IC693MDL330

IC693MDL330
This Datasheet is for the
IC693MDL330
120/240 Volt AC Output - 2 Amp, 8 Point
http://www.cimtecautomation.com/parts/p-14652-ic693mdl330.aspx
Provides the wiring diagrams and installation guidelines for this GE Series 90-30
module.
For further information, please contact Qualitrol Technical Support at
1-800-784-9385
[email protected]
7
120/240 Volt AC Output - 2 Amp, 8 Point
IC693MDL330
This 2 amp AC output module has a catalog number with a D or later suffix (i.e.,
IC693MDL330D); previous versions (modules with a C or earlier suffix) were rated at 1 amp.
The 120/240 volt, 2 Amp AC Output module for the Series 90-30 Programmable Logic
Controller provides 8 output points in two isolated groups with four points in each group. Each
group has a separate common associated with it. The two commons are not tied together
inside the module. This allows each group to be used on different phases of the AC supply, or
they can be powered from the same supply. Each group is protected with a 5 amp fuse for
each common, and an RC snubber is provided for each output to protect against transient
electrical noise on the power line. This module provides a high-degree of inrush current (10x
the rated current) which makes the outputs suitable for controlling a wide range of inductive
and incandescent loads. AC Power (DC power cannot be used) to operate loads connected to
outputs must be supplied by the user.
LED indicators which provide the ON/OFF status of each point are located at the top of the
module. There are two horizontal rows with eight green LEDs in each row and a red LED
centered between and to the right of the two rows. This module uses the upper eight LEDs,
labeled A1 through 8 for output status. The red “F” LED is a blown fuse indicator that turns
ON if any of the fuses should blow. An insert goes between the inside and outside surface of
the hinged door. The surface towards the inside of the module (when the hinged door is
closed) has circuit wiring information, and circuit identification information can be recorded
on the outside surface. The outside left edge of the insert is color-coded red to indicate a
high-voltage module. This module can be installed in any I/O slot of a 5 or 10-slot baseplate in
a Series 90-30 PLC system.
Table 7-4. Specifications for IC693MDL330
Rated Voltage
Output Voltage Range
Outputs per Module
Isolation
120/240 volts AC
85 to 264 volts AC, 50/60 Hz
8 (two groups of four outputs each)
1500 volts between field side and logic side
500 volts between each group
Output Current 2 amp maximum per point
4 amps maximum per group at 40 C (104F)
Output Characteristics
Inrush Current
Minimum Load Current
Output Voltage Drop
Output Leakage Current
On Response Time
Off Response Time
Power Consumption
20 amps maximum for one cycle
100 mA
1.5 volts maximum
3 mA maximum at 120 volts AC
6 mA maximum at 240 volts AC
1 ms maximum
1/2 cycle maximum
160 mA (all outputs on) from 5 volt bus on backplane
Maximum load current is dependent upon ambient temperature as shown in graph on following page.
Refer to Appendix B for product standards and general specifications.
7-6
Series 90-30 PLC I/O Module Specifications – July 2000
GFK-0898F
Discrete Output Modules
7
IC693MDL330 Output Module Field Wiring Information
The following figure provides wiring information for connecting user
supplied input devices and power source to the 120/240 volt AC output, 2 Amp
module.
a43105
MODULE CIRCUITRY
TERMINALS
1
OPTICAL
COUPLER
100Ω
47
FIELD WIRING
NC
2
Î
Î
Î
3
A1
NC
4
5
A2
NC
6
7
A3
NC
8
OTHER CIRCUITS
9
.047
A4
NC
10
5A
11
H
~
N
NC
A5
12
13
NC
14
A6
NC
15
16
17
A7
NC
18
19
A8
NC
20
H
~
N
Figure 7-4. Field Wiring - 120/240 Volt AC Output, 2 Amp Module IC693MDL330
a43703
8
4
TOTAL
MODULE
LOAD
2
CURRENT
(AMPS)
2 AMPS
1
10°C
20°C 30°C 40°C 50°C 60°C
AMBIENT TEMPERATURE (°C)
Figure 7-5. Input Points vs. Temperature for IC693MDL330
GFK-0898F
Chapter 7 – Discrete Output Modules
7-7
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement