MINI Cooper Paceman Ride-on Car OWNER’S MANUAL

MINI Cooper Paceman Ride-on Car OWNER’S MANUAL
MINI Cooper
Paceman
Ride-on Car
OWNER’S MANUAL
5F6262F
Keep instructions for future reference.
1
Safety
WARNING!
The owner’s manual contains assembly, use and maintenance
• Using the vehicle near streets, motor vehicles, drop-offs such as:
instructions. The vehicle must be assembled by an adult who has
steps, water (swimming pools) or other bodies of water, sloped
read and understands the instructions in this manual. Keep the packsurfaces, hills, wet areas, flammable vapors, in alleys, at night or
aging away from children and dispose of all packaging before use.
in the dark could result in an unexpected accident. Always use
Note: For best performance use on flat, hard surfaces.
the vehicle in a safe, secure environment with continuous
adult supervision.
The following safety hazards may result in serious injury or death
• Using the vehicle in unsafe conditions such as snow, rain, loose
to the user of the vehicle:
dirt, mud, sand or fine gravel may result in unexpected action
• This product contains small parts that are for adult assembly
such as tip over and skidding, and damage to the electrical system
only. Keep small children away when assembling. Remove and
and battery.
dispose of all protective material and poly bags before
assembly. Be sure to remove all packaging materials and parts • Using the vehicle in an unsafe manner. Examples include but are
not limited to:
from underneath the vehicle body.
a. Pulling the vehicle with another vehicle or similar • Battery posts, terminals and related accessories contain lead
device
and lead compounds (acids) chemicals known to the state of
b. Allowing more than one rider
California to cause cancer, reproductive harm, and are toxic and
c. Pushing the user from the back
corrosive. Never open the battery.
d. Traveling at an unsafe speed
• Body parts such as hands, legs, hair and clothing can get caught
Always use common sense and safe practices when using the vehicle.
in moving parts. Never place a body part near a moving part or
wear loose clothing while using the vehicle. Always wear shoes
This product contains or emits chemicals known to the state
when using the vehicle.
of California to cause cancer or birth defects or other
reproductive harm.
2
BATTERY WARNINGS
WARNING!
• Use of a battery or charger other than the supplied Kid
Trax Toys 6V rechargeable battery and charger may
cause a fire or explosion. Only use the supplied Kid Trax
Toys 6V rechargeable battery and charger with the
vehicle.
• Contact or exposure to battery leakage (lead acid) may
cause serious injury. If contact or exposure occurs
immediately call your physician. If the chemical is on the
skin or in the eyes, flush with cool water for 15 minutes.
If the chemical was swallowed, immediately give the
person water or milk. Do not give water or milk if the
patient is vomiting or has a decreased level of alertness.
Do not induce vomiting.
• Using the Kid Trax Toys 6V rechargeable battery and
charger for any other product may result in overheating,
fire or explosion. Never use the KidTrax Toys 6V
rechargeable battery and charger with another product.
• Battery posts, terminals and related accessories contain
lead and lead compounds (acid), chemicals known to the
State of California to cause cancer, reproductive harm
and are toxic and corrosive. Never open the battery.
• Explosive gases are created during charging. Charge the
battery in a well ventilated area. Do not charge the
battery near heat or flammable materials.
• Tampering or modifying the electric circuit system may
cause a shock, fire or explosion and permanently
damage the system. Exposed wiring, circuitry in the
charger may cause electric shock. Always keep the
charger housing closed.
The following safety hazards may result in serious injury or death
to the user of the vehicle:
• Contact between the positive and negative terminals
may result in fire or explosion. Avoid direct contact
between the terminals. Picking up the battery by the
wires or charger can cause damage to the battery and
may result in a fire. Always pick up the battery by it’s
case or handles.
• Liquids on the battery may cause fire or electric shock.
Always keep all liquids away from the battery and keep
the battery dry.
3
USER REQUIREMENTS AND WARNINGS
Age
Weight
WARNING!
3+
60 lbs (27 kgs)
Before using the vehicle the child should understand the vehicle
controls and safety issues. They must also demonstrate the
capability to handle the vehicle and operate its controls. It is the
responsibility of the adult to educate the child and supervise the
vehicles use. Read the following safety warnings to any child using
the vehicle before riding.
WARNING!
• Park the vehicle indoors or cover it with a tarp to protect it
from wet weather.
• Do not leave the vehicle in the sun for long periods of time or
fading may occur. Store in shade or cover with tarp.
• Do not wash the vehicle with a hose.
• Do not wash the vehicle with soap and water.
RE-CHARGE INTERVAL AND TIME
• Never leave child unattended. Always supervise the child.
Important!
• Always sit in the seat when using the vehicle.
• Damage to the battery may occur if it is allowed to drain
completely. Do not allow the battery to drain completely.
• Keep your hands, hair and clothes away from moving parts.
• Always wear shoes when using the vehicle.
• Only one rider is allowed in the vehicle at a time.
• Children under 3 years of age cannot use the vehicle.
• Only drive on level ground.
• Do not go near swimming pools or other bodies of water,
drop-offs or up and down steep inclines.
• Do not drive the vehicle into loose dirt, mud, sand or fine gravel.
• Do not drive the vehicle on streets or near cars.
4
CARE WARNINGS
• Check the battery and charger (supply cord, connector) for wear
and damage before charging. Do not charge the battery if
damage has occurred. Only replace with a Kid Trax Toys 6V
rechargeable battery and charger.
On average you will need to charge the battery between 10 and 14
hours. Do not charge the battery for more than 20 hours. Failure to
charge the battery as directed could cause permanent damage to
the battery and void the warranty.
2
Parts
5
3
Assembly
❿
❼
❾
❾ ❽
❾
6
❽
❷
❻
❶
❻
❶
❹
❸ ❹
❸
❹
❺
❿
❾
❾❽
❼
❺
❸
❶
❷
❷
❻
❹❺
❹
❺
7
1
2
3
8
3
2
1
6
1
4
5
5
9
7
7
8
1
8
2
10
2
5
3
4
4
4
12
Use
12
3
20+
1
2
13
5
Maintenance
The vehicle should be checked for damage, missing or badly worn
parts before use.
• Check the tightness of the fasteners before each use.
1
• Check the tightness of the wheels.
• Ensure the battery is securely in place before use
• Occasionally use lightweight oil to lubricate moving parts such as
wheels and steering linkage.
• Do not use oil on plastic or nylon parts. No lubrication is
required.
• Store the vehicle indoors or cover it with a tarp to protect it from
the wet weather. Keep it away from sources of heat, such as
stoves and heaters.
• Clean the vehicle with a soft, dry cloth. To restore shine to plastic
parts, use a non-wax furniture polish. Do not use car wax,
abrasive cleaners or wash the vehicle with soap and water. Water
will damage the motor, electrical system and battery.
• KidTrax Toys recommends that you take the vehicle to an
authorized service center for periodic maintenance and service.
Call Kid Trax Toys Consumer Relations at 877-741-6154 for an
authorized service center.
14
2
2
3
4
7
5
8
15
6
Troubleshooting
The following are examples of potential problems. Completely read through this manual and the troubleshooting guide table before calling
Kid Trax Toys Consumer Relations. If you still need help resolving the problem please call 877-741-6154. Kid Trax Toys recommends that
you take the vehicle to an authorized service center for periodic maintenance and service. Call the number listed above for the closest
center to you.
Problem
Vehicle does not run
Possible Cause
Remedy
Battery low on power
Recharge battery (see Battery: Recharge Interval and Time)
Thermal fuse has tripped
Let the vehicle rest for 5 to 10 minutes before continuing normal
operation. (see Maintenance)
Battery connector or wires are loose
Check that the battery connectors are firmly plugged into each
other. If wires are loose around the motor call Consumer
Relations at 877-741-6154 for an authorized service center
Battery is dead
Replace battery (see Battery: Replacement and Disposal)
Electrical system is damaged
Call Consumer Relations at
877-741-6154 for an authorized service center
Motor is damaged
Call Consumer Relations at
877-741-6154 for an authorized service center
Vehicle does not run very
long
Battery is under charged
Check that the battery connectors are firmly plugged into each
other when recharging (see Battery: Recharge Interval and Time)
Loud grinding or clicking
noises coming from motor
or gear box
Motor or gears are damaged
Call Consumer Relations at 877-741-6154 for an authorized
service center
16
Problem
Vehicle runs sluggishly or
beeping occurs
Vehicle needs a push to
go forward
6V Battery will not
recharge
Possible Cause
Remedy
Battery low on power
Recharge battery (see Battery: Recharge Interval and Time)
Battery is old
Replace battery (see Battery: Replacement and Disposal)
Vehicle is overloaded
Reduce weight on vehicle (see User Requirements and
Safety Warnings)
Vehicle is being used in harsh
conditions
Operate the vehicle level ground and firm surfaces (see User
Requirements and Safety Warnings)
Poor contact of wires or connectors
Check that battery connectors are firmly plugged into each other.
If wires are loose around the motor call Consumer Relations at
877-741-6154 for an authorized service center
“Dead Spot” on motor
A dead spot means the electric power is not being delivered to the
terminal connection and the vehicle needs repair. Call Consumer
Relations at 877-741-6154 for an authorized service center
Battery connector or adapter
connector is loose
Check that battery connectors are firmly plugged into each other
Charger not plugged in
Check that battery charger is plugged into a working wall outlet
Charger is not working (lights not
glowing)
Call Consumer Relations at 877-741-6154 for an authorized
service center
Battery bubbles or gurgles This is normal and not a cause for
when charging
concern
Charger feels warm when
recharging
This is normal and not a cause for
concern
17
7
Service
Do not return this product to the place of purchase. If your vehicle
needs service, repairs or replacement parts, call:
KidTrax Toys Consumer Relations
Hours: 8:00 am – 5:00 pm (CST) Monday - Friday
Phone: 877-741-6154
Email: [email protected]
Web: www.kidtraxtoys.com
For service and repairs you will be directed to an authorized service
center. To order parts have the model and serial number, found
underneath the seat on the battery cover.
The following is a list of available replacement parts:
• Wheels
• Hardware bag for wheel assembly
• Steering assembly
• 6-volt KidTrax battery
• Battery Charger
18
8
Warranty
One-Year Limited Warranty
Six-Month Limited Warranty on Battery
Pacific Cycle, Inc. (PC) warrants this product to the original retail purchaser as follows: The vehicle (except for the 6-volt battery) is warranted
against defective materials or workmanship for one year from the date of original purchase. The 6-volt battery is warranted against defective
materials or workmanship for six months from the date of original purchase. An original receipt is required to validate your warranty. PC will,
at its option, provide replacement parts or replace this product. PC reserves the right to substitute if the part or model has been discontinued.
To make a claim under this warranty you may contact us at www.kidtraxtoys.com; fax us at 1-800-858-2800, 24 hours a day; write to KidTrax
Consumer Relations Department, KidTrax Toys, P.O. Box 344 Olney, IL 62450 or call 1-877-741-6154 from 8 a.m. to 5 p.m., Monday through
Friday, CST. Proof of purchase is required, and shipping charges are the responsibility of the consumer.
Warranty Limitations
This warranty does not include damages which arise from accident, misuse, abuse, neglect or other causes not arising out of defects in
materials or workmanship, nor does it cover damages arising out of service by other than an authorized PC service center. For personal use
only. Not for commercial use. The original owner shall pay all labor charges connected with the repair or replacement of all parts. Under no
circumstances does this limited warranty include the cost of shipment or transportation to or from an authorized Kid Trax repair center or Kid
Trax retailer.
Limitation of Damages:
The warranty and remedies as set forth are exclusive and in lieu of all others, oral or written, expressed or implied. In no event will PC or the
dealer selling this product be liable to you for any damages, including incidental or consequential damages, arising out of the use or inability to
use this product. Some states do not allow limitations as the exclusion or limitation of incidental or consequential damages, so the above
limitation may not apply to you.
Limitation of Warranties and Warranty Terms
Any implied warranties, including implied warranties of the merchantability and fitness for a particular purpose, shall be limited to the
duration and terms of the express written warranty. Some states do not allow limitations as the exclusion or limitation of incidental or
consequential damages, so the above limitation may not apply to you. This warranty gives you specific legal rights, and you may have other
rights, which vary from state to state. Neither PC nor the dealer selling this product authorized any person to create for it any other warranty,
obligation or liability in connection with this product.
19
© 2014 Pacific-Cycle Inc.
4902 Hammersly Rd.
Madison, WI 53711
Styles and colors may vary. Made in China
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement