470msds

470msds
MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417
CHEMTREC: (800) 424-9300
REVISION DATE: November 11, 2004
DATE OF ISSUE: December 29, 2004
I - Product Identification
Windshield Deicer Concentrate
PRODUCT CODE: 0470
CHEMICAL FORMULATION: Alcohol based cleaner.
NFPA HAZARD IDENTIFICATION SYSTEM:
HEALTH: 1
HAZARD RATING:
4 - Extreme;
3 - High;
FLAMMABILITY: 3
2 - Moderate;
1 - Slight;
REACTIVITY: 0
0 - Insignificant
II - Hazardous Ingredients
SUBSTANCE
Methanol
Key:
Values reported as TWA unless noted.
APPROX
OSHA
ACGIH
EPA 40 CFR:
%
PEL
TLV
302
355
372
65.0-75.0
200 ppm
200 ppm
Y
N
Y
CAS #
67-56-1
PEL: Permissible Exposure Limit
TLV: Threshold Limit Value
C: Ceiling level
STEL: Short Term Exp osure Limit
N/A: Not Applicable
N/D: Not Determined
N/E: Not Established
Y: Yes
N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (°F): N/D
VAPOR PRESSURE (mm Hg): N/D
VAPOR DENSITY (AIR = 1): N/D
SOLUBILITY IN WATER: Soluble
APPEARANCE AND ODOR: Clear, dark blue liquid; alcohol odor.
SPECIFIC GRAVITY (WATER = 1): 0.875
VOC CONTENT (% by weight): 65.0-75.0
EVAPORATION RATE (WATER = 1): N/D
pH: N/A
IV - Fire and Explosion Hazard Data
FLASH POINT (°F): < 70
(TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %)
UPPER: N/D
LOWER: N/D
EXTINGUISHING MEDIA: Water, foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Vapors may travel considerable distance to a source of ignition and flash back.
PRODUCT NAME: Windshield Deicer Concentrate
PRODUCT CODE: 0470
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizers.
CONDITIONS TO AVOID: Heat, sparks and open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY
INHALATION: X
EYE CONTACT: X
SKIN CONTACT: X
INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: Mild irritation and redness, tearing, blurred vision. May injure eye tissue if not removed promptly.
IF ON SKIN: Redness, dryness, irritation, defatting with prolonged or repeated exposure.
IF SWALLOWED: Gastrointestinal irritation, dizziness, drowsiness, drunkenness, weakness, CNS depression. May be harmful or fatal if
swallowed. Small amounts of the liquid aspirated into the respiratory system during ingestion, or from vomiting, may cause
bronchiopneumonia or pulmonary edema.
IF INHALED: Respiratory tract irritation, nausea, vomiting, headache and dizziness.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical attention.
IF ON SKIN: Wash with soap and water. Remove contaminated clothing and launder before reuse. If irritation persists, obtain medical
attention.
IF SWALLOWED: Contact physician or poison control center immediately. Give affected person one to two glasses of water. Do not
induce vomiting unless told to do so by a physician or poison control center. Never give anything by mouth to an unconscious person.
IF INHALED: Remove person to fresh air. If breathing has stopped administer artificial respiration. If breathing is difficult, administer
oxygen.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and remove all source of ignition. Soak up spilled
material with inert absorbent material and place in a properly labeled container for proper disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH approved
respirator, following manufacturer’s recommendations.
VENTILATION
LOCAL: Recommended
MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or chemical goggles
OTHER PROTECTIVE EQUIPMENT: Eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat or open flame. Keep
container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: Compounds, cleaning liquid (Methanol)
DOT CLASS: 3
DOT ID NUMBER: NA1993
DOT PACKING GROUP: II
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportat ion is
further intended, different shipping names and labeling may apply.
REVISION DATE: November 11, 2004
Prepared by: PMR
DATE OF ISSUE: December 29, 2004
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this
data or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee,
users or third parties caused by the material such vendees or users assume all risks associated with the use of this material.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement