Wet Edge Kingston Gray SDS

Wet Edge Kingston Gray SDS
42.0.6
Page 1/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
1 Identification
· Product identifier:
· Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
· Product code: TB-WEGY
· Details of the supplier of the safety data sheet
· Manufacturer/Supplier:
Camger Coatings Systems Inc.
364 Main Street
NORFOLK, MA 02056
USA
t.meisner@camger.com
· Information department: Product safety department
· Emergency telephone number: During normal opening times: +1 (508) 528-5787
2 Hazard(s) identification
· Classification of the substance or mixture
GHS02 Flame
Flam. Liq. 3 H226 Flammable liquid and vapor.
GHS08 Health hazard
Muta. 1B
Carc. 1B
STOT RE 1
Asp. Tox. 1
H340
H350
H372
H304
May cause genetic defects.
May cause cancer.
Causes damage to the central nervous system through prolonged or repeated exposure.
May be fatal if swallowed and enters airways.
· Label elements
· GHS label elements
The product is classified and labeled according to the Globally Harmonized System (GHS).
· Hazard pictograms
GHS02
GHS08
· Signal word Danger
· Hazard-determining components of labeling:
Stoddard solvent
· Hazard statements
Flammable liquid and vapor.
May cause genetic defects.
May cause cancer.
Causes damage to the central nervous system through prolonged or repeated exposure.
May be fatal if swallowed and enters airways.
· Precautionary statements
Keep away from heat/sparks/open flames/hot surfaces. No smoking.
Use explosion-proof electrical/ventilating/lighting/equipment.
Do not breathe dust/fume/gas/mist/vapors/spray.
Wear protective gloves / eye protection / face protection.
Ground/bond container and receiving equipment.
(Contd. on page 2)
US
42.0.6
Page 2/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 1)
Keep container tightly closed.
Use only non-sparking tools.
Take precautionary measures against static discharge.
Wash thoroughly after handling.
Do not eat, drink or smoke when using this product.
Obtain special instructions before use.
Do not handle until all safety precautions have been read and understood.
IF SWALLOWED: Immediately call a POISON CENTER/ doctor.
If on skin (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower.
IF exposed or concerned: Get medical advice/attention.
Get medical advice/attention if you feel unwell.
Do NOT induce vomiting.
In case of fire: Use for extinction: CO2, powder or water spray.
Store locked up.
Store in a well-ventilated place. Keep cool.
Dispose of contents/container in accordance with local/regional/national/international regulations.
· Classification system:
· NFPA ratings (scale 0 - 4)
2
2
Health = 2
Fire = 2
Reactivity = 0
0
· HMIS-ratings (scale 0 - 4)
HEALTH
*2
FIRE
2
REACTIVITY 0
Health = *2
Fire = 2
Reactivity = 0
· Other hazards
· Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.
3 Composition/information on ingredients
· Chemical characterization: Mixtures
· Description: Mixture of the substances listed below with nonhazardous additions.
· Dangerous components:
13463-67-7 titanium dioxide
8052-41-3 Stoddard solvent
1332-58-7 Kaolin
64742-48-9 Hydrogen treated naphtha (Mineral spirits)
1330-20-7 Xylene
100-41-4 ethylbenzene
25-50%
10-<25%
2.5-<10%
0.1-≤2.5%
0.1-≤2.5%
0.1-≤2.5%
4 First-aid measures
· Description of first aid measures
· General information:
Immediately remove any clothing soiled by the product.
Symptoms of poisoning may even occur after several hours; therefore medical observation for at least 48 hours
after the accident.
· After inhalation: Supply fresh air; consult doctor in case of complaints.
· After skin contact: Immediately rinse with water.
(Contd. on page 3)
US
42.0.6
Page 3/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 2)
· After eye contact:
Rinse opened eye for several minutes under running water. If irritation occurs, get medical assistance.
· After swallowing: If symptoms persist consult doctor. Do not induce vomiting.
· Information for doctor:
· Most important symptoms and effects, both acute and delayed No further relevant information available.
· Indication of any immediate medical attention and special treatment needed
No further relevant information available.
5 Fire-fighting measures
· Extinguishing media
· Suitable extinguishing agents:
CO2, extinguishing powder or water spray. Fight larger fires with water spray or alcohol resistant foam.
· For safety reasons unsuitable extinguishing agents: Water with full jet
· Special hazards arising from the substance or mixture
During heating or in case of fire poisonous gases are produced.
· Advice for firefighters
· Protective equipment: Mouth respiratory protective device.
6 Accidental release measures
· Personal precautions, protective equipment and emergency procedures
Mount respiratory protective device.
Wear protective equipment. Keep unprotected persons away.
· Environmental precautions: Do not allow to enter sewers/ surface or ground water.
· Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Dispose contaminated material as waste according to item 13.
Ensure adequate ventilation.
· Reference to other sections
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.
7 Handling and storage
· Handling:
· Precautions for safe handling
Ensure good ventilation/exhaustion at the workplace.
Open and handle receptacle with care.
Prevent formation of aerosols.
· Information about protection against explosions and fires:
Keep ignition sources away - Do not smoke.
Protect against electrostatic charges.
Keep respiratory protective device available.
· Conditions for safe storage, including any incompatibilities
· Storage:
· Requirements to be met by storerooms and receptacles: No special requirements.
· Information about storage in one common storage facility: Not required.
· Further information about storage conditions: Keep receptacle tightly sealed.
· Specific end use(s) No further relevant information available.
US
(Contd. on page 4)
42.0.6
Page 4/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 3)
8 Exposure controls/personal protection
· Additional information about design of technical systems: No further data; see item 7.
· Control parameters
· Components with limit values that require monitoring at the workplace:
8052-41-3 Stoddard solvent
PEL Long-term value: 2900 mg/m³, 500 ppm
REL Long-term value: 350 mg/m³
Ceiling limit value: 1800* mg/m³
*15-min
TLV Long-term value: 525 mg/m³, 100 ppm
1332-58-7 Kaolin
PEL Long-term value: 15* 5** mg/m³
*total dust **respirable fraction
REL Long-term value: 10* 5** mg/m³
*total dust **respirable fraction
TLV Long-term value: 2* mg/m³
E; as respirable fraction
· Additional information: The lists that were valid during the creation were used as basis.
· Exposure controls
· Personal protective equipment:
· General protective and hygienic measures:
Keep away from foodstuffs, beverages and feed.
Immediately remove all soiled and contaminated clothing.
Wash hands before breaks and at the end of work.
Store protective clothing separately.
· Breathing equipment:
In case of brief exposure or low pollution use respiratory filter device. In case of intensive or longer exposure
use respiratory protective device that is independent of circulating air.
· Protection of hands:
Protective gloves
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/
the chemical mixture.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation
· Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of quality
and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the
resistance of the glove material can not be calculated in advance and has therefore to be checked prior to the
application.
· Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective gloves and has to be
observed.
(Contd. on page 5)
US
42.0.6
Page 5/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 4)
· Eye protection:
Tightly sealed goggles
9 Physical and chemical properties
· Information on basic physical and chemical properties
· General Information
· Appearance:
Liquid
Form:
Grey
Color:
Characteristic
· Odor:
Not determined.
· Odor threshold:
· pH-value:
Not determined.
· Change in condition
Melting point/Melting range:
Boiling point/Boiling range:
Undetermined.
220 °C (428 °F)
· Flash point:
40 °C (104 °F)
· Flammability (solid, gaseous):
Not applicable.
· Ignition temperature:
230 °C (446 °F)
· Decomposition temperature:
Not determined.
· Auto igniting:
Product is not selfigniting.
· Danger of explosion:
Product is not explosive. However, formation of explosive air/vapor
mixtures are possible.
· Explosion limits:
Lower:
Upper:
1.1 Vol %
6.0 Vol %
· Vapor pressure at 20 °C (68 °F):
2 hPa (2 mm Hg)
· Density at 20 °C (68 °F):
· Relative density
· Vapor density
· Evaporation rate
1.24 g/cm³ (10.348 lbs/gal)
Not determined.
Heavier than (Air)
Slower than (n-Butyl Acetate)
· Solubility in / Miscibility with
Water:
Not miscible or difficult to mix.
· Partition coefficient (n-octanol/water): Not determined.
· Viscosity:
Dynamic:
Kinematic:
Not determined.
Not determined.
· Solvent content:
VOC content:
· Other information
344.0 g/l / 2.87 lb/gl
No further relevant information available.
10 Stability and reactivity
· Reactivity No further relevant information available.
(Contd. on page 6)
US
42.0.6
Page 6/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 5)
· Chemical stability
· Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications.
· Possibility of hazardous reactions No dangerous reactions known.
· Conditions to avoid No further relevant information available.
· Incompatible materials: No further relevant information available.
· Hazardous decomposition products: No dangerous decomposition products known.
11 Toxicological information
· Information on toxicological effects
· Acute toxicity:
· Primary irritant effect:
· on the skin: No irritant effect.
· on the eye: No irritating effect.
· Sensitization: No sensitizing effects known.
· Additional toxicological information:
The product shows the following dangers according to internally approved calculation methods for
preparations:
The product can cause inheritable damage.
· Carcinogenic categories
· IARC (International Agency for Research on Cancer)
13463-67-7 titanium dioxide
1330-20-7 Xylene
100-41-4 ethylbenzene
14807-96-6 Talc (hydrous magnesium silicate)
136-52-7 cobalt bis(2-ethylhexanoate)
67-63-0 propan-2-ol
2B
3
2B
2B
2B
3
· NTP (National Toxicology Program)
None of the ingredients is listed.
· OSHA-Ca (Occupational Safety & Health Administration)
No ingredient of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or
potential carcinogen by OSHA.
12 Ecological information
· Toxicity
· Aquatic toxicity: No further relevant information available.
· Persistence and degradability No further relevant information available.
· Behavior in environmental systems:
· Bioaccumulative potential No further relevant information available.
· Mobility in soil No further relevant information available.
· Additional ecological information:
· General notes:
Water hazard class 2 (Self-assessment): hazardous for water
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
· Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.
· Other adverse effects No further relevant information available.
US
(Contd. on page 7)
42.0.6
Page 7/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 6)
13 Disposal considerations
· Waste treatment methods
· Recommendation:
Must not be disposed of together with household garbage. Do not allow product to reach sewage system.
· Uncleaned packagings:
· Recommendation: Disposal must be made according to official regulations.
14 Transport information
· UN-Number
· DOT, IMDG, IATA
UN1263
· UN proper shipping name
· DOT, IATA
· IMDG
Paint
PAINT
· Transport hazard class(es)
· DOT
· Class
· Label
3 Flammable liquids
3
· IMDG, IATA
· Class
· Label
3 Flammable liquids
3
· Packing group
· DOT, IMDG, IATA
III
· Environmental hazards:
Not applicable.
· Special precautions for user
· Danger code (Kemler):
· EMS Number:
· Stowage Category
Warning: Flammable liquids
30
F-E,S-E
A
· Transport in bulk according to Annex II of
Not applicable.
MARPOL73/78 and the IBC Code
· Transport/Additional information:
· DOT
· Quantity limitations
· Remarks:
On passenger aircraft/rail: 60 L
On cargo aircraft only: 220 L
Flash Point – 100F or higher. D.O.T. label NOT required.
173.150(f)1 May be reclassified as Combustible Liquid.
(Contd. on page 8)
US
42.0.6
Page 8/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 7)
· IMDG
· Limited quantities (LQ)
· Excepted quantities (EQ)
· UN "Model Regulation":
5L
Code: E1
Maximum net quantity per inner packaging: 30 ml
Maximum net quantity per outer packaging: 1000 ml
UN 1263 PAINT, 3, III
15 Regulatory information
· Safety, health and environmental regulations/legislation specific for the substance or mixture
· Sara
· Section 355 (extremely hazardous substances):
None of the ingredients is listed.
· Section 313 (Specific toxic chemical listings):
100-41-4 ethylbenzene
136-52-7 cobalt bis(2-ethylhexanoate)
67-63-0 propan-2-ol
95-63-6 1,2,4-Trimethylbenzene
· TSCA (Toxic Substances Control Act):
13463-67-7 titanium dioxide
8052-41-3 Stoddard solvent
1332-58-7 Kaolin
64742-48-9 Hydrogen treated naphtha (Mineral spirits)
22464-99-9 Zirconium Carboxylate
100-41-4 ethylbenzene
14807-96-6 Talc (hydrous magnesium silicate)
68390-98-7 Quaternary ammonium compounds, benzyl-C14-18-alkyldimethyl, chlorides
136-52-7 cobalt bis(2-ethylhexanoate)
67-63-0 propan-2-ol
95-63-6 1,2,4-Trimethylbenzene
108-65-6 2-methoxy-1-methylethyl acetate
· Proposition 65
· Chemicals known to cause cancer:
13463-67-7 titanium dioxide
100-41-4 ethylbenzene
· Chemicals known to cause reproductive toxicity for females:
None of the ingredients is listed.
· Chemicals known to cause reproductive toxicity for males:
None of the ingredients is listed.
· Chemicals known to cause developmental toxicity:
None of the ingredients is listed.
· Carcinogenic categories
· EPA (Environmental Protection Agency)
1330-20-7 Xylene
100-41-4 ethylbenzene
I
D
(Contd. on page 9)
US
42.0.6
Page 9/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 8)
· TLV (Threshold Limit Value established by ACGIH)
13463-67-7 titanium dioxide
1332-58-7 Kaolin
1330-20-7 Xylene
100-41-4 ethylbenzene
14807-96-6 Talc (hydrous magnesium silicate)
67-63-0 propan-2-ol
A4
A4
A4
A3
A4
A4
· NIOSH-Ca (National Institute for Occupational Safety and Health)
13463-67-7 titanium dioxide
· GHS label elements
The product is classified and labeled according to the Globally Harmonized System (GHS).
· Hazard pictograms
GHS02
GHS08
· Signal word Danger
· Hazard-determining components of labeling:
Stoddard solvent
· Hazard statements
Flammable liquid and vapor.
May cause genetic defects.
May cause cancer.
Causes damage to the central nervous system through prolonged or repeated exposure.
May be fatal if swallowed and enters airways.
· Precautionary statements
Keep away from heat/sparks/open flames/hot surfaces. No smoking.
Use explosion-proof electrical/ventilating/lighting/equipment.
Do not breathe dust/fume/gas/mist/vapors/spray.
Wear protective gloves / eye protection / face protection.
Ground/bond container and receiving equipment.
Keep container tightly closed.
Use only non-sparking tools.
Take precautionary measures against static discharge.
Wash thoroughly after handling.
Do not eat, drink or smoke when using this product.
Obtain special instructions before use.
Do not handle until all safety precautions have been read and understood.
IF SWALLOWED: Immediately call a POISON CENTER/ doctor.
If on skin (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower.
IF exposed or concerned: Get medical advice/attention.
Get medical advice/attention if you feel unwell.
Do NOT induce vomiting.
In case of fire: Use for extinction: CO2, powder or water spray.
Store locked up.
Store in a well-ventilated place. Keep cool.
Dispose of contents/container in accordance with local/regional/national/international regulations.
· National regulations:
· Additional classification according to Decree on Hazardous Materials:
Carcinogenic hazardous material group III (dangerous).
(Contd. on page 10)
US
42.0.6
Page 10/10
Safety Data Sheet
acc. to OSHA HCS
Printing date 03/07/2016
Reviewed on 03/07/2016
Trade name: TB-WEGYG TOTALBOAT WET EDGE KINGSTON GRAY (GL)
TB-WEGYQ TOTALBOAT WET EDGE KINGSTON GRAY (QT)
(Contd. of page 9)
· Information about limitation of use:
Workers are not allowed to be exposed to the hazardous carcinogenic materials contained in this preparation.
Exceptions can be made by the authorities in certain cases.
· Chemical safety assessment: A Chemical Safety Assessment has not been carried out.
16 Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
· Department issuing SDS: Environment protection department.
· Contact:
Mr. Meisner
Compliance department.
· Date of preparation / last revision 03/07/2016 / · Abbreviations and acronyms:
ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International
Carriage of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
DOT: US Department of Transportation
IATA: International Air Transport Association
ACGIH: American Conference of Governmental Industrial Hygienists
EINECS: European Inventory of Existing Commercial Chemical Substances
ELINCS: European List of Notified Chemical Substances
CAS: Chemical Abstracts Service (division of the American Chemical Society)
NFPA: National Fire Protection Association (USA)
HMIS: Hazardous Materials Identification System (USA)
VOC: Volatile Organic Compounds (USA, EU)
PBT: Persistent, Bioaccumulative and Toxic
vPvB: very Persistent and very Bioaccumulative
NIOSH: National Institute for Occupational Safety
OSHA: Occupational Safety & Health
TLV: Threshold Limit Value
PEL: Permissible Exposure Limit
REL: Recommended Exposure Limit
Flam. Liq. 3: Flammable liquids, Hazard Category 3
Muta. 1B: Germ cell mutagenicity, Hazard Category 1B
Carc. 1B: Carcinogenicity, Hazard Category 1B
STOT RE 1: Specific target organ toxicity - Repeated exposure, Hazard Category 1
Asp. Tox. 1: Aspiration hazard, Hazard Category 1
US
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising