Installation Instructions for Cessna 210 with Air Conditioning Kit RCS-300-4

Installation Instructions for Cessna 210 with Air Conditioning  Kit RCS-300-4
Installation Instructions for Cessna 210 with Air Conditioning
and all P210 models
Kit RCS-300-4
(R1180004)
Doc: 9051-0118-018
This is a FAA STC’d installation requiring a logbook entry upon completion.
Rev
Date
Approved
D 2/1/2008
GH
Installing your Rosen Sunvisor System is easily performed, and should take approximately 15 to 30
minutes.
Please read these short instructions COMPLETELY before starting.
Tools required:
Phillips screwdriver
5/32 Allen Key
9/64 Allen Key
Installation Hardware (included):
Qty:
(4)
MS1699530B
(2)
PS8C16CPG02NA
(4)
AN960C8L
(2)
A8K75
#8-32 x 1 Socket Head Cap Screw
#8-32x1” Pan Head, Nylon Washered Screw
#8 Washer
#8-32 Rivnut
•
Remove both old visors using a Phillips screwdriver.
•
Mount the visor assembly marked “Pilot’s Side” on the pilot’s side of the aircraft with the two #8-32
Socket Head Cap Screws and washers (supplied) and the 5/32” hex key (supplied). These mount
into the original hard points in the aircraft. Slots are provided to allow for miss mounting of the
original visors.
•
Tighten the pilot’s side visor securely.
•
Repeat the procedure for the co-pilot’s side.
Note:
If at any point in the future you feel there is too much flex in the bracket when the visor is
extended to the rear, an 8-32 rivnut and an 8-32x1” washered fastener are included to mount to
the spar using the extra 3/16” hole in the black anodized bracket.
86365 College View Road
Eugene, Oregon USA 97405
www.rosenvisor.com
541.747.0034
Page 1 of 2
Continued Airworthiness Instructions:
•
•
(On the ground only)
o
Periodically clean the lenses with a soft cloth, mild soap and water or an approved
aviation grade windscreen cleaner. Do not use abrasives on the lens.
o
Periodically adjust the pivot tensions on the visor assemblies.
Updates to this continued airworthiness section is available on the Rosen Website.
(www.rosenvisor.com)
The most up to date version of this document is available on the Rosen Website. (www.rosenvisor.com)
Airworthiness Limitations:
The Airworthiness Limitations Section is FAA approved and specifies maintenance required under
§§43.16 and 91.403 of the Federal Aviation Regulations unless an alternative program has been FAA
approved.
There are no airworthiness limitations associated with this installation.
86365 College View Road
Eugene, Oregon USA 97405
www.rosenvisor.com
541.747.0034
Page 2 of 2
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Related manuals

Download PDF

advertisement