Wiring Schematic Info

Wiring Schematic Info
240V
P35
P35
120V
OZONE CONNECTOR
240V
VOLTAGE
120V
240V
P72
P72
GREEN / GROUND
P73
P73
WHITE / COM
P49
P59
WHITE / COM
P46
P60
BLACK / LINE
P25
P25
BLACK / LINE
P30
P30
TC-MP-P122-P222-O1-A11-A21-2H35.0
-RTC-IR-SPW-AU11-JJM-CC5
13315-01F
P105
P61
P34
P34
LIFTER POWER
P112
P112
LIFTER UP/DOWN
P106
P102
P21, P56
PUMP #2 HIGH
LIFTER 12V
HEATER #1
HEATER #2
12VDC 4A
17A
5A
SERIAL # :
Fuses are located under the cover.
Replace only with the same type of fuses.
INPUT 12VDC 4A
INPUT 240VAC 60Hz 48A MAX
Model:
COM PORT
P5
Options:
TC-MP-P122-P222-O1-A11-A21-2H35.0
TEMP. PROBE
0200-205012
P15 P16
LIGHT
P7
P17
PUMP #3 /
HEATER #2
HIGH LIMIT #2
P13
P63
P20
HEATER#2
OUTPUT
240 VAC
HIGH LIMIT
PROBE
SPA
WATCH
BONDING LUG
P9
HEATER#1
OUTPUT
240 VAC
P14
P10
P44
RTC-IR-SPW-AU11-JJM-CC5
ID Number:
F1
P35
P56
WARNING:
BEFORE OBTAINING ACCESS TO TERMINALS,
ALL SUPPLY CIRCUITS MUST BE DISCONNECTED
KEYPAD WITHOUT
DISPLAY (CABLE IS
POLARISED )
20FLA
20FLA
3.8A
1A
12VAC 2A
1A
1A
P21
HEATER
HIGH LIMIT #1
P67
WARNING
- WATER TEMPERATURE IN EXCESS OF 38°C MAY BE INJURIOUS TO YOUR HEALTH.
- DISCONNECT THE ELECTRIC POWER BEFORE SERVICING.
JUMPER WIRE
P66
- CSA ENCLOSURE 2. FOR INDOOR USE ONLY.
- TEST THE GROUND FAULT CIRCUIT INTERRUPTER BEFORE EACH USE OF THE SPA.
- READ THE INSTRUCTION MANUAL.
- ADEQUATE DRAINAGE MUST BE PROVIDED IF THE EQUIPMENT IS TO BE INSTALLED IN A PIT.
LINE2
P53
P55
P60
P57
P62
CAUTION
P23
P54
P58
P61
P59
- USE COPPER CONDUCTORS ONLY.
- CONNECT ONLY TO A CIRCUIT PROTECTED BY A CLASS A, GROUND FAULT CIRCUIT
INTERRUPTER (GFCI).
- A DISCONNECTING MEANS MUST BE INSTALLED WITHIN SIGHT FROM THE EQUIPMENT AND
AT LEAST 5 FT (1.52m) FROM THE INSIDE WALLS OF THE HOT TUB.
- FOR SUPPLY CONNECTION, USE CONDUCTORS SIZED ON THE BASIS OF 60°C AMPACITY
BUT RATED MINIMUM 90°C.
- CAUTION: WIRING CONNECTED IN THIS BOX MUST BE RATED AT LEAST 300V.
- PLEASE MAKE SURE THAT LOW-LEVEL PROGRAMMING IS PROPERLY SET AFTER INITIAL POWER-UP.
GND
LINE2
3A/250VAC FAST-ACT.
P52
P11 P12
P53
P52
PUMP3/HEATER2
P71
P40
BLACK / LINE
AUXILIARY I/O
PUMP #1
PUMP #2
BLOWER
OZONE
LIGHT
FIBER BOX
ACCESSORY
Options:
RTC-IR-SPW-AU11-JJM-CC5
P4
P18
25A/480VAC TIME-DELAY
CLASS G
P71
WHITE / COM
F2
F5
P43
P82
GREEN / GROUND
GND
F3
P2
P3
REGULATION
240V
NEUTRAL
P101
120V
NEUTRAL
P47
P41 P50
P40 P42
P45 P46
P48 P49
VOLTAGE
INPUT
120 VAC
240 VAC
60 Hz
KEYPAD
WITH DISPLAY
1
FAN 2 CONNECTOR
F4
1A/250VAC
FAST-ACT.
PUMP #2 LOW
P1
I2C
P36
JMP1
JMP2
JMP3
JMP4
JMP5
JMP6
JMP7
JMP8
PUMP2
P36
LINE1
EXT. XFO
BLACK / LINE
LINE1
P90
P74
P54
1
240V
P74
P41
JUMPERS
P31
120V
WHITE / COM
ACC
VOLTAGE
GREEN / GROUND
30A/480VAC TIME-DELAY
CLASS G
FAN 1 CONNECTOR
PUMP #1 LOW
AUX.1
AUXILIARY
CONTROL
HEATER #2 (1Kw)
EXT.
I/O #1
P63, P44
EXT.
I/O #2
P22
240V
HEATER #1 (4Kw)
HEATER CONNECTOR
P32
P39
VOLTAGE
P28
OZONE
P80
P83
P34
P24
RED / MOTOR
20A/600VAC TIME-DELAY
CLASS G
BLACK / LIGHT
PUMP1
P50
CIRC.
PUMP
30A/480VAC TIME-DELAY
CLASS G
P75
WHITE / COM
F8
P38
P37
GREEN / GROUND
PUMP #1 HIGH
AUX.2
MAIN
CONTROL
P115
P26 P25
P24
P115
P33
GROUND
IR
RECEIVER
P8
P65
P27
#2
P30
P81
120V
#1
P51
VOLTAGE
LIFTER 12V
LIFTER
P69 P70 P73 P74
P68 P71 P72 P75 P77
FIBER BOX CONNECTOR
ID 0200-205012
Model:
TC-MP-P122-P222-O1-A11-A21-2H35.0
I2C OUT
DVD
P47
BLACK / LINE
P28
WHITE / COM
P29
P77
I2C IN
P52
P36
P77
P14
P64
GREEN / GROUND
LIGHT 1
LINE1
240V
LINE2
120V
LINE1
VOLTAGE
P109
LIGHT CONNECTOR
LINE2
ACCESSORY CONNECTOR
0VDC
P116
P117
10A / 3AG TD
FUSE
BLOWER CONNECTOR
VOLTAGE
GREEN / GROUND
P115
P112
LIGHT 1
PRESSURE
SWITCH
TEMP. PROBE
BLACK / HIGH SPEED
P106
SERIAL LINK
P65
P102
AUX. I/O #4
P65
P101
RADIO
BLACK / HIGH SPEED
LIFTER
+12 VDC
OPTIONNAL
SIDE PANEL
P22
120 VAC
P58
P22
AUX
#4
P45
RED / LOW SPEED
TV
DVD TUNER RADIO
WHITE / COM
P37
P122
P57
P37
P119 P120 P121
P48
TV TUNER
P70
WHITE / COM
RED / LOW SPEED
AUX. I/O #1
P70
STANDARD
SIDE PANEL
120V
GREEN / GROUND
IR RECEIVER
P69
BLOWER
P69
FIBER
BOX
GREEN / GROUND
VOLTAGE
PUMP #2
PUMP #2 CONNECTOR
240V
OZONE
120V
PUMP #1
PUMP #1 CONNECTOR
VOLTAGE
F
NOTES ADDED
E
MODIFIED TO GECKO, BLOWER ADDED
MAY 07 M.C.
D
LIFTER CONNECTION MODIFIED
NOV 06 M.C.
C
EXM-5 AND TV LIFTER REMOVED, FIBER BOX ADDED
MAY 06 M.C.
B
LIFTER CONNECTION MODIFIED RF BOX REMOVED
A
ORIGINAL
NO.
REVISION
JUN 07
FEB 06
M.C.
M.C.
DEC 05 M.C.
DATE
PAR
APP.
FICHIER :
13315-01F
LOGICIEL :
CORELDRAW 9
PRINT DATE:
JUN 26, 2007
450, Des Canetons
Québec, (Québec)
G2E 5W6
Tel.: (418) 872-4411
Fax: (418) 872-0920
CONCU PAR :
DATE
DESSINE PAR : M. CAOUETTE
DESCRIPTION
TC-MP-P122-P222-O1-A11-A21-2H35.0
-RTC-IR-SPW-AU11-JJM-CC5
ENSEMBLE
DATE
DEC 21, 2005
VERIFIE PAR :
DATE
0200-205012
APPROUVE PAR :
DATE
ECHELLE
1"=1"
NUMERO DE PIECE
POUR FIN DE
FEUILLE
1 DE 1
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement