data:
KBD: dc
KBD: 1f dc
5.3.3.4.2 Floppy test
An attempt is made to read the disk label of the diskette in the floppy drive. If successful
the main display shows the label.
5.3.3.4.3 MIDI & Mouse test
This test is in 2 parts. Initially the data is written to and read back from the MIDI and
mouse control circuitry. Secondly the MIDI and Mouse interfaces are enabled and the
data received is displayed on the main LCD. Pressing and releasing the left hand mouse
button will result in the following display data:
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5-4
Mouse: e0 80 80
Mouse: c0 80 80
Data received from the MIDI port is displayed on the main LCD. Note that the MIDI
input should not be plugged into the MIDI output.
5.3.3.4.4 Polled Printer test
A predefined data stream is output from the printer port to a standard parallel printer.
When run, the following data should appear on the printer paper:
“ABCDEFGHIJKLMNOPQRSTUVWXYZabcdefghijklmnopqrstuvwxyz()1234567890”
5.3.3.4.5 IRQ Printer test
A predefined data stream is output from the printer port to a standard parallel printer.
When run, the following data should repeatedly appear on the printer paper:
“Printer interrupt test – if you can read this then it is working!”
5.3.3.4.6 Clock test
Each second the number of accumulated timer interrupts is displayed. Each second the
“Tick Time” should increase by 256 counts.
5.3.3.5
Auxiliary tests
The auxiliary tests are a further set of tests which are used to confirm fundamental
operation of the circuitry, and are not available in consoles with serial numbers prior to
G98XXX. Menu items are selected by typing the required test number followed by
Enter. Each test may be run once or continuously – when run continuously they will halt
when an error is detected, or when Enter is pressed. Note that Enter must be pressed and
held until it is recognised to terminate correctly. The following menu options are
available in the Auxiliary Test menu:
1) Bus Exercise
2) RAM Test
3) FLASH Test
4) Test VGA RAM
5) Test LCD RAM
6) Display Testbars
7) Test DMX1 Output
8) Test DMX2 Output
9) *
10) *
11) Scan Cards
12) Activate Front Panel Cards
13) Test Program Card Switches
14) *
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5-5
15) *
16) Run Tests 2,3,5,7,8,9
17) DMX Receive
18) Display version
A summary of the tests is shown in Table 2.
Note that these tests may also be run by selecting the DIP switches as shown in Table 2.
This is of use when the LCD or front panel card bus is not functional, or a program card
is not available to select a test. When run from the DIP switches all tests are run
continuously.
Test
Number
DIP Switch
(87654321)
Title
Time to execute
(seconds)
1
100001XX
Bus Exercise
0
2
100010XX
RAM test
120
3
100011XX
FLASH test
50
4
100100XX
Test VGA RAM
17
5
100101XX
Test LCD RAM
17
6
100110XX
Display testbars
2
7
100111XX
Test DMX1 output
3
8
101000XX
Test DMX2 output
3
9
101001XX
Test MIDI output
3
10
101010XX
*
-
11
101011XX
*
-
12
101100XX
Scan Cards
0
13
101101XX
Activate Front Panel Cards
-
14
101110XX
Test Program Card switches
-
15
101111XX
*
-
16
110000XX
*
-
17
110001XX
Run tests 2,3,5,7,8,9
197
18
110010XX
DMX receive
-
19
110011XX
Display version
1
Table 2: Auxiliary Test summary
5.3.3.5.1 Bus Exercise
The Bus exercise is not a test as such, but is used to debug CPU cards that have
fundamental faults, such as newly manufactured cards in production.
The CPU has been programmed to output sequences of events that can be seen on a
CRO, synchronised to the falling edge of L5. The data can be used to verify the correct
operation of the CPU control signals.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5-6
The sequence of operations performed during this routine are shown in table 3.
Event
Signals of
interest
Comment
Set Green LED on
L5
CRO Synchronisation
Set Green LED off
L5
CRO Synchronisation
Move 01 to 40010004
IC16 pin 29
Write to RAM bank 0 byte 0
Move 02 to 40010005
IC17 pin 29
Write to RAM bank 0 byte 1
Move 04 to 40010006
IC18 pin 29
Write to RAM bank 0 byte 2
Move 08 to 40010007
IC19 pin 29
Write to RAM bank 0 byte 3
Move 40010004 to
CPU
IC16-19 pin 24
Read from RAM bank 0
Move 10 to 40200000
IC20 pin 29
Write to RAM bank 1 byte 0
Move 20 to 40200001
IC21 pin 29
Write to RAM bank 1 byte 1
Move 40 to 40200002
IC22 pin 29
Write to RAM bank 1 byte 2
Move 80 to 40200003
IC23 pin 29
Write to RAM bank 1 byte 3
Move 40200004 to
CPU
IC20-23 pin 24
Read from RAM bank 1
Set Red LED on
L4
CRO Synchronisation
Set Red LED off
L4
CRO Synchronisation
Move 10 to 20000000
IC13 pin 29
Write to FLASH byte 0
Move 20 to 20000001
IC14 pin 29
Write to FLASH byte 1
Move 40 to 20000002
IC12 pin 29
Write to FLASH byte 2
Move 80 to 20000003
IC11 pin 29
Write to FLASH byte 3
Move 20000004 to
CPU
IC11-14 pin 24
Read from FLASH
Move AA to 606A0000
IC65 pin 13
PC Memory Write
Move 606A0000 to
CPU
IC65 pin 14
PC Memory Read
Move 55 to 60000000
IC65 pin 50
PC IO Write
Move 60000000 to
CPU
IC65 pin 49
PC IO Read
Table 3: Bus exercise event summary
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5-7
Figure 1 shows the relationship between L5, IC16 WR, and the CPU DACK signals as
measured while running this test.
Figure 1: Sample waveform during Bus Exercise
Trace #1:
L5
Trace #2:
IC16 Pin 29 (WR)
Trace #3:
IC1 pin 44 (DACK1)
Trace #4:
IC1 pin 43 (DACK0)
5.3.3.5.2 Test System RAM
The system RAM is checked for correct operation. This test requires approximately 2
minutes to execute when fitted with 2MBytes of RAM, ie. IC20-23 not fitted.
5.3.3.5.3 FLASH Test
The system FLASH is checked for correct operation. This test requires approximately 50
seconds to execute when fitted with 1MByte of FLASH, ie. IC11-14 fitted with 28F020
devices. Note that due to the limited number of write cycles available in FLASH devices,
it is not recommended that this test be run continuously.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5.3.3.5.4
5-8
Test VGA RAM
The VGA controller is initialised and a memory test is performed on its RAM. This test
takes approximately 17 seconds to execute and during execution a VGA monitor will
show the memory test patterns.
5.3.3.5.5
Test LCD RAM
The Graphics LCD controller is initialised and a memory test is performed on its RAM.
This test takes approximately 17 seconds to execute and during execution the graphics
LCD will show the memory test patterns.
5.3.3.5.6
Display testbars
Test bars are displayed on the VGA and LCD screens for the purpose of checking colour
(VGA) and grey scaling (LCD). Press Enter to return to the normal menu when the
screen results have been viewed.
5.3.3.5.7
Test DMX 1 Output
The DMX1 output is connected to the MIDI input via the adaptor cable shown in
Appendix D, or the combiner circuit shown in Appendix E. When the test is run the
DMX1 output is exercised and the results read back into the MIDI input. The test takes
about 3 seconds to complete.
5.3.3.5.8
Test DMX2 Output
The DMX2 output is connected to the MIDI input via the adaptor cable shown in
Appendix D, or the combiner circuit shown in Appendix E. When the test is run the
DMX2 output is exercised and the results read back into the MIDI input. The test takes
about 3 seconds to complete.
5.3.3.5.9
Test MIDI output
The MIDI output is connected to the MIDI input via a standard MIDI link cable. When
the test is run the MIDI output is exercised and the results read back into the MIDI
input. The test takes about 3 seconds to complete.
5.3.3.5.10
*
This test not currently implemented.
5.3.3.5.11 *
This test not currently implemented.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5-9
5.3.3.5.12 Scan Cards
This test scans the front panel card bus and displays the cards found on the VDU. When
run continuously this test will activate the front panel card bus and the signals can be
used to repair faulty PCBs.
5.3.3.5.13 Activate front Panel Cards
When run continuously, this test activates the front panel card bus as shown in Table 4.
It can be used to verify correct operation of the majority of the front panel controls. The
program switches in general are not activated by this test, but can be verified using the
separated “Test Program Card Switches” test 14 described in section 5.3.3.5.14.
In general a pressed switch is indicated by its associated LED or LCD, and fader values
are displayed on the associated LCD. Note that any brightness and contrast changes that
are made are not permanent and will be reset to their previous values when the console is
re-started.
This test is terminated by pressing Enter.
Card
Type
Indication
Menu
Palette select
Associated LED
Menu
up arrow
“T” in associated LCD
Menu
Down arrow
“B” in associated LCD
Playback
“DBO”, “Choose”, go, pause,
“Flash”
Associated LED
Playback
“Next Page”
“B” in associated LCD
Playback
Fader levels
Associated LCD
Playback
LCD contrast
Controlled by Fader #1
Program
“Try Cue, ”Highlight”, “Blind”,
“Clear Restore”, “Group”,
“Position”, “Colour”, “Beam”,
“Effect”, “Monitor”, “Menus”,
“Setup”, spare
Associated LED
Program
Left Wheel
Main LCD contrast
Program
Middle Wheel
Main LCD brightness
Program
Right Wheel
Desklamp brightness
Table 4: Front panel activation responses
5.3.3.5.14 Test Program Card Switches
This test is used to verify the correct operation of the program card switches. Once
activated the user must press all switches on the program card (in any order) to terminate
the test. The number of switch presses remaining is displayed on the VDU.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5.3.3.5.15
5 - 10
*
This test not currently implemented.
5.3.3.5.16
*
This test not currently implemented.
5.3.3.5.17 Run tests 2, 3, 5, 7, 8, 9
The test numbers as listed are run automatically, with the results being displayed on the
VDU. Note that in order to test the DMX1, DMX2, and MIDI outputs a signal combiner
circuit must be used as shown in Appendix E.
5.3.3.5.18 Receive DMX
DMX signal from an external source is connected to the MIDI input using the adaptor
cable detailed in Appendix D. The DMX signal present is displayed on the VDU. Note
that both DMX outputs transmit a test data pattern that can be used to feed into the
input, however only one should be plugged into the MIDI input. Note also that the data
pattern changes each time the test is run.
Press Enter to terminate the test.
5.3.3.5.19 Display version (?)
The software version of the test routines is output to L4 and L5 in flashes. The green
LED (L5) flashes once at the start of the test. The version is then displayed in red LED
(L4) flashes. The version is also displayed at the end of the title, ie.?, and for this reason
this test is mainly for use when no program card is available.
5.3.3.6
Full Stress test
The console CPU is run with everything activated as a full test on the system. While this
test is running the following occurs:
•
Changing any fader setting, wheel setting, or pushing any button on the front panel
results in an indication of the event in the main LCD;
•
Moving the mouse (if connected), pressing a button on the external keyboard (if
connected), or providing some MIDI input will result in the event being displayed on
the main LCD;
•
The LEDs on the front panel cards flash in sequence;
•
The VDU scrolls through the 16 programmed colours;
•
The system RAM is continuously tested.
Note that system is very busy during this test and can take some time to respond to
inputs. To exit, press and hold Enter until the system responds.
5.3.3.7
Toggle Cache
The cache is toggled on or off.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Boot ROM in-built menu, self tests, setups, etc
5.3.3.8
5 - 11
Restart
The console is restarted. This is generally used when use of the self tests has been
completed and it is desired to start the main operating software. Holding the Enter
button down immediately after activating this option allows re-entry to the self tests and
setups.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Fault Finding table
6-1
6.0 Fault Finding Table
Symptom
Possible Cause
Remedy
Show memory corrupt
Clean start
Program memory corrupt
Reload program
Mains fuse blown
Replace fuse in power inlet
Flat cable disconnected
Check that all flat cable connectors
are locked closed
Faulty flatcable
Replace flatcable
Circuit board not working
Replace card
Software Bug
Write down message and forward
to Jands, then try clean start or
program reload
Insufficient memory
Install more memory or delete
some unnecessary data
Flat battery
Replace battery
Power fail circuit out of adjustment
Re-trim T1 as per section 3.1.2
Console always shows error
Software bug
Write down message and forward
to Jands, then try clean start or
program reload
Console won’t write or read diskette
Disk not DOS format
Format on a PC compatible
computer (DOS 3.0 and above)
Diskette damaged
Replace diskette
Poor quality diskette
Use quality diskette
Diskette drive damaged
Replace diskette drive
Fixture not available for patching
Fixture library in console not up to
date or corrupted
Load new
diskette.
No DMX output
Incorrect patch
Check patch
Incorrect receiver address
Check receiver
Faulty DMX cable
Repair / replace cable
No line termination
Terminate DMX line
Blown DMX driver
Replace driver
Console won’t run
Front panel config error on start up
Console crash with message “Sorry
I’ve Croaked” etc
Console drops its memory
library
from
library
Patch to other DMX output
Short circuit lamp
Remove short circuit
Blown fuse
Replace fuse
Level turned down
Adjust level
Blown bulb
Replace bulb
Unearthed power cable
Use earthed cable/outlet
Poor quality cables
Use quality shielded cables
No intensity control from console
Grand Master down
Adjust Grand Master
DMX
Blind button active
Press blind button
VGA monitor not working
Monitor not turned on
Check power connection
Desk Lamp off
Radio Interference
Press power switch
Revision 3 - 11 April 2000
Monitor not plugged into console
Check VGA connection to console
Screen output not selected
Select output in setup menu
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Maintenance
7-1
7.0 Maintenance
If a console should start to misbehave or operate erratically, the problems encountered
can usually be attributed to one of two causes:
•
normal wear and tear, eg. switches failing and becoming intermittent;
•
physical abuse, eg. transit damage, spilt drinks, shorted cables.
Parts most likely to wear out in time with normal use include the following:
•
switches;
•
faders;
•
LCD backlights;
•
digital encoders.
These are generally easy to spot and there is little that can prevent such wear from
occurring, however careful use will maximise their life. Almost all parts of the console
can be damaged by physical abuse, however there are a number of things that can be
done to prevent this kind of damage:
•
Cover the console when not in use, eg. before, after and between sets.
•
ALWAYS insert a diskette into the floppy disk drive when the console is to be
transported. This prevents damage to the drive mechanism.
•
Do not use spare audio lines for DMX cable. If so, there is a danger that the
connector will get plugged into the wrong signal.
•
Do not smoke over the console.
•
Do not obstruct the rear ventilation holes.
•
When cleaning, do not use solvents and never allow the entry of liquids into the
console. Use only a damp soft cloth for cleaning.
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Technical Data and Specifications
8-1
8.0 Technical Data and Specifications
HOG 1000/500 Specifications
Mains Supply:
90-265VAC, 47-63Hz, 40 watts max.
Mains Fuse:
2A, M205 delay type
Temperature:
40°C maximum ambient
Outputs:
DMX Out 1 & 2, MIDI Thru, MIDI Out, Two Desk Lamps,
Printer, VGA, RS232
Inputs:
Keyboard (AT type), MIDI In
Control channels:
1000
Data Protocol:
USITT DMX-512/1990, electrically conforms to RS485A.
Memory capacity:
2Mbytes standard, 4Mbytes maximum
Printer Port:
IBM compatible, parallel only
Disk Drive:
IBM format DOS 3.0 and above, 1.44MB high density
Mouse Port:
Microsoft compatible 9 pin “D” connector
Desk Lamps:
12 volt 5 watt x 2, maximum output 10W total
Construction:
All steel chassis with lexan/polycarbonate covered control surface
Dimensions:
L: 945mm
W: 530mm
H: 110mm
L: 945mm
W: 530mm
H: 110mm
Weight:
19 kg net / 24.5 kg shipping
19 kg net / 24.5 kg shipping
Ingress protection:
Revision 3 - 11 April 2000
IP20
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Glossary of Terms
9-1
9.0 Glossary of Terms
Abbreviation
BOOT
Term
Explanation
BOOT
System startup
CE
Chip enable
A select pin provided on a device to enable it to
be used in conjunction with a CS line
CE
Compliance mark
Equipment marked as such complies with the
European safety/EMC regulations
C-Tick
Compliance mark
Equipment marked as such complies with the
Australian EMC regulations
Central Processing
Unit
The heart of a microprocessor or computer
CS
Chip Select
A connection that goes true under certain
circumstances to select a particular device
DIP
Dual In-line Package
A device package format with 2 parallel rows of
pins
EL
Electroluminescent
A type of backlight that uses high voltage
EPROM
Erasable
Programmable Read
Only Memory
A type of memory that is not intended to be reprogrammed in circuit
FLASH
Flash RAM
A type of memory very much like EPROM but
which is designed to be re-programmed in-system
enabling program updates
Jumper
Shunt, Link
A jumper is used to configure a system by shorting
a pair of pins together
LED
Light Emitting Diode
A diode that is optimised to radiate light
LCD
Liquid Crystal
Display
A type of display that uses a liquid to prevent the
transmission of light
PSU
Power Supply Unit
The power supply converts incoming mains to
voltages usable by the electronics
PWM
Pulse Width
Modulation
A cyclic technique of digital power control where a
load is switched fully on for a period of time
dependant upon the required output power
RAM
Random Access
Memory
Memory in which the data contained within can be
accessed in any order. The term RAM generally
refers to memory that can be read and written to
by the system
ROM
Read Only Memory
Memory that cannot be changed by the system
SRAM
Static RAM
A form of RAM that uses static memory cells to
store information.
CPU
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix A – History of Modifications
Appendix A
A-1
History of Modifications
ECHELON 1k
Serial Number
D98591
Modification
First consoles made with:
Operating software V2.3(30)
Boot ROM version 1.15
Menu card version MLCMENU1
Playback card version ECHPBAK1
Program card version ECHPROG2
CPU card version COLDCPU2
Backlight driver card version BAKLITE3
F98141
Change menu card to ECHMENU2, change desk lamp dimmer frequency
to 15KHz, change program card LCD backlight dimmer transistor Q3 to
higher power MJE350.
G98540 onwards
Boot ROM updated to V1.17, operating software updated to V2.3(32).
H98XXX onwards
Add 1M resistor to power fail circuit to eliminate startup problems
Add Auxiliary tests to boot ROM
I98XXX onwards
Operating software updated to V2.3(34), Boot ROM updated to V1.17-2
J98XXX onwards
Change program card to ECHPROG3
Change playback card to ECHPBAK2
K98XXX onwards
Operating software updated to V3.1, Q3 changed to BCP53
K98571 onwards
Boot ROM V1.18
F99XXX onwards
CPU card changed to COLDCPU4, Boot ROM V1.18-3
H99XXX onwards
Operating software V3.2(122)B
HOG 1000
I99553 onwards
HOG 1000 Lexan starts
K99591 onwards
Change program card to ECHPROG4
K99601 onwards
Operating software V3.2(130)
B00565 onwards
CPU card changed to COLDCPU6, Playback card ECHPBAK1
C00155 onwards
33MHz CPU, Operating software V3.2(133), Boot ROM V1.20-4
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix A – History of Modifications
A-2
ECHELON 500
Serial Number
F99130
Modification
First consoles made with:
Operating software V3.2(122)B
Boot ROM version 1.20-3
Playback card version ECHPBAK2
Program card version ECHPROG3
CPU card version COLDCPU4
Backlight driver card version BKLTSML2
HOG 500
K99555 onwards
Operating software V3.2(130), Program card version ECHPROG4
B00539 onwards
CPU card version COLDCPU6, Playback card ECHPBAK1
C00145 onwards
33MHz CPU, Operating software V3.2(133), Boot ROM V1.20-4
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix B – Connector Pinouts
Appendix B
B-1
Connector Pinouts
Front Panel Card Bus Connector (View from component side)
Menu, Playback, Program Cards
D0
GND
GND
D1
D3
D2
D4
GND
GND
D5
D7
D6
R/W
+5
+5
ALE
MUX
DS
+12
-12
Graphics LCD Connector (View from component side at CPU Card)
GND
Vee
Vo
GND
+5
CP
LP
M
FLM
DISP
D0
D1
D2
D3
(View from component side)
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix B – Connector Pinouts
FDD Power Connector
+5V
GND
GND
NC
B-2
Main Power Connector (CONN8)
+5V
GND
-12V
GND
+5V
+12V
GND
DIM
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix B – Connector Pinouts
B-3
FDD Connector (CONN6)
DSKCHG
GND
HDSEL
GND
RDATA
GND
WRTPRT
GND
TRK0
GND
WGATE
GND
WDATA
GND
STEP
GND
DIR
GND
MTR1
GND
DS0
GND
DS1
GND
MTR0
GND
INDEX
GND
DRATE1
GND
NC
GND
DENSEL
GND
Expansion bus Connector (CONN2)
GND
INT
ACK
A0
+12v
A1
A2
-12V
A3
A4
GND
A5
A6
GND
A7
A8
GND
A9
A10
GND
A11
A12
+5
A13
A14
+5
A15
A16
GND
A17
A18
GND
IO
GND
R/W
D7
GND
D4
D3
NC
RESET
GND
D6
D5
GND
D2
GND
D1
D0
GND
DMX CONNECTOR (Conn19)
DMX1+
DMX1GND
DMX2DMX2+
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix B – Connector Pinouts
B-4
DESK LAMP
CONNECTIONS
3
1
PIN No.
FUNCTION
1
NC
2
GND
3
V+
2
DESK LAMP CONNECTOR
MIDI CONNECTIONS
PIN
FUNCTION
No.
1
3
5
2
4
IN
OUT
THRU
1
NC
NC
NC
2
NC
SHIELD
SHIELD
3
NC
NC
NC
4
IN+
OUT+
OUT+
5
IN-
OUT-
OUT-
MIDI CONNECTOR
KEYBOARD CONNECTIONS
1
3
5
2
4
PIN No.
FUNCTION
1
KCLK
2
KDATA
3
NC
4
GND
5
+5V
KEYBOARD CONNECTOR
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix B – Connector Pinouts
B-5
DMX CONNECTIONS
5
4
3
PIN No.
FUNCTION
1
SHIELD
1
2
SIGNAL-
2
3
SIGNAL+
4
NC
5
NC
DMX CONNECTOR
VGA CONNECTIONS
1
PIN No.
FUNCTION
1
RED
2
GREEN
3
BLUE
4
NC
5
NC
6
RED RETURN
7
GREEN RETURN
8
BLUE RETURN
9
NC
10
GND
11
NC
12
NC
13
HSYNC
14
VSYNC
15
NC
6
11
VGA CONNECTOR
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix B – Connector Pinouts
B-6
PRINTER CONNECTIONS
13
1
25
14
PIN No.
FUNCTION
PIN No.
FUNCTION
1
STROBE
13
SELECT
2
D0
14
AUTOFEED
3
D1
15
ERROR
4
D2
16
INIT
5
D3
17
SELECT IN
6
D4
18
GND
7
D5
19
GND
8
D6
20
GND
9
D7
21
GND
10
ACK
22
GND
11
BUSY
23
GND
12
PAPER
24
GND
END
25
GND
PRINTER CONNECTOR
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix C - Spare Parts
C-1
Appendix C
Spare Parts
The following spare parts for HOG 1000/500 consoles are available from the JANDS
Service Department:
ITEM
PART No.
Switching power supply NFS40-7608
ZSX020
Fuse M205 2 amp fast blow (mains)
ZEF215
3.5” Disk drive
ZZA144
Desklamp socket AXR-3-31PB
ZPG038
DMX out socket AXR-5-21PB
ZPG210
Fader 10K 60mm (Alps)
ZRS010
Fader knob black/white line
ZZK035
Encoder HRPG
ZRP045
Encoder knob
ZZK121
Switch (Schadow) SERU
ZSW045
Switchcap SRKL (Schadow)
ZSC005
Switch (Cherry) MX1A-A1NW
ZSW150
Switchcap (Cherry) no LED window
ZSC050
Switchcap (Cherry) with LED window
ZSC055
Lithium Battery 6126 CR (CPU)
ZDC010
75176 / DS3695 (DMX driver)
ZIC101
IC H11N1
ZIC017
Backlite driver card complete
YPC326
Menu card complete
YPC320
Playback card complete
YPC324
Program card complete
YPC322
CPU card complete
YPC330
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix D
DMX/MIDI Adapters
D-1
Appendix D
DMX to MIDI adaptor
A DMX to MIDI adaptor cable is required to run some of the Auxiliary tests contained in the Boot
ROM. The adaptor should be wired as shown:
DMX pin
MIDI pin
Detail
3
5
connect with 220R 0.25W 5% resistor
2
4
direct connection
1
2
direct connection
2 x DMX, MIDI signal combiner
A DMX /MIDI combiner circuit is required to run some of the Auxiliary tests contained in the Boot
ROM. Refer to sections 5.3.3.5.7, 5.3.3.5.8, 5.3.3.5.17.
VCC
IC1
75176
VCC
8
R4
FromDMX1 output
10K
VCC
1
2
3
FromKeyboard Input
5
4
C1
100nF
R5
5
10K
VCC
VCC
IC2
75176
VCC
IC3A
8
74HC10
1
2
13
R2
FromDMX2 output
VCC
12
To MIDI Input
IC3B
R7 220R
74HC10
3
4
5
5
4
6
R6 220R
10K
6
1
2
3
7
R3
5
10K
IC3C
74HC10
VCC
9
10
11
8
R9
OPTO1
FromMIDI output
R1 220R
4
5
1
H11N1
270R
VCC
6
4
D1
1N914
2
5
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix E
Circuit Diagrams and Overlays
Appendix E
Revision 3 - 11 April 2000
E-1
Circuit diagrams and overlays
ECHELON / HOG 1000/500
TECHNICAL MANUAL
Appendix E
Circuit Diagrams and Overlays
E-2
COLDCPU2 Circuit diagrams and overlay
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
D
J3
3X.1
24
22
27020
D2413
D2514
D2615
D2717
D2818
D2919
D3020
D3121
OE
L7
1
LED GREEN
L1
1K 1206
R2
R6
1K 1206
Q1
+12
R12
10K 1206
BCX19
1K 1206
R9
BCX17
Q4
100nF 1206
C2
100nF 1206
C3
C4
100nF 1206
D0
D1
D2
D3
D4
D5
D6
D7
1
22
24
31
13
14
15
17
18
19
20
21
1
22
24
31
D8 13
D9 14
D1015
D1117
D1218
D1319
D1420
D1521
1
22
24
31
D24 2
D25 3
D26 4
D27 5
D28 6
D29 7
D30 8
D31 9
1
11
28020
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC11
28020
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC12
28020
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC14
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC13
28020
D1613
D1714
D1815
D1917
D2018
D2119
D2220
D2321
1
22
24
31
D2413
D2514
D2615
D2717
D2818
D2919
D3020
D3121
C5
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
100nF 1206
25
4
28
29
3
2
30
31
12
11
10
9
8
7
6
5
27
26
23
BAV103
D1
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
VCC
VCC
CE/PGM
O0
O1
O2
O3
O4
O5
O6
O7
VCC
VPP
VCC
1
32
LED RED
VCC
2K2 1206
R117
A19
GND
16
1D
2D
3D
4D
5D
6D
7D
8D
OC
CLK
IC68 74HC574
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
2
1Q
2Q
3Q
4Q
5Q
6Q
7Q
8Q
12
11
10
9
8
7
6
5
27
26
23
25
4
28
29
3
2
30
12
11
10
9
8
7
6
5
27
26
23
25
4
28
29
3
2
30
12
11
10
9
8
7
6
5
27
26
23
25
4
28
29
3
2
30
25
4
28
29
3
2
30
12
11
10
9
8
7
6
5
27
26
23
19
18
17
16
15
14
13
12
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
L5
L4
A(0..31)
22
24
29
13
14
15
17
18
19
20
21
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
D0
D1
D2
D3
D4
D5
D6
D7
22
24
29
13
14
15
17
18
19
20
21
22
24
29
D8 13
D9 14
D1015
D1117
D1218
D1319
D1420
D1521
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
62040
IC22
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
62040
IC21
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
1K 1206
R36
Backlite
R129
4k7 1206
R130
10K 1206
VCC
LCDON
10K 1206
R131
Sys_Reset
BAV103
D9
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
62040
4
28
3
31
2
30
1
12
11
10
9
8
7
6
5
27
26
23
25
IC20
3
1. Set T1 fully CCW
2. Short J9
3. Start Console
4. Adjust T1 until L6 lights
5. Remove J9 short
BAV103
D5
R13
10K 1206
RESET
LED RED
L2
10K 1206
LINK
4
VCC
12
13
14
15
16
17
18
19
SDO
SDI
REBOOT
LED RED
L3
1K 1206
1K 1206
R14
R7
VCC
10uF SMD
C19
C1
8X.1
R5
VCC
A7
A6
A5
A4
A3
A2
A1
A0
A1512
A1413
A1314
A1215
A1116
A1017
A9 18
A8 19
A2312
A2213
A2114
A2015
A1916
A1817
A1718
A1619
A3112
A3013
A2914
A2815
A2716
A2617
A2518
A2419
CONN3
ISP port
100nF 1206
C7 C8 C9 C107
C135 C136 C137 C138 C6
100nF 1206
100nF 1206 100nF 1206
100nF 1206 100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
62040
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
22
24
29
D1613
D1714
D1815
D1917
D2018
D2119
D2220
D2321
22
24
29
D2413
D2514
D2615
D2717
D2818
D2919
D3020
D3121
IC23
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
4
28
3
31
2
30
1
12
11
10
9
8
7
6
5
27
26
23
25
62040
SRAMPOWR
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
SRAMPOWR
IC19
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
62040
IC18
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
62040
IC17
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
62040
IC16
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
R35 1K 1206
LED GREEN
LED RED
D0
D1
D2
D3
D4
D5
D6
D7
22
24
29
D8 13
D9 14
D1015
D1117
D1218
D1319
D1420
D1521
22
24
29
D1613
D1714
D1815
D1917
D2018
D2119
D2220
D2321
22
24
29
D2413
D2514
D2615
D2717
D2818
D2919
D3020
D3121
32
Vcc
32
Vcc
32
Vcc
32
Vcc
32
Vcc
32
Vcc
32
Vcc
32
Vcc
4
16
15
11
10
12
13
2
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC8
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC30
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC6
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC7
RES
/RES
WDI
PFO
CEO
CEI
VOUT
BCX17
Q2
ISPEN
MODE
SCLK
D(0..31)
A(0..31)
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
RAM2RD
RAM2W0
RAM2W1
RAM2W2
RAM2W3
RAM2SIZ
RAM1SIZ
SCLK
MODE
SDO
SDI
ISPEN
D24
D25
D26
D27
AD7
AD6
AD5
AD4
AD3
AD2
AD1
AD0
AD15
AD14
AD13
AD12
AD11
AD10
AD9
AD8
AD23
AD22
AD21
AD20
AD19
AD18
AD17
AD16
AD31
AD30
AD29
AD28
AD27
AD26
AD25
AD24
PFI
OSC1
OSC2
WDO
LOW
VBATT
9
11
12
13
14
15
16
17
18
B7
B6
B5
B4
B3
B2
B1
B0
IC2
B7
B6
B5
B4
B3
B2
B1
B0
IC3
B7
B6
B5
B4
B3
B2
B1
B0
IC4
B7
B6
B5
B4
B3
B2
B1
B0
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
1
19
5
4K7 1206
R29
5
LINK
J1
LA9
LA19
D7
D6
D5
D4
D3
D2
D1
D0
D15
D14
D13
D12
D11
D10
D9
D8
D23
D22
D21
D20
D19
D18
D17
D16
D31
D30
D29
D28
D27
D26
D25
D24
JH2MAIN
3V
BAT1
47K 1206
R30
1K 1206
R1
R80
22K 1206
R81
22K 1206
1K TRIM
VR2
10K 1206
C155
100nF 1206
7
8
14
6
1
AD7
AD6
AD5
AD4
AD3
AD2
AD1
AD0
AD1511
AD1412
AD1313
AD1214
AD1115
AD1016
AD9 17
AD8 18
AD2311
AD2212
AD2113
AD2014
AD1915
AD1816
AD1717
AD1618
AD3111
AD3012
AD2913
AD2814
AD2715
AD2616
AD2517
AD2418
R28
MAX693
IC15
R78
2K2 1206
2096
IC33
106
74
69
68
67
36
24
78
46
50
20
18
12
11
122
6
VCC
D24
D25
D26
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
IC5
RAM1RD
RAM1W0
RAM1W1
RAM1W2
RAM1W3
103
60
100
62
99
21
45
IC25
3
3
VCC
FLASHRD
FLASHW0
FLASHW1
FLASHW2
FLASHW3
35
61
101
63
34
70
ACLK
71 A0
66 A1
102 A2
53 A3
119 A4
41 A9
27 A20
95 A21
91 A22
40 A29
29 A30
55 A31
A0
A1
A2
A3
A4
A9
A20
A21
A22
A29
A30
A31
BOOTROM
25
AD089
AD190
AD291
AD392
AD495
AD596
AD697
AD798
AD8 1
AD9 2
AD103
AD114
AD125
AD138
AD149
AD15
10
AD16
11
AD17
14
AD18
15
AD19
16
AD20
17
AD21
20
AD22
21
AD23
22
AD24
23
AD25
26
AD26
27
AD27
28
AD28
29
AD29
30
AD30
33
AD31
34
15
BAV103
D6
MEMCLK
A/D0
A/D1
A/D2
A/D3
A/D4
A/D5
A/D6
A/D7
A/D8
A/D9
A/D10
A/D11
A/D12
A/D13
A/D14
A/D15
A/D16
A/D17
A/D18
A/D19
A/D20
A/D21
A/D22
A/D23
A/D24
A/D25
A/D26
A/D27
A/D28
A/D29
A/D30
A/D31
MCF5202
IC1
SIZ1
SIZ0
TS
AA
DTIP
R/W
42
41
40
48
47
39
VCC
VCC
SIZ1
SIZ0
TS
AA
DTIP
RW
SPAREOUT
SPAREIN
VA9
IOCHRDY
ALE
MEM_WR
MEM_RD
IO_WR
IO_RD
NMI
5
54
44
90
128
38
43
58
59
LA19
LA9
MiscIO
RESET
S4
S3
S2
S1
121
19
56
118
39
13
75
31
DA1
DA0
VCC
89
96
DMX2WR
DMX1WR
23
123
108
92
98
88
1
2
3
4
5
6
7
8
6
SW-DIP8
SW1
IOSEL
DMX1WR
DMX2WR
IORD
IOWR
MEMRD
MEMWR
ALE
IOCHRDY
SPAREOUT
SPAREIN
VA9
RTCADD
RTCDATA
DIPSW
CARDBUF
CARDMUX
CARDAL
CARDDS
IPL2
IPL1
IPL0
EXPINT
INT6
INT7
INTEN
INT5
INT1
MIDIINT
RS232INT
EXPACK
EXPSEL
CPUCLK
BD
BG
BR
IPL0
IPL1
IPL2
AVEC
TT0
TT1
PST3
PST2
PST1
PST0
CLK
RST
HIZ
TIELOW
TCK
TMS/BKMT
TDI/DSI
TDO/DSO
TRST/D
MTMOD0
MTMOD1
MTMOD2
6
1K 1206
R4
DDATA0
DDATA1
DDATA2
DDATA3
DA1
DA0
TBI
TEA
ATM
44
43
54
55
63
IOSEL
94
16
15
14
13
12
11
10
9
105
117
4
87
107
104
10
126
127
2
125
86
124
9
52
26
85
22
30
42
83
49
51
50
64
65
66
62
35
36
59
58
57
56
87
67
75
85
74
73
72
71
70
77
78
76
81
82
83
84
1K 1206
R11
18
17
16
15
14
13
12
11
B0
B1
B2
B3
B4
B5
B6
B7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
19
1
2
3
4
5
6
7
8
9
File:
Vcc
VCC
R27
R31
16
17
21
20
19
22
7
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
D2418
D2517
D2616
D2715
D2814
D2913
D3012
D3111
74HC245
IC26
A2
A1
A0
Number: COLDCPU2.S01
H:\LAB\ECHELON\CIRCUIT\COLDCPU2.S01
18
17
16
15
14
13
12
11
74HC245
IC28
A10
A9
A8
A7
A6
A5
A4
A3
CS
AS
DS
STBY
R/W
RESET
D0
D1
D2
D3
D4
D5
D6
D7
12
11
18
17
16
15
14
13
74HC245
IC29
A18
A17
A16
A15
A14
A13
A12
A11
74HC245
IC31
MC146818A
D24 5
D25 6
D26 7
D27 8
D28 9
D2910
D3012
D3114
R3
1K 1206
10R 1206
D2418
D2517
D2616
D2715
D2814
D2913
D3012
D3111
IC27
Echelon CPU card
D24
D25
D26
D27
D28
D29
D30
D31
1
2
10R 1206
GND
7
10K 1206
VCC
10K 1206
CLK24M
R/W
IC2474HC245
R82
1K 1206
VCC
4
R116
VCC
24MHz
IC32
Size: A2
1K 1206
R10
VCC
INTEN
KEYINT
DMXINT
MIDIINT
RS232INT
EXPINTOUT
R127
10K 1206
2
4
6
8
10
12
14
16
18
20
22
24
26
VCC
10K 1206
R124
IDC26
1
3
5
7
9
11
13
15
17
19
21
23
25
CONN13
Interface
Title
VCC
VCC
BDM
OUT
3
R125
2
5
BAT-ON
GND
4
1
11
13
18
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
SQW
PS
MOT
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
IRQ
OSC2
OSC1
Date: 1-Oct-1999
Revision: 0
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
VCC
23
4
3
25
24
27
26
2
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
8
ACK
INT
A2
A1
A0
RW
RESET
IO
SPARE
A10
A9
A8
A7
A6
A5
A4
A3
A18
A17
A16
A15
A14
A13
A12
A11
D0
D1
D2
D3
D4
D5
D6
D7
RW
-12
+12
DS
ALE
MUX
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
1K 1206
R8
8
1
22pF 1206
C26
Card Bus
Drawn By: D.Timmins
470K 1206
R34
4M7 1206
R32
4M7 1206
R33
32.768KHz
X1
+12
ALEL
+5
RW
D7
GND
D4
D3
GND
D0
-12
+12
C116
220R 1206
10NF 1206
R91
C117
220R 1206
10NF 1206
R92
C118
220R 1206
10NF 1206
R93
C119
220R 1206
10NF 1206
R94
VCC
220R 1206
R83 1206
220R
R84 1206
220R
R85 1206
220R
R86 1206
220R
R87 1206
220R
R88 1206
220R
R89 1206
220R
R90
LAMPCLK
C25
10nF 1206
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Sheet 1 of 4
R126
1K 1206
CONN1
20WAYIDC
14
19
20
17
15
18
2
3
5
6
8
9
11
12
13
16
1
4
7
10
-12
DS
ALEH
+5
D6
D5
GND
D2
D1
GND
D0
GND
D3
D4
GND
D7
RW
GND
IO
A18
GND
A15
A14
+5
A11
A10
GND
A7
A6
GND
A3
A2
+12
ACK
GND
C108
10NF 1206
C109
10NF 1206
C110
10NF 1206
C111
10NF 1206
C112
10NF 1206
C113
10NF 1206
C114
10NF 1206
C115
10NF 1206
Bus
Expansion
GND
D1
D2
GND
D5
D6
GND
REset
SPARE
GND
A17
A16
+5
A13
A12
GND
A9
A8
GND
A5
A4
-12
A1
A0
INT
CONN2 50WAYIDC
48
49
44
45
47
14
15
18
17
32
33
35
36
38
39
41
42
29
30
8
9
19
1
20
21
23
24
26
27
2
3
5
6
8
9
11
12
2
3
4
5
6
7
19
1
2
3
4
5
6
7
8
9
EXPINTIN
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
CLKOUT
CLKFS
74HC245
IC9
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
74HC245
IC10
NC
NC
NC
NC
1
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
R26
R25
R24
R23
R22
R21
R20
R19
Vdd
28
A
B
C
D
A
B
C
9
5
1
6
2
7
3
8
4
R114
R115
220R 1206
220R 1206
R113
R112
220R 1206
220R 1206
5PINDIN
1
2
3
4
5
B7
B9
Bead
VCC
1
B6
Bead
MC1488
VCC
74HC14
-12
+12
R42
47R 1206
74HC14
IC35A
IC52
H11L1
2
BAV103
D2
5
3
VCC
R57
74HC14 220R 1206
IC35C
6
9
1
VCC
9
MC1488
IC47C
10
11
MC1489
IC35D
R37
4
5
IC44D
MC1488
IC47B
8
14
2
1
6
MC1489
IC44B
3
MC1489
IC47A
1K 1206
1K 1206
Bead
PolySwitch
VCC
VCC
R38
B11
Bead
B10
Bead
8
VCC
8
13
6
10
MC1489
Bead
B8
Bead
Bead
3
IC44C
B12
KU3H
P2
B5
220R 1206
R41
CONN18
5PINDIN
1
2
3
4
5
CONN17
5PINDIN
1
2
3
4
5
CONN16
Out
5PINDIN
1
2
3
4
5
CONN15
Serial
RS232
DB9
4
9
12
CONN14
2
5
IC44A
6
1
1
4
3
RESET
C134
74HC14
IC35B
1nF 1206
4
2
VCC
1nF 1206
74HC14
100
86
87
88
89
90
91
92
93
94
95
96
97
98
99
81
82
83
84
85
1nF 1206
IOCHRD
DTR2
DRV2
Vss
MTR2
DS3
VIO
MTR3
RI2
DCD2
RXD2
TXD2
DSR2
RTS2
CTS2
RTS1
CTS1
DTR1
RI1
DCD1
1nF 1206
1nF 1206
C164
1nF 1206
C163
C162
1nF 1206
C161
10
C160
1nF 1206
C159
C158
1nF 1206
C157
11
1
2
A(0..31)
R/W
D(0..31)
5
2
14
15
16
17
18
19
VCC
78
77
76
75
74
73
72
71
70
69
3
4
5
6
7
8
9
10
11
12
IOCHRDY
PRINTER
R170
3
CLK24M
FDD
34WAYIDC
CONN6
VCC
R79
R121
R122
R123
47R 1206
R47
R46
R77
R49
DB25
CONN5
DSR1
TXD1
RXD1
STROBE
AUTOFD
ERROR
INIT
SLCTIN
Vcc
PD0
PD1
PD2
PD3
Vss
PD4
68
67
66
65
64
11
12
13
DENSEL
MTR0
DS1
DS0
MTR1
Vss
DIR
STEP
WDATA
WGATE
HDSEL
INDEX
TRK0
WRTPRT
Vcc
80
79
20
21
22
23
24
25
13
14
15
16
17
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29
31
33
A3
PSPIRQ
SSPIRQ
DACK
TC
A6
A5
A4
IOW
IOR
A9
A8
A7
FINTR
PINTR
D2
D1
D0
Vss
AEN
IOWR
IORD
MIDIINT
RS232INT
R52
R53
R54
R55
R56
VCC
1K 1206
R111
A6
A5
A4
A3
A9
A8
A7
5X2MM
CONN19
1K 1206
1K 1206
1K 1206
1K 1206
1K 1206
37C665IR
31
45
44
43
42
41
40
39
38
37
36
35
34
33
32
50
49
48
47
46
D26
D25
D24
RSTDRV
IC48
47R 1206
47R 1206
47R 1206
47R 1206
47R 1206
47R 1206
47R 1206
47R 1206
D31
D30
D29
D28
56
55
54
53
52
1
2
3
4
5
6
7
8
9
10
63
62
18
19
PD5
PD6
PD7
ACK
BUSY
PE
SLCT
61
60
59
58
57
20
21
22
23
24
RDATA
DSKCHG
DRATE1
DRATE2
X1
X2
IDED7
D27
51
GAMECS
RESET
D7
D6
D5
D4
FDRQ
D3
25
26
27
28
IDEENL
IDEENH
HDCS0
HDCS1
IOCS16
A0
A1
A2
A0 29
A1 30
A2
5
4
3
2
1
C870
TH3
C870
TH1
MOV1
DMX2
MOV2
C870
TH4
C870
TH2
DMX1
1.5KE12CA
4
R44 R45
Bead
B4
Bead
B3
Bead
B2
Bead
B1
10K 1206 10K 1206
1.5KE12CA
4
6
7
75176
IC50
7
6
75176
IC51
10R 1206
R60
3
OUT
VCC
DMX1WR
DMX2WR
4
1
2
3
3
2
1
4
24MHz
OSC1
1UF SMD
C28
VCC
1UF SMD
C29
VCC
5
5
A0
2
8
9
23
3
D24 7
D25 6
D26 5
D27 4
D2831
D2930
D3029
D3128
2
9
23
8
3
D24 7
D25 6
D26 5
D27 4
D2831
D2930
D3029
D3128
W
FF
HF
XI
D3
D4
D5
D6
D7
D2
D3
D0
D1
W
XI
FF
HF
D5
D6
D7
D0
D1
D2
D3
D3
D4
RS
FL
EF
R
Q4
Q5
Q6
Q7
Q8
Q2
Q3
Q0
Q1
IC38
7202
7202
RS
R
FL
EF
Q6
Q7
Q8
Q0
Q1
Q2
Q3
Q4
Q5
IC39
70
62
106
45
128
18
26
24
25
39
69
12
108
23
90
13
27
11
88
40
10
11
13
14
19
20
21
22
15
91
28
63
103
98
25
60
61
127
21
22
15
18
119
121
19
20
26
24
68
87
10
126
13
14
1K 1206
R108
DMXFULL
DMX2O
DMX_Reset
DMX2RD
DMX2RESET
DMX2EMPTY
F26
F27
F28
F20
F21
F22
F23
F24
F25
DMX1FULL
DMX1O
RES
DMX1RESET
DMX1EMPTY
DMX1RD
F14
F15
F16
F17
F18
F12
F13
F10
F11
2096
IC53
1k 1206
R48
10
11
VCC
EXPINTIN
EXPINTOUT
DMXINT
KEYINT
6
6
GND
1
17
33
49
65
81
87
112
VCC
16
48
82
113
AUX POWER
CONN9
4X.156
Backlite
80
1
2
3
4
+12
MEMCLK
D
MIDI
Thru
In
KEYBOARD
4
Vcc
57
RLED
3
1
IOSEL
D25
D26
D24
A0
A1
A2
A3
LAMPCLK
8X.156
8
7
6
5
4
3
2
1
38
20
50
3
66
41
21
8
54
78
46
18
File:
EnaVEE
VEE
Sys_Reset
10K 1206
R43
BCX19
Q5
A2
Number: COLDCPU2.s02
Echelon CPU Card
+12
-12
SDI
SDO
INTEN
ISPEN
LCDON
SPAREIN
SPAREOUT
DISPOFF
NMI
SCLK
MODE
7
7
H:\LAB\ECHELON\CIRCUIT\COLDCPU2.S02
Size:
Title
VCC
VCC
3X.156
CONN7
D24
D25
D26
D27
D28
D29
D30
D31
A0
A1
A2
A3
26
59
86
85
25
123
125
6
24
36
99
95
4
93
2
CONN8
+12
1
2
3
VPP
SDI
SDO
INTEN
ISPEN
LCDON
SPAREIN
SPAREOUT
DISPOFF
NMI
SCLK
MODE
-12
VCC
35
D27
D28
D29
D30
D31
EnaVEE
VEE
Sys_Reset
LAMPCLK
IC35E
5
5
GND
2
17
1
17
1
12
27
12
27
117
89
107
43
KEYINT
INT1
EXPINTOUT
EXPINTIN
KEYB_CLK
KEYB_DATA
15
29
53
IO
LAMP
102
44
83
GLED
PINTR
55
RW
BACKLITE
RESET
105
19
2
8
8
R40
1
220R 1206
0
Date: 1-Oct-1999
Revision:
47R 1206
R51
100nF 1206
C10
BAV103
D4
BAV103
D3
Sheet
2 of 4
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
TIP42
Q7
10uF SMD
C20
0.47R 5W
R39
P1
8
+12
8
0
Drawn By: D.Timmins
VCC
1K 1206
R110
LED RED
L6
PolySwitch
RUE090
A
B
C
D
A
B
C
1
BAR43C
D7
1N5817
D7A
D5
D4
D3
D2
D1
D0
D7
D6
A6
A5
A4
A3
A2
A1
A0
-22V
10uF SMD
C21
14WAYIDC
CONN10
D3114
D3015
D2916
D2817
D2718
D2619
D2520
D2421
A8
A7
A6
A5
A4
A3
A2
A1
A0
32
31
30
29
28
27
26
25
24
23
A13
A12
A11
A10
A9
A8
A7
VCC
62
61
60
59
64
52
65
53
A1336
A1235
A1134
A1033
A19
A18
A17
A16
A15
A14
49
46
99
ACTIND
AEN
RESET
1
2
47
48
F3
-12
BEAD BEAD
F4
+12
F2
BEAD
RW
-12
+12
DS
ALE
MUX
CONN4
20WAYIDC
14
19
20
17
15
18
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
R120
1M 1206
R118
FB
CTRL
ADJ
V+
MAX749
4
3
2
1
VCC
MA4
MA3
MA2
MA1
MA0
D10
MA7
MA6
MA5
WE
D15
D14
D13
D12
D11
MA8
CASL
RAS
CASH
MD13
MD14
MD15
MD5
MD6
MD7
MD8
MD9
MD10
MD11
MD12
MD3
MD4
MD0
MD1
MD2
65510
IC67
F1
BEAD
R106 150R 1206
R105 150R 1206
R104 150R 1206
2
R95 150R 1206
R96 150R 1206
R97 150R 1206
R98 150R 1206
R99 150R 1206
R100 150R 1206
R101 150R 1206
R102 150R 1206
C106
10pF 1206
470K 1206
GND
DLOW
DHI
CS
IC55
R119
5
6
7
EnaVEE
DISPOFF
R103 150R 1206
1K 1206
R61
R128
1R
220K 1206
2
3
5
6
8
9
11
12
13
16
1
4
7
10
47uH
IND1
VCC
T1p
BCX17
Q3
R107
1R
8
50
55
56
57
58
11
12
51
1
2
3
4
5
6
7
8
9
10
11
12
13
14
43
A1842
A1741
A1640
A1539
A1437
C131
LA19
LA9
C130
IORD
IOWR
MEMR
MEMW
3
100
98
44
45
VCC
10NF 1206
UD7
UD6
UD5
UD4
SHCLK
LP
ACDCLK
FLM
ENAVDD
UD0
UD1
UD2
UD3
D9
D8
ENAVEE
LMA8
LMA7
LMA6
LMA5
74 LMA4
75 LMA3
76 LMA2
77 LMA1
78 LMA0
C132
10uF
10K 1206
R50
10
71
72
73
67
66
68
69
5
6
7
8
9
70
82
81
80
91
90
89
87
86
85
84
83
93
92
96
95
94
100pF 1206
C127
C129
GND
Vo
Vee
Vss
Vdd
CP
LP
M
FLM
DISP
D0
D1
D2
D3
100R 1206
10NF 1206
10NF 1206
R109
C11
VEE
100nF 1206
C125
C133
10NF 1206
D
10NF 1206
IORD
C124
D(0..31)
IOCHRDY
IOWR
C126
C128
13
3
3
74HC14
IC35F
12
4
17
5
16
3
18
19
1
2
5
16
3
4
17
1
2
18
19
16
3
17
5
4
1
2
18
19
3
5
16
4
17
18
19
1
2
OE
WE
RAS
CAS
D0
D1
D2
D3
IC64
OE
WE
RAS
CAS
D0
D1
D2
D3
IC63
OE
WE
CAS
RAS
D0
D1
D2
D3
IC62
WE
OE
A0
A1
A2
A3
A4
A5
A6
A7
A8
414256
A7
A8
A0
A1
A2
A3
A4
A5
A6
414256
A6
A7
A8
A0
A1
A2
A3
A4
A5
414256
A2
A3
A4
A5
A6
A7
A8
D2
D3
RAS
CAS
A0
A1
414256
D0
D1
IC61
6
7
8
9
11
12
13
14
15
14
15
6
7
8
9
11
12
13
13
14
15
6
7
8
9
11
12
11
12
13
14
15
8
9
6
7
VCC
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
VCC
C40
100nF 1206
VCC
VCC
VCC
VCC
VCC
10uF SMD
C23
2u2F SMD
C32
4
VCC
R65
VCC
VCC
-12
C15
VCC
47R 1206
R71
VCC
VCC
VCC
VCC
R72
VCC
47R 1206
VCC
VCC
VCC
D8
VCC
VCC
BAV103
150R 1206
R70
100nF 1206
2u2F SMD
C33
10R 1206
R75
C18
P0
VSS4
GREEN
RED
IREF
HSYNC
AVSS2
OVRW
AVDD2
EED1
EECS
BLUE
SD6
SD7
AVSS1
VFILTR
AVDD1
TWR
VSYNC
SD0
SD1
SD2
SD3
VDD3
SD4
SD5
VSS5
IRQ
VSS4
SA16
AEN
IOCHRD
REFRESH
IOR
IOW
0WS
SA14
SA15
RESET
SA13
VCC
VCC
10uF SMD
C24
VCC
VCC
100nF 1206
C17
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
Video
CONN11
VGACONN
VCC
VCC
VCC
VCC
VCC
4
6
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
1R
R74
VCC
5
10R 1206
R76
1
LM334
IC56
79
80
76
77
78
62
63
64
65
66
67
68
69
70
71
72
73
74
75
D30
D31
D28
D29
54
55
56
57
58
59
60
61
D24
D25
D26
D27
52
53
47
48
49
50
51
46
A1342
A1443
A1544
A1645
6
VCC
1R
C16
100nF 1206
100nF 1206
R73
VCC
47R 1206
R59
150R 1206
R66
150R 1206
VA9
41
5
C60
100nF 1206
A(0..31)
10NF 1206
10NF 1206
C41
100nF 1206
C61
100nF 1206
C50
100nF 1206
C42
100nF 1206
C62
100nF 1206
C51
100nF 1206
C43
100nF 1206
C63
100nF 1206
C52
100nF 1206
C44
100nF 1206
C64
100nF 1206
C53
100nF 1206
C45
100nF 1206
C65
100nF 1206
C54
100nF 1206
C46
100nF 1206
C66
100nF 1206
C55
100nF 1206
C47
100nF 1206
C67
100nF 1206
C56
100nF 1206
C48
100nF 1206
C68
100nF 1206
C57
100nF 1206
3
2
2
R68
150R 1206
C69
100nF 1206
C58
100nF 1206
C70
100nF 1206
C90
100nF 1206
C80
100nF 1206
R69
150R 1206
C71
100nF 1206
C91
100nF 1206
C81
100nF 1206
C36
10pF 1206
C72
100nF 1206
C92
100nF 1206
C82
100nF 1206
C49
100nF 1206
A12
A11
A10
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
C37
10pF 1206
C73
100nF 1206
C38
10pF 1206
C74
100nF 1206
C84
100nF 1206
C93
100nF 1206
RDY
CLKIN
STBY
BHE
RFSH
10NF 1206
1
C35
220pF 1206
C94
100nF 1206
C83
100nF 1206
MD31
97
MD30
98
MD29
99
MD28
100
C75
100nF 1206
C95
100nF 1206
C59
100nF 1206
A8
A7
A6
A5
A4
A3
A2
A1
A0
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
101
C34
220pF 1206
11
10
C96
100nF 1206
C85
100nF 1206
R67
150R 1206
A19
A18
A17
106
107
9
MD12
VDD6
MD9
MD10
MD11
MD4
MD5
MD6
MD7
VSS10
WE1
MD8
CAS
WE0
VSS11
MD0
MD1
MD2
MD3
MA6
MA7
MA8
VSS12
MA9
RAS
OE
VDD7
MA4
MA5
AVSS4
MFILTR
AVDD4
MA0
MA1
MA2
MA3
XTAL
MCLK
VSS13
OSC
GD5429
IC65
VCC
VSS2
MD22
C77
100nF 1206
MD27
102
MD26
103
MD25
104
MD24
105
C76
100nF 1206
7
C97
100nF 1206
C87
100nF 1206
C78
100nF 1206
C88
100nF 1206
C98
100nF 1206
C86
100nF 1206
8
SD8
SD9
MD21
MD20
19
18
17
16
15
14
13
12
VSS3
SA12
SA11
SA10
SA9
SA8
SA7
SA6
SA5
SA4
SA3
SA2
SA1
SA0
VDD2
BALE
SHBE
MCS16
IOCS16
LA23
LA22
LA21
LA20
LA19
LA18
LA17
MEMR
MEMW
VDD4
P1
P2
P3
AVDD3
P4
P5
P6
P7
AVSSS3
VSS7
DCLK
BLANK
EVIDEO
ESYNC
EDCLK
MD31
MD30
MD29
MD28
VSS8
MD27
MD26
MD25
MD24
WE3
VDD5
MD23
6
5
SD10
SD11
MD23
108
MD22
109
MD21
110
MD20
111
MD19
112
MD18
113
MD17
114
MD19
MD18
4
3
VSS1
MD17
2
SD12
MD16
MD16
115
116
SD13
WE2
1
VDD1
SD14
SD15
EROM
MD15
MD14
MD13
119
VSS9
120
ALE
MEMWR
MEMRD
RSTDRV
160
159
VCC
122
121
125
124
123
139
138
137
136
135
134
133
132
131
130
129
128
127
126
147
146
145
144
143
142
141
140
149
148
154
153
152
151
150
156
155
158
157
VCC
47R 1206
VCC
VCC
100nF 1206
C13
100nF 1206
C14
R58
VCC
MA06
MA17
MA28
MA39
MA4
11
MA5
12
MA6
13
MA7
14
MA8
15
MA06
MA17
MA28
MA39
MA4
11
MA5
12
MA6
13
MA7
14
MA8
15
MA06
MA17
MA28
MA39
MA4
11
MA5
12
MA6
13
MA7
14
MA8
15
MA06
MA17
MA28
MA39
MA4
11
MA5
12
MA6
13
MA7
14
MA8
15
VCC
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
IC60
414256
A8
A1
A2
A3
A4
A5
A6
A7
A0
IC59
414256
A2
A3
A4
A5
A6
A7
A8
A0
A1
IC58
414256
A6
A7
A8
A4
A5
A0
A1
A2
A3
D0
D1
D2
D3
VCC
OE
WE
RAS
CAS
D0
D1
D2
D3
OE
WE
RAS
CAS
D1
D2
D3
D0
OE
WE
RAS
CAS
D2
D3
D0
D1
OE
WE
CAS
RAS
150R 1206
IC57
R64
150R 1206
R63
VCC
5
16
3
4
17
1
2
18
19
16
3
4
17
5
1
2
18
19
4
17
5
16
3
18
19
1
2
16
3
17
5
4
1
2
18
19
File:
A2
Number: COLDCPU2.S03
Echelon CPU Card
7
0
Date: 1-Oct-1999
Revision:
C153
10uF SMD
C147
C150
10uF SMD 10uF SMD
H:\LAB\ECHELON\CIRCUIT\COLDCPU2.S03
Size:
Title
+12
-12
-12
Sheet
3 of 4
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
C145
10uF SMD
-12
-12
+12
+12
-12
+12
VCC
VCC
VCC
VCC
MD28
MD29
MD30
MD31
MD24
MD25
MD26
MD27
MD20
MD21
MD22
MD23
MD16
MD17
MD18
MD19
2u2F SMD
C31
10uF SMD
C22
VCC
MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
7
C143
100nF 1206
117
118
C79
100nF 1206
C89
100nF 1206
C99
100nF 1206
C100
100nF 1206
C139
100nF 1206
C101
100nF 1206
C140
100nF 1206
C102
100nF 1206
C141
100nF 1206
C103
100nF 1206
C142
100nF 1206
C104
100nF 1206
C27
100nF 1206
C105
100nF 1206
C151
100nF 1206
C144
100nF 1206
C148
100nF 1206
C149
100nF 1206
C152
100nF 1206
C154
100nF 1206
C146
100nF 1206
1
2
8
GND
Vcc
14.31818MHz
IC66
4
Drawn By: D.Timmins
150R 1206
R62
8
OUT
3
10NF 1206
C120
10NF 1206
C121
10NF 1206
C122
10NF 1206
C123
VCC
A
B
C
D
Appendix E
Circuit Diagrams and Overlays
E-3
COLDCPU4 Circuit diagrams and overlay
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
D
24
22
27020
D2413
D2514
D2615
D2717
D2818
D2919
D3020
D3121
OE
1
A0
A1
A2
A3
VCC
A11
A12
A13
A14
A15
A16
A17
A18
12 A0
11 A1
10 A2
9 A3
8 A4
7 A5
6 A6
5 A7
27 A8
26 A9
23A10
25A11
4 A12
28A13
29A14
3 A15
2 A16
30A17
31A18
LED GREEN
L1
1K 1206
R2
A4
A5
A6
A7
A8
A9
A10
VCC
1
32
VPP
VCC
CE/PGM
O4
O5
O6
O7
O0
O1
O2
O3
GND
16
D0
D1
D2
D3
D4
D5
D6
D7
1
22
24
31
13
14
15
17
18
19
20
21
1
22
24
31
D8 13
D9 14
D1015
D1117
D1218
D1319
D1420
D1521
1
22
24
31
D1613
D1714
D1815
D1917
D2018
D2119
D2220
D2321
1
22
24
31
D2413
D2514
D2615
D2717
D2818
D2919
D3020
D3121
D24 2
D25 3
D26 4
D27 5
D28 6
D29 7
D30 8
D31 9
1
11
28020
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC11
28020
1D
2D
3D
4D
5D
6D
7D
8D
OC
CLK
IC68 74HC574
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
D2
D3
D4
D5
D6
D7
Vpp
CE
OE
WE
A0
A1
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A11
A12
A13
A14
A15
A16
A17
A4
A5
A6
A7
A8
A9
A10
A0
A1
A2
A3
D0
D1
IC12
28020
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC14
28020
Vpp
CE
OE
WE
D4
D5
D6
D7
D0
D1
D2
D3
IC13
2
1Q
2Q
3Q
4Q
5Q
6Q
7Q
8Q
A20
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
29A16
3 A17
2 A18
30A19
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
29A16
3 A17
2 A18
30A19
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
29A16
3 A17
2 A18
30A19
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
29A16
3 A17
2 A18
30A19
19
18
17
16
15
14
13
12
TP1 L5
L4
A(0..31)
22
24
29
13
14
15
17
18
19
20
21
1K 1206
R36
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
CE
OE
WE
D3
D4
D5
D6
D7
D0
D1
D2
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
CE
OE
WE
D5
D6
D7
D0
D1
D2
D3
D4
Backlite
R129
4k7 1206
R130
VCC
LCDON
Sys_Reset
10K 1206
10K 1206
D0
D1
D2
D3
D4
D5
D6
D7
22
24
29
13
14
15
17
18
19
20
21
22
24
29
D8 13
D9 14
D1015
D1117
D1218
D1319
D1420
D1521
22
24
29
D1613
D1714
D1815
D1917
D2018
D2119
D2220
D2321
22
24
29
D2413
D2514
D2615
D2717
D2818
D2919
D3020
D3121
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC22
CE
OE
WE
D3
D4
D5
D6
D7
D0
D1
D2
IC21
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
CE
OE
WE
D5
D6
D7
D0
D1
D2
D3
D4
IC20 62040
SRAMPOWR
62040
IC23
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
62040
62040
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A12
A13
A14
A15
A16
A17
A18
A5
A6
A7
A8
A9
A10
A11
A0
A1
A2
A3
A4
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
3 A16
31A17
2 A18
30A19
1 A20
12A2
11A3
10A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
3 A16
31A17
2 A18
30A19
1 A20
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
3 A16
31A17
2 A18
30A19
1
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
3 A16
31A17
2 A18
30A19
1
3
BAV103
D5
LED RED
L2
LINK
4
VCC
12
13
14
15
16
17
18
19
SDO
SDI
REBOOT
LED RED
L3
1K 1206
10K 1206
R14
R7
10uF SMD
C19
100nF 1206
1K 1206
VCC
8X.1
R5
1. Set VR2 fully CCW
2. Short J1
3. Start Console
4. Adjust VR2 until L3 lights
5. Remove J1 short
RESET
10K 1206
R13
VCC
A7
A6
A5
A4
A3
A2
A1
A0
A1512
A1413
A1314
A1215
A1116
A1017
A9 18
A8 19
A2312
A2213
A2114
A2015
A1916
A1817
A1718
A1619
A3112
A3013
A2914
A2815
A2716
A2617
A2518
A2419
CONN3
ISP port
C1
C7 C8 C9 C107
C135 C136 C137 C138 C6
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
3 A16
31A17
2 A18
30A19
1 A20
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
3 A16
31A17
2 A18
30A19
1 A20
R131
SRAMPOWR
62040
IC19
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
IC1862040
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
3 A16
31A17
2 A18
30A19
1
12 A2
11 A3
10 A4
9 A5
8 A6
7 A7
6 A8
5 A9
27A10
26A11
23A12
25A13
4 A14
28A15
3 A16
31A17
2 A18
30A19
1
BAV103
D9
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A12
A13
A14
A15
A16
A17
A18
A5
A6
A7
A8
A9
A10
A11
A0
A1
A2
A3
A4
IC1762040
R35 1K 1206
LED GREEN
LED RED
D0
D1
D2
D3
D4
D5
D6
D7
22
24
29
D8 13
D9 14
D1015
D1117
D1218
D1319
D1420
D1521
22
24
29
D1613
D1714
D1815
D1917
D2018
D2119
D2220
D2321
22
24
29
D2413
D2514
D2615
D2717
D2818
D2919
D3020
D3121
IC16
62040
32
Vcc
GND
3216
Vcc
GND
3216
Vcc
GND
3216
Vcc
GND
16
32
Vcc
32
Vcc
32
Vcc
32
Vcc
16
15
11
10
13
12
2
2Q
1Q
8Q
7Q
6Q
5Q
4Q
3Q
RES
/RES
WDI
PFO
CEO
CEI
VOUT
MAX693
Q2
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
RAM2RD
RAM2W0
RAM2W1
RAM2W2
RAM2W3
RAM2SIZ
RAM1SIZ
SCLK
MODE
SDO
SDI
ISPEN
D24
D25
D26
D27
AD7
AD6
AD5
AD4
AD3
AD2
AD1
AD0
AD15
AD14
AD13
AD12
AD11
AD10
AD9
AD8
AD23
AD22
AD21
AD20
AD19
AD18
AD17
AD16
AD31
AD30
AD29
AD28
AD27
AD26
AD25
AD24
PFI
OSC1
OSC2
7
8
14
6
1
AD7
AD6
AD5
AD4
AD3
AD2
AD1
AD0
11
12
13
14
15
16
17
18
AD1511
AD1412
AD1313
AD1214
AD1115
AD1016
AD9 17
AD8 18
AD2311
AD2212
AD2113
AD2014
AD1915
AD1816
AD1717
AD1618
AD3111
AD3012
AD2913
AD2814
AD2715
AD2616
AD2517
AD2418
R28
1K TRIM
VR2
1M 1206
R18
10K 1206
C155
100nF 1206
WDO
LOW
VBATT
9
2K2 1206
R78
2096
IC33
106
74
69
68
67
36
24
78
46
50
20
18
12
11
122
6
VCC
D24
D25
D26
BCX17
ISPEN
MODE
SCLK
D(0..31)
A(0..31)
CLK
OC
2D
1D
8D
7D
6D
5D
4D
3D
74HC574
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
CLK
OC
4D
3D
2D
1D
8D
7D
6D
5D
74HC574
IC15
IC8
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC30
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC6
4Q
3Q
2Q
1Q
8Q
7Q
6Q
5Q
IC7
70
ACLK
103
4
B1
B0
B7
B6
B5
B4
B3
B2
IC2
B7
B6
B5
B4
B3
B2
B1
B0
IC3
B7
B6
B5
B4
B3
B2
B1
B0
IC4
B3
B2
B1
B0
B7
B6
B5
B4
IC5
A1
A0
A7
A6
A5
A4
A3
A2
DIR
E
74HC245
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
A3
A2
A1
A0
A7
A6
A5
A4
E
DIR
74HC245
GND
1
17
33
49
65
81
97
112
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
19
1
5
D15
D14
D13
D12
D11
D10
D9
D8
D23
D22
D21
D20
D19
D18
D17
D16
D31
D30
D29
D28
D27
D26
D25
D24
4K7 1206
R29
5
JH2MAIN
LA9
LA19
D7
D6
D5
D4
D3
D2
D1
D0
3V
BAT1
LINK
J1
47K 1206
R30
1K 1206
R1
22K 1206
R80
VCC
16
48
82
113
RAM1RD
RAM1W0
RAM1W1
RAM1W2
RAM1W3
60
100
62
99
IC25
3
3
VCC
FLASHRD
FLASHW0
FLASHW1
FLASHW2
FLASHW3
35
61
101
63
34
AD089
AD190
AD291
AD392
AD495
AD596
AD697
AD798
AD8 1
AD9 2
AD103
AD114
AD125
AD138
AD149
AD15
10
AD16
11
AD17
14
AD18
15
AD19
16
AD20
17
AD21
20
AD22
21
AD23
22
AD24
23
AD25
26
AD26
27
AD27
28
AD28
29
AD29
30
AD30
33
AD31
34
15
BAV103
D6
MEMCLK
A/D6
A/D7
A/D8
A/D9
A/D10
A/D11
A/D12
A/D13
A/D14
A/D15
A/D16
A/D17
A/D18
A/D19
A/D20
A/D21
A/D22
A/D23
A/D24
A/D25
A/D26
A/D27
A/D28
A/D29
A/D30
A/D31
A/D0
A/D1
A/D2
A/D3
A/D4
A/D5
MCF5202
IC1
GND
6
12
18
24
31
37
45
52
61
68
79
86
93
99
VCC
VCC
7
13
19
25
32
38
46
53
60
69
80
88
94
100
VCC
NMI
VCC
1
2
3
4
5
6
7
8
SW-DIP8
SW1
IOSEL
DMX1WR
DMX2WR
IORD
IOWR
MEMRD
MEMWR
ALE
IOCHRDY
SPAREOUT
SPAREIN
VA9
RTCADD
RTCDATA
DIPSW
CARDBUF
CARDMUX
CARDAL
CARDDS
IPL2
IPL1
IPL0
EXPINT
INT6
INT7
INTEN
INT5
INT1
MIDIINT
RS232INT
EXPACK
EXPSEL
CPUCLK
BR
BD
BG
IPL0
IPL1
IPL2
AVEC
TT0
TT1
PST3
PST2
PST1
PST0
CLK
RST
HIZ
TIELOW
TCK
TMS/BKMT
TDI/DSI
TDO/DSO
TRST/D
MTMOD1
MTMOD2
MTMOD0
DDATA0
DDATA1
DDATA2
DDATA3
6
1K 1206
R4
6
16
15
14
13
12
11
10
9
105
117
4
87
107
104
10
126
127
2
125
86
124
9
52
26
85
22
30
42
83
49
51
50
64
65
66
62
35
36
59
58
57
56
87
67
75
85
74
73
72
71
70
76
77
78
81
82
83
84
VCC
1K 1206
R11
1K 1206
R10
VCC
INTEN
KEYINT
DMXINT
MIDIINT
RS232INT
EXPINTOUT
VCC
12
14
16
18
20
22
24
26
11
13
15
17
19
21
23
25
13
12
11
18
17
16
15
14
B0
B1
B2
B3
B4
B5
B6
B7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
19
1
7
8
9
2
3
4
5
6
Vcc
VCC
File:
Size:
Title
D24
D25
D26
D27
D28
D29
D30
D31
10K 1206
R116
VCC
4
24MHz
IC32
CLK24M
R/W
IC2474HC245
R82
VCC
VCC
10K 1206
R124
IDC26
2
4
6
8
10
1
3
5
7
9
CONN13
Interface
R127
10K 1206
BDM
R125
1
2
R27
10R 1206
GND
7
18
17
16
15
14
13
12
11
D2418
D2517
D2616
D2715
D2814
D2913
D3012
D3111
Number: COLDCPU5.SC1
7
18
17
16
15
14
13
12
11
74HC245
IC26
A2
A1
A0
H:\LAB\ECHELON\CIRCUIT\COLDCPU5.SC1
A2
18
17
16
15
14
13
12
11
74HC245
IC28
A10
A9
A8
A7
A6
A5
A4
A3
CS
AS
DS
STBY
R/W
RESET
D0
D1
D2
D3
D4
D5
D6
D7
18
17
16
15
14
13
12
11
74HC245
IC29
A18
A17
A16
A15
A14
A13
A12
A11
74HC245
Echelon CPU card
17
21
20
19
22
16
D24 5
D25 6
D26 7
D27 8
D28 9
D2910
D3012
D3114
D2418
D2517
D2616
D2715
D2814
D2913
D3012
D3111
IC27
IC31
MC146818A
R31
R3
VCC
10R 1206
2
5
BAT-ON
GND
4
BOOTROM
25
21
45
LA19
LA9
MiscIO
RESET
S4
S3
S2
S1
121
19
56
118
39
13
SIZ1
SIZ0
TS
AA
DTIP
R/W
42
41
40
48
47
39
SIZ1
SIZ0
TS
AA
DTIP
RW
5
54
44
90
128
38
43
58
59
SPAREOUT
SPAREIN
VA9
IOCHRDY
ALE
MEM_WR
MEM_RD
IO_WR
IO_RD
23
123
108
92
98
88
DA1
DA0
TBI
TEA
ATM
75
31
DA1
DA0
DMX2WR
DMX1WR
89
96
71 A0
66 A1
102 A2
53 A3
119 A4
41 A9
27 A20
95 A21
91 A22
40 A29
29 A30
55 A31
R81
1K 1206
10K 1206
OUT
3
1K 1206
44
43
54
55
63
IOSEL
94
A0
A1
A2
A3
A4
A9
A20
A21
A22
A29
A30
A31
22K 1206
1
11
NC
13
18
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
B6
B7
B0
B1
B2
B3
B4
B5
B0
B1
B2
B3
B4
B5
B6
B7
74HC245
IC9
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
74HC245
IC10
NC
NC
NC
1
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
R26
R25
R24
R23
R22
R21
R20
R19
Vdd
SQW
PS
MOT
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
IRQ
OSC2
OSC1
GND
CLKOUT
CLKFS
0
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
VCC
15
25
24
ACK
INT
A2
A1
A0
RW
RESET
IO
SPARE
A10
A9
A8
A7
A6
A5
A4
A3
A12
A11
A18
A17
A16
A15
A14
A13
LAMPCLK
C25
8
A
B
C
D
1
Error : F:\PUBLIC\JANDS.EPS image file not supported.
C26
22pF 1206
10pF 1206
C12
470K 1206
4M7 1206
R32
X1
32.768KHz
4M7 1206
R33
Card Bus
-12
DS
ALEH
+5
D6
D5
GND
D2
D1
GND
C116
10NF 1206
C117
10NF 1206
C118
10NF 1206
C119
10NF 1206
R34
1K 1206
R8
10nF 1206
R94
+12
ALEL
+5
RW
D7
GND
D4
D3
GND
D0
+12
R93
R92
-12
220R 1206
220R 1206
220R 1206
R91
VCC
D0
GND
D3
D4
GND
D7
RW
GND
IO
A18
GND
A15
A14
+5
A11
A10
GND
A7
A6
GND
A3
A2
+12
ACK
GND
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
C108
C109
C110
C111
C112
C113
C114
C115
Expansion
Bus
50WAYIDC
GND
D1
D2
GND
D5
D6
GND
REset
SPARE
GND
A17
A16
+5
A13
A12
GND
A9
A8
GND
A5
A4
-12
A1
A0
INT
CONN2
220R 1206
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Sydney Australia
Ph (02) 9582-0909
Time: 11:20:54 Sheet 1 of 4
23
4
3
R126
8
D0
D1
D2
D3
D4
D5
D6
D7
220R 1206
1206
220R 1206 220R
220R 1206
220R 1206 220R
220R 1206 220R 1206
1206
R83
R84
R85
R86
R87
R88
R89
R90
20WAYIDC
RW
-12
+12
DS
ALE
MUX
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
48
49
44
45
47
14
15
18
17
32
33
35
36
38
39
41
42
20
21
23
24
26
27
29
30
2
3
5
6
8
9
11
12
CONN1
14
19
20
17
15
18
2
3
5
6
8
9
11
12
13
16
1
4
7
10
1K 1206
tp3
27
26
2
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
EXPINTIN
DIR
E
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A6
A7
A0
A1
A2
A3
A4
A5
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
Date: 1-Oct-1999
Revision:
28
A
B
C
9
5
1
6
2
7
3
8
4
5PINDIN
1
2
3
4
5
CONN18
5PINDIN
1
2
3
4
5
Bead
Bead
P2 KU3H VCC
B5
1
B6
Bead
VCC
R38
R41
PolySwitch
B12
Bead
220R 1206
220R 1206
Bead
B11
8
R113 VCC
220R 1206
R115
220R 1206
R114 VCC
220R 1206
8
13
6
10
R112
Bead
B9
Bead
B8
MC1488
VCC
74HC14
9
-12
+12
74HC14
IC35C
6
9
1
VCC
IC35D
MC1488
10
11
MC1489
IC47C
R37
4
5
IC44D
MC1488
IC47B
8
14
2
1
6
MC1489
IC44B
3
MC1489
IC44A
IC47A
IC44C
3
4
MC1489
B10
CONN17
100nF 1206
C165
5PINDIN
1
2
3
4
5
B7
Bead
CONN16
5PINDIN
1
2
3
4
5
CONN15
Serial
RS232
DB9
CONN14
1
2
5
9
74HC14
IC35A
VCC
IC52
H11N1
2
BAV103
D2
5
R42
R57
3
74HC14
IC35B
1nF 1206
1nF 1206
4
2
C134
C157
1nF 1206
VCC
74HC14
10
100
86
87
88
89
90
91
92
93
94
95
96
97
98
99
81
82
83
84
85
IOCHRD
DTR2
DRV2
Vss
MTR2
DS3
VIO
MTR3
RI2
DCD2
RXD2
TXD2
DSR2
RTS2
CTS2
RTS1
CTS1
DTR1
RI1
DCD1
1nF 1206
C160
1nF 1206
1
2
12
1nF 1206
1nF 1206
C161
47R 1206
R170
VCC
78
77
76
75
74
73
72
71
70
69
3
4
5
6
7
8
9
10
11
12
1nF 1206
C158
C159
1nF 1206
C162
C163
C164
80
79
14
15
16
17
18
19
IOCHRDY
CONN5
PRINTER
68
67
66
65
64
DSR1
TXD1
RXD1
STROBE
AUTOFD
ERROR
INIT
SLCTIN
Vcc
PD0
PD1
PD2
PD3
Vss
PD4
DENSEL
MTR0
DS1
DS0
MTR1
Vss
DIR
STEP
WDATA
WGATE
HDSEL
INDEX
TRK0
WRTPRT
Vcc
3
CLK24M
FDD
34WAYIDC
CONN6
13
14
15
16
17
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
DB25
61
60
59
58
57
VCC
20
21
22
23
24
D
6
1
Out
MIDI Thru
In
KEYBOARD
4
3
47R 1206
220R 1206
11
12
13
20
21
22
23
24
25
1
2
3
4
5
6
7
8
9
10
63
62
18
19
47R 1206
47R 1206
47R 1206
D31
D30
D29
D28
56
55
54
53
52
47R 1206
D2
D1
D0
Vss
AEN
47R 1206
5X2MM
CONN19
IOWR
IORD
MIDIINT
RS232INT
31
45
44
43
42
41
40
39
38
37
36
35
34
33
32
50
49
48
47
46
D26
D25
D24
IC48
B3
Bead
Bead
B2
Bead
1K 1206
1K 1206
1K 1206
1K 1206
1K 1206
A6
A5
A4
A3
A9
A8
A7
B4
5
4
3
2
1
Bead
B1
R52
R53
R54
R55
R56
VCC
1K 1206
RSTDRV
47R 1206
37C665IR
A3
PSPIRQ
SSPIRQ
DACK
TC
A6
A5
A4
IOW
IOR
A9
A8
A7
FINTR
PINTR
R111
25
26
27
28
PD5
PD6
PD7
ACK
BUSY
PE
SLCT
47R 1206
D27
51
GAMECS
RESET
D7
D6
D5
D4
FDRQ
D3
IDEENL
IDEENH
HDCS0
HDCS1
IOCS16
A0
A1
A2
47R 1206
R47
R46
11
4
TH4
C870
C870
SA12CA
TH3
MOV3
SA12CA
SA12CA
MOV4
MOV1
SA12CA
C870
C870
MOV2
TH2
TH1
R44 R45
10K 1206
6
7
7
6
75176
IC50
75176
IC51
10R 1206
R60
3
OUT
VCC
DMX1WR
DMX2WR
4
1
2
3
3
2
1
4
24MHz
OSC1
1UF SMD
C28
VCC
1UF SMD
C29
VCC
5
5
A0
2
8
9
23
3
D24 7
D25 6
D26 5
D27 4
D2831
D2930
D3029
D3128
2
9
23
8
3
D24 7
D25 6
D26 5
D27 4
D2831
D2930
D3029
D3128
W
FF
HF
XI
D3
D4
D5
D6
D7
D2
D3
D0
D1
W
XI
FF
HF
D5
D6
D7
D0
D1
D2
D3
D3
D4
VCC
32
GND
16
RS
FL
EF
R
Q4
Q5
Q6
Q7
Q8
Q2
Q3
Q0
Q1
IC38
7202
VCC
32
GND
16
7202
RS
R
FL
EF
Q6
Q7
Q8
Q0
Q1
Q2
Q3
Q4
Q5
IC39
70
62
106
45
128
18
26
24
25
39
69
12
108
23
90
13
27
11
88
40
10
11
13
14
19
20
21
22
15
91
28
63
103
98
25
60
61
127
21
22
15
18
119
121
19
20
26
24
68
87
10
126
13
14
1K 1206
R108
DMXFULL
DMX2O
DMX_Reset
DMX2RD
DMX2RESET
DMX2EMPTY
F26
F27
F28
F20
F21
F22
F23
F24
F25
DMX1FULL
DMX1O
RES
DMX1RESET
DMX1EMPTY
DMX1RD
F14
F15
F16
F17
F18
F12
F13
F10
F11
2096
IC53
1k 1206
R48
10
11
VCC
EXPINTIN
EXPINTOUT
DMXINT
KEYINT
6
6
GND
1
17
33
49
65
81
97
112
VCC
16
48
82
113
AUX POWER
CONN9
4X.156
Backlite
80
1
2
3
4
35
IOSEL
D25
D26
D24
A0
A1
A2
A3
LAMPCLK
P3
-12
VPP
SDI
SDO
INTEN
ISPEN
LCDON
SPAREIN
SPAREOUT
DISPOFF
NMI
SCLK
MODE
D27
D28
D29
D30
D31
EnaVEE
VEE
Sys_Reset
D24
D25
D26
D27
D28
D29
D30
D31
1
2
3
8X.156
8
7
6
5
4
3
2
1
3X.156
CONN7
38
20
50
3
66
41
21
8
54
78
46
18
26
59
86
85
25
123
125
6
24
36
99
95A2
4 A3
93A0
2 A1
CONN8
RUE090
VCC
+12
+12
MEMCLK
RESET
4
10K 1206
R123
R122
R121
R79
R77
R49
A0 29
A1 30
A2
RDATA
DSKCHG
DRATE1
DRATE2
X1
X2
IDED7
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29
31
33
4
Vcc
57
RLED
3
1
LAMPCLK
A(0..31)
R/W
D(0..31)
1K 1206
5
2
1K 1206
GND
2
17
1
17
1
12
27
12
27
117
89
107
43
KEYINT
INT1
EXPINTOUT
EXPINTIN
KEYB_CLK
KEYB_DATA
15
29
53
IO
LAMP
102
44
83
GLED
PINTR
55
RW
BACKLITE
RESET
105
19
IC35E
5
5
File:
Size:
10K 1206
R43
A2
Number: COLDCPU5.SC2
7
C10
BAV103
D4
BAV103
D3
Date: 1-Oct-1999
Revision:
0
100nF 1206
47R 1206
R51
Echelon CPU Card
BCX19
Q5
H:\LAB\ECHELON\CIRCUIT\COLDCPU5.SC2
+12
-12
SDI
SDO
INTEN
ISPEN
Title
VCC
VCC
EnaVEE
VEE
Sys_Reset
LCDON
SPAREIN
SPAREOUT
DISPOFF
NMI
SCLK
MODE
7
R40
2
220R 1206
1
8
8
P1
Time: 11:28:08
8
+12
8
RUE090
A
B
C
D
Error : F:\PUBLIC\JANDS.EPS image fi
VCC
1K 1206
R110
LED RED
L6
PolySwitch
Sheet 2 of 4
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
TIP42
Q7
C20
0.47R 5W
R39
10uF SMD
A
B
C
BAR43C
D7
1N5817
D7A
1
D5
D4
D3
D2
D1
D0
D7
D6
A6
A5
A4
A3
A2
A1
A0
-22V
10uF SMD
C21
Q3A
BC558
14WAYIDC
CONN10
D3114
D3015
D2916
D2817
D2718
D2619
D2520
D2421
A8
A7
A6
A5
A4
A3
A2
A1
A0
VCC
62
61
60
59
64
52
65
53
32
31
30
29
28
27
26
25
24
23
A13
A12
A11
A10
A9
A8
A7
F3
-12
BEAD BEAD
F4
+12
F2
BEAD
RW
-12
+12
DS
ALE
MUX
20WAYIDC
CONN4
14
19
20
17
15
18
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
R120
GND
DLOW
DHI
CS
F1
BEAD
V+
R106 150R 1206
R105 150R 1206
R104 150R 1206
4
3
2
1
VCC
2
150R 1206
150R 1206
150R 1206
150R 1206
150R 1206
150R 1206
150R 1206
150R 1206
1M 1206
FB
CTRL
ADJ
R118
R95
R96
R97
R98
R99
R100
R101
R102
C106
10pF 1206
470K 1206
R119
5
6
7
EnaVEE
MA4
MA3
MA2
MA1
MA0
D10
MA7
MA6
MA5
WE
D15
D14
D13
D12
D11
MA8
CASL
RAS
CASH
MD13
MD14
MD15
MD5
MD6
MD7
MD8
MD9
MD10
MD11
MD12
MD3
MD4
IC55 MAX749
R103 150R 1206
1K 1206
R61
R128
1R
220K 1206
2
3
5
6
8
9
11
12
13
16
1
4
7
10
47uH
IND1
VCC
T1p
BCX17
Q3
R107
1R
8
50
55
56
57
58
11
12
51
1
2
3
4
5
6
7
8
9
10
11
12
13
14
A1336
A1235
A1134
A1033
A19
A18
A17
A16
A15
A14
VCC
13
38
63
88
GND
4
22
54
79
97
49
46
99
ACTIND
AEN
RESET
1
2
47
48
IORD
IOWR
MEMR
MEMW
3
100
98
44
45
C131
43
A1842
A1741
A1640
A1539
A1437
C130
GND
Vo
Vee
Vss
Vdd
CP
LP
M
FLM
DISP
D0
D1
D2
D3
MD0
MD1
MD2
10NF 1206
LA19
LA9
C127
C129
UD7
UD6
UD5
UD4
SHCLK
LP
ACDCLK
FLM
ENAVDD
UD0
UD1
UD2
UD3
D9
D8
ENAVEE
65510
LMA8
LMA7
LMA6
LMA5
74 LMA4
75 LMA3
76 LMA2
77 LMA1
78 LMA0
C132
10uF
10K 1206
R16
10K 1206
R50
10
71
72
73
67
66
68
69
5
6
7
8
9
70
82
81
80
91
90
89
87
86
85
84
83
93
92
96
95
94
10NF 1206
10NF 1206
IC67
C11
10K 1206
R15
100nF 1206
D10
BAV103
DISPOFF
C125
VCC
10NF 1206
100pF 1206
C124
C133
10NF 1206
100R 1206
VEE
BAV103
D11
10NF 1206
R109
C122
D
10NF 1206
IORD
ISPEN
C121
D(0..31)
IOCHRDY
IOWR
10NF 1206
A(0..31)
C126
C128
13
3
3
74HC14
IC35F
12
4
17
5
16
3
18
19
1
2
5
16
3
4
17
1
2
18
19
16
3
17
5
4
1
2
18
19
3
5
16
4
17
18
19
1
2
OE
WE
RAS
CAS
D0
D1
D2
D3
IC64
OE
WE
RAS
CAS
D0
D1
D2
D3
IC63
OE
WE
CAS
RAS
D0
D1
D2
D3
IC62
WE
OE
A0
A1
A2
A3
A4
A5
A6
A7
A8
414256
A7
A8
A0
A1
A2
A3
A4
A5
A6
414256
A6
A7
A8
A0
A1
A2
A3
A4
A5
414256
A2
A3
A4
A5
A6
A7
A8
D2
D3
RAS
CAS
A0
A1
414256
D0
D1
IC61
6
7
8
9
11
12
13
14
15
14
15
6
7
8
9
11
12
13
13
14
15
6
7
8
9
11
12
11
12
13
14
15
8
9
6
7
VCC
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
VCC
C40
100nF 1206
VCC
VCC
VCC
VCC
VCC
10uF SMD
C23
1uF SMD
C32
4
VCC
R65
VCC
47R 1206
R59
VCC
VCC
-12
C16
VCC
47R 1206
R71
VCC
100nF 1206
C15
100nF 1206
VCC
VCC
VCC
R72
VCC
47R 1206
VCC
VCC
VCC
D8
VCC
VCC
C18
C33
100nF 1206
1uF SMD
P0
VSS4
GREEN
RED
IREF
HSYNC
AVSS2
OVRW
AVDD2
EED1
EECS
BLUE
SD6
SD7
AVSS1
VFILTR
AVDD1
TWR
VSYNC
SD0
SD1
SD2
SD3
VDD3
SD4
SD5
VSS5
IRQ
VSS4
SA16
AEN
IOCHRD
REFRESH
IOR
IOW
0WS
SA14
SA15
RESET
SA13
BAV103
VCC
VCC
VCC
VCC
100nF 1206
C17
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
Video
CONN11
VGACONN
VCC
VCC
VCC
VCC
VCC
4
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
1R
R74
VCC
6
VCC
VCC
VCC
5
10R 1206
R76
1
LM334
IC56
79
80
76
77
78
62
63
64
65
66
67
68
69
70
71
72
73
74
75
D30
D31
D28
D29
54
55
56
57
58
59
60
61
D24
D25
D26
D27
52
53
47
48
49
50
51
46
A1342
A1443
A1544
A1645
6
VCC
1R
R73
150R 1206
R66
150R 1206
VA9
41
5
C60
100nF 1206
2
10NF 1206
10NF 1206
C41
100nF 1206
C61
100nF 1206
C50
100nF 1206
C42
100nF 1206
C62
100nF 1206
C51
100nF 1206
C43
100nF 1206
C63
100nF 1206
C52
100nF 1206
C44
100nF 1206
C64
100nF 1206
C53
100nF 1206
C45
100nF 1206
C65
100nF 1206
C54
100nF 1206
C46
100nF 1206
C66
100nF 1206
C55
100nF 1206
C67
100nF 1206
C56
100nF 1206
C47
100nF 1206
C68
100nF 1206
C57
100nF 1206
C48
100nF 1206
3
2
RDY
CLKIN
STBY
BHE
RFSH
10NF 1206
1
C24
ALE
MEMWR
MEMRD
RSTDRV
R68
150R 1206
C69
100nF 1206
C58
100nF 1206
C49
100nF 1206
10uF SMD
C90
100nF 1206
C59
100nF 1206
C70
100nF 1206
R70
C71
100nF 1206
C91
100nF 1206
C80
100nF 1206
150R 1206
R69
150R 1206
C92
100nF 1206
C81
100nF 1206
C36
10pF 1206
C72
100nF 1206
C93
100nF 1206
C82
100nF 1206
R75
A12
A11
A10
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
C38
10pF 1206
C74
100nF 1206
C37
10pF 1206
C73
100nF 1206
MD31 97
MD30 98
MD29 99
MD28100
C35
220pF 1206
C94
100nF 1206
C83
100nF 1206
106
107
C95
100nF 1206
C84
100nF 1206
10R 1206
A8
A7
A6
A5
A4
A3
A2
A1
A0
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
101
C34
220pF 1206
C75
100nF 1206
R67
150R 1206
A19
A18
A17
MD27102
MD26103
MD25104
MD24105
C76
100nF 1206
11
10
C96
100nF 1206
C85
100nF 1206
C77
100nF 1206
C97
100nF 1206
C87
100nF 1206
C78
100nF 1206
C88
100nF 1206
C98
100nF 1206
C86
100nF 1206
9
MD12
VDD6
MD9
MD10
MD11
MD4
MD5
MD6
MD7
VSS10
WE1
MD8
CAS
WE0
VSS11
MD0
MD1
MD2
MD3
MA6
MA7
MA8
VSS12
MA9
RAS
OE
VDD7
MA4
MA5
AVSS4
MFILTR
AVDD4
MA0
MA1
MA2
MA3
XTAL
MCLK
VSS13
OSC
GD5429
IC65
VCC
VSS2
19
18
17
16
15
14
13
12
VSS3
SA12
SA11
SA10
SA9
SA8
SA7
SA6
SA5
SA4
SA3
SA2
SA1
SA0
VDD2
BALE
SHBE
MCS16
IOCS16
LA23
LA22
LA21
LA20
LA19
LA18
LA17
MEMR
MEMW
VDD4
P1
P2
P3
AVDD3
P4
P5
P6
P7
AVSSS3
VSS7
DCLK
BLANK
EVIDEO
ESYNC
EDCLK
MD31
MD30
MD29
MD28
VSS8
MD27
MD26
MD25
MD24
WE3
VDD5
MD23
7
MD22
8
SD8
SD9
MD21
MD20
6
5
SD10
SD11
MD23108
MD22109
MD21110
MD20111
MD19112
MD18113
MD17114
MD19
MD18
4
3
VSS1
MD17
2
SD12
MD16
MD16115
116
SD13
1
VDD1
SD14
SD15
EROM
WE2
119
MD15
MD14
MD13
120
VSS9
117
118
C79
100nF 1206
C89
100nF 1206
C99
100nF 1206
160
159
VCC
122
121
125
124
123
139
138
137
136
135
134
133
132
131
130
129
128
127
126
147
146
145
144
143
142
141
140
149
148
154
153
152
151
150
156
155
158
157
VCC
VCC
VCC
100nF 1206
C13
100nF 1206
C14
R58 47R 1206
VCC
VCC
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
IC60
414256
A8
A1
A2
A3
A4
A5
A6
A7
A0
IC59
414256
A2
A3
A4
A5
A6
A7
A8
A0
A1
IC58
414256
A6
A7
A8
A4
A5
A0
A1
A2
A3
IC57
VCC
OE
WE
RAS
CAS
D0
D1
D2
D3
OE
WE
RAS
CAS
D1
D2
D3
D0
OE
WE
RAS
CAS
D2
D3
D0
D1
OE
WE
CAS
RAS
D0
D1
D2
D3
VCC
5
16
3
4
17
1
2
18
19
16
3
4
17
5
1
2
18
19
4
17
5
16
3
18
19
1
2
16
3
17
5
4
1
2
18
19
File:
Size:
Title
Number: COLDCPU5.SC3
7
H:\LAB\ECHELON\CIRCUIT\COLDCPU5.SC3
A2
Echelon CPU Card
+12
0
VCC
1
2
8
Sheet 3 of 4
GND
Vcc
14.31818MHz
IC66
4
VCC
A
B
C
D
Error : F:\PUBLIC\JANDS.EPS image fi
150R 1206
R62
8
C144
220uF
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
C145
10uF SMD
-12
Time: 11:29:46
C153
10uF SMD
Date: 1-Oct-1999
Revision:
C147
C150
10uF SMD 10uF SMD
+12
-12
+12
+12
-12
+12
VCC
MD28
MD29
MD30
MD31
MD24
MD25
MD26
MD27
MD20
MD21
MD22
MD23
MD16
MD17
MD18
MD19
1uF SMD
C31
VCC
-12
MA06
MA17
MA28
MA39
MA4
11
MA5
12
MA6
13
MA7
14
MA8
15
MA06
MA17
MA28
MA39
MA4
11
MA5
12
MA6
13
MA7
14
MA8
15
MA06
MA17
MA28
MA39
MA4
11
MA5
12
MA6
13
MA7
14
MA8
15
MA06
MA17
MA28
MA39
MA4
11
12
MA5
MA6
13
MA7
14
MA8
15
R64 150R 1206
150R 1206
R63
10uF SMD
C22
VCC
MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
7
VCC
C100
100nF 1206
C139
100nF 1206
C101
100nF 1206
C140
100nF 1206
C102
100nF 1206
C141
100nF 1206
C103
100nF 1206
C142
100nF 1206
C104
100nF 1206
C27
100nF 1206
C105
100nF 1206
C151
100nF 1206
C149
100nF 1206
C148
100nF 1206
C154
100nF 1206
C152
100nF 1206
C143
100nF 1206
C146
100nF 1206
OUT
3
10NF 1206
C120
C123
Appendix E
Circuit Diagrams and Overlays
E-4
COLDCPU6 Circuit diagrams and overlay
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
D
24
22
OE
1
CE/PGM
O4
O5
O6
O7
O0
O1
O2
O3
1
32
A0
A1
A2
A3
VCC
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
VPP
VCC
IC25
27020
D24 13
D25 14
D26 15
D27 17
D28 18
D29 19
D30 20
D31 21
GND
16
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
LED GREEN
L1
1K 1206
R2
12
11
10
9
8
7
6
5
27
26
23
25
4
28
29
3
2
30
31
D0
D1
D2
D3
D4
D5
D6
D7
D8
D9
D10
D11
D12
D13
D14
D15
D16
D17
D18
D19
D20
D21
D22
D23
D24
D25
D26
D27
D28
D29
D30
D31
1
22
24
31
13
14
15
17
18
19
20
21
1
22
24
31
13
14
15
17
18
19
20
21
1
22
24
31
13
14
15
17
18
19
20
21
1
22
24
31
13
14
15
17
18
19
20
21
D24
D25
D26
D27
D28
D29
D30
D31
2
3
4
5
6
7
8
9
1
11
28020
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC11
28020
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC12
28020
Vpp
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC14
28020
Vpp
CE
OE
WE
D4
D5
D6
D7
D0
D1
D2
D3
IC13
12
11
10
9
8
7
6
5
27
26
23
25
4
28
29
3
2
30
12
11
10
9
8
7
6
5
27
26
23
25
4
28
29
3
2
30
12
11
10
9
8
7
6
5
27
26
23
25
4
28
29
3
2
30
1D
2D
3D
4D
5D
6D
7D
8D
OC
CLK
IC68 74HC574
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A0
A1
A2
A3
12
11
10
9
8
7
6
5
27
26
23
25
4
28
29
3
2
30
2
1Q
2Q
3Q
4Q
5Q
6Q
7Q
8Q
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
19
18
17
16
15
14
13
12
L4
LED GREEN
L5
LED RED
A(0..31)
D0
D1
D2
D3
D4
D5
D6
D7
D8
D9
D10
D11
D12
D13
D14
D15
D16
D17
D18
D19
D20
D21
D22
D23
D24
D25
D26
D27
D28
D29
D30
D31
4k7 1206
R130
10K 1206
R129
BAV103
D9
32
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
IC1762040
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
IC1862040
1K 1206
1K 1206
R36
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
CE
OE
WE
D5
D6
D7
D0
D1
D2
D3
D4
R35
22
24
29
13
14
15
17
18
19
20
21
22
24
29
13
14
15
17
18
19
20
21
22
24
29
13
14
15
17
18
19
20
21
22
24
29
13
14
15
17
18
19
20
21
IC16
62040
GND
16
GND
VSS
32
VSS
32
VSS
32
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
D0
D1
D2
D3
D4
D5
D6
D7
D8
D9
D10
D11
D12
D13
D14
D15
22
24
29
13
14
15
17
18
19
20
21
22
24
29
13
14
15
17
18
19
20
21
22
24
29
13
14
15
17
18
19
20
21
22
24
29
13
14
15
17
18
19
20
21
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC22
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
IC21
CE
OE
WE
D0
D1
D2
D3
D4
D5
D6
D7
CE
OE
WE
D5
D6
D7
D0
D1
D2
D3
D4
62040
IC20 62040
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
62040
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
62040
IC23
A0
A1
A2
A3
A4
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
Backlite
10K 1206
VCC
LCDON
Sys_Reset
3
BAV103
D5
R13
LED RED
L2
10K 1206
1. Set VR2 fully CCW
2. Short J1
3. Start Console
4. Adjust VR2 until L3 lights
5. Remove J1 short
RESET
10K 1206
SDO
SDI
LINK
REBOOT
LED RED
L3
1K 1206
1K 1206
R14
R7
VCC
8X.1
100nF 1206
C1
12
13
14
15
16
17
18
19
A7
A6
A5
A4
A3
A2
A1
A0
4
VCC
12
13
14
15
16
17
18
19
12
13
14
15
16
17
18
19
A23
A22
A21
A20
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
12
13
14
15
16
17
18
19
4
A31
A30
A29
A28
A27
A26
A25
A24
CONN3
ISP port
R5
VCC
C7 C8 C9
C135 C136 C137 C138 C6
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
100nF 1206
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
A20
D16
D17
D18
D19
D20
D21
D22
D23
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
D24
D25
D26
D27
D28
D29
D30
D31
SRAMPOWR
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
3
12
11
10
9
8
7
6
5
27
26
23
25
4
28
3
31
2
30
1
R131
SRAMPOWR
62040
IC19
VSS
16
GND
16
GND
16
32
VSS
32
VSS
32
VSS
32
VSS
16
15
11
10
12
13
RES
/RES
WDI
PFO
CEO
CEI
VOUT
MAX693
Q2
BCX17
ISPEN
MODE
SCLK
D(0..31)
A(0..31)
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
CLK
OC
4D
3D
2D
1D
8D
7D
6D
5D
74HC574
IC15
2
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC8
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC30
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC6
4Q
3Q
2Q
1Q
8Q
7Q
6Q
5Q
IC7
RAM2RD
RAM2W0
RAM2W1
RAM2W2
RAM2W3
RAM2SIZ
RAM1SIZ
SCLK
MODE
SDO
SDI
ISPEN
OSC1
OSC2
WDO
LOW
VBATT
PFI
AD7
AD6
AD5
AD4
AD3
AD2
AD1
AD0
AD15
AD14
AD13
AD12
AD11
AD10
AD9
AD8
AD23
AD22
AD21
AD20
AD19
AD18
AD17
AD16
AD31
AD30
AD29
AD28
AD27
AD26
AD25
AD24
11
12
13
14
15
16
17
18
11
12
13
14
15
16
17
18
11
12
13
14
15
16
17
18
11
12
13
14
15
16
17
18
1K TRIM
VR2
1M 1206
R18
10K 1206
R28
C155
100nF 1206
7
8
14
6
1
9
2K2 1206
R78
2096
IC33
106
74
69
68
67
36
24
78
46
50
20
18
D24
D25
D26
D27
AD7
AD6
AD5
AD4
AD3
AD2
AD1
AD0
AD15
AD14
AD13
AD12
AD11
AD10
AD9
AD8
AD23
AD22
AD21
AD20
AD19
AD18
AD17
AD16
AD31
AD30
AD29
AD28
AD27
AD26
AD25
AD24
12
11
122
6
VCC
D24
D25
D26
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
11
1
9
8
7
6
5
4
3
2
70
ACLK
VCC
TP1
B7
B6
B5
B4
B3
B2
B1
B0
IC2
B7
B6
B5
B4
B3
B2
B1
B0
IC3
B7
B6
B5
B4
B3
B2
B1
B0
IC4
B3
B2
B1
B0
B7
B6
B5
B4
IC5
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
A7
A6
A5
A4
A3
A2
A1
A0
DIR
E
74HC245
A3
A2
A1
A0
A7
A6
A5
A4
DIR
E
74HC245
4K7 1206
R29
22K 1206
R80
VCC
16
48
82
113
RAM1RD
RAM1W0
RAM1W1
RAM1W2
RAM1W3
103
60
100
62
99
22K 1206
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
1
19
9
8
7
6
5
4
3
2
1
19
5
GND
1
17
33
49
65
81
97
112
FLASHRD
FLASHW0
FLASHW1
FLASHW2
FLASHW3
D15
D14
D13
D12
D11
D10
D9
D8
D23
D22
D21
D20
D19
D18
D17
D16
D31
D30
D29
D28
D27
D26
D25
D24
5
D7
D6
D5
D4
D3
D2
D1
D0
JH2MAIN
LA9
LA19
3V
BAT1
1K 1206
R1
LINK
J1
47K 1206
R30
35
61
101
63
34
AD0 89
AD1 90
AD2 91
AD3 92
AD4 95
AD5 96
AD6 97
AD7 98
AD8 1
AD9 2
AD10 3
AD11 4
AD12 5
AD13 8
AD14 9
AD1510
AD1611
AD1714
AD1815
AD1916
AD2017
AD2120
AD2221
AD2322
AD2423
AD2526
AD2627
AD2728
AD2829
AD2930
AD3033
AD3134
15
BAV103
D6
MEMCLK
A0
A1
A2
A3
A4
A9
A20
A21
A22
A29
A30
A31
71
66
102
53
119
41
27
95
91
40
29
55
BOOTROM
25
21
45
LA19
LA9
VCC
MiscIO
RESET
S4
S3
S2
S1
121
19
56
118
39
13
A/D0
A/D1
A/D2
A/D3
A/D4
A/D5
A/D6
A/D7
A/D8
A/D9
A/D10
A/D11
A/D12
A/D13
A/D14
A/D15
A/D16
A/D17
A/D18
A/D19
A/D20
A/D21
A/D22
A/D23
A/D24
A/D25
A/D26
A/D27
A/D28
A/D29
A/D30
A/D31
MCF5202
IC1
GND
6
12
18
24
31
37
45
52
61
68
79
86
93
99
SIZ1
SIZ0
TS
AA
DTIP
R/W
42
41
40
48
47
39
23
123
108
92
98
88
SIZ1
SIZ0
TS
AA
DTIP
RW
SPAREOUT
SPAREIN
VA9
IOCHRDY
ALE
MEM_WR
MEM_RD
IO_WR
IO_RD
NMI
5
54
44
90
128
38
43
58
59
VCC
7
13
19
25
32
38
46
53
60
69
80
88
94
100
VCC
VCC
VA9
DIPSW
CARDBUF
CARDMUX
CARDAL
CARDDS
CARDRW
RTCADD
RTCDATA
IPL2
IPL1
IPL0
EXPINT
INT6
INT7
INTEN
INT5
INT1
MIDIINT
RS232INT
EXPACK
EXPSEL
CPUCLK
BD
BG
BR
IPL0
IPL1
IPL2
AVEC
TT0
TT1
PST3
PST2
PST1
PST0
CLK
RST
HIZ
TIE LOW
TCK
TMS/BKMT
TDI/DSI
TDO/DSO
TRST/D
MTMOD0
MTMOD1
MTMOD2
SW-DIP8
SW1
6
16
15
14
13
12
11
10
9
4
87
107
104
10
3
105
117
126
127
2
125
86
124
9
52
26
85
22
30
42
83
49
51
50
64
65
66
62
35
36
59
58
57
56
87
67
75
85
74
73
72
71
70
76
77
78
81
82
83
84
1K 1206
IOSEL
DMX1WR
DMX2WR
IORD
IOWR
MEMRD
MEMWR
ALE
IOCHRDY
SPAREOUT
SPAREIN
1
2
3
4
5
6
7
8
6
R4
DDATA0
DDATA1
DDATA2
DDATA3
DA1
DA0
TBI
TEA
ATM
75
31
DA1
DA0
DMX2WR
DMX1WR
89
96
VCC
1K 1206
R11
1K 1206
R10
VCC
INTEN
KEYINT
DMXINT
MIDIINT
RS232INT
EXPINTOUT
VCC
20
22
24
26
19
21
23
25
18
17
16
15
14
13
12
11
B0
B1
B2
B3
B4
B5
B6
B7
IC24
R82
VCC
VCC
10K 1206
R124
IDC26
2
4
6
8
10
12
14
16
18
1
3
5
7
9
11
13
15
17
CONN13
Interface
R127
10K 1206
BDM
19
1
2
3
4
5
6
7
8
9
D24
D25
D26
D27
D28
D29
D30
D31
10K 1206
File:
Number:
R27
D7
7
D24
D25
D26
D27
D28
D29
D30
D31
R/W
RESET
VCC
D24
D25
D26
D27
D28
D29
D30
D31
74HC245
IC26
A2
A1
A0
74HC245
IC28
A10
A9
A8
A7
A6
A5
A4
A3
74HC245
IC29
A18
A17
A16
A15
A14
A13
A12
A11
74HC245
IC27
CS
AS
DS
COLDCPU6.SC1
15
18
13
14
17
DS12885S
D24 4
D0
D25 5
D26 6 D1
D27 7 D2
D3
D28 8
D29 9 D4
D5
D30 10
D31 11 D6
IC31
R31
H:\Lab\ECHELON\CIRCUIT\COLDCPU6.SC1.sch
Size: A2
1
2
10R 1206
R3
VCC
7
GND
Echelon CPU card
Title
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
R/W
CLK24M
Vcc
VCC
4
R116
VCC
24MHz
IC32
3
10R 1206
2
3
VCC
5
BAT-ON
GND
4
1K 1206
R125
OUT
10K 1206
1K 1206
44
43
54
55
63
IOSEL
94
A0
A1
A2
A3
A4
A9
A20
A21
A22
A29
A30
A31
R81
24
VCC
1
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
10K 1206
R26
R25
R24
R23
R22
R21
R20
R19
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
17
16
15
14
13
12
11
18
22
GND
74HC245
IC9
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
74HC245
IC10
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
3
2
20
23
21
1
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
2
3
5
6
8
9
11
12
13
16
1
4
7
10
C19
10uF SMD
ACK
INT
C26
8
Sheet 1 of 4
R94
R93
R92
R91
+12
ALEL
+5
RW
D7
GND
D4
D3
GND
D0
-12
+12
220R 1206
220R 1206
220R 1206
220R 1206
VCC
Drawn By:
Card Bus
D0
GND
D3
D4
GND
D7
RW
GND
IO
A18
GND
A15
A14
+5
A11
A10
GND
A7
A6
GND
A3
A2
+12
ACK
GND
-12
DS
ALEH
+5
D6
D5
GND
D2
D1
GND
C116
10NF 1206
C117
10NF 1206
C118
10NF 1206
C119
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
10NF 1206
C108
C109
C110
C111
C112
C113
C114
C115
Expansion
Bus
50WAYIDC
GND
D1
D2
GND
D5
D6
GND
REset
SPARE
GND
A17
A16
+5
A13
A12
GND
A9
A8
GND
A5
A4
-12
A1
A0
INT
CONN2
A2
A1
A0
RW
RESET
IO
SPARE
A10
A9
A8
A7
A6
A5
A4
A3
A18
A17
A16
A15
A14
A13
A12
A11
10pF 1206
32.768KHz
X1
20WAYIDC
RW
-12
+12
DS
ALE
MUX
CONN1
14
19
20
17
15
18
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
VCC
100nF 1206
C107
IRQ
OSC2
OSC1
VBAT
SQW
RCLR
MOT
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
8
D0
D1
D2
D3
D4
D5
D6
D7
220R 1206
1206
220R 1206 220R
220R 1206
220R 1206 220R
220R 1206 220R 1206
1206
R83
R84
R85
R86
R87
R88
R89
R90
48
49
44
45
47
14
15
18
17
32
33
35
36
38
39
41
42
20
21
23
24
26
27
29
30
3
5
6
8
9
11
12
3
4
5
6
7
8
9
19
1
2
2
EXPINTIN
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
Date: 11-Apr-2000 Time: 10:36:53
Revision: 0
16
GND
12
A
B
C
D
A
B
C
7
3
8
4
9
5
1
6
2
1
2
3
4
5
B7
Bead
B8
Bead
1
2
3
4
5
Bead
B10
Bead
B9
4
5
4
5
1
2
3
4
5
KEYBOARD
5PINDIN 5x2mm
1
2
3
4
5
1
B6
Bead
PolySwitch
8
R38
VCC
R41
9
R37
VCC
9
VCC
74HC14
IC35D
MC1488
10
11
1
MC1489
IC47C
220R 1206
220R 1206
R112
R113 VCC
R115
220R 1206
4
5
8
14
2
1
IC44D
MC1488
IC47B
R114 VCC
8
13
6
10
220R 1206
Bead
MC1488
6
MC1489
IC44B
3
MC1489
IC44A
IC47A
IC44C
3
4
MC1489
220R 1206
P2 KU3H VCC
B5
Bead
B12
CONN18
CONN18A
5PINDIN 5x2mm
MIDI In
10nF 1206
CONN17 CONN17A
C165 1
1
2
2
B11
Bead
3
3
5PINDIN 5x2mm
MIDI Thru
1
2
3
4
5
CONN16 CONN16A
5PINDIN 5x2mm
MIDI Out
1
2
3
4
5
CONN15 CONN15A
Serial
RS232
DB9
CONN14
2
5
9
VCC
R57
6
74HC14
74HC14
IC35A
2
BAV103
D2
IC52
H11N1
5
IC35C R42
-12
+12
3
74HC14
IC35B
1nF 1206
1nF 1206
1nF 1206
C134
C157
2
1nF 1206
4
1nF 1206
47R 1206
R170
1nF 1206
C164
1nF 1206
C162
C163
RTS1
CTS1
DTR1
RI1
DCD1
RI2
DCD2
RXD2
TXD2
DSR2
RTS2
CTS2
DTR2
DRV2
Vss
MTR2
DS3
VIO
MTR3
IOCHRD
1nF 1206
C159
C158
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
1nF 1206
C160
C161
VCC
VCC
IOCHRDY
CONN5
PRINTER
1
2
3
4
5
6
7
74HC14
DB25
10
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
12
47R 1206
47R 1206
D31
D30
D29
D28
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
3
CLK24M
FDD
34WAYIDC
CONN6
VCC
47R 1206
47R 1206
5X2MM
CONN19
IOWR
IORD
MIDIINT
RS232INT
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
D26
D25
D24
IC48
5
4
3
2
1
B3
Bead
Bead
B2
Bead
1K 1206
1K 1206
1K 1206
1K 1206
1K 1206
A6
A5
A4
A3
A9
A8
A7
B4
Bead
B1
R52
R53
R54
R55
R56
VCC
1K 1206
RSTDRV
47R 1206
37C665IR
D2
D1
D0
Vss
AEN
IOW
IOR
A9
A8
A7
FINTR
PINTR
PSPIRQ
SSPIRQ
DACK
TC
A6
A5
A4
A3
R111
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
1
6
1
47R 1206
29
30
D
4
3
47R 1206
220R 1206
47R 1206
D27
52
51
DSR1
TXD1
RXD1
STROBE
AUTOFD
ERROR
INIT
SLCTIN
Vcc
PD0
PD1
PD2
PD3
Vss
PD4
PD5
PD6
PD7
ACK
BUSY
PE
SLCT
GAMECS
RESET
D7
D6
D5
D4
FDRQ
D3
A0
A1
A2
47R 1206
R47
R46
11
4
TH4
C870
C870
SA12CA
TH3
MOV3
SA12CA
SA12CA
MOV4
MOV1
SA12CA
C870
C870
MOV2
TH2
TH1
R44 R45
10K 1206
RESET
4
10K 1206
R123
R122
R121
R79
R77
R49
DENSEL
MTR0
DS1
DS0
MTR1
Vss
DIR
STEP
WDATA
WGATE
HDSEL
INDEX
TRK0
WRTPRT
Vcc
RDATA
DSKCHG
DRATE1
DRATE2
X1
X2
IDED7
IDEENL
IDEENH
HDCS0
HDCS1
IOCS16
A0
A1
A2
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29
31
33
6
7
75176
IC50
7
6
75176
IC51
10R 1206
R60
3
OUT
VCC
DMX1WR
DMX2WR
4
1
2
3
3
2
1
4
4
Vcc
24MHz
OSC1
1UF SMD
C28
VCC
1UF SMD
C29
VCC
5
5
A0
D24
D25
D26
D27
D28
D29
D30
D31
D24
D25
D26
D27
D28
D29
D30
D31
8
9
23
2
7
6
5
4
31
30
29
28
3
8
9
23
2
7
6
5
4
31
30
29
28
3
XI
FF
HF
W
D0
D1
D2
D3
D3
D4
D5
D6
D7
VCC
32
GND
16
XI
FF
HF
W
D0
D1
D2
D3
D3
D4
D5
D6
D7
R
FL
EF
RS
Q0
Q1
Q2
Q3
Q4
Q5
Q6
Q7
Q8
IC38
7202
VCC
32
GND
16
R
FL
EF
RS
Q0
Q1
Q2
Q3
Q4
Q5
Q6
Q7
Q8
IC39
7202
63
103
98
70
18
26
24
25
62
106
45
128
18
26
24
25
1
2
3
4
CONN9
4X.156
1K 1206
R108
DMXFULL
DMX2O
DMX2RD
DMX2RESET
DMX2EMPTY
DMX_Reset
F20
F21
F22
F23
F24
F25
F26
F27
F28
DMX1FULL
DMX1O
DMX1RD
DMX1RESET
DMX1EMPTY
RES
F10
F11
F12
F13
F14
F15
F16
F17
F18
AUX POWER
39
69
12
108
23
90
13
27
11
88
40
10
11
13
14
19
20
21
22
15
91
28
68
87
10
126
119
121
60
61
127
2096
IC53
1k 1206
R48
10
11
13
14
19
20
21
22
15
VCC
EXPINTIN
EXPINTOUT
DMXINT
KEYINT
6
+12
6
-12
VCC
GND
1
17
33
49
65
81
97
112
53
VCC
16
48
82
113
Backlite
80
MEMCLK
3
1
17
1
17
1
P3
3
4
3
4
8
7
VCC
VCC
+12
-12
SDI
SDO
INTEN
EnaVEE
VEE
Sys_Reset
LCDON
SPAREIN
SPAREOUT
DISPOFF
NMI
SCLK
MODE
ISPEN
File:
Number:
10K 1206
R43
BCX19
Q5
COLDCPU6.SC2
7
7
H:\Lab\ECHELON\CIRCUIT\COLDCPU6.SC2
Size: A2
Echelon CPU Card
Title
8
7
6
5
2
8X0.2screw terminal
1
6
D24
D25
D26
D27
D28
D29
D30
D31
CONN8A
1
2
3
3X.156
2
5
A0
A1
A2
A3
CONN7
38
20
50
3
99
24
36
26
59
86
85
25
123
125
6
66
41
21
8
54
78
46
18
93
2
95
4
1
8X.156
VPP
SDI
SDO
INTEN
RUE090
CONN8
+12
A0
A1
A2
A3
IOSEL
D24
D25
D26
D27
D28
D29
D30
D31
EnaVEE
VEE
Sys_Reset
LCDON
SPAREIN
SPAREOUT
DISPOFF
NMI
SCLK
MODE
ISPEN
LAMPCLK
A(0..31)
R/W
D(0..31)
1K 1206
5
2
1K 1206
GND
2
12
27
12
27
117
89
107
43
KEYINT
INT1
EXPINTOUT
EXPINTIN
KEYB_CLK
KEYB_DATA
15
29
35
BACKLITE
IO
LAMP
102
57
44
83
RLED
GLED
PINTR
55
RW
RESET
105
19
IC35E
R40
2
220R 1206
1
8
5
5
8
C20
P1
+12
8
8
Sheet 2 of 4
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
TIP42
Q7
0.47R 5W
R39
Date: 11-Apr-2000 Time: 10:39:37
Revision: 0
47R 1206
R51
100nF 1206
C10
BAV103
D4
BAV103
D3
10uF SMD
Drawn By:
VCC
1K 1206
R110
LED RED
L6
RUE090
PolySwitch
A
B
C
D
A
B
C
BAR43C
D7
1N5817
D7A
1
14
15
16
17
18
19
20
21
D7
D6
D5
D4
D3
D2
D1
D0
-22V
10uF SMD
C21
Q3A
BC558
14WAYIDC
CONN10
D31
D30
D29
D28
D27
D26
D25
D24
VCC
13
38
63
88
VCC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
F3
-12
BEAD BEAD
F4
+12
F2
BEAD
VCC
R128
1R
14
19
20
17
15
18
2
3
5
6
8
9
11
12
13
16
1
4
7
10
RW
-12
+12
DS
ALE
MUX
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
220K 1206
R120
20WAYIDC
5
6
7
8
EnaVEE
FB
CTRL
R106 150R 1206
R105 150R 1206
R104 150R 1206
2
1
4
3
2
150R 1206
150R 1206
150R 1206
150R 1206
150R 1206
150R 1206
150R 1206
150R 1206
1M 1206
R103 150R 1206
F1
BEAD
V+
ADJ
R118
R95
R96
R97
R98
R99
R100
R101
R102
C106
10pF 1206
470K 1206
GND
DLOW
DHI
CS
VCC
CASL
RAS
CASH
WE
D15
D14
D13
D12
D11
MA8
MA7
MA6
MA5
MA4
MA3
MA2
MA1
MA0
D10
IC55 MAX749
R119
220R 1206
R61
CONN4
47uH
IND1
BCX17
T1p
Q3
R107
1R
GND
Vo
Vee
Vss
Vdd
CP
LP
M
FLM
DISP
D0
D1
D2
D3
A8
A7
A6
A5
A4
A3
A2
A1
A0
GND
4
22
54
79
97
62
61
60
59
64
52
65
53
50
55
56
57
58
11
12
51
UD7
UD6
UD5
UD4
SHCLK
LP
ACDCLK
FLM
ENAVDD
UD0
UD1
UD2
UD3
D9
D8
ENAVEE
A19
A18
A17
A16
A15
A14
A13
A12
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
49
46
99
ACTIND
AEN
RESET
1
2
47
48
IORD
IOWR
MEMR
MEMW
3
100
98
44
45
C131
43
42
41
40
39
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
C130
A18
A17
A16
A15
A14
A13
A12
A11
A10
10NF 1206
LA19
LA9
C127
C129
LMA8
LMA7
LMA6
LMA5
LMA4
LMA3
LMA2
LMA1
LMA0
C132
10uF
100R 1206
R16
10K 1206
R50
67
66
68
69
5
6
7
8
9
70
71
72
73
74
75
76
77
78
10
96
95
94
93
92
91
90
89
87
86
85
84
83
82
81
80
10NF 1206
10NF 1206
MD0
MD1
MD2
MD3
MD4
MD5
MD6
MD7
MD8
MD9
MD10
MD11
MD12
MD13
MD14
MD15
D10
100R1206
R15
100nF 1206
C11
BAV103
DISPOFF
C125
65510
10NF 1206
IC67
C124
VCC
10NF 1206
100pF 1206
C123
100R 1206
VEE
BAV103
D11
10NF 1206
R109
C122
C133
10NF 1206
D
ISPEN
C121
D(0..31)
IOCHRDY
IOWR
IORD
10NF 1206
A(0..31)
C126
C128
3
13
3
74HC14
IC35F
12
4
17
5
16
3
1
2
18
19
4
17
5
16
3
1
2
18
19
4
17
5
16
3
1
2
18
19
4
17
5
16
3
1
2
18
19
OE
WE
RAS
CAS
D0
D1
D2
D3
IC64
OE
WE
RAS
CAS
D0
D1
D2
D3
IC63
OE
WE
RAS
CAS
D0
D1
D2
D3
IC62
OE
WE
RAS
CAS
D0
D1
D2
D3
IC61
A0
A1
A2
A3
A4
A5
A6
A7
A8
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
414256
6
7
8
9
11
12
13
14
15
6
7
8
9
11
12
13
14
15
6
7
8
9
11
12
13
14
15
6
7
8
9
11
12
13
14
15
VCC
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
LMA0
LMA1
LMA2
LMA3
LMA4
LMA5
LMA6
LMA7
LMA8
VCC
C40
100nF 1206
VCC
VCC
VCC
VCC
VCC
10uF SMD
C23
1uF SMD
C32
4
VCC
R65
VCC
47R 1206
R59
VCC
VCC
-12
C16
C15
100nF 1206
VCC
47R 1206
R71
VCC
100nF 1206
VCC
VCC
VCC
R72
VCC
47R 1206
VCC
VCC
VCC
RESET
SA13
SA14
SA15
SA16
AEN
IOCHRD
REFRESH
IOR
IOW
0WS
IRQ
VSS4
SD0
SD1
SD2
SD3
VDD3
SD4
SD5
VSS5
SD6
SD7
AVSS1
VFILTR
AVDD1
TWR
VSYNC
HSYNC
AVSS2
OVRW
AVDD2
EED1
EECS
BLUE
GREEN
RED
IREF
P0
VSS4
VCC
VCC
C18
C33
100nF 1206
1uF SMD
D8
VCC
1R
R74
BAV103
VCC
VCC
VCC
VCC
100nF 1206
C17
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
Video
VCC
VCC
VCC
VCC
VCC
4
6
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
VCC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
CONN11
VGACONN
VCC
5
10R 1206
R76
1
LM334
IC56
D30
D31
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
VA9
6
VCC
1R
R73
150R 1206
R66
150R 1206
D28
D29
D24
D25
D26
D27
A13
A14
A15
A16
5
C60
100nF 1206
2
10NF 1206
10NF 1206
C41
100nF 1206
C61
100nF 1206
C50
100nF 1206
C42
100nF 1206
C62
100nF 1206
C51
100nF 1206
C43
100nF 1206
C63
100nF 1206
C52
100nF 1206
C44
100nF 1206
C64
100nF 1206
C53
100nF 1206
C45
100nF 1206
C65
100nF 1206
C54
100nF 1206
C46
100nF 1206
C66
100nF 1206
C55
100nF 1206
C47
100nF 1206
C67
100nF 1206
C56
100nF 1206
C68
100nF 1206
C57
100nF 1206
C48
100nF 1206
3
2
C69
100nF 1206
C58
100nF 1206
C49
100nF 1206
C24
RDY
CLKIN
STBY
BHE
RFSH
10NF 1206
1
R68
150R 1206
C90
100nF 1206
C59
100nF 1206
R70
C71
100nF 1206
R75
A12
A11
A10
40
39
38
37
36
81
82
83
84
85
C70
100nF 1206
150R 1206
R69
150R 1206
C91
100nF 1206
C80
100nF 1206
C72
100nF 1206
C92
100nF 1206
C81
100nF 1206
10uF SMD
C36
10pF 1206
C82
100nF 1206
10R 1206
A8
A7
A6
A5
A4
A3
A2
A1
A0
C37
10pF 1206
C73
100nF 1206
ALE
MEMWR
MEMRD
RSTDRV
C35
220pF 1206
C93
100nF 1206
C83
100nF 1206
MD31
MD30
MD29
MD28
C38
10pF 1206
C74
100nF 1206
C34
220pF 1206
C75
100nF 1206
C94
100nF 1206
C84
100nF 1206
MD27
MD26
MD25
MD24
C76
100nF 1206
C95
100nF 1206
C85
100nF 1206
C77
100nF 1206
C96
100nF 1206
C86
100nF 1206
C97
100nF 1206
C87
100nF 1206
R67
150R 1206
A19
A18
A17
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
VSS3
SA12
SA11
SA10
SA9
SA8
SA7
SA6
SA5
SA4
SA3
SA2
SA1
SA0
VDD2
BALE
SHBE
MCS16
IOCS16
LA23
LA22
LA21
LA20
LA19
LA18
LA17
MEMR
MEMW
VSS2
SD8
SD9
SD10
SD11
VSS1
SD12
VDD4
P1
P2
P3
AVDD3
P4
P5
P6
P7
AVSSS3
VSS7
DCLK
BLANK
EVIDEO
ESYNC
EDCLK
MD31
MD30
MD29
MD28
VSS8
MD27
MD26
MD25
MD24
WE3
VDD5
MD23
MD22
MD21
MD20
MD19
MD18
MD17
MD16
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
MD23
MD22
MD21
MD20
MD19
MD18
MD17
MD16
C78
100nF 1206
C88
100nF 1206
2
1
VSS13
OSC
XTAL
MCLK
AVSS4
MFILTR
AVDD4
MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
VSS12
MA9
RAS
OE
VDD7
CAS
WE0
VSS11
MD0
MD1
MD2
MD3
MD4
MD5
MD6
MD7
VSS10
WE1
MD8
MD9
MD10
MD11
MD12
VDD6
GD5429
IC65
VCC
SD13
SD14
4
3
SD15
EROM
VDD1
WE2
MD15
VCC
160
159
158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
VCC
VCC
VCC
100nF 1206
C13
100nF 1206
C14
R58 47R 1206
VCC
VCC
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
IC60
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
IC59
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
IC58
414256
A0
A1
A2
A3
A4
A5
A6
A7
A8
IC57
VCC
OE
WE
RAS
CAS
D0
D1
D2
D3
OE
WE
RAS
CAS
D0
D1
D2
D3
OE
WE
RAS
CAS
D0
D1
D2
D3
OE
WE
RAS
CAS
D0
D1
D2
D3
VCC
File:
Number:
COLDCPU6.SC3
7
H:\Lab\ECHELON\CIRCUIT\COLDCPU6.SC3.sch
Size: A2
Echelon CPU Card
C147
10uF SMD
+12
C153
10uF SMD
VCC
1
2
8
GND
Vcc
4
14.31818MHz
IC66
Drawn By:
C144
220uF
150R 1206
R62
8
Sheet 3 of 4
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
C145
10uF SMD
VCC
MD28
MD29
MD30
MD31
MD24
MD25
MD26
MD27
MD20
MD21
MD22
MD23
MD16
MD17
MD18
MD19
-12
Date: 11-Apr-2000 Time: 10:40:19
Revision: 0
C150
10uF SMD
+12
-12
+12
+12
-12
+12
VCC
4
17
5
16
3
1
2
18
19
4
17
5
16
3
1
2
18
19
4
17
5
16
3
1
2
18
19
4
17
5
16
3
1
2
18
19
1uF SMD
C31
VCC
-12
MA0 6
MA1 7
MA2 8
MA3 9
MA4 11
MA5 12
MA6 13
MA7 14
MA8 15
MA0 6
MA1 7
MA2 8
MA3 9
MA4 11
MA5 12
MA6 13
MA7 14
MA8 15
MA0 6
MA1 7
MA2 8
MA3 9
MA4 11
MA5 12
MA6 13
MA7 14
MA8 15
MA0 6
MA1 7
MA2 8
MA3 9
MA4 11
MA5 12
MA6 13
MA7 14
MA8 15
R64 150R 1206
150R 1206
R63
10uF SMD
C22
VCC
MA0
MA1
MA2
MA3
MA4
MA5
MA6
MA7
MA8
7
VCC
Title
119
120
MD14
MD13
VSS9
C98
100nF 1206
C156
100nF 1206
117
118
C79
100nF 1206
C89
100nF 1206
C99
100nF 1206
C100
100nF 1206
C139
100nF 1206
C101
100nF 1206
C140
100nF 1206
C102
100nF 1206
C141
100nF 1206
C103
100nF 1206
C142
100nF 1206
C104
100nF 1206
C27
100nF 1206
C105
100nF 1206
C151
100nF 1206
C149
100nF 1206
C148
100nF 1206
C154
100nF 1206
C152
100nF 1206
C143
100nF 1206
C146
100nF 1206
OUT
3
10NF 1206
C120
VCC
A
B
C
D
Appendix E
Circuit Diagrams and Overlays
E-5
ECHPROG2 Circuit diagrams and overlays
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
-12
DS
ALE
+5
D6
D5
GND
D2
D1
GND
14
19
20
17
15
18
+12
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
L8 12
L7 13
L6 14
L5 15
L4 16
L3 17
L2 18
L1 19
CONN2
4X.1
CONN4
1
INV1
11
1
DD79
DD68
DD57
DD46
DD35
DD24
DD13
DD02
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
GND
VIN
2
1
11
1
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
2
3
4
5
6
7
8
9
L1612
L1513
L1414
L1315
L1216
L1117
L1018
L9 19
2
10uF
C1
T1p
220R
1K
11
1
T1p
BCX17
Q1
Y7
Y6
Y5
Y4
Y3
Y2
Y1
Y0
74HC138
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
9
8
7
6
5
4
3
2
7
9
10
11
12
13
14
15
D7
D6
D5
D4
D3
D2
D1
D0
10K
R5
4K7
R7
CONTRAST
BRIGHTNESS
R19
R18
U1p
BCX19
Q2
C
B
A
E3
E2
E1
VCC
47K
+12
3
2
1
6
5
4
IC20
R2
10K
R10
12
13
14
15
16
17
18
19
D0
D1
D2
D3
D4
D5
D6
D7
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
S3
S2
S1
ST
AC
UP
ME
MN
BCX17
+12
R8
19
1
22K
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
D7
D6
D5
D4
D3
D2
D1
D0
Q3
74HC574
IC2
B0
B1
B2
B3
B4
B5
B6
B7
74HC245
IC16
C
OC
LCD connector
ZIF14
CONN3
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
To CCFL
CXA-L10L
18
17
16
15
14
13
12
11
8D
7D
6D
5D
4D
3D
2D
1D
9
8
7
6
5
4
3
2
74HC573
BB
CO
PF
GI
CR
TQ
BL
HL
IC3
74HC573
2
IC4
vcc
IDC14
TO CPU Card
IDC20
RW
-12
+12
DS
ALE
MUX
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
2
3
5
6
8
9
11
12
13
16
1
4
7
10
CONN1
+12
MUX
+5
R/W
D7
GND
D4
D3
GND
D0
4
4
3
2
1
OUT2
5
GND
D
L(1..16)
1
14
13
12
11
10
9
8
7
6
5
4
3
2
1
14
13
12
11
10
9
8
7
6
5
4
3
2
1
3
OUT1
3
3
47K
R20
4K7
R6
10K
R11
22K
R105
47K
R4
100K
R9
100K
R1
100K
R3
R21
10uF
C3
100K
VCC
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
4
20
19
18
17
16
15
14
13
12
11
20
19
18
17
16
15
14
13
12
11
1Q
2Q
3Q
4Q
5Q
6Q
7Q
8Q
74HC573
IC1
VCC
VCC
19
18
17
16
15
14
13
12
GAL16V8
IC18
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
GAL16V8
IC19
4
1D
2D
3D
4D
5D
6D
7D
8D
OC
C
VCC
2
3
4
5
6
7
8
9
1
11
D0
D1
D2
D3
D4
D5
D6
D7
74HC14
IC24A
1
2
5
5
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
18
17
16
15
14
13
12
11
S1
S2
S3
S4
S5
S6
S7
S8
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
B0
B1
B2
B3
B4
B5
B6
B7
2
3
4
5
6
7
8
9
EF
FX
T9
TT
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC6
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC5
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
<
/\
\/
>
IL
IU
ID
IR
B0
B1
B2
B3
B4
B5
B6
B7
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
11
B0
B1
B2
B3
B4
B5
B6
B7
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
6
VCC
10
74HC14
IC24E
S73
S74
S75
S76
E
DIR
File:
7
6
11
14
2
7
6
11
14
2
7
6
11
14
2
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
COUT
Q0
Q1
Q2
Q3
IC23
COUT
Q0
Q1
Q2
Q3
IC22
COUT
Q0
Q1
Q2
Q3
IC21
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
S65
S66
S67
S68
S69
S70
S71
S72
S33
S34
S35
S36
S37
S38
S39
S40
S9
S10
S11
S12
S13
S14
S15
S16
P0
P1
P2
P3
P0
P1
P2
P3
P0
P1
P2
P3
PE
CIN
U/D
CLK
RST
4516
PE
CIN
U/D
CLK
RST
4516
PE
CIN
U/D
CLK
RST
4516
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
7
1
5
10
15
9
4
12
13
3
1
5
10
15
9
4
12
13
3
1
5
10
15
9
4
12
13
3
D:\R_&_D\Echelon\echprog2.sc1
PG
MA
SE
PA
TI
CU
ST
LI
1
0
2
.
3
EN
@
S1
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
7
Date: 1-Oct-1999
RE
LR
LL
GO
NE
PI
S2
S3
74HC245
IC8
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC14
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC15
Number:ECHPROG2.SC1 Revision: 0
Echelon PROGRAM Card
Size: A3
Title
%01100011
CARD TYPE
INDENTITY
19
1
A0
A1
A2
A3
A4
A5
A6
A7
T1
T2
T3
T4
T5
T6
T7
T8
74HC245
S49
S50
S51
S52
S53
S54
S55
S56
E
DIR
7
4
8
5
9
6
TH
FU
IC10
18
17
16
15
14
13
12
11
19
1
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
GI
BK
PF
/
CO
BB
+
IC9
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
D0
D1
D2
D3
D4
D5
D6
D7
IC12
S25
S26
S27
S28
S29
S30
S31
S32
E
DIR
74HC245
18
17
16
15
14
13
12
11
19
1
CC
AC
MO
LO
DE
UP
UN
RE
IC13
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
B0
B1
B2
B3
B4
B5
B6
B7
IC17
TQ
ME
HL
MN
BL
BE
CR
EN
74HC245
A0
A1
A2
A3
A4
A5
A6
A7
IC11
6
IC24B
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
10nF
C12
9
5
3
VCC
100K
4
2
D
C
ENC3
4
2
D
C
ENC2
4
2
D
C
ENC1
HPENCODER
10k
R16
HPENCODER
10k
R14
HPENCODER
10k
R12
A
B
C
D
8
Error : F:\PUBLIC\JANDS.EPS image fil
100K
R28
10nF
C7
100K
R27
10k
R17
10nF
C8
100K
R26
10k
VCC
100K
R15
R25
VCC
8
R24
10nF
C9
100K
R23
10k
R13
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Time: 12:01:39 Sheet 1 of 2
8
74HC14
IC24D
10nF
C11
74HC14
6
S57
S58
S59
S60
S61
S62
S63
S64
S41
S42
S43
S44
S45
S46
S47
S48
S17
S18
S19
S20
S21
S22
S23
S24
10nF
C10
IC24C
4
74HC14
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
S(1..76)
A
B
C
D
S(1..76)
1
1
S77A
CHERRY
VCC
100K
100K
VCC
R80
R79
S46A
CHERRY
S52
VCC
S51
S52A
CHERRY
100K
100K
VCC
R55
R54
S51A
CHERRY
S27
VCC
S26
S27A
CHERRY
VCC
100K
100K
S26A
CHERRY
R30
R29
VCC
S2
100K
R74
S46
2k2
R152
100K
R81
S53
VCC
2
S53A
CHERRY
100K
R56
S28
VCC
S28A
CHERRY
100K
R31
S3
VCC
S2A
S3A
CHERRY CHERRY
S1
VCC
S1A
CHERRY
2k2
Red
Red
R151
S2B
L2
S4B
2k2
L1
R150
L(1..16)
2
2k2
S4
VCC
VCC
VCC
100K
R82
S54
VCC
S5
VCC
C41
100nF
C40
100nF
100nF
VCC
C53
VCC
VCC
100K
R84
S56
VCC
VCC
100nF
C42
100nF
3
VCC
VCC
100K
R85
S57
VCC
VCC
100nF
C43
100nF
VCC
VCC
100K
R86
S58
VCC
100nF
C44
100nF
VCC
VCC
100K
R87
S59
VCC
S10
VCC
S10A
CHERRY
2k2
100nF
C45
100nF
VCC
VCC
100K
R88
S60
VCC
VCC
S11
100nF
C46
100nF
4
VCC
VCC
100K
R89
S61
VCC
VCC
100nF
C47
100nF
VCC
VCC
100K
R90
S62
VCC
100nF
C48
100nF
VCC
VCC
100K
R91
S63
VCC
S14
VCC
100nF
C49
100nF
VCC
VCC
100K
R92
S64
VCC
2k2
R162
5
100nF
C50
100nF
VCC
VCC
100K
R93
S65
VCC
2k2
100nF
C51
100nF
VCC
100K
R94
S66
VCC
S17
VCC
100K
R95
S67
VCC
S67A
CHERRY
100K
R70
S42
VCC
S42A
CHERRY
100K
100nF
Red
100K
R96
S68
VCC
S68A
CHERRY
100K
R71
S43
VCC
S43A
CHERRY
100K
R46
S18
VCC
6
6
100K
R97
S69
File:
1
S20
VCC
S20A
CHERRY
3
4
5
6
7
C18
10uF
10uF
100K
R100
S72
VCC
S72A
CHERRY
100K
R75
S47
VCC
S47A
CHERRY
100K
R50
S22
VCC
S22A
CHERRY
C14
+12
100K
R99
S71
VCC
S71A
CHERRY
100K
R104
S76
VCC
S76A
CHERRY
100K
R49
S21
VCC
S21A
CHERRY
100K
R101
S73
VCC
S73A
CHERRY
100K
R76
S48
VCC
S48A
CHERRY
100K
R51
S23
VCC
7
S74
VCC
S74A
CHERRY
100K
R77
S49
VCC
S49A
CHERRY
100K
R52
S24
VCC
S24A
CHERRY
100K
R103
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Time: 12:04:17 Sheet 2 of 2
100K
S75
VCC
S75A
CHERRY
100K
R78
S50
VCC
S50A
CHERRY
100K
R53
S25
VCC
S25A
CHERRY
10 11 12 13
R102
Date: 1-Oct-1999
Number:ECHPROG2.SC2 Revision: 0
D:\R_&_D\Echelon\Echprog2.sc2
9
lcd1
8
S23A
CHERRY
14 15 16 17 18 19
2
7
Echelon PROGRAM Card
VCC
100K
R98
S70
VCC
S70A
CHERRY
100K
R73
S45
VCC
S45A
CHERRY
100K
Size: A3
Title
VCC
S69A
CHERRY
100K
R72
S44
VCC
S44A
CHERRY
100K
R47
S19
VCC
R48
Red
S31B
L16
S19A
CHERRY
2k2
R165
S29B
L15
S18A
CHERRY
2k2
R164
S17A
CHERRY
C64
S66A
CHERRY
100K
R69
S41
VCC
S41A
CHERRY
100K
R44
S16
VCC
Red
S27B
L14
R45
R163
S16A
CHERRY
Red
S25B
L13
C63
S65A
CHERRY
100K
R68
S40
VCC
S40A
CHERRY
100K
R43
S15
VCC
S15A
CHERRY
Red
C62
S64A
CHERRY
100K
R67
S39
VCC
S39A
CHERRY
100K
5
S7B
L12
S14A
CHERRY
C61
S63A
CHERRY
100K
R66
S38
VCC
S38A
CHERRY
100K
R41
S13
VCC
2k2
R161
R42
Red
S1B
L11
S13A
CHERRY
2k2
R160
C60
S62A
CHERRY
100K
R65
S37
VCC
S37A
CHERRY
100K
R40
S12
C59
S61A
CHERRY
100K
R64
S36
VCC
Red
S5B
L10
S12A
CHERRY
2k2
R159
S36A
CHERRY
100K
C58
S60A
CHERRY
100K
R63
S35
VCC
S35A
CHERRY
100K
Red
S3B
S11A
CHERRY
L9
4
R39
R158
Green
S64B
R38
L8
C57
S59A
CHERRY
100K
R62
S34
VCC
S34A
CHERRY
100K
R37
S9
VCC
S9A
CHERRY
2k2
R157
Green
S63B
C56
S58A
CHERRY
100K
R61
S33
VCC
S33A
CHERRY
100K
R36
S8
C55
S57A
CHERRY
100K
R60
S32
VCC
L7
S8A
CHERRY
2k2
R156
Green
S48B
S32A
CHERRY
100K
R35
S7
C54
S56A
CHERRY
100K
R59
S31
VCC
S31A
CHERRY
100K
L6
S7A
CHERRY
2k2
R155
Green
S23B
VCC
R34
S6
100nF
VCC
100K
R83
S55
VCC
S55A
CHERRY
100K
R58
S30
VCC
S30A
CHERRY
100K
L5
S6A
CHERRY
2k2
R154
C52
S54A
CHERRY
100K
R57
S29
VCC
S29A
CHERRY
100K
Red
S10B
S5A
CHERRY
L4
R33
R153
S4A
CHERRY
Red
S14B
R32
L3
3
A
B
C
D
8
Error : F:\PUBLIC\JANDS.EPS image fil
8
Appendix E
Circuit Diagrams and Overlays
E-6
ECHPROG3 Circuit diagrams and overlays
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
-12
DS
ALE
+5
D6
D5
GND
D2
D1
GND
14
19
20
17
15
18
12
13
16
1
4
7
10
9
11
4X.1
CONN2
1
INV1
CONN4
+12
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
L8
L7
L6
L5
L4
L3
L2
L1
12
13
14
15
16
17
18
19
IDC14
TO CPU Card
IDC20
RW
-12
+12
DS
ALE
MUX
D7
VCC
VCC
GND
GND
GND
GND
D5
D6
D0
D1
D2
D3
D4
2
3
5
6
8
CONN1
+12
MUX
+5
R/W
D7
GND
D4
D3
GND
D0
14
14
D
13
12
11
13
12
11
14
L(1..16)
7
6
10
9
8
10
9
8
10
9
8
4
7
6
7
6
3
2
13
12
11
1
1
5
18
17
16
15
14
13
8D
7D
6D
5D
4D
3D
2D
1D
D7
D6
D5
D4
D3
D2
D1
D0
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
2
3
4
5
6
7
L1612
L1513
L1414
L1315
L1216
L1117
L1018
L9 19
GND
VIN
2
1
TRANS14
CONN5
LCD connector
ZIF14
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
2
10uF
C1
12
13
14
15
16
17
18
19
Q3
19
1
8
9
D1
10k
BRIGHTNESS
220R
R5
1K
T1p
4K7
R7
3
D2
3
BAV103
7
9
10
11
12
13
14
15
BCX17
Q1
Y7
Y6
Y5
Y4
Y3
Y2
Y1
Y0
D7
D6
D5
D4
D3
D2
D1
D0
CONTRAST
47K
R19
11
1
9
8
7
6
5
4
3
2
74HC138
BAV103
C
B
A
E3
E2
E1
R2
3
2
1
6
5
4
VCC
100K
IC20
8D
7D
6D
5D
4D
3D
2D
1D
C
OC
R22
S3
S2
S1
ST
AC
UP
ME
MN
R18
10K
R10
+12
100nF
BCX19
U1p
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
C65
D0
D1
D2
D3
D4
D5
D6
D7
Q2
BCP53
+12
R8
10k
E
DIR
A6
A7
B6
B7
IC2
12
11
A0
A1
A2
A3
A4
A5
B0
B1
B2
B3
B4
B5
74HC245
IC16
C
OC
11
1
C16
C15
100nF 100nF
11
1
DD79
DD68
DD57
DD46
DD35
DD24
DD13
DD02
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
CONN3
vcc
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
9
8
7
6
5
4
3
2
IC3
74HC573
BB
CO
PF
GI
CR
TQ
BL
HL
2
IC4
To CCFL
CXA-L10L
GND
4
OUT2
5
4
3
2
1
5
4
3
2
1
5
4
3
2
1
3
OUT1
100K
100K
47K
R20
4K7
R6
10K
R11
22K
R105
47K
R4
100K
R9
R3
4K7
R168
R1
10k
R167
R21
10uF
C3
100K
VCC
VCC
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
4
19
18
17
16
15
14
13
12
GAL16V8
IC18
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
GAL16V8
IC19
4
20
19
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
20
19
8Q
1Q
2Q
3Q
4Q
5Q
6Q
7Q
74HC573
IC1
VCC
VCC
8D
1D
2D
3D
4D
5D
6D
7D
OC
C
VCC
2
3
4
5
6
7
8
9
1
11
D0
D1
D2
D3
D4
D5
D6
D7
74HC14
IC24A
1
2
5
5
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
9
2
3
4
5
6
7
8
19
1
2
3
4
5
6
7
8
9
18
17
16
15
14
13
12
11
S1
S2
S3
S4
S5
S6
S7
S8
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
B0
B1
B2
B3
B4
B5
B6
2
3
4
5
6
7
8
S49
S50
S51
S52
S53
S54
S55
S56
D0
D1
D2
D3
D4
D5
D6
D7
9
2
3
4
5
6
7
8
9
19
1
E
DIR
A7
<
/\
\/
>
IL
IU
ID
IR
EF
FX
T9
TT
E
DIR
A6
A7
A0
A1
A2
A3
A4
A5
74HC245
IC7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC6
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC5
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
B6
B7
B0
B1
B2
B3
B4
B5
B0
B1
B2
B3
B4
B5
B6
B7
11
B0
B1
B2
B3
B4
B5
B6
B7
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
6
VCC
10
74HC14
IC24E
S73
S74
S75
S76
E
DIR
T1
T2
T3
T4
T5
T6
T7
T8
7
6
11
14
2
7
6
11
14
2
7
6
11
14
2
B0
B1
B2
B3
B4
B5
B6
B7
B7
B0
B1
B2
B3
B4
B5
B6
B0
B1
B2
B3
B4
B5
B6
B7
COUT
Q0
Q1
Q2
Q3
IC23
COUT
Q0
Q1
Q2
Q3
IC22
COUT
Q0
Q1
Q2
Q3
IC21
18
17
16
15
14
13
12
11
11
18
17
16
15
14
13
12
18
17
16
15
14
13
12
11
S65
S66
S67
S68
S69
S70
S71
S72
S33
S34
S35
S36
S37
S38
S39
S40
S9
S10
S11
S12
S13
S14
S15
S16
P0
P1
P2
P3
P0
P1
P2
P3
P0
P1
P2
P3
PE
CIN
U/D
CLK
RST
4516
PE
CIN
U/D
CLK
RST
4516
PE
CIN
U/D
CLK
RST
4516
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
1
5
10
15
9
4
12
13
3
1
5
10
15
9
4
12
13
3
1
5
10
15
9
4
12
13
3
19
1
2
3
4
5
6
7
8
9
19
1
9
2
3
4
5
6
7
8
19
1
2
3
4
5
6
7
8
9
7
PG
MA
SE
PA
TI
CU
ST
LI
1
0
2
.
3
EN
@
S1
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
RE
LR
LL
GO
NE
PI
S2
S3
74HC245
IC8
E
DIR
A7
A0
A1
A2
A3
A4
A5
A6
74HC245
IC14
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC15
IC24B
18
17
16
15
14
13
12
11
11
18
17
16
15
14
13
12
18
17
16
15
14
13
12
11
10nF
8
10nF
C12
74HC14
IC24D
10nF
C11
74HC14
6
S57
S58
S59
S60
S61
S62
S63
S64
S41
S42
S43
S44
S45
S46
S47
S48
S17
S18
S19
S20
S21
S22
S23
S24
C10
IC24C
4
74HC14
B0
B1
B2
B3
B4
B5
B6
B7
B7
B0
B1
B2
B3
B4
B5
B6
B0
B1
B2
B3
B4
B5
B6
B7
9
5
3
10k
7
8
4
2
D
C
3
VCC
1,5
D
1,5
3
D
1,5
HPENCODER
ENC1
4
C
VCC
10k
2
R16
HPENCODER
ENC2
4
C
3
10k
2
VCC
R14
HPENCODER
ENC3
10k
R12
Drawn By:
100K
R28
10k
10nF
C7
100K
R27
VCC
100K
R17
10nF
C8
R26
R25
VCC
100K
R15
100K
VCC
8
R24
10nF
C9
100K
R23
10k
R13
S(1..76)
Jands Electronics P/L
40 Kent Rd
Echelon PROGRAM Card
Mascot NSW 2020
Australia
Size: A3 Number: ECHPROG3.SC1 Revision: 0
Ph (02) 9582-0909
File:H:\LAB\ECHELON\CIRCUIT\Echprog3.sc1
Date: 30-Sep-1999
Sheet 1 of 2
Title
%01100011
CARD TYPE
INDENTITY
19
1
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
18
17
16
15
14
13
12
11
11
7
4
8
5
9
6
TH
FU
IC10
B0
B1
B2
B3
B4
B5
B6
B7
B7
A0
A1
A2
A3
A4
A5
A6
74HC245
GI
BK
PF
/
CO
BB
+
IC9
E
DIR
A7
A0
A1
A2
A3
A4
A5
A6
74HC245
D0
D1
D2
D3
D4
D5
D6
D7
IC12
S25
S26
S27
S28
S29
S30
S31
S32
E
DIR
74HC245
18
17
16
15
14
13
12
19
1
CC
AC
MO
LO
DE
UP
UN
RE
IC13
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
B0
B1
B2
B3
B4
B5
B6
B7
IC17
TQ
ME
HL
MN
BL
BE
CR
EN
74HC245
A0
A1
A2
A3
A4
A5
A6
A7
IC11
6
A
B
C
D
A
B
C
D
S(1..76)
1
1
VCC
100K
R74
S46
S77A
CHERRY
100K
100K
VCC
R80
R79
S46A
CHERRY
S52
VCC
S51
S52A
CHERRY
100K
100K
VCC
R55
R54
S51A
CHERRY
S27
VCC
S26
S27A
CHERRY
100K
100K
VCC
R30
R29
S26A
CHERRY
S2
VCC
S1
VCC
2k2
R152
100K
R81
S53
VCC
2
S53A
CHERRY
100K
R56
S28
VCC
S28A
CHERRY
100K
R31
S3
VCC
VCC
VCC
100K
R82
S54
VCC
Red
C41
100nF
C40
100nF
100nF
VCC
C53
VCC
VCC
100K
R84
S56
VCC
L6
3
100nF
C42
100nF
3
VCC
VCC
100K
R85
S57
VCC
100nF
C43
100nF
VCC
VCC
100K
R86
S58
VCC
100nF
C44
100nF
VCC
VCC
100K
R87
S59
VCC
S10
VCC
S10A
CHERRY
100nF
C45
100nF
VCC
VCC
100K
R88
S60
VCC
Red
100nF
C46
100nF
4
VCC
VCC
100K
R89
S61
VCC
VCC
100nF
C47
100nF
VCC
VCC
100K
R90
S62
VCC
100nF
C48
100nF
VCC
VCC
100K
R91
S63
VCC
S14
VCC
100nF
C49
100nF
VCC
VCC
100K
R92
S64
VCC
2k2
R162
5
100nF
C50
100nF
VCC
VCC
100K
R93
S65
VCC
2k2
100nF
C51
100nF
VCC
100K
R94
S66
VCC
S17
VCC
100K
R95
S67
VCC
S67A
CHERRY
100K
R70
S42
VCC
S42A
CHERRY
100K
100nF
Red
100K
R96
S68
VCC
S68A
CHERRY
100K
R71
S43
VCC
S43A
CHERRY
100K
R46
S18
VCC
6
6
100K
R97
S69
VCC
S20A
CHERRY
1
5
6
S76
VCC
S76A
CHERRY
100K
R49
S21
VCC
C18
10uF
10uF
+12
100K
R100
S72
VCC
7
8
9
S73
VCC
S73A
CHERRY
100K
R76
S48
VCC
S48A
CHERRY
100K
R51
S23
VCC
S23A
CHERRY
100K
R101
S72A
CHERRY
100K
R75
C14
100K
R99
S71
VCC
S71A
CHERRY
100K
S47
VCC
S47A
CHERRY
100K
R50
S22
VCC
S22A
CHERRY
Echelon PROGRAM Card
VCC
100K
R98
S70
VCC
4
S21A
CHERRY
R104
S70A
CHERRY
100K
R73
S45
VCC
S45A
CHERRY
100K
R48
3
S74
VCC
S74A
CHERRY
100K
R77
S49
VCC
S49A
CHERRY
100K
R52
S24
VCC
S24A
CHERRY
100K
100K
R103
S75
VCC
S75A
CHERRY
100K
R78
S50
VCC
S50A
CHERRY
100K
R53
S25
VCC
S25A
CHERRY
10 11 12 13
R102
14 15 16 17 18 19 lcd1
2
7
7
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Size: A3 Number: ECHPROG3.SC2 Revision: 0
Ph (02) 9582-0909
File:H:\LAB\ECHELON\CIRCUIT\Echprog3.sc2
Date: 30-Sep-1999
Sheet 2 of 2
Title
VCC
S69A
CHERRY
100K
R72
S44
VCC
S44A
CHERRY
100K
R47
S19
VCC
S20
Red
S31B
L16
S19A
CHERRY
2k2
R165
S29B
L15
S18A
CHERRY
2k2
R164
S17A
CHERRY
C64
S66A
CHERRY
100K
R69
S41
VCC
S41A
CHERRY
100K
R44
S16
VCC
Red
S27B
L14
R45
R163
S16A
CHERRY
Red
S25B
L13
C63
S65A
CHERRY
100K
R68
S40
VCC
S40A
CHERRY
100K
R43
S15
VCC
S15A
CHERRY
Red
C62
S64A
CHERRY
100K
R67
S39
VCC
S39A
CHERRY
100K
5
S7B
L12
S14A
CHERRY
C61
S63A
CHERRY
100K
R66
S38
VCC
S38A
CHERRY
C60
S62A
CHERRY
100K
R65
S37
VCC
100K
R41
S13
VCC
2k2
R161
R42
Red
S1B
L11
S13A
CHERRY
2k2
R160
S37A
CHERRY
100K
R40
S12
C59
S61A
CHERRY
100K
R64
S36
VCC
S36A
CHERRY
100K
R39
S11
VCC
Red
S5B
L10
S12A
CHERRY
2k2
R159
S3B
4
S11A
CHERRY
L9
C58
S60A
CHERRY
100K
R63
S35
VCC
S35A
CHERRY
100K
C57
S59A
CHERRY
100K
R62
S34
VCC
S34A
CHERRY
100K
R37
S9
VCC
2k2
R158
Green
S64B
R38
L8
S9A
CHERRY
C56
S58A
CHERRY
100K
R61
S33
VCC
S33A
CHERRY
100K
R36
S8
VCC
2k2
R157
Green
S63B
L7
S8A
CHERRY
C55
S57A
CHERRY
100K
R60
S32
VCC
S32A
CHERRY
100K
R35
S7
VCC
2k2
R156
Green
S48B
S7A
CHERRY
C54
S56A
CHERRY
100K
R59
S31
VCC
S31A
CHERRY
100K
R34
S6
VCC
2k2
R155
Green
S23B
L5
S6A
CHERRY
100nF
VCC
100K
R83
S55
VCC
S55A
CHERRY
100K
R58
S30
VCC
S30A
CHERRY
100K
R33
S5
VCC
2k2
R154
S10B
S5A
CHERRY
L4
C52
S54A
CHERRY
100K
R57
S29
VCC
S29A
CHERRY
100K
R32
S4
VCC
S4A
CHERRY
2k2
R153
Red
S14B
L3
S2A
S3A
CHERRY CHERRY
2k2
S1A
CHERRY
R151
Red
Red
2k2
S2B
L2
S4B
L1
R150
L(1..16)
2
8
Drawn By:
8
A
B
C
D
Appendix E
Circuit Diagrams and Overlays
E-7
ECHPROG4 Circuit diagrams and overlays
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
-12
DS
ALE
+5
D6
D5
GND
D2
D1
GND
14
19
20
17
15
18
+12
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
CONN2
L8
L7
L6
L5
L4
L3
L2
L1
IDC14
TO CPU Card
IDC20
RW
-12
+12
DS
ALE
MUX
GND
GND
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
2
3
5
6
8
9
11
12
13
16
1
4
7
10
CONN1
+12
MUX
+5
R/W
D7
GND
D4
D3
GND
D0
4X.1
CONN4
1
INV1
9
8
7
6
5
4
3
2
8D
7D
6D
5D
4D
3D
2D
1D
9
8
7
6
5
4
3
2
DD7
DD6
DD5
DD4
DD3
DD2
DD1
DD0
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
11
1
11
1
D7
D6
D5
D4
D3
D2
D1
D0
A1
A2
A3
A4
A5
A6
A7
B1
B2
B3
B4
B5
B6
B7
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
2
3
4
5
6
7
8
9
GND
VIN
2
1
TRANS14
CONN5
2
10uF
C1
100nF 100nF
LCD connector
ZIF14
L16
L15
L14
L13
L12
L11
L10
L9
12
13
14
15
16
17
18
19
D1
10k
BRIGHTNESS
220R
R5
1K
7
9
10
11
12
13
14
15
T1p
BCX17
Q1
Y7
Y6
Y5
Y4
Y3
Y2
Y1
Y0
D7
D6
D5
D4
D3
D2
D1
D0
4K7
R7
3
D2
3
BAV103
CONTRAST
47K
R19
11
1
9
8
7
6
5
4
3
2
74HC138
BAV103
C
B
A
E3
E2
E1
R2
3
2
1
6
5
4
VCC
100K
IC20
8D
7D
6D
5D
4D
3D
2D
1D
C
OC
R22
S3
S2
S1
ST
AC
UP
ME
MN
R18
10K
R10
+12
BCX19
U1p
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
100nF
C65
D0
D1
D2
D3
D4
D5
D6
D7
Q2
BCP53
+12
10k
12
13
14
15
16
17
18
19
Q3
19
1
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
R8
E
DIR
A0
B0
74HC245
IC16
IC2
18
17
16
15
14
13
12
11
C
OC
CONN3 C16 C15
To CCFL
CXA-L10L
BB
CO
PF
GI
CR
TQ
BL
HL
74HC573
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC3
74HC573
vcc
12
13
14
15
16
17
18
19
2
IC4
LCD DISPLAY: OPTREX DMF-50174
OUT2
4
1
2
3
4
5
GND
D
L(1..16)
1
14
13
12
11
10
9
8
7
6
5
4
3
2
1
14
13
12
11
10
9
8
7
6
5
4
3
2
1
14
13
12
11
10
9
8
7
6
5
4
3
2
1
3
OUT1
22K
R105
47K
R4
100K
4K7
R6
10K
R11
R20
47K
100K
100K
R9
R3
4K7
R168
R1
10k
R167
R21
10uF
C3
100K
VCC
VCC
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
4
GAL16V8
IC18
DEC
A3
A2
A1
A0
GND
RW
ALEH
DS
GAL16V8
IC19
4
19
18
17
16
15
14
13
12
20
19
18
17
16
15
14
13
12
11
20
19
18
17
16
15
14
13
12
11
1Q
2Q
3Q
4Q
5Q
6Q
7Q
8Q
74HC573
IC1
VCC
VCC
1D
2D
3D
4D
5D
6D
7D
8D
OC
C
VCC
2
3
4
5
6
7
8
9
1
11
D0
D1
D2
D3
D4
D5
D6
D7
74HC14
IC24A
1
2
5
5
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
19
1
9
2
3
4
5
6
7
8
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
18
17
16
15
14
13
12
11
S1
S2
S3
S4
S5
S6
S7
S8
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
S25
S26
S27
S28
S29
S30
S31
S32
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
EF
FX
T9
TT
B7
A7
E
DIR
B0
B1
B2
B3
B4
B5
B6
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
B4
B5
B6
B7
A0
A1
A2
A3
A4
A5
A6
74HC245
IC7
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC6
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC5
E
DIR
A4
A5
A6
A7
<
/\
\/
>
IL
IU
ID
IR
S49
S50
S51
S52
S53
S54
S55
S56
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
11
18
17
16
15
14
13
12
18
17
16
15
14
13
12
11
11
18
17
16
15
14
13
12
11
VCC
6
10
74HC14
IC24E
S73
S74
S75
S76
E
DIR
T1
T2
T3
T4
T5
T6
T7
T8
7
6
11
14
2
7
6
11
14
2
7
6
11
14
2
B4
B5
B6
B7
B0
B1
B2
B3
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
COUT
Q0
Q1
Q2
Q3
IC23
COUT
Q0
Q1
Q2
Q3
IC22
COUT
Q0
Q1
Q2
Q3
IC21
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
S65
S66
S67
S68
S69
S70
S71
S72
S33
S34
S35
S36
S37
S38
S39
S40
S9
S10
S11
S12
S13
S14
S15
S16
P0
P1
P2
P3
P0
P1
P2
P3
P0
P1
P2
P3
PE
CIN
U/D
CLK
RST
4516
PE
CIN
U/D
CLK
RST
4516
PE
CIN
U/D
CLK
RST
4516
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
1
5
10
15
9
4
12
13
3
1
5
10
15
9
4
12
13
3
1
5
10
15
9
4
12
13
3
7
PG
MA
SE
PA
TI
CU
ST
LI
1
0
2
.
3
EN
@
S1
E
DIR
A4
A5
A6
A7
A0
A1
A2
A3
RE
LR
LL
GO
NE
PI
S2
S3
74HC245
IC8
DIR
E
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC14
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC15
File:H:\Lab\ECHELON\CIRCUIT\ECHPROG4.SC1
IC24B
7
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
10nF
10nF
C12
9
5
3
10k
4
2
8
D
C
3
VCC
1,5
4
2
D
C
3
VCC
1,5
HPENCODER
ENC1
10k
R16
HPENCODER
ENC2
1,5
D
C
3
10k
4
VCC
R14
2
HPENCODER
ENC3
10k
R12
Drawn By: GH
100K
R28
10k
10nF
C7
100K
R27
VCC
100K
R17
10nF
C8
R26
R25
VCC
100K
R15
100K
VCC
8
R24
10nF
C9
100K
R23
10k
R13
S(1..76)
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Sheet 1 of 2
8
74HC14
IC24D
10nF
C11
74HC14
6
S57
S58
S59
S60
S61
S62
S63
S64
S41
S42
S43
S44
S45
S46
S47
S48
S17
S18
S19
S20
S21
S22
S23
S24
C10
IC24C
4
74HC14
B4
B5
B6
B7
B0
B1
B2
B3
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
Date: 13-Apr-2000
A3 Number: ECHPROG4.SC1 Revision: 0
Echelon PROGRAM Card
Size:
Title
%01100011
CARD TYPE
INDENTITY
19
1
A4
A5
A6
A7
A0
A1
A2
A3
74HC245
A0
A1
A2
A3
IC10
18
17
16
15
14
13
12
11
DIR
E
7
4
8
5
9
6
TH
FU
74HC245
B0
B1
B2
B3
19
1
A0
A1
A2
A3
A4
A5
A6
A7
IC9
DIR
E
GI
BK
PF
/
CO
BB
+
74HC245
A0
A1
A2
A3
A4
A5
A6
A7
IC12
18
17
16
15
14
13
12
11
E
DIR
74HC245
B0
B1
B2
B3
B4
B5
B6
B7
19
1
CC
AC
MO
LO
DE
UP
UN
RE
IC13
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
B0
B1
B2
B3
B4
B5
B6
B7
IC17
TQ
ME
HL
MN
BL
BE
CR
EN
74HC245
A0
A1
A2
A3
A4
A5
A6
A7
IC11
6
A
B
C
D
A
B
C
D
S(1..76)
1
1
L(1..16)
VCC
100K
R74
S46
S77A
CHERRY
100K
100K
VCC
R80
R79
S46A
CHERRY
S52
VCC
S51
S52A
CHERRY
100K
100K
VCC
R55
R54
S51A
CHERRY
S27
VCC
S26
S27A
CHERRY
100K
100K
VCC
R30
R29
S26A
CHERRY
S2
VCC
S1
VCC
S2A
CHERRY
2k2
S1A
CHERRY
R151
100K
R81
S53
VCC
2
S53A
CHERRY
100K
R56
S28
VCC
S28A
CHERRY
100K
R31
S3
VCC
S3A
CHERRY
2k2
R152
Red
Red
2k2
S2B
L2
S4B
R150
L1
2
2k2
S4
VCC
VCC
VCC
100K
R82
S54
VCC
S5
VCC
C41
100nF
C40
100nF
100nF
VCC
C53
VCC
VCC
100K
R84
S56
VCC
VCC
100nF
C42
100nF
3
VCC
VCC
100K
R85
S57
VCC
VCC
100nF
C43
100nF
VCC
VCC
100K
R86
S58
VCC
100nF
C44
100nF
VCC
VCC
100K
R87
S59
VCC
S10
VCC
S10A
CHERRY
2k2
100nF
C45
100nF
VCC
VCC
100K
R88
S60
VCC
S11
VCC
100nF
C46
100nF
4
VCC
VCC
100K
R89
S61
VCC
VCC
100nF
C47
100nF
VCC
VCC
100K
R90
S62
VCC
100nF
C48
100nF
VCC
VCC
100K
R91
S63
VCC
S14
VCC
100nF
C49
100nF
VCC
VCC
100K
R92
S64
VCC
2k2
R162
100nF
C50
100nF
5
VCC
VCC
100K
R93
S65
VCC
2k2
100nF
C51
100nF
VCC
100K
R94
S66
VCC
S17
VCC
100K
R95
S67
VCC
S67A
CHERRY
100K
R70
S42
VCC
S42A
CHERRY
100K
100nF
Red
100K
R96
S68
VCC
S68A
CHERRY
100K
R71
S43
VCC
S43A
CHERRY
100K
R46
S18
VCC
6
6
100K
R97
S69
S20
VCC
S20A
CHERRY
1
VCC
100K
R98
S70
VCC
4
5
6
C18
10uF
+12
100K
R100
S72
VCC
S72A
CHERRY
100K
R75
S47
VCC
S47A
CHERRY
100K
R50
S22
VCC
S22A
CHERRY
10uF
100K
R99
S71
VCC
S71A
CHERRY
100K
R104
S76
VCC
S76A
CHERRY
100K
R49
S21
VCC
S21A
CHERRY
C14
S70A
CHERRY
100K
R73
S45
VCC
S45A
CHERRY
100K
3
7
8
9
100K
R101
S73
VCC
S73A
CHERRY
100K
R76
S48
VCC
S48A
CHERRY
100K
R51
S23
VCC
S23A
CHERRY
100K
7
Date: 13-Apr-2000
A3 Number: ECHPROG4.SC2 Revision: 0
File:H:\Lab\ECHELON\CIRCUIT\ECHPROG4.SC2
S74
100K
R103
S75
VCC
S75A
CHERRY
100K
R78
S50
VCC
S50A
CHERRY
100K
R53
S25
VCC
S25A
CHERRY
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Sheet 2 of 2
VCC
S74A
CHERRY
100K
R77
S49
VCC
S49A
CHERRY
100K
R52
S24
VCC
S24A
CHERRY
10 11 12 13
R102
14 15 16 17 18 19 lcd1
2
7
Echelon PROGRAM Card
Size:
Title
VCC
S69A
CHERRY
100K
R72
S44
VCC
S44A
CHERRY
100K
R47
S19
VCC
R48
Red
S31B
L16
S19A
CHERRY
2k2
R165
S29B
L15
S18A
CHERRY
2k2
R164
S17A
CHERRY
C64
S66A
CHERRY
100K
R69
S41
VCC
S41A
CHERRY
100K
R44
S16
VCC
Red
S27B
L14
R45
R163
S16A
CHERRY
Red
S25B
L13
C63
S65A
CHERRY
100K
R68
S40
VCC
S40A
CHERRY
100K
R43
S15
VCC
S15A
CHERRY
Red
C62
S64A
CHERRY
100K
R67
S39
VCC
S39A
CHERRY
100K
5
S7B
L12
S14A
CHERRY
C61
S63A
CHERRY
100K
R66
S38
VCC
S38A
CHERRY
100K
R41
S13
VCC
2k2
R161
R42
Red
S1B
L11
S13A
CHERRY
2k2
R160
C60
S62A
CHERRY
100K
R65
S37
VCC
S37A
CHERRY
100K
R40
S12
C59
S61A
CHERRY
100K
R64
S36
VCC
Red
S5B
L10
S12A
CHERRY
2k2
R159
S36A
CHERRY
100K
C58
S60A
CHERRY
100K
R63
S35
VCC
S35A
CHERRY
100K
Red
S3B
S11A
CHERRY
L9
4
R39
R158
Green
S64B
R38
L8
C57
S59A
CHERRY
100K
R62
S34
VCC
S34A
CHERRY
100K
R37
S9
VCC
S9A
CHERRY
2k2
R157
Green
S63B
C56
S58A
CHERRY
100K
R61
S33
VCC
S33A
CHERRY
100K
R36
S8
C55
S57A
CHERRY
100K
R60
S32
VCC
L7
S8A
CHERRY
2k2
R156
Green
S48B
S32A
CHERRY
100K
R35
S7
C54
S56A
CHERRY
100K
R59
S31
VCC
S31A
CHERRY
100K
L6
S7A
CHERRY
2k2
R155
Green
S23B
VCC
R34
100nF
VCC
100K
R83
S55
VCC
S55A
CHERRY
100K
R58
S30
VCC
S30A
CHERRY
100K
L5
S6A
CHERRY
S6
2k2
R154
C52
S54A
CHERRY
100K
R57
S29
VCC
S29A
CHERRY
100K
Red
S10B
S5A
CHERRY
L4
R33
R153
S4A
CHERRY
Red
S14B
R32
L3
3
8
Drawn By:
8
A
B
C
D
Appendix E
Circuit Diagrams and Overlays
E-8
ECHPBAK1 Circuit diagrams and overlays
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
D
14
19
20
17
15
18
2
3
5
6
8
9
11
12
13
16
1
4
7
10
RW
-12
+12
DS
ALE
MUX
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
IDC20
CONN1
-12
DS
ALE
+5
D6
D5
GND
D2
D1
GND
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
1
+12
MUX
+5
R/W
D7
GND
D4
D3
GND
D0
L(1..33)
12
13
14
15
16
17
18
L3319
L8 12
L7 13
L6 14
L5 15
L4 16
L3 17
L2 18
L1 19
4X.1 RA
CONN3
1
2
3
4
1
2
3
4
4X.1 RA
11
1
DD79
DD68
DD57
DD46
DD35
DD24
DD13
DD02
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
DB
F2
P2
G2
C2
F1
P1
G1
C1
CONN2
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC22
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC18
18
17
16
15
14
13
12
11
11
1
9
8
7
6
5
4
3
2
11
1
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
IC3
B0
B1
B2
B3
B4
B5
B6
B7
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
D7
D6
D5
D4
D3
D2
D1
D0
D7
D6
D5
D4
D3
D2
D1
D0
19
1
2
3
4
5
6
7
8
9
12
13
14
15
16
17
18
19
D0
D1
D2
D3
D4
D5
D6
D7
L1612
L1513
L1414
L1315
L1216
L1117
L1018
L9 19
2
10K
VR1
40X2
LCD0B
LCD BACKLIGHT
74HC245
IC4
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
9
8
7
6
5
4
3
2
E3
E2
E1
8D
7D
6D
5D
4D
3D
2D
1D
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
3
2
1
6
5
4
IC5
C
B
A
Y7
Y6
Y5
Y4
Y3
Y2
Y1
Y0
74HC138
C
OC
11
1
7
9
10
11
12
13
14
15
VCC
3
CARD
SELECT
SHUNT
3
2
1
0
JP1
100k
R9
L2412
L2313
L2214
L2115
L2016
L1917
L1818
L1719
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
D7
D6
D5
D4
D3
D2
D1
D0
IC20
9
8
7
6
5
4
3
2
74HC573
F4
P4
G4
C4
F3
P3
G3
C3
IC19
D7
D6
D5
D4
D3
D2
D1
D0
F6
P6
G6
C6
F5
P5
G5
C5
11
1
9
8
7
6
5
4
3
2
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
VCC
4
12
13
14
15
16
17
18
19
20
19
18
17
16
15
14
13
12
11
20
19
18
17
16
15
14
13
12
11
47k
470k
R7
R11
22K
R2
4k7
8D
7D
6D
5D
4D
3D
2D
1D
D7
D6
D5
D4
D3
D2
D1
D0
R10
FADTOP
11
1
9
8
7
6
5
4
3
2
2k2
R23
R5
5
1k
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
19
1
2k2
R12
4K7
R4
100nF
C15
5
CONTRAST
100uF
C40
VCC 100R
C
OC
10k
F8
P8
G8
C8
F7
P7
G7
C7
R6
R18
VCC
R1
10uF
C10
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC21
100k
VCC
L3212
L3113
L3014
L2915
L2816
L2717
L2618
L2519
VCC
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
IC8
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
GAL16V8
IC2
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
GAL16V8
IC1
D7
D6
D5
D4
D3
D2
D1
D0
74HC573
11
1
9
8
7
6
5
4
3
2
4
-12
FADGND
1
100R
R13
1
11
12
7
6
8
13
C7
G7
P7
F7
C8
G8
P8
F8
VCC
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC15
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
C1
G1
P1
F1
C2
G2
P2
F2
74HC245
IC12
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
+12
Vin
Vrf(-)
Vrf(+)
MODE
WR/RDY
RD
CS
ADC0820
IC7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
8
6
5
S25
S26
S27
S28
S29
S30
S31
S32
S1
S2
S3
S4
S5
S6
S7
S8
100K
F(1..9)
2
3
TL072
IC6A
R19
-12
4
Vcc
7
TL072
2
3
4
5
6
7
8
9
INT
OFL
9
18
100R
4051
IC10
100R
D7
D6
D5
D4
D3
D2
D1
D0
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
R14
DB
Ne
17
16
15
14
5
4
3
2
R3
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC16
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
C3
G3
P3
F3
C4
G4
P4
F4
74HC245
IC13
DB7
DB6
DB5
DB4
DB3
DB2
DB1
DB0
19
1
6
GM
VCC
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
19
1
6
D0
D1
D2
D3
D4
D5
D6
D7
IC6B
20
S/T
19
3
S9
S10
S11
S12
S13
S14
S15
S16
S33
S34
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
File:
19
1
2
3
4
5
6
7
8
9
Number:ECHPBK1.SC1
D:\R_&_D\Echelon\Echpbk1.sc1
C5
G5
P5
F5
C6
G6
P6
F6
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC17
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC14
7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
4051
IC11
7
Date: 1-Oct-1999
Revision: 0
Echelon PLAYBACK Card
Size: A3
Title
2
3
4
5
6
7
8
9
19
1
IC9
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
74HC574
6
11
10
9
INH
A
B
C
2
F9
7
VEE
1
15
16
3
X
X0
X1
X2
X3
X4
X5
X6
X7
13
14
15
12
1
5
2
4
X
1
11
OC
CLK
3
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
S17
S18
S19
S20
S21
S22
S23
S24
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
2
3
4
5
6
7
8
9
1D
2D
3D
4D
5D
6D
7D
8D
1Q
2Q
3Q
4Q
5Q
6Q
7Q
8Q
VCC
S(1..34)
6
11
10
9
D7 14
D6 13
D5 12
D4 11
D3 10
D2 9
D1 8
D0 7
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Time: 12:05:33 Sheet 1 of 2
8
40X2
LCD0A
A
B
C
D
8
Error : F:\PUBLIC\JANDS.EPS image fil
D7
D6
D5
D4
D3
D2
D1
D0
CARD TYPE
INDENTITY
%01100010
INH
A
B
C
19
18
17
16
15
14
13
12
X0
X1
X2
X3
X4
X5
X6
X7
F1 13
F2 14
F3 15
F4 12
F5 1
F6 5
F7 2
F8 4
7
VEE
5
R/W
VO
RS
E
3
4
6
A
1
S18A
R91
100K
S17A
R90
100K
VCC
100K
100K
S18
R31
R30
VCC
S17
S2A
S1A
2
100K
R92
S19A
VCC
S19
100K
R32
S3A
100K
R93
S20A
VCC
S20
100K
R33
S4A
100K
R94
S21A
VCC
S21
100K
R34
S5A
3
100K
R95
S22A
VCC
S22
100K
R35
S6A
100K
R96
S23A
VCC
S23
100K
R36
S7A
100K
R97
S24A
VCC
S24
100K
R37
S8A
VCC
2K2
100K
R98
4
S25A
VCC
100K
R38
S9A
VCC
S25
S9
L25
VCC
L24
S8
2K2
R74
LED
2K2
R75
LED
100K
R99
S26A
VCC
S26
100K
R39
S10A
VCC
S10
L26
VCC
L23
S7
2K2
R73
LED
2K2
R76
LED
100K
R100
S27A
VCC
S27
100K
R40
S11A
VCC
S11
L27
VCC
L22
S6
2K2
R72
LED
2K2
R77
LED
S28B
2K2
R62
LED
S12B
100K
R101
S28A
VCC
S28
100K
R41
S12A
VCC
S12
L28
VCC
L21
S5
2K2
R71
LED
S27B
2K2
R61
LED
S11B
2K2
R78
LED
S29B
2K2
R63
LED
S13B
5
100K
R102
S29A
VCC
S29
100K
R42
S13A
VCC
S13
L29
VCC
L20
S4
2K2
R70
LED
S26B
2K2
R60
LED
S10B
2K2
R79
LED
S30B
2K2
R64
LED
S14B
100K
R103
S30A
VCC
S30
100K
R43
S14A
VCC
S14
L30
VCC
L19
S3
2K2
R69
LED
S25B
2K2
R59
LED
S9B
2K2
R80
LED
S31B
2K2
R65
LED
S15B
100K
R104
S31A
VCC
S31
100K
R44
S15A
VCC
S15
L31
B
S2
L18
2K2
R68
S24B
2K2
R58
LED
S8B
2K2
R81
LED
S32B
2K2
R66
LED
S16B
6
10K
2K2
R82
LED
10K
10K
10K
R47
100K
R46
100K
100nF
C36
VCC
100nF
C28
VCC
100nF
C19
VCC
10K
10K
10K
7
100nF
C37
VCC
100nF
C29
VCC
100nF
C20
VCC
100nF
C6
F6
100nF
C38
VCC
100nF
C30
VCC
100nF
C21
VCC
100nF
C7
F7
8
100nF
C31
VCC
100nF
C22
VCC
100nF
C9
F9
8
100nF
C32
VCC
100nF
C23
VCC
10K
100nF
C8
F8
Protel Technology Inc.
4675 Stevens Creek Blvd.
Suite 200
Santa Clara, CA 95051
USA
Time: 12:06:24 Sheet 2 of 2
100nF
C5
F5
Date: 1-Oct-1999
Number: ECHPBK1.SC2Revision: 0
File: D:\R_&_D\Echelon\Echpbk1.sc2
Size: A3
Echelon PLAYBACK Card
S34A
100nF
100nF
S33A
VCC
S34
C35
VCC
VCC
C34
100nF
100nF
C27
VCC
C26
VCC
VCC
100nF
C18
100nF
100nF
VCC
-12
C43
10uF
100nF
C4
F4
C25
C17
100nF
VCC
10uF
+12
C42
100nF
C3
F3
C16
VCC
C41
10uF
VCC
C2
100nF
100nF
F2
C1
F1
S33B
VCC
S33
Title
100K
R105
S32A
VCC
S32
100K
R45
S16A
10K
7
FAD1 FAD2 FAD3 FAD4 FAD5 FAD6 FAD7 FAD8 FAD9
FADGND
F(1..9)
FADTOP
6
VCC
S16
L32
VCC
L17
S1
L2
2K2
L3
LED
L4
R67
L5
LED
L6
R66a
L7
LED
L8
S23B
2K2
R57
LED
S7B
L9
S22B
2K2
R56
LED
S6B
L10
S21B
2K2
R55
LED
S5B
L11
S20B
2K2
R54
LED
S4B
L12
S19B
2K2
R53
LED
S3B
5
L13
S18B
2K2
R52
LED
S2B
4
L14
S17B
2K2
R51
LED
S1B
3
L15
S(1..34)
L(1..33)
2
L16
C
D
1
L1
L33
100nF
C33
VCC
100nF
C24
VCC
A
B
C
D
Appendix E
Circuit Diagrams and Overlays
E-9
ECHPBAK2 Circuit diagrams and overlays
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
14
19
20
17
15
18
RW
-12
+12
DS
ALE
MUX
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
4X.1 RA
CONN3
1
2
3
4
1
2
3
4
4X.1 RA
1
TL072
IC6B
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
+12
MUX
+5
R/W
D7
GND
D4
D3
GND
D0
L(1..33)
CONN2
7
2
3
5
6
8
9
11
12
13
16
1
4
7
10
IDC20
CONN1
-12
DS
ALE
+5
D6
D5
GND
D2
D1
GND
5
D
6
16
18
17
16
15
14
13
12
11
8D
7D
6D
5D
4D
3D
2D
1D
2
3
4
5
6
7
8
9
L1612
L1513
L1414
L1315
L1216
L1117
L1018
L9 19
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
DB
B0
B1
B2
B3
B4
B5
B6
B7
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
IC3
VR1
10K
11
1
9
8
7
6
5
4
3
2
11
1
74HC245
IC4
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
C
OC
Variable resistor VR1
replaced by wire link on
some boards
15
40X2
LCD0B
11
1
DD79
DD68
DD57
DD46
DD35
DD24
DD13
DD02
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
74HC573
IC22
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
2
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
1
11
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
D7
D6
D5
D4
D3
D2
D1
D0
12
13
14
15
16
17
18
19
1D
2D
3D
4D
5D
6D
7D
8D
OC
C
19
18
17
16
15
14
13
12
10K
1Q
2Q
3Q
4Q
5Q
6Q
7Q
8Q
R129
C
B
A
E3
E2
E1
10K
3
2
1
6
5
4
IC5
F4
P4
G4
C4
F3
P3
G3
C3
R130
74HC573
IC8
19
1
D0
D1
D2
D3
D4
D5
D6
D7
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
D7
D6
D5
D4
D3
D2
D1
D0
IC19
9
8
7
6
5
4
3
2
74HC573
F2
P2
G2
C2
F1
P1
G1
C1
IC18
LCD BACKLIGHT
12
13
14
15
16
17
18
L3319
L8 12
L7 13
L6 14
L5 15
L4 16
L3 17
L2 18
L1 19
11
1
JP1
10K
3
R109
10K
10K
10K
R106
R110
R107
R111
CARD
SELECT
SHUNT
3
2
1
0
L2412
L2313
L2214
L2115
L2016
L1917
L1818
L1719
VCC
10K
7
9
10
11
12
13
14
15
R9
100k
D7
D6
D5
D4
D3
D2
D1
D0
10K
R108
Y7
Y6
Y5
Y4
Y3
Y2
Y1
Y0
74HC138
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
9
8
7
6
5
4
3
2
10K
R112
10K
R113
10K
R114
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC20
10K
R117
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
10K
R115
10K
R116
F6
P6
G6
C6
F5
P5
G5
C5
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
10K
R120
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
10K
R118
10K
4
GAL16V8
IC2
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
GAL16V8
IC1
D7
D6
D5
D4
D3
D2
D1
D0
R119
11
1
9
8
7
6
5
4
3
2
4
20
19
18
17
16
15
14
13
12
11
20
19
18
17
16
15
14
13
12
11
10K
R121
10K
R122
10K
R123
VCC
VCC
F8
P8
G8
C8
F7
P7
G7
C7
10K
R124
10K
R125
10K
R126
VCC
R1
10uF
C10
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC21
100k
VCC
L3212
L3113
L3014
L2915
L2816
L2717
L2618
L2519
FADGND
100nF
100uF
C40
C15
100R
10K
47K
R134
VCC
5
4M7 4M7 22K
R127
10K
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
R10
VCC
FADTOP
11
1
D7
D6
D5
D4
D3
D2
D1
D0
R131 R132 R133
R128
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
9
8
7
6
5
4
3
2
5
22K
10K
R2
R6
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
+12
Vin
Vrf(-)
Vrf(+)
MODE
WR/RDY
RD
CS
ADC0820
IC7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
S25
S26
S27
S28
S29
S30
S31
S32
S1
S2
S3
S4
S5
S6
S7
S8
100K
2
3
4
5
6
7
8
9
2k2
6
R12
4K7
INT
OFL
9
18
4051
IC10
D7
D6
D5
D4
D3
D2
D1
D0
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
100R
R14
DB
Ne
17
16
15
14
5
4
3
2
100R
R3
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC16
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
C3
G3
P3
F3
C4
G4
P4
F4
74HC245
IC13
DB7
DB6
DB5
DB4
DB3
DB2
DB1
DB0
19
1
2k2
-12
2
3
4
5
6
7
8
9
19
1
R4
GM
VCC
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
6
R23
1k
R5
F(1..9)
2
3
TL072
IC6A
R19
-12
CONTRAST
4k7
47k
R18
470k
R7
1
100R
R13
1
11
12
7
6
8
13
C7
G7
P7
F7
C8
G8
P8
F8
VCC
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC15
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
C1
G1
P1
F1
C2
G2
P2
F2
74HC245
IC12
R11
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
8
4
Vcc
20
S/T
19
3
S9
S10
S11
S12
S13
S14
S15
S16
S33
S34
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
19
1
2
3
4
5
6
7
8
9
A3 Number: ECHPBK2.SC1
File:H:\LAB\ECHELON\CIRCUIT\Echpbk2.sc1
C5
G5
P5
F5
C6
G6
P6
F6
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC17
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC14
7
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
4051
IC11
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
7
Date: 1-Oct-1999
Revision: 2
Echelon PLAYBACK Card
Size:
Title
2
3
4
5
6
7
8
9
19
1
IC9
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
74HC574
6
11
10
9
INH
A
B
C
2
F9
7
VEE
1
3
X
X0
X1
X2
X3
X4
X5
X6
X7
13
14
15
12
1
5
2
4
X
1
11
OC
CLK
3
S17
S18
S19
S20
S21
S22
S23
S24
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
2
3
4
5
6
7
8
9
1D
2D
3D
4D
5D
6D
7D
8D
1Q
2Q
3Q
4Q
5Q
6Q
7Q
8Q
VCC
S(1..34)
6
11
10
9
D7 14
D6 13
D5 12
D4 11
D3 10
D2 9
D1 8
D0 7
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Sheet 1 of 2
8
VCC
8
C
D
40X2
A
B
LCD0A
Drawn By: D.Timmins
D7
D6
D5
D4
D3
D2
D1
D0
CARD TYPE
INDENTITY
%01100010
INH
A
B
C
19
18
17
16
15
14
13
12
X0
X1
X2
X3
X4
X5
X6
X7
F1 13
F2 14
F3 15
F4 12
F5 1
F6 5
F7 2
F8 4
7
VEE
5
R/W
VO
RS
E
3
4
6
1
VCC
100K
100K
S18A
R91
100K
S17A
R90
100K
VCC
R31
R30
S18
S2A
S1A
VCC
S19
2
100K
R92
S19A
100K
R32
S3A
VCC
S20
100K
R93
S20A
100K
R33
S4A
VCC
S21
100K
R94
S21A
100K
R34
S5A
VCC
S22
VCC
3
100K
R95
S22A
100K
R35
S6A
VCC
S23
VCC
100K
R96
S23A
100K
R36
S7A
L24
VCC
VCC
S24
S8
100K
R97
S24A
100K
R37
S8A
2K2
R73
VCC
100K
R98
4
S25A
100K
R38
S9A
2K2
R74
VCC
S25
S9
L25
VCC
L23
S7
2K2
R72
VCC
S26
100K
R99
S26A
100K
R39
S10A
2K2
R75
VCC
S10
L26
VCC
L22
S6
2K2
R71
LED
S26B
VCC
S27
100K
R100
S27A
100K
R40
S11A
2K2
R76
LED
S27B
VCC
S11
L27
VCC
L21
S5
2K2
R70
LED
S25B
2K2
R61
VCC
S28
100K
R101
S28A
100K
R41
S12A
2K2
R77
LED
S28B
2K2
R62
LED
S12B
VCC
S12
L28
VCC
L20
S4
2K2
R69
LED
S24B
2K2
R60
LED
S11B
5
VCC
S29
100K
R102
S29A
100K
R42
S13A
2K2
R78
LED
S29B
2K2
R63
LED
S13B
VCC
S13
L29
VCC
L19
S3
2K2
R68
LED
S23B
2K2
R59
LED
S10B
VCC
S30
100K
R103
S30A
100K
R43
S14A
2K2
R79
LED
S30B
2K2
R64
LED
S14B
VCC
S14
L30
S17
S2
L18
2K2
LED
S22B
2K2
R58
LED
S9B
VCC
S31
100K
R104
S31A
100K
R44
S15A
2K2
R80
LED
S31B
2K2
R65
LED
S15B
VCC
S15
L31
A
L17
S1
L2
R67
L3
2K2
L4
R66a
L5
LED
L6
S21B
L7
LED
L8
S20B
2K2
R57
LED
S8B
L9
LED
2K2
R56
LED
S7B
L10
S19B
2K2
R55
LED
S6B
L11
LED
2K2
R54
LED
S5B
L12
S18B
2K2
R53
LED
S4B
L13
LED
2K2
R52
LED
S3B
5
L14
S17B
2K2
R51
LED
S2B
4
6
VCC
S32
7
8
100K
R46
S33A
VCC
S34
100K
R47
A3 Number: ECHPBK2.SC2
File:H:\LAB\ECHELON\CIRCUIT\Echpbk2.sc2
100nF
C36
VCC
100nF
C28
VCC
100nF
C19
VCC
100nF
C5
F5
100nF
C37
VCC
100nF
C29
VCC
100nF
C20
VCC
100nF
C6
F6
100nF
C38
VCC
100nF
C30
VCC
100nF
C21
VCC
100nF
C7
F7
100nF
C31
VCC
100nF
C22
VCC
7
100nF
C32
VCC
100nF
C23
VCC
100nF
C9
F9
100nF
C33
VCC
100nF
C24
VCC
8
Drawn By: D.Timmins
100nF
C8
F8
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Revision: 2
Ph (02) 9582-0909
Date: 30-Sep-1999
Sheet 2 of 2
100nF
S34A
C35
100nF
VCC
VCC
C34
100nF
100nF
C27
VCC
C26
VCC
VCC
100nF
C18
100nF
100nF
VCC
-12
C43
10uF
100nF
C4
F4
C25
C17
100nF
VCC
C16
VCC
+12
C42
10uF
100nF
C3
F3
Echelon PLAYBACK Card
VCC
2K2
R82
LED
S33B
VCC
C41
10uF
C2
100nF
100nF
F2
C1
F1
FAD1
FAD2
FAD3
FAD4
FAD5
FAD6
FAD7
FAD8
FAD9
10K
10K
10K
10K
10K
10K
10K
10K
10K
S33
Size:
Title
100K
R105
S32A
100K
R45
S16A
2K2
R81
LED
S32B
2K2
R66
LED
S16B
FADGND
F(1..9)
FADTOP
6
VCC
S16
L32
B
L1
LED
S1B
3
L15
S(1..34)
L(1..33)
2
L16
C
D
1
L33
A
B
C
D
Appendix E
Circuit Diagrams and Overlays
E - 10
MLCMENU1 Circuit diagrams and overlays
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
D
RW
-12
+12
DS
ALE
MUX
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
IDC20
14
19
20
17
15
18
2
3
5
6
8
9
11
12
13
16
1
4
7
10
CONN1
1
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
1L(1..16)
2L(1..16)
B0
B1
B2
B3
B4
B5
B6
B7
74HC245
A0
A1
A2
A3
A4
A5
A6
A7
6
5
4
3
2
1
C
B
A
E3
E2
E1
Y7
Y6
Y5
Y4
Y3
Y2
Y1
Y0
IC5 74HC138
7
9
10
11
12
13
14
15
JP1
100k
R14
11
1
VCC
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
C18 C19 C20 C21 C22 C23
2
1
0
CARD SEL
C13 C14 C15 C16 C17 C9
12
13
14
15
16
17
18
19
VCC
C
OC
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC20
VCC
VCC
VCC
2
VCC
VCC
VCC
VCC
VCC
VCC
3
VCC
VCC
VCC
VCC
VCC
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
11
1
9
8
7
6
5
4
3
2
D7
D6
D5
D4
D3
D2
D1
D0
VCC
VCC
4
10uF
4
C30
VCC
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
GAL16V8
IC2
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
GAL16V8
IC1
100nF 100nF 100nF 100nF 100nF 100nF
C8
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
19
1
D0
D1
D2
D3
D4
D5
D6
D7
11
1
8D
7D
6D
5D
4D
3D
2D
1D
2L812
2L713
2L614
2L515
2L416
2L317
2L218
2L119
VCC
C7
E
DIR
2
3
4
5
6
7
8
9
C
OC
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
D7
D6
D5
D4
D3
D2
D1
D0
VCC
C6
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
74HC574
IC3
18
17
16
15
14
13
12
11
8D
7D
6D
5D
4D
3D
2D
1D
9
8
7
6
5
4
3
2
3
100nF 100nF 100nF 100nF 100nF 100nF 100nF 100nF 100nF 100nF
C4
11
1
DD79
DD68
DD57
DD46
DD35
DD24
DD13
DD02
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
1L16
12
1L15
13
1L14
14
1L13
15
1L12
16
1L11
17
1L10
18
1L919
IC19
D7
D6
D5
D4
D3
D2
D1
D0
74HC573
9
8
7
6
5
4
3
2
IC18
IC4
1L812
1L713
1L614
1L515
1L416
1L317
1L218
1L119
2
20
19
18
17
16
15
14
13
12
11
20
19
18
17
16
15
14
13
12
11
R1
10uF
C1
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC21
VCC
100k
VCC
2L16
12
2L15
13
2L14
14
2L13
15
2L12
16
2L11
17
2L10
18
2L919
1
2
3
4
4X.1 RA
CONN2
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
11
1
9
8
7
6
5
4
3
2
5
D7
D6
D5
D4
D3
D2
D1
D0
5
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
TO LCD BACKLIGHT
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
LCD1B
40X2
LCD0B
40X2
15
16
1
15
16
B0
B1
B2
B3
B4
B5
B6
B7
6
D7
D6
D5
D4
D3
D2
D1
D0
2
3
4
5
6
7
8
9
18
17
16
15
14
13
12
11
2S1
2S2
2S3
2S4
2S5
2S6
2S7
2S8
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
7
8
9
E
DIR
File:
7
12
13
14
15
16
17
18
19
R149
R4
4K7
R5
10K
R6
22K
47K
R148
R145
4K7
R146
10K
R147
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
18
17
16
15
14
13
12
11
18
17
16
15
14
13
12
11
22K
47K
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
VCC
2S(1..16)
11+
22+
1
CARD TYPE
INDENTITY
%01100001
8
A
B
C
D
8
Error : F:\PUBLIC\JANDS.EPS image fil
1S(1..16)
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Time: 10:59:56 Sheet 1 of 2
74HC573
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
IC8
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC17
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC14
Date: 1-Oct-1999
Number:MLCMENU1.SC1 Revision: 0
H:\LAB\ECHELON\CIRCUIT\Mlcmenu1.sc1
Size: A3
Echelon MENU Card
-12
2k2
2k2
R49
4k7
1k
R11
4k7
R50
1k
R8
R12
-12
R153
11
1
9
8
7
6
5
4
3
2
2k2
D7
D6
D5
D4
D3
D2
D1
D0
19
1
2
3
4
5
6
7
8
9
19
1
2
3
4
5
6
7
8
9
R154
R9
D7
D6
D5
D4
D3
D2
D1
D0
40X2
LCD1A
4
3
2
1
Title
CONTRAST
14
13
12
11
10
9
8
7
D0
D1
D2
D3
D4
D5
D6
D7
2S9
2S10
2S11
2S12
2S13
2S14
2S15
2S16
18
17
16
15
14
13
12
11
2k2
D7
D6
D5
D4
D3
D2
D1
D0
E
DIR
B0
B1
B2
B3
B4
B5
B6
B7
B0
B1
B2
B3
B4
B5
B6
B7
D0
D1
D2
D3
D4
D5
D6
D7
1S9
1S10
1S11
1S12
1S13
1S14
1S15
1S16
18
17
16
15
14
13
12
11
7
4X.1 RA
CONN3
D7
D6
D5
D4
D3
D2
D1
D0
14
13
12
11
10
9
8
7
LCD0A
40X2
19
1
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
E
DIR
IC16
B0
B1
B2
B3
B4
B5
B6
B7
19
1
A0
A1
A2
A3
A4
A5
A6
A7
IC15
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
D0
D1
D2
D3
D4
D5
D6
D7
IC13
1S1
1S2
1S3
1S4
1S5
1S6
1S7
1S8
74HC245
18
17
16
15
14
13
12
11
6
IC12
5
R/W
E
RS
VO
6
4
3
5
R/W
VO
RS
E
3
4
6
1
1S3
1S2
1S1
2
1S4
100K
R93
1S5
100K
100K
R94
1S6
R92
3
100K
R95
1S7
2S2
100K
100K
R96
1S8
S23A
VCC
100K
R97
S24A
1S9
S22A
VCC
100K
R37
VCC
100K
R98
4
S25A
100K
R38
1S10
S21A
VCC
100K
R36
100K
R99
S26A
VCC
100K
R39
1S11
R91
S20A
VCC
100K
R35
100K
R100
S27A
VCC
100K
R40
1S12
100K
S19A
VCC
100K
R34
S11A
100K
R101
S28A
VCC
100K
R41
S12A
VCC
2K2
1S13
R90
VCC
100K
R33
S10A
VCC
2K2
2S13
5
VCC
VCC
100K
R102
S29A
100K
R42
S13A
2K2
R78
LED
1S14
S18A
VCC
100K
R32
S9A
VCC
2K2
R77
LED
S29B
2K2
R63
LED
S13B
VCC
VCC
100K
R103
S30A
100K
R43
S14A
2K2
R79
LED
S30B
2K2
R64
LED
S14B
1S15
S17A
VCC
100K
S8A
VCC
2K2
R76
LED
S28B
2K2
R62
LED
S12B
100K
R104
S31A
VCC
100K
R44
S15A
VCC
2K2
R80
LED
S31B
2K2
R65
LED
S15B
1S16
A
2S(1..16)
2L1
S7A
2L8
VCC
2L9
S6A
2L7
VCC
2K2
2L10
S5A
2L6
VCC
2K2
R75
LED
2L11
R31
S4A
2L5
VCC
2K2
R74
LED
2L12
100K
S3A
2L4
VCC
2K2
R73
LED
S27B
2K2
R61
LED
S11B
2L13
S2A
2L3
VCC
2K2
R72
LED
S26B
2K2
R60
LED
S10B
2L14
R30
2L2
VCC
2K2
R71
LED
S25B
2K2
R59
LED
S9B
2L15
B
1L1
R70
S24B
2K2
R58
LED
S8B
5
6
6
File:
VCC
2-
VCC
1-
100K
R107
S36A
100K
R47
S34A
2-
2+
1-
1+
7
H:\LAB\ECHELON\CIRCUIT\Mlcmenu1.sc2
7
Date: 1-Oct-1999
Number:MLCMENU1.SC2 Revision: 0
Echelon MENU Card
100K
R106
S35A
VCC
Size: A3
Title
100K
R105
S32A
VCC
100K
100K
2+
R46
R45
VCC
1+
S33A
2K2
R81
LED
S32B
2K2
R66
LED
S16B
S16A
VCC
2L16
S1A
1L2
VCC
1L3
2K2
1L4
2K2
1L5
LED
1L6
R69
1L7
LED
S23B
2K2
R57
LED
S7B
1L8
R68
S22B
2K2
R56
LED
S6B
1L9
LED
S21B
2K2
R55
LED
S5B
1L10
R67
S20B
2K2
R54
LED
S4B
1L11
LED
S19B
2K2
R53
LED
S3B
1L12
R66a
S18B
2K2
R52
LED
S2B
4
1L13
LED
S17B
2K2
R51
LED
S1B
3
1L14
1S(1..16)
2L(1..16)
1L(1..16)
2
1L15
C
D
1
1L16
2S16
2S15
2S14
2S12
2S11
2S10
2S9
2S8
2S7
2S6
2S5
2S4
2S3
2S1
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Time: 11:01:04 Sheet 2 of 2
A
B
C
D
8
Error : F:\PUBLIC\JANDS.EPS image fil
8
Appendix E
Circuit Diagrams and Overlays
E - 11
ECHMENU2 Circuit diagrams and overlays
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
D
RW
-12
+12
DS
ALE
MUX
D0
D1
D2
D3
D4
D5
D6
D7
VCC
VCC
GND
GND
GND
GND
IDC20
14
19
20
17
15
18
2
3
5
6
8
9
11
12
13
16
1
4
7
10
CONN1
1L(1..16)
2L(1..16)
1
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
1
B0
B1
B2
B3
B4
B5
B6
B7
74HC245
C6
CLK
OC
8D
7D
6D
5D
4D
3D
2D
1D
C7
74HC574
IC3
18
17
16
15
14
13
12
11
IC4
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
A0
A1
A2
A3
A4
A5
A6
A7
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
2
3
4
5
6
7
8
9
8D
7D
6D
5D
4D
3D
2D
1D
C8
E
DIR
19
1
D0
D1
D2
D3
D4
D5
D6
D7
11
1
VCC
6
5
4
3
2
1
C
B
A
E3
E2
E1
Y7
Y6
Y5
Y4
Y3
Y2
Y1
Y0
IC5 74HC138
7
9
10
11
12
13
14
15
JP1
VCC
VCC
VCC
VCC
2
VCC
VCC
VCC
VCC
VCC
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
100k
R14
11
1
9
8
7
6
5
4
3
2
3
VCC
VCC
D7
D6
D5
D4
D3
D2
D1
D0
2L812
2L713
2L614
2L515
2L416
2L317
2L218
2L119
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC20
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
3
VCC
VCC
VCC
VCC
VCC
11
1
9
8
7
6
5
4
3
2
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
VCC
10uF
VCC
D7
D6
D5
D4
D3
D2
D1
D0
VCC
4
4
C30
GAL16V8
IC2
RW
ALEH
DS
DEC
A3
A2
A1
A0
GND
GAL16V8
100nF 100nF 100nF 100nF 100nF 100nF
VCC
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
IC1
C18 C19 C20 C21 C22 C23
2
1
0
CARD SEL
C13 C14 C15 C16 C17 C9
12
13
14
15
16
17
18
19
C
OC
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
1L16
12
1L15
13
1L14
14
1L13
15
1L12
16
1L11
17
1L10
18
1L919
IC19
D7
D6
D5
D4
D3
D2
D1
D0
74HC573
9
8
7
6
5
4
3
2
IC18
100nF 100nF 100nF 100nF 100nF 100nF 100nF 100nF 100nF 100nF
C4
11
1
DD79
DD68
DD57
DD46
DD35
DD24
DD13
DD02
DD0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
1L812
1L713
1L614
1L515
1L416
1L317
1L218
1L119
2
20
19
18
17
16
15
14
13
12
11
20
19
18
17
16
15
14
13
12
11
R1
10uF
C1
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
74HC573
IC21
VCC
100k
VCC
2L16
12
2L15
13
2L14
14
2L13
15
2L12
16
2L11
17
2L10
18
2L919
11
1
1
2
3
4
4X.1 RA
CONN2
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
9
8
7
6
5
4
3
2
5
D7
D6
D5
D4
D3
D2
D1
D0
5
1
VCC
2
VSS
VCC
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
19
1
9
7
8
2
3
4
5
6
19
1
2
3
4
5
6
7
8
9
40X2
LCD0B
TO LCD BACKLIGHT
15
16
15
16
B0
B1
B2
B3
B4
B5
B6
B7
6
D7
D6
D5
D4
D3
D2
D1
D0
2
3
4
5
6
7
8
9
18
17
16
15
14
2S1
2S2
2S3
2S4
2S5
2S6
2S7
2S8
D0
D1
D2
D3
D4
D5
D6
D7
2
3
4
5
6
D7
D6
D5
D4
D3
D2
D1
D0
40X2
4
3
2
1
4X.1 RA
LCD1B
40X2
14
13
12
11
10
9
8
7
LCD0A
B7
B5
B6
CONN3
E
DIR
A7
A5
A6
D7
D6
D5
D4
D3
D2
D1
D0
11
13
12
D7
D6
D5
D4
D3
D2
D1
D0
E
DIR
A7
A5
A6
11
13
12
2k2
-12
R8
2k2
4k7
1k
R11
4k7
R49
1k
R50
R153
2k2
11
1
9
8
7
6
5
4
3
2
19
1
9
7
8
2
3
4
5
6
19
1
2
3
4
5
6
7
8
9
R154
1
2
R9
2k2
R12
-12
VSS
VCC
VCC
D7
D6
D5
D4
D3
D2
D1
D0
D0
D1
D2
D3
D4
D5
D6
D7
2S9
2S10
2S11
2S12
2S13
2S14
2S15
2S16
18
17
16
15
14
lcd1A
LCD40X2
B7
B5
B6
B0
B1
B2
B3
B4
B0
B1
B2
B3
B4
B5
B6
B7
D0
D1
D2
D3
D4
D5
D6
D7
1S9
1S10
1S11
1S12
1S13
1S14
1S15
1S16
18
17
16
15
14
13
12
11
7
B7
A7
74HC573
C
OC
8D
7D
6D
5D
4D
3D
2D
1D
IC8
12
13
14
15
16
17
18
19
R149
R4
4K7
R5
10K
R6
22K
47K
R148
R145
4K7
R146
10K
R147
8Q
7Q
6Q
5Q
4Q
3Q
2Q
1Q
11
13
12
18
17
16
15
14
18
17
16
15
14
13
12
11
22K
47K
B5
B6
A5
A6
E
DIR
B0
B1
B2
B3
B4
B0
B1
B2
B3
B4
B5
B6
B7
A0
A1
A2
A3
A4
74HC245
IC17
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
IC14
VCC
2S(1..16)
11+
22+
Echelon MENU Card
7
1
CARD TYPE
INDENTITY
%01100001
8
8
Drawn By:D.Timmins
1S(1..16)
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Size: A3 Number: ECHMENU2.SC1 Revision: 0
Ph (02) 9582-0909
File:H:\LAB\ECHELON\CIRCUIT\Echmenu2.sc1
Date: 30-Sep-1999
Sheet 1 of 2
Title
CONTRAST
14
13
12
11
10
9
8
7
19
1
9
7
8
A0
A1
A2
A3
A4
74HC245
A0
A1
A2
A3
A4
74HC245
E
DIR
IC16
B0
B1
B2
B3
B4
19
1
A0
A1
A2
A3
A4
A5
A6
A7
IC15
E
DIR
A0
A1
A2
A3
A4
A5
A6
A7
74HC245
D0
D1
D2
D3
D4
D5
D6
D7
IC13
1S1
1S2
1S3
1S4
1S5
1S6
1S7
1S8
74HC245
18
17
16
15
14
13
12
11
6
IC12
5
R/W
E
RS
VO
6
4
3
5
R/W
VO
RS
3
4
E
6
A
B
C
D
1
VCC
1S4
1S3
1S2
1S1
2
1S5
100K
R94
1S6
100K
3
100K
R95
1S7
R93
100K
R96
1S8
100K
100K
R97
S24A
1S9
R92
S23A
VCC
VCC
100K
R98
4
S25A
1S10
2S2
100K
S22A
VCC
VCC
100K
R99
S26A
100K
R39
1S11
R91
S21A
VCC
100K
R38
VCC
100K
R100
S27A
100K
R40
1S12
100K
S20A
VCC
100K
R37
VCC
100K
R101
S28A
100K
R41
S12A
1S13
R90
S19A
VCC
100K
R36
S11A
VCC
2K2
R77
2S13
5
VCC
VCC
100K
R102
S29A
100K
R42
S13A
2K2
R78
1S14
S18A
VCC
100K
R35
S10A
VCC
2K2
R76
LED
S29B
2K2
R63
LED
S13B
VCC
VCC
100K
R103
S30A
100K
R43
S14A
2K2
R79
LED
S30B
2K2
R64
LED
S14B
1S15
S17A
VCC
100K
R34
S9A
VCC
2K2
R75
LED
S28B
2K2
R62
LED
S12B
VCC
VCC
100K
R104
S31A
100K
R44
S15A
2K2
R80
LED
S31B
2K2
R65
LED
S15B
1S16
A
2S(1..16)
2L1
100K
VCC
2L9
R33
S8A
2L8
VCC
2K2
R74
2L10
100K
S7A
2L7
VCC
2K2
R73
2L11
R32
S6A
2L6
VCC
2K2
R72
2L12
100K
S5A
2L5
VCC
2K2
R71
LED
S27B
2K2
R61
LED
S11B
2L13
R31
S4A
2L4
VCC
2K2
R70
LED
S26B
2K2
R60
LED
S10B
2L14
100K
S3A
2L3
VCC
2K2
R69
LED
S25B
2K2
R59
LED
S9B
2L15
R30
S2A
2L2
VCC
2K2
R68
LED
S24B
2K2
R58
LED
S8B
5
6
6
VCC
VCC
100K
R106
S35A
VCC
100K
R107
S36A
100K
R47
S34A
Echelon MENU Card
VCC
2-
VCC
1-
2-
2+
1-
1+
7
7
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Size: A3 Number: ECHMENU2.SC2 Revision: 0
Ph (02) 9582-0909
File:H:\LAB\ECHELON\CIRCUIT\Echmenu2.sc2
Date: 30-Sep-1999
Sheet 2 of 2
Title
100K
R105
S32A
100K
100K
2+
R46
R45
VCC
1+
S33A
2K2
R81
LED
S32B
2K2
R66
LED
S16B
S16A
2L16
B
1L1
S1A
1L2
VCC
1L3
2K2
1L4
R67
1L5
2K2
1L6
R66a
1L7
LED
S23B
2K2
R57
LED
S7B
1L8
LED
S22B
2K2
R56
LED
S6B
1L9
LED
S21B
2K2
R55
LED
S5B
1L10
LED
S20B
2K2
R54
LED
S4B
1L11
LED
S19B
2K2
R53
LED
S3B
1L12
LED
S18B
2K2
R52
LED
S2B
4
1L13
LED
S17B
2K2
R51
LED
S1B
3
1L14
1S(1..16)
2L(1..16)
1L(1..16)
2
1L15
C
D
1
1L16
2S16
2S15
2S14
2S12
2S11
2S10
2S9
2S8
2S7
2S6
2S5
2S4
2S3
2S1
8
Drawn By: D.Timmins
8
A
B
C
D
Appendix E
Circuit Diagrams and Overlays
E - 12
BAKLITE3 Circuit diagrams and overlay
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
COM
CONTROL
+12V
1
2
3
C8
2200uF
1
6
5
470K
R14
U1C
D3
BAV103
470K
R7
5.5V->
100K
R3
7
9
10
4K7
R10
4K7
R12
R18
10K
C10
1uF
R19
2K2
C4
1uF
5.0V->
U1A
8
10K
R5
3
2
U1D
C9
100nF
MKS2
100K
R6
R4
10K
100K
R8
10K
R1
10K
R2
10K
R20
1
2
470K
R17
BAV103
D2
C3
100nF
470K
R16
470K
R21
D
C5
1uF
2
4
C6
1uF
13 U1B
11
12
R15
220R
14
C7
1uF
10K
R24
D1
BAV103
R9
4K7
1K
R11
1
R22
10K
BAV103
D4
Q1
BCX19
R13
220R
G
G
Q3
Q2
C1
MOSFETS: N-Channel,
1
File:
Number:backlight3.SCH
3
H:\LAB\ECHELON\CIRCUIT\Baklite3.sch
Size: A4
BACKLIGHT DRIVER
Title
S
D
S
D
3
2200uF
C2
2200uF
4
Date: 1-Oct-1999
Revision:v3.0
TX2
14:240
4
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Sheet 1 of 1
RFD14N05SM
MTD3055V
Vds 50V min
Rds 0.25 Ohms max
1
eg. IRFR014
STD12N05
4
TX1
14:240
4
Drawn By: Doug Ford
A
B
C
D
Appendix E
Circuit Diagrams and Overlays
E - 13
BKLTSML2 Circuit diagrams and overlay
Revision 3 - 11 April 2000
ECHELON / HOG 1000/500
TECHNICAL MANUAL
A
B
C
D
1
1
Seiko 5C
INV1
Output 2
Output 1
TO BACKLIGHT
100-300VAC
10uF
C2
10uF
C1
2
BCX19
U1p
220R
R4
10k
BCX17
T1p
Q2
R5
Q1
10k
R3
100R
100R
+12
R1
R2
+12
2
+12
File:
Number:bkltsml0
3
H:\LAB\EVENT4\CIRCUIT\Bkltsml2.sch
Size: A4
Small Backlight driver
Title
3
-12
Date: 30-Sep-1999
Revision:0
4
Jands Electronics P/L
40 Kent Rd
Mascot NSW 2020
Australia
Ph (02) 9582-0909
Sheet 1 of 1
4
Drawn By:
A
B
C
D
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising