Material Safety Data Sheet BIOGUARD® SOFTSWIM® FILTER CLEANER

Material Safety Data Sheet BIOGUARD® SOFTSWIM® FILTER CLEANER
Material Safety Data Sheet
BIOGUARD® SOFTSWIM® FILTER CLEANER
Version: 1.2
Revision Date: 01/01/2014
Print Date: 03/05/2014
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Product name:
BIOGUARD® SOFTSWIM® FILTER CLEANER
Product Use Description:
Recreational Water Product
Company:
Bio-Lab, Inc.
BioGuard
P.O. Box 300002
Lawrenceville, GA
30049-1002
Telephone: (800) 859-7946
Emergency telephone
number:
CHEMTREC: (24 hours) 800-424-9300, 703-527-3887
Poison Control Center (Medical) :: (877) 800-5553
Customer Care: 800-998-7946
For additional emergency telephone numbers see section 16 of the Safety Data Sheet.
Prepared by
Product Safety Department
01/01/2014
SECTION 2. HAZARDS IDENTIFICATION
Emergency Overview
Danger
Form: liquid
Colour: pink
Odour: pungent
:
Hazard Summary
Corrosive
May be fatal if swallowed.
Causes eye burns.
Causes skin burns.
Causes respiratory tract irritation.
Avoid breathing vapors.
Do not get in eyes, on skin, or on clothing.
:
OSHA Hazards
THIS MATERIAL IS HAZARDOUS UNDER THE CRITERIA OF THE FEDERAL
OSHA HAZARD COMMUNICATION STANDARD 29CFR 1910.1200.
Potential Health Effects
Primary Routes of Entry
SAP 6.0
: Skin contact
Eye contact
Inhalation
1/8
SDS Number: 000000006652
Material Safety Data Sheet
BIOGUARD® SOFTSWIM® FILTER CLEANER
Version: 1.2
Revision Date: 01/01/2014
Print Date: 03/05/2014
Ingestion
Inhalation
: Causes respiratory tract irritation.
Skin
: Causes skin burns.
Eyes
: Causes serious eye damage.
Ingestion
: May be fatal if swallowed.
Chronic Exposure
: None known.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components
Component / CAS-No.
Weight percent
< 15 %
orthophosphoric acid
7664-38-2
hydrogen chloride
7647-01-0
< 15 %
SECTION 4. FIRST AID MEASURES
First aid procedures
Inhalation
: Remove to fresh air.
Give oxygen or artificial respiration if needed.
Call a POISON CENTER or doctor/ physician.
Skin contact
: Remove contaminated clothing and shoes.
Rinse immediately with plenty of water for at least 15 minutes.
Call a POISON CENTER or doctor/ physician.
Eye contact
: Rinse immediately with plenty of water, also under the eyelids, for at least 15
minutes.
Remove contact lenses, if present, after the first 5 minutes, then continue rinsing
eye.
Call a POISON CENTER or doctor/ physician.
Ingestion
: Call a physician or poison control centre immediately.
DO NOT induce vomiting unless directed to do so by a physician or poison
control center.
Have person sip a glass of water if able to swallow.
Never give anything by mouth to an unconscious person.
Notes to physician
Treatment
SAP 6.0
: Probable mucosal damage may contraindicate the use of gastric lavage.
2/8
SDS Number: 000000006652
Material Safety Data Sheet
BIOGUARD® SOFTSWIM® FILTER CLEANER
Version: 1.2
Revision Date: 01/01/2014
Print Date: 03/05/2014
SECTION 5. FIREFIGHTING MEASURES
Flammable properties
Flash point
: Remarks: not applicable
Fire fighting
Suitable extinguishing media
: Use extinguishing measures that are appropriate to local circumstances and the
surrounding environment.
Further information
: There are no unusual fire and explosion hazards known.
Protective equipment and precautions for firefighters
Special protective equipment
for firefighters
: In the event of fire, wear self-contained breathing apparatus.
Thoroughly decontaminate fire fighting equipment including all fire fighting
wearing apparel after the incident.
SECTION 6. ACCIDENTAL RELEASE MEASURES
Methods for containment /
Methods for cleaning up
: Using appropriate protective clothing and safety equipment, contain spilled
material.
Soak up with inert absorbent material.
Using clean dedicated equipment, sweep and scoop all spilled material,
contaminated soil, and other contaminated material and place into clean dry
containers for disposal.
Additional advice
: Treat recovered material as described in the section "Disposal considerations".
SECTION 7. HANDLING AND STORAGE
Handling
Handling procedures
: Avoid breathing vapors.
Avoid contact with skin, eyes and clothing.
Do not mix with other chemicals.
Wash hands thoroughly with soap and water after handling and before eating,
drinking or using tobacco.
Do not handle until all safety precautions have been read and understood.
Storage
Requirements for storage
areas and containers
: Store in original container.
Keep tightly closed.
Store in a cool, dry, well ventilated area away from heat or open flame.
Keep out of reach of children.
Keep away from animals.
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Guidelines
Components with workplace control parameters
SAP 6.0
3/8
SDS Number: 000000006652
Material Safety Data Sheet
BIOGUARD® SOFTSWIM® FILTER CLEANER
Version: 1.2
Revision Date: 01/01/2014
Components / CAS-No.
Value / Basis /
Update
Control
parameters
orthophosphoric acid
7664-38-2
TWA
1 mg/m3
Print Date: 03/05/2014
Further information
ACGIH
2007-01-01
STEL
3 ppm
ACGIH
2007-01-01
TWA
1 mg/m3
OSHA Z-1
1997-08-04
TWA
1 mg/m3
OSHA P0
1989-01-19
STEL
3 mg/m3
OSHA P0
1989-01-19
TWA
1 mg/m3
NIOSH REL
2005-09-01
ST
3 mg/m3
NIOSH REL
2005-09-01
hydrogen chloride
7647-01-0
C
2 ppm
ACGIH
2007-01-01
C
5 ppm
7 mg/m3
OSHA Z-1
2006-02-28
C
5 ppm
7 mg/m3
OSHA P0
1989-01-19
C
5 ppm
7 mg/m3
NIOSH REL
2005-09-01
Engineering measures
SAP 6.0
4/8
SDS Number: 000000006652
Material Safety Data Sheet
BIOGUARD® SOFTSWIM® FILTER CLEANER
Version: 1.2
Engineering measures
Revision Date: 01/01/2014
Print Date: 03/05/2014
: Use with adequate ventilation.
Ensure that eyewash stations and safety showers are close to the workstation
location.
Personal protective equipment
Eye protection
: Goggles
Safety glasses with side-shields
Hand protection
: Wear rubber gloves.
Respiratory protection
: A respiratory protection program that meets OSHA 1910.134 and ANSI Z88.2
requirements must be followed whenever workplace conditions warrant a
respirator's use.
Hygiene measures
: Remove and wash contaminated clothing before re-use.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Form
Colour
: liquid
: pink
Odour
: pungent
Safety data
Flash point
: Note: not applicable
pH
: <2
Boiling point/boiling range
: > 212 °F (100 °C)
Vapour pressure
: no data available
Water solubility
: Note: completely miscible
Partition coefficient: noctanol/water
Viscosity, kinematic
: Note: no data available
: Note: no data available
Relative vapour density
: Note: Heavier than air
SECTION 10. STABILITY AND REACTIVITY
Conditions to avoid
: Remarks: High temperatures.
Poor ventilation.
Contamination
Materials to avoid
: Remarks: Do not mix with other swimming pool/spa chemicals in their
concentrated forms.
Metals
5/8
SDS Number: 000000006652
SAP 6.0
Material Safety Data Sheet
BIOGUARD® SOFTSWIM® FILTER CLEANER
Version: 1.2
Revision Date: 01/01/2014
Print Date: 03/05/2014
Alkalis
Hazardous decomposition
products
: Note: Inorganic vapors.
Carbon oxides
Acid fumes.
Oxides of phosphorus
nitrogen oxides (NOx)
Hazardous reactions
: Hazardous polymerisation does not occur.
SECTION 11. TOXICOLOGICAL INFORMATION
Skin irritation
: Remarks: Causes skin burns.
Eye irritation
: Remarks: Causes eye burns.
12. ECOLOGICAL INFORMATION
Further information on ecology
Additional ecological
information
: May be toxic to fish.
May be toxic to aquatic organisms.
Do not flush into surface water or sanitary sewer system.
SECTION 13. DISPOSAL CONSIDERATIONS
Further information
: Dispose of waste material in compliance with all federal, state, and
local regulations.
Contaminated packaging
: Do not re-use empty containers.
Rinse thoroughly before discarding in trash.
Offer rinsed packaging material to local recycling facilities.
SECTION 14. TRANSPORT INFORMATION
DOT
UN number
Description of the goods
Class
Packing group
ERG Code
IATA
UN number
Description of the goods
Class
Packing group
SAP 6.0
:
:
:
:
:
:
1760
Corrosive liquids, n.o.s.
(Phosphoric acid, Hydrochloric Acid Solution)
8
II
154
: 1760
: Corrosive liquid, n.o.s.
(Phosphoric acid, Hydrochloric Acid Solution)
: 8
: II
6/8
SDS Number: 000000006652
Material Safety Data Sheet
BIOGUARD® SOFTSWIM® FILTER CLEANER
Version: 1.2
Labels
Environmentally hazardous
IMDG
UN number
Description of the goods
Revision Date: 01/01/2014
Print Date: 03/05/2014
: 8
: no
Class
Packing group
EmS Number 1
EmS Number 2
: 1760
: CORROSIVE LIQUID, N.O.S.
(Phosphoric acid, Hydrochloric Acid Solution)
: 8
: II
: F-A
: S-B
Marine pollutant
Environmentally hazardous
: no
: no
SECTION 15. REGULATORY INFORMATION
OSHA Hazards
: This material is hazardous under the criteria of the Federal OSHA Hazard
Communication Standard 29CFR 1910.1200.
CERCLA Reportable
Quantity
: 5000 lbs
EPCRA - EMERGENCY PLANNING COMMUNITY RIGHT - TO - KNOW
The components of this product are reported in the following inventories:
US.TSCA
On TSCA Inventory
DSL
All components of this product are on the Canadian DSL list.
AICS
Not in compliance with the inventory
NZIoC
Not in compliance with the inventory
ENCS
Not in compliance with the inventory
KECI
Not in compliance with the inventory
PICCS
Not in compliance with the inventory
IECSC
Not in compliance with the inventory
SAP 6.0
7/8
SDS Number: 000000006652
Material Safety Data Sheet
BIOGUARD® SOFTSWIM® FILTER CLEANER
Version: 1.2
Revision Date: 01/01/2014
TSCA list Information
Print Date: 03/05/2014
US. Toxic Substances Control Act (TSCA) Section 12(b) Export Notification (40 CFR
707, Subpt D)
ZUS_T12B
Not relevant
SECTION 16. OTHER INFORMATION
Further information
HMIS Classification
: Health hazard: 3
Flammability: 0
Physical hazards: 0
PPI:Ask supervisor or safety specialist for handling instructions
NFPA Classification
:
Health hazard: 3
Fire Hazard: 0
Reactivity Hazard: 0
0
3
0
Other Emergency Phone Number
Latin America:
Brazil
+55 113 711 9144
All other countries
+44 (0) 1235 239 670
Mexico:
+52 555 004 8763
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the
date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage,
transportation, disposal and release and is not to be considered a warranty or quality specification. The information
relates only to the specific material designated and may not be valid for such material used in combination with any other
materials or in any process, unless specified in the text.
SAP 6.0
8/8
SDS Number: 000000006652
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising