Captain Series Model: CA15 & CA15-3 Ratings Diesel

Captain Series Model: CA15 & CA15-3  Ratings Diesel
Made in the USA!
Captain Series
Model: CA15 & CA15-3
Ratings Diesel
Single and/or Three Phase Available
Standby:
Prime:
kW
kVA
kW
kVA
60Hz
17.8
22.6
15.0
19.0
50 Hz
14.8
18.7
12.5
15.8
Standby Rating
FEATURES:
Voltage
PH
Hz
kW/kVA
Amps
kW/kVA
Amps
US EPA Tier 4 Final emissions certified &
277/480
3
60
17.8/22.2
37.1
15/19
31.3
California CARB certified emissions
139/240
3
60
17.8/22.2
74.2
15/19
62.5

Engine mounted diesel oxidation catalyst (DOC)
254/440
3
60
17.8/22.2
40.5
15/19
34.1

Available in Single or 3-phase models
127/220
3
60
17.8/22.2
80.9
15/19
68.2

Available in 50 Hz, 60 Hz, or 400 Hz

1800 RPM operation for long life
240/416
3
60
17.8/22.2
42.8
15/19
36.1

Brushless generator with automatic voltage
120/208
3
60
17.8/22.2
85.6
15/19
72.1
regulator
120/240
3
60
17.8/22.2
74.2
15/19
62.5

Main line commercial grade circuit breaker
219/380
3
60
17.8/22.2
46.8
15/19
39.5

Powder coated lightweight aluminum enclosure
with sound attenuation
120/240
1
60
17.8/17.8
74.2
15/15
62.5

Heavy duty aluminum radiator with pusher fan and
guards

Factory Load Tested Prior to Shipment

Service reminders for air and fuel filters

Heady duty dry type air cleaner

Advanced PTG series electronic controller with information display

Spin on 2-micron fuel filter

Convenient single side service

Fuel / Water Separator standard

12 VDC fuel pump with bulkheads for easy connection

12VDC starting motor and a 50A 12VDC alternator

4 point mounting system with vibration isolators

Safety shutdowns for high water temp, low oil
pressure, & low coolant

Air Intake from bottom

Customized to your specifications

Generator
Prime Rating
Newage
RATINGS: All three-phase units are rated at 0.8 power factor. All single-phase units are rated at 1.0 power factor.
STANDBY RATINGS: Standby ratings apply to installations served by a reliable utility source. The standby rating is applicable to varying loads for
the duration of a power outage. There is no overload capability for this rating. Ratings are in accordance with ISO-3046/1, BS 5514, AS 2789, and
DIN 6271.
PRIME POWER RATINGS: Prime power ratings apply to installations where utility power in unavailable or unreliable. At varying load the number
of generator set operating hours is unlimited. A 10% overload capacity is available for one hour in twelve. Ratings are in accordance with
ISO-8528/1, overload power in accordance with ISO-3046/1, BS5514, AS2789, and DIN 6271. For limited running time and base load ratings consult the factory. The generator set manufacturer reserves the right to change the design or specifications without notice and without any obligation
or liability whatsoever.
GENERAL GUIDELINES FOR DERATION: Altitude: Derate 0.5% per 100m (328 ft.) elevation above 1000m (3279 ft.) Temperature: Derate 1.0%
per 10°C (18°F) temperature above 40°C (104°F).
Engine Application Data
ENGINE SPECIFICATIONS
ENGINE BRAND
Isuzu
ENGINE MODEL
4LE
ENGINE TYPE
Vertical, Liquid-Cooled, 4 Cylinder Diesel
NUMBER OF CYLINDERS
4
BORE & STROKE
TOTAL DISPLACEMENT
COMBUSTION TYPE
mm (in)
85 x 96 (3.35 x 3.78)
L (in3)
2.2 (134.25)
Direct Injection Type
ASPIRATION
Turbo Charged with Charge Air Cooler
LUBRICANT
API Service Class CJ-4 SAE or JASO DH-2
STARTING MOTOR
12V, 2.0 kW
CHARGING ALTERNATOR
12V, 50A
EXHAUST AFTERTREATMENT
OIL CHANGE INTERVAL
Diesel Oxidizing Catalyst (DOC)
250 Hours
GENERATOR SPECIFICATIONS
OUTPUT VOLTAGE
120/240 VAC 1 phase or
120/240, 120/208 or 277/480 VAC 3 phase
POWER OUTPUT
15,000 Watts Prime
AMPERAGE
See Chart on Page 1
FUEL CONSUMPTION
2.2 GPH @ Full Load
1.2 GPH @ Half Load
WEIGHT
1040 lbs.
4723 Muirfield Court
Santa Rosa, CA 95405
Phone: 707 542-2224
Fax: 707 542-2227
Email: sales@generatorjoe.net
Web: www.generatorjoe.net
Control Panel
STATE OF THE ART CONTROL
GeneratorJoe’s advanced new PTG410 controller provides the ultimate
in
control and protection. The controller provides manual and remote
starting capability, as well as, available auto start on low battery.
Automatic shutdowns and warnings help prevent damage in the event
a
problem is encountered. In the unlikely event a shutdown occurs, the
PTG410’s J1939 compatibility, ability to display J1939 Diagnostic
Trouble Codes, and 150 Event Log will make troubleshooting easy.
The PTG410, additionally, provides metering and instrumentation for
the engine and generator. Capable of displaying Oil Pressure, Engine
Temperature, Engine Hours, RPM, Battery Voltage, A/C Voltage and A/C Amperage; the PTG410 gives you the information you want with the
press of a button. Furthermore, the PTG410 is UL Recognized and NFPA 110 compatible.
AC Alternator Specifications
STANDARDS
Stamford industrial generators meet the requirements of BS EN 60034 and the relevant section of other international standards such as B55000,
VDE 0530, NEMA MG1-32, 1EC34, CSA C22.2-100, A51359.
Other standards and certifications can be considered on request.
VOLTAGE REGULATORS
MX341 AVR
This sophisticated AVR is incorporated into the Stamford Permanent Magnet Generator (PMG) control system.
The PMG provides power via the AVR to the main exciter, giving a source of constant excitation power independent of generator output. The main
exciter output is then fed to the main rotor, through a full wave bridge, protected by a surge suppressor. The AVR has in-built protection against
sustained over-excitation, caused by internal or external faults. This de-excites the machine after a minimum of 5 seconds.
An engine relief load acceptance feature can enable full load to be applied to the generator in a single step.
If three-phase sensing is required with the PMG system the MX321 AVR must be used.
We recommend three-phase sensing for applications with greatly unbalanced or highly non-linear loads.
(Optional) MX321 AVR
The most sophisticated of all our AVRs combines all the features of the MX341 with, additionally, three-phase rms sensing, for improved
regulation and performance. Over voltage protection is built-in and short circuit current level adjustments is an optional facility.
WINDINGS & ELECTRICAL PERFORMANCE
All generator stators are wound to 2/3 pitch. This eliminates triplen (3rd, 9th, 15th ...) harmonics on the voltage waveform and is found to be the
optimum design for trouble-free supply of non-linear loads. The 2/3 pitch design avoids excessive neutral currents sometimes seen with higher
winding pitches, when in parallel with the mains. A frilly connected damper winding reduces oscillations during paralleling. This winding, with the
2/3 pitch and carefully selected pole and tooth designs, ensures very low waveform distortion.
SHAFT
The generator rotor is dynamically balanced to better than B56861:Part 1 Grade 2.5 for minimum vibration in operation.
INSULATION/IMPREGNATION
The insulation system is class H.
All wound components are impregnated with materials and processes designed specifically to provide the high build required for static windings
and the high mechanical strength required for rotating components.
QUALITY ASSURANCE
Generators are manufactured using production procedures having a quality assurance level to BS EN ISO 9001.
Generator Controller Options
27 1/2"
27 1/8"
30 1/2"
33"
27"
44"
49 5/8"
EXHAUST
(OPTIONAL LOCATION)
EXHAUST
(OPTIONAL LOCATION)
A/C ELECTRICAL
FUEL
BATTERY
4723 Muirfield Court
Santa Rosa, CA 95405
Phone: 707 542-2224
Fax: 707 542-2227
Email: sales@generatorjoe.net
Web: www.generatorjoe.net
Standard Features and Optional Accessories
Standard Features

EPA Certified Tier 4 Final Emissions

Heavy duty steel base

Brushless alternator

4 Point Mounting W/Vibration isolators

Aluminum Enclosure

Engine Mounted Diesel Oxidation Catalyst (DOC)

Commercial Grade Circuit Breaker

Single Side Service

12 VDC Fuel pump

Heavy duty air cleaner

Service reminders for filters

Fuel/Water Separator

Oil drain valve with extension

Governor

Safety sensors & shutdowns

Owners manual

2 Year, 3000 Hour Warranty
Gross Weights and Dimensions
OVERALL SIZE, L x W x H, in.: 50 in. x 27 in. x 28 in.
WEIGHT (WET): 1,500 lbs.
Note: Dim and weights reflect standard open unit with no options
Note: This drawing is provided for reference only and
should not be used for planning installation. Contact
your local distributor for more detailed information.
Optional Accessories
⃞
Single or 3 phase, 60, 50or 400 Hertz.
⃞
Deluxe Generator Controls, Full Gauges,
Auto Start
⃞
Remote panel w/start, stop & hour meter
⃞
Deluxe Remote Panel w/start, stop & hour
Meter, Coolant Temp & Oil Pressure
⃞
Remote Panel Wiring Harnesses
⃞
Emergency Stop Mushroom Buttons &
Wiring Harnesses
⃞
Oil Pan Heater
⃞
Coolant Heater
⃞
Low Profile Reduced Height Package
⃞
Remote Radiator Packages
⃞
Remote Battery
⃞
Battery Charger
⃞
Battery Heaters
⃞
Customized to Your Specifications
4723 Muirfield Court
Santa Rosa, CA 95405
Phone: 707 542-2224
Fax: 707 542-2227
Email: sales@generatorjoe.net
Web: www.generatorjoe.net
A small business owned by service a connected disabled veteran.
Cage 1U5V7 - TIN/EIN #943026355 - Duns #054590203
Made in the USA!
Model: CA15 & CA15-3
© Copyright, GeneratorJoe Inc. All Rights Reserved
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising