MB QUART SS750.1 Technical information

MB QUART SS750.1 Technical information
Hubbell Marine Products
www.hubbell-marine.com
Marine Products
New Marine Products
30A LED Cable Sets. . . . page 7
50A LED Cable Sets. . . page 14
30 amp and 50 amp Cable Sets with High Intensity LED Indicator Lights
Hubbell now offers 30 amp and 50 amp cable sets with LED indicator lights,
in both Yellow and White. The 30 amp cable sets have a bright, durable,
green LED that indicates power is on. The high-intensity green LED is visible
- even in bright sunlight, and is enclosed in Hubbell's fully-molded design
for superior waterproofing and exceptional durability. The 50 amp cable sets
are available with TWO high-intensity LEDs. The bright green LED indicates
“power-on” as in our 30 amp cable sets while the red LED, when lit, indicates
there is an incorrect wiring condition at the power source that requires
immediate attention. Now, you can have the very latest in (50 amp) marine
cable set technology - from Hubbell - the quality leader in Marine Electrical
Shore Power Products.
100 amp 3-phase 277/480 Volt Pin and Sleeve Offering
Hubbell has added a line of 4 Pole, 5 Wire 100 amp 277/480 volt Pin and
Sleeve ship-to-shore devices. Made of yellow Zytel® super tough nylon, the
UV-stabilized, high-visibility housings provide increased safety and abuseresistance and are fully watertight when properly installed and mated providing years of reliable service.
100A 480V Pin and Sleeve . . . .
. . . . . . . . . . . . . . pages 18 & 19
YQ100PLUS Adapter
Hubbell Marine’s newly redesigned 100 amp “intelligent” adapter can now
ely power a boat’s 100 amp 125/250 volt AC shore power cable set from
o 50 amp 125/250 volt AC receptacles at dockside, achieving 100 amp
0 volts - OR - from a single 50 amp 125/250 volt AC receptacle, acting as
ngle adapter , and achieving 50 amp 125/250 volts, when only one such
let is available. We have also managed to build all of this latest technology
o a much smaller, NEMA 4X watertight enclosure with LED indicator lights
t check for polarity and proper wiring conditions. The newly redesigned,
aller YQ100PLUS allows for safe power from dual 50 amp 125/250 volt
eptacles or a single 50 amp 125/250 volt receptacle - another first from
bbell - the quality leader in Marine Electrical Shore Power Products.
New Marine Products
Y
TV-Only Ship-to-Shore Inlet
Hubbell now offers a TV-Only ship-to-shore inlet for boats that no longer
require the telephone connection. With the rising use of cell phones, etc.
Hubbell now makes an inlet with only the TV connection, allowing the boat
manufacturer to eliminate the cost of the internal phone wiring infrastructure
that is often times no longer needed. The TV-Only inlet is available in
traditional stainless steel styling to match the stainless steel shore power
inlets on board.
HBLTVSS . . . . . . . . . . . page 28
Zytel® is a registered trademark of E.I. DuPont.
ii
www.hubbell-wiring.com
Marine Products
New Marine Products
200 amp 600 volt AC Pin and Sleeve Ship-to-Shore Devices
Another Hubbell Marine first- Hubbell Marine is proud to offer the ONLY 200
amp rated, marinized, UL Listed 200 amp ship-to-shore system. As the size
of the mega-yachts continue to grow, along with the ever-increasing demand
for more power on board, Hubbell Marine continues to keep pace by offering
a full line of 200 amp fittings, back boxes and accessories that are NEMA 4X
rated for superior water resistance and is fully interchangeable with UL1686
configured and listed devices as Crouse-Hinds® Arktite® or Appleton®
Powertite® systems when installed in accordance with instructions
furnished with each device.
200A Pin and Sleeve Ship-toShore . . . . . . . . . pages 20 & 21
Tamper Resistant and Weather Resistant Duplex Receptacles
TR and WR/TR Rated
Hubbell Marine now offers a wide variety of receptacles and switches for
indoor and outdoor applications. Available in Style Line® Decorator-type
and standard duplex type, these new receptacles comply with new tamperresistant (TR) requirements and with new weather and tamper-resistant
requirements (WR & TR) as defined by the 2008 National Electrical Code
Article 406.8 - for use in damp and wet locations. See page iv for additional
technical information.
Hubbell now offers the ability to put 2 or 3 Communication Devices
in a single, Style Line® plate
Any combination of phone (6-position jack), cable TV (F-type connector) and
Category 5e modular data jacks can be assembled onto a 2-port or 3-port
frame—each sold individually so you can customize them as needed. Or the
highly popular phone and cable TV combination is available with the frame
and matching wallplate under a single catalog number, in all the popular
colors. Finally—a single communications plate that can take the place of
2 or 3 plates—available from a company you can trust for superior quality.
Hubbell’s Marine communication frames and connectors deliver high quality
data and multimedia transmission to the point of connection. Hubbell’s
2 and 3-port Style Line® frames and leading edge connections allow for
customized configurations. Install Hubbell’s Marine communication
offering and be assured a reliable connection.
TR and WR/TR Receptacles . .
. . . . . . . . . . . . . . . . . . . page 38
Communication Devices . . . . .
. . . . . . . . . . . . . . . . . . . page 41
While-In-Use Weatherproof
Covers . . . . . . . . . . . . . page 42
www.hubbell-wiring.com
iii
New Marine Products
Marine Grade Outlet Box While-In-Use Weatherproof Covers
Hubbell Marine now offers in-use marine grade outlet box covers that
can accommodate Duplex, GFCI, Toggle Switch and Single Receptacles.
These outlet box covers can be mounted horizontally or vertically and
are made of a rugged, gray polycarbonate compound. UL listed and
NEMA 3R rated, these covers meet the new National Electrical Code
requirements for while-in-use outdoor power distribution and provide
maximum in-use protection.
Marine Products
Marine Products
2008 NEC Receptacle Code Compliance and General Information
New
Tamper-Resistant
Duplex Receptacles
New
Weather-Resistant
Duplex Receptacles
Comply with NEC 406.11
Comply with NEC 210.52
Comply with NEC 406.8(A)
All 125V, 15A and 20A
receptacles shall be
listed tamper-resistant
receptacles per NEC
Article 406.11, “TamperResistant Receptacles
in Dwelling Units”.
All 125V and 250V,
15A and 20A receptacles
shall be listed as
weather resistant type
per NEC Article 406.8,
“Receptacles in Damp
and Wet Locations”.
Ta
Weather Resistant
These symbols appear in this catalog for easy identification.
Weather-Resistant (WR)
Tamper-Resistant (TR)
receptacles incorporate
internal mechanisms to limit
access to energized internal
components.
Interior
This new TR requirement
is mandatory for use in
dwelling unit outlets.
There are also many other
applications where the
use of TR receptacles can
provide an additional level
of electrical safety.
receptacles installed
outdoors and in other
wet and damp locations
are subject to more
demanding temperature
variations, direct sunlight
and unusual mechanical
abuse than those in a
typical dry environment.
Hubbell’s WR receptacles
are designed to withstand
these environments and
conditions.
Washdown Areas
Marinas/Docks
Exterior
Industrial and Commercial Wiring Devices and Systems
Residential Products
Kellems Wire Management Products
Marine Products
IS
2008 NEC Receptacle Code Compliance & General Information
What Do These Code Requirements Mean?
O
90 01 : 2001
RoHS
National Electrical
Manufacturers Association
NEMA promotes the
competitiveness of its
member companies by
providing a forum for the
development of technical
standards that are in the best
interests of the industry and
the users of its products.
iv
National Association of
Electrical Distributors
Since 1908, NAED has served
as the trade association for
the electrical distribution
industry.
To be an NAED associate
member, your company must
be a manufacturer or valueadded reseller.
Restriction of
Hazardous Substances
The RoHS Directive stands for
“the restriction of the use of
certain hazardous substances
in electrical and electronic
equipment”.
www.hubbell-wiring.com
International Organization
for Standardization
ISO (International Organization
for Standardization) is the
world’s largest developer
and publisher of International
Standards.
Dimensions in Inches (mm)
Marine Products
30 Amp Cable Set
50 Amp Cable Set
100 Amp Cable Sets
and Devices
Twist-Lock® Devices
Table of Contents
Marine Products
Marine Products
Ship-to-Shore Selection Chart - Boatside
30A
125V AC
2 Pole
3 Wire
Pages 5-9
HBL303NM
HBL303SSBL
HBL303SS
HBL26CM13
HBL60CM33
HBL60CM33W
HBL503NM
HBL503RI
HBL503SS
HBL63CM60
HBL77CM15
HBL77CM15W
HBL504NM
HBL504RI
HBL504SS
HBL63CM64
HBL77CM15
HBL77CM15W
50A
125V AC
2 Pole
3 Wire
Pages 10-11, 14
50A
125/250V AC
3 Pole
4 Wire
Pages 12-14
100A
125/250V AC
3 Pole
4 Wire
Ship-to-Shore Selection Chart - Boatside
Pages 15-17
M4100B12R
M4100C12R
100A
3ØY
4 Pole
5 Wire
Pages 15, 18-19
120/208V AC
277/480V AC
M5100B9R
M5100B7R
M5100C9R
M5100C7R
200A
600V AC/250V DC
4 Pole
5 Wire
Pages 20-21
M5200BS1R
M5200CS1R
Portable
Telephone
Cable
TV
Pages 26-27
2
HBLPHTVNM
HBLPHTVRI
HBLPHTVSS
www.hubbell-wiring.com
HBLTVSS
PH6624
PH7440
Dimensions in Inches (mm)
Marine Products
Marine Products
Ship-to-Shore Selection Chart - Dockside
YC310250 - 280' (85.3m) Yellow cable only.
WC310280 - 280' (85.3m) White cable only.
HBL61CM08 & HBL61CM
HBL61CM08LED
HBL61CM05 & HBL61CM05LED
HBL61CM03 & HBL61CM03LED
HBL61CM08W & HBL61CM08WLED
HBL61CM03W & HBL61CM03WLED
-
50' (15.2m)
35' (10.7m)
25' (7.6m)
50' (15.2m)
25' (7.6m)
HBL60CM31
HBL60CM31W
HBL26CM11
HBL26CM10
HBL74CM25WOA
HBL74CM25WOAW
HBL63CM61
HBL63CM70
HBL77CM74WO
HBL63CM65
HBL63CM69
HBL77CM74WO
YC306250 - 250' (76.2m) Yellow cable only.
HBL61CM53 & HBL61CM53LED
- 50' (15.2m)
HBL61CM53W & HBL61CM53WLED - 50' (15.2m)
HBL61CM43 & HBL61CM43LED
- 25' (7.6m)
HBL77CM16
HBL77CM16W
YC406250 - 250' (76.2m) Yellow cable only.
HBL61CM52 & HBL61CM52LED
HBL61CM42 & HBL61CM42LED
HBL61CM52W & HBL61CM52WLED
HBL61CM42W & HBL61CM42WLED
-
50' (15.2m)
25' (7.6m)
50' (15.2m)
25' (7.6m)
CS1004
CS754
CS100IT4
CS754IT4
-
100' (30.4m) 4-Wire
75' (22.8m) 4-Wire
100' (30.4m) 3-Wire
75' (22.8m) 3-Wire
CW125IT4
CW100IT4
CW754
CS50EXT4
-
HBL77CM16
HBL77CM16W
125' (38.0m) One-ended cable set for winches.
100' (30.4m) One-ended cable set for winches.
75' (22.8m) One-ended cable set for winches.
50' (15.2m) Extension cord.
M4100P12
M4100C12
M4100R12
M5100P9
M5100P7
M5100C9
M5100C7
M5100R9
M5100R7
M5200PS1
M5200CS1
CS100IT5 - 100' (30.4m) 4-Wire
CS75IT5 - 75' (22.8m) 4-Wire
PH6630
PH6599
PH6598
PH6599W
PH6598W
-
M5200RS1
250' (76.2m) Yellow cable only.
50' (15.2m)
25' (7.6m)
50' (15.2m)
25' (7.6m)
75 Oh
Ohm TV Cable.
9 - 50' (15.2m)
- 25' (7.6m)
9W - 50' (15.2m)
8W - 25' (7.6m)
PH7440
Dimensions in Inches (mm)
www.hubbell-wiring.com
PH6625
TV97
PH6597TV
PH6597
3
Ship-to-Shore Selection Chart - Dockside
CW125IT5 - 125' (38.0m) One-ended cable set for winches.
CW100IT5 - 100' (30.4m) One-ended cable set for winches.
CS50EXT5 - 50' (15.2m) Extension cord.
Marine Products
Marine Products
30 Ampere, 125 Volt Cable Set
Features and Benefits
UL Listed.
Available in 25, 35 and 50 foot lengths.
Jute fillers inside jacket for maximum cable flexibility.
Hubbell cable coils neater, lighter, lays flatter.
Molded flexneck adds life to cable set by helping
to prevent right-angle cable damage and pullout.
Strain relief bull ring protects against stress and strain
on the conductors caused by boat movement,
crew traffic and rough handling.
Molded design totally encased in
solid PVC material, for superior
waterproofing and durability.
30 Ampere, 125 Volt Cable Set - Features and Benefits
Exclusive copper crimp barrel termination
provides protection against internal
overheating and burnout compared to
brass crimps. These copper crimps are
the same type used by power companies.
The result: tighter connections, better
conductivity and longer life.
Locking ring assures proper alignment of connector
to inlet for complete contact and waterproofing.
Prevents accidental disengagement.
Line-up notches to indicate:
Locked - Unlocked.
Arrow indicating lock position.
Arrow with ground symbol allows
lining up with ground of receptacle.
New improved styling.
Arrow indicating unlock position.
Note: Cable sets must be fully extended before using.
4
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
30 Ampere, 125 Volt Twist-Lock® Devices
2 Pole 3 Wire
Ship-to-Shore Devices
W
IP56
SUITABILITY
G
Inlets Only.
30A 125V
NEMA L5-30R
UL/CSA
30A 125V Ship-to-Shore Devices
30A 125V Traditional Stainless Steel Inlets
Catalog Numbers
HBL303NM
HBL303NM
HBL303SSBL Δ
HBL303SS
HBL303SSBL
HBLCBISS
HBLCBINM
SR3050**
HBL303INT
HBL60CM75
HBL303SS
HBL303SSO
HBLCBINM
HBL303SSO
Mounting holes are
26 in. (60.3) on center.
Dimensions in Inches (mm)
www.hubbell-wiring.com
5
30 Ampere, 125 Volt Twist-Lock® Devices
Description
Stylized UV resistant non-metallic shore power inlet has white
Centrex cover which makes unit weatherproof when completely
closed. Interior has easy-to-wire terminations and is transparent for
quick and easy visual inspection. Mounting holes are 2.38 in. (60.3) on
centers and match existing mounting patterns. Mounting screws and
gasket included. Protective rear enclosure/strain relief also included.
Stylized type 316 stainless steel shore power inlet has easy to use
push-button latch that makes unit watertight when fully engaged.
Interior has easy-to-wire terminations and is transparent for quick
and easy visual inspection. Mounting holes are 2.38 in. (60.3) on centers
and match existing mounting patterns. Mounting screws and gasket
included. Protective rear enclosure/strain relief also included.
Traditional, stainless steel shore power inlet has new easy-to-wire
terminations. Interior is transparent for quick and easy visual inspection.
Interior is shielded from the elements by a gasketed, self-closing cover,
watertight when cover is screwed in place. Mounting holes are 2.38 in.
(60.3) on centers. Mounting screws and gasket included. Protective
rear enclosure/strain relief also included.
Traditional stainless steel inlet housing; blank for attaching a circuit breaker
(not included). Mounting hardware for Carling series breakers included.
Stylized non-metallic inlet housing; blank for attaching a circuit breaker
(not included). Mounting hardware for Carling series breakers included.
Protective rear cover. Fits all 30A shore power inlets.
Secures to back of inlets with 3 screws which are provided.
Replacement interior for HBL303SS and 60CM61 shore power inlets.
Nickel plated brass adapter plate for mounting chrome plated brass
shore power inlets to FS/FD box.
Traditional Stainless steel power outlet has gasketed, self-closing cover,
watertight when cover is screwed in place. Mounting holes are 2.38 in.
(60.3) on centers. Mounting screws and gasket included.
Notes: ** Not UL/CSA.
Δ To be discontinued when present stocks are exhausted.
Marine Products
30 Ampere, 125 Volt AC Cable Sets and Bulk Cable
Marine Products
30 Ampere, 125 Volt AC Cable Sets and Bulk Cable
2 Pole 3 Wire
Ship-to-Shore Devices
IP56
(Boatside)
30A 125V Shore Power Cable Set
HBL61CM08
YC310250
6
W
SUITABILITY
(Cable Sets)
G
30A 125V
NEMA L5-30R
Description
Catalog Numbers
Yellow 50 ft. (15.2m) vinyl jacketed shore power cable set. #10 AWG is
factory pre-wired with molded-on devices. Connector end has
non-metallic threaded sealing ring which makes inlet/connector
interface watertight.
HBL61CM08
Same as HBL61CM08 except 35 ft. (10.7m) in length.
Same as HBL61CM08 except 25 ft. (7.6m) in length.
HBL61CM05
HBL61CM03
Same as HBL61CM08 except in white.
Same as HBL61CM03 except in white.
HBL61CM08W
HBL61CM03W
Yellow 250 ft. (76.2m) three conductor, #10 AWG type STW, PVC jacketed
portable cord with jute fillers for added flexibility. Ideal for
making cable sets, extension cord, and adapters that will not
mark boat’s deck. 250 ft. (76.2m) lengths only.
YC310250
White 280 ft. (85.3m) three conductor, #10 AWG type STW, PVC jacketed
portable cord with jute fillers for added flexibility. Ideal for
making cable sets, extension cord, and adapters that will not
mark boat’s deck. 280 ft. (85.3m) lengths only.
WC310280
Replacement non-metallic sealing ring for 30A cable sets
and boots. Not UL Listed.
RPL30P
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
30 Ampere, Cable Set with High Intensity LED “Power-On” Indicator
Ship-to-Shore Cable Sets
Bull ring
for added
strain relief.
Bright, durable, LED (green) indicates “power-on”.
High intensity LED is visible—even in bright sunlight.
Totally molded design for superior waterproofing and durability.
Exclusive copper crimp barrel terminations for tighter
connections and longer life..
Exclusive crimp
termination
for longer life.
W
IP56
G
SUITABILITY
(Boatside)
30A Shore Power Cable Set with LED “Power-On” Indicator
30A 125V
NEMA L5-30R
UL/CSA
Description
Catalog Numbers
Yellow 50 ft. (15.2m) vinyl jacketed shore power cable set. #10 AWG is factory pre-wired with
molded-on devices. Connector end has non-metallic threaded sealing ring which makes
inlet/connector interface watertight.
Same as HBL61CM08LED except 35 ft. (10.7m) in length.
Same as HBL61CM08LED except 25 ft. (7.6m) in length.
Same as HBL61CM08LED except in white.
Same as HBL61CM05LED except in white.
Same as HBL61CM03LED except in white.
Replacement non-metallic sealing ring for 30A cable sets and boots. Not UL Listed.
HBL61CM08LED
HBL61CM05LED
HBL61CM03LED
HBL61CM08WLED
HBL61CM05WLED
HBL61CM03WLED
RPL30P
Bright green LED
indicates “Power-On”.
Ergonomic
styling.
Dimensions in Inches (mm)
Arrows line-up.
www.hubbell-wiring.com
7
30 Amp Cable Set with High Intensity LED “Power-On” Indicator
•
•
•
•
Marine Products
Marine Products
30 Ampere, 125 Volt Twist-Lock® Devices
Plugs, receptacles and
connectors only.
2 Pole 3 Wire
Ship-to-Shore Devices
W
G
30A 125V
NEMA L5-30R
UL/CSA
30A 125V Ship-to-Shore Devices
HBL26CM10
HBL26CM11
30 Ampere, 125 Volt Twist-Lock® Devices
HBL60CM31
HBL26CM13
HBL60CM33
Description
Yellow single receptacle has Rynite® body and abuse resistant
nylon face. IP20 SUITABILITY.
Yellow Insulgrip® plug has rugged nylon housing and cord grip
with range of .36–.93 in. (9–24) that utilizes a unique offset
jaws arrangement to provide secure strain relief. IP20 SUITABILITY.
Catalog Numbers
HBL26CM10
Yellow Seal-Tite® cover for weatherproofing HBL26CM11 plugs.
IP55 SUITABILITY. Note: Fits Insulgrip devices only.
HBL60CM31+
White Seal-Tite cover for weatherproofing HBL26CM11 plugs.
IP55 SUITABILITY. Note: Fits Insulgrip devices only.
HBL60CM31W+
Yellow Insulgrip connector body has rugged nylon housing and
cord grip with range of .36–.93 in. (9–24) that utilizes a unique
offset jaws arrangement to provide secure strain relief.
Yellow Seal-Tite cover for weatherproofing HBL26CM13
connector bodies when used with shore power inlets. Threaded
sealing ring makes connection watertight. Also for weatherproofing
HBL26CM11 plug when used with HBL303SSO power outlet.
IP56 SUITABILITY. Note: Fits Insulgrip devices only.
White Seal-Tite cover for weatherproofing HBL26CM13
connector body when used with shore power inlets. Threaded
sealing ring makes connection watertight. Also for weatherproofing
HBL26CM11 plug when used with HBL303SSO power outlet.
IP56 SUITABILITY. Note: Fits Insulgrip devices only.
Yellow Seal-Tite cover for weatherproofing HBL26CM13
connector bodies when used on extension cords or adapters.
IP55 SUITABILITY. Note: Fits Insulgrip devices only.
Yellow polycarbonate spring-loaded lift cover for weatherproofing old style 26CM10 receptacle. Meets the most stringent
requirements of UL’s three listing categories for weatherproof
plates. Stainless steel screws and neoprene gasket included for
mounting to FS/FD type weatherproof boxes.
IP44 SUITABILITY.
Same as HBL74CM24WO except gray in color.
IP44 SUITABILITY.
HBL26CM13
Yellow polycarbonate spring-loaded lift cover for weatherproofing HBL26CM10 receptacle. Meets the most stringent
requirements of UL’s three listing categories for weatherproof
plates. Stainless steel screws and neoprene gasket included for
mounting to FS/FD type weatherproof boxes. IP44 SUITABILITY.
Same as HBL74CM25WOA except white in color.
IP44 SUITABILITY.
HBL74CM25WOA**
HBL26CM11
HBL60CM33+
HBL60CM33W+
HBL60CM32+
HBL74CM24WO**
HBL7424WO**
HBL74CM25WOAW
Same as HBL74CM25WOA except gray in color.
IP44 SUITABILITY.
HBL7425WOA**
Stainless steel wall plate for old 26CM10.
SS725
Stainless steel wall plate for new HBL26CM10.
Notes: ** See page 43 for photo.
+ Boots are not UL listed.
SS720
HBL60CM32
Rynite® is a registered trademark of E. I. DuPont.
8
www.hubbell-wiring.com
Dimensions in Inches (mm)
30 Ampere, 125 Volt Twist-Lock® Devices
Plugs and connectors only.
2 Pole 3 Wire
Ship-to-Shore Devices
W
Marine Products
Marine Products
G
30A 125V
NEMA L5-30R
UL/CSA
30A 125V Ship-to-Shore Devices
Description
Yellow Valise® plug has one-piece nylon housing and assembles
easily with two screws. Built-in cord grip has range of .59–.93 in.
(15.0–23.6). IP20 SUITABILITY.
Black Valise plug for use on bass boats with trolling motor.
One-piece nylon housing assembles easily with two screws.
Built-in cord grip has a range of .59–.93 in. (15.0–23.6).
IP20 SUITABILITY.
Yellow Seal-Tite® cover for weatherproofing HBL26CM11V
plugs. IP55 SUITABILITY. Note: Fits Valise devices only.
Yellow Valise connector body has a one-piece nylon housing
and assembles easily with two screws. Built-in cord grip has
range of .59–.93 in. (15.0–23.6). IP20 SUITABILITY.
Yellow Seal-Tite cover for HBL26CM13V connector body when
used with shore power inlets. Threaded sealing ring makes
connection watertight. IP56 SUITABILITY.
Note: Fits Valise devices only.
Yellow Seal-Tite cover for weatherproofing HBL26CM13V
connector bodies when used on extension cords or adapters.
IP55 SUITABILITY. Note: Fits Valise devices only.
Replacement non-metallic sealing ring for 30A cable sets
and boots. Not UL listed.
Note: + Boots are not UL listed.
Catalog Numbers
HBL26CM11V
HBL26CM11V
HBL26CM11VB
HBL60CM31V+
HBL26CM13V
HBL60CM33V+
HBL26CM11VB
HBL60CM32V+
RPL30P
HBL60CM31V
30 Ampere, 125 Volt Twist-Lock® Devices
HBL26CM13V
RPL30P
Valise® Plug
HBL60CM33V
HBL60CM32V
Dimensions in Inches (mm)
www.hubbell-wiring.com
9
Marine Products
Marine Products
50 Ampere, 125 Volt Twist-Lock® Devices
Ship-to-Shore Devices
W
G
50A 125V Ship-to-Shore Devices
HBL503NM
HBL503RI
HBL503SS
50 Ampere, 125 Volt Twist-Lock® Devices
Inlets and connectors
only.
2 Pole 3 Wire
Description
Stylized non-metallic shore power inlet has UV resistant white Centrex
cover which makes unit weatherproof when completely closed. Interior
has easy to wire terminals. Mounting holes are 2.38 in. (60.3) on centers and
match existing mounting patterns. Mounting screws and gasket included.
IP56 SUITABILITY.
Stylized type 316 stainless steel shore power inlet has easy to use
push-button latch that makes unit watertight when fully engaged. Interior
has easy to wire terminals. Mounting holes are 2.38 in. (60.3) on centers and
match existing mounting patterns. Mounting screws and gasket included.
IP56 SUITABILITY.
Traditional stainless steel shore power inlet has gasketed, self-closing cover
so interior is shielded from the elements when not in use. Watertight when
cover is securely fastened. Mounting holes are 2.38 in. (60.3) on centers, and
rear portion has 2.17 in. (55.1) diameter. Mounting screws and gasket included.
IP56 SUITABILITY.
Protective rear cover. Fits all inlets except HBL503SS. Secures to back of
inlets with 3 screws which are provided.
Replacement interior for HBL503SS and 63CM72 shore power inlets.
Nickel plated brass connector body has heat resistant thermoset interior
and combination metal and rubber cord grip provides superior strain relief
capability. Cord grip range is .44–1.14 in. (11.1–29.0). IP20 SUITABILITY.
Yellow Seal-Tite® cover for connector bodies when used with 50A shore
power inlets. Threaded sealing ring makes connections watertight.
IP56 SUITABILITY.
White Seal-Tite cover for connector bodies when used with 50A shore
power inlets. Threaded sealing ring makes connections watertight.
IP56 SUITABILITY.
Nickel plated brass cord clamp assembly with clamp range of .44–1.14 in.
(11.1–29.0) provides strain relief for terminations on shore power inlets.
Yellow Seal-Tite cover for weatherproofing 50A connector bodies on
extension cords or adapters. IP55 SUITABILITY.
Notes: + Boots are not UL listed.
** Not UL/CSA.
Δ To be discontinued when present stocks are exhausted.
50A 125V
Catalog Numbers
HBL503NM
HBL503RI Δ
HBL503SS
SR3050**
CR16277
HBL63CM60
HBL77CM15+
HBL77CM15W+
HBL77CM67
HBL77CM17+
50A Traditional Stainless Steel Inlets
HBL63CM60
HBL77CM15
HBL77CM17
10
www.hubbell-wiring.com
Dimensions in Inches (mm)
50 Ampere, 125 Volt Twist-Lock® Devices
Plugs and receptacles only.
2 Pole 3 Wire
Ship-to-Shore Devices
W
G
50A 125V
50A 125V Ship-to-Shore Devices
Description
Catalog Numbers
Yellow 50 ft. (15.2m) vinyl jacketed shore power cable set. #6 AWG type
STOW is completely factory pre-wired with molded-on devices.
Connector end has threaded metallic sealing ring to make inlet/
connector interface watertight. IP56 SUITABILITY
Y (BOATSIDE).
HBL61CM53
Same as HBL61CM53 except with two high intensity LEDs.
HBL61CM53LED •
Same as HBL61CM53 except white.
HBL61CM53W
Same as HBL61CM53W except with two high intensity LEDs.
HBL61CM53WLED •
Same as HBL61CM53 except 25 ft. (7.6m) in length.
HBL61CM43
Same as HBL61CM43 except with two high intensity LEDs.
HBL61CM43LED •
Three conductor, #6 AWG type STOW, yellow PVC jacketed portable
cord with jute fillers for added flexibility. Ideal for making cable sets,
extension cords, and adapters will not mark boat’s deck. 250 ft. (75.2m)
lengths only.
YC306250
Nickel plated brass plug has heat resistant thermoset interior and
combination metal and rubber cord grip, provides superior strain
relief capability. Cord grip range is .44–1.14 in. (11.1–29.0).
IP20 SUITABILITY.
HBL63CM61
Yellow Seal-Tite® cover for weatherproofing 50A plugs. IP55 SUITABILITY.
HBL77CM16+
White Seal-Tite cover for weatherproofing 50A plugs. IP55 SUITABILITY.
HBL77CM16W+
Single receptacle has a heat-resistant thermoset base. IP20 SUITABILITY.
HBL63CM70
Yellow Valox lift cover for weatherproofing 50A receptacles.
Meets requirements of the most stringent of UL’s three listing
categories for weatherproof plates. Stainless steel screws and
a neoprene gasket included. For mounting to FS/FD type
weatherproof boxes. IP44 SUITABILITY.
HBL77CM74WO
Same as HBL77CM74WO except gray in color. IP44 SUITABILITY.
HBL7774WO
Stainless steel wall plate for 50A receptacle.
SS750
®
Marine Products
Marine Products
HBL61CM53
HBL61CM53W
HBL61CM43
HBL63CM61
HBL77CM16
Notes: + Boots are not UL listed.
• Features and benefits on page 14.
HBL77CM74WO
Valox® is a trademark of SABIC Innovative Plastics, acquired from General Electric Company.
Dimensions in Inches (mm)
www.hubbell-wiring.com
SS750
11
50 Ampere, 125 Volt Twist-Lock® Devices
HBL63CM70
50A Molded Cable Sets
Marine Products
Marine Products
50 Ampere, 125/250 Volt Twist-Lock® Devices
Ship-to-Shore Devices
Y
X
W
G
50A 125/250V Ship-to-Shore Devices
HBL504NM
HBL504RI
50 Ampere, 125/250 Volt Twist-Lock® Devices
Inlets and connectors only.
3 Pole 4 Wire
HBL504SS
Description
Stylized non-metallic shore power inlet has UV resistant white Centrex
cover which makes unit weatherproof when completely closed. Interior
is heat resistant thermoset material and has box lug terminals. Mounting
holes are 2.38 in. (60.3) on centers and match existing mounting patterns.
Mounting screws and gasket included. IP56 SUITABILITY.
Stylized type 316 stainless steel shore power inlet has easy to use pushbutton latch that makes unit watertight when fully engaged. Interior is heat
resistant thermoset material and has box lug terminals. Mounting holes are
2.38 in. (60.3) on centers and match existing mounting patterns. Mounting
screws and gasket included. IP56 SUITABILITY.
Traditional stainless shore power inlet has gasketed, self-closing cover
so that the interior is shielded from the elements when not in use. It is
watertight when the cover is securely fastened. The mounting holes are
2.38 in. (60.3) on centers, and the rear portion has a 2.17 in. (55.1) diameter.
Mounting screws and gasket are included. IP56 SUITABILITY.
Protective rear cover. Fits all inlets except HBL504SS.
Secures to back of inlets with 3 screws which are provided.
Replacement interior for 63CM74 and HBL504SS power inlets.
Nickel plated brass connector body has a heat resistant thermoset
interior and combination metal and rubber cord grip, which provides
superior strain relief capability. Cord grip range is .44–1.14 in.
(11.1–29.0). IP20 SUITABILITY.
Yellow Seal-Tite® cover for connector bodies when used with 50A shore
power inlets. Threaded sealing ring makes connections watertight.
IP56 SUITABILITY.
White Seal-Tite cover for connector bodies when used with 50A shore
power inlets. Threaded sealing ring makes connections watertight.
IP56 SUITABILITY.
Nickel plated brass cord clamp assembly with clamp range of .44–1.14 in.
(11.1–29.0) provides strain relief for terminations on shore power inlets.
Yellow Seal-Tite cover for weatherproofing 50A connector bodies on
extension cords or adapters. IP55 SUITABILITY.
50A
125/250V
UL/CSA
Catalog Numbers
HBL504NM
HBL504RI Δ
HBL504SS
SR3050**
CR16279**
HBL63CM64
HBL77CM15+
HBL77CM15W+
HBL77CM67
HBL77CM17+
Notes: ** Not UL/CSA.
+ Boots are not UL listed.
Δ To be discontinued when present stocks are exhausted.
50A Traditional Stainless Steel Inlets
HBL63CM64
HBL77CM15
HBL77CM17
12
www.hubbell-wiring.com
Dimensions in Inches (mm)
50 Ampere, 125/250 Volt Twist-Lock® Devices
Plugs and receptacles only.
3 Pole 4 Wire
Ship-to-Shore Devices
Y
X
W
G
50A
125/250V
UL/CSA
50A 125/250V Ship-to-Shore Devices
Description
Yellow 50 ft. (15.2m) vinyl jacketed shore power cable set, #6 AWG type
STOW is completely factory pre-wired with molded-on devices.
The connector end has a metallic threaded sealing ring for making
the inlet/connector interface watertight. IP56 SUITABILITY (BOATSIDE).
Catalog Numbers
HBL61CM52
Same as HBL61CM52 except with two high intensity LEDs.
Same as HBL61CM52 except white.
HBL61CM52LED •
HBL61CM52W
Same as HBL61CM52W except with two high intensity LEDs.
Yellow 25 ft. (15.2m) vinyl jacketed shore power cable set, #6 AWG type
STOW is completely factory pre-wired with molded-on devices.
The connector end has a metallic threaded sealing ring for making
the inlet/connector interface watertight. IP56 SUITABILITY (BOATSIDE).
HBL61CM52WLED •
HBL61CM42
Same as HBL61CM42 except with two high intensity LEDs.
Same as HBL61CM42 except white.
Same as HBL61CM42W except with two high intensity LEDs.
Four conductor, #6 AWG type STOW, yellow PVC jacketed portable
cord with jute fillers for added flexibility is ideal for making cable sets,
extension cords, and adapters that will not mark the boats deck.
Available in 250 ft. (76.2m) lengths only.
Nickel plated brass plug has a heat resistant thermoset interior and
combination metal and rubber cord grip, which provides superior
strain relief capability. Cord grip range is .44–1.14 in. (11.1–29.0).
IP20 SUITABILITY.
Yellow Seal-Tite® cover for weatherproofing 50A plugs.
IP55 SUITABILITY.
White Seal-Tite® cover for weatherproofing 50A plugs.
IP55 SUITABILITY.
Single receptacle has a heat resistant thermoset base.
IP20 SUITABILITY.
Yellow Valox® lift cover for weatherproofing 50A receptacles.
Meets requirements of the most stringent of UL’s three listing categories
for weatherproof plates. Stainless steel screws and a neoprene gasket
included. For mounting to FS/FD type weatherproof boxes.
IP44 SUITABILITY.
Same as HBL77CM74WO except gray in color. IP44 SUITABILITY.
Stainless steel wall plate for 50A receptacle.
HBL61CM42LED •
HBL61CM42W
HBL61CM42WLED •
YC406250
HBL61CM52
HBL61CM52W
HBL61CM42
HBL61CM42W
HBL63CM65
HBL63CM65
HBL77CM16+
HBL77CM16W+
HBL63CM69
HBL77CM74WO
HBL77CM16
HBL63CM69
50A Molded Cable Sets
HBL77CM74WO
Valox® is a trademark of SABIC Innovative Plastics, acquired from General Electric Company.
www.hubbell-wiring.com
SS750
13
50 Ampere, 125/250 Volt Twist-Lock® Devices
HBL7774WO
SS750
Notes: + Boots are not UL listed.
• Features and benefits on page 14.
Dimensions in Inches (mm)
Marine Products
Marine Products
Marine Products
Marine Products
50 Ampere, Cable Set with Two High Intensity LEDs:
“Power-On” and “Incorrect Wiring” Indicators
Ship-to-Shore Cable Sets
Bull ring
for added
strain relief.
50 Ampere, Cable Set with Two High Intensity LEDs
• Two bright, durable, LEDs. GREEN indicates “Power-On” and
RED indicates “Incorrect Wiring” at the power source.
• High intensity LEDs are visible—even in bright sunlight.
• Totally molded design for superior waterproofing and durability.
• Exclusive copper crimp barrel terminations for tighter
connections and longer life.
IP56
Exclusive crimp
termination
for longer life.
Y
W
SUITABILITY
(Boatside)
X
G
50A 125V
50A Shore Power Cable Set with Two LED Indicators
W
G
50A
125/250V
Description
Catalog Number
Catalog Numbers
Yellow 50 ft. (15.2m) vinyl jacketed shore power cable set, #6 AWG type
STOW is completely factory pre-wired with molded-on devices.
The connector end has a metallic threaded sealing ring for making
the inlet/connector interface watertight.
Same as HBL61CM52LED except in white.
Same as HBL61CM52LED except 25 ft. (7.6m) in length.
Same as HBL61CM42LED except in white.
HBL61CM53LED
HBL61CM52LED
HBL61CM53WLED
HBL61CM43LED
–
HBL61CM52WLED
HBL61CM42LED
HBL61CM42WLED
indicates Incorrect
Wiring” at the
power source.
14
Ergonomic
styling.
Arrows
line-up.
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
100 Ampere, 125/250 Volt and 3ØY 120/208 Volt
3, 4, and 5 Wire
Ship-to-Shore Cable Sets
IP67
SUITABILITY
100A
125/250V AC
100A 125/250V Ship-to-Shore Cable Sets
Description
Catalog Numbers
Yellow 75 ft. (22.8m) corrosion resistant shore power cable set, 105° C rated,
CS75IT4
#2 AWG, 2 pole 3 wire (no neutral), STOW cable with 3 pole 4 wire, 100A 125/250V
plug and connector body for use with boats with isolation transformer on board.
CS100IT4
Yellow 75 ft. (22.8m) corrosion resistant shore power cable set, 105° C rated,
#2 AWG, 3 pole 4 wire STOW cable.
CS754
Same as CS754 except 100 ft. (30.4m) in length.
CS1004
Yellow 50 ft. (15.2m) corrosion resistant extension cord, 105° C rated, #2 AWG,
3 pole 4 wire STOW cable. For mating with existing shore power cable set.
Yellow 75 ft. (22.8m) corrosion resistant one-ended (male only) power supply
cable, 105° C rated, #2 AWG, 3 pole 4 wire STOW cable with 3 pole 4 wire
male plug only; for use with boats using a cable winch system.
CS50EXT4
Yellow 100 ft. (30.4m) corrosion resistant one-ended (male only) power supply
cable, 105° C rated, #2 AWG, 2 pole 3 wire (no neutral) STOW cable with 3 pole
4 wire male plug only; for use with boats with isolation transformer on board
and a cable winch system.
CW100IT4
Same as CW100IT4 except 125 ft. (38.0m) in length.
CW125IT4
CW754
Description
Catalog Numbers
Yellow 75 ft. (22.8m) corrosion resistant shore power cable set, 105° C rated,
CS75IT5
#2 AWG, 3 pole 4 wire (no neutral), STOW cable with 4 pole 5 wire, 100A 120/208V
plug and connector body for use with boats with isolation transformer on board.
Same as CS75IT5 except 100 ft. (30.4m) in length.
CS100IT5
Yellow 50 ft. (15.2m) corrosion resistant extension cord, 105° C rated, #2 AWG,
4 pole 5 wire STOW cable. For mating with existing shore power cable set.
CS50EXT5
Yellow 100 ft. (30.4m) corrosion resistant one-ended (male only) power supply
cable, 105° C rated, #2 AWG, 3 pole 4 wire (no neutral) STOW cable with 4 pole
5 wire male plug only; for use with boats with isolation transformer on board
and a cable winch system.
CW100IT5
Same as CW100IT5 except 125 ft. (38.0m) in length.
CW125IT5
LPS-1®
Note: Periodic cleaning and lubrication (such as
made by Holt Lloyd Corp.) of the
pins and sleeves of these devices is necessary to enjoy years of optimal use.
www.hubbell-wiring.com
Benefits
Factory assembled. Reliable and consistent
terminations.
100 Amp pin and
sleeve devices.
Rugged, watertight,
UL listed, AB02029 YC
compliant, corrosion
resistant.
UL Listed cable.
High visibility yellow,
STOW cable, 105° C
rated, and UL listed.
Breadth of line.
Available in 75, 100,
and 125 ft. lengths with
and without a neutral.
Fifty foot extension
cords also available.
100% inspection.
Each cable set is tested
to ensure quality
performance.
100A 3ØY
120/208V AC
100A 120/208V Ship-to-Shore Cable Sets
Dimensions in Inches (mm)
Features
CS75IT4
15
100 Ampere, 125/250 Volt and 3ØY 120/208 Volt
Same as CS75IT4 except 100 ft. (30.4m) in length.
• Hubbell Marine was the first to offer
100 amp marine grade devices that
are considered second to none.
• Hubbell developed the standard for
100 amp Pin and Sleeve devices with
the National Electric Code and the
American Boat and Yacht Council.
• Only Hubbell offers 3, 4 and 5 wire
100 amp cable sets for your shore
power requirements.
• Cable sets manufactured in factorycontrolled conditions using specially
compounded cable to accommodate
a full 100 amp.
Marine Products
Marine Products
100 Ampere, 125/250 Volt
3 Pole 4 Wire
Ship-to-Shore Devices
IP67
SUITABILITY
100A
125/250V AC
100A 125/250V Ship-to-Shore Devices
M4100B12R
M4100C12R
Description
Catalog Numbers
Gray nylon shore power inlet has gasketed, spring-loaded cover which
closes automatically when not in use and is watertight when securely
fastened. Mounting holes are 4.88 in. (123.8) on centers and rear portion
has 3.94 in. (100.0) diameter. Mounting screws and gasket included.
M4100B12R
Yellow Zytel® super tough nylon watertight connector body has
gasketed locking ring to make inlet/connector interface watertight.
Cord grip range is 1.00–1.94 in. (25.4–49.3).
Note: This device mates with shore power inlet only.
M4100C12R
15° angle cast aluminum back box has corrosion resistant gray
finish and top hub with 1½ in. N.P.T. 100A receptacles can be
mounted directly to it.
BB1001W
Same as BB1001W except threaded top hub is 2.00 in. N.P.T.
BB1002W
15° angle non-metallic back box, made of high-grade engineered
thermoplastic Valox® to resist chemicals, abuse and U.V. rays.
Has integral grounding plate, 1½ in. N.P.T. hub size and 120 cu. in.
capacity (hub is not included - Raco part number 1706 is recommended).
BB100N
Replacement Parts
Replacement lift cover assembly; includes cover, arm and assembly tool.
CA100
Replacement locking ring and cord clamp.
CC100
Replacement locking ring only.
LR100
Notes: Periodic cleaning and lubrication (such as LPS-1 made by Holt Lloyd Corp.) of the pins
and sleeves of these devices is necessary to enjoy years of optimal use.
®
BB1001W
BB1002W
100 Ampere, 125/250 Volt
Shore Power Inlet
BB100N
Valox® is a trademark of SABIC Innovative Plastics, acquired from General Electric Company.
16
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
100 Ampere, 125/250 Volt
3 Pole 4 Wire
Ship-to-Shore Devices
IP67
SUITABILITY
100A
125/250V AC
100A 125/250V Ship-to-Shore Devices
Description
Catalog Numbers
Yellow Zytel® super tough nylon watertight plug has gasketed locking ring
to make plug/receptacle interface watertight. Cord grip range is
1.00–1.94 in. (25.4–49.3).
M4100P12
Gray nylon dockside receptacle has gasketed, spring-loaded cover.
Closes automatically when not in use and is watertight when
securely fastened. Mounting holes are 4.88 in. (123.8) on centers.
Mounting screws and gasket included.
M4100R12
Yellow Zytel® super tough nylon watertight connector body for mating plug
to connector interface on extension cords or adapters. Cord grip range
is 1.00–1.94 in. (25.4–49.3). Note: It cannot be mated to the shore
power inlet.
M4100C12
Back box for inlets and receptacles has 15° angle section which
can be installed in any of 4 positions. Box is cast aluminum with
corrosion resistant gray alkyd-based enamel finish and 1½ in. N.P.T.
hub which can be mounted for either top or bottom feed.
FW60100
Closure Cap for 100A plugs and connector bodies that (do not have
a cap attached) have locking rings.
PC100
M4100P12
M4100R12
Replacement Parts
Replacement lift cover assembly; includes cover, arm and assembly tool.
CA100
Replacement locking ring and cord clamp.
CC100
Replacement locking ring only.
LR100
Notes: Periodic cleaning and lubrication (such as LPS-1 made by Holt Lloyd Corp.) of the pins
and sleeves of these devices is necessary to enjoy years of optimal use.
®
FW60100
M4100C12
FW60100
100A Connector Body
100 Ampere, 125/250 Volt
PC100
Zytel® is a registered trademark of E.I. DuPont.
Dimensions in Inches (mm)
CA100
www.hubbell-wiring.com
17
Marine Products
Marine Products
100 Ampere, 3ØY 120/208 Volt and 3ØY 277/480 Volt
4 Pole 5 Wire
Ship-to-Shore Devices
IP67
SUITABILITY
100A 3ØY 120/208V and 100A 3ØY 277/480V
Ship-to-Shore Devices
M5100B9R
M5100C9R
100A 3ØY
277/480V AC
100A 3ØY
120/208V AC
Description
Catalog Numbers
Gray nylon shore power inlet has gasketed, spring-loaded
cover which closes automatically when not in use and is
watertight when securely fastened. Mounting holes are
4.88 in. (123.8) on centers and rear portion has 3.94 in.
(100.0) diameter. Mounting screws and gasket included.
M5100B9R
M5100B7R
Yellow Zytel® super tough nylon watertight connector body
has gasketed locking ring to make inlet/connector interface
watertight. Cord grip range is 1.00–1.94 in. (25.4–49.3).
Note: This device mates with shore power inlet only.
M5100C9R
M5100C7R
15° angle cast aluminum back box has corrosion resistant
gray finish and top hub with 1½ in. N.P.T. 100A receptacles
can be mounted directly to it.
BB1001W
BB1001W
Same as BB1001W except threaded top hub is 2.0 in. N.P.T.
BB1002W
BB1002W
15° angle non-metallic back box, made of high-grade
engineered thermoplastic Valox® to resist chemicals, abuse
and U.V. rays. Has integral grounding plate, 1½ in. N.P.T.
hub size and 120 cu. in. capacity (hub is not included Raco part number 1706 is recommended).
BB100N
BB100N
CA100
CA100
Replacement Parts
100 Ampere, 3ØY 120/208 Volt and 3ØY 277/480 Volt
Replacement lift cover assembly; includes cover, arm and
assembly tool.
BB1001W
BB1002W
Replacement locking ring and cord clamp.
CC100
CC100
Replacement locking ring only.
LR100
LR100
Note: Periodic cleaning and lubrication (such as LPS-1® made by Holt Lloyd Corp.) of the pins
and sleeves of these devices is necessary to enjoy years of optimal use.
Shore Power Inlet
BB100N
Valoxx® is a trademark of SABIC Innovative Plastics, acquired from General Electric Company.
Zytel® is a registered trademark of E.I. DuPont.
18
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
100 Ampere, 3ØY 120/208 Volt and 3ØY 277/480 Volt
4 Pole 5 Wire
Ship-to-Shore Devices
IP67
SUITABILITY
100A 3ØY 120/208V and 100A 3ØY 277/480V
Ship-to-Shore Devices
100A 3ØY
277/480V AC
100A 3ØY
120/208V AC
Description
Catalog Numbers
Yellow Zytel super tough nylon watertight plug has gasketed
locking ring to make plug/receptacle interface watertight.
Cord grip range is 1.00–1.94 in. (25.4–49.3).
M5100P9
M5100P7
Gray nylon dockside receptacle has gasketed, spring-loaded
cover. Closes automatically when not in use and is watertight
when securely fastened. Mounting holes are 4.88 in. (123.8) on
centers. Mounting screws and gasket included.
M5100R9
M5100R7
Yellow Zytel® super tough nylon watertight connector body for
making plug to connector interface on extension cords or
adapters. Cord grip range is 1.00–1.94 in. (25.4–49.3).
Note: It cannot be mated to the shore power inlet.
M5100C9
M5100C7
Back box for inlets and receptacles has 15° angle section which
can be installed in any of 4 positions. Box is cast aluminum with
corrosion resistant gray alkyd-based enamel finish and 1½ in. N.P.T.
hub which can be mounted for either top or bottom feed.
FW60100
FW60100
Closure Cap for 100A plugs and connector bodies that (do not
have a cap attached) have locking rings.
PC100
PC100
Replacement lift cover assembly; includes cover, arm and
assembly tool.
CA100
CA100
Replacement locking ring and cord clamp.
CC100
CC100
Replacement locking ring only.
LR100
LR100
®
M5100P9
M5100R9
Replacement Parts
M5100C9
FW60100
100A Connector Body
ody
FW60100
PC100
CA100
Zytel® is a registered trademark of E.I. DuPont.
Dimensions in Inches (mm)
www.hubbell-wiring.com
19
100 Ampere, 3ØY 120/208 Volt and 3ØY 277/480 Volt
Note: Periodic cleaning and lubrication (such as LPS-1® made by Holt Lloyd Corp.) of the pins
and sleeves of these devices is necessary to enjoy years of optimal use.
Marine Products
Marine Products
200 Ampere, 600V AC/250V DC, 50-400 Hertz
NEMA 4X
4 Pole 5 Wire
Ship-to-Shore Devices
bbell was the first to offer a marine-ized UL listed 100 AMP Ship-To-Shore
stem…and now, we are the first to offer a marine-ized, UL listed 200 AMP
p-to-shore system.
Hubbell’s 200 AMP Ship-To-Shore System is:
• NEMA 4X rated for superior water resistance.
• Made of copper-free aluminum with an electrostatically applied
epoxy/polyester finish.
• Accepts a cord range of #1 AWG – 250 MCM.
• Pin and sleeves are made of nickel-plated Tellurium copper for
superior corrosion and heat resistance.
And
Fully interchangeable with UL 1686 configured and listed devices such
as Crouse-Hinds® Arktite® or Appleton® Powertite® (when installed in
accordance with instructions furnished with device).
200 Ampere, 600V AC/250V DC, 50-400 Hertz
200A 600V Ship-to-Shore Devices
M5200BS1R
200A
600V AC/250V DC
Description
Catalog Numbers
Gray metallic watertight shore power inlet with
wingnut-secured lid for water tightness when not in use.
M5200BS1R
Gray/yellow metallic watertight connector body with
locking ring to make inlet/connector body interface
watertight. Cord range is #1 AWG-250 MCM
(0.653 max. conductor diameter).
M5200CS1R
Dimensions
M5200CS1R
20
www.hubbell-wiring.com
Dimensions in Inches (mm)
200 Ampere, 600V AC/250V DC, 50-400 Hertz
NEMA 4X
4 Pole 5 Wire
Ship-to-Shore Devices
200A
600V AC/250V DC
200A 125/250V Ship-to-Shore Devices
Description
Catalog Numbers
Gray/yellow metallic watertight plug with locking ring to make
plug/receptacle interface watertight. Cord grip range is
#1 AWG-250 MCM (0.653 max. conductor diameter).
M5200PS1
Gray metallic, watertight dockside receptacle with wing
nut-secured lid for water tightness when not in use.
M5200RS1
Gray/yellow metallic watertight connector body with wing
nut-secured lid for water tightness when not in use.
For making plug/connector body interface on extension
cords or adapters.
M5200CS1
Gray metallic Back Box for inlets and receptacles has
15° angle section which can be installed in any of
4 positions, 2.0 in. N.P.T. hub.
MB2003W
Gray metallic Back Box – same as above but 2½ in. N.P.T. hub.
MB2004W
Marine Products
Marine Products
M5200PS1
M5200RS1
Dimensions
200 Ampere, 600V AC/250V DC, 50-400 Hertz
M5200CS1
MB2003W
Dimensions in Inches (mm)
www.hubbell-wiring.com
21
Marine Products
Marine Products
Internationally Rated Twist-Lock® Devices
16, 32 Ampere, 230 Volt
IP56
SUITABILITY
Hubbell offers the only CE certified electrical shore power system truly
dedicated for boats destined for Europe and the International community.
Hubbell’s offering of international shore power inlets are available in
traditional 6QE-inch stainless steel and attractive white non-metallic types
resembling our domestic offering in style and appearance but are not
interchangeable with the domestic shore power system.
HBL316NM
HBL332NM
Utilizing standard NEMA (National Electrical Manufacturer’s Association)
configurations not typically used in the marine market, Hubbell can offer
a safe and non-interchangeable 16 Amp 230 Volt system and 32 Amp
230 Volt system for use with 50 cycle systems. The system includes white
power supply cables (one-end, female only) in both the 16 Amp and
32 Amp categories.
16A 230V Ship-To-Shore Power System
Internationally Rated Twist-Lock® Devices
HBL316SSX
HBL332SSX
HBL316CSW25
HBL316CSW
HBL332CSW
HBL316CRC
HBL332CRC
Description
Non-metallic, white, stylized, U.V. resistant shore power inlet.
White Centrex cover makes the inlet weatherproof when closed.
Mounting holes are 2.38 in. (60.3) on centers and match most existing
mounting patterns. Rear enclosure strain/relief cap is provided.
Traditional, stainless steel shore power inlet has new easy-to-wire
terminations. Interior is transparent for quick and easy visual
inspection. Interior is shielded from the elements by a gasketed,
self-closing cover, watertight when cover is screwed in place.
Mounting holes are 2.38 in. (60.3) on centers. Mounting screws and
gasket included. Protective rear enclosure/strain relief also included.
25 ft. (7.6m) white, vinyl jacketed power supply cord with female
(boat side) end only; other end blunt cut.
50 ft. (15.2m) white, vinyl jacketed power supply cord with female
(boat side) end only; other end blunt cut.
Yellow locking connector replacement end for HBL316CSW25
and HBL316CSW. IP20 SUITABILITY.
White Seal-Tite® cover with threaded sealing ring for use with
HBL316CRC and HBL332CRC connector bodies.
IP55 SUITABILITY.
Catalog Numbers
HBL316NM
HBL316SSX
HBL316CSW25
HBL316CSW
HBL316CRC
HBL103RX
32A 230V, 50 Cycle Ship-To-Shore Power System
Description
Non-metallic, white, stylized, U.V. resistant shore power inlet.
White Centrex cover makes the inlet weatherproof when closed.
Mounting holes are 2.38 in. (60.3) on centers and match most existing
mounting patterns. Rear enclosure/strain relief cap is provided.
Traditional, stainless steel shore power inlet has new easy-to-wire
terminations. Interior is transparent for quick and easy visual
inspection. Interior is shielded from the elements by a gasketed,
self-closing cover, watertight when cover is screwed in place.
Mounting holes are 2.38 in. (60.3) on centers. Mounting screws and
gasket included. Protective rear enclosure/strain relief also included.
50 ft. (15.2m) white, vinyl jacketed power supply cord with female
(boat side) end only; other end blunt cut.
Yellow locking connector replacement end for HBL332CSW.
IP20 SUITABILITY.
White Seal-Tite cover with threaded sealing ring for use with
HBL316CRC and HBL332CRC connector bodies.
IP55 SUITABILITY.
Catalog Numbers
HBL332NM
HBL332SSX
HBL332CSW
HBL332CRC
HBL103RX
HBL103RX
22
www.hubbell-wiring.com
Dimensions in Inches (mm)
Internationally Rated Pin and Sleeve Devices
16, 32, 63 Ampere, 240 Volt
UL Classified to IEC
60309-1 and 60309-2
IP67
SUITABILITY
Devices are rated in either 16A, 32A or 63A, 240V, 2 pole plus earth ( ) .
Marine Products
Marine Products
16A 240V, 2 Pole
Description
Shore power inlet with mounting holes 3.13 in. (79.3) on centers
and 2.72 in. (69.1) diameter on rear portion.
Connector body with cord grip range of .36–.83 in. (9.1-21.1).
Catalog Numbers
HBL316B6W
Shore power receptacle with mounting holes 3.13 in. (79.3)
on centers and 2.72 in. (69.1) diameter on rear portion.
HBL316R6W
Plug with cord grip range of .36–.83 in. (9.1-21.1).
Closure plug for HBL316B6W. Not CSA.
Back box for inlets and receptacles is cast aluminum with
corrosion resistant alkyd-based enamel finish and two
¾ in. N.P.T. hubs.
Feed-thru box for inlets and receptacles is cast aluminum
with corrosion resistant alkyd-based enamel finish and one
¾ in. N.P.T. hubs.
HBL316P6W
PC320
BB201W
HBL316C6W
HBL316B6W
FT202W
HBL316R6W
32A 240V, 2 Pole
Catalog Numbers
HBL332B6W
HBL332C6W
HBL332R6W
HBL332P6W
PC3430
BB301W
HBL316C6W
63A 240V, 2 Pole
Description
Shore power inlet with mounting holes 3.88 in. (98.4) on centers
and 3.94 in. (88.1) diameter on rear portion.
Catalog Numbers
HBL363B6W
Connector body with cord grip range of .70–1.45 in. (17.8–36.8).
Shore power receptacle with mounting holes 3.88 in. (98.4) on
centers and 3.94 in. (88.1) diameter on rear portion.
HBL363C6W
HBL363R6W
Plug body with cord grip range of .70–1.45 in. (17.8–36.8).
HBL363P6W
Closure plug for HBL363B6W. Not CSA.
Back box with 1½ in. N.P.T. hub.
Back box for inlets and receptacles has 15° angle section which
can be installed in any of four positions. Box is cast aluminum with
corrosion resistant gray alkyd-based enamel finish and 1½ in. N.P.T.
hub which can be mounted for either top or bottom feed.
PC60
BB601W
FW60100
HBL316P6W
PC320
BB201W
Dimensions in Inches (mm)
www.hubbell-wiring.com
23
Internationally Rated Pin and Sleeve Devices
Description
Shore power inlet with mounting holes 3.13 in. (79.3) on centers
and 2.72 in. (69.1) diameter on rear portion.
Connector body with cord grip range of .45–1.25 in. (11.4–31.8).
Shore power receptacle with mounting holes 3.13 in. (79.3) on
centers and 2.72 in. (69.1) diameter on rear portion.
Plug body with cord grip range of .45–1.25 in. (11.4–31.8).
Closure plug for HBL332B6W. Not CSA.
Back box for inlets and receptacles is cast aluminum with
corrosion resistant alkyd-based enamel finish and one
1.0 in. N.P.T. hub.
Marine Products
Marine Products
Intelligent Y Adapters
YQ230 - Safely powers a 50A, 125/250V AC boat from two 30A, 125V AC receptacles at dockside.
Application:
Problem: A boat owner with one
electrical system on board docks
in a marina that can only provide a
different electrical system.
Solution: Use of the Hubbell YQ
series of Intelligent Adapters can
correct many electrical system
mismatches.
Features and Benefits:
• 3 pole contactor breaks both hots
and neutrals to prevent possibility
of “live” plug when not engaged.
• Combines two oppositely-phased
30A, 125V receptacles to provide
30 amp,125/250 volts of power.
Note: The YQ230 Adapter will only
work with two 30A receptacles that
are on different phases.
YQ100PLUS - Safely powers a 100A, 125/250V AC boat from two 50A 125/250V AC receptacles at dockside -or- from
a single 50A 125/250V AC receptacle acting as a single adapter.
Internal Logic Senses That:
• Both plugs are fully engaged (i.e.,
one is not dangling loose while
the other is plugged in) -or- the
“A” leg plug is engaged to access
a single 50A, 125/250V receptacle.
• The polarity of the receptacle
on the dock is correct (i.e., no
mis-wiring of the hot and neutral
wires).
• The two receptacles are from
correct phases.
Intelligent Y Adapters
Note: The YQ100PLUS Adapter
must be plugged into two 50A,
125/250V AC receptacles that are
on the same phase to achieve 100
amp, 125/250 volts power -or- the
“A” leg 50A male into a single 50A,
125/250V AC receptacle to achieve
50 amp, 125/250 volts power.
Intelligent Y Adapters
24
Description
Adapter that permits use of 50A, 125/250V AC cable set. (HBL61CM52),
with two 30A, 125V AC receptacles, HBL26CM10.
Catalog Numbers
YQ230
Adapter that permits use of 100A, 125/250V AC cable set. (CS754, CS1004)
with one or two 50A, 125/250V AC receptacles, 63CM69.
YQ100PLUS
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
Adapter Selection Guide
Boat/Cable Set Side
Connector Body (Female End)
Power Center/Dock Side
Molded Straight Adapters
Catalog Number
Plug (Male End)
15A 125V, 2P 3W Straight
HBL105GF*
30A 125V, 2P 3W Twist-Lock®
30A 125V, 2P 3W Twist-Lock®
HBL61CM22
HBL61CM22W
15A 125V, 2P 3W
Straight Blade (lock type)
30A 125V, 2P 3W Twist-Lock
HBL61CM25
20A 125V, 2P 3W Twist-Lock
50A 125V, 2P 3W Twist-Lock
HBL61CM54
15A 125V, 2P 3W Straight Blade
30A 125V, 2P 3W Twist-Lock
HBL61CM55
50A 125V, 2P 3W Twist-Lock
50A 125V, 2P 3W Twist-Lock
HBL61CM56
30A 125V, 2P 3W Twist-Lock
50A 125/250V, 3P 4W Twist-Lock
HBL61CM59
50A 125/250V, 3P 4W Crow Foot
30A 125V, 2P 3W Twist-Lock
HBL61CM71
50A 125/250V, 3P 4W Twist-Lock
50A 125V, 2P 3W Twist-Lock
HBL61CM72
50A 125/250V, 3P 4W Twist-Lock
100A 125/250V, 3P 4W Pin/Sleeve
HBL61CM100
50A 125/250V, 3P 4W Twist-Lock
Molded “Y” Adapters
(2) 30A 125V, 2P 3W Twist-Lock
HBL64CM54
50A 125/250V, 3P 4W Twist-Lock
(2) 50A 125V, 2P 3W Twist-Lock
HBL64CM55
50A 125/250V, 3P 4W Twist-Lock
(2) 30A 125V, 2P 3W Twist-Lock
HBL64CM56
30A 125V, 2P 3W Twist-Lock
(2) 30A 125V, 2P 3W Twist-Lock
HBL64CM57
50A 125V, 2P 3W Twist-Lock
(2) 30A 125V, 2P 3W Twist-Lock
HBL64CM59
50A 125/250V, 3P 4W Crow Foot
One Piece Adapters
HBL31CM28
15A 125V, 2P 3W Straight Blade
15 or 20A 125V, 2P 3W Straight Blade
HBL31CM29
30A 125V, 2P 3W Twist-Lock
20A 125V, 2P 3W Twist-Lock
HBL21CM28
15A 125V, 2P 3W Straight Blade
15 or 20A 125V, 2P 3W Straight Blade
HBL21CM29
20A 125V, 2P 3W Twist-Lock
Note: See following two pages for photographs and descriptions.
* Provides GFCI Protection
Dimensions in Inches (mm)
www.hubbell-wiring.com
25
Adapter Selection Guide
30A 125V, 2P 3W Twist-Lock
Marine Products
Marine Products
Molded Straight Adapters
IP65
SUITABILITY
Molded Straight Adapters
HBL21CM28
HBL21CM29
HBL31CM28
HBL31CM29
HBL61CM22
Description
Catalog Numbers
Permits use of 20A 125V Twist-Lock® locking type plug with
HBL21CM28†
15 or 20A 125V straight blade receptacle. IP20 SUITABILITY.
Permits use of 15A or 20A 125V straight blade plug with
HBL21CM29†
20A 125V Twist-Lock locking type receptacle. IP20 SUITABILITY.
Permits use of 30A 125V Twist-Lock locking type plug with
HBL31CM28
15 or 20A 125V straight blade receptacle. IP20 SUITABILITY.
Permits use of 15A or 20A 125V straight blade plug with
HBL31CM29
30A 125V Twist-Lock locking type receptacle. IP20 SUITABILITY.
Permits use of 30A 125V cable set, HBL61CM08, with 15 or
HBL61CM22
20A 125V straight blade receptacle. Anchor locking screw
on plug when screwed down resists pullout of the cable set.
Same as HBL61CM22, except white.
HBL61CM22W
Permits use of 30A 125V cable set, HBL61CM08, with
HBL61CM25
20A 125V Twist-Lock receptacle, HBL23CM10.
Permits use of 50A 125V cable set, HBL61CM53, with
HBL61CM54
15 or 20A 125V straight blade receptacle.
Permits use of 30A 125V cable set, HBL61CM08, with
HBL61CM55
50A 125V Twist-Lock receptacle, HBL63CM70.
Permits use of 50A 125V cable set, HBL61CM53, with
HBL61CM56
30A 125V Twist-Lock receptacle, HBL26CM10.
Permits use of 50A 125/250V Twist-Lock locking type
HBL61CM59
cable set, HBL61CM52, with 50A 125/250V crow foot
straight blade receptacle HBL7962.
Permits use of 30A 125V cable set, HBL61CM08, with
HBL61CM71
50A 125/250V Twist-Lock receptacle, HBL63CM69.
Permits use of 50A 125V cable set, HBL61CM53, with
HBL61CM72
50A 125/250V Twist-Lock receptacle, HBL63CM69.
Permits use of 15A 125V 3 wire straight blade plug with
HBL5273L †
15 or 20A 125V 2 wire straight blade receptacle.
Permits a 100 amp 125/250 volt cable set to plug into a
HBL61CM100
single 50 amp 125/250 volt outlet.
Permits use of 15A straight blade plug with 30A 125V
HBL105GF
Twist-Lock receptacle; with GFCI protection.
Notes: † UL listed.
Adapters do not provide overcurrent protection.
Adapters do not provide GFCI protection except HBL105GF.
The male plug end (50A 125/250V) has a blade removed and the blade slot
filled with epoxy. Omitting the blade ensures achieving 125V safely.
Molded Straight Adapters
HBL61CM25
HBL105GF
HBL61CM59
HBL61CM54
HBL61CM71
HBL61CM56
HBL61CM72
HBL61CM55
HBL61CM100
26
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
Molded Y Adapters
IP65
SUITABILITY
Molded Y Adapters
Description
Permits use of two 30A 125V cable sets, HBL61CM08, with
one 50A 125/250V receptacle, HBL63CM69.
Permits use of two 50A 125V cables sets, HBL61CM53, with
one 50A 125/250V receptacle, HBL63CM69.
Permits use of two 30A 125V cable sets, HBL61CM08, with
one 30A 125V receptacle, HBL26CM10.
Permits use of two 30A 125V cable sets, HBL61CM08, with
one 50A 125V receptacle, HBL63CM70.
Permits use of two 30A 125V cable sets, HBL61CM08, with
one 50A 125/250V crow-foot straight receptacle, HBL7962.
Catalog Numbers
HBL64CM54
HBL64CM55
HBL64CM56
HBL64CM54
HBL64CM57
HBL64CM59
Notes: The adapters shown on this page are not UL Listed because of the nature
of adapters with their variety of ratings.
Adapters do not provide overcurrent protection.
Adapters do not provide GFCI protection except HBL105GF.
HBL64CM55
HBL64CM56
HBL64CM59
HBL64CM57
Molded Y Adapters
Dimensions in Inches (mm)
www.hubbell-wiring.com
27
Marine Products
Marine Products
Telephone and Cable TV Devices
Ship-to-Shore Devices
Telephone and Cable TV Ship-to-Shore Devices
HBLPHTVNM
HBLPHTVSS
HBLTVSS
Description
Catalog Numbers
Stylized non-metallic inlet provides telephone and cable TV
connections in one unit. UV resistant white Centrex® cover makes
unit weatherproof when completely closed. Mounting holes are
2.38 in. (60.3) on centers and match existing mounting patterns.
Mounting screws and gasket provided. IP56 SUITABILITY.
HBLPHTVNM
Stylized Type 316 stainless steel inlet provides telephone and
cable TV connections in one unit. Easy to use push-button latch
makes unit watertight when fully engaged. Mounting holes are
2.38 in. (60.3) on centers and match existing mounting patterns.
Mounting screws and gasket provided. IP56 SUITABILITY.
HBLPHTVRI Δ
Traditional stainless steel inlet provides connections for telephone
and cable TV in one unit. Connections can be used individually or
together. Gasketed cover is self-closing so interior is shielded
from the elements when not in use. Watertight when cover is
screwed in place. Mounting holes are 2.38 in. (60.3) on centers.
Mounting screws and gasket included. IP56 SUITABILITY.
HBLPHTVSS
Same as HBLPHTVSS above except no phone.
HBLTVSS
Replacement int. for PH6594TV and HBLPHTVSS series inlets.
Factory pre-wired 50 ft. (15.2m) telephone cable set. Uses 3
conductor, #16 AWG type SJTO, yellow vinyl cord for marine
and recreational vehicle applications. IP55 SUITABILITY.
CR16914
PH6599
Same as PH6599 except white.
PH6599W
Same as PH6599 except 25 ft. (7.6m) in length.
PH6598
Same as PH6598 except white.
Black locking type plug for telephone cable sets or adapters.
PH6598W
Black locking type connector body used on telephone cable sets
or adapters.
PH6624
Yellow Seal-Tite® cover for weatherproofing PH6624 connector
body on cable sets when connecting to an inlet and for weatherproofing PH6625 plug. IP55 SUITABILITY.
PH7440
Yellow Seal-Tite cover for weatherproofing PH6624 connector
body when used on extension cords or adapters. IP55 SUITABILITY.
PH7499
PH6625
Telephone and Cable TV Devices
Note: Δ To be discontinued when present stocks are exhausted.
PH6625
PH6624
P
P
P
PH6598W
PH7440
28
Centrex® is a registered trademark of LANXESS Corporation.
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
Telephone and Cable TV Devices
Ship-to-Shore Devices
IP55
SUITABILITY
Telephone and Cable TV Ship-to-Shore Devices
Description
Black polycarbonate combination telephone/TV outlet with
spring-loaded weatherproof lift cover. Can be wired for telephone
service only or for telephone and MATV/CATV services in one
FS/FD box in both marinas and RV parks. Can be padlocked to
prevent unauthorized use.
Catalog Numbers
PH6597TV
Black polycarbonate telephone outlet has gasketed, springloaded lift cover for weatherproofing. Designed for mounting to
FS/FD type weatherproof boxes (like PH6619) in both marinas
and RV parks.
PH6597
Black polycarbonate cable TV outlet has coax connector
and gasketed, spring-loaded lift cover for weatherproofing.
Designed for mounting to FS/FD type weatherproof
boxes (like PH6619) in both marinas and RV parks.
TV97
Black polycarbonate telephone outlet has gasketed, springloaded lift cover for weatherproofing. Can be used to retrofit
old style telephone outlets of Pauluhn Manufacturing Company
(2833 and 2843) in both marinas and RV parks.
Black non-metallic FS box with ¾ in. threaded hubs used for
mounting phone and TV outlets and PH6595 recreational
vehicle inlet (see PH6621 for mounting box on recreational
vehicle). Cord connector included for strain relief and to maintain
watertight integrity of box when cable is used. PVC adapter also
included for connection of PVC conduit to box.
Stainless steel bracket for mounting PH6619 FS box to
recreational vehicles when used with PH6595 inlet.
Black polycarbonate RV inlet for telephone connection only.
Has spring-loaded, gasketed weatherproof lift cover designed for
mounting to FS/FD type weatherproof boxes.
50 ft. (15.2m) yellow jacketed ship-to-shore TV cable set is the
industry standard 75 Ohm, RG59-U with male plugs on both ends.
Adapter included for a quick, slip-on connection to inlet on boat.
Same as TV99 except white.
Same as TV99 except 25 ft. (7.6m) in length.
Same as TV98 except white.
PH6596
PH6597TV
TV97
PH6619
PH6621
PH6595
PH6597
TV99
TV99W
TV98
TV98W
PH6596
Telephone and Cable TV Devices
PH6619
TV99
TV99W
TV98
TV98W
PH6595
Dimensions in Inches (mm)
www.hubbell-wiring.com
29
Marine Products
Marine Products
30 Ampere, 28 Volt DC Rated
Electric Fishing Reel Devices
Electric Fishing Reel Devices
Hubbell has a DC rated electrical system designed specifically for larger
electric fishing reel systems.
Up until now, larger electric fishing reel systems typically utilized conventional
30 Amp AC rated devices since an appropriately rated DC system was not
available.
HBL328DCR
The system features a corrosion resistant plug, connector body and
receptacle and can be used along with a Hubbell outlet box and weatherproof
cover plate to complete the installation. These devices are all rated at 28 volts
DC and are applicable for all 12, 24 and 32 volt DC fishing reel systems. The
devices are UL listed and CSA certified. All devices are made of high-visibility
yellow nylon that is impact resistant and U. V. stabilized for longer life. Also,
the contacts are nickel plated for corrosion resistance.
Electric Fishing Reel Devices
HBL328DCP
30 Ampere, 28 Volt DC Rated
HBL328DCC
Description
Yellow locking single receptacle with abuse-resistant face.
Can be mounted in Hubbell box HBL6080 and used with
HBL74CM25WOA weatherproof plate.
Yellow locking plug has rugged nylon housing and rear dust
seal to keep dust and foreign matter out.
Yellow locking connector body has rugged, nylon housing
and rear dust seal to keep dust and foreign matter out.
Catalog Numbers
HBL328DCR
HBL328DCP
HBL328DCC
Accessories
Description
Black phenolic type FD (deep) weatherproof box has two
¾ in. (19.1) I.P.S. molded-in knockouts.
4.56 in. H x 2.94 in. W x 3.25 in. D (115.9 x 74.6 x 82.6)
and has 22 cubic inch capacity.
Spring-loaded lift cover, for weatherproofing
HBL328DCR outlet. Yellow in color.
Same as HBL74CM25WOAW except white in color.
Same as HBL74CM25WOAW except gray in color.
Catalog Numbers
HBL6080
HBL74CM25WOA
HBL74CM25WOAW
HBL7425WOA
HBL6080
HBL74CM25WOA
30
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
12 Volt DC Rated Switches
Panel Mount Toggle and Rocker Switches
KEY CHART
M11SP
M11LRGSP
1. Toggle switch
Fits panels up to ¼ in.
thick when not using the
back-up nut provided;
fits panels up to 6QEin.
thick when using the
back-up nut. Requires
a ½ in. mounting hole.
M11LTR
3. Lighted-tip toggle switch
Red pilot light visible in
tip of toggle only. Same
panel specs as 1.
2. Lighted toggle switch
Built-in pilot light
(R=red, G=green) for
night vision. Same
panel specs as 1.
MR11SP
Catalog Numbers
Key
Single pole, single throw.
On/Off.
M11SP
M11LRSP
M11LRGSP
M11LTR
MR11SP
MR11LRSP
1
2
2
3
4
5
Horn, starter, winches,
gauges
Single pole, single throw.
Momentary On/Off.
M11MSP*
M11LTRM
MR11MSP
1
3
4
Bilge pumps, speed selector,
lights, navigation lights
Single pole, double throw.
On/Off/On.
M123SP
M123LTR
MR123SP
MR123LRSP
1
3
4
5
Bilge pumps
Single pole, double throw.
Momentary On/Off/On.
M123MSP
MR123MSP
1
4
Trim Tabs
Single pole, double throw.
Momentary On/Off/Momentary On.
M123MMSP
MR123MMSP
1
4
Lights, accessories
Double pole, single throw.
On/Off.
M21SP
MR21SP
1
4
Navigation lights, wipers,
dual fuel tanks
Double pole, double throw.
On/Off/On.
M223SP
MR223SP
MR223LRSP
1
4
5
Navigation lights, windlass
Double pole, double throw.
On/Off/On (with jumper).
M223JSP
1
Winches, trim tabs,
dual fuel tanks
Double pole, double throw.
Momentary On/Off/Momentary On.
M223MMSP
MR223MMSP
1
4
Provides positive seal against
moisture, oil, etc. Fits any
non-lighted toggle switch.
Black silicone rubber boot bonded
to brass nut.
MSB1
For remote operation of horn.
Push-button horn switch with 56:O in.
long nickel plated brass mounting stem.
Terminals are .25 in. spade.
MH11
Fits MH11 horn switch.
Black push-button (horn) boot.
MHB11
M223SP
MH11
MHB11
Dimensions in Inches (mm)
www.hubbell-wiring.com
31
12 Volt DC Rated Switches
Description
Lights, bilge blower, bilge
pump(s), accessories
M21SP
MSB1
5. Lighted rocker switch
Built-in pilot light for
night vision. Same
panel specs as 4.
Typical Applications
M11SP
M123SP
MR123LRSP
4. Rocker switch
Requires a 1½ in. high
x (6 in. wide rectangular
opening.
Marine Products
Marine Products
15 Ampere, 125 Volt AC Twist-Lock® Devices
2 Pole 3 Wire
15A 125V AC
Twist-Lock®
15A 125V
NEMA L5-15R
UL/CSA
Devices
Description
Yellow duplex receptacle has heat resistant body. IP20 SUITABILITY.
HBL47CM00
15 Ampere, 125 Volt AC Twist-Lock® Devices
HBL52CM21
HBL47CM20C
Catalog Numbers
HBL47CM00
Yellow Valox® spring-loaded lift cover for weatherproofing
duplex receptacles. Stainless steel screws and neoprene gasket
included for mounting to FS/FD type weatherproof boxes.
IP20 SUITABILITY.
Same as HBL52CM21 except white in color.
HBL52CM21
Same as HBL52CM21 except gray in color.
Same as HBL52CM21 except for mounting to standard boxes.
Same as HBL52CM22 except gray in color.
Yellow Insulgrip® plug has rugged nylon housing and detachable
cord grip with range of .30–.69 in. (7.5–17.4) that utilizes a unique
offset jaws arrangement to provide secure strain relief.
Short yellow Seal-Tite® cover for weatherproofing HBL47CM20C
Insulgrip plug when used with receptacles or connector bodies.
Also can be used to weatherproof HBL47CM29C Insulgrip
connector body when used with HBL47CM16 flanged inlet.
IP55 SUITABILITY.
Yellow Insulgrip connector body has rugged nylon housing and
detachable cord grip with range of .30–.69 in. (7.5–17.4) that
utilizes a unique offset jaws arrangement to provide secure
strain relief.
Yellow Seal-Tite cover for weatherproofing HBL47CM29C
Insulgrip connector body when used on extension cords and
adapters. IP20 SUITABILITY.
Panel mount flanged outlet has heat resistant melamine interior
and stainless steel casing. IP20 SUITABILITY.
Panel mount flanged inlet has heat resistant melamine interior
and stainless steel casing. IP20 SUITABILITY.
Three conductor, #14 AWG type STW, yellow PVC jacketed
portable cord has jute fillers for added flexibility and is ideal for
making cable sets, extension cords and adapters as it will not
mark the boat’s deck. Available in 250 ft. (76.2m) length only.
HBL5221
HBL52CM22
HBL5222
HBL52CM21W
HBL47CM20C
HBL60CM23+
HBL47CM29C
HBL60CM24+
HBL47CM15
HBL47CM16
YC314250
Note: + Boots are not UL listed.
HBL60CM23
HBL47CM29C
HBL47CM15
HBL60CM24
32
HBL47CM16
Valox® is a trademark of SABIC Innovative Plastics, acquired from General Electric Company.
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
15 Ampere, 125 Volt AC Straight Blade Devices
2 Pole 3 Wire
IP20
SUITABILITY
15A 125V
NEMA L5-15R
UL/CSA
15A 125V AC Straight Blade Devices
Description
Yellow single receptacle features Rynite® body and abuse
resistant nylon face.
Yellow corrosion resistant duplex receptacle. Use where
salt or other corrosive elements are a problem.
Same as HBL52CM62 except ivory.
Catalog Numbers
HBL52CM61
Yellow Insulgrip® plug has rugged nylon housing and detachable
cord grip with range of .23–.72 in. (5.8–18.3) that utilizes a unique
offset jaws arrangement for secure strain relief.
Yellow Seal-Tite® cover for weatherproofing straight blade
Insulgrip plugs, HBL52CM66C and HBL53CM66C, when used
with receptacles and connector bodies. Can also be used to
weatherproof Insulgrip connector bodies when mating with
flanged inlets. IP55 SUITABILITY. Not UL or CSA.
Note: For Insulgrip® devices only.
Yellow Insulgrip connector body has rugged nylon housing and
detachable cord grip with range of .23–.72 in. (5.8–18.3) that
utilizes a unique offset jaws arrangement for secure strain relief.
Yellow Seal-Tite cover for weatherproofing straight blade
Insulgrip connector bodies, HBL52CM69C and HBL53CM69C,
on extension cords and adapters. IP55 SUITABILITY. Not UL or CSA.
Note: For Insulgrip devices only.
Yellow Valise® plug has one-piece nylon housing that assembles
easily with two screws. Built-in cord grip has range of .22–.66 in.
(5.6–16.8).
Yellow Valise connector body has one-piece nylon housing that
assembles easily with two screws. Built-in cord grip has range of
.22–.66 in. (5.6–16.8).
Yellow Insulgrip® plug with anchor locking screw to prevent
accidental pull-out. The plug is “locked” into the receptacle when
the screw is turned down so the head is flush with the plug
surface. The cord grip range is .30–.69 in. (7.5–17.4).
UL Recognized Component.
Compact gray nylon panel mount inlet ideal for bass boat battery
charging connection. Has gasketed spring-loaded lift cover for
weatherproofing front and neoprene boot for weatherproofing rear.
Will accept both 15A 125V and 20A 125V 2 pole 3 wire straight
blade connector bodies.
Same as HBL61CM64 except black in color.
Yellow Valox® spring-loaded lift cover for weatherproofing
duplex receptacles. Stainless steel screws and neoprene
gasket included for mounting to FS/FD type weatherproof boxes.
Same as HBL52CM21 except gray in color.
Same as HBL52CM21 except for mounting to standard boxes.
Same as HBL52CM22 except gray in color.
Yellow Valox spring-loaded lift cover for weatherproofing
single straight blade receptacles. Stainless steel screws and
neoprene gasket included. For mounting to FS/FD type
weatherproof boxes. IP44 SUITABILITY.
Same as HBL74CM23WO except gray in color.
Note: + Boots are not UL listed.
* Refer to page iv for TR and WR descriptions.
HBL52CM66C
HBL52CM62
*
HBL52CM62I
*
HBL52CM61
HBL52CM62
HBL60CM17+
HBL52CM66C
HBL52CM69C
HBL60CM18+
HBL52CM69C
HBL52CM66V
HBL52CM80C
HBL52CM66V
HBL61CM64
HBL52CM69V
HBL61CM64BK
HBL52CM21
HBL5221
HBL52CM22
HBL5222
HBL74CM23WO
HBL52CM80C
HBL7423WO
HBL74CM23WO
Rynite is a registered trademark of E. I. DuPont.
Valoxx® is a trademark of SABIC Innovative Plastics, acquired from General Electric Company.
®
Dimensions in Inches (mm)
www.hubbell-wiring.com
HBL61CM64
33
15 Ampere, 125 Volt AC Straight Blade Devices
HBL52CM69V
Marine Products
Marine Products
20 Ampere, 125 Volt Twist-Lock® Devices
Plugs, receptacles and
connectors only.
2 Pole 3 Wire
W
G
20A 125V
NEMA L5-20R
UL/CSA
20A 125V Twist-Lock® Devices
HBL23CM10
20 Ampere, 125 Volt Twist-Lock® Devices
HBL74CM25WOA
HBL23CM11
HBL60CM31
HBL26CM13
Description
Yellow single receptacle has Rynite® body and abuse resistant nylon face.
IP20 SUITABILITY.
Yellow polycarbonate spring-loaded lift cover for weather-proofing
HBL23CM10 receptacle. Meets the most stringent requirements of UL’s
three listing categories for weatherproof plates. Stainless steel screws and
neoprene gasket included for mounting to FS/FD type weatherproof boxes.
IP44 SUITABILITY.
Same as HBL74CM25WOA except gray in color.
Same as HBL74CM25WOA except white in color.
Yellow Insulgrip® plug has rugged nylon housing and cord grip with range of
.36–.93 in. (9–24) that utilizes a unique offset jaws arrangement to provide
secure strain relief. IP20 SUITABILITY.
Yellow Seal-Tite® cover for weatherproofing HBL26CM11 or HBL23CM11
plugs. IP55 SUITABILITY. Note: Fits Insulgrip devices only.
Same as HBL60CM31 except white in color.
Yellow Insulgrip connector body has rugged nylon housing and cord
with range of .36–.93 in. (9–24) that utilizes a unique offset jaws
arrangement to provide secure strain relief. IP20 SUITABILITY.
Yellow Seal-Tite cover for weatherproofing HBL26CM13 or HBL23CM13
connector bodies when used on extension cords or adapters.
IP55 SUITABILITY. Note: Fits Insulgrip devices only.
Yellow vinyl Seal-Tite cover for weatherproofing HBL23CM13V or
HBL26CM13V connector bodies. IP55 SUITABILITY.
Note: Fits Valise® devices only.
Yellow Valise plug has one-piece nylon housing, assembles easily with
two screws. Built-in cord grip has range of .33–.72 in. (8.3–18.2).
IP20 SUITABILITY.
Yellow Seal-Tite cover for weatherproofing HBL23CM11V or
HBL26CM11V plugs. IP55 SUITABILITY. Note: Fits Valise devices only.
Three conductor, #12 AWG type STW, yellow PVC jacketed portable cord
with jute fillers for added flexibility. Ideal for making cable sets, extension
cords and adapters as will not mark boat’s deck. Available in 250 ft. (76.2m)
length only.
Note: + Boots are not UL listed.
Catalog Numbers
HBL23CM10
HBL74CM25WOA
HBL7425WOA
HBL74CM25WOAW
HBL23CM11
HBL60CM31+
HBL60CM31W+
HBL23CM13
HBL60CM32+
HBL60CM32V+
HBL23CM11V
HBL60CM31V+
YC312250
HBL60CM32
HBL23CM11V
HBL60CM32V
HBL60CM31V
Rynite® is a registered trademark of E. I. DuPont.
34
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
20 Ampere, 125 Volt AC Straight Blade Devices
2 Pole 3 Wire
20A 125V
NEMA L5-20R
UL/CSA
20A 125V AC Straight Blade Devices
Catalog Numbers
HBL53CM66C
HBL53CM66C
HBL53CM69C
HBL60CM18+
HBL60CM19+
HBL60CM17+
HBL53CM69C
HBL53CM62
HBL53CM61
HBL61CM65
HBL60CM18
HBL60CM19
HBL52CM21
HBL52CM21W
HBL5221
HBL52CM22
HBL5222
HBL74CM23WO
HBL60CM17
HBL7423WO
HBL53CM62
HBL52CM21
HBL74CM23WO
Rynite® is a registered trademark of E. I. DuPont.
Dimensions in Inches (mm)
HBL61CM65
HBL53CM61
www.hubbell-wiring.com
35
20 Ampere, 125 Volt AC Straight Blade Devices
Description
Yellow Insulgrip® plug has rugged nylon housing and detachable cord
grip with range of .23–.72 in. (5.8–18.3) that utilizes unique offset jaws
arrangement to provide secure strain relief. IP20 SUITABILITY.
Yellow Insulgrip connector body has rugged nylon housing and cord
grip with range of .23–.72 in. (5.8–18.3) that utilizes unique offset jaws
arrangement for secure strain relief. IP20 SUITABILITY.
Yellow Seal-Tite® cover for weatherproofing straight blade Insulgrip
connector bodies, HBL52CM69C and HBL53CM69C, on extension
cords and adapters. IP55 SUITABILITY. Note: For Insulgrip devices only.
Yellow closure plug used with HBL60CM18 long Seal-Tite cover to
prevent water from entering front of device when not in use. IP55 SUITABILITY.
Yellow Seal-Tite cover for weatherproofing straight blade Insulgrip® plugs,
HBL52CM66C and HBL53CM66C, when used to mate receptacles and
connector bodies. Can also be used with Insulgrip connector bodies when
mating with flanged inlets. IP55 SUITABILITY. Note: For Insulgrip devices only.
Yellow duplex receptacle has Rynite® body. Receptacle accepts both 20A
125V and 15A 125V 2 pole 3 wire straight blade plugs. IP20 SUITABILITY.
Single version of HBL53CM62 duplex yellow receptacle. IP20 SUITABILITY.
Compact gray nylon panel mount outlet ideal for electric trolling motors
and reel applications. Features gasketed spring-loaded lift cover for
weatherproofing front and neoprene boot for weatherproofing rear.
Accepts both 20A 125V and 15A 125V 2 pole 3 wire straight blade plugs.
IP55 SUITABILITY.
Yellow polycarbonate spring-loaded lift cover for weatherproofing
duplex receptacles. Stainless steel screws and neoprene gasket included
for mounting to FS/FD type weatherproof boxes. IP20 SUITABILITY. Not CSA.
Same as HBL52CM21 except white in color.
Same as HBL52CM21 except gray in color.
Same as HBL52CM21 except for mounting to standard boxes.
Same as HBL52CM22 except gray in color.
Yellow polycarbonate spring-loaded lift cover for weatherproofing
single straight blade receptacles. Stainless steel screws and neoprene
gasket included. For mounting to FS/FD type weatherproof boxes.
IP44 SUITABILITY. Not CSA.
Same as HBL74CM23WO except gray in color.
Note: + Boots are not UL listed.
Marine Products
Marine Products
Portable Ground Fault Circuit Interrupters and Testers
Portable Ground Fault Circuit Interrupters (GFCIs)
These UL Listed portable GFCIs have been designed to protect people
from line-to-ground electrical shock hazards which may develop from faulty
appliance, tools or defective portable cords. If a ground fault does occur and the
leakage level exceeds 4 to 6 milliamperes, the GFCI unit quickly acts to protect
the user by opening the circuit, thus interrupting the power supply and limiting
the duration of any electrical current flow. After tripping, the module is reset by
pushing a button on its face. A test button allows the user to test that the GFCI
is in working order.
GFP15M
Note: GFCI devices will not protect against overloads or short circuits.
Portable Ground Fault Circuit Interrupters and Testers
Portable Ground Fault Circuit Interrupters and Testers
GFT2G
HBL5200
GFP315A
Description
This unit is small and compact—measuring only 4.19 in. H x 5.19 in. L
x 6.69 in. W (10.6cm x 13.2cm x 17.0cm) and weighing only
3 pounds—yet protects as many as four tools at one time.
The housing is high-impact yellow polycarbonate as are the
liftcovers which protect the receptacles from dirt and damage.
Simply insert the plug on the end of the 6 foot (1.8m) cord into any
60Hz 120V receptacle and then plug the equipment to be used
into one of the receptacles on the unit. Incorporates a 20 Amp
GFCI module that can be replaced in the field. The module
provides not only ground fault protection, but also contains the
no voltage release feature.
3-outlet plug-in unit. Plugs into boat convenience receptacles
to provide ground fault protection.
This unit is designed to measure the trip level of GFCI portables,
receptacles, or breakers within any range from 2 to 7 milliamperes,
or the leakage in portable tools or appliances within a leakage
range of 1 to 7 milliamperes. It can be used on any AC circuit of
110 to 130V.
Catalog Numbers
GFP15M
This outlet circuit tester has a simple arrangement of neon lights
which visually indicate correct wiring, reversed polarity, open
ground wire, open neutral wire, open hot wire, hot and ground
reversed and hot wire on neutral terminal, and hot terminal unwired.
Simply plug the HBL5200 into a single phase 125V 2 pole 3 wire
outlet and the combination of lighted and/or unlighted lamps will
immediately indicate the condition of the circuit. The instructions
and symbol identification are printed on durable polyester labels
permanently attached to the tester. To test other 2 pole 3 wire single
phase 125V outlets, use one of the proper adapters shown on
pages 26 and 27.
HBL5200
GFCI Line Cord Devices
Ideal for personal plug-in protection at marinas
and onboard boats when used with pumps,
drills, sanders and all portable electrical
equipment. GFCI mechanism is watertight
and approved for outdoor use. High visibility
yellow SJTW-A power cord resists moisture,
chemicals and sunlight.
Two different lengths available.
GFP315A
GFT2G
GFCI Specifications
Rating: 15A 120V 60Hz 2 pole 3 wire
straight blade
Trip Level: 4-6 milliamperes
Trip Time: .025 seconds nominal
Frequency: 60 Hertz nominal
Voltage: 120 volts +10%, -15%
Max Interrupting Capacity: 2,000 amperes
Max Humidity: 95%
UL Class A
GFP6C15M 6 ft. (1.8m) line cord
GFP25C15M 25 ft. (7.6m) line cord
GFP6C15M
GFP25C15M
36
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
GFCI and Surge Protection Receptacles
Inside the Boat
The American Boat and Yacht Council recommends the use of ground fault
protected receptacles in a head, galley, machinery space or on a weather deck.
Refer to ABYC “Ground Fault Protection”.
Ground Fault Circuit Interrupter (GFCI) Receptacles
These UL Listed receptacles have been designed to protect people from lineto-ground electrical shock hazards which may develop from faulty appliance,
tools or defective portable cords. If a ground fault does occur and the leakage
level exceeds 4 to 6 milliamperes, the GFCI unit quickly acts to protect the
user by opening the circuit, thus interrupting the power supply and limiting
the duration of any electrical current flow. After tripping, the receptacle is reset
by pushing a button on its face. A test button allows the user to test that the
GFCI is in working order.
GFR5252MW
Note: All Hubbell GFCI receptacles are in compliance with new UL 943 Mandate.
GFCI receptacles will not protect against overloads or short circuits.
Due to 2006 UL 943 revisions, Hubbell Marine Ground Fault Receptacles
now come with an LED that will flash if the receptacle is no longer capable
of providing GFCI protection. This can occur due to power surges and/or
lightning in the area. The new design will also prevent power going to the
face when mis-wired.
Hubbell’s GFCI receptacles can be mounted on any standard 2.50 inch (63.5)
deep box. A feed-thru feature provides protection not only at that receptacle
but also at any other receptacle located downstream from it on the same circuit.
These devices meet the requirements of The National Electric Code (NEC)
and American Boat and Yacht Council Standard and will accept locking fork
terminals. Ground Fault Receptacles are also available for OEM applications.
Devices rated for 15A and 20A are available in brown, ivory, gray and white.
Consult factory for details.
Close-Up View of
Open Terminals
GFCI Receptacles and Surge Suppression Receptacles
Description
15A 125V brown GFCI duplex receptacle. Brown nylon
wall plate included.
Same as GFR5252M except receptacle and plate are ivory.
Same as GFR5252M except receptacle and plate are white.
Catalog Numbers
GFR5252M
Same as GFR5252M except receptacle and plate are gray.
GFR5252MGY
Gray PVC weatherproof lift cover for ground fault receptacles
(such as GFR5252M series) and Style Line® receptacles.
For vertical mounting in standard or FS/FD type boxes.
CWP26CR
Same as CWP26CR except white.
Ivory duplex surge suppression receptacle with power on
indicator light and damage-alert alarm beeper.
CWP26CRW
HBL5262ISA
GFR5252MI
GFR5252MW
Surge suppression receptacles 15A 125V AC Nominal. UL Listed at 400V
voltage protection level. Suitable for ANSI/IEEE C 62.41-installation categories
“A” (outlets and long branch circuits) and “B” (major feeders and short
branch circuits). The Hubbell Surge Suppression Receptacle helps protect
your electronic equipment from damage caused by transient voltages.
The receptacle contains metal oxide varisters which dissipate the electrical
energy of voltage spikes without interfering with normal operations.
Dimensions in Inches (mm)
www.hubbell-wiring.com
CWP26CR
HBL5262ISA
37
GFCI and Surge Protection Receptacles
Caution: Ground Fault Receptacles should not be mounted in locations exposed
to salt spray nor in the engine room. For GFCI protection of such locations,
downstream feeding from an internally located Ground Fault Receptacle is
recommended.
Marine Products
Marine Products
RoHS
Receptacles
15 and 20 Ampere, 125V AC
Style Line® Decorator Receptacles
High-impact nylon face resists breaking, chipping and cracking.
Will accept locking fork terminal to comply with ABYC standards.
Available in 4 colors for any decor with matching wall plates.
Smooth, high-gloss finish for rich appearance.
*
*
Commercial Style Line® Decorator Series
DR15WHITR
Description
15A 125V duplex
receptacle.
Color
Almond
Black
Brown
Gray
Ivory
Light Almond
Office White
White
Standard
Duplex
DR15AL
DR15BLK
DR15
DR15GRY
DR15I
DR15LA
DR15OW
DR15WHI
Duplex Tamper
Resistant
DR15ALTR
DR15BLKTR
DR15TR
DR15GRYTR
DR15ITR
DR15LATR
–
DR15WHITR
Duplex Weather
and Tamper
Resistant
DR15ALWRTR
DR15BLKWRTR
DR15WRTR
DR15GRYWRTR
DR15IWRTR
DR15LAWRTR
–
DR15WHIWRTR
Duplex Tamper
Resistant
Duplex Side and
Back Wired,
Weather and
Tamper Resistant
Commercial Series
CR15
CR15TR
Description
Color
Standard
Duplex Spec
Grade Side
Wired
15A 125V duplex
receptacle.
Almond
CR15AL
CR15ALTR
BR15ALWRTR
Black
CR15BLK
CR15BLKTR
BR15BLKWRTR
Brown
CR15
CR15TR
BR15WRTR
Gray
CR15GRY
CR15GRYTR
BR15GRYWRTR
Ivory
CR15I
CR15ITR
BR15IWRTR
Light Almond
CR15LA
CR15LATR
BR15LAWRTR
Office White
CR15OW
DR15GRYWRTR
BR15IWR
–
–
White
CR15WHI
CR15WHITR
BR15WHIWRTR
Notes: All devices above will accept locking fork terminal to comply with ABYC standards.
* Refer to page iv for TR and WR descriptions.
*
Extra Heavy Duty Single Receptacles
Description
15A 125V single receptacle.
20A 125V single receptacle.
HBL5251
HBL5361I
Color
Brown
Ivory
Brown
Ivory
Catalog Numbers
HBL5251
HBL5251I
HBL5361
HBL5361I
*
Receptacles
Corrosion Resistant Receptacles
Description
15A 125V yellow corrosion resistant duplex receptacle.
Use where salt or other corrosive elements are a problem.
Same as HBL52CM62 except ivory.
Catalog Numbers
HBL52CM62
HBL52CM62I
Special Application Illuminated Receptacle
HBL52CM62I
38
HBL8200ILI
Description
Illuminated receptacle 15A 125V grounding. A high qualityy
receptacle with an illuminated face. Ideal for use in halls or
as a gentle night light.
www.hubbell-wiring.com
Catalog Numbers
HBL8200ILI
Dimensions in Inches (mm)
RoHS
Switches and Weatherproof Switch Plates
15 and 20 Ampere, 120-277V AC
Commercial Series
Description
15A single-pole toggle switch for controlling
Handle Color
Almond
Catalog Numbers
CS115AL
AC load from one point.
Brown
Gray
Ivory
CS115
CS115GY
CS115I
Light Almond
Office White
CS115LA
CS115OW
White
Almond
Brown
CS115W
CS315AL
CS315
Gray
Ivory
Light Almond
CS315GY
CS315I
CS315LA
Office White
White
CS315OW
CS315W
15A three-way toggle switch for controlling
AC load from two points.
Marine Products
Marine Products
CS115I
Note: All devices above will accept locking fork terminal to comply with ABYC standards.
Special Application Series
HBL1281
HBL1283
HBL17CM50
HBL1795
HBL1221PL
HBL1223PL
HBL1281
HBL1281I
HBL1283†
HBL1283I†
HBL17CM50†
Clear silicone rubber weatherproof bubble plate for use with all
AC toggle switches and PresSwitches. Also ideal for use with
lighted handle toggle switches. Not CSA.
HBL1795
†Not
HBL1221PL
HBL1223IL
Yellow neoprene weatherproof plate for use only with PresSwitches.
PresSwitch button is activated when bubble is pressed. Not CSA.
Note:
HBL1221IL
Catalog Numbers
HBL1221IL
UL Listed.
Outlet Box
Description
Plastic switch/receptacle box.
Measures 3.281" x 2.188" x 2.50" (83.3 x 55.6 x 63.5) deep.
For mounting in walls without studs. A support strap is provided
which pulls box tightly against back side of wall. Not CSA.
Catalog Numbers
HBL6079
HBL6079
Dimensions in Inches (mm)
www.hubbell-wiring.com
39
Switches and Weatherproof Switch Plates
Description
20A 120V toggle switch with neon lamp set in ivory handle.
Handle illuminates when switch is in “OFF” position.
20A 120V three-way toggle switch with illuminated ivory handle for
controlling AC load from two points. Handle illuminates when “OFF”.
20A 120V single-pole toggle switch with neon lamp set in clear
red handle. Handle illuminates when switch is “ON”. Serves as
instant reminder that current is flowing to an appliance.
20A 120V three-way toggle switch for controlling AC load from two
points. Red handle illuminates when “ON”.
Single-pole PresSwitch® for controlling AC load from one point.
Switch activated brown button.
Same as HBL1281 except ivory button.
Three-way PresSwitch® for controlling AC load from two points.
Switch activated brown button.
Same as HBL1283 except ivory button.
• Nylon plates—virtually unbreakable.
• Rounded corners for stylish look.
• Reinforced ribs for extra strength.
• Screws are factory-inserted for fumble-free installation.
Wallplates
Inside the Boat
Color
Smooth Nylon
Standard
Mid-Size
Smooth Metal
Material
1-Gang,
1-Toggle
Black
Brown
Gray
Ivory
White
NP1BK
NP1
NP1GY
NP1I
NP1W
NPJ1BK
NPJ1
NPJ1GY
NPJ1I
NPJ1W
Brass
Stainless Steel
SB1
SS1
1-Gang,
1-Duplex
Black
Brown
Gray
Ivory
White
NP8BK
NP8
NP8GY
NP8I
NP8W
NPJ8BK
NPJ8
NPJ8GY
NPJ8I
NPJ8W
Brass
Stainless Steel
SB8
SS8
1-Gang,
1-Decorator
Black
Brown
Gray
Ivory
White
NP26BK
NP26
NP26GY
NP26I
NP26W
NPJ26BK
NPJ26
NPJ26GY
NPJ26I
NPJ26W
Brass
Stainless Steel
SB26
SS26
2-Gang,
2-Toggle
Black
Brown
Gray
Ivory
White
NP2BK
NP2
NP2GY
NP2I
NP2W
NPJ2BK
NPJ2
NPJ2GY
NPJ2I
NPJ2W
Brass
Stainless Steel
SB2
SS2
2-Gang,
2-Duplex
Black
Brown
Gray
Ivory
White
NP82BK
NP82
NP82GY
NP82I
NP82W
NPJ82BK
NPJ82
NPJ82GY
NPJ82I
NPJ82W
Brass
Stainless Steel
SB82
SS82
2-Gang,
2-Decorator
Black
Brown
Gray
Ivory
White
NP262BK
NP262
NP262GY
NP262I
NP262W
NPJ262BK
NPJ262
NPJ262GY
NPJ262I
NPJ262W
Brass
Stainless Steel
SB262
SS262
2-Gang,
1-Toggle,
1-Duplex
Black
Brown
Gray
Ivory
White
NP18BK
NP18
NP18GY
NP18I
NP18W
NPJ18BK
NPJ18
NPJ18GY
NPJ18I
NPJ18W
Brass
Stainless Steel
SB18
SS18
2-Gang,
1-Toggle,
1-Decorator
Black
Brown
Gray
Ivory
White
NP126BK
NP126
NP126GY
NP126I
NP126W
NPJ126BK
NPJ126
NPJ126GY
NPJ126I
NPJ126W
Brass
Stainless Steel
SB126
SS126
1-Gang,
1-Single
1.40" Dia. Hole
Black
Brown
Gray
Ivory
White
NP7BK
NP7
NP7GY
NP7I
NP7W
NPJ7BK
NPJ7
NPJ7GY
NPJ7I
NPJ7W
Brass
Stainless Steel
SB7
SS7
1-Gang,
1-Blank,
Box Mount
Black
Brown
Gray
Ivory
White
NP13BK
NP13
NP13GY
NP13I
NP13W
NPJ13BK
NPJ13
NPJ13GY
NPJ13I
NPJ13W
Brass
Stainless Steel
SB13
SS13
Description
Wallplates
Marine Products
Marine Products
40
www.hubbell-wiring.com
Catalog Numbers
Dimensions in Inches (mm)
Marine Products
Marine Products
Communication Frames and Connectors
Hubbell now offers the ability to put 2 or 3 communication devices in a single, Style Line® plate.
Any combination of phone (6-position jack), cable TV (F-type connector) and Category 5e modular data jacks
can be assembled onto a 2-port or 3-port frame—each sold individually so you can customize them as needed.
Or the highly popular phone and cable TV combination is available with the frame and matching
wallplate under a single catalog number, in all the popular colors.
Finally—a single communications plate that can take the place of 2 or 3 plates—available
from a company you can trust for superior quality.
Hubbell’s Marine communication frames and connectors deliver high quality data and
multimedia transmission to the point of connection. Hubbell’s 2 and 3 port Style Line
frames and leading edge connections allow for customized configurations. Install
Hubbell’s Marine communication offering and be assured a reliable connection.
2 Port Communication Frame, Fully Loaded (6-Position Phone Jack,
F-Type
yp Cable TV Jack and Style
y Line® Plate Included))
Color
Ivory
White
No. of Ports
2
2
Connection Type
USOC, F-Type
USOC, F-Type
Catalog Numbers
NS783I
NS783W
NS783I
Style
y Line® Frames, 2 Port and 3 Port Unloaded
Color
Black
Gray
Ivory
White
Black
Gray
Ivory
White
No. of Ports
2
2
2
2
3
3
3
3
Connection Type
–
–
–
–
–
–
–
–
Catalog Numbers
NS612BK
NS612GY
NS612I
NS612W
NS613BK
NS613GY
NS613I
NS613W
NS612I
Category
g y 6 Modular Keystone
y
Jacks
Wiring
T568A/T568B
T568A/T568B
T568A/T568B
T568A/T568B
No. Positions
8-Positions
8-Positions
8-Positions
8-Positions
Catalog Numbers
NSJ6BK
NSJ6GY
NSJ6I
NSJ6W
NS613I
Category
g y 5e Modular Keystone
y
Jacks
Color
Black
Gray
Ivory
White
Wiring
T568A/T568B
T568A/T568B
T568A/T568B
T568A/T568B
No. Positions
8-Positions
8-Positions
8-Positions
8-Positions
Catalog Numbers
NSJ5EBK
NSJ5EGY
NSJ5EI
NSJ5EW
NSJ6W
USOC Modular Keystone
y
Jacks
Color
Black
Gray
Ivory
White
Wiring
USOC
USOC
USOC
USOC
No. Positions
6-Positions
6-Positions
6-Positions
6-Positions
NSJ5EW
Catalog Numbers
NSJUBK
NSJUGY
NSJUI
NSJUW
NSJUW
F-Type
yp Connector Keystone
y
Color
Black
Gray
Ivory
White
Dimensions in Inches (mm)
Catalog Numbers
SFFGBK
SFFGGY
SFFGEI
SFFGW
www.hubbell-wiring.com
SFFGEI
41
Communication Frames and Connectors
Color
Black
Gray
Ivory
White
Marine Products
Marine Products
Boatyard Accessory Items
Marine Grade Outlet Box Hoods
IP66
SUITABILITY
Enclosures only.
Marine Grade Outlet Box Hoods
Description
Color
Mounting
Catalog Numbers
Standard Cover, 1-Gang,
For Duplex, GFCI, Toggle and Single Receptacles,
Diameter 1.34, 1.40, 1.60, 1.72, 2.03 and 2.15 inch
Gray
Horizontal
or Vertical
RW57500
Deep Cover, 1-Gang,
For Duplex, GFCI, Toggle and Single Receptacles,
Diameter 1.34, 1.40, 1.60, 1.72, 2.03 and 2.15 inch
Gray
Horizontal
or Vertical
RW57600
Deep Cover, 2-Gang,
For Single Receptacles,
Diameter 1.34, 1.40, 1.60, 1.72, 2.03 and 2.15 inch
Gray
Vertical
RW57950
RW57500
RW57600
Boatyard Accessory Items
RW57950
HBL6085
Nylon Watertight Strain Relief Cord Connectors
These Hubbell nylon cord connectors provide strain relief and a watertight seal
where cable enters a piece of equipment, panel, or box. A patented GOTCHA®
ring, with a split and hinge design, allows for better adjustment to the cord as the
connector nut is tightened, providing superior cord gripping compared to other
types. A soft neoprene bushing compresses to keep liquids out and allows the nut
to be easily tightened.
Description
A gray male PVC adapter with ¾ in. N.P.T. pipe thread for adapting
PVC conduit to FS and FD boxes with ¾ in. N.P.T. hub (HBL6080,
HBL6080OS, HBL60CM83). Not UL Listed.
Catalog Numbers
HBL6085
Straight nylon cord connector, ½ in. N.P.T. hub size, diameter range
.25–.38 in. (6.4–9.5).
HBL10CM22S
Straight nylon cord connector, ½ in. N.P.T. hub size, diameter range
.38–.50 in. (9.5–12.7).
HBL10CM23S
Straight nylon cord connector, ¾ in. N.P.T. hub size, diameter range
.38–.50 in. (9.5–12.7).
HBL10CM35S
Straight nylon cord connector, ¾ in. N.P.T. hub size, diameter range
.50–.63 in. (12.7–15.9).
HBL10CM36S
Straight nylon cord connector, ¾" N.P.T. hub size, diameter range
.63–.75 in. (15.9-19.1).
HBL10CM37S
Straight nylon cord connector, 1.0 in. N.P.T. hub size, diameter range
.63–.75 in. (15.9-19.1).
HBL10CM41S
HBL 0CM22S
HBL10CM22S
42
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
Boatyard Accessory Items
Marine Grade Lift Covers
Marine Grade Weatherproof Plates
Description
Yellow Valox® spring-loaded lift cover for weatherproofing duplex
receptacles. Stainless steel screws and neoprene gasket included for
mounting to FS/FD type weatherproof boxes. IP20 SUITABILITY.
Same as HBL52CM21 except white in color.
Catalog Numbers
HBL52CM21
Same as HBL52CM21 except gray in color.
Same as HBL52CM21 except for mounting to standard boxes.
Same as HBL52CM22 except gray in color.
HBL5221
HBL52CM22
HBL5222
Yellow Valox spring-loaded lift cover for weatherproofing single
straight blade receptacles. Stainless steel screws and neoprene gasket
included. For mounting to FS/FD type weatherproof boxes. IP44 SUITABILITY.
HBL74CM23WO
Same as HBL74CM23WO except gray in color.
HBL7423WO
Yellow Valox spring-loaded lift cover for weatherproofing old
style 26CM10 receptacle. Meets the most stringent requirements
of UL’s three listing categories for weatherproof plates. Stainless steel
screws and neoprene gasket included for mounting to FS/FD type
weatherproof boxes. IP44 SUITABILITY.
Same as HBL74CM24WO except gray in color.
Yellow Valox spring-loaded lift cover for weatherproofing
HBL26CM10 receptacle. Meets the most stringent requirements
of UL’s three listing categories for weatherproof plates. Stainless
steel screws and neoprene gasket included for mounting to
FS/FD type weatherproof boxes. IP44 SUITABILITY.
Same as HBL74CM25WOA except white in color.
Same as HBL74CM25WOA except gray in color.
Yellow Valox lift cover for weatherproofing 50A receptacles.
Meets requirements of the most stringent of UL’s three listing
categories for weatherproof plates. Stainless steel screws and
a neoprene gasket included. For mounting to FS/FD type
weatherproof boxes. IP44 SUITABILITY.
Same as HBL77CM74WO except gray in color.
HBL74CM24WO
HBL52CM21W
HBL52CM21
HBL74CM23WO
HBL7424WO
HBL74CM25WOA
HBL74CM25WOAW
HBL7425WOA
HBL77CM74WO
HBL77CM74WO
CWP1CR
HBL7774WO
Commercial Grade Weatherproof Plates
Available in a host of configurations—Twist-Lock® and straight blade receptacles
in single or duplex as well as switches—these plates are perfect for marine use.
The PVC resists deterioration over time and has high tensile and impact strength.
Each plate comes with a tightly sealing, rubberized gasket and a super strong lift
cover spring.
CWP8CR
Description
Gray PVC weatherproof lift cover for toggle switches (such as CS115).
For vertical mounting in standard or FS/FD type boxes.
Catalog Numbers
CWP1CR
Gray PVC weatherproof lift cover for duplex receptacles (such as
HBL52CM62). For vertical mounting in standard or FS/FD type boxes.
Gray PVC weatherproof lift cover for ground fault receptacles (such as
GF5252MGYA) and Style Line® receptacles. For vertical mounting in
standard or FS/FD type boxes.
CWP8CR
Same as CWP26CR except white in color.
CWP26CRW
CWP26CR
CWP26CR
Valox® is a trademark of SABIC Innovative Plastics, acquired from General Electric Company.
Dimensions in Inches (mm)
www.hubbell-wiring.com
43
Boatyard Accessory Items
Commercial Grade Weatherproof Plates
Marine Products
Marine Products
Boatyard Accessory Items
Marine Grade Dockside Boxes and Covers
Marine Grade Dockside Boxes and Covers
HBL6080
HBL60CM83
Description
Black phenolic type FD (deep) weatherproof box has two
¾ in. (19.1) I.P.S. molded-in knockouts. 4.56 in. H x 2.94 in. W x 3.25 in. D
(115.9H x 74.6W x 82.6D) and has 22 cubic inch capacity.
Catalog Numbers
HBL6080
Yellow fiberglass type FD (deep) weatherproof box has two
¾ in. (19.1) I.P.S. molded-in knockouts. 4.56 in. H x 2.94 in. W x 3.25 in. D
(115.9H x 74.6W x 82.6D) and has 22 cubic inch capacity.
Yellow fiberglass type FD box same as HBL60CM83 - except
has two 1.0 inch (25.4) I.P.S. molded-in knockouts.
Black phenolic type FS (shallow) weatherproof box has two
¾ in. (19.1) I.P.S. molded-in knockouts. 4.56 in. H x 2.94 in. W x 2.19 in. D
(115.9H x 74.6W x 55.6D) and has 16 cubic inch capacity.
Black non-metallic FS box with ¾ in. threaded hubs used for
mounting phone and TV outlets and PH6595 recreational vehicle
inlet (see PH6621 for mounting box on recreational vehicle).
Cord connector included for strain relief and to maintain watertight
integrity of box when cable is used. PVC adapter also included for
connection of PVC conduit to box.
Black phenolic junction box with four ¾ in. (19.1) I.P.S. molded-in
knock-outs. Has 4.13 in. (104.8) diameter and is 1.88 in. (47.6) deep.
Phenolic blank cover, ¼ in. (6.4) thick, for HBL6081 box.
HBL60CM83
Black phenolic blank cover plate for HBL6080OS.
Yellow Valox® blank cover plate for use with FS and FD type boxes.
HBL60CM84
HBL6080OS
PH6619
HBL6081
HBL6082
HBL6087
HBL60CM88
Boatyard Accessory Items
HBL60CM84
HBL6080OS
HBL6081
PH6619
HBL6082
HBL6087
HBL60CM88
Valox® is a trademark of SABIC Innovative Plastics, acquired from General Electric Company.
44
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Marine Products
Boatyard Accessory Items
Lighting and Lighting Fixtures
Non-Metallic Vapor-tight Incandescent Fixtures
These non-metallic, vapor-tight incandescent fixtures offer long life and troublefree lighting in wet locations in marinas and on boats. Some features of these
new units are:
• UV resistant, gray, glass filled thermoplastic polyester box, mounting
adapters and globe guards resists abuse and harmful effects of the elements.
• Excellent temperature operating range of -40°F (-40°C) to +302°F (150°) for use
in areas with wide temperature variations or extreme ambient
temperatures.
• High temperature silicone gasketing maintains integrity and molded
threads for ease of installation/removal.
• Heat resistant glass globe withstands thermal shock in wet locations and
has thread type mounting to assure weathertight sealing.
• High strength protective globe guard helps prevent accidental globe and
lamp breakage.
• Accommodates Type A incandescent lamps up to 150 watts.
• UL 1598 Standard for luminaries.
• UL 1598A Marine type luminaries.
NVX15GHGA
Lighting and Lighting Fixtures
Description
Catalog Numbers
Ceiling mount non-metallic, vapor-tight incandescent luminaries
including the fixture, mounting box, guard and heat resistant
glass globe. Accepts up to 150 watt Type A incandescent
lamp (not included).
NVX15GHGA
Pendant mount non-metallic, vapor-tight incandescent luminaries
including fixture, mounting cap, guard and heat resistant glass
globe. Accepts up to 150 watt Type A incandescent lamp
(not included).
NVA15GHGA
Wall mount bracket only to adapt NVX15GHGA ceiling mount
fixture to a wall mount fixture. Order NVBA and NVX15GHGA
to get wall mount fixture.
NVBA
Replacement guard to NVX15GHGA and NVA15GHGA.
NVGA
Heat resistant replacement globe for NVX15GHGA and
NVA15GHGA. Made of tempered glass.
VCGP100
NVA15GHGA
NVBA
Boatyard Accessory Items
Dimensions in Inches (mm)
www.hubbell-wiring.com
45
Marine Products
Marine Products
Electrical Standards
Codes and Specifications
ABYC Standard, July 2001, Excerpts.
8.4 DEFINITIONS – For the purposes of this standard, the following
definitions apply.
Ground fault circuit interrupter (GFCI) – A device intended for the protection of
personnel that functions to de-energize a circuit, or portion thereof, within an
established period of time when a current to ground exceeds some predetermined
value that is less than that required to operate the overcurrent protective device of the
supply circuit.
Watertight – So constructed that water will not enter the enclosure under the
test conditions specified in NEMA standard 250.
Weatherproof – Constructed or protected so that exposure to the weather
will not interfere with successful operation.
8.12
8.12.2 GFCI and GFP breakers shall meet the requirements of Underwriters
Laboratories standard UL 943, Ground Fault Circuit Interrupters, and the
requirements of UL 489, Molded Case Circuit Protectors for Circuit Breaker
Enclosures.
8.12.3 GFCI and GFP breakers may be installed as panelboard feeder
breakers to protect all associated circuits or in individual branch circuits.
8.12.4 Single-pole GFCI and GFP breakers shall only be used if:
8.12.4.2 the system uses either a polarization transformer, or
the system is 120/240 volts.
8.12.5 GFCI receptacle devices shall meet the requirements of
Underwriters Laboratories standard UL 943, Ground Fault circuit
Interrupters, and the requirements of UL 498, Electrical Attachment Plugs
and Receptacles.
8.12.6 GFCI receptacle devices may be installed as part of a convenience
outlet installation either in single outlet applications or in multiple feed
through installations. See ABYC E-8.17.8.
Isolation transformer primary main breakers – GFP breakers may
be installed as the main breaker on the primary side of isolation
transformers. See E-8.23, Diagram 8 and Diagram 11. This GFP
breaker will provide ground fault protection only for the primary
winding of the transformer. Protection for circuits supplied by
the secondary winding of the transformer may be provided in
accordance with ABYC E-8.11.4, E-8.11.5, E-8.11.6.3, and
E-8.12.4.
SWITCHES
8.16.1 Switches used in branch circuits shall simultaneously open all
ungrounded conductor(s) of the branch circuit.
Electrical Standards
8.16.2 Switches shall have voltage ratings not less than the system
voltage, current ratings not less than the connected load, and shall be rated
for the type of load, i.e., inductive or resistive.
8.17
8.17.5.1 600 watts for a 15 ampere circuit;
8.17.5.2 1000 watts for a 20 ampere circuit.
8.17.6 Receptacles shall be installed in locations not normally subject
to rain, spray, or flooding, but, if receptacles are used in such areas, the
following shall apply:
8.17.6.1 Receptacles installed in locations subject to rain, spray, or splash
shall be weatherproof as may be provided by a spring loaded, self closing
cover.
8.17.6.2 Receptacles installed in areas subject to flooding or momentary
submersion shall be of a watertight design as may be provided by a
threaded, gasketed cover.
8.17.7 Receptacles provided for the galley shall be located so appliance
cords can be plugged in without crossing a traffic area, galley stove, or sink.
8.17.8 If installed in a head, galley, machinery space, or on a weather deck,
the receptacle shall be protected by a Type A (nominal 4-6 milliamperes)
Ground Fault Circuit Interrupter (GFCI). See ABYC E-8.12.
8.12.4.1 the single phase 120 volt system has a polarity indicator, or
8.16
8.17.5 A branch circuit supplying a combination of receptacle loads and
permanently connected loads shall not supply fixed loads in excess of the
following:
NOTE: Refer to E-8.18.5 for load calculations.
GROUND FAULT PROTECTION
8.12.1 If installed, a ground fault protector (GFP) shall only be used to
protect equipment.
NOTE: A ground fault circuit interrupter (GFCI) may be used on single phase
AC circuits to provide additional protection for personnel
and equipment.
NOTE:
8.17.4 Power wiring for receptacles shall be connected so that the
grounded (white) conductor attaches to the terminal identified by the
word “white" or a light color (normally white or silver). The ungrounded
conductors(s) shall be attached to the terminal(s) identified by a dark color
(normally brass or copper) and, optionally, the letters X, Y, and Z or L1, L2,
and L3.
RECEPTACLES
8.17.1 Receptacles shall be installed in boxes that meet the requirements
of UL 514A, Metallic Outlet Boxes, or 514C, Nonmetallic Outlet Boxes, Flush
Device Boxes and Covers 514.D Cover plates for flush mounted wiring
devices.
8.17.2 Receptacles shall be of the grounding type with a terminal provided
for the grounding (green) conductor as shown in Figure 10 and Figure 11.
NOTE: GFCI receptacle devices are not necessarily ignition protected per
ABYC E-8.9.1.
8.22
SHORE POWER SUPPLY
8.22.1 Power Inlet – The receptacle, or receptacles, installed to receive
a connecting cable to carry AC shore power aboard shall be a male type
connector.
8.22.1.1 Power inlets installed in locations subject to rain, spray, or splash
shall be weatherproof whether or not in use.
8.22.1.2 Power inlets installed in areas subject to flooding or momentary
submersion shall be of a watertight design whether or not in use.
8.22.1.3 Metallic power inlets installed on metallic boats using an isolation
transformer or a galvanic isolator shall be insulated from metallic structure
and components. On nonmetallic boats using an isolation transformer or a
galvanic isolator the power inlet shall be insulated from metallic components
connected to the boat’s ground.
8.22.2 Shore Power Cable – On each boat equipped with an AC shore
power system, a shore power cable that contains the conductors for the
power circuit and a grounding (green) conductor shall be provided.
8.22.2.1 Except where the shore power cable is permanently connected to
the boat, the boat end of this cable shall be terminated with a locking and
grounding female type connector to match the boat power inlet. See Figure
11 and Figure 12.
8.22.2.2 The shore power cable shall be flexible cord with the minimum
properties of Type SO, ST, STO, SEO, or STOOW, and shall be suitable for
outdoor use. The shore connection end of this cable shall be fitted with a
locking and grounding type plug with the required number of poles and shall
comply with the National Electrical Code. See Figure 11 or Figure 12 and
Appendix AP Table 2.
8.17.3 Receptacles and matching plugs used on AC systems shall not be
interchangeable with receptacles and matching plugs used on DC systems.
46
www.hubbell-wiring.com
Dimensions in Inches (mm)
Marine Products
Catalog Number Index
Catalog
Number
Page
Number
BB1001W ............................. 16, 18
BB1002W ............................. 16, 18
BB100N ................................ 16, 18
BB201W ......................................23
BB301W ......................................23
BB601W ......................................23
BR15ALWRTR ............................38
BR15BLKWRTR .........................38
BR15GRYWRTR ........................38
BR15IWRTR ...............................38
BR15LAWRTR............................38
BR15WHIWRTR .........................38
BR15WRTR.................................38
CA100 .......................16, 17, 18, 19
CC100.......................16, 17, 18, 19
CR15............................................38
CR15AL .......................................38
CR15ALTR ..................................38
CR15BLK ....................................38
CR15BLKTR ...............................38
CR15GRY....................................38
CR15GRYTR...............................38
CR15I...........................................38
CR15ITR......................................38
CR15LA .......................................38
CR15LATR ..................................38
CR15OW .....................................38
CR15TR.......................................38
CR15WHI ....................................38
CR15WHITR ...............................38
CR16277 .....................................10
CR16279 .....................................12
CR16914 .....................................28
CS1004 ........................................15
CS100IT4 ....................................15
CS100IT5 ....................................15
CS115 ..........................................39
CS115AL .....................................39
CS115GY.....................................39
CS115I .........................................39
CS115LA .....................................39
CS115OW ...................................39
CS115W ......................................39
CS315 ..........................................39
CS315AL ....................................39
CS315GY.....................................39
CS315I .........................................39
CS315LA .....................................39
CS315OW ...................................39
CS315W ......................................39
CS50EXT4...................................15
CS50EXT5...................................15
CS754 ..........................................15
CS75IT4.......................................15
CS75IT5.......................................15
CW100IT4 ...................................15
CW100IT5 ...................................15
CW125IT4 ...................................15
CW125IT5 ...................................15
CW754 .........................................15
CWP1CR .....................................43
CWP26CR............................ 37, 43
CWP26CRW ........................ 37, 43
CWP8CR .....................................43
DR15............................................38
DR15AL .......................................38
DR15ALTR ..................................38
DR15ALWRTR............................38
Catalog
Number
Page
Number
DR15BLK ....................................38
DR15BLKTR ...............................38
DR15BLKWRTR.........................38
DR15GRY....................................38
DR15GRYTR...............................38
DR15GRYWRTR ........................38
DR15I...........................................38
DR15ITR......................................38
DR15IWRTR ...............................38
DR15LA .......................................38
DR15LATR ..................................38
DR15LAWRTR............................38
DR15OW .....................................38
DR15TR.......................................38
DR15WHI ....................................38
DR15WHITR ...............................38
DR15WHIWRTR .........................38
DR15WRTR ................................38
FT202W .......................................23
FW60100 ........................ 17, 19, 23
GFP15M ......................................36
GFP315A .....................................36
GFR5252M..................................37
GFR5252MGY ............................37
GFR5252MI.................................37
GFR5252MW ..............................37
GFT2G .........................................36
HBL103RX ..................................22
HBL105GF ..................................26
HBL10CM22S.............................42
HBL10CM23S.............................42
HBL10CM35S.............................42
HBL10CM36S.............................42
HBL10CM37S.............................42
HBL10CM41S.............................42
HBL1221IL ..................................39
HBL1221PL.................................39
HBL1223IL ..................................39
HBL1223PL.................................39
HBL1281 .....................................39
HBL1281I ....................................39
HBL1283 .....................................39
HBL1283I ....................................39
HBL1795 .....................................39
HBL17CM50 ...............................39
HBL21CM28 ...............................26
HBL21CM29 ...............................26
HBL23CM10 ...............................34
HBL23CM11 ...............................34
HBL23CM11V.............................34
HBL23CM13 ...............................34
HBL23CM13V.............................34
HBL26CM10 .................................8
HBL26CM11 .................................8
HBL26CM11V...............................9
HBL26CM11VB ............................9
HBL26CM13 .................................8
HBL26CM13V...............................9
HBL303INT ...................................5
HBL303NM ...................................5
HBL303SS.....................................5
HBL303SSBL................................5
HBL303SSO..................................5
HBL316B6W ...............................23
HBL316C6W ...............................23
HBL316CRC ...............................22
HBL316CSW...............................22
HBL316CSW25 ..........................22
Catalog
Number
Page
Number
HBL316NM .................................22
HBL316P6W ...............................23
HBL316R6W ...............................23
HBL316SSX ................................22
HBL31CM28 ...............................26
HBL31CM29 ...............................26
HBL328DCC ...............................30
HBL328DCP ...............................30
HBL328DCR ...............................30
HBL332B6W ...............................23
HBL332C6W ...............................23
HBL332CRC ...............................22
HBL332CSW...............................22
HBL332NM .................................22
HBL332P6W ...............................23
HBL332R6W ...............................23
HBL332SSX ................................22
HBL363B6W ...............................23
HBL363C6W ...............................23
HBL363P6W ...............................23
HBL363R6W ...............................23
HBL47CM00 ...............................32
HBL47CM15 ...............................32
HBL47CM16 ...............................32
HBL47CM20C ............................32
HBL47CM29C ............................32
HBL503NM .................................10
HBL503RI....................................10
HBL503SS...................................10
HBL504NM .................................12
HBL504RI....................................12
HBL504SS...................................12
HBL5200 .....................................36
HBL5221 ..................32, 33, 35, 43
HBL5222 ..................32, 33, 35, 43
HBL5251 .....................................38
HBL5251I ....................................38
HBL5262ISA ...............................37
HBL5273L ...................................26
HBL52CM21 ............32, 33, 35, 43
HBL52CM21W .............. 32, 35, 43
HBL52CM22 ............32, 33, 35, 43
HBL52CM61 ...............................33
HBL52CM62 ........................ 33, 38
HBL52CM62I ....................... 33, 38
HBL52CM66C ............................33
HBL52CM66V.............................33
HBL52CM69C ............................33
HBL52CM69V.............................33
HBL52CM80C ............................33
HBL5361 .....................................38
HBL5361I ....................................38
HBL53CM61 ...............................35
HBL53CM62 ...............................35
HBL53CM66C ............................35
HBL53CM69C ............................35
HBL6079 .....................................39
HBL6080 .............................. 30, 44
HBL6080OS ................................44
HBL6081 .....................................44
HBL6082 .....................................44
HBL6085 .....................................42
HBL6087 .....................................44
HBL60CM17 ........................ 33, 35
HBL60CM18 ........................ 33, 35
HBL60CM19 ...............................35
HBL60CM23 ...............................32
HBL60CM24 ...............................32
www.hubbell-wiring.com
Catalog
Number
Page
Number
HBL60CM31 .......................... 8, 34
HBL60CM31V........................ 9, 34
HBL60CM31W ...................... 8, 34
HBL60CM32 .......................... 8, 34
HBL60CM32V........................ 9, 34
HBL60CM33 .................................8
HBL60CM33V...............................9
HBL60CM33W .............................8
HBL60CM75 .................................5
HBL60CM83 ...............................44
HBL60CM84 ...............................44
HBL60CM88 ...............................44
HBL61CM03 .................................6
HBL61CM03LED..........................7
HBL61CM03W .............................6
HBL61CM03WLED ......................7
HBL61CM05 .................................6
HBL61CM05LED..........................7
HBL61CM05WLED ......................7
HBL61CM08 .................................6
HBL61CM08LED..........................7
HBL61CM08W .............................6
HBL61CM08WLED ......................7
HBL61CM100 .............................26
HBL61CM22 ...............................26
HBL61CM22W ...........................26
HBL61CM25 ...............................26
HBL61CM42 ...............................13
HBL61CM42LED................. 13, 14
HBL61CM42W ...........................13
HBL61CM42WLED ............. 13, 14
HBL61CM43 ...............................11
HBL61CM43LED................. 11, 14
HBL61CM52 ...............................13
HBL61CM52LED................. 13, 14
HBL61CM52W ...........................13
HBL61CM52WLED ............. 13, 14
HBL61CM53 ...............................11
HBL61CM53LED................. 11, 14
HBL61CM53W ...........................11
HBL61CM53WLED ............. 11, 14
HBL61CM54 ...............................26
HBL61CM55 ...............................26
HBL61CM56 ...............................26
HBL61CM59 ...............................26
HBL61CM64 ...............................33
HBL61CM64BK..........................33
HBL61CM65 ...............................35
HBL61CM71 ...............................26
HBL61CM72 ...............................26
HBL63CM60 ...............................10
HBL63CM61 ...............................11
HBL63CM64 ...............................12
HBL63CM65 ...............................13
HBL63CM69 ...............................13
HBL63CM70 ...............................11
HBL64CM54 ...............................27
HBL64CM55 ...............................27
HBL64CM56 ...............................27
HBL64CM57 ...............................27
HBL64CM59 ...............................27
HBL7423WO .................. 33, 35, 43
HBL7424WO .......................... 8, 43
HBL7425WOA ........... 8, 30, 34, 43
HBL74CM23WO ........... 33, 35, 43
HBL74CM24WO ................... 8, 43
HBL74CM25WOA ..... 8, 30, 34, 43
HBL74CM25WOAW .. 8, 30, 34, 43
47
Marine Products
Catalog Number Index
Catalog
Number
Page
Number
HBL7774WO .................. 11, 13, 43
HBL77CM15 ........................ 10, 12
HBL77CM15W .................... 10, 12
HBL77CM16 ........................ 11, 13
HBL77CM16W .................... 11, 13
HBL77CM17 ........................ 10, 12
HBL77CM67 ........................ 10, 12
HBL77CM74WO ........... 11, 13, 43
HBL8200ILI .................................38
HBLCBINM ...................................5
HBLCBISS ....................................5
HBLPHTVNM .............................28
HBLPHTVRI ................................28
HBLPHTVSS ...............................28
HBLTVSS.....................................28
LR100 .......................16, 17, 18, 19
M11LRGSP .................................31
M11LRSP ....................................31
M11LTR .......................................31
M11LTRM ...................................31
M11MSP .....................................31
M11SP .........................................31
M123LTR .....................................31
M123MMSP ................................31
M123MSP ...................................31
M123SP.......................................31
M21SP .........................................31
M223JSP.....................................31
M223MMSP ................................31
M223SP.......................................31
M4100B12R ................................16
M4100C12...................................17
M4100C12R ................................16
M4100P12 ...................................17
M4100R12...................................17
M5100B7R ..................................18
M5100B9R ..................................18
M5100C7.....................................19
M5100C7R ..................................18
M5100C9.....................................19
M5100C9R ..................................18
M5100P7 .....................................19
M5100P9 .....................................19
M5100R7 .....................................19
M5100R9 .....................................19
M5200BS1R................................20
M5200CS1 ..................................21
M5200CS1R................................20
M5200PS1...................................21
M5200RS1 ..................................21
MB2003W ...................................21
MB2004W ...................................21
MH11 ...........................................31
MHB11 ........................................31
MR11LRSP .................................31
MR11MSP...................................31
MR11SP ......................................31
MR123LRSP ...............................31
MR123MMSP .............................31
MR123MSP.................................31
MR123SP ....................................31
MR21SP ......................................31
MR223LRSP ...............................31
MR223MMSP .............................31
MR223SP ....................................31
MSB1 ...........................................31
NP1 .........................................W-40
NP1BK....................................W-40
48
Catalog
Number
Page
Number
NP1GY....................................W-40
NP1I ........................................W-40
NP1W .....................................W-40
NPJ1 .......................................W-40
NPJ1BK..................................W-40
NPJ1GY..................................W-40
NPJ1I ......................................W-40
NPJ1W ...................................W-40
NP8 .........................................W-40
NP8BK....................................W-40
NP8GY....................................W-40
NP8I ........................................W-40
NP8W .....................................W-40
NPJ8 .......................................W-40
NPJ8BK..................................W-40
NPJ8GY..................................W-40
NPJ8I ......................................W-40
NPJ8W ...................................W-40
NP26 .......................................W-40
NP26BK..................................W-40
NP26GY..................................W-40
NP26I ......................................W-40
NP26W ...................................W-40
NPJ26 .....................................W-40
NPJ26BK ...............................W-40
NPJ26GY ...............................W-40
NPJ26I ....................................W-40
NPJ26W .................................W-40
NP2 .........................................W-40
NP2BK....................................W-40
NP2GY....................................W-40
NP2I ........................................W-40
NP2W .....................................W-40
NPJ2 .......................................W-40
NPJ2BK..................................W-40
NPJ2GY..................................W-40
NPJ2I ......................................W-40
NPJ2W ...................................W-40
NP82 .......................................W-40
NP82BK..................................W-40
NP82GY..................................W-40
NP82I ......................................W-40
NP82W ...................................W-40
NPJ82 .....................................W-40
NPJ82BK ...............................W-40
NPJ82GY ...............................W-40
NPJ82I ....................................W-40
NPJ82W .................................W-40
NP262 .....................................W-40
NP262BK ...............................W-40
NP262GY ...............................W-40
NP262I ....................................W-40
NP262W .................................W-40
NPJ262 ...................................W-40
NPJ262BK .............................W-40
NPJ262GY .............................W-40
NPJ262I..................................W-40
NPJ262W ...............................W-40
NP18 .......................................W-40
NP18BK..................................W-40
NP18GY..................................W-40
NP18I ......................................W-40
NP18W ...................................W-40
NPJ18 .....................................W-40
NPJ18BK ...............................W-40
NPJ18GY ...............................W-40
NPJ18I ....................................W-40
NPJ18W .................................W-40
Catalog
Number
Page
Number
NP126 .....................................W-40
NP126BK ...............................W-40
NP126GY ...............................W-40
NP126I ....................................W-40
NP126W .................................W-40
NPJ126 ...................................W-40
NPJ126BK .............................W-40
NPJ126GY .............................W-40
NPJ126I..................................W-40
NPJ126W ...............................W-40
NP7 .........................................W-40
NP7BK....................................W-40
NP7GY....................................W-40
NP7I ........................................W-40
NP7W .....................................W-40
NPJ7 .......................................W-40
NPJ7BK..................................W-40
NPJ7GY..................................W-40
NPJ7I ......................................W-40
NPJ7W ...................................W-40
NP13 .......................................W-40
NP13BK..................................W-40
NP13GY..................................W-40
NP13I ......................................W-40
NP13W ...................................W-40
NPJ13 .....................................W-40
NPJ13BK ...............................W-40
NPJ13GY ...............................W-40
NPJ13I ....................................W-40
NPJ13W .................................W-40
NS612BK ....................................41
NS612GY.....................................41
NS612I .......................................41
NS612W .....................................41
NS613BK ....................................41
NS613GY.....................................41
NS613I ........................................41
NS613W .....................................41
NS783BK ....................................41
NS783GY.....................................41
NS783I .......................................41
NS783W .....................................41
NSJ5EBK ...................................41
NSJ5EGY ....................................41
NSJ5EI ........................................41
NSJ5EW .....................................41
NSJ6BK ......................................41
NSJ6GY.......................................41
NSJ6I ..........................................41
NSJ6W .......................................41
NSJUBK .....................................41
NSJUGY .....................................41
NSJUI .........................................41
NSJUW .......................................41
NVA15GHGA ..............................45
NVBA ...........................................45
NVGA ...........................................45
NVX15GHGA ..............................45
PC100 ................................... 17, 19
PC320 ..........................................23
PC3430 ........................................23
PC60 ............................................23
PH6595 ........................................29
PH6596 ........................................29
PH6597 ........................................29
PH6597TV ...................................29
PH6598 ........................................28
PH6598W ....................................28
www.hubbell-wiring.com
Catalog
Number
Page
Number
PH6599 ........................................28
PH6599W ....................................28
PH6619 ................................. 29, 44
PH6621 ........................................29
PH6624 ........................................28
PH6625 ........................................28
PH6630 ........................................28
PH7440 ........................................28
PH7499 ........................................28
RPL30P ................................ 6, 7, 9
RW57500.....................................42
RW57600.....................................42
RW57950.....................................42
SB1 ..............................................40
SB126 ..........................................40
SB13 ............................................40
SB18 ............................................40
SB2 ..............................................40
SB26 ............................................40
SB262 ..........................................40
SB7 ..............................................40
SB8 ..............................................40
SB82 ............................................40
SFFGBK .....................................41
SFFGEI .......................................41
SFFGGY .....................................41
SFFGW .......................................41
SR3050 ............................. 5, 10, 12
SS1...............................................40
SS126 ..........................................40
SS13 ............................................40
SS18 ............................................40
SS2...............................................40
SS26 ............................................40
SS262 ..........................................40
SS7...............................................40
SS720 ............................................8
SS725 ............................................8
SS750 ................................... 11, 13
SS8...............................................40
SS82 ............................................40
TV97.............................................29
TV98.............................................29
TV98W .........................................29
TV99.............................................29
TV99W .........................................29
VCGP100.....................................45
WC310280 ....................................6
YC306250....................................11
YC310250......................................6
YC312250....................................34
YC314250....................................32
YC406250....................................13
YQ100PLUS................................24
YQ230..........................................24
Marine Products
RoHS Product Index
RoHS
Catalog
Number
RoHS compliance is an on going commitment at Hubbell. The following is a current list of compliant
Hubbell Marine Products at time of this printing. For the most current list of all Hubbell Wiring DeviceKellems, visit us at www.hubbell-wiring.com.
Page
Number
BB601W ......................................23
CR15AL.......................................38
CR15GRY....................................38
CR15LA.......................................38
CR15WHI ....................................38
CS115AL .....................................39
CS115I.........................................39
CS115OW ....................................39
39
CS315GY..............................
.........39
CS315LA ......................................39
CS315W .......................................39
HBL10CM22S..............................42
HBL10CM23S..............................42
HBL10CM35S
S.............................42
.4
HBL10CM36
36S..............................42
HBL10CM3
M37S..............................42
HBL10CM
CM41S..............................42
HBL21C
CM28 ................................26
HBL21
21CM29 ................................26
HBL2
L23CM13V..............................34
HBL
L26CM11VB .............................9
HB
BL303INT .................
5
HB
BL303NM ....................................5
HBL303SS............................
HBL303SSBL...........
.
...........
HBL303SSO...................................5
HBL31CM28 ..............
26
HBL503NM ..........................
10
HBL503RI.............................
HBL503SS............................
HBL504NM .........................
Catalog
Number
Page
Number
HBL504RI....................................12
HBL504SS...................................12
HBL52CM66V.............................33
HBL52CM69V...........
......................33
33
HBL52CM80C
CM80C ............................33
HBL60
BL60CM31W .............................8
HBL60CM33 .................................8
HBL60CM33V...............................9
HBL60CM33W ......
..........................8
HBL60CM75
M75 .................................5
HBL61C
L61CM03 .................................6
HB
HBL61CM03W
.............................6
HBL61CM05 .................................6
HBL61CM08 .................................6
HBL61CM08W .............................6
HBL61CM100.............................26
HBL61CM22 ...............................26
HBL61CM22W ...........................26
HBL61CM25 ...............................26
HBL61CM42 ...............................13
HBL61CM42W ...........................13
HBL
BL6
3
HBL61
.........
3
HBL61
53 .........................
HBL61 M53W ........................
HBL
M5 .............................. 6
HBL6 M .............................. 6
HBL61 M .............................. 6
HBL61 M5 ........................... 6
HBL61 M71
..................
6
Catalog
Number
Page
Number
HBL61CM72 ...............................26
HBL63CM61 ...............................11
HBL63CM64 ...............................12
HBL63
HBL63CM65
...............................13
HBL63CM69
69 .......
...........................13
HBL64CM54 ..................
...............27
HBL64CM55 ...........................
......27
HBL64CM56 ...............................27
27
HBL64CM57 ...............................27
HBL64C
HBL64CM59
59 .....
............................27
HBL77CM15 ...............
..................10
HBL77CM15W ............................10
HBL77CM16 ................................11
HBL77CM16W ...........................11
11
HBL77CM17 ...............................10
HBL77CM67 ...............................10
HBLCBINM...................................5
HBLCBISS ....................................5
M4100B12R................................16
M4100C12...................................17
M4100C12R................................16
M
...........
...... 17
M
...........
............17
M
...........
...........
M
...........
.............1
M5100C7
..
....
19
M5100C7R ..............
.....18
M5100C9
...........
9
M
........... ............
M
........... ..............
M
...........
....
19
Catalog
Number
Page
Number
M5100R7.....................................19
M5100R9.....................................19
NP13............................................40
NP13W ........................................40
NS612GY.....................................41
NS783BK ....................................41
NS783GY.....................................41
NSJ5EI ........................................41
NSJ6I ..........................................41
NS
NSJUI
.........................................41
RPL3
L30P .........................................6
SB18 .............................................40
SR3050 ...........................................5
WC310280
0 ....................................
.
6
YC306250.....................................11
YC310250.......................................6
YC312250.....................................34
YC
YC3
C314250.....................................32
YC40
06250.....................................13
RoHS
R
Ro
oHS
HS
www.hubbell-wiring.com
49
Marine Products Group
Hubbell Incorporated (Delaware) • 185 Plains Road, Milford, CT 06461-2420 • Phone: (800) 288-6000 • Fax: (800) 255-1031
Printed In U.S.A. Copyright 2008, Hubbell Incorporated • Specifications subject to change without notice.
®
Registered Trademark of Hubbell Incorporated. • ™ Trademark of Hubbell Incorporated.
H5263
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement