Other Networks
TURCK
Network Media Products
Data Highway Plus
(Blue Hose®)
The Data Highway Plus (DH+) network is a local area network that is very simple to implement. It is designed to provide
simple communication between PLC's, SLC's and PC's.
The Data Highway Plus network allows connection to a maximum of 64 devices per link although 15 or fewer nodes are
recommended per link. Devices include:
• PLC-5 and SLC 5/04 programmable controllers
• Color graphics systems
• Personal computers
• Host computers
• Numerical controls
• Programmable RS-232-C/RS-422 devices
A network can be configured with 99 links. With a multi-link network, more nodes in the network are possible.
By placing nodes in the proper link with some nodes and separate from other nodes, the efficiency of message delivery can
be improved. Using simple twisted-pair wiring, DH+ can be configured as a trunk-line drop or a daisy-chain topology.
S1
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Data Highway Plus (Blue Hose®), Cable Specifications
Blue Hose is a shielded, twisted pair network cable. The cable consists of blue, clear and shield wires. A terminating
resistor must be attached across the blue and clear wires at each end of the network. The resistor value depends on the
baud rate selected. The cable shield must be connected to chassis ground only at the scanner end of the network.
Jacket
Drain Wire
Clear
Blue
Figure A
Aluminum Foil-Polyester Tape
Tinned-Copper Braided Shield
Jacket
Inner Jacket
Drain Wire
Clear
Blue
Figure B
Baud Rate
Maximum Cable Length
57.6 Kbps
10,000 feet (3048 meters)
115.2 Kbps
5,000 feet (1524 meters)
230.4 Kbps
2,500 feet (762 meters)
Data Pair
Type
390
AWM 2464
80°C 300 Volts
391A
60°C 300 Volts
Outer Jacket
Shields
Blue Hose
Armor
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
Figure
NEC CC CL2
CEC CC
2/20 AWG
BU, Clear
9.5 Ohms
PC
PC Blue
6 CC (.238 in)
Braid/Coil
20 AWG
RB51157-*M
36 lbs.
A
NEC CC CL2
CEC CC
CCG FT4 [HLBCD]
2/20 AWG
BU, Clear
9.5 Ohms
PC
Aluminum
Armor/PC
Blue
Armor
Foil Braid
RB51199-*M
122 lbs.
armorfast ®
B
Approvals
* Indicates length in meters.
Blue Hose is a registered trademark of Belden CDT Inc.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 meters.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S2
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Data Highway Plus (Blue Hose®), Cable and Cordset Selection Matrix
eurofast ®
Pin (Male)
1
eurofast Bulkhead
Pin (Male)
Socket (Female)
Socket (Female)
3
2
4
5
6
RSC
WSC
RKC
WKC
FSFD
FKFD
RSC 39x-*M
WSC 39x-*M
RKC 39x-*M
WKC 39x-*M
FSFD 39x-*M
FKFD 39x-*M
RSC RSC 39x-*M
RSC WSC 39x-*M
RSC RKC 39x-*M
RSC WKC 39x-*M
RSC FSFD 39x-*M
RSC FKFD 39x-*M
WSC WSC 39x-*M
WSC RKC 39x-*M
WSC WKC 39x-*M
WSC FSFD 39x-*M
WSC FKFD 39x-*M
RKC RKC 39x-*M
RKC WKC 39x-*M
RKC FSFD 39x-*M
RKC FKFD 39x-*M
WKC WKC 39x-*M
WKC FSFD 39x-*M
WKC FKFD 39x-*M
Bare
eurofast
Pin (Male)
1
RSC
3
Socket (Female)
WSC
2
RKC
4
WKC
*
x
See page S4 for dimensional drawings.
Indicates length in meters.
Indicates cable type.
For armorfast ® cable: Change part number (RSC RSC 39-*M to RSA RSA 391A-*M)
For stainless steel connectors: Change part number (RSC RSC 39-*M to RSCV RSCV 39-*M)
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 Meters.
eurofast
Male
S3
Pinouts
1. Drain (Shield)
2. Clear (RI0 #2)
3. Blue (RI0 #1)
4. N/C
5. N/C
eurofast
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Data Highway Plus (Blue Hose®), eurofast ® Cordset and Receptacle Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +60°C (-40° to +140°F)
1
RSC ..
2
Page S3
RKC ..
3
WSC ..
Page S3
4
Page S3
WKC ..
5
Page S3
Blue Hose
6
FSFD ..
RSA ..
Page S3
(armorfast ® only)
FKFD ..
RKA ..
Page S3
(armorfast only)
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S4
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Notes
S5
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
CC-Link
CC-Link (Control & Communication Link) is a field network system that processes control and information data at high
speed while ensuring a deterministic response.
Features include:
• Simple communication programming - configuration software available but not required
• Allows automation controllers to be programmed and monitored over the network
• Provides network diagnostic information
• A standby network master to assume network control if primary master goes off-line
• Bypasses network devices needing service without disrupting network traffic
• Automatically restores off-line, bypassed devices to the network
• Network devices can be added while network is operating
CC-Link / LT
Maximum Number of Slaves
64
64
Max. No. of Addressable I/O Points (bit)
8192 in / 8192 out
1024 in / 1024 out
Maximum Number of Addressable Numerical
Data Values (word)
2048 in / 2048 out
---
Typical Scan Rate for 64 Stations
4 ms @ 10 Mbps
2 ms @ 2.5 Mbps
Network Topology
Multi-drop, T branch, Star
T branch, Star
Error Detection System
CRC
CRC
Physical Layer
RS-485
RS-485
Media
Shielded Twisted 3-wire Cable
4-wire Flat Cable (includes power)
Communication Method
Broadcast, Polling
BITR Method
Transmission Format
HDLC
HDLC
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
CC-Link
CC-Link
S6
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
CC-Link, Cable Specifications
• Cable Certified by the CC-Link Partner
Association (CLPA) to Ver. 1.10 Cable Standard
• Cables are Available in 3 Conductor and 5
Conductor (with power conductors) Versions
Jacket
Drain Wire
Yellow
Blue
White
Figure A
Aluminum/Mylar Foil Shield
Tinned-Copper Braid Shield
Jacket
Drain Wire
Yellow
Blue
White
Figure B
Black
Red
Aluminum/Mylar Foil Shield
Tinned-Copper Braid Shield
Maximum Transmission Distance
Communication
Speed
10 Mbps
CC-Link Cable Ver. 1.10
CC-Link High Performance Cable
CC-Link Cable
100 meters (328 feet)
100 meters (328 feet)
5 Mbps
160 meters (525 feet)
150 meters (492 feet)
2.5 Mbps
400 meters (1312 feet)
200 meters (656 feet)
625 Kbps
900 meters (2953 feet)
600 meters (1968 feet)
156 Kbps
1200 meters (3937 feet)
1200 meters (3937 feet)
Data Triad
Type
430
AWM 2464
75°C 300 Volts
630
AWM 2464
75°C 300 Volts
*
S7
Approvals
Power Pair
Outer Jacket
Shields
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
Figure
AWG
Color Code
DCR (/1000 feet)
Insulation
Power
Material Color
Nominal O.D.
NEC PLTC
CEC [CMG]
3/20 AWG
WH, YE, BU
11.4 Ohms
PE
---
PVC Brown
7.7 mm (.305 in)
Foil/Braid
22 AWG
RB51126-*M
55 lbs.
A
NEC PLTC
CEC [CMG]
3/20 AWG
WH, YE, BU
11.4 Ohms
PE
2/18 AWG
RD, BK
PVC Brown
10.5 mm (.413 in)
Foil/Braid
22 AWG
RB51127-*M
101 lbs.
B
Indicates length in meters.
Standard cable lengths are 30, 75, 150, 225 and 300 meters.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
CC-Link, 630 Communication/Power Cable and Cordset Selection Matrix
minifast ®
Pin (Male)
1
minifast Bulkhead
Pin (Male)
Socket (Female)
Socket (Female)
2
3
4
9
10
RSM
WSM
RKM
WKM
RSFP
RKFP
RSM 630-*M
WSM 630-*M
RKM 630-*M
WKM 630-*M
RSFP 630-*M
RKFP 630-*M
RSM RSM 630-*M
RSM WSM 630-*M
RSM RKM 630-*M
RSM WKM 630-*M
RSM RSFP 630-*M
RSM RKFP 630-*M
WSM WSM 630-*M
WSM RKM 630-*M
WSM WKM 630-*M
WSM RSFP 630-*M
WSM RKFP 630-*M
RKM RKM 630-*M
RKM WKM 630-*M
RKM RSFP 630-*M
RKM RKFP 630-*M
WKM WKM 630-*M
WKM RSFP 630-*M
WKM RKFP 630-*M
Bare
RSM
2
minifast
Pin (Male)
1
Socket (Female)
WSM
3
RKM
4
WKM
CC-Link
*
See page S11 for dimensional drawings.
Indicates length in meters.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 Meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM … to RSV, WSM … to WSV.
minifast
Pinouts
minifast
Male
1. Blue (DA)
2. White (DB)
3. Yellow (DG)
4. Red (V+)
5. Black (V-)
6. Drain (Shield)
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S8
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
CC-Link, 430 Communication Cable and Cordset Selection Matrix
minifast ®
Pin (Male)
1
eurofast ®
Pin (Male)
Socket (Female)
2
3
4
5
RSM
WSM
RKM
WKM
RSC
RSM 430-*M
WSM 430-*M
RKM 430-*M
WKM 430-*M
RSC 430-*M
RSM RSM 430-*M
RSM WSM 430-*M
RSM RKM 430-*M
RSM WKM 430-*M
RSM RSC 430-*M
WSM WSM 430-*M
WSM RKM 430-*M
WSM WKM 430-*M
WSM RSC 430-*M
RKM RKM 430-*M
RKM WKM 430-*M
RKM RSC 430-*M
WKM WKM 430-*M
WKM RSC 430-*M
Bare
minifast
Pin (Male)
1
RSM
2
Socket (Female)
WSM
3
RKM
4
WKM
6
WSC
Socket (Female)
*
RSC RSC 430-*M
RSC
eurofast
Pin (Male)
5
7
RKC
8
WKC
See pages S11 - S12 for dimensional drawings.
Indicates length in meters.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10...15 Meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM… to RSV, WSM… to WSV.
minifast
Male
Pinouts
Female
eurofast
Male
Female
1. Grey (Drain)
2. White (DB)
3. Yellow (DG)
4. Blue (DA)
S9
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
CC-Link, 430 Communication Cable and Cordset Selection Matrix
Pin (Male)
6
7
minifast ® Bulkhead
Pin (Male)
Socket (Female)
8
9
10
eurofast Bulkhead (Thin Only)
Pin (Male)
Socket (Female)
11
12
WSC
RKC
WKC
RSFP
RKFP
FSFD
FKFD
WSC 430-*M
RKC 430-*M
WKC 430-*M
RSFP 430-*M
RKFP 430-*M
FSFD 430-*M
FKFD 430-*M
RSM WSC 430-*M
RSM RKC 430-*M
RSM WKC 430-*M
RSM RSFP 430-*M
RSM RKFP 430-*M
RSM FSFD 430-*M
RSM FKFD 430-*M
WSM WSC 430-*M
WSM RKC 430-*M
WSM WKC 430-*M
WSM RSFP 430-*M
WSM RKFP 430-*M
WSM FSFD 430-*M
WSM FKFD 430-*M
RKM WSC 430-*M
RKM RKC 430-*M
RKM WKC 430-*M
RKM RSFP 430-*M
RKM RKFP 430-*M
RKM FSFD 430-*M
RKM FKFD 430-*M
WKM WSC 430-*M
WKM RKC 430-*M
WKM WKC 430-*M
WKM RSFP 430-*M
WKM RKFP 430-*M
WKM FSFD 430-*M
WKM FKFD 430-*M
RSC WSC 430-*M
RSC RKC 430-*M
RSC WKC 430-*M
RSC RSFP 430-*M
RSC RKFP 430-*M
RSC FSFD 430-*M
RSC FKFD 430-*M
WSC WSC 430-*M
WSC RKC 430-*M
WSC WKC 430-*M
WSC RSFP 430-*M
WSC RKFP 430-*M
WSC FSFD 430-*M
WSC FKFD 430-*M
RKC RKC 430-*M
RKC WKC 430-*M
RKC RSFP 430-*M
RKC RKFP 430-*M
RKC FSFD 430-*M
RKC FKFD 430-*M
WKC WKC 430-*M
WKC RSFP 430-*M
WKC RKFP 430-*M
WKC FSFD 430-*M
WKC FKFD 430-*M
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
CC-Link
eurofast ®
Socket (Female)
S10
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
CC-Link, minifast ® Cordset and Receptacle Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
TPU (Polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
300 V
9A
-40°C to +75°C
1
RSM ..
3
Pages S8 - S10
RKM ..
2
WSM ..
4
Pages S8 - S10
WKM ..
9
RSFP ..
S11
Pages S8 - S10
Pages S8 - S10
10
Pages S8 - S10
RKFP ..
Pages S8 - S10
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
CC-Link, eurofast ® Cordset and Receptacle Connector Dimensions
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40°C to +75°C
5
RSC ..
7
Pages S8 - S10
RKC ..
6
WSC ..
8
Pages S8 - S10
WKC ..
11
FSFD ..
Pages S8 - S10
Pages S8 - S10
CC-Link
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
12
Pages S8 - S10
FKFD ..
Pages S8 - S10
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S12
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
CC-Link, (7/8-16UN) minifast ® 4-wire Panel Mount Receptacles
• Mounted for Quick Connection to
Enclosures
Housing
Part Number
Specs
Application
Pinouts
1
Male
RSFV 43
Nickel Plated CuZn
1/2-14NPT
or Stainless Steel
threads,
300 V, 9 A
standard duty
-40°C to +105°C
2
1.
2.
3.
4.
GY
WH
YE
BU
Female
RKFV 43
See page S16 for dimensional drawings.
Standard cable length is 0.5 meters. Consult factory for other lengths.
Standard housing material is nickel plated cast zinc. "RKF .."; "RKFV .." indicates 316 stainless steel housing (leads only)
S13
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
CC-Link, (M12x1) eurofast ® 4-wire Panel Mount Receptacles
• Mounted for Quick Connection to
Enclosures
Housing
Part Number
Specs
Application
Pinouts
3
Male
FSV 43
Nickel Plated CuZn
or Stainless Steel
PG 9 threads
250 V, 4 A
-40°C to +105°C
4
1.
2.
3.
4.
GY
WH
YE
BU
Female
FKV 43
CC-Link
See page S16 for dimensional drawings.
Standard cable length is 0.5 meters. Consult factory for other lengths.
Standard housing material is nickel plated cast zinc. "RKF .."; "RKFV .." indicates 316 stainless steel housing (leads only)
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S14
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
CC-Link, (7/8-16UN) minifast ® 6-wire Panel Mount Receptacles
• Mounted for Quick Connection to
Enclosures
Housing
Part Number
Specs
Application
Pinout
1
Male
RSF 63
Nickel Plated CuZn
or Stainless Steel
1/2-14NPT threads,
standard duty
250 V, 4 A
-40°C to +105°C
2
1.
2.
3.
4.
5.
6.
BU
WH
YE
RD
BK
GY
Female
RKF 63
See page S16 for dimensional drawings.
Standard cable length is 0.5 Meters. Consult factory for other lengths.
Receptacles require a 13/16" (21 mm) clearance hole for panel mounting.
Standard housing material is nickel plated cast zinc. "RKF .."; "RKFV .." indicates 316 stainless steel housing (leads only) and "RKFK .." indicates nylon housing.
For locknuts to be included, add "W/LN" to the end of the part number.
To specify PVC jacketed cable, add "/S717" to the end of the part number.
S15
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
minifast ® Male and Female Receptacles
1
RSF .. 1/2-14NPSM
2
Page S13, S15
RKF .. 1/2-14NPT
Page S13, S15
eurofast ® Male and Female Receptacles
3
Page S14
FK .. PG 9
Page S14
CC-Link
FS .. PG 9
4
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S16
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Genius I/O
Genius bus from GE Fanuc is a proven I/O bus and communications network. It can handle large I/O and data transfers.
Features and benefits:
• Robust for superior data integrity and noise immunity
• Deterministic
• Supports redundant configurations (both cable and I/O)
• Available on a variety of GE Fanuc products
Supported by many third-party interfaces: variable frequency drives, operator interfaces, human machine interfaces, etc.
S17
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Genius I/O, 470 Cable Specifications
• Cable that Meets the Requirements of Genius I/O
Systems and Communications Standard
• This is a Twin Axial Cable with 100 Ohm Impedance
Jacket
Bare Copper
Tinned-Copper
Foil Shield
Tinned-Copper Braided Shield
Max Bus Length:
7500 feet with 16 devices at 38.4 Kbaud
3500 feet with 32 devices at 153.6 Kbaud
470
75°C 300 Volts
*
Approvals
NEC CMG CL2
CEC CMG
Outer Jacket
Shields
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
2/20 AWG
Natural,
Natural
9.5 Ohms
PE
PVC Black
8.4 mm (.330 in)
Foil/Braid
Bulk Cable
Part Number /
Weight/300 M
RB51153-*M
68 lbs.
Genius I/O
Data Pair
Type
Indicates length in meters.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 meters. Consult factory for other lengths.
Genius I/O is a registered trademark of GE.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S18
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Genius I/O, 470 Communication Cable and Cordset Selection Matrix
minifast ®
Pin (Male)
1
eurofast ®
Pin (Male)
Socket (Female)
2
3
4
5
RSM
WSM
RKM
WKM
RSC
RSM 470-*M
WSM 470-*M
RKM 470-*M
WKM 470-*M
RSC 470-*M
RSM RSM 470-*M
RSM WSM 470-*M
RSM RKM 470-*M
RSM WKM 470-*M
RSM RSC 470-*M
WSM WSM 470-*M
WSM RKM 470-*M
WSM WKM 470-*M
WSM RSC 470-*M
RKM RKM 470-*M
RKM WKM 470-*M
RKM RSC 470-*M
WKM WKM 470-*M
WKM RSC 470-*M
Bare
RSM
2
minifast
Pin (Male)
1
Socket (Female)
WSM
3
RKM
4
WKM
6
WSC
Socket (Female)
*
RSC RSC 470-*M
RSC
eurofast
Pin (Male)
5
7
RKC
8
WKC
See pages S21 - S22 for dimensional drawings.
Indicates length in meters.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM… to RSV, WSM… to WSV.
minifast
Male
Pinouts
Female
eurofast
Male
Female
1. Silver
2. Copper
3. N/C
4. Drain
S19
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Genius I/O, 470 Communication Cable and Cordset Selection Matrix
Pin (Male)
6
7
minifast ® Bulkhead
Pin (Male)
Socket (Female)
8
9
10
eurofast Bulkhead (thin only)
Pin (Male)
Socket (Female)
11
12
WSC
RKC
WKC
RSFP
RKFP
FSFD
FKFD
WSC 470-*M
RKC 470-*M
WKC 470-*M
RSFP 470-*M
RKFP 470-*M
FSFD 470-*M
FKFD 470-*M
RSM WSC 470-*M
RSM RKC 470-*M
RSM WKC 470-*M
RSM RSFP 470-*M
RSM RKFP 470-*M
RSM FSFD 470-*M
RSM FKFD 470-*M
WSM WSC 470-*M
WSM RKC 470-*M
WSM WKC 470-*M
WSM RSFP 470-*M
WSM RKFP 470-*M
WSM FSFD 470-*M
WSM FKFD 470-*M
RKM WSC 470-*M
RKM RKC 470-*M
RKM WKC 470-*M
RKM RSFP 470-*M
RKM RKFP 470-*M
RKM FSFD 470-*M
RKM FKFD 470-*M
WKM WSC 470-*M
WKM RKC 470-*M
WKM WKC 470-*M
WKM RSFP 470-*M
WKM RKFP 470-*M
WKM FSFD 470-*M
WKM FKFD 470-*M
RSC WSC 470-*M
RSC RKC 470-*M
RSC WKC 470-*M
RSC RSFP 470-*M
RSC RKFP 470-*M
RSC FSFD 470-*M
RSC FKFD 470-*M
WSC WSC 470-*M
WSC RKC 470-*M
WSC WKC 470-*M
WSC RSFP 470-*M
WSC RKFP 470-*M
WSC FSFD 470-*M
WSC FKFD 470-*M
RKC RKC 470-*M
RKC WKC 470-*M
RKC RSFP 470-*M
RKC RKFP 470-*M
RKC FSFD 470-*M
RKC FKFD 470-*M
WKC WKC 470-*M
WKC RSFP 470-*M
WKC RKFP 470-*M
WKC FSFD 470-*M
WKC FKFD 470-*M
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Genius I/O
eurofast ®
Socket (Female)
S20
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Genius I/O, minifast ® Cordset and Receptacle Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
300 V
9A
-40°C to +75°C
1
RSM ..
3
Pages S19 - S20
RKM ..
2
WSM ..
4
Pages S19 - S20
WKM ..
9
RSFP ..
S21
Pages S19 - S20
Pages S19 - S20
10
Pages S19 - S20
RKFP ..
Pages S19 - S20
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Genius I/O, eurofast ® Cordset and Receptacle Connector Dimensions
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40°C to +75°C
5
RSC ..
7
Pages S19 - S20
RKC ..
6
WSC ..
8
Pages S19 - S20
WKC ..
11
FSFD ..
Pages S19 - S20
Pages S19 - S20
Genius I/O
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
12
Pages S19 - S20
FKFD ..
Pages S19 - S20
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S22
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Interbus
Interbus has been designed as a fast sensor / actuator bus for transmitting process data in industrial environments.
Bus Type
Remote bus: token passing with repeater nodes; Local bus: master-to-slave
Maximum Number of Nodes
Remote bus: 64 in / 64 out; Local bus: 192 in / 192 out
Bus Topology
Remote bus: repeater ring; Local bus: bus
Maximum Network Length
400 meters between remote bus nodes; 10 meters on local bus (can accommodate three slaves)
Transmission Media
Remote bus: twisted pairs with shield/drain; Local bus: 5 pairs twisted
Inputs / Outputs bits Node
8/8 minimum for each node; 2048/2048 total for all nodes
Speed
500 Kbps
Bus Power (for field nodes)
From busline or separate power source
Duplicate Address Detection
To some degree: master assigns a virtual address based upon physical order
Attendance Check
Per scan
Error Detection
CRC checksum
Error Correction Type
Data not validated by checksum is flagged as bad and not used - nodes wait for 3 consecutive scans of
validated data before data can be used
Determinism
Deterministic but not during error correction
S23
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Interbus®, Cable Specifications
• Cable that Meets the Requirements of Interbus-S (IBS)
Remote Bus Cable
• Remote Bus Cable Contains Three Twisted Pair Wires,
and a Drain Wire for Communication Only, No Power
Jacket
Drain Wire
White
Brown
Yellow
Green
Grey
Pink
Data Pair
Type
660
AWM 2464
80°C 300 Volts
*
Approvals
NEC AWM
CEC AWM I/II A/B FT1
Outer Jacket
Shields
AWG
Color Code
DCR (/1000
feet) Insulation
Material Color
Nominal O.D.
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
6/24 AWG
PK/GY,
GN/YE,
WH/BN
26.2 Ohms
PE
PVC Beige
7.4 mm (.290 in)
Braid
24 AWG
RB50699-*M
51 lbs.
Interbus
Tinned-Copper Braid Shield
Indicates length in meters.
Standard cable lengths are 30, 75, 150, 225, and 300 meters.
Interbus is a registered trademark of Phoenix Contact.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S24
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Interbus®, Cable and Cordset Selection Matrix
eurofast ®
Pin (Male)
1
Socket (Female)
3
2
4
RSS
WSS
RKS
WKS
RSS 660-*M
WSS 660-*M
RKS 660-*M
WKS 660-*M
RSS RSS 660-*M
RSS WSS 660-*M
RSS RKS 660-*M
RSS WKS 660-*M
WSS RSS 660-*M
WSS WSS 660-*M
WSS RKS 660-*M
WSS WKS 660-*M
RKS RSS 660-*M
RKS WSS 660-*M
RKS RKS 660-*M
RKS WKS 660-*M
WKS RSS 660-*M
WKS WSS 660-*M
WKS RKS 660-*M
WKS WKS 660-*M
eurofast
Pin (Male)
Bare
1
RSS
3
Socket (Female)
WSS
2
RKS
4
WKS
*
S25
See page S26 for dimensional drawings.
Indicates length in meters.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 Meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSS… to RSV, WSS… to WSV.
eurofast
Pinouts
eurofast
Male
1. Yellow (DO)
2. Green (DO)
3. Grey (DI)
4. Pink (DI)
5. Brown (COM)
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +80°C (-40° to +176°F)
1
RSS ..
3
Page S25
RKS ..
2
WSS ..
Page S25
4
Page S25
WKS ..
Interbus
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Page S25
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S26
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Notes
S27
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Smart
Distributed
System
(SDS)
The Smart Distributed System, developed by Honeywell's MICRO SWITCH Division, is a bus system for intelligent sensors
and actuators. The SDS system is based on CAN as defined in the Bosch V2.0 CAN Specification. SDS allows multiple
nodes to share a single bus.
SDS is based on a three layer communication model. The Application Layer specifies system services and protocol.
The Data Link Layer provides functions and procedures to establish, maintain and release data-link-connections among
devices on the network and to transfer data-link-service-data-units. The Physical Layer provides the mechanical, electrical,
functional and procedural means to activate, maintain and de-activate physical connections for bit transmission between
data-link-entities. Physical Layer devices are interconnected by physical media.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
SDS
Over a single 4-wire cable, Smart Distributed System can interface up to 64 nodes with a maximum of 126 addresses.
These intelligent sensor and actuator devices do more than just turn on and off. Smart Distributed System devices have
advanced device-level functions, system and device diagnostics.
S28
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
SDS™, Micro Cable Specifications
• Cable that Meets the Physical
Layer Specifications of Smart
Distributed System (SDS)
Jacket
Drain Wire
Blue
Brown
Black
White
Foil Shield (pairs)
Foil Shield (overall)
Maximum Trunk Lengths for various data rates independent of bus voltage drop
Maximum
Trunk Length
Data Transmission Rate
Maximum
Branch Length
Maximum
Number of Nodes
22.8 meters (75 feet)
1 Mbit/s
0.3 meters (1 feet)
32
91.4 meters (300 feet)
500 Kbit/s
0.9 meters (3 feet)
64
182.8 meters (600 feet)
250 Kbit/s
1.8 meters (6 feet)
64
457.2 meters (1500 feet)
125 Kbit/s
3.6 meters (12 feet)
64
Power Pair
Type
532
AWM 2464
75°C 300 Volts
531
AWM 2464
75°C 300 Volts
530
AWM 2464
80°C 300 Volts
Outer Jacket
Shields
Approvals
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
Data Pair
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
NEC PLTC
CEC AWM-I/II A/B FT4
2/22 AWG
BU/BN
17 Ohms
PVC
2/22 AWG
WH/BK
17 Ohms
PE
PVC Grey
7.3 mm (.285 in)
Foil
22 AWG
RB50604-*M
41 lbs.
NEC PLTC
CEC AWM-I/II A/B FT4
2/16 AWG
BU/BN
4.3 Ohms
PVC
2/22 AWG
WH/BK
17 Ohms
PE
PVC Grey
8.4 mm (.330 in)
Foil
22 AWG
RB50591-*M
69 lbs.
NEC PLTC
CEC AWM-I/II A/B FT4
2/16 AWG
BU/BN
4.3 Ohms
PVC
2/20 AWG
WH/BK
10 Ohms
PE
PVC Grey
10.4 mm (.409 in)
Foil
20 AWG
RB50628-*M
94 lbs.
* Indicates length in meters.
S29
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
SDS™, Mini Cable and Cordset Selection Matrix - 530
minifast ®
Pin (Male)
1
Socket (Female)
2
3
Pin (Male)
4
minifast
Socket (Female)
9
10
RSM
WSM
RKM
WKM
RSFP
RKFP
RSM 530-*M
WSM 530-*M
RKM 530-*M
WKM 530-*M
RSFP 530-*M
RKFP 530-*M
RSM RSM 530-*M
RSM WSM 530-*M
RSM RKM 530-*M
RSM WKM 530-*M
RSM RSFP 530-*M
RSM RKFP 530-*M
WSM WSM 530-*M
WSM RKM 530-*M
WSM WKM 530-*M
WSM RSFP 530-*M
WSM RKFP 530-*M
RKM RKM 530-*M
RKM WKM 530-*M
RKM RSFP 530-*M
RKM RKFP 530-*M
WKM WKM 530-*M
WKM RSFP 530-*M
WKM RKFP 530-*M
Bare
minifast
Pin (Male)
1
RSM
2
Socket (Female)
WSM
3
RKM
4
WKM
SDS
*
See pages S33 for dimensional drawings.
Indicates length in meters.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM … to RSV, WSM … to WSV.
minifast
Pinouts
minifast
Male
1. Bare (Shield Drain Wire)
2. Brown (+ Voltage)
3. Blue (- Voltage)
4. Black (CAN_H)
5. White (CAN_L)
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S30
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
SDS™, Micro and Mid Cable and Cordset Selection Matrix - 532, 531
minifast ®
Pin (Male)
1
eurofast ® (Thin/Mid Only)
Pin (Male)
Socket (Female)
2
3
4
5
RSM
WSM
RKM
WKM
RSC
RSM 53x-*M
WSM 53x-*M
RKM 53x-*M
WKM 53x-*M
RSC 53x-*M
RSM RSM 53x-*M
RSM WSM 53x-*M
RSM RKM 53x-*M
RSM WKM 53x-*M
RSM RSC 53x-*M
WSM WSM 53x-*M
WSM RKM 53x-*M
WSM WKM 53x-*M
WSM RSC 53x-*M
RKM RKM 53x-*M
RKM WKM 53x-*M
RKM RSC 53x-*M
WKM WKM 53x-*M
WKM RSC 53x-*M
Bare
RSM
2
minifast
Pin (Male)
1
Socket (Female)
WSM
3
RKM
4
Pin (Male)
5
RSC RSC 53x-*M
RSC
6
WSC
Socket (Female)
eurofast (thin/mid only)
WKM
7
RKC
8
WKC
*
x
See pages S33 - S34 for dimensional drawings.
Indicates length in meters.
Indicates cable type.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM ... to RSV, WSM ... to WSV.
minifast
Male
S31
Pinouts
1. Bare (Shield Drain Wire)
2. Brown (+ Voltage)
3. Blue (- Voltage)
4. Black (CAN_H)
5. White (CAN_L)
minifast
eurofast
Female
Male
Pinouts
eurofast
Female
1. Brown (+ Voltage)
2. Blue (- Voltage)
3. White (CAN_L)
4. Black (CAN_H)
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
SDS™, Micro and Mid Cable and Cordset Selection Matrix - 532, 531
eurofast ®
Socket (Female)
Pin (Male)
6
7
minifast ® Bulkhead
Pin (Male)
Socket (Female)
8
9
10
eurofast Bulkhead
Pin (Male)
Socket (Female)
11
12
RKC
WKC
RSFP
RKFP
FSFD
FKFD
WSC 53x-*M
RKC 53x-*M
WKC 53x-*M
RSFP 53x-*M
RKFP 53x-*M
FSFD 53x-*M
FKFD 53x-*M
RSM WSC 53x-*M
RSM RKC 53x-*M
RSM WKC 53x-*M
RSM RSFP 53x-*M
RSM RKFP 53x-*M
RSM FSFD 53x-*M
RSM FKFD 53x-*M
WSM WSC 53x-*M
WSM RKC 53x-*M
WSM WKC 53x-*M
WSM RSFP 53x-*M
WSM RKFP 53x-*M
WSM FSFD 53x-*M
WSM FKFD 53x-*M
RKM WSC 53x-*M
RKM RKC 53x-*M
RKM WKC 53x-*M
RKM RSFP 53x-*M
RKM RKFP 53x-*M
RKM FSFD 53x-*M
RKM FKFD 53x-*M
WKM WSC 53x-*M
WKM RKC 53x-*M
WKM WKC 53x-*M
WKM RSFP 53x-*M
WKM RKFP 53x-*M
WKM FSFD 53x-*M
WKM FKFD 53x-*M
RSC WSC 53x-*M
RSC RKC 53x-*M
RSC WKC 53x-*M
RSC RSFP 53x-*M
RSC RKFP 53x-*M
RSC FSFD 53x-*M
RSC FKFD 53x-*M
WSC WSC 53x-*M
WSC RKC 53x-*M
WSC WKC 53x-*M
WSC RSFP 53x-*M
WSC RKFP 53x-*M
WSC FSFD 53x-*M
WSC FKFD 53x-*M
RKC RKC 53x-*M
RKC WKC 53x-*M
RKC RSFP 53x-*M
RKC RKFP 53x-*M
RKC FSFD 53x-*M
RKC FKFD 53x-*M
WKC WKC 53x-*M
WKC RSFP 53x-*M
WKC RKFP 53x-*M
WKC FSFD 53x-*M
WKC FKFD 53x-*M
SDS
WSC
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S32
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
SDS™, minifast ® Cordset and Receptacle Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
300 V
9A
-40° to +75°C (-40° to +167°F)
1
RSM ..
3
Pages S30 - S32
RKM ..
2
WSM ..
4
Pages S30 - S32
WKM ..
9
RSFP ..
S33
Pages S30 - S32
Pages S30 - S32
10
Pages S30 - S32
RKFP ..
Pages S30 - S32
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
SDS™, eurofast ® Cordset and Receptacle Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane) or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40° to +75°C (-40° to +167°F)
5
RSC ..
7
Pages S30 - S32
RKC ..
6
8
Pages S30 - S32
WKC ..
Pages S30 - S32
SDS
WSC ..
Pages S30 - S32
11
FSFD ..
12
Pages S30 - S32
FKFD ..
Pages S30 - S32
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S34
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
SDS™, eurofast ® Passive Multiport Junctions
• Rugged, Fully Encapsulated Enclosure
• For Connecting I/O in Concentrated
Areas
• Bus-In / Bus-Out Eliminates Need for
Splitter Tee
Part Number
Specs
Application
Wiring Diagrams
4-port Junction
JBBS-53-E401
•
Bus in/bus out straight (7/8-16UN) minifast ®
through ports
•
Four device ports with (M12x1) eurofast
connectors
6-port Junction
JBBS-53-E601
Die-cast aluminum
enclosure.
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Six device ports with (M12x1) eurofast
connectors
8-port Junction
JBBS-53-E801
S35
•
Bus in/bus out straight (7/8-16UN) minifast
through ports
•
Eight device ports with (M12x1) eurofast
connectors
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Anodized Aluminum
Nickel Plated CuZn or Stainless Steel
TPU (polyurethane or POM (Nylon)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
250 V
4A
-40°C to +75°C
Dimensions
8-Port
6-Port
SDS
4-Port
Pinouts
eurofast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S36
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
SDS™, Terminating Resistors
• Stabilize and Minimize Reflections on the
Bus Line
• Required at the Beginning and End of
Bus Line
Housing
Part Number
RSM 53-TR2
RSE 53-TR2
S37
Specs
Application
Pinout
Male
Nickel Plated Brass or
Stainless Steel
300 V, 9 A
-40°C to +75°C
minifast ® Terminating Resistor
Nickel Plated Brass or
Stainless Steel
250 V, 4 A
-40°C to +75°C
eurofast ® Terminating Resistor
•
•
•
•
Internal resistor
Male minifast connector
Internal resistor
Female
Ω
Male eurofast connector
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
®
Bus Type
Master-to-slave
Bus Topology
Bus, straight feed-through
Transmission Speed
188 kBaud (fixed)
Transmission Medium
Coax Cable (supplies communication and power
Transmission Signal
FSK (Frequency Shift Key) modulation; one data bit every 5.3 microseconds
Maximum Number of Nodes
32 to 64
Network Length
250 meters per branch
Address Setting
Via DIP Switch
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
sensoplex
sensoplex is TURCK's own proprietary network originally introduced in 1987. sensoplex was designed for tough industrial
environments and is highly noise resistant. It can interface to other device level networks, such as DeviceNet™, Modbus
and PROFIBUS®-DP. An intrinsic safe version of sensoplex is available.
S38
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
sensoplex®, Cable Specifications
• Cable that Meets the Requirements of sensoplex 2
Installations
• Cable is a 75 Ohm Impedance Coaxial Cable
• Coaxial Cable Allows both Power and Signal to be
Transferred to the Field Devices
Figure A
Figure B
Inner Conductor
Type
Approvals
Koax-75/B-Flex
80°C 30 Volts
Koax-75/B
80°C 30 Volts
Koax-75/OR-Flex
80°C 30 Volts
Koax-75/OR
80°C 30 Volts
Outer Jacket
Shields
Type
Bulk Cable
Part Number /
Weight/300 M
Figure
Type
Material Insulation
Material Color
Nominal O.D.
VDE 04721/0298
Flexible
Copper Alloy
PE
TPE Blue
7 mm (.276 in)
Foil/Braid
RB82701-*M
33 lbs.
A
VDE 04721/0298
Solid
Alloy
PE
TPE Blue
7 mm (.276 in)
Foil/Braid
RB82702-*M
33 lbs.
A
VDE 04721/0298
Flexible
Copper Alloy
PE
TPE Orange
Foil/Braid
RB82700-*M
33 lbs.
B
VDE 04721/0298
Solid
Alloy
PE
TPE Orange
Foil/Braid
RB50100-*M
33 lbs.
B
* Indicates length in meters.
Standard cable lengths are 30, 75, 150, 225, and 300 meters.
S39
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
sensoplex®, Cable and Cordset Selection Matrix
Straight
1
Right Angle
2
RS
WS
KOAX-RS-*M-XX
KOAX-WS-*M-XX
Straight
Bare
1
KOAX-RS-*M-XX-RS KOAX-RS-*M-XX-WS
Right Angle
RS
2
KOAX-WS-*M-XX-WS
WS
* Indicates length in meters.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 Meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RS… to RSV, WS… to WSV.
KOAX - RS - *M - XB - WS
Left Connector
Right Connector
RS = Straight
WS = Right Angle
Blank = None
RS = Straight
WS = Right Angle
Length in Meters (*)
Cable Type
Standard Lengths = 1.0, 2.0, 4.0, 6.0, 10, 15 Meters
Consult factory for other lengths
XB = Blue Coaxial
XOR = Orange Coaxial
BFLEX = Blue Flex Coaxial
1
RS ..
sensoplex
ORFLEX = Orange Flex Coaxial
2
WS ..
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S40
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Seriplex™
Seriplex is designed to be easy and simple to use where applications demand a very high speed.
Response times are less than a millisecond for 128 points.
• Cable runs of 5,000+ feet
• System throughput time is 0.4 msec for 32 sensors plus 32 actuators (5 msec for 510 I/O)
• Supports more than 255 inputs and 255 outputs
• Flexibility of system without system reconfiguration
• Supports any wiring configuration - star, loop, tree, trunks, daisy chain
Seriplex media consists of a small, 4-wire shielded cable that provides both communications and power.
Bus Type
Master/slave and peer-to-peer
Bus Topology
Open - any combination of tree, loop, multi-drop, star, etc.
Maximum Number of Slaves
Non-multiplexed: 5010+ (225 input + 255 output)
Multiplexed: 7.680 discrete or 480 analog or a combination
Data Packet Size
1-255 bits
Network Length
5,000 ft. or longer (without repeaters)
Bus Scan Time
Scalable - 0.72 ms for 31 sensors plus 31 actuators; 5.2 ms for
510 I/O devices
Error Detection System
Yes - CDR, digital debounce and diagnostic output
Transmission Signal
Binary, Analog, ASCII
Media
4-wire cable
Determinism
Yes - inherently deterministic
S41
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Seriplex™, Cable Specifications
• Cable that Meets the Requirements
of Seriplex CBL 1622-PI
• Cable Consists of Two Wires for
Clock and Data and Two for Power
and Common
Jacket
Drain Wire
Black
White
Red
Green
Aluminum-Polyester Tape
Maximum Distance = 1524 meters (5000 feet)
Data
Type
582
75°C 300 Volts
Approvals
NEC CL2 CM
CEC CM
Outer Jacket
Shields
AWG
Color Code
DCR (/1000 feet)
Insulation
AWG
Color Code
Power
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
Bulk Cable
Part Number /
Weight/300 M
2/22 AWG
WH/GN
18.1 Ohms
PE
2/16 AWG
RD/BK
4.5 Ohms
PE
PVC Orange
9.4 mm (.368 in)
Foil
22 AWG
RB50789-*M
56 lbs.
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Seriplex
* Indicates length in meters.
Standard cable lengths are 30, 75, 150, 225 and 300 meters.
S42
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Seriplex™, Cable and Cordset Selection Matrix
minifast ®
Pin (Male)
1
Socket (Female)
2
3
Pin (Male)
4
minifast
Socket (Female)
5
6
RSM
WSM
RKM
WKM
RSFP
RKFP
RSM 582-*M
WSM 582-*M
RKM 582-*M
WKM 582-*M
RSFP 582-*M
RKFP 582-*M
RSM RSM 582-*M
RSM WSM 582-*M
RSM RKM 582-*M
RSM WKM 582-*M
RSM RSFP 582-*M
RSM RKFP 582-*M
WSM WSM 582-*M
WSM RKM 582-*M
WSM WKM 582-*M
WSM RSFP 582-*M
WSM RKFP 582-*M
RKM RKM 582-*M
RKM WKM 582-*M
RKM RSFP 582-*M
RKM RKFP 582-*M
WKM WKM 582-*M
WKM RSFP 582-*M
WKM RKFP 582-*M
Bare
RSM
2
minifast
Pin (Male)
1
Socket (Female)
WSM
3
RKM
4
WKM
See page S44 for dimensional drawings.
* Indicates length in meters.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 1.0, 2.0, 4.0, 6.0, 10....15 Meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM … to RSV, WSM … to WSV.
S43
minifast
Pinouts
minifast
Male
1. Bare (Shield Drain Wire)
2. Red (+ Voltage)
3. Black (- Voltage)
4. Green (Clock)
5. White (Data)
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Seriplex™, minifast ® Cordset and Receptacle Connector Dimensions
Specifications
PUR (polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
300 V
9A
-40°C to +75°C
1
RSM ..
3
Page S43
RKM ..
2
WSM ..
4
Page S43
WKM ..
5
RSFP ..
Page S43
Seriplex
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
Page S43
6
Page S43
RKFP ..
Page S43
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S44
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
Network Power
Cordsets and Tees
S45
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
Power Cordset and Tee Applications
This is only an example of the broad offering of power connectivity products.
See Connectivity Catalog B2005 for entire product line.
Transition Connector
BIC-84-E424
Enterprise
Switch or Router
Power Supply
Server
RSM 2RKM 50
BL67 System
RSM RKM 50-1M
Server
Patch Panel
VB2
SE-84X-E524
Sensor
25 Pair Fan Cable
WSC WSC 840-1M
Closet
Valve
BL20 I/O System
FLDP-IOM-88-0002-ST
Power Cords
Power Supply
RSM 2RKM 50
RSM RKM 50-1M
RSSW RKSW 455-1M
PLC & PB Master Controller
Valve
Sensor
VB2
RSSW RKSW 455-1M
RSM RKM 50-1M
RKSW D9T 455-1M
RKSW 45-TR
FLDP IOM-32-0001
FLDP IOM-88-0001
BL67 I/O System
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S46
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
TURCK 5-Pin Power Cordsets, Cable Specifications
• NEMA 1, 3, 4, 6P and IEC IP 67
Protection
• 300 V, 9 A
Data Pair
Type
50
AWM 2517
105°C 300 Volts
Approvals
NEC AWM
CEC AWM
FT1
Outer Jacket
Shields
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
5/18 AWG
BK, BU, GN/YE,
BN, WH
6.9 Ohms
PVC
PVC Yellow
7.2 mm (.285 in)
None
Bulk Cable
Part Number /
Weight/300 M
RB50549-*M
60 lbs.
* Indicates length in meters.
Standard cable lengths are 30, 100 and 200 meters. Consult factory for other lengths.
S47
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
TURCK 5-Pin Power, Cordset Selection Matrix
minifast ®
Pin (Male)
1
Socket (Female)
2
3
4
RSM
WSM
RKM
WKM
RSM 50-*M
WSM 50-*M
RKM 50-*M
WKM 50-*M
RSM RSM 50-*M
RSM WSM 50-*M
RSM RKM 50-*M
RSM WKM 50-*M
WSM WSM 50-*M
WSM RKM 50-*M
WSM WKM 50-*M
RKM RKM 50-*M
RKM WKM 50-*M
Bare
minifast
Pin (Male)
1
RSM
2
Socket (Female)
WSM
3
RKM
4
WKM WKM 50-*M
Power Cords
WKM
See pages S51 for dimensional drawings.
* Indicates length in meters.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM ... to RSV, WSM ... to WSV.
Pinouts
minifast
Female
1. Black
2. Blue
3. Green/Yellow
4. Brown
5. White
Male
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S48
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
TURCK 5-Pin Power, Cordset Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
PUR (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 67
300 V
9A
-40° to +105°C (-40° to +221°F)
1
RSM ..
3
Pages S50
RKM ..
2
WSM ..
S49
Pages S50
4
Pages S50
WKM ..
Pages S50
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
TURCK 5-Pin Power Tee
• Simplifies Wiring Installations
• Tough Molded Ployurethane Body
Housing
Part Number
TPU (Polyurethane)
250 V, 4 A
-40° to +75°C
Application
Wiring Diagrams
minifast Power Tee
•
•
Data, ground, shield
Stainless steel
coupling nuts
Power Cords
RSM 2RKM 50
Specs
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S50
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
TURCK 4-Pin Power Cordsets, Cable Specifications
• NEMA 1, 3, 4, 6P and IEC IP 67
Protection
• 600 V, 9 A
Data Pair
Type
46
105°C 600 Volts
Approvals
NEC STOW
CEC STOW
FT2
Outer Jacket
Shields
AWG
Color Code
DCR (/1000 feet)
Insulation
Material Color
Nominal O.D.
Type
Drain Wire
4/16 AWG
BK, WH, RD, GN,
4.3 Ohms
PVC
PVC Yellow
11 mm (.435 in)
None
Bulk Cable
Part Number /
Weight/300 M
RB50538-*M
120 lbs.
* Indicates length in meters.
Standard cable lengths are 30, 100 and 200 meters. Consult factory for other lengths.
S51
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
TURCK 4-Pin Power, Cordset Selection Matrix
minifast ®
Pin (Male)
1
Socket (Female)
2
3
4
RSM
WSM
RKM
WKM
RSM 46-*M
WSM 46-*M
RKM 46-*M
WKM 46-*M
RSM RSM 46-*M
RSM WSM 46-*M
RSM RKM 46-*M
RSM WKM 46-*M
WSM WSM 46-*M
WSM RKM 46-*M
WSM WKM 46-*M
RKM RKM 46-*M
RKM WKM 46-*M
Bare
minifast
Pin (Male)
1
RSM
2
Socket (Female)
WSM
3
RKM
4
WKM WKM 46-*M
Power Cords
WKM
See pages S55 for dimensional drawings.
* Indicates length in meters.
Refer to the Cordset Builder at www.turck.com for assistance with cordset/cable combinations.
Standard cable lengths are 0.3, 0.5, 1.0, 2.0, 2.5, 3.0, 3.5, 4.0, 5.0, 6.0, 8.0, 10, 15....50 meters. Consult factory for other lengths.
For stainless steel coupling nuts change part number RSM ... to RSV, WSM ... to WSV.
Pinouts
minifast
Female
Male
1. Black
2. White
3. Red
4. Green
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S52
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
TURCK
Network Media Products
TURCK 4-Pin Power, Cordset Connector Dimensions
Specifications
Housing:
Coupling Nut:
Contact Carrier:
Contacts:
Protection:
Rated Voltage:
Rated Current:
Ambient Temperature:
PUR (Polyurethane)
Nickel Plated CuZn or Stainless Steel
TPU (Polyurethane)
Gold Plated CuZn
NEMA 1, 3, 4, 6P and IEC IP 68
300 V
9A
-40° to +105°C (-40° to +221°F)
1
RSV ..
3
Pages S54
RKV ..
2
WSV ..
S53
Pages S54
4
Pages S54
WKV ..
Pages S54
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Industrial
Automation
TURCK 4-Pin Power Tee
• Simplifies Wiring Installations
• Tough Molded Ployurethane Body
Housing
Part Number
TPU (Polyurethane)
250 V, 4 A
-40° to +75°C
Application
Wiring Diagrams
minifast Power Tee
•
•
Data, ground, shield
Stainless steel
coupling nuts
Power Cords
RSM 2RKM 40
Specs
Pinouts
minifast
Male
Female
TURCK Inc. 3000 Campus Drive Minneapolis, MN 55441 Application Support: 1-800-544-7769 Fax: (763) 553-0708 www.turck.com
S54
Courtesy of Steven Engineering, Inc.-230 Ryan Way, South San Francisco, CA 94080-6370-Main Office: (650) 588-9200-Outside Local Area: (800) 258-9200-www.stevenengineering.com
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement