RedLine RO428 SDS

RedLine RO428 SDS
SAFETY DATA SHEET
according to 29 CFR 1910 (OSHA HCS)
Revision Date: 5/7/2015
Preparation # 151411710006
SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1
Product identifiers
Product name
1.2
Relevant identified uses of the substance or mixture and uses advised against
Identified uses
1.3
:
Cutting Oil
Details of the supplier of the safety data sheet
Company
Productivity Inc.
15150 25th Ave N
Plymouth, MN 55447
:
Telephone
Fax
1.4
RedLine RO428
:
+1 763-476-8600
+1 763-742-1206
:
:
Emergency Telephone Number
Emergency Phone #
:
1-800-422-0798
SECTION 2: Hazards Identification
2.1
Classification of the substance or mixture
GHS Classification in accordance with 29 CFR 1910 (OSHA HCS)
Not Hazardous
2.2
2.3
Label Elements
Hazard Symbols
Signal Word
Hazard Statements
Precautionary Statements
:
:
:
:
No symbol
No signal word
This product does not require any hazard statements
This product does not require any precautionary statements
Other Hazards
:
Used oil may contain harmful impurities. Not classified as flammable but will
burn.
SECTION 3: Composition/information on ingredients
Mixtures
Chemical nature
of the product
:
Petroleum Hydrocarbon Mixture
Concentrations of Ingredients
Not applicable.
SECTION 4: First aid measures
4.1
Description of first aid measures
Page 1 of 6
General Information
:
Not expected to be a health hazard when used under normal conditions.
Eye Contact
:
Rinse immediately with plenty of water for at least 15 minutes. If symptoms
persist obtain medical attention.
Skin Contact
:
Wash off with soap and plenty of water; remove all contaminated clothes and
shoes.
Ingestion
:
Gently wipe or rinse the inside of the mouth with water. In general no treatment
is necessary unless large quantities are swallowed, however obtain medical
advice. Do NOT induce vomiting. Never give anything by mouth to an
unconscious person.
Inhalation
:
Move to fresh air. No treatment necessary under normal conditions of use. If
symptoms persist, obtain medical advice.
4.2
Most important symptoms and effects, both acute and delayed
Ingestion may result in nausea, vomiting, and or diarrhea.
4.3
Indication of any immediate medical attention and special treatment needed
Immediate medical attention not required under normal conditions of use.
SECTION 5: Firefighting measures
5.1
Extinguishing media
Foam, water spray or fog. Dry chemical powder, carbon dioxide, sand or earth may be used for small fires only.
Do not use water in a jet.
5.2
Specific hazards arising from the substance or mixture
Hazardous combustion products may include: A complex mixture of airborne solid and liquid particulates and
gases (smoke). Carbon monoxide. Unidentified organic and inorganic compounds.
5.3
Advice for Firefighters
Proper protective equipment including breathing apparatus must be worn when approaching a fire in a confined
space.
SECTION 6: Accidental release measures
6.1
Personal precautions, protective equipment, and emergency procedures
Avoid contact with skin and eyes. Ensure adequate ventilation to maintain oil mist below control parameters in
section 8.1
6.2
Environmental precautions
Avoid release to the environment. Prevent further leakage or spillage if safe to do so. Prevent the material from
spreading and entering drains by using sand, earth, or other barriers.
6.3
Methods and material for containment and cleaning up
Slippery when spilt. Avoid accidents, clean up immediately.
Contain spillage, and then collect with non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth,
vermiculite) and place in container for disposal according to local / national regulations.
6.4
Additional Advice
Refer to protective measures listed in section 7 and 8. For disposal see section 13.
SECTION 7: Handling and storage
General Precautions
Use local exhaust ventilation if there is risk of inhalation of vapors, mists or aerosols. Properly dispose of any
contaminated rags or cleaning materials to prevent fires.
Page 2 of 6
7.1
Precautions for safe handling
Handle in accordance with good industrial hygiene and safety practice.
7.2
Conditions for safe storage, including any incompatibilities
Keep container tightly closed and in a cool place.
SECTION 8: Exposure controls/personal protection
8.1
Control parameters
Occupational Exposure Limits
Material
CAS No.
TLV or PEL
Oil mist, mineral
64742-52-5
5 mg/m3
Biological limit values
Data not available
8.2
Appropriate engineering controls
Wash hands before breaks and at the end of workday.
Maintain air concentrations below occupational exposure standards.
Remove and wash contaminated clothing before re-use.
Material can create slippery conditions.
Control of environmental exposure
Stop leak or spill if possible. Prevent material from entering drains.
8.3
Individual protective measures such as personal protective equipment
Eye Protection
Wear tightly fitting safety goggles or face shield if splashes are likely to occur.
Hand Protection
Where hand contact with the product may occur the use of gloves approved to relevant standards may provide
suitable protection: PVC, neoprene or nitrile rubber gloves. Gloves should only be worn on clean hands.
Skin Protection
Skin protection not ordinarily required beyond standard issue work clothes.
Respiratory Protection
No respiratory protection is ordinarily required under normal conditions of use. In accordance with good industrial
hygiene practices, precautions should be taken to avoid breathing of material. In case of insufficient ventilation
wear suitable respiratory equipment with filter for organic vapor.
SECTION 9: Physical and Chemical Properties
9.1
Information on basic physical and chemical properties
a)
Appearance
:
Transparent amber fluid
b)
Odour
:
Slight hydrocarbon
c)
Odour Threshold
:
No data available
d)
pH
:
Not applicable
Page 3 of 6
e)
Melting point/freezing :
point
Initial boiling point
:
and boiling range
No data available
g)
Flash point
:
340 °F min.
h)
Evaporation rate
:
No data available
i)
Flammability (solid,
gas)
:
No data available
j)
Upper/lower
flammability or
explosive limits
:
Upper explosion limit: no data available
Lower explosion limit: no data available
k)
Vapor pressure
:
No data available
l)
Vapor density (air=1)
:
> 1 (estimated)
m)
Relative density
:
0.93 g/mL at 25 °C / 77 °F
n)
Water solubility
:
Negligible
o)
Partition coefficient:
n-octanol/water
:
> 6 (based on information of similar products)
p)
Auto-ignition
Temperature
:
No data available
q)
Decomposition
Temperature
:
No data available
r)
Kinematic Viscosity
:
135 SUS at 100 °F
:
Not applicable
f)
9.2
Other Information
No data available
SECTION 10: Stability and reactivity
Reactivity
Data not available.
Chemical stability
Stable under normal conditions.
Possibility of hazardous reactions
None under normal processing. Reacts with strong oxidizing agents.
Conditions to Avoid
Extremes of temperature and direct sunlight.
Incompatible Materials
Strong oxidizing agents.
Hazardous decomposition products
Hazardous decomposition products are not expected to form during normal storage.
SECTION 11: Toxicological information
11.1 Information on toxicological effects
Basis for assessment
Information given based on data on the components and toxicology of similar products.
Page 4 of 6
Likely routes of exposure
Skin and eye contact are primary routes of exposure. Exposure may occur following accidental ingestion.
Acute toxicity
Expected to be of low toxicity.
Skin corrosion/irritation
May cause skin irritation after prolonged exposure. Prolonged exposure or repeated exposure without proper
cleaning can clog pores of the skin.
Serious eye damage/eye irritation
Expected to be slightly irritating.
Respiratory irritation
Inhalation of vapors or mists may cause irritation.
Respiratory or skin sensitization
Not expected to cause respiratory or skin sensitization.
Germ cell mutagenicity
Not considered a mutagenic hazard.
Carcinogenicity
No component of this product is identified as a probable, possible, or confirmed carcinogen by IARC, NTP,
Monographs, or OSHA.
Reproductive toxicity
Not expected to be a hazard.
Specific target organ toxicity - single exposure
Not expected to be a hazard.
Specific target organ toxicity - repeated exposure
Not expected to be a hazard.
Aspiration hazard
Not considered an aspiration hazard.
Additional Information
Used oils may contain harmful impurities that have accumulated during use. The concentration of such impurities
will depend on use and may present risks to health and the environment on disposal. Used oil should be handled
with caution and skin contact should be avoided when possible.
SECTION 12: Ecological information
12.1
Toxicity
Eco-toxicity effects
Ecotoxicological data have not been determined specifically for this product. Information is based on a knowledge
of the components and ecotoxicology of similar products. Expected to be practically nontoxic: LL/EL/IL50 >
100mg/l (to aquatic organisms). Not expected to cause chronic effects to aquatic organisms at concentrations
less than 1mg/L.
12.2
Persistence and degradability
No information available
12.3
Bioaccumulative potential
No information available
12.4
Mobility in soil
Liquid under most conditions. Floats on water. If it enters soil, it will adsorb to soil particles and will not be mobile.
12.5
Other adverse effects
No information available
Page 5 of 6
SECTION 13: Disposal Considerations
13.1
Waste treatment methods
Product Disposal
Recover or recycle if possible. Dispose in accordance with applicable regulations. Do not dispose into the
environment, in drains, or in water courses.
Contaminated packaging
Dispose in accordance with applicable regulations, preferably to a recognized collector or contractor.
SECTION 14: Transportation information
14.1
UN number
:
Not applicable
14.2
UN proper shipping name
:
Not applicable
14.3
Transport hazard class(es) :
Not applicable
14.4
Packaging group
:
Not applicable
14.5
Environmental hazards
:
Not applicable
14.6
Special precautions
for user
:
Not applicable
SECTION 15: Regulatory information
This safety datasheet complies with the requirements of 29 CFR 1910 (OSHA HCS)
15.1
Safety, health and environmental regulations/legislation specific for the substance or mixture
Not available
SECTION 16: Other Information
HMIS Rating
HEALTH
FLAMMABILITY
REACTIVITY
PERSONAL PROTECTION
:
:
:
:
1
1
0
B
TLV = Threshold Limit Exposure (ACGIH)
Preparation Date
:
PEL= Permissible Exposure Limit (OSHA)
5/7/2015
All reasonably practicable steps have been taken to ensure this data sheet and the health, safety and environmental
information contained in it is accurate as of the date specified below. No warranty or representation, express or implied is
made as to the accuracy or completeness of the data and information in this data sheet.
Page 6 of 6
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement