Samsung | SGH-E200 | Samsung SGH-E200 service manual

GSM TELEPHONE
SGH-E200
GSM TELEPHONE
CONTENTS
1.
Safety Precautions
2.
Specification
3.
Operation Instruction and
Installation
4.
Array course control
5.
Exploded View/Disassembly
and Assembly Instructions
6.
MAIN Electrical Parts List
7.
Block Diagrams
8.
PCB Diagrams
9.
Flow Chart of Troubleshooting
10.
Reference data
1. Safety Precautions
1-1. Repair Precaution
● Repair in Shield Box, during detailed tuning.
Take specially care of tuning or test,
because specipicty of cellular phone is sensitive for surrounding interference(RF noise).
● Be careful to use a kind of magnetic object or tool,
because performance of parts is damaged by the influence of magnetic force.
● Surely use a standard screwdriver when you disassemble this product,
otherwise screw will be worn away.
● Use a thicken twisted wire when you measure level.
A thicken twisted wire has low resistance, therefore error of measurement is few.
● Repair after separate Test Pack and Set because for short danger (for example an
overcurrent and furious flames of parts etc) when you repair board in condition of
connecting Test Pack and tuning on.
● Take specially care of soldering, because Land of PCB is small and weak in heat.
● Surely tune on/off while using AC power plug, because a repair of battery charger is
dangerous when tuning ON/OFF PBA and Connector after disassembling charger.
● Don't use as you pleases after change other material than replacement registered on SEC System.
Otherwise engineer in charge isn't charged with problem that you don't keep this rules.
1-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Safety Precautions
1-2. ESD(Electrostatically Sensitive Devices) Precaution
Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD
(Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.
You can prevent from ESD damage by static electricity.
● Remove static electricity remained your body before you touch semiconductor or parts with
semiconductor. There are ways that you touch an earthed place or wear static electricity
prevention string on wrist.
● Use earthed soldering steel when you connect or disconnect ESD.
● Use soldering removing tool to break static electricity. , otherwise ESD will be damaged by
static electricity.
● Don't unpack until you set up ESD on product. Because most of ESD are packed by box and
aluminum plate to have conductive power,they are prevented from static electricity.
● You must maintain electric contact between ESD and place due to be set up until ESD is connected
completely to the proper place or a circuit board.
1-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
2. Specification
2-1. GSM General Specification
G SM 90 0
Ph ase 1
EG SM 9 00
Ph ase 2
DCS1800
Ph ase 1
PCS1900
Fr eq.
Band[MHz]
Uplin k/Down link
8 90~915
9 35~960
8 80~915
9 25~960
17 10~178 5
18 05~188 0
185 0~1910
193 0~1990
ARF CN ra nge
1~124
0~124 &
97 5~1023
5 12~885
51 2~810
T x/Rx spacing
45MHz
45MHz
95MHz
8 0MHz
Mo d. Bit r ate/
Bit Period
270 .833kb ps
3 .692u s
270 .833kb ps
3 .692u s
270 .833kb ps
3 .692u s
270 .833kb ps
3. 692us
Ti me Slo t
Pe rio d/Fr am e
Per iod
5 76.9u s
4. 615ms
5 76.9u s
4. 615ms
5 76.9u s
4. 615ms
57 6.9us
4.6 15ms
Modula tion
0 .3G M SK
0 .3G MSK
0 .3G M SK
0. 3G MSK
MS Power
33d Bm~5dBm
33d Bm~5dBm
30d Bm~0dBm
30d Bm~0dBm
Powe r Class
5pcl ~ 19pcl
5pcl ~ 19pcl
0pcl ~ 15pcl
0pcl ~ 15pcl
Se nsitivity
-10 2dBm
-10 2dBm
-10 0dBm
-100 dBm
TDMA Mu x
8
8
8
8
Cell Radiu s
35Km
35Km
2Km
-
2-1
Speclflcation
2-2. GSM Tx Power Class
TX Power
control level
GSM900
TX Power
control level
DCS1800
TX Power
control level
PCS1800
5
33±2 dBm
0
30±3 dBm
0
30±3 dBm
6
31±2 dBm
1
28±3 dBm
1
28±3 dBm
7
29±2 dBm
2
26±3 dBm
2
26±3 dBm
3
24±3 dBm
8
27±2 dBm
3
24±3 dBm
4
22±3 dBm
4
22±3 dBm
9
25±2 dBm
5
20±3 dBm
5
20±3 dBm
10
23±2 dBm
6
18±3 dBm
6
18±3 dBm
11
21±2 dBm
7
16±3 dBm
7
16±3 dBm
8
14±3 dBm
8
14±3 dBm
9
12±4 dBm
9
12±4 dBm
10
10±4 dBm
10
10±4 dBm
11
8±4dBm
11
8±4dBm
12
6±4 dBm
12
6±4 dBm
13
4±4 dBm
13
4±4 dBm
12
13
14
15
19±2 dBm
17±2 dBm
15±2 dBm
13±2 dBm
16
11±3 dBm
17
9±3dBm
18
7±3 dBm
14
2±5 dBm
14
2±5 dBm
19
5±3 dBm
15
0±5 dBm
15
0±5 dBm
2-2
3. Operation Instruction and Installation
Main Function
-1.3M Camera
-1.8", QCIF, 65K colors
-Video Recording & Messaging
-Music Player(MP3/AAC/AAC+)
-Multimedia Message Service (MMS)
-Bluetooth Wireless Technology
-E-mail
-Voice recorder
-Java / WAP2.0
-Tri-band(900/1800/1900MHz)
3-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Operation Instruction and Installation
3-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
4. Array course control
4-1. Software Adjustments
Test Jig (GH80-03306A)
Test Cable(GH39-00499B)
Serial Cable(CSA LL64151-A)
Power Supply Cable
4-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
4-2. Software Downloading
4-2-1. Pre-requsite for Downloading
• Downloader Program(OneNAND_Downloader_v12_for_PNX5230)
• E200Mobile Phone
• Data Cable
• Binary file, TFS file
4-2-2. S/W Downloader Program
■ Load the binary download program by executing the
“OneNAND_Downloader_v12_for_PNX5230”
1. Select the connected serial port and the rate of speed
2. Select the check box, the mode you want to download.
- if the binary file wanted, check only 'BIN'
- if the tfs file wanted, check only 'TFS'
- if all the files wanted, check 'BIN+TFS'
1
2
4-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
3. Select the file(s) what you want to download
4-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Array course control
4-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
5. Exploded View/Disassembly&Assembly Instructions
5-1. Cellular phone Exploded View
QMW01
QFR01
QKP01
QME01
QMI01
QLC01
QSH01
QCA01
QMO01
QAN03
QSP01
QMP01
QVK01
QAN01
QCR58
QSD01
QRF03
QRE01
QVO01
QCW01
QCR04
QBA01
QBA00
5-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-2. Cellular phone Parts list
Design LOC
Description
Sec Code
QAN01
ANTENNA
GH42-01116A
QAN03
FPCB ANTENNA CHIP-SGH E200
GH42-01099A
QBA01
INNER BATTERY PACK-800MAH , BL
GH43-02790A
QBA00
PMO-COVER BATT
GH72-36417A
QCA01
UNIT-CAMERA MODULE
GH59-03978A
QCR04
SCREW-MACHINE
6001-001479
QCR58
SCREW-MACHINE
6001-001870
QCW01
PCT-COVER CAMERA WINDOW
GH72-36429A
QFR01
ASSY CASE-FRONT
GH98-03281A
QKP01
ASSY KEYPAD-(SER/BLK)
GH98-03859A
QLC01
LCD-SGH E200 MODULE
GH07-01054A
QMO01
MOTOR DC-SGH E200
GH31-00301A
QMP01
PBA MAIN-SGHE200
GH92-03601A
QMW01
ASSY COVER-MAIN WINDOW
GH98-03886A
QSH01
ASSY BRACKET-SHIELD
GH98-03284A
QSP01
SPEAKER
3001-002124
QVK01
UNIT-VOLUME KEY
GH59-04001A
QVO01
ASSY KEY-VOLUME
GH98-04936A
QRE01
ASSY CASE-REAR
GH98-03282A
QRF03
PMO-COVER EAR
GH72-36422A
QSD01
PMO-COVER MICRO SD
GH72-36423A
UNIT-KEY FPCB
GH59-04005A
AS-MIC SVC
GH81-05445A
QME01
QMI01
5-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
Description
Sec Code
BAG PE
6902-000634
CBF INTERFACE-DATA LINK CABLE
GH39-00444A
ADAPTOR-SGHE690,BLK,EU,A_TYPE
GH44-01361A
S/W CD-SGHE200 PC LINK CD
GH46-00407A
UNIT-20P,EARPHONE,BLK,B-TYPE
GH59-04029A
MANUAL-SFC
GH68-04336A
LABEL(P)-BARCODE RUSSIA
GH68-08494A
LABEL(R)-WATER SOAK
GH68-09361A
LABEL(R)-MAIN(SER)
GH68-14021C
MANUAL USERS-EU RUSSIAN
GH68-14288A
BOX-UNIT BOX(SER)
GH69-05106B
CUSHION-CASE(EU)
GH69-05109A
MPR-INSU TAPE
GH74-29553A
MPR-INSU TAPE
GH74-30538A
MPR-TAPE SHEET LABEL
GH74-31820A
MPR-TAPE MAIN WINDOW V2
GH74-32035A
VINYL-BOHO CAMERA WINDOW
GH74-32399A
VINYL-BOHO MAIN WINDOW
GH74-32939A
5-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-3. Disassembly and Assembly Instruction
5-3-1. Disassembly
1
2
Unscrew 4 screws in rear cover
Separate the rear cover
3
Unscrew marked
2
1
4 points
From the bottom part separte the rear cover
1) Be careful of the damage of cover and scratch.
3
1) Be careful of the damage of cover and scratch.
4
Remove the Volume key and separate
Separate the Camera Connector,
Main key PBA Connector and LCD
the Volume key PBA from case.
Connector from Main PBA
Use pinset for
separate
the LCD
connector
1) Be careful of the damage on key PBA
5-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5
Separate the PBA ASSY from upper
6
Unscrew 3 screws in PBA ASSY
case
Unscrew marked
3 points
7
Separate the PBA from
8
PBA ASSY Bracket
1) Speaker, camera, motor is attached by adhensive tape.
Thus be careful when disassemble.
Separate the LCD from Bracket.
1) Adhesive tape is attached on back side of LCD. Thus
be careful when disassemble.
5-5
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-3-2. Assembly
1
Insert LCD to Bracket(front side).
2
Insert PBA to bracket(back side)
1) Adhesive tape is attached on back side of Speaker, motor,
camer. Thus be careful when assemble.
3
4
Screw to the PBA ASSY
Assemble the PBA ASSY with the front
case
Screwing
3 points
.
.
5-6
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5
6
Insert the connector and fpcb to
Attach the Volume key PBA on case
and locate the Volume key .
market socket.
Use pinset for
insert
the LCD
connector
7
8
Assemble the Rear Case
Screw the rear cover
Screw marked
4 points
1
2
3
.
.
5-7
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-8
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Exploded View/Disassembly&Assembly Instructions
5-8
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
6. MAIN Electrical Parts List
Design LOC
Description
SEC Code
STATUS
BAT400
BTC600
C101
C102
C103
C104
C105
C106
C107
C108
C109
C111
C112
C114
C115
C116
C117
C118
C119
C122
C123
C125
C126
C131
C132
C201
C202
C203
C204
C205
C206
C208
C209
C210
C211
C212
C213
C214
C215
C216
C221
C222
C301
C302
C303
C304
C305
C306
C307
C308
BATTERY-LI(2ND)
CONNECTOR-BATTERY
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
4302-001181
3711-006003
2203-005234
2203-000696
2203-000812
2203-005234
2203-005234
2203-000233
2203-000233
2203-005234
2203-005234
2203-005382
2203-005281
2203-000233
2203-000233
2203-000233
2203-000278
2203-005482
2203-000812
2203-002709
2203-002709
2203-001221
2203-002709
2203-000233
2203-005736
2203-005482
2203-000812
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-005482
2203-006562
2203-000254
2203-005482
2203-000812
2203-005482
2203-000425
2203-006824
2203-005482
2203-000425
2203-006423
2203-006423
2203-005482
2203-005482
2203-005482
2203-005482
2203-006423
2203-000696
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
C309
C310
C315
C316
C317
C318
C319
C321
C322
C323
C324
C325
C326
C400
C401
C402
C403
C404
C405
C407
C409
C410
C411
C412
C413
C414
C415
C416
C417
C420
C421
C422
C425
C426
C430
C431
C432
C501
C502
C503
C504
C505
C506
C507
C508
C509
C511
C512
C513
C514
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
2203-000995
2203-000233
2203-006562
2203-006562
2203-006423
2203-006562
2203-006838
2203-006838
2203-006305
2203-000233
2203-006842
2203-000278
2203-000278
2203-006257
2203-006562
2203-006562
2203-006257
2203-006824
2203-006257
2203-006257
2203-006824
2203-006824
2203-006257
2203-005736
2203-006257
2203-006562
2203-006562
2203-000550
2203-000550
2203-006257
2203-006324
2203-006423
2203-006361
2203-006474
2203-006562
2203-006348
2203-006825
2203-006194
2203-005482
2203-005496
2203-005483
2203-005496
2203-005483
2203-005482
2203-000233
2203-000643
2203-005395
2203-005395
2203-005482
2203-005482
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
C515
C516
C517
C518
C519
C520
C521
C522
C523
C524
C525
C526
C540
C542
C543
C544
C546
C548
C549
C551
C552
C553
C554
C602
C605
C606
C607
C608
C609
C610
C611
C614
C615
C616
C617
C700
C701
C702
C703
C704
C705
C716
C717
D600
F100
F300
F500
F704
F705
F706
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
C-CER,CHIP
DIODE-SWITCHING
DUPLEXER-FEM
FILTER-LC
FILTER-EMI/ESD
FILTER-EMI/ESD
FILTER-EMI/ESD
FILTER-EMI/ESD
2203-000679
2203-000679
2203-000330
2203-000330
2203-005482
2203-005482
2203-005395
2203-005395
2203-006260
2203-006260
2203-005482
2203-006137
2203-000278
2203-005050
2203-003054
2203-000278
2203-000278
2203-001259
2203-005050
2203-000278
2203-000386
2203-000386
2203-000386
2203-006562
2203-006562
2203-006562
2203-006562
2203-006562
2203-006048
2203-006824
2203-005482
2203-000425
2203-006423
2203-000812
2203-006562
2203-005682
2203-005682
2203-006562
2203-006562
2203-006562
2203-006562
2203-006423
2203-006423
0401-001141
2911-000072
2909-001279
2901-001376
2901-001319
2901-001319
2901-001319
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
F707
F708
HDC601
HDC602
IFC500
L101
L102
L103
L104
L105
L106
L108
L303
L400
L500
L501
L502
L503
L504
L505
OSC100
OSC300
OSC400
PAM100
R101
R102
R104
R107
R204
R205
R206
R208
R209
R210
R211
R212
R213
R214
R215
R217
R218
R221
R223
R225
R226
R227
R301
R302
R303
R306
FILTER-EMI/ESD
FILTER-EMI/ESD
HEADER-BOARD TO BOARD
HEADER-BOARD TO BOARD
SOCKET-INTERFACE
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
INDUCTOR-SMD
BEAD-SMD
INDUCTOR-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
BEAD-SMD
INDUCTOR-SMD
BEAD-SMD
CRYSTAL-SMD
CRYSTAL-SMD
CRYSTAL-SMD
IC-POWER AMP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
2901-001319
2901-001319
3711-005659
3711-005659
3710-002442
2703-002612
2703-002544
2703-002586
2703-002608
2703-002558
2703-002155
2703-002586
3301-001659
2703-003113
3301-001729
3301-001729
3301-001876
3301-001876
2703-002313
3301-001876
2801-004587
2801-004560
2801-004466
1201-002423
2007-001313
2007-000143
2007-000171
2007-008419
2007-000148
2007-000148
2007-002796
2007-000148
2007-000140
2007-000171
2007-000148
2007-000170
2007-000148
2007-000170
2007-001319
2007-001319
2007-000758
2007-000171
2007-000758
2007-000171
2007-000171
2007-000171
2007-000162
2007-008055
2007-000171
2007-000141
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
R307
R308
R309
R310
R311
R312
R313
R319
R322
R400
R401
R402
R403
R405
R407
R408
R409
R410
R411
R412
R413
R414
R416
R501
R502
R503
R504
R505
R506
R507
R508
R509
R510
R511
R512
R513
R514
R516
R517
R518
R519
R521
R522
R600
R601
R603
R604
R605
R606
R607
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
2007-000141
2007-001303
2007-007014
2007-000162
2007-007014
2007-000170
2007-007489
2007-000170
2007-000148
2007-007573
2007-008354
2007-000162
2007-009168
2007-008542
2007-009157
2007-008542
2007-008542
2007-007100
2007-007311
2007-008542
2007-007317
2007-008542
2007-009314
2007-009112
2007-009155
2007-009155
2007-009112
2007-007741
2007-000172
2007-002796
2007-002796
2007-000172
2007-009112
2007-007528
2007-007014
2007-007014
2007-000162
2007-007528
2007-008542
2007-007528
2007-007528
2007-008785
2007-008785
2007-000162
2007-008055
2007-007142
2007-008419
2007-000162
2007-000162
2007-000159
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SNA
SNA
SNA
SNA
SA
SA
SA
SA
SA
SNA
SA
SA
SA
SA
SA
SA
SA
SA
SNA
SNA
SA
SA
SA
SA
SA
SA
SA
6-5
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
R608
R609
R610
R611
R612
R613
R614
R615
R701
R703
RFS100
RFS101
SIM600
SLC700
TA100
TA400
TA500
TA501
TA502
TA503
TA504
TA600
TA601
TR600
U102
U202
U301
U302
U303
U304
U400
U401
U402
U500
U501
U502
U503
U600
U601
U700
UCP200
UME300
VR600
VR604
VR701
ZD400
ZD500
ZD501
ZD502
ZD503
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
R-CHIP
CONNECTOR-COAXIAL
CONNECTOR-COAXIAL
CONNECTOR-CARD EDGE
CONNECTOR-FPC/FFC/PIC
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
C-TA,CHIP
FET-SILICON
IC-TRANSCEIVER
FILTER-EMI SMD
IC-CMOS LOGIC
IC-CMOS LOGIC
IC ASIC-SGHE490
IC-TRANSCEIVER
IC-POWER SUPERVISOR
IC-POSI.FIXED REG.
IC-POSI.FIXED REG.
IC-AUDIO AMP
IC-TUNER
IC-CMOS LOGIC
IC-ANALOG MULTIPLEX
IC-POSI.FIXED REG.
IC-MULTI REG.
IC-DC/DC CONVERTER
IC-COMM. CONTROLLER
IC-MCP
THERMISTOR-NTC
VARISTOR
VARISTOR
DIODE-ZENER
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-ZENER
2007-000162
2007-009314
2007-008516
2007-007107
2007-000152
2007-009112
2007-009168
2007-009168
2007-000162
2007-009168
3705-001358
3705-001448
3709-001453
3708-002202
2404-001474
2404-001430
2404-001377
2404-001377
2404-001381
2404-001226
2404-001474
2404-001268
2404-001381
0505-002111
1205-003093
2901-001316
0801-002237
0801-002237
GH13-00044A
1205-002942
1203-004382
1203-003737
1203-003737
1201-002356
1204-002700
0801-003025
1001-001428
1203-003737
1203-004291
1203-003708
1205-003082
1108-000104
1404-001221
1405-001082
1405-001082
0403-001547
0406-001215
0406-001254
0406-001254
0403-001547
SA
SA
SA
SA
SA
SNA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
SA
6-6
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
Design LOC
Description
SEC Code
STATUS
ZD600
ZD602
ZD603
ZD604
ZD605
ZD606
ZD703
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
DIODE-TVS
0406-001201
0406-001200
0406-001215
0406-001215
0406-001254
0406-001254
0406-001215
SA
SA
SA
SA
SA
SA
SA
6-7
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Main Electrical Parts List
6-8
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
7. Block Diagrams
7-1. RF Solution Block Diagram
7-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Block Diagrams
7-2. Base Band Solution Block Diagram
7-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
8. PCB Diagrams
Top
8-1
PCB Diagrams
Bottom
8-2
9. Flow Chart of Troubleshooting
9-1. Power On
' Power On ' does not work
Yes
No
Check the Battery Voltage
Change the Battery
is more than 3.4V
Yes
No
C420(VISA) = 2.7V?
Check the PMU related to VISA
Yes
No
Check the Clock at
Resolder OSC400
R410=32KHZ
Yes
No
C400(+VDD_IO_LOW) &
C405(+VDD_IO_HIGH) = "H"?
Check the related circuit
Yes
No
C426+VDD_GSM_CORE)
Check the +VDD_GSM_CORE circuit
= 1.2V?
Yes
No
Check for the clock at C310
Check the clock generation circuit
(related to OSC300)
= 26MHz
Yes
Check the initial operation
Yes
END
9-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-2. Initial
Initial Failure
Yes
No
U400 pin 7 (RSTON) ="H"?
Check the circuit related to reset
Yes
No
Is U301 pin 4
Check the U301
OK?
Yes
Check the 16bit data signal
& memory CE
Yes
END
9-3
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-4
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-3. Charging Part
Abnormal charging part
Yes
No
Check the C431
> 4.9V
Check the circuit related to
V_EXT_CHARGE
Yes
No
Resolder or replace U400
U400 pin 36 = "L"?
Yes
No
Check the circuit related to
U400 pin 34 = "L"?
AUX_ON signal
Yes
END
9-5
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-6
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-4. Sim Part
Phone can't access SIM Card
Yes
No
C610, C611
= "H"?
Resolder or replace U400
Yes
No
After Power ON,
Check the Clock
Check SIMCLK Signal on
pin15 of SIM600 in a few
second
Yes
No
After SIM card insert,
Replace PBA
SIM600 pin 13 = "H(SIM_RST)"?
Yes
Check the SIM Card
Yes
END
9-7
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-8
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-5. Microphone Part
Microphone does not work
Yes
No
Check the connection
Resolder MIC
from MIC
Yes
Check the circuit
No
Resolder the C548, C546, C551, C514, C516,
C520, C512, C518, C522, R516, R519, R508
from UCP200 to MIC
Yes
Check the MIC
No
Replace the MIC
Yes
END
9-9
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-10
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-6. Speaker Part(Melody)
Speaker does not work
Yes
No
U500 pin 7 = 2.9V?
Resolder or replace U500
Yes
No
Check the signal at
Pin 8, 9 of U500
Resolder the C503, C505
> 1.3V
Yes
No
Check the signal at
Resolder or replace U500
Pin 15, 17 of U500
Yes
No
Is Speaker working?
Change the Speaker
Yes
END
9-11
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-12
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-7. Key Data Input
Check Initial Operation
Yes
When one of the keys is
No
Check the Dome sheet & Key Pad
pushed,
is it displayed on LCD?
Yes
When one of the keys is
No
Replace the PBA
pushed,
KBIO signal is OK?
Yes
END
9-13
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-8. Receiver Part
Receiver does not work
Yes
No
Resolder UCP200 or change PBA
Is Receiver working?
Yes
No
Replace the Receiver
Is Receiver working?
Yes
END
9-14
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-9. Back Light (for Color Main LCD)
Backlight does not work
Yes
No
Is LCD Contrast set on high
Set LCD Contrast on high level
level in the Menu?
Yes
No
U700 PIN 3 = H ?
Check the inserting condition of slide FPCB
Resolder UCP200 or change PBA
Yes
No
Check the U700 & the related circuit
U700 PIN 1 = H ?
Yes
Replace the LCD Module
Yes
END
9-15
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-16
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-10. Key Back Light
Main Key LED does not work
Yes
No
Check the UCP200 related to
"MAIN_LED_ON"
U401 pin1 = H ?
Yes
END
9-17
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-11. Camera part
"Camera" function does not work
Yes
No
Check the Camera
connector
Reconnect the camera module
Yes
No
U601 pin 6 = H ?
Resold or replace U601
Yes
No
Check U302(pin2, pin4) related to
26Mhz and R308
C310 = 26MHz?
Yes
Is there another problem?
Yes
Replace the camera
module
END
9-18
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-19
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-12. GSM Receiver
RX ON
RF input : 62CH center freq : 947.4MHz
Amp : -50dBm
Yes
No
F100 Pin13
>= -65dBm
Resolder RFS100, C103, L106
Yes
No
F100 pin1,2
>= -68dBm
No
Check F100
pin9,pin11 = L
Check ANT Switch
control circuit
Yes
Resolder F100
Yes
No
U101
pin 24 >= -70dBm
pin 25 >= -70dBm
Resolder C108, C109, L105
Yes
U101 pin 4,5,6,7
>= 1V
No
No
U101 pin 11,12
16,17,32,33>=2.8V
Yes
Check
U101, OSC100
RF26MHz, RF PSU Part
Yes
Resolder U101
Check UCP200
END
9-20
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-13. GSM Transmitter
TX ON (5Level)
Yes
No
F100 Pin13
>= 20dBm
Resolder RFS100,C103,L106
Yes
No
F100 pin10
>= 18dBm
Check F100
pin9=L,
pin11=H(2.6V)
No
Check ANT Switch
control circuit
Yes
Yes
No
PAM100 pin12
>= 18dBm
Change or Resolder
L101,C111,C121
Resolder or Change PAM100
Yes
No
PAM100 pin18
<= -11dBm
Check +VBAT or PAM
control signal
Yes
No
U101 pin 4,5,6,7
>= 1V
U101 pin 11,12
16,17,32,33>=2.8V
No
Check & Resolder RFOLP
signal, RF13MHz,
RF PSU Part
Yes
Yes
Check UCP200
END
9-21
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Resolder U101
Flow Chart of Troubleshooting
9-14. DCS Receiver
RX ON
RF input : 698CH center freq : 1842.4MHz
Amp : -50dBm
Yes
No
F100 Pin13
>= -65dBm
Resolder RFS100,C103,L106
Yes
No
F100 pin3,4
>= -68dBm
Check F100
pin9,pin11 = L
No
Check ANT Switch
control circuit
Yes
Yes
Resolder F100
No
U101
pin 22 >= -70dBm
pin 23 >= -70dBm
Resolder C104, C105, L104
Yes
U101 pin 4,5,6,7
>= 1V
No
No
U101 pin 11,12
16,17,32,33>=2.8V
Yes
Check
U101, OSC100
RF26MHz, RF PSU Part
Yes
Resolder U101
Check UCP200
END
9-22
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-15. DCS Transmitter
TX ON (5Level)
Yes
No
F100 Pin13
>= 20dBm
Resolder RFS100,C103,L106
Yes
No
F100 pin8
>= 18dBm
Check F100
pin9 = H (2.6V),
pin11 = L
No
Check ANT Switch
control circuit
Yes
Yes
No
PAM100 pin18
>= 18dBm
Change or Resolder
C115,C116,C131
Resolder or Change PAM100
Yes
No
PAM100 pin1
<= -11dBm
Check +VBAT or PAM
control signal
Yes
No
U101 pin 4,5,6,7
>= 1V
U101 pin 11,12
16,17,32,33>=2.8V
No
Check & Resolder RFOHP
signal, RF13MHz,
RF PSU Part
Yes
Yes
Check UCP200
END
9-23
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Resolder U101
Flow Chart of Troubleshooting
9-16. PCS Receiver
RX ON
RF input : 660CH center freq : 1959.8MHz
Amp : -50dBm
Yes
No
F100 Pin13
>= -65dBm
Resolder RFS100,C103,L106
Yes
No
F100 pin5,6
>= -68dBm
Check F100
pin9,pin11 = L
Yes
No
Check ANT Switch
control circuit
Yes
Resolder F100
No
U101
pin 21 >= -70dBm
pin 20 >= -70dBm
Resolder C101, C102, L103
Yes
U101 pin 4,5,6,7
>= 1V
No
No
U101 pin 11,12
16,17,32,33>=2.8V
Yes
Check
U101, OSC100
RF26MHz, RF PSU Part
Yes
Resolder U101
Check UCP200
END
9-24
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-17. PCS Transmitter
TX ON (5Level)
Yes
No
F100 Pin13
>= 20dBm
Resolder RFS100,C103,L106
Yes
No
F100 pin8
>= 18dBm
Check F100
pin9=H (2.6V),
pin11=L
No
Check ANT Switch
control circuit
Yes
Yes
No
PAM100 pin18
>= 18dBm
Change or Resolder
C115,C116,C131
Resolder or Change PAM100
Yes
No
PAM100 pin1
<= -11dBm
Check +VBAT or PAM
control signal
Yes
No
U101 pin 4,5,6,7
>= 1V
U101 pin 11,12
16,17,32,33>=2.8V
No
Check & Resolder RFOHP
signal, RF13MHz,
RF PSU Part
Yes
Yes
Check UCP200
END
9-25
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Resolder U101
Flow Chart of Troubleshooting
9-26
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-27
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Flow Chart of Troubleshooting
9-28
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
10. Reference data
Reference Abbreviate
- AAC: Advanced Audio Coding.
- AVC : Advanced Video Coding.
- BER : Bit Error Rate
- BPSK: Binary Phase Shift Keying
- CA : Conditional Access
- CDM : Code Division Multiplexing
- C/I : Carrier to Interference
- DMB : Digital Multimedia Broadcasting
- EN : European Standard
- ES : Elementary Stream
- ETSI: European Telecommunications Standards Institute
- MPEG: Moving Picture Experts Group
- PN : Pseudo-random Noise
- PS : Pilot Symbol
- QPSK: Quadrature Phase Shift Keying
- RS : Reed-Solomon
- SI
: Service Information
- TDM : Time Division Multiplexing
- TS : Transport Stream
10-1
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
Reference data
10-2
SAMSUNG Proprietary-Contents may change without notice
This Document can not be used without Samsung's authorization
GSPN (Global Service Partner Network)
Country
North America
Latin America
CIS
Europe
China
Asia
Mideast & Africa
Web Site
service.samsungportal.com
latin.samsungportal.com
cis.samsungportal.com
europe.samsungportal.com
china.samsungportal.com
asia.samsungportal.com
mea.samsungportal.com
This Service Manual is a property of Samsung Electronics Co.,Ltd.
Any unauthorized use of Manual can be punished under applicable
International and/or domestic law.
ⓒ Samsung Electronics Co.,Ltd.
2007. 04. Rev.1.0
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising