9 14-10
NUMBER: 9 14–10
S.M. REF.: Listed in Table
ENGINE: DD Platform
DATE: September 2010
SUBJECT: INSTALLATION OF THE MOTOR CONTROL MODULE
ADDITIONS, REVISIONS, OR UPDATES
Publication Number
Platform
Section Title
Change
Page Number(s)
DDC-SVC-MAN-0084
EPA07/10 DD Platform
2.5 Installation of the
Motor Control Module
Correction to MCM
crankcase mounting
bolt torque.
Insert as stated.
NOTE: Page numbers are based on the most recent version of the individual publication and may be adjusted throughout the annual print cycle.
Perform the following steps for MCM-MCM2 installation:
NOTE:
If installing a new MCM-MCM2; after installation, program to proper settings using the programming
station.
NOTE:
Do not ground the MCM-MCM2 housing. This can result in false codes being logged.
NOTICE:
Ensure the MCM-MCM2 metal housing does not come in contact
with the chassis.
NOTICE:
Ensure MCM-MCM2 is not contaminated with diesel fuel.
1. Install the MCM-MCM2 to the engine with four bolts and isolators. Torque the
MCM-MCM2-to-engine bolts to 15 N·m (11 lb·ft).
2. Connect the 21 and 120-pin engine harness connectors to the MCM-MCM2 close and lock
latch on the connectors.
3. If equipped with an MCM fuel cooler, install bracket onto fuel line; install bracket and line
to MCM-MCM2 with two bolts.
4. If equippe d with an MCM fuel cooler, install both fuel lines from the MCM-MCM2 to the
fuel filter module. Torque bolts to 55 N·m (41 lb·ft).
5. Reconnect vehicle battery power.
6. Turn the ignition to the "ON" position. Observe the DDDL 7.X for any diagnostic code(s). If
any code(s) are logged, refer to the proper code diagnostics.
ENGINE EXHAUST
To avoid injury from inhaling engine exhaust, always operate
the engine in a well-ventilated area. Engine exhaust is toxic.
7. Start the engine, and check for leaks.
ADDITIONAL SERVICE INFORMATION
Additional service information is available in Power Service Literature.
Detroit Diesel®, DDC®, Series 60® and the spinning arrows design are registered trademarks of Detroit Diesel Corporation.
© Copyright 2010 Detroit Diesel Corporation. All rights reserved. Printed in U.S.A.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising