121msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: November 11, 2004
DATE OF ISSUE: December 29, 2004
I - Product Identification
Hot Wax Concentrate
PRODUCT CODE: 0121
CHEMICAL FORMULATION: Water based protective coating.
NFPA HAZARD IDENTIFICATION SYSTEM:
HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 1
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
2-Butoxyethanol
Strait run middle distillate
Isopropanol
Key:
Values reported as TWA unless noted.
APPROX
OSHA
ACGIH
EPA 40 CFR:
%
PEL
TLV
302
355
372
1.00-5.00
25 ppm (skin)
25 ppm (skin)
N
N
Y
15.0-25.0
400 ppm
400 ppm
N
N
N
1.00-3.00
400 ppm
400 ppm
N
N
N
CAS #
111-76-2
64742-46-7
67-63-0
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value
C: Ceiling level
STEL: Short Term Exposure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (°F): N/D
SPECIFIC GRAVITY (WATER = 1): 0.96
VAPOR PRESSURE (mm Hg): N/D
VOC CONTENT (% by weight): N/D
VAPOR DENSITY (AIR = 1): N/D
EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Soluble
pH: 6.5 – 7.5
APPEARANCE AND ODOR: Clear, amber liquid, slight solvent odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): > 200
(TEST METHOD): Closed cup.
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/D
LOWER: N/D
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Fire fighters must use full protective gear including self-contained breathing apparatus. Use
water spray to cool fire-exposed containers.
UNUSUAL FIRE AND EXPLOSION HAZARD: None.
PRODUCT NAME: Hot Wax Concentrate
PRODUCT CODE: 0121
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizing agents.
CONDITIONS TO AVOID: None.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION: X
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate to severe irritation and corneal injury.
IF ON SKIN: Mild to moderate irritation with prolonged or repeated exposure.
IF SWALLOWED: Gastrointestinal irritation, nausea, diarrhea. Aspiration may be a hazard.
IF INHALED: Respiratory tract irritation, dizziness, headache.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Obtain medical attention.
IF ON SKIN: Wash thoroughly with soap and water. Remove contaminated clothing and launder separately before reuse. If irritation
persists, obtain medical attention.
IF SWALLOWED: Call physician or poison control center immediately. Rinse mouth with water. Give affected person 1 to 2 glasses of
water. Do not induce vomiting unless told to do so by a poison control center or physician. Never give anything by mouth to an
unconscious person.
IF INHALED: Remove person to fresh air. Perform artificial respiration if breathing has stopped. Obtain medical attention, if irritation
persists.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and remove all sources of ignition. Soak up spilled
material with inert absorbent material and place in a closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH approved
respirator, following manufacturer’s recommendations.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or goggles.
OTHER PROTECTIVE EQUIPMENT: Eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat or open flame. Keep
container tightly closed when not in use. Wash thoroughly after use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: None
DOT CLASS: None
DOT ID NUMBER: None
DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is
further intended, different shipping names and labeling may apply.
REVISION DATE: November 11, 2004
Prepared by: PMR
DATE OF ISSUE: December 29, 2004
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or
the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or third
parties caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement