110msds

110msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: November 7, 2004
DATE OF ISSUE: November 9, 2004
I - Product Identification
Anti-Static Spray
PRODUCT CODE: 0110
CHEMICAL FORMULATION: Antistatic cleaning solution.
NFPA HAZARD IDENTIFICATION SYSTEM:
HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 2
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
SUBSTANCE
Isopropanol
Key:
APPROX
%
5.00-15.0
OSHA
PEL
400 ppm
ACGIH
TLV
400 ppm
EPA 40 CFR:
302
355
372
N
N
N
CAS #
67-63-0
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value
C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (°F): N/D
SPECIFIC GRAVITY (WATER = 1): 0.98
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): < 10.0
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): > 1.0
SOLUBILITY IN WATER: Soluble
pH: N/D
APPEARANCE AND ODOR: Clear, colorless liquid, alcohol odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): 107
(TEST METHOD): Closed Cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/D
LOWER: N/D
EXTINGUISHING MEDIA: Water fog, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Fire fighters should be equipped with full protective gear including self-contained breathing
apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Use water spray to cool fire-exposed containers. Solvent vapors may cause flashbacks.
PRODUCT NAME: Anti-Static Spray
PRODUCT CODE: 0110
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: None
CONDITIONS TO AVOID: Heat, sparks or open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION: X
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: Slight irritation and redness.
IF ON SKIN: Mild irritation with prolonged exposure.
IF SWALLOWED: Gastrointestinal irritation, nausea, and diarrhea. Aspiration may be a hazard.
IF INHALED: Respiratory irritation, dizziness, headache.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Obtain medical attention.
IF ON SKIN: Wash thoroughly with soap and water. Remove contaminated clothing and launder separately before reuse. If irritation
persists, obtain medical attention.
IF SWALLOWED: Call physician or poison control center immediately. Rinse mouth with water and give affected person 1 to 2 glasses
of water and induce vomiting. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air. If irritation persists, obtain medical attention.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and extinguish all sources of ingestion. Contain
spill. Soak up on inert absorbent material and place in labeled closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. Do not breathe vapors or mists. If recommended Exposure Limits are
exceeded wear a NIOSH approved respirator, following manufacturer’s recommendations.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or goggles.
OTHER PROTECTIVE EQUIPMENT: Eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat or open flame. Keep
container tightly closed when not in use. Wash thoroughly before handling.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: None
DOT CLASS: None
DOT ID NUMBER: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is
further intended, different shipping names and labeling may apply.
REVISION DATE: November 7, 2004
Prepared by: PMR
DATE OF ISSUE: November 9, 2004
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or
the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or
third parties caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising