LO-9-2805-256-12
LO 9-2805-256-12
LUBRICATION ORDER
TECHNICAL ORDER
TO 38G2-102-2LC-1
13 MARCH 1992
(Supersedes LO 5-2805-256-12, 17 November 1986)
ENGINE, GASOLINE, 1 1/2 HP,
MILITARY STANDARD MODELS
(MODEL 1A08-1, NSN 2805-00-601-5181)
(MODEL 1A08-2, NSN 2805-00-714-8552)
(MODEL 1A08-3, NSN 2805-00-068-7510)
(MODEL 1A08-4, NSN 2805-01-182-8467)
References: TM 9-2805-256-14, C9100-IL and FM 9-207
REPORTING OF ERRORS
You can improve this publication by calling attention to errors and by recommending improvements and by
stating your reasons for the recommendations. Your letter or DA Form 2028, Recommended Changes to
Publications and Forms, should be mailed directly to Commander, US Army Troop Support Command,
ATTN: AMSTR-MMTS, 4300 Goodfellow Boulevard, St. Louis, MO 63120-1798. A reply will be furnished
directly to you.
NOTES
This LO is for crew/operator (C) or organizational (O) maintenance. Lube intervals (on-condition or hard time) and task
hour times are based on normal hours of operation. Change the intervals if your lubricants are contaminated or if you
are operating the equipment under adverse operating conditions. Lube more during constant use and less during
periods of low activity. Adequate preservation precautions must be taken during inactive periods. Use correct grade of
lubricant for seasonal temperature expected.
W A R N I N G - Dry cleaning solvent PD-680 used to clean parts is potentially dangerous to personnel and property.
Avoid repeated and prolonged skin contact. Do not use near open flame or excessive heat. Flash point of solvent is
100°F-138°F (38°C-60°C).
Clean parts with dry cleaning solvent PD-680 and dry before lubricating.
Before you start your lube service.
ALWAYS
NEVER
a. Clean parts before lubricating.
b. Use the lubrication order as your guide.
a. Use wrong type/grade lubricant.
b. Use too much lubricant.
The 1 1/2 HP military standard gasoline engine is not enrolled in the Army Oil Analysis Program (AOAP) HARD TIME
INTERVALS APPLY.
DISTRIBUTION STATEMENT A - Approved for public release; distribution is unlimited.
Card 1 of 4
LO
9-2805-256-12
TO
38G2-102-2LC-1
Card 2 of 4
LO 9-2805-256-12
TO 38G2-102-2LC-1
TABLE 1.
Lubricant Table for 1 1/2 HP Military Standard Gasoline Engine
1.
FOR OPERATION OF EQUIPMENT IN PROTRACTED COLD TEMPERATURE -10°F (-23°C).
Remove
lubricant prescribed in table 1 for temperatures above -10°F (-23°C). Clean parts with dry cleaning solvent PD-680.
Relubricate with lubricants specified in table 1 for temperatures below -10°F (-23°C).
For arctic operation refer to FM
9-207.
2.
OIL
CAN
POINTS.
Every
25
hours
lubricate
all
exposed
adjusting
threads
with
OE/HDO.
3.
Insurecam wick is lubricated with OE/HDO (sparingly) whenever ignition contact points are replaced or
adjusted.
4.
CRANCKCASE.
Drain crankcase when hot.
Every 50 hours drain and refill crankcase, operate engine for five
minutes, check for leaks, check crankcase oil level and bring to full mark.
Copy of this lubrication order will remain with the equipment at all times; instructions herein are mandatory.
Card 3 of 4
LO 9-2805-256-12
TO
38G2-102-2LC-1
By Order of the Secretaries of the Army and the Air Force:
GORDON R. SULLIVAN
General, United States Army
Chief of Staff
Official:
MILTON H. HAMILTON
MILTON H. HAMILTON
Administrative Assistant to the
Secretary of the Army
00690
MERRILL A.
McPEAK
General USAF
Chief of Staff
Official:
CHARLES C. McDONALD
General, USAF
Commander, Air Force Logistics Command
Distribution:
To be distributed in accordance with DA Form 12-25A, Operator and Unit Maintenance Requirements for Engine,
Gasoline, 1½ HP, Models 1A08-1/2/3/4.
U.S.
GOVERNMENT
PRINTING
OFFICE:
1995
O
-
386-730
(20304)
Card 4 of 4
P
I
N
:
0
6
9
3
5
5
/
0
0
0
This fine document...
Was brought to you by me:
Liberated Manuals -- free army and government manuals
Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly
available information, slap “watermarks” and other junk on it, and sell it.
Those masters of search engine manipulation make sure that their sites that
sell free information, come up first in search engines. They did not create it...
They did not even scan it... Why should they get your money? Why are not
letting you give those free manuals to your friends?
I am setting this document FREE. This document was made by the US
Government and is NOT protected by Copyright. Feel free to share,
republish, sell and so on.
I am not asking you for donations, fees or handouts. If you can, please
provide a link to liberatedmanuals.com, so that free manuals come up first in
search engines:
<A HREF=http://www.liberatedmanuals.com/>Free Military and Government Manuals</A>
– Sincerely
Igor Chudov
http://igor.chudov.com/
– Chicago Machinery Movers
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising