pdf224
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 1
Heronhill - for all your Toshiba requirements
FILE NO. A90-9924
TOSHIBA
SERVICE MANUAL
AIR-CONDITIONER
SPLIT TYPE, COOLING ONLY
BUILT-IN DUCT TYPE
RAV-164B-PE/164A-PE
RAV-264B-PE/264A-PE
RAV-264B-PE/264A8-PE
RAV-364B-PE/364A8-PE
RAV-464B-PE/464A8-PE
CEILING TYPE
RAV-134C-PE/134A-PE
RAV-164C-PE/164A-PE
RAV-264C-PE/264A-PE
RAV-264C-PE/264A8-PE
RAV-364C-PE/364A8-PE
RAV-464C-PE/464A8-PE
WALL TYPE
RAV-164K-PE/164A-PE
RAV-264K-PE/264A-PE
RAV-264K-PE/264A8-PE
2 WAY CASSETTE TYPE
RAV-134TU-PE/134A-PE
RAV-164TU-PE/164A-PE
4 WAY CASSETTE TYPE
RAV-164U-PE/164A-PE
RAV-264U-PE/264A-PE
RAV-264U-PE/264A8-PE
RAV-364U-PE/364A8-PE
RAV-464U-PE/464A8-PE
Printed in UK JULY 1999
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 2
Heronhill - for all your Toshiba requirements
CONTENTS
1.
SPECIFICATIONS
2.
CONSTRUCTIONS VIEWS
3.
WIRING DIAGRAMS
4.
SPECIFICATIONS OF ELECTRICAL PARTS
5.
REFRIGERANT PIPING DIAGRAMS
6.
PERFORMANCE CHARACTERISTICS
7.
EXPLODED VIEWS AND PARTS LISTS
3
15
23
31
41
46
49
SUMMARY
The units referred to within this Manual conform with the protection requirements of Directives 89/336/EEC
Electromagnetic Compatibility and 73/23/EEC Low Voltage.
Operating conditions of units are as follows:
OUTDOOR
TEMPERATURE
-2 to 43˚C
ROOM
TEMPERATURE
18 to 32˚C
ROOM
HUMIDITY
LESS THAN 80%
Note 1:
Cooling Capacity is based on the following temperature conditions:
Indoor air inlet temperature 27˚C DB, 19˚C WB.
Outdoor air inlet temperature 35˚C DB.
Note 2:
For details on Control Circuits, refer to Service Manual A90-9925.
Note 3:
Metric/Imperial pipe conversion:
Diameter (mm)
6.4
9.5
12.7
15.9
19
22
Nominal Diameter (inch)
1/4
3/8
1/2
5/8
3/4
7/8
2
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 3
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Cooling capacity
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
Model
RAV-164B-PE
kW
Phase
V
Hz
m
4.5
1
220-240
50
COOLING
2.2
90
10.6
60
42/39/36
50
R407C
1.2
35
Capillary tube & Expansion valve
ø12.7
Flare
ø6.4
Flare
7.5
m
30
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
External static
pressure
OUTDOOR UNIT Model
Appearance colour
Dimensions
Standard
Max. motor
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
m
m
mm
m3/h
W
mmAq
mmAq
mm
mm
mm
kg
m3/h
W
Model
Output
kW
Protective device
fuse,
crankcase heater,
inner overload relay
Long-life filter kit
Dimensions
15
30
ø32.5 (ID)
RAV-164B-PE
Black (zinc galvanized steel &
thermal insulator)
345
770
875
39
Finned tube
Multi-blade fan
840
60
4
10
RAV-164A-PE
Bronze white (Munsell 6Y7.5/1)
740
880
310
58
Finned tube
Propeller fan
2,700
39
PG350X3F-4LS
1.5
RBC-RK162BE-PE
Height
Width
Depth
Net weight
80
mm
mm
mm
kg
700
285
8
Air filter
Washable
Specifications are subject to change without notice
3
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 4
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Model
RAV-264B-PE
Cooling capacity
kW
Phase
V
Hz
m
7.1
1
220-240
50
COOLING
3.1
90
15.0
80
43/40/37
53
R407C
1.9
35
Capillary tube & Expansion valve
ø15.9
Flare
ø9.5
Flare
7.5
7.1
3
380-415
50
COOLING
2.9
85
4.9
25
43/40/37
53
R407C
1.9
35
Capillary tube & Expansion valve
ø15.9
Flare
ø9.5
Flare
7.5
m
30
30
15
30
ø32.5 (ID)
RAV-264B-PE
Black (zinc galvanized steel &
thermal insulator)
345
1,070
875
53
Finned tube
Multi-blade fan
1,140
100
4
10
RAV-264A-PE
Bronze white (Munsell 6Y7.5/1)
790
880
310
64
Finned tube
Propeller fan
3,000
63
PG460X3F-4MS
2.2
15
30
ø32.5 (ID)
RAV-264B-PE
Black (zinc galvanized steel &
thermal insulator)
345
1,070
875
53
Finned tube
Multi-blade fan
1,140
100
4
10
RAV-264A8-PE
Bronze white (Munsell 6Y7.5/1)
790
880
310
64
Finned tube
Propeller fan
3,000
63
YG460X3F-MS
2.2
fuse,
crankcase heater,
over current relay,
reverse phase protector
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
External static
pressure
OUTDOOR UNIT Model
Appearance colour
Dimensions
Standard
Max. motor
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
m
m
mm
m3/h
W
mmAq
mmAq
mm
mm
mm
kg
m3/h
W
Model
Output
kW
fuse,
crankcase heater,
inner overload relay
Protective device
Long-life filter kit
Dimensions
Height
Width
Depth
Net weight
mm
mm
mm
kg
Air filter
RAV-264B-PE
RBC-RK262BE-PE
RBC-RK262BE-PE
80
1000
285
10
80
1000
285
10
Washable
Washable
Specifications are subject to change without notice
4
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 5
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Model
Cooling capacity
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
RAV-364B-PE
RAV-464B-PE
m
10.0
3
380-415
50
COOLING
4.2
87
7.0
42
45/42/39
55
R407C
2.7
35
Capillary tube & Expansion valve
ø19 (ø22)
Flare
ø9.5
Flare
7.5
12.5
3
380-415
50
COOLING
5.15
87
8.5
50
46/43/40
55
R407C
3.5
50
Capillary tube & Expansion valve
ø19 (ø22)
Flare
ø9.5
Flare
7.5
m
50
50
20
50
ø32.5 (ID)
RAV-364B-PE
Black (zinc galvanized steel &
thermal insulator)
345
1,420
875
58
Finned tube
Multi-blade fan
1,820
120
4
10
RAV-364A8-PE
Bronze white (Munsell 6Y7.5/1)
1,240
930
385
102
Finned tube
Propeller fan
6,000
39 + 63
ZR49KCE-TFD-230
3.0
20
50
ø32.5 (ID)
RAV-464B-PE
Black (zinc galvanized steel &
thermal insulator)
345
1,420
875
62
Finned tube
Multi-blade fan
2,100
140
4
10
RAV-464A8-PE
Bronze white (Munsell 6Y7.5/1)
1,240
930
385
114
Finned tube
Propeller fan
6,000
39 + 63
ZR61KCE-TFD-230
3.75
kW
Phase
V
Hz
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-50m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size*
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
External static
pressure
OUTDOOR UNIT Model
Appearance colour
Dimensions
Standard
Max. motor
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
m
m
mm
m3/h
W
mmAq
mmAq
mm
mm
mm
kg
m3/h
W
Model
Output
kW
fuse, reverse phase protector, crankcase heater, inner overload relay,
Protective device
bi-metal thermostat
Long-life filter kit
Dimensions
Height
Width
Depth
Net weight
mm
mm
mm
kg
Air filter
RBC-RK462BE-PE
RBC-RK462BE-PE
80
1,350
285
12
80
1,350
285
12
Washable
Washable
*(ø22) should be used when length of pipe exceeds 30m
Specifications are subject to change without notice
5
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 6
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Model
RAV-134C-PE
RAV-164C-PE
Cooling capacity
kW
Phase
V
Hz
m
3.6
1
220-240
50
COOLING
2.0
88
9.9
60
40/37/33
50
R407C
1.05
35
Capillary tube & Expansion valve
ø12.7
Flare
ø6.4
Flare
7.5
4.5
1
220-240
50
COOLING
2.2
90
10.6
60
43/39/36
50
R407C
1.2
35
Capillary tube & Expansion valve
ø12.7
Flare
ø6.4
Flare
7.5
m
30
30
15
30
ø20 (OD)
RAV-134C-PE
Silky
Mist
188
1,030
640
24
Finned tube
Multi-blade fan
780
34
Washable
RAV-134A-PE
Bronze white (Munsell 6Y7.5/1)
740
880
310
58
Finned tube
Propeller fan
2,700
39
PG330X3F-4LS
1.5
15
30
ø20 (OD)
RAV-164C-PE
Silky
Mist
188
1,030
640
24
Finned tube
Multi-blade fan
850
34
Washable
RAV-164A-PE
Bronze white (Munsell 6Y7.5/1)
740
880
310
58
Finned tube
Propeller fan
2,700
39
PG350X3F-4LS
1.5
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
Air filter
OUTDOOR UNIT Model
Appearance colour
Dimensions
m
m
mm
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
fuse, crankcase heater, inner overload relay
Protective device
Specifications are subject to change without notice
6
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 7
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Model
RAV-264C-PE
RAV-264C-PE
Cooling capacity
kW
Phase
V
Hz
m
7.1
1
220-240
50
COOLING
3.1
90
15.0
80
45/41/37
53
R407C
1.9
35
Capillary tube & Expansion valve
ø15.9
Flare
ø9.5
Flare
7.5
7.1
3
380-415
50
COOLING
2.9
85
4.9
25
45/41/37
53
R407C
1.9
35
Capillary tube & Expansion valve
ø15.9
Flare
ø9.5
Flare
7.5
m
30
30
15
30
ø20 (OD)
RAV-264C-PE
Silky
Mist
188
1,230
640
28
Finned tube
Multi-blade fan
1,200
34
Washable
RAV-264A-PE
Bronze white (Munsell 6Y7.5/1)
790
880
310
64
Finned tube
Propeller fan
3,000
63
PG460X3F-4MS
2.2
15
30
ø20 (OD)
RAV-264C-PE
Silky
Mist
188
1,230
640
28
Finned tube
Multi-blade fan
1,200
34
Washable
RAV-264A8-PE
Bronze white (Munsell 6Y7.5/1)
790
880
310
64
Finned tube
Propeller fan
3,000
63
YG460X3F-MS
2.2
fuse, crankcase heater,
inner overload relay
fuse, crankcase heater, overcurrent
relay, reverse phase protector
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
Air filter
OUTDOOR UNIT Model
Appearance colour
Dimensions
m
m
mm
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
Protective device
Specifications are subject to change without notice
7
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 8
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Model
RAV-364C-PE
RAV-464C-PE
Cooling capacity
kW
Phase
V
Hz
m
10.0
3
380-415
50
COOLING
4.2
87
7.0
42
47/43/40
55
R407C
2.7
35
Capillary tube & Expansion valve
ø19 (ø22)
Flare
ø9.5
Flare
7.5
12.5
3
380-415
50
COOLING
5.15
87
8.5
50
49/45/41
55
R407C
3.5
50
Capillary tube & Expansion valve
ø19 (ø22)
Flare
ø9.5
Flare
7.5
m
50
50
20
50
ø20 (OD)
RAV-364C-PE
Silky
Mist
240
1,430
640
39
Finned tube
Multi-blade fan
1,680
75
Washable
RAV-364A8-PE
Bronze white (Munsell 6Y7.5/1)
1,240
930
385
102
Finned tube
Propeller fan
6,000
39 + 63
ZR49KCE-TFD-230
3.0
20
50
ø20 (OD)
RAV-464C-PE
Silky
Mist
240
1,630
640
44
Finned tube
Multi-blade fan
2,100
75
Washable
RAV-464A8-PE
Bronze white (Munsell 6Y7.5/1)
1,240
930
385
114
Finned tube
Propeller fan
6,000
39 + 63
ZR61KCE-TFD-230
3.75
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-50m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size*
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
Air filter
OUTDOOR UNIT Model
Appearance colour
Dimensions
m
m
mm
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
fuse, reverse phase protector, crankcase heater,
inner overload relay, bi-metal thermostat
Protective device
*(ø22) should be used when length of pipe exceeds 30m
Specifications are subject to change without notice
8
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 9
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Model
RAV-164K-PE
Cooling capacity
kW
Phase
V
Hz
m
4.5
1
220-240
50
COOLING
2.2
90
10.6
60
43/39/36
50
R407C
1.2
35
Capillary tube & Expansion valve
ø12.7
Flare
ø6.4
Flare
7.5
m
30
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
Air filter
OUTDOOR UNIT Model
Appearance colour
Dimensions
15
30
ø20 (OD)
RAV-164K-PE
Silky
Mist
372
1,150
226
20
Finned tube
Transverse flow fan
770
27
Washable
RAV-164A-PE
Bronze white (Munsell 6Y7.5/1)
740
880
310
58
Finned tube
Propeller fan
2,700
39
PG350X3F-4LS
1.5
m
m
mm
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
Protective device
fuse, crankcase heater, inner overload relay
Specifications are subject to change without notice
9
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 10
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Refrigerant
RAV-264K-PE
m
7.1
1
220-240
50
COOLING
3.1
90
15.0
80
44/40/37
53
R407C
1.9
35
Capillary tube & Expansion valve
ø15.9
Flare
ø9.5
Flare
7.5
7.1
3
380-415
50
COOLING
2.9
85
4.9
25
44/40/37
53
R407C
1.9
35
Capillary tube & Expansion valve
ø15.9
Flare
ø9.5
Flare
7.5
m
30
30
15
30
ø20 (OD)
RAV-264K-PE
Silky
Mist
372
1,478
226
26
Finned tube
Transverse flow fan
1,200
27
Washable
RAV-264A-PE
Bronze white (Munsell 6Y7.5/1)
790
880
310
64
Finned tube
Propeller fan
3,000
63
PG460X3F-4MS
2.2
15
30
ø20 (OD)
RAV-264K-PE
Silky
Mist
372
1,478
226
26
Finned tube
Transverse flow fan
1,200
27
Washable
RAV-264A8-PE
Bronze white (Munsell 6Y7.5/1)
790
880
310
64
Finned tube
Propeller fan
3,000
63
YG460X3F-MS
2.2
fuse, crankcase heater,
inner overload relay
fuse, overcurrent relay,
crankcase heater,
reverse phase protector
kW
Phase
V
Hz
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
RAV-264K-PE
Model
Cooling capacity
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
Air filter
OUTDOOR UNIT Model
Appearance colour
Dimensions
m
m
mm
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
Protective device
Specifications are subject to change without notice
10
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 11
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Cooling capacity
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
Model
RAV-134TU-PE
RAV-164TU-PE
kW
Phase
V
Hz
m
3.6
1
220-240
50
COOLING
2.0
88
9.9
60
40/36/34
50
R407C
1.05
35
Capillary tube & Expansion valve
ø12.7
Flare
ø6.4
Flare
7.5
4.5
1
220-240
50
COOLING
2.2
90
10.6
60
41/37/35
50
R407C
1.2
35
Capillary tube & Expansion valve
ø12.7
Flare
ø6.4
Flare
7.5
m
30
30
15
30
ø25.5 (OD)
RAV-134TU-PE
Grey (galvanized steel &
thermal insulator)
190
910
480
23
Finned tube
Transverse flow fan
700
7x2
RAV-134A-PE
Bronze white (Munsell 6Y7.5/1)
740
880
310
58
Finned tube
Propeller fan
2,700
39
PG330X3F-4LS
1.5
15
30
ø25.5 (OD)
RAV-164TU-PE
Grey (galvanized steel &
thermal insulator)
190
910
480
23
Finned tube
Transverse flow fan
750
7x2
RAV-164A-PE
Bronze white (Munsell 6Y7.5/1)
740
880
310
58
Finned tube
Propeller fan
2,700
39
PG350X3F-4LS
1.5
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
OUTDOOR UNIT Model
Appearance colour
Dimensions
m
m
mm
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
fuse, crankcase heater, inner overload relay
Protective device
CEILING PANEL model
Appearance colour
Dimensions
Height
Width
Depth
Net weight
mm
mm
mm
kg
Air filter
RBC-U133PG(W)-PE
Silky white (Munsell 2.9Y8.9/0.8)
25
1,050
550
4.5
RBC-U133PG(W)-PE
Silky white (Munsell 2.9Y8.9/0.8)
25
1,050
550
4.5
Washable
Washable
Specifications are subject to change without notice
11
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 12
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Model
RAV-164U-PE
Cooling capacity
kW
Phase
V
Hz
m
4.5
1
220-240
50
COOLING
2.2
90
10.6
60
38/35/32
50
R407C
1.2
35
Capillary tube & Expansion valve
ø12.7
Flare
ø6.4
Flare
7.5
m
30
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
OUTDOOR UNIT Model
Appearance colour
Dimensions
m
m
mm
15
30
1" BSP (male threaded connection)
RAV-164U-PE
Black (zinc galvanized steel &
thermal insulator)
259
820
820
25
Finned tube
Centrifugal fan
1,020
28
RAV-164A-PE
Bronze white (Munsell 6Y7.5/1)
740
880
310
58
Finned tube
Propeller fan
2,700
39
PG350X3F-4LS
1.5
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
fuse, crankcase heater,
inner overload relay
Protective device
RBC-U264PG(W)-E
CEILING PANEL model
Appearance colour
Dimensions
Height
Width
Depth
Net weight
White
20
940
940
6
mm
mm
mm
kg
Washable
Air filter
Specifications are subject to change without notice
12
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 13
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Model
RAV-264U-PE
RAV-264U-PE
Cooling capacity
kW
Phase
V
Hz
m
7.1
1
220-240
50
COOLING
3.1
90
15.0
80
43/39/35
50
R407C
1.9
35
Capillary tube & Expansion valve
ø15.9
Flare
ø9.5
Flare
7.5
7.1
3
380-415
50
COOLING
2.9
85
4.9
25
43/39/35
50
R407C
1.9
35
Capillary tube & Expansion valve
ø15.9
Flare
ø9.5
Flare
7.5
m
30
30
15
30
1" BSP (male threaded connection)
RAV-264U-PE
Black (zinc galvanized steel &
thermal insulator)
259
820
820
25
Finned tube
Centrifugal fan
1,260
28
RAV-264A-PE
Bronze white (Munsell 6Y7.5/1)
790
880
310
80
Finned tube
Propeller fan
3,000
64
PG460X3F-4MS
2.2
15
30
1" BSP (male threaded connection)
RAV-264U-PE
Black (zinc galvanized steel &
thermal insulator)
259
820
820
25
Finned tube
Centrifugal fan
1,260
28
RAV-264A8-PE
Bronze white (Munsell 6Y7.5/1)
790
880
310
80
Finned tube
Propeller fan
3,000
64
YG460X3F-MS
2.2
fuse, crankcase heater,
inner overload relay
fuse, crankcase heater,
overcurrent relay,
reverse phase protector
RBC-U264PG(W)-E
RBC-U264PG(W)-E
White
20
940
940
6
White
20
940
940
6
Washable
Washable
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-30m)
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
OUTDOOR UNIT Model
Appearance colour
Dimensions
m
m
mm
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
Protective device
CEILING PANEL model
Appearance colour
Dimensions
Height
Width
Depth
Net weight
mm
mm
mm
kg
Air filter
Specifications are subject to change without notice
13
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 14
Heronhill - for all your Toshiba requirements
1. SPECIFICATIONS
Item
Cooling capacity
Power source
Power consumption
Power factor
Running current
Starting current
Operating noise
(SPL)
Refrigerant
Indoor Unit (High, Med, Low)
Outdoor Unit
Name of Refrigerant
Charge Volume
Add. Volume (20-50m)
Model
RAV-364U-PE
RAV-464U-PE
kW
Phase
V
Hz
m
10.0
3
380-415
50
COOLING
4.2
87
7.0
42
42/40/37
55
R407C
2.7
35
Capillary tube & Expansion valve
ø19 (ø22)
Flare
ø9.5
Flare
7.5
12.5
3
380-415
50
COOLING
5.15
87
8.5
50
45/43/40
55
R407C
3.5
50
Capillary tube & Expansion valve
ø19 (ø22)
Flare
ø9.5
Flare
7.5
m
50
50
kW
%
A
A
dB(A)
dB(A)
kg
g/m
Refrigerant control
Interconnection
pipe
Larger side size*
Coupler style
Smaller side size
Coupler style
Standard length
Maximum actual pipe length
(of one way)
Maximum height difference
If Indoor Unit higher
If Outdoor Unit higher
mm
Height
Width
Depth
mm
mm
mm
kg
Condensate drain pipe diameter
INDOOR UNIT Model
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
OUTDOOR UNIT Model
Appearance colour
Dimensions
m
m
mm
m3/h
W
Height
Width
Depth
Net weight
Heat exchanger type
Outdoor fan type
Air flow volume
Fan motor output
Compressor
mm
mm
mm
mm
kg
m3/h
W
Model
Output
kW
fuse, reverse phase protector, crankcase heater,
inner overload relay, bi-metal thermostat
Protective device
CEILING PANEL model
Appearance colour
Dimensions
20
20
50
50
1" BSP (male threaded connection) 1" BSP (male threaded connection)
RAV-364U-PE
RAV-464U-PE
Black (zinc galvanized steel &
Black (zinc galvanized steel &
thermal insulator)
thermal insulator)
309
309
1,230
1,230
820
820
43
43
Finned tube
Finned tube
Centrifugal fan
Centrifugal fan
1,750
1,820
36
36
RAV-364A8-PE
RAV-464A8-PE
Bronze white (Munsell 6Y7.5/1)
Bronze white (Munsell 6Y7.5/1)
1,240
1,240
930
930
385
385
102
114
Finned tube
Finned tube
Propeller fan
Propeller fan
6,000
6,000
39 + 63
39 + 63
ZR49KCE-TFD-230
ZR61KCE-TFD-230
3.0
3.75
Height
Width
Depth
Net weight
mm
mm
mm
kg
Air filter
RBC-U464PG(W)-E
RBC-U464PG(W)-E
White
20
1,350
940
8
White
20
1,350
940
8
Washable
Washable
*(ø22) should be used when length of pipe exceeds 30m
Specifications are subject to change without notice
14
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 15
Heronhill - for all your Toshiba requirements
2. CONSTRUCTION VIEWS
2.1 Indoor Unit
RAV-164B-PE
RAV-264B-PE
RAV-364B-PE
RAV-464B-PE
Rear return air
inlet knockouts
320
Electrical box
Thermal insulator
Unit dimension: 800
Hanging bolt pitch: B
80
60
305
345
60 80
90 120
Refrigerant
piping joint
(Gas øF)
H
150
J=MxK
80
6-ø4 Mounting screw
hole ø160
210
320
320
Hanging bolt pitch: 565
720
630
340
11
70
75
100
Hanging bolt
4-M10
Provided at site
170
Unit dimension: A
Air outlet
N-ø200
270
Refrigerant
piping joint
(Liquid øG)
Drain pipe connection
port (Inner diameter: 32.5)
ø125 Knockout
hole (rear)
(Fresh air inlet)
(Port diameter: nominal
for PVC pipes) ø35
Wiring connection port
Lower return
Air inlet
Ensure that there is sufficient space around the
indoor unit for installation and servicing
300-400
Inspection
hole
450
200
Indoor unit
450
Provide an inspection
hole in this position
Model
RAV-164B-PE
RAV-264B-PE
RAV-364B-PE
RAV-464B-PE
A
700
1000
1350
1350
B
750
1050
1400
1400
F
12.7
15.9
19.0
19.0
G
6.4
9.5
9.5
9.5
H
252
252
252
252
J
280
580
930
930
K
280
290
310
310
M
1
2
3
3
N
2
3
4
4
(Unit : mm)
15
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 16
Heronhill - for all your Toshiba requirements
2. CONSTRUCTION VIEWS
2.2 Indoor Unit
RAV-134C-PE
RAV-164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
Drain piping joint
Refrigerant pipe
connection (Gas øG)
78
12
145
80 80
85
62
34
Hard vinyl chloride
pipe outer dia. 20mm
Refrigerant pipe
connection (Liquid øF)
Alternative
Knock-out hole
for drain piping
30
140
50
Right-side panel
knock-out for
piping and wiring
130 50
150
180
200
170
100 10
Hanging bolt hole
4 - (12x25) Slot
Knock-out holes for
piping and wiring
85
12
120
30
Air filter
C
640
250
Hanging bolt
pitch
Air inlet
B (Hanging bolt pitch)
A
Hanging bolt
Less than 40
E
40
B
Outer hanging bolt pitch
Inner hanging bolt pitch
Greater than
500
Hanging bolt
Less than 40
D
Hanging plate
(Right)
130
Hanging plate
(Left)
150
Minimum
150
Minimum
Space required for service and installation
Greater than
400
Model
RAV-134C-PE
RAV-164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
A
B
C
D
E
F
G
1,030
1,030
1,230
1,430
1,630
920
920
1,120
540
540
540
550
550
188
188
188
1,020
1,020
1,220
240
240
1,420
1,620
6.4
6. 4
9. 5
9.5
9.5
12.7
12.7
15.9
19.0
19.0
1,320
1,520
(unit : mm)
16
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 17
Heronhill - for all your Toshiba requirements
2. CONSTRUCTION VIEWS
2.3 Indoor Unit
RAV-164K-PE
RAV-264K-PE
158
143
226
A
216
Refrigerant pipe
connection
(Gas øC)
ø20
(OD.)
372
595
495
(Both sides)
Piping hole
40
(Knockout hole)
900
Drain pipe
40
Air outlet
4-way adjustable
Refrigerant pipe
connection
(Liquid øB)
Piping hole
(Knockout hole)
70 118
More than 30
A
B
C
RAV-164K-PE
1150
12.7
6.4
RAV-264K-PE
1478
15.9
9.5
MODEL
More than 300
More than 300
RAV-164K-PE
Space required for service
150
Slots
18-6x30
6-ø6 Holes
150
40 20
24
169
150
30 50 50 45
2040 150
(unit : mm)
600
Anchor bolt holes
4 - 10x20 slots
RAV-264K-PE
150
150
150
150 40 20
Slots
21-6x30
8-ø6 Holes
169
150
30 50 50 45
2040 150
940
Anchor bolt holes
4 - 10x20 slots
Installation board mounting bolt hole location
17
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 18
Heronhill - for all your Toshiba requirements
2. CONSTRUCTION VIEWS
2.4 Indoor Unit
RAV-134TU-PE
RAV-164TU-PE
80
480
290
Drain pipe joint
(outer ø25.5)
Hanger bolt
(4-M10)
70
Refrigerant piping joint
(Liquid ø6.4)
Refrigerant piping joint
(Gas ø12.7)
840
110
131
25
96
156
190
190
Wiring connection
A
Panel outer dimension 1050
Ceiling opening 1010
Hang bolt pitch 930
20
40
70
1050
840
550
TOSHIBA
Ceiling opening 510
480
Hang bolt pitch 410
Panel outer dimension 550
40
20
40
110
90
66
73
View A
200
(Unit: mm)
600
Minimum
600
Minimum
600
Minimum
Space required for service and installation
18
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
Heronhill - for all your Toshiba requirements
2. CONSTRUCTION VIEWS
2.5 Indoor Unit
RAV-164UH-PE
RAV-264UH-PE
185
39
20
73
140
240
138
195
Ceiling
Drain pipe connection
(1" BSP threaded connection)
Knockout for side ducts ø150 (both sides)
30
40
405
400
Model (RAV-)
164U
264U
øA
øB
12.7
6.4
15.9
9.5
268
195
536
800 (Hanger bolt pitch)
820 (External cassette dimension)
880 (Ceiling opening)
940 (Panel dimension)
Wiring connection
(Gland plate 3xø20 holes)
940
298
138
30
200
Refrigerant pipe connection
(Liquid øB)
106
259
106
160
Refrigerant pipe connection
(Gas øA)
170
100
80
Fresh air inlet
Condensate pipe 1" BSP
threaded connection
Fresh air inlet duct size
Side outlet duct size
ø100
4 - ø6
45°
ø180
0
130
ø30
ø144
4 ø130
ø97
130
ø18
ø14
80
6 - ø6
10
80
10
45°
45°
30 2
45°
ø200
32
940
ø150
536
620 (Hanger bolt pitch)
820 (External cassette dimension)
880 (Ceiling opening)
940 (Panel dimension)
130
30
30
6
19
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 20
Heronhill - for all your Toshiba requirements
2. CONSTRUCTION VIEWS
2.6 Indoor Unit
RAV-364U-PE
RAV-464U-PE
185
Knockout for side ducts ø150 (both sides)
941
106
Refrigerant pipe connection
(Gas side ø19.0)
170
100
20
30
Drain pipe connection
(1" BSP threaded connection)
610
605
800 (Hanger bolt pitch)
820 (External cassette dimension)
880 (Ceiling opening)
940 (Panel dimension)
40
200
73
140
Ceiling
Ceiling panel
Wiring connection
(Gland plate 3xø20 holes)
940
39
240
30
30
138
Refrigerant pipe connection
(Liquid side ø9.5)
202
138
348
309
210
106
80
Fresh air inlet
Condensate pipe 1" BSP
940
1030 (Hanger bolt pitch)
30
130
threaded connection
1350
1230 (External cassette dimension)
1290 (Ceiling opening)
1350 (Panel opening)
Fresh air inlet duct size
Side outlet duct size
80
10
130
10
45°
ø180
ø18
45°
30 2
45°
45°
ø200
4 ø130
80
6 - ø6
0
ø14
ø97
130
4 - ø6
ø150
ø100
ø30
ø144
32
30
6
20
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 21
Heronhill - for all your Toshiba requirements
2. CONSTRUCTION VIEWS
2.7 Outdoor Unit
RAV-134A-PE
RAV-164A-PE
RAV-264A-PE
RAV-264A8-PE
360
Refrigerant pipe connection
(Gas ø D)
12
340
30
70
70 50
280
40
12
Knock-out hole for drain
(2-20x60 slots)
Hole for drain
(2xø19 hole)
165
117
Refrigerant pipe connection
(Liquid ø C)
50
45
Electric
parts box
310
Air outlet
880
104
Anchor bolt hole
(4-12x18slots)
Earth screw (M6)
45
790
Terminal cover
A
500
Handle
(Both sides)
18
B
90
88
320
37
364
Blow out guide
mounting hole
(4-ø3 embosses)
566
Space required for service
Outlet
500
100
(Space for wiring
and piping)
When installed with the
inlet facing the wall
Model
500
300
100
100
(Space for wiring
and piping)
Outlet
When installed with the
outlet facing the wall
A
B
øC
øD
RAV-134A-PE
RAV-164A-PE
740
380
6.4
12.7
RAV-264A-PE
RAV-264A8-PE
790
430
9.5
15.9
(unit : mm)
21
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
Heronhill - for all your Toshiba requirements
2. CONSTRUCTION VIEWS
2.8 Outdoor Unit
RAV-364AH8-PE
RAV-464AH8-PE
Knock-out hole for drain
(2-30x80 slots)
44
416
80
30
30
12
Refrigerant pipe
connection
(Gas ø19)
360
55
Air inlet
125
Air inlet
Refrigerant pipe
connection
(Liquid ø9.5)
29
12
50
Air outlet
45
Handle
(front side only)
Earth screw
(M6)
45
840
Anchor bolt hole
(4-12x18 slots)
Terminal cover
Handle
(Both sides)
Air outlet
385
930
500
115
1240
615
500
299
245
50
275
90
37
18
73
150
70
440
566
Blow out guide mounting hole
(8-ø3 embosses)
Knock-out hole
(ø40)
150
Space required for service
150
(Space for wiring
and piping)
500
150
(Space for wiring
and piping)
When installed with the
inlet facing the wall
500
300
Outlet
Outlet
When installed with the
outlet facing the wall
(unit : mm)
22
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 23
Heronhill - for all your Toshiba requirements
3. WIRING DIAGRAMS
3.1 RAV-164B-PE
RAV-264B-PE
RAV-364B-PE
RAV-464B-PE
Connector
assembly
(accessory)
TC
TA
CN05
(TC)
CN04
(TA)
CN12
ORG
BLU
7
6
5
4
3
2
1
L
RY03
5 5
7 7
YEL
7
6
5
CN01
4 (TRANS)
3
2
1
RED
GRY
FM
WHI
RY01
(output)
9 9
FM
GRN/YEL
RED
BRW
BLK
ORG
BLU
YEL
BLU
(Fan speed
increase
option)
RC
WHI
BLK
YEL
RED
BRW
BLK
ORG
BLU
YEL
CN07
(FAN)
H
BLK
1 1
M
ORG
3 3
RY02
REMOCON
ORG
1 1
YEL
2 2
BLU
3 3
CN02
RED
BLK
ORG
BLU
YEL
3 3
RY07
RY14
RY01
1
1
1
3
3
(N)
5
5
7
7
CN11
(FLOAT)
1
3
1
3
BLK
F (L1)
3
RED
CN10
(PUMP) 5
GRY
TR
CN03
RED
1 1
GRN/YEL
1
2
3
1
2
3
Indoor unit
(1 Phase
model)
A
B
C
F2
Earth
Screw
L
N
Power
Supply
220/240V
~50Hz
A
B
C
Remote
Controller
(optional)
1
(3 Phase
model)
2
3
L2
L3
F2
Earth
Screw
L1
Outdoor unit
Symbol
FM
RC
TR
F
shows terminal block and figures show terminal numbers.
Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
N
Power
Supply
380/415V
3N~50Hz
Name
Symbol
Name
Sensor
TA
Fan Motor
Sensor
TC
Running Capacitor
Transformer
RY01-RY14 Relay
Fuse (PCB)
23
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 24
Heronhill - for all your Toshiba requirements
3. WIRING DIAGRAMS
3.2 RAV-134C-PE
TC
TA
CN05
(TC)
CN04
(TA)
ORG
BLU
7
6
5
4
3
2
1
5 5
7 7
FM
BLU
GRY
WHI
RC
YEL
RY01
(output)
9 9
7
6
5
CN01
4 (TRANS)
3
2
1
GM
CN09
(WHI).
(LOUVER)
WHI
BLK
YEL
L
RY03
GRN/YEL
BLK
CN12
RED
CN07
(FAN)
H
BLK
1 1
M
ORG
3 3
RY02
REMOCON
ORG
1 1
YEL
2 2
BLU
3 3
CN02
BLK
RAV-164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
3 3
RY07
RY14
RY01
RY11
1
1
1
3
3
(N)
5
5
7
7
CN11
(FLOAT)
1
3
1
3
BLK
F (L1)
3
RED
CN10
(PUMP) 5
GRY
TR
CN03
RED
1 1
GRN/YEL
1
2
3
1
2
3
Indoor unit
(1 Phase
model)
A
B
F2
C
Earth
Screw
L
N
Power
Supply
220/240V
~50Hz
A
B
C
Remote
Controller
(optional)
1
(3 Phase
model)
2
3
L2
L3
F2
Earth
Screw
L1
Outdoor unit
Symbol
FM
RC
TR
F
shows terminal block and figures show terminal numbers.
Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
N
Power
Supply
380/415V
3N~50Hz
Name
Symbol
TA
Fan Motor
TC
Running Capacitor
Transformer
GM
Fuse (PCB)
RY01-RY14
Name
Sensor
Sensor
Geared Motor
Relay
24
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 25
Heronhill - for all your Toshiba requirements
3. WIRING DIAGRAMS
3.3 RAV-164K-PE
TC
TA
CN05
(TC)
CN12
ORG
BLU
7
6
5
4
3
2
1
CN07
(FAN)
H
BLK
1 1
ORG
M
3 3
9 9
BLU
3 3
YEL
1 1
L
RY03
5 5
7 7
9 9
7 7
5 5
BLK
ORG
BLU
FM
YEL
RED
WHI
RED
7
6
5
CN01
4 (TRANS)
3
2
1
RC
WHI
GRY
RED
RY01
(output)
GM
CN09
(WHI).
(LOUVER)
WHI
BLK
YEL
RY02
REMOCON
ORG
1 1
YEL
2 2
BLU
3 3
CN02
BLK
CN04
(TA)
BLK
RAV-264K-PE
3 3
RY01
RY07
RY14
RY11
1
1
1
3
3
(N)
5
5
7
7
CN11
(FLOAT)
1
3
1
3
BLK
F (L1)
3
RED
CN10
(PUMP) 5
GRY
TR
CN03
RED
1 1
GRN/YEL
1
2
3
1
2
3
Indoor unit
(1 Phase
model)
A
B
C
F2
Earth
Screw
L
N
Power
Supply
220/240V
~50Hz
A
B
C
Remote
Controller
(Optional)
1
(3 Phase
model)
2
3
L2
L3
F2
Earth
Screw
L1
Outdoor unit
Symbol
FM
RC
TR
F
shows terminal block and figures show terminal numbers.
Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
N
Power
Supply
380/415V
3N~50Hz
Name
Symbol
TA
Fan Motor
TC
Running Capacitor
Transformer
GM
Fuse (PCB)
RY01~RY14
Name
Sensor
Sensor
Geared Motor
Relay
25
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:02 pm
Page 26
Heronhill - for all your Toshiba requirements
3. WIRING DIAGRAMS
3.4 RAV-134TU-PE
RAV-164TU-PE
TC
TA
DM
7
6
5
4
3
2
1
7 7
9 9
BLU
YEL
RED
7
6
5
CN01
4 (TRANS)
3
2
1
CN09
(WHI).
(LOUVER)
RY01
(output)
F3
WHI
BLK
YEL
5 5
CS
BLK
ORG
BLU
L
RY03
BLK
CN12
CN07
(FAN)
BLK
H
1 1
M
ORG
3 3
RY02
REMOCON
ORG
1 1
YEL
2 2
BLU
3 3
CN02
15 15
14 14
13 13
12 12
11 11
10 10
9 9
8 8
7 7
6 6
5 5
4 4
3 3
2 2
1 1
CN05
(TC)
CN04
(TA)
Interface
PCB
3 3
RY07
RY14
RY01
TR
RY11
TR
CN10
(PUMP) 5
5
F (L1)
3
3
1
1
1
1
3
3
CN03
RED
1 1
(N)
5
5
7
7
CN11
(FLOAT)
1
3
1
3
SM
01
6
4
8
43
SM
02
7
43
3
43
2
5
RED
WHI
1 2 3 4 5 6
1 2 3 4 5 6
WHI
WHI
1
1
2
3
4
5
6
RC02
WHI
1
2
3
RED
4
5
6
FM
02
YEL
BLU
ORG
BLK
RC01
WHI
RED
GRN/YEL
Indoor unit
A
B
1
2
3
1
2
3
1
2
3
4
5
6
1 WHI
2
3
RED
4
5
6
FM
01
YEL
BLU
ORG
BLK
C
(1 Phase
model)
F2
A
B
C
Remote
Controller
(Optional)
Earth
Screw
L
N
Power
Supply
220/240V
~50Hz
Outdoor
unit
Symbol
FM01, 02
RC01, 02
TR
TA
TC
RY01-RY14
shows terminal block and figures show terminal numbers.
Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
Name
Fan Motor
Running Capacitor
Transformer
Sensor
Sensor
Relay
Symbol
F
F3
DM
SM01, 02
CS
43
Name
Fuse (PCB)
Fuse (Interface) PCB
Drain Pump
Stepper Motor
Float Switch
Relay
26
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 27
Heronhill - for all your Toshiba requirements
3. WIRING DIAGRAMS
3.5 RAV-164U-PE
TC
TA
RAV-264U-PE
RAV-364U-PE
RAV-464U-PE
RED
CN05
(TC)
CN04
(TA)
CN12
ORG
BLU
7
6
5
4
3
2
1
L
RY03
5 5 BLU
7 7 YEL
9 9 RED
GRN/YEL
RED
WHI
GRY
1
2
3
4
5
6
7
8
9
FM
BLK
ORG
BLU
YEL
RY01
(output)
7
6
5
CN01
4 (TRANS)
3
2
1
GM
CN09
(WHI).
(LOUVER)
WHI
BLK
YEL
1
2
3
4
5
6
7
8
9
CN07
(FAN)
H
BLK
1 1
M
ORG
3 3
RY02
REMOCON
ORG
1 1
YEL
2 2
BLU
3 3
CN02
RC
3 3
RY07
RY14
RY01
RY11
1
1
3
3
(N)
5
5
7
7
CN11
(FLOAT)
1
3
1
3
BLK
F (L1)
1
1
3
3
RED
CN10
(PUMP) 5
5
GRY
TR
CN03
RED
1 1
CS
8
43
7
DM
3
43
5
1
6
4
GRN/YEL
2
43
1
2
3
1
2
3
Indoor unit
(1 Phase
model)
A
B
F2
C
Earth
Screw
L
N
Power
Supply
220/240V
~50Hz
A
B
C
Remote
Controller
(Optional)
1
(3 Phase
model)
2
3
L2
L3
F2
Earth
Screw
L1
Outdoor unit
Symbol
FM
RC
TR
shows terminal block and figures show terminal numbers.
Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
N
Power
Supply
380/415V
3N~50Hz
Name
Fan Motor
Running Capacitor
Transformer
F
Fuse (PCB)
DM
Drain Motor
CS
Float Switch
Symbol
TA
TC
GM
Name
Sensor
Sensor
Geared Motor
RY01-RY14 Relay
Relay
43
27
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 28
Heronhill - for all your Toshiba requirements
3. WIRING DIAGRAMS
3.6 RAV-134A-PE
RAV-164A-PE
RAV-264A-PE
1
2
3
Indoor unit
Outdoor unit
1
2
3
Earth
Screw
A
1
2
3
4
13
14
52C
B
RC c
RED
CM
WHI
F
63F2
31
32
49C BLK
RED
6
5
3
4
2
52C
63F1
1
BLK 1 1 BLK
ORN 2 2 ORN
BLU
BLU
3 3
RED
6
5
4
3
2
WHI
1
RC o
CH
6
5
4
3
2
1
BLK
ORN
BLU
RED
FM
0
WHI
RED
Surge Absorber
L
N
Power Supply 220/240V~50Hz
Shows terminal block and figures show terminal numbers. Broken lines show wiring at site.
Do not operate the units with magnetic contactor pushed in.
Symbol
Name
Symbol
49C
RCc
RCo
F
63F1,2
Inner overload relay
Running capacitor (compressor)
Running capacitor (fan motor)
Fuse (T5A)
Pressure Switch (2 Stage)
CM
52C
FMo
CH
Name
Compressor
Magnetic contactor
Fan motor
Crankcase heater
28
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 29
Heronhill - for all your Toshiba requirements
3. WIRING DIAGRAMS
3.7 RAV-264A8-PE
1
2
3
Indoor unit
Outdoor unit
1
2
3
Earth
Screw
51C
49C
21
A
22
52C
B
47C
Surge Absorber
L1
47C
S
R
T
Power
Supply
L2
380/415V
L3
1
2
2
3
4
4
5
6
6
13
14
6
F
3N~50Hz
5
6 3 F2
N
31
3
4
2
6 3 F1
32
1
52C
CM
BLK 1 1 BLK
ORN 2 2 ORN
BLU
BLU
3 3
RED
RC o
WHI
6
5
4
3
2
1
6
5
4
3
2
1
BLK
ORN
BLU
RED
FM
0
WHI
CH
1.
Shows terminal block and figures show terminal numbers. Broken lines show wiring at site.
2. When the three phases are not connected correctly, the reverse phase protector operates, and the unit will
not start. In this case, check the three phase wiring.
Do not operate the units with magnetic contactor pushed in.
Symbol
49C
47C
RCo
F
63F1,2
Name
Symbol
Thermostat
Return Lock
Running capacitor (fan motor)
Fuse (T5A)
Pressure Switch (2 Stage)
CM
52C
FMo
CH
51C
Name
Compressor
Magnetic contactor
Fan motor
Crankcase heater
Overload relay
29
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 30
Heronhill - for all your Toshiba requirements
3. WIRING DIAGRAMS
3.8 RAV-364A8-PE
RAV-464A8-PE
1
2
3
Indoor unit
Outdoor unit
1
2
3
Earth
Screw
Surge Absorber
26HD
A1
7
7
8
43F1
52C
A2
43F
2 8
8
7
RED
6
5
4
RED
3
2
WHI
1
BLK
43F1
3
43F2
5
1
3
5
1
BLK
6
5
4
RED
3
FM
2
WHI UP
1
RC01
47C
43F1
4
43F2
6
2
4
6
6
5
4
RED
3
RC02
2
WHI
1
BLK
2
63F2
6
5
3
4
2
63F1
1
6
5
4
RED
3
FM
2
WHI LOW
1
BLK
47C
S
R
T
L1
L2
L3
L1
T1
L2
T2
L3
T3
13
14
21
22
CM
*
N
Power Supply 380-415V 3N~50Hz
CH
52C
Shows terminal block and figures show terminal numbers.
Broken lines show wiring at site.
Do not operate the units with magnetic contactor pushed in.
Symbol
63F1,2
43F1,2
47C
F
Name
2-Stage Pressure Switch
Relay
Reverse Phase Protector
Fuse (T5A)
* Compressor has internal thermal protection
Name
Symbol
CM
Compressor
52C
Magnetic contactor
FMUP,LOW Fan motor (Outdoor)
Symbol
Name
RC01,02 Running capacitor
Crankcase heater
CH
26HD Bimetal Thermostat
30
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 31
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.1
RAV-164B-PE
No
SMF-230-60-4A
2
Running capacitor for
indoor fan motor
EEP2G405HQA114
AC 400V, 4µF
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Sensor for room temperature
Output (rated) 60W, 4 pole, 230V, 1 Phase, 50Hz
Maximum input
38mA
Sensor for heat
exchanger temperature
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
˚C
-12
10
k½
67.5
21.3
RAV-264B-PE
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
STF-200-100-4B
Output (rated) 100W, 4 pole, 200V, 1 Phase, 50Hz
2
Running capacitor for
indoor fan motor
EAG40M505UF
AC 400V, 5µF
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Sensor for room temperature
5
Maximum input
38mA
Sensor for heat
exchanger temperature
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
˚C
-12
10
k½
67.5
21.3
RAV-364B-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
STF-200-120-4B
Output (rated) 120W, 4 pole, 200V, 1 Phase, 50Hz
2
Running capacitor for
indoor fan motor
EAG40M505UF
AC 400V, 5µF
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Sensor for room temperature
5
4.4
SPECIFICATIONS
Indoor Unit fan motor
No
4.3
TYPE
1
5
4.2
PARTS NAME
Maximum input
38mA
Sensor for heat
exchanger temperature
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
˚C
-12
10
k½
67.5
21.3
RAV464B-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
STF-200-140-4F
Output (rated) 140W, 4 pole, 200V, 1 Phase, 50Hz
2
Running capacitor for
indoor fan motor
EAG40M106UF
AC 400V, 10µF
3
Transformer (Indoor Unit)
4
Sensor for room temperature
5
AC 187-264V
ST-9586
Maximum input
38mA
Sensor for heat
exchanger temperature
Maximum input
15.5mA
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
˚C
-12
10
k½
67.5
21.3
31
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 32
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.5 RAV-134C-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
SMF-230-34-4H
2
Running capacitor for
indoor fan motor
EEP2H155HQA107
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-6
AC 230V, 3W
5
Sensor for room temperature
6
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.5µF
Maximum input
38mA
Indoor Unit sensor for heat
exchanger temperature
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
˚C
-12
10
k½
67.5
21.3
4.6 RAV-164C-PE
No
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
SMF-230-34-4D
2
Running capacitor for
indoor fan motor
EEP2W255HQA113
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-6
AC 230V, 3W
5
Sensor for room temperature
6
4.7
PARTS NAME
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.5µF
Maximum input
38mA
Indoor Unit sensor for heat
exchanger temperature
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
˚C
-12
10
k½
67.5
21.3
RAV-264C-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
SMF-230-34-4D
2
Running capacitor for
indoor fan motor
EEP2W255HQA113
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-6
AC 230V, 3W
5
Sensor for room temperature
6
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.5µF
Maximum input
38mA
Indoor Unit sensor for heat
exchanger temperature
Maximum input
15.5mA
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
˚C
-12
10
k½
67.5
21.3
32
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 33
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.8 RAV-364C-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
SMF-230-75-4U
Output (rated) 75W, 4 pole, 230V, 1 Phase, 50Hz
2
Running capacitor for
indoor fan motor
EVM45M305UF
AC 450V, 3.0µF
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-6
AC 230V, 3W
5
Sensor for room temperature
6
Maximum input
38mA
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
Indoor Unit sensor for heat
exchanger temperature
˚C
-12
10
k½
67.5
21.3
4.9 RAV-464C-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
SMF-230-75-4B
2
Running capacitor for
indoor fan motor
EEP2G405HQA114
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8 -3-6
AC 230V, 3W
5
Sensor for room temperature
6
Output (rated) 75W, 4 pole, 230V, 1 Phase, 50Hz
AC 400V, 4.0µF
Maximum input
38mA
Indoor Unit sensor for heat
exchanger temperature
Maximum input
15.5mA
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
˚C
-12
10
k½
67.5
21.3
33
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 34
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.10 RAV-164K-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
MMF-230-27-4P
2
Running capacitor for
indoor fan motor
EEP2H155HQA107
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-6
AC 230V, 3W
5
Sensor for room temperature
6
Output (rated) 27W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.5µF
Maximum input
38mA
Indoor Unit sensor for heat
exchanger temperature
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
˚C
-12
10
k½
67.5
21.3
4.11 RAV-264K-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Indoor Unit fan motor
MMF-230-27-4R
2
Running capacitor for
indoor fan motor
EEP2W205HQA107
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-6
AC 230V, 3W
5
Sensor for room temperature
6
Output (rated) 27W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.0µF
Maximum input
38mA
Maximum input
15.5mA
Indoor Unit sensor for heat
exchanger temperature
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
˚C
-12
10
k½
67.5
21.3
34
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 35
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.12
RAV-134TU-PE
No
TYPE
SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
1
Indoor unit fan motor (x2)
2
Running capacitor for
indoor fan motor (x2)
3
Transformer (Indoor Unit)
4
Stepper motor (x2)
5
Drain pump
PCD-4N230TF-3
AC 230V, 0.2A
6
Float switch
FS-085-003E
AC 230V, 0.5A
7
Sensor for room temperature
8
9
4.13
PARTS NAME
PAF-230-7-4
EEP2H105HQA105
AC 187-264V
ST-9586
DC 12V, 80mNm
MP35EA2
Maximum input
38mA
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
Indoor Unit sensor for heat
exchanger temperature
Relay
AC 500V, 1.0µF
˚C
-12
10
k½
67.5
21.3
AC 240V, 2ab
LY2F-L
RAV-164TU-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
1
Indoor unit fan motor (x2)
2
Running capacitor for
indoor fan motor (x2)
3
Transformer (Indoor Unit)
4
Stepper motor (x2)
5
Drain pump
PCD-4N230TF-3
AC 230V, 0.2A
6
Float switch
FS-085-003E
AC 230V, 0.5A
7
Sensor for room temperature
8
9
PAF-230-7-4
EEP2H105HQA105
AC 187-264V
ST-9586
DC 12V, 80mNm
MP35EA2
Maximum input
38mA
Maximum input
15.5mA
Indoor Unit sensor for heat
exchanger temperature
Relay
AC 500V, 1.0µF
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
˚C
-12
10
k½
67.5
21.3
AC 240V, 2ab
LY2F-L
35
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 36
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.14
RAV-164U-PE
No
TYPE
SPECIFICATIONS
Output (rated) 28W, 6 pole, 230V, 1 Phase, 50Hz
1
Indoor unit fan motor
MMF-230-28A
2
Running capacitor for
indoor fan motor
EEP2H105HQA105
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-8
AC240V, 3W
5
Drain pump
PJV-0739
AC 230V, 0.2A
6
Float switch
FS-085-003B
AC 230V, 0.5A
7
Sensor for room temperature
8
9
4.15
PARTS NAME
Maximum input
38mA
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
Indoor Unit sensor for heat
exchanger temperature
Relay
AC 500V, 1.0µF
˚C
-12
10
k½
67.5
21.3
AC 240V, 2ab
LY2F-L
RAV-264U-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
Output (rated) 28W, 6 pole, 230V, 1 Phase, 50Hz
1
Indoor unit fan motor
MMF-230-28A
2
Running capacitor for
indoor fan motor
EEP2W205HQA107
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-8
AC240V, 3W
5
Drain pump
PJV-0739
AC 230V, 0.2A
6
Float switch
FS-085-003B
AC 230V, 0.5A
7
Sensor for room temperature
8
9
Maximum input
38mA
Maximum input
15.5mA
Indoor Unit sensor for heat
exchanger temperature
Relay
AC 450V, 2.0µF
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
˚C
-12
10
k½
67.5
21.3
AC 240V, 2ab
LY2F-L
36
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 37
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.16
RAV-364U-PE
No
TYPE
SPECIFICATIONS
Output (rated) 36W, 6 pole, 230V, 1 Phase, 50Hz
1
Indoor unit fan motor
MMF-230-36A
2
Running capacitor for
indoor fan motor
EEP2W255HQA113
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-8
AC240V, 3W
5
Drain pump
PJV-0739
AC 230V, 0.2A
6
Float switch
FS-085-003B
AC 230V, 0.5A
7
Sensor for room temperature
8
9
4.17
PARTS NAME
Maximum input
38mA
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
Maximum input
15.5mA
Indoor Unit sensor for heat
exchanger temperature
Relay
AC 450V, 2.5µF
˚C
-12
10
k½
67.5
21.3
AC 240V, 2ab
LY2F-L
RAV-464U-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
Output (rated) 36W, 6 pole, 230V, 1 Phase, 50Hz
1
Indoor unit fan motor
MMF-230-36A
2
Running capacitor for
indoor fan motor
EVM45M305UF
3
Transformer (Indoor Unit)
ST-9586
AC 187-264V
4
Geared motor
MT8-3-8
AC240V, 3W
5
Drain pump
PJV-0739
AC 230V, 0.2A
6
Float switch
FS-085-003B
AC 230V, 0.5A
7
Sensor for room temperature
8
9
AC 450V, 3.0µF
Maximum input
38mA
Maximum input
15.5mA
Indoor Unit sensor for heat
exchanger temperature
Relay
˚C
15
20
25
30
40
k½
16.1
12.6
10.0
8.0
5.2
˚C
-12
10
k½
67.5
21.3
AC 240V, 2ab
LY2F-L
37
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 38
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.18
RAV-134A-PE
No
4.19
PARTS NAME
SPECIFICATIONS
1
Compressor
PG330X3F-4LS
Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz
2
Outdoor unit fan motor
SMF-230-39N-3
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
3
Running capacitor for
outdoor fan motor
EEP2G405HQA114
4
Magnetic contactor
5
Pressure switch (2-Stage)
6
Crankcase heater
AC 240V, 28W
7
Fuse
T5A
8
Running capacitor
for compressor
AC 400V, 4µF
AC 220-240V, 50Hz
FMCa-1S-02
Tripping pressure 19kgf/cm2G, 21kgf/cm2G
Resetting pressure 13kgf/cm2G,15kgf/cm2G
STB-X602
AC 440V, 45µF
MT-44MP456W
RAV-164A-PE
No
4.20
TYPE
PARTS NAME
TYPE
SPECIFICATIONS
1
Compressor
PG350X3F-4LS
Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz
2
Outdoor unit fan motor
SMF-230-39N-3
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
3
Running capacitor for
outdoor fan motor
EEP2G405HQA114
4
Magnetic contactor
5
Pressure switch (2-Stage)
6
Crankcase heater
AC 240V, 28W
7
Fuse
T5A
8
Running capacitor
for compressor
AC 400V, 4µF
AC 220-240V, 50Hz
FMCa-1S-02
Tripping pressure 21kgf/cm2G, 23kgf/cm2G
Resetting pressure 15kgf/cm2G,17kgf/cm2G
STB-X603
AC 440V, 45µF
MT-44MP456W
RAV-264A-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Compressor
PG460X3F-4MS
Output (rated) 2.2kW, 2 pole, 220/240V, 1 Phase, 50Hz
2
Outdoor unit fan motor
SMF-230-63N-3
Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz
3
Running capacitor for
outdoor fan motor
EEP2G405HQA114
4
Magnetic contactor
5
Pressure switch (2-Stage)
6
Crankcase heater
AC 240V, 28W
7
Fuse
T5A
8
Running capacitor
for compressor
AC 400V, 4µF
AC 220-240V, 50Hz
FMCa-1S-02
Tripping pressure 21kgf/cm2G, 23kgf/cm2G
Resetting pressure 15kgf/cm2G,17kgf/cm2G
STB-X603
EAR42M606UF
AC 420V, 60µF
38
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 39
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.21
RAV-264A8-PE
No
PARTS NAME
TYPE
SPECIFICATIONS
1
Compressor
YG460X3F-MS
Output (rated) 2.2kW, 2 pole, 380/415V, 3 Phase, 50Hz
2
Outdoor unit fan motor
SMF-230-63N-3
Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz
3
Running capacitor for
outdoor fan motor
EEP2G405HQA114
4
Magnetic contactor
5
Pressure switch (2-Stage)
6
Crankcase heater
AC 240V, 28W
7
Fuse
T5A
8
Reverse Phase Protector
FMSa-1
AC 400V, 4µF
AC 220-240V, 50Hz
STB-X603
Tripping pressure 21kgf/cm2G, 23kgf/cm2G
Resetting pressure 15kgf/cm2G,17kgf/cm2G
STR-4AD
39
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 40
Heronhill - for all your Toshiba requirements
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.22
RAV-364A8-PE
No
1
PARTS NAME
Compressor
TYPE
SPECIFICATIONS
ZR49KCE-TFD-230
Output (rated) 3.0kW, 2 pole, 380/415V, 3 Phase, 50Hz
Winding resistance 3.73 ½ at 20˚C
2
4.23
Outdoor unit fan motor
SMF-230-63N-3
Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz
SMF-230-39N-3
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
EEP2G405HQA114
AC 400V, 4µF
FC-2S
AC 230V, 50Hz
3
Running capacitor for
outdoor fan motor
4
Magnetic contactor
5
Pressure switch (2-Stage)
6
Crankcase heater
AC 240V, 28W
7
Fuse
T5A
8
Reverse Phase Protector
9
Bimetal thermostat
Tripping pressure 19kgf/cm2G, 21kgf/cm2G
Resetting pressure 13kgf/cm2G,15kgf/cm2G
STB-X602
STR-4AD
Tripping temperature: 135°C
CS-12A
Resetting temperature: 110°C
RAV-464A8-PE
No
1
PARTS NAME
Compressor
TYPE
SPECIFICATIONS
ZR61KCE-TFD-230
Output (rated) 3.75kW, 2 pole, 380/415V, 3 Phase, 50Hz
Winding resistance 2.19 ½ at 20˚C
2
Outdoor unit fan motor
SMF-230-63N-3
Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz
SMF-230-39N-3
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
EEP2G405HQA114
AC 400V, 4µF
FC-2S
AC 230V, 50Hz
3
Running capacitor for
outdoor fan motor
4
Magnetic contactor
5
Pressure switch (2-Stage)
6
Crankcase heater
AC 240V, 28W
7
Fuse
T5A
8
Reverse Phase Protector
9
Bimetal thermostat
Tripping pressure 19kgf/cm2G, 21kgf/cm2G
Resetting pressure 13kgf/cm2G,15kgf/cm2G
STB-X602
STR-4AD
Tripping temperature: 135°C
CS-12A
Resetting temperature: 110°C
40
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 41
Heronhill - for all your Toshiba requirements
5. REFRIGERANT PIPING DIAGRAMS
5.1 Indoor Unit
RAV-134C-PE
RAV-134TU-PE
Outdoor Unit
RAV-134A-PE
Indoor unit
Distributor strainer
& capillary tube
Heat exchanger
Strainer
TC Sensor
Refrigerant pipe (Larger side)
ø12.7mm (1/2")
Refrigerant pipe (Smaller side)
ø6.4mm (1/4")
Packed valve
Packed valve
Liquid tank
Capillary tube
Dryer
Heat exchanger
Distributor
Strainer
Compressor
Pressure switch
Accumulator
Outdoor unit
INDOOR UNIT
Capillary
Model
OUTDOOR UNIT
Main
Capillary
RAV-134C-PE
IDø2.0x300Lx2P
IDø2.0x200Lx2P
RAV-134A-PE
IDø2.6x400Lx1P
RAV-134TU-PE
IDø2.4x300Lx2P
Model
Bypass
Capillary
41
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 42
Heronhill - for all your Toshiba requirements
5. REFRIGERANT PIPING DIAGRAMS
5.2 Indoor Unit
RAV-164C-PE
RAV-164B-PE
RAV-164K-PE
RAV-164TU-PE
Outdoor Unit
RAV-164A-PE
Indoor unit
Distributor strainer
& capillary tube
Heat exchanger
Strainer
TC Sensor
Refrigerant pipe (Larger side)
ø12.7mm (1/2")
Refrigerant pipe (Smaller side)
ø6.4mm (1/4")
Packed valve
Packed valve
Liquid tank
Capillary tube
Dryer
Heat exchanger
Distributor
Strainer
Compressor
Pressure switch
Accumulator
Outdoor unit
INDOOR UNIT
Model
RAV-164C-PE
RAV-164B-PE
RAV-164K-PE
RAV-164TU-PE
Capillary
Model
IDø1.7x150Lx2P
IDø1.7x300Lx1P
IDø1.7x300Lx2P
IDø1.7x400Lx2P
IDø1.7x300Lx2P
IDø1.7x400Lx2P
IDø2.2x200Lx2P
RAV-164A-PE
OUTDOOR UNIT
Main
Bypass
Capillary
Capillary
IDø2.6x400Lx1P
42
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 43
Heronhill - for all your Toshiba requirements
5. REFRIGERANT PIPING DIAGRAMS
Outdoor Unit
RAV-264A-PE
RAV-264A8-PE
5.3 Indoor Unit
RAV-264B-PE
RAV-264C-PE
RAV-264K-PE
RAV-264U-PE
Indoor unit
Distributor strainer
& capillary tube
Heat exchanger
Strainer
TC Sensor
Refrigerant pipe (Larger side)
ø15.9mm (5/8")
Refrigerant pipe (Smaller side)
ø9.5mm (3/8")
Packed valve
Packed valve
Liquid tank
Capillary tube
Dryer
Heat exchanger
Distributor
Strainer
Compressor
Pressure switch
Accumulator
Outdoor unit
INDOOR UNIT
MODEL
RAV-264B-PE
RAV-264C-PE
RAV-264K-PE
RAV-264U-PE
OUTDOOR UNIT
CAPILLARY
MODEL
MAIN CAPILLARY
BYPASS CAPILLARY
IDø2.6x200Lx4P
IDø2.6x400Lx2P
IDø2.6x200Lx4P
IDø2.6x600Lx2P
IDø2.6x200Lx4P
IDø2.6x400Lx2P
IDø2.6x200Lx5P
IDø2.6x400Lx1P
RAV-264A/A8-PE
IDø2.6x300Lx1P
43
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 44
Heronhill - for all your Toshiba requirements
5. REFRIGERANT PIPING DIAGRAMS
Outdoor Unit
RAV-364A8-PE
5.4 Indoor Unit
RAV-364C-PE
RAV-364B-PE
RAV-364U-PE
Indoor unit
Distributor strainer
& capillary tube
Heat exchanger
Strainer
TC Sensor
Refrigerant pipe (Larger side)
ø19mm (3/4")
Refrigerant pipe (Smaller side)
ø9.5mm (3/8")
Packed valve
Packed valve
Liquid tank
Capillary tube
Dryer
Heat exchanger
Pressure switch
Distributor
Strainer
Compressor
Accumulator
Outdoor unit
INDOOR UNIT
MODEL
OUTDOOR UNIT
CAPILLARY
MODEL
RAV-364C-PE
IDø2.0x200Lx8P
RAV-364B-PE
IDø2.2x200Lx6P
IDø2.6x200Lx6P
RAV-364U-PE
RAV-364A8-PE
MAIN CAPILLARY
BYPASS CAPILLARY
IDø2.4x500Lx1P
IDø2.6x300Lx2P
IDø2.6x500Lx2P
44
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 45
Heronhill - for all your Toshiba requirements
5. REFRIGERANT PIPING DIAGRAMS
Outdoor unit
RAV-464A8-PE
5.5 Indoor unit
RAV-464C-PE
RAV-464B-PE
RAV-464U-PE
Indoor unit
Distributor strainer
& capillary tube
Heat exchanger
Strainer
TC Sensor
Refrigerant pipe (Larger side)
ø19mm (3/4")
Refrigerant pipe (Smaller side)
ø9.5mm (3/8")
Packed valve
Packed valve
Liquid tank
Capillary tube
Dryer
Heat exchanger
Distributor
Strainer
Compressor
Pressure switch
Accumulator
Outdoor unit
INDOOR UNIT
MODEL
CAPILLARY
RAV-464B-PE
IDø2.2x200Lx6P
RAV-464C-PE
IDø2.0x200Lx8P
IDø2.6x200Lx6P
RAV-464U-PE
OUTDOOR UNIT
MODEL
MAIN CAPILLARY
RAV-464A8-PE
IDø3.0x600Lx1P
BYPASS CAPILLARY
IDø2.6x300Lx2P
IDø2.6x500Lx2P
45
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 46
Heronhill - for all your Toshiba requirements
6. PERFORMANCE CHARACTERISTICS
6.1 Cooling capacity
Ambient Temp. (Dry Bulb) (°C)
Capacity Ratio (%)
(KW)
RAV-134A-PE
RAV-164A-PE
RAV-264A-PE
RAV-264A8-PE
2.88
3.60
5.68
8.00
10.00
3.06
3.82
6.04
8.50
10.63
3.24
4.05
6.39
9.00
11.25
3.42
4.28
6.75
9.50
11.88
3.60
4.50
7.10
10.00
12.50
3.78
4.73
7.46
10.50
13.13
3.96
4.95
7.81
11.00
13.75
4.14
5.18
8.17
11.50
14.38
4.32
5.40
8.52
12.00
15.00
RAV-364A8-PE
RAV-464A8-PE
Room Temp. (Wet Bulb) (°C)
46
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 47
Heronhill - for all your Toshiba requirements
6. PERFORMANCE CHARACTERISTICS
6.2 Cooling capacity
RAV-134A-PE
RAV-164A-PE
RAV-264A-PE
RAV-264A8-PE
Outdoor Unit Height H (m)
Cooling Capacity Ratio
H
L
INDOOR
UNIT
Piping Length (m)
6.3 Cooling capacity
RAV-364A8-PE
RAV-464A8-PE
Outdoor Unit Height H (m)
Cooling Capacity Ratio
Piping Length (m)
The broken line shows in case the piping length is 30m or less
47
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 48
Heronhill - for all your Toshiba requirements
6. PERFORMANCE CHARACTERISTICS
6.4 Piping Length/Additional Refrigerant Volume
!
The amount of refrigerant put into the outdoor unit at the factory is sufficient to fill up to 20m of
refrigerant pipework.
!
If the length of the refrigerant pipework is 20m or less, addition of refrigerant at the installation site
is unnecessary.
!
If the length of the pipework exceeds 20m, extra refrigerant must be added. Refer to the table
below for details of the extra amounts.
!
Overcharge or undercharge of refrigerant in the outdoor unit will cause malfunction of
the compressor.
The prescribed amount of the replenishment of the refrigerant is shown in the table below:
Additional amount of refrigerant to add at
installation site (kg)±50g
Less
than
25m
Less
than
30m
Less Less
than than
35m 40m
134A-PE
0.18
0.35
—
—
—
164A-PE
0.18
0.35
—
—
—
MODEL
(RAV-)
Less
than
20m
364A8-PE
Filled
at
0.18
Factory
0.18
464A8-PE
0.25
264A/A8-PE
!
Recharge amount if unit is reclaimed
(kg)±50g
Less Less
than than
45m 50m
Less
than
5m
Less Less
than than
20m 25m
Less
than
30m
Less
than
35m
Less
than
40m
Less
than
45m
Less
than
50m
—
0.79
1.05
1.23
1.4
—
—
—
—
—
0.94
1.2
1.38
1.55
—
—
—
—
0.35
—
—
—
—
1.64
1.9
2.08
2.25
—
—
—
—
0.35
0.53
0.7
0.88
1.05
2.44
2.7
2.88
3.05
3.23
3.4
3.58
3.75
0.5
0.75
1.0
1.25
1.5
3.13
3.5
3.75
4.0
4.25
4.5
4.75
5.0
ADD ONLY R407C REFRIGERANT TO THESE UNITS
48
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 49
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.1 Indoor Unit
RAV-164B-PE
RAV-264B-PE
Indoor Unit
RAV-164BH-PE
RAV-364B-PE
RAV-264BH-PE
RAV-464B-PE
RAV-364BH-PE
RAV-464BH-PE
214
218
216
204
208
203
215
209
211
205
206
212
207
210
202
213
201
217
Ref
No.
Part No.
201
43160394
202
43107215
Model
Ref
No.
Part No.
Description
Model
Connector-9P
All
208
43155096
MF Capacitor 5mF 400V
RAV-264/364B-PE
Sensor Holder
All
208
43155097
MF Capacitor 10mF 400V
RAV-464B-PE
All
209
43A58002
Transformer
All
210
43A60002
Terminal Block –ABC’
All
All
Description
43120149
Fan-Multi Blade
204
43A21009
Fan Motor SMF-230-60-4A
RAV-164B-PE
204
43121516
Fan Motor STF-200-100-4B
RAV-264B-PE
211
43A60001
Terminal Block – ‘123’
204
43121528
Fan Motor STF-200-120-4B
RAV-364B-PE
212
43A69005
PC Board
204
43121535
Fan Motor STF-200-140-4F
RAV-464B-PE
213
43A72004
Drain Pan Assembly
205
203
All
RAV-164B-PE
43A44031
Refrigeration Asm
RAV-164B-PE
213
43A72005
Drain Pan Assembly
RAV-264B-PE
205
43A44032
Refrigeration Asm
RAV-264B-PE
213
43191310
Drain Pan Assembly
RAV-364/464B-PE
205
43A44039
Refrigeration Asm
RAV-364B-PE
214
43125135
Bearing
RAV-464B-PE
205
43A44040
Refrigeration Asm
RAV-464B-PE
215
43A60009
Bushing
All
206
43050377
Sensor-Room Temp
All
216
43A88011
Owners Manual
All
207
43A50004
Sensor-H/Exchanger
All
217
43A70002
Drain Socket
208
43155080
MF Capacitor 4mF 400V
RAV-164B-PE
218
43125137
Coupling
All
RAV-464B-PE
49
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 50
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.2 Indoor Unit
Indoor Unit
RAV-134C-PE
RAV-134CH/CHR-PE
RAV-164C-PE
RAV-164CH/CHR-PE
RAV-264CH/CHR-PE
RAV-264C-PE
RAV-364CH/CHR-PE
RAV-364C-PE
RAV-464CH/CHR-PE
RAV-464C-PE
211
242
206
231
203
205
209
204
234
235
223
224
220
237
238
216
230
217 215
214
226
218
240
239
219
225
229
232
233
228
206
227
241
207
201
236
208
213
Ref
No.
201
202
203
204
205
206
207
208
209
209
209
209
210
211
212
213
214
214
215
215
215
215
216
217
218
218
218
218
219
219
220
220
221
222
223
Part No.
43107214
43107215
43107216
43107223
43107222
43107224
43109321
43109322
43109324
43109320
43109327
43109328
43109329
43119373
43119393
43119394
43120172
43120174
43A21013
43A21005
43A21007
43A21006
43125131
43125142
43125143
43125141
43125145
43125144
43126127
43126129
43126128
43126130
43A39004
43A39005
43A44037
222
Description
Hinge
Sensor Holder
Spring
Grille Shaft – Left
Grille Shaft – Right
Grille Support – Centre
Inlet Grille – Large
Inlet Grille – Small
Horizontal Grille
Horizontal Grille
Horizontal Grille
Horizontal Grille
Vertical Grille
Bolt Cover
Shaft Holder
Lever
Fan – Multi Blade
Fan – Multi Blade
Fan Motor
Fan Motor
Fan Motor
Fan Motor
Bearing
Coupling
Shaft SS
Shaft SS
Shaft SS
Shaft SS
Fan Case – Lower
Fan Case – Lower
Fan Case – Upper
Fan Case – Upper
Connect Bar
Connect Bar
Refrigeration Assembly
221
212
Ref
No.
223
223
223
223
224
224
224
224
225
226
226
226
226
227
228
229
230
231
232
233
234
235
236
237
238
239
240
241
241
241
241
242
242
242
242
Model
All
All
All
All
All
RAV-364/464C-PE
264/364/464C-PE
134/164/264/364C-PE
RAV-134/164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
All
All
All
All
134/164/264C-PE
364/464C-PE
RAV-134C-PE
RAV-164/264C-PE
RAV-364C-PE
RAV-464C-PE
164/264/364/464C-PE
164/264/364/464C-PE
RAV-164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
134/164/264C-PE
364/464C-PE
134/164/264C-PE
364/464C-PE
All
264/464C-PE
RAV-134C-PE
Part No.
43A44038
43A44054
43A44055
43A44056
43155101
43155138
43A55001
43155080
43A70007
43172121
43172119
43172122
43172123
43179107
43180284
43180283
43A88011
43A21008
43150148
43A50004
43102624
43102625
43117812
43A58002
43A60001
43A60002
43A69005
43A91001
43A91002
43A91003
43A91004
43A91005
43A91006
43A91007
43A91008
210
202
Description
Refrigeration Assembly
Refrigeration Assembly
Refrigeration Assembly
Refrigeration Assembly
MF Capacitor
MF Capacitor
MF Capacitor
MF Capacitor
Hose Assembly
Drain Pan Assembly
Drain Pan Assembly
Drain Pan Assembly
Drain Pan Assembly
Plug
Air Filter – Large
Air Filter – Small
Owners Manual
Geared Motor
Sensor – Room Temp.(TA)
Sensor – H/Exchanger (TC)
Side Panel Right Assmb.
Side Panel Left Assmb.
Plate H
Transformer
Terminal Block 123
Terminal Block ABC
PC Board
Under Panel
Under Panel
Under Panel
Under Panel
Upper Panel Asm
Upper Panel Asm
Upper Panel Asm
Upper Panel Asm
Model
RAV-164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
RAV-134C-PE
RAV-164/264C-PE
RAV-364C-PE
RAV-464C-PE
All
RAV-134/164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
All
134/164/264C-PE
264/364C-PE
All
All
All
All
All
All
All
All
All
All
RAV-134/164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
RAV-134/164C-PE
RAV-264C-PE
RAV-364C-PE
RAV-464C-PE
50
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 51
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.3 Indoor Unit
RAV164K-PE
RAV264K-PE
Indoor Unit
RAV-164K-PE
RAV-264K-PE
226
220
207
202
217
210
216
209
208
213
218
205
204
203
201
221
228
223
222
212
224
211
215
214
229
219
227
225
Ref
No.
201
201
202
203
204
204
205
207
208
209
210
210
211
211
212
213
213
214
Part No.
43A21016
43A21017
43A69005
43A58002
45155101
43A55002
43A60001
43A60002
43A50010
43A50009
43A44050
43A44051
43172112
43172114
43170182
43A09005
43A09006
43A09003
Description
Model
Fan – Motor
Fan – Motor
PC Board
Transformer
Capacitor
Capacitor
Terminal 123
Terminal ABC
Sensor – Room Temperature TA
Sensor – Heat Exchanger TC
Refrigeration ASM
Refrigeration ASM
Drain Pan
Drain Pan
Drain Hose
H-Grille
H-Grille
V-Grille
RAV-164K-PE
RAV-264K-PE
All
All
RAV-164K-PE
RAV-264K-PE
All
All
All
All
RAV-164K-PE
RAV-264K-PE
RAV-164K-PE
RAV-264K-PE
All
RAV-164K-PE
RAV-264K-PE
All
Ref
No.
215
216
217
217
218
219
220
221
222
223
224
225
226
226
227
228
228
229
Part No.
Description
43A39004
43022189
43120135
43120136
43A09004
43A80008
43A00001
43A00002
43A00003
43121533
43A19002
43107215
43122028
43122029
43119394
43A91050
43A91051
43A88011
Connection Bar
Bearing
Cross Flow Fan
Cross Flow Fan
Inlet Grille
Air Filter
Side Cabinet – Left
Side Cabinet – Right
Control Panel
Geared Motor
Sensor Holder, TA
Sensor Holder, TC
Fan Nose
Fan Nose
Lever
D Cabi – Assembly
D Cabi – Assembly
Owner’s Manual
Model
All
All
RAV-164K-PE
RAV-264K-PE
All
All
All
All
All
All
All
All
RAV-164K-PE
RAV-264K-PE
All
RAV-164K-PE
RAV-264K-PE
All
51
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 52
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.4 Indoor Unit
RAV-134TU-PE
RAV-164TU-PE
Indoor Unit
RAV-134TU-PE
RAV-164TU-PE
219
217
218
220
222
201
214
223
221
216
203
205
204
207
206
208
209
202
210
213
211
212
214
215
Ref
No.
201
202
203
204
205
206
207
208
209
210
211
212
213
213
214
215
216
217
218
219
220
221
222
223
Part No.
43A22001
43020288
43151217
43A70003
43020253
43071019
43070164
43A60002
43A60001
43A21014
43A50006
43A22002
43A44043
43A44044
43039240
43A72001
43A88011
43A69008
43155100
43A69005
43A58002
43A50004
43150118
43154141
214
Description
Casing Assembly
Fan
Float Switch
Pump Assembly
Bearing
Drain Connection
Drain Hose
Terminal ABC
Terminal 123
Fan Motor
Sensor Holder
Casing Outlet
Refrigeration Assembly
Refrigeration Assembly
Canoe Clip
Drain Pan
Owner’s Manual
Interface PC Board
Capacitor, Metal Film
PC Board
Transformer
Sensor - Heat Exchanger (TC)
Sensor - Room Temperature (TA)
Relay - LY2F-L
Model
All
All
All
All
All
All
All
All
All
All
All
All
RAV-134TU-PE
RAV-164TU-PE
All
All
All
All
All
All
All
All
All
All
52
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 53
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.5 Indoor Unit
RAV-164U-PE
Indoor Unit
RAV-264U-PE
RAV-164U-PE
RAV-264U-PE
201
222
206
205
203
202
204
218
219
207
215
221
216
212
208
211
209
213
217
220
214
223
Ref
No.
201
202
202
203
204
205
206
207
208
209
210
211
212
213
214
215
216
217
217
218
219
220
221
222
223
210
Part No.
43A70005
43A44033
43A44034
43A70006
43A51002
43A21018
43A11004
43A20001
43A72006
43A22003
43A19004
43A58002
43A69005
43A50007
43150118
43A60001
43A60002
43155100
43A55002
43097166
43A97002
43A72008
43107215
43A88011
43154141
Description
Model
Drain Hose Assembly
Refrigeration Assembly
Refrigeration Assembly
Drain Pump
Float Switch
Fan Motor
Rubber Insulation
Centrifugal Fan
Drain Pan Assembly
Bellmouth
Fan Guard
Transformer
PC Board
Sensor - Heat Exchanger (TC)
Sensor - Room Temp. (TA)
Terminal 123
Terminal ABC
MF Capacitor
MF Capacitor
Washer
Fan Washer
Plug
Sensor Holder
Owner’s Manual
Relay - LY2F-L
All
RAV-164U-PE
RAV-264U-PE
All
All
All
All
All
All
All
All
All
All
All
All
All
All
RAV-164U-PE
RAV-264U-PE
All
All
All
All
All
All
53
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 54
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.6 Indoor Unit
RAV-364U-PE
RAV-464U-PE
205
206
201
202
222
207
203
218
204
215
219
216
212
220
211
208
209
213
217
214
221
210
223
Ref
No.
201
202
202
203
204
205
206
207
208
209
210
211
212
213
214
215
216
217
217
218
219
220
221
222
223
Part No.
43A70005
43A44035
43A44036
43A70006
43A51002
43A21019
43A11005
43A20002
43A72007
43A22004
43A19005
43A58002
43A69005
43A50007
43150118
43A60001
43A60002
43155138
43155120
43097166
43A97002
43A72008
43107215
43A88011
43154141
Description
Model
Drain Hose Assembly
Refrigeration Assembly
Refrigeration Assembly
Drain Pump
Float Switch
Fan Motor
Rubber Insulation
Centrifugal Fan
Drain Pan Assembly
Bellmouth
Fan Guard
Transformer
PC Board
Sensor - Heat Exchanger
Sensor - Room Temp.
Terminal 123
Terminal ABC
MF Capacitor
MF Capacitor
Washer
Fan Washer
Plug
Sensor Holder
Owner’s Manual
Relay - LY2F-L
RAV-364/464U-PE
RAV-364U-PE
RAV-464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364U-PE
RAV-464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
RAV-364/464U-PE
All
54
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 55
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.7 Outdoor Unit
RAV-134A-PE
RAV-164A-PE
RAV-264A-PE
RAV-264A8-PE
28
32
19
12
10
8
30
11
1
18
7
26
9
3
2
15
31
20
24
5
6
4
16
23
25
21
22
17
14
13
27
Ref
No.
1
2
2
3
3
4
5
6
7
8
9
9
9
10
11
11
12
13
14
15
16
17
18
18
Part No.
43120156
43A21012
43A21011
43A43016
43A43017
43049132
43149212
43149198
43169584
43A49003
43A60003
43A60004
43A60005
43A60001
43152334
43152345
43A19001
43119368
43162027
43A63001
43148105
43A45001
43155115
43055379
Description
Model
Propellor Fan
All
Fan Motor
RAV-134/164A-PE
Fan Motor
RAV-264A/A8-PE
Condensor
RAV-134/164A-PE
Condensor
RAV-264/A/A8-PE
Base Spring, B
All
Base Spring, A
All
Spring Buffer
All
Surge Absorber
All
Pressure Switch (2 stage)
All
Terminal Block, 2P
RAV-134/164A-PE
Terminal Block, 2P
RAV-264A-PE
Terminal Block, 4P
RAV-264A8-PE
Terminal Block, 4P
All
Magnetic Contactor
RAV-134/164/264A-PE
Magnetic Contactor
RAV-264A8-PE
Fan Guard
All
Hanger
All
Cover, Electrical Parts
All
Cord Clamp
All
Accumulator
Dryer
All
MF Capacitor – Compressor
RAV-134/164A-PE
RAV-264A-PE
MF Capacitor – Compressor
Ref
No.
19
20
20
20
20
21
21
22
22
23
24
25
26
27
27
28
29
29
30
30
31
31
32
29
Part No.
Description
Model
43155080
43A41506
43A41507
43A41508
43A41509
43146406
43146415
43A46013
43146417
43193063
43157167
43050277
43A60006
43A47041
43A47040
43A91016
43A91019
43A91022
43A91017
43A91018
43A91023
43A11036
43154148
MF Capacitor – Fan
Comp – PG330X3F-4LS
Comp – PG350X3F-4LS
Comp – PG460X3F-4MS
Comp – YG460X3F-MS
Packed Valve (12.7mm)
Packed Valve (15.9mm)
Packed Valve (6.35mm)
Packed Valve (9.5mm)
Spring
Heater, Crankcase
Thermostat, Bi-metal (comp)
Fuse T5A
Capi Form
Capi Form
ASM Roof Plate
ASM Side Cabinet
ASM Side Cabinet
ASM Air-Out Cabinet
ASM Air-Out Cabinet
Fin-Guard (back)
Fin-Guard (back)
Reverse Phase Protector
All
RAV-134A-PE
RAV-164A-PE
RAV-264A-PE
RAV-264A8-PE
RAV-134/164A-PE
RAV-264A/A8-PE
RAV-134/164A-PE
RAV-264A/A8-PE
All
All
RAV-264A8-PE
All
RAV-134/164A-PE
RAV-264A/A8-PE
All
RAV-134/164A-PE
RAV-264A/A8-PE
RAV-134/164A-PE
RAV-264A/A8-PE
RAV-134/164A-PE
RAV-264A/A8-PE
RAV-264A8-PE
55
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 56
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.8 Outdoor Unit
RAV-364A8-PE
RAV-464A8-PE
RAV-464A8-PE
32
27
4
31
6
3
25
16
21
1
20
17
28
18
19
26
22
13
8
29
2
15
7
9
23
30
5
11
24
12
10
14
Ref
No.
1
2
3
4
5
5
6
6
7
8
9
9
10
11
12
13
14
14
15
16
Part No.
43A21011
43A21012
43120156
43A19001
43A43012
43A43014
43A43013
43A43015
43119368
43162027
43A41503
43A41502
43A42001
43146415
43146416
43147321
43A45001
43A45002
43148096
43155080
Description
Fan Motor AC230V, 50Hz 63W
Fan Motor AC230V, 50Hz 39W
Propeller Fan
Fan Guard
Condenser Lower
Condenser Lower
Condenser Upper
Condenser Upper
Hanger, Plastic
Cover, Electrical Parts
Compressor, ZR61KCE-TFD-230
Compressor,ZR49KCE-TFD-230
Compressor Boot
Packed Valve, (3/8”)
Packed Valve, (3/4”)
Check Joint
Dryer, XH10
Dryer, XH10
Accumulator, 1.6Ltr
Capacitor, Plastic Film, 4.0mF, 400V
Ref
No.
17
18
19
20
21
22
23
24
24
25
26
27
28
28
29
30
30
31
32
Model
All
All
All
All
RAV-464A8-PE
RAV-364A8-PE
RAV-464A8-PE
RAV-364A8-PE
All
All
RAV-464A8-PE
RAV-364A8-PE
All
All
All
All
RAV-364A8-PE
RAV-464A8-PE
All
All
Part No.
43060479
43A60005
43A60001
43A53004
43169584
43A49002
43157167
43A47038
43A47039
43154148
43A60006
43A91027
43A91037
43A91029
43A91028
43A91036
43A91031
43A91030
43150112
Description
Terminal Block, 4P
Terminal, 4P
Terminal, 4P
Magnetic Contactor, FC-2S
Surge Protector
Pressure Switch (2 Stage)
Crankcase Heater, AC240V, 28W
Capillary Assembly
Capillary Assembly
Reverse Phase Protector, STR-4AD
Fuse T5A
ASM Roof Plate
ASM Side Cabi
ASM Side Cabi
Air Out Cabi
Fin Guard – Back
Fin Guard – Back
Fin Guard – Side
Bimetal – Thermo
Model
All
All
All
All
All
All
All
RAV-464A8-PE
RAV-364A8-PE
All
All
All
RAV-464A8-PE
RAV-364A8-PE
All
RAV-464A8-PE
RAV-364A8-PE
All
All
56
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 57
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.9 Ceiling Panel
RBC-U133PG(W)-PE
Ceiling Panel
RBC-U133PG(W)-PE
10
8
7
5
9
10
2
6
7
1
3
4
Ref
No.
1
2
3
4
5
Part No.
43080392
43007108
43009504
43007107
43007109
Ref
No.
6
7
8
9
10
Description
Filter
Plate connect (long)
ASM-Grille-Out
Bushing
Plate connect (short)
Part No.
43009503
43007124
43009499
43A26001
43007125
Description
Grille-L-R
Support plate
ASM-Grille-Out
ASM-Motor
Support plate
57
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 58
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.10 Ceiling Panel
RBC-U264PG(W)-E
Ceiling Panel
RBC-U264PG(W)-E
11
12
13
4
7
12
1
6
2
15
9
Ref
No.
1
2
4
5
6
7
9
11
12
13
14
15
Part No.
43400658
43407072
43407085
43407091
43107249
43409110
43A09009
43411007
43411008
43411009
43121671
41480545
14
5
Description
Panel
Grille Catch
Joint Kit
Cam
Motor Kit Assembly
Louver-(Small)
Grille – Air Inlet
Cushion Air Outlet B
Cushion Air Outlet C
Cushion Air Outlet D
Geared Motor
Air Filter
58
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 59
Heronhill - for all your Toshiba requirements
7. EXPLODED VIEWS AND PARTS LISTS
7.11 Ceiling Panel
RBC-U464PG(W)-E
11
10
7
13
4
8
10
1
6
2
9
5
15
14
3
Ref
No.
1
2
3
4
5
6
7
8
9
10
11
13
14
15
Part No.
43400662
43407072
43407076
43407085
43402091
43107249
43409110
43409114
43A09010
43411006
43411007
43411009
43121671
41480546
Description
Panel
Grille Catch
Grille, Louvre M
Joint Kit
Cam
Motor Kit Assembly
Louver – (Small)
Louver – (Large)
Grille Air Inlet
Cushion Air Outlet A
Cushion Air Outlet B
Cushion Air Outlet D
Geared Motor
Air Filter
59
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
K6436 Cooling only Manual
30/7/99 2:03 pm
Page 60
Heronhill - for all your Toshiba requirements
TOSHIBA
AIR CONDITIONING
PORSHAM CLOSE, BELLIVER INDUSTRIAL ESTATE, PLYMOUTH PL6 7DB UK
A division of Toshiba Carrier UK Ltd
Tel: 01823 665660
www.heronhill.co.uk
Fax: 01823 665807
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising