gtc800603 rev 9-2015
GAI -TRONICS®
A Hubbell Company
Centra Page/Party
®
Market
Application
Product
Dependable
Dependable paging and party line
communications for rugged and
hazardous offshore platforms and rigs.
Centra Page/Party® Products
GAI-Tronics’ Centra Page/Party® system provides dependable paging and
party line communications for rugged and hazardous industrial facilities.
Centra Page features centrally-located electronics which provide
environmental protection, and unitized amplification for easy
maintenance. Standard Centra Page cabinets can support up to 30
handset stations and in most cases up to 60 paging speakers.
Alarms and telephone interfacing can also be added to Centra Page.
Basic Operation:
Basic system operation is simple: an individual lifts a station handset,
locates an available party line, depresses the handset pressbar and
announces a page, and releases the pressbar. The paged individual
goes to an available station, turns the party line selector switch to the
proper party line, lifts the handset and answers the page. Telephone
type, duplex communication can then be held on the party line without
broadcasting over speakers.
The primary component of a Centra Page system is the card rack. This
unit houses the individual line cards (Part # 69037-101), which
corresponds to specific handset stations and speakers in the system.
The card rack contains termination points for power and the alarm /
tone generator and telephone interface connections. Each card rack
accommodates up to ten line cards.
All stations are homerun wired to the
central cabinet, where station status is
monitored. To maximize flexibility,
stations are available in Desktop,
Desk-Edge, Weatherproof, Indoor,
Flush-mount, and Jack Stations when
used with headset configurations.
The 10961-101 AMI Centra Page Interface contains a priority alarm test
and telephone interface panel, allowing the customer access to the public
telephone network. The AMI I/O Controller Board is mounted onto the
panel with a terminal block. The interface connects the alarm, page and
party audio between the Audio Messenger and Centra-Page System.
The 10959-208 Audio Messenger Interface provides the capability
to generate emergency tone alarms, prerecorded voice message and
automated normal operations announcements over the Centra Page
System. A Smart Media® memory card stores the configuration
programming, the voice and tone recordings. Five standard alarms
are factory installed.
Specifications
Central Cabinet
Construction: Wall mounted, 16-gauge cold rolled steel with
polyurethane enamel finish
Dimensions . . . . . . . . . . . . . 20.625” W X 18.5” D x 31” H
(523.9mm x 469.9 mm x 787.4 mm)
Connections: All connections are made to terminal blocks
located on wall-mounted rear section
Contents: Up to three card racks with up to ten line cards,
AMI Centra Page Interface, Rackmount Audio
Messenger Interface
Weight: 165 lbs. (74.8 kg) approx.
Power Requirements: 22-28 VDC negative ground
35A maximum; 3A idle
Audio Messenger Interface: Five tones, internally selected
priority, Alarm muting available when voice page initiated,
Alarm test switches
Tones: The following tones are factory-set: Yelp, Warble,
Siren, Pulse, and Steady. Additional tones are customer
configurable using AMI’s ACT Software.
Telephone Interface: Standard modular plug/jack to ordinary telephone line (48 VDC, 20 Hz bridged ringing), “In Use”
indicator on front panel , Signal on page line indicates
incoming calls 1300 and 1600 Hz tones toggled at 20 Hz
Inputs / Outputs: Can support the addition of 29 inputs
and 29 outputs.
Line Cards
- Handset Amplifier
- Speaker Amplifier portion delivers to 16 W to 8 ohm
or 70.7 v line
- Short circuit current limited
- Five indicator lights:
. . . . . . . . . . . .• Power to handset
• Off-hook
• Page Activated
• Power to Speaker
• Signal Intensity
Typical Diagram
The Central Cabinet must be
located in a non-hazardous
area. Stations and speaker
may be then located in both
hazardous and non-hazardous
locations, depending on the
method used to install wiring.
Reference Manual:
42004-356A
Ordering Information
Part Number
Description
Cabinet Components
10468-002 . . . . . . . . . . . . . . Central Cabinet
10461-002 . . . . . . . . . . . . . . 19" P.C. Card Rack
69037-101 . . . . . . . . . . . . . . Station Line Card
69460-001 . . . . . . . . . . . . . . Crews’ Quarters Muting Card
10961-101 . . . . . . . . . . . . . . AMI Central-Page Interface
10959-208 . . . . . . . . . . . . . . Rack-Mount Audio Messenger Interface
14736-242 . . . . . . . . . . . . . . Blank Panel 19” x 10.5”
Safety Barrier / Stations / Headsets
10439-102 . . . . . . . . . . . . . . Safety Barrier
472-002 . . . . . . . . . . . . . . . . Indoor Handset Station
473-002 . . . . . . . . . . . . . . . . Outdoor Weatherproof Handset Station
475-002 . . . . . . . . . . . . . . . . Indoor Handset / Headset Jack Station
475-004 . . . . . . . . . . . . . . . . Weatherproof Handset / Headset Jack Station
476-002 . . . . . . . . . . . . . . . . Flush Mount Handset Station
478-002 . . . . . . . . . . . . . . . . Desk Top Handset Station with Speaker
10453-501 . . . . . . . . . . . . . . Headset Microphone Assembly
10410-002 . . . . . . . . . . . . . . 30’ Headset Assembly Ext. Cable
10450-302 . . . . . . . . . . . . . . Handset Assembly
System / Speaker Cable
60051-001 . . . . . . . . . . . . . . 6 Conductor System Cable - PVC Jacket
60051-003 . . . . . . . . . . . . . . 6 Conductor System Cable - Bronze Braid / PVC Jacket
60028-101 . . . . . . . . . . . . . . 3 Conductor Speaker Cable - PVC Jacket
60028-003 . . . . . . . . . . . . . . 3 Conductor System Cable - Bronze Braid / PVC Jacket
Horns / Drivers
13309-001 . . . . . . . . . . . . . . Horn Non-Metallic Weatherproof
13309-001SB . . . . . . . . . . . Horn Non-Metallic Weatherproof with Stainless Steel Bracket
13340 . . . . . . . . . . . . . . . . . . Horn Non-Metallic Weatherproof
12526-001 . . . . . . . . . . . . . . Stainless Steel Mounting Bracket
13314-003 . . . . . . . . . . . . . . Speaker Driver Division II, 70V Weatherproof
13310-203 . . . . . . . . . . . . . . Speaker Driver Division I, 70V
13351 . . . . . . . . . . . . . . . . . . Wall Speaker 70V Non-Classified, Weatherproof
B406T-70W . . . . . . . . . . . . . Indoor Wall Speaker without Volume Control (with Transformer)
B650T-70 . . . . . . . . . . . . . . . Indoor Ceiling Speaker without Volume Control (with Transformer)
12506-001 . . . . . . . . . . . . . . Volume Control Kit
Recognized by
Minerals Management Service
Loud and Clear for Sixty Years.
Pub. 800603 Rev. 9-2015
GAI-Tronics® USA (Corporate) Toll Free: 1 (800) 492-1212 Tel: (610) 777-1374 Fax: (610) 796-5954 www.gai-tronics.com
GAI-Tronics® UK Tel: +44 (0)1283 500500 Fax: +44 (0)1283 500400 www.gai-tronics.co.uk
GAI-Tronics® S.r.l - Italy Tel: +39 02 48601460 Fax: +39 02 93663110 www.gai-tronics.it
GAI-Tronics® Malaysia Tel: +60-3-8945-4035 / 8945-7348 Fax: +60-3-8945-4675 www.gai-tronics.com
GAI-Tronics® Austdac - Australia Tel: 011-61-28-851-5000 Fax: 011-61-29-899-2490 www.austdac.com.au
Quality Management System Certified by DNV-GL - ISO 9001:2008
The policy of GAI-Tronics is one of continuous improvement; therefore the company reserves the right to change specifications without notice.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement