Motorola | LTS 2000TM | GTX/LTS2000 Handheld Radio Service Manual Revision (IMR414)

instruction
manual
revision
GENERAL:
This revision outlines changes that have occurred since the printing of your instruction manual. Use this information to
correct your manual.
INSTRUCTION MANUAL AFFECTED:
68P02948C90-O GTX/GTX LTR/LTS 2000TM Portable Radio Service Manual
REVISION DETAILS:
1) On the front inside cover, replace the safety information with the following safety information.
SAFE AND EFFICIENT OPERATION OF MOTOROLA TWO-WAY RADIOS
This section provides information and instructions for the safe and efficient operation of Motorola Portable two-way
Radios. This information supersedes the general safety information contained in your user guide.
For information regarding radio use in a hazardous atmosphere please refer to the Factory Mutual (FM) Approval Manual Supplement or Instruction Card, which is included with radio models that offer this capability.
Exposure to Radio Frequency Energy
National and International Standards and Guidelines
Your Motorola two-way Radio, which generates and radiates radio frequency (RF) electromagnetic energy (EME) is
designed to comply with the following national and international standards and guidelines regarding exposure of human
beings to radio frequency electromagnetic energy:
•Federal Communications Commission Report and Order No. FCC 96-326 (August 1996) •American National Standards Institute (C95-1-1992)
•National Council on Radiation Protection and Measurements (NCRP - 1986)
•International Commission on Non-Ionizing Radiation Protection (ICNRP - 1986)
•European Committee for Electrotechnical Standardization (CENELEC)
- Env. 50166 -1 1995E - Human Exposure to Electromagnetic Fields Low Frequency (0 Hz to 10kHz)
- Env. 50166 -2 1995E - Human Exposure to Electromagnetic Fields High Frequency (10kHz to 300Ghz)
- Proceedings of SC211/8 1996 - Safety Considerations for Human International Commission on Non-Ionizing Radiation Protection (ICNRP-1986) Exposure to E.M.Fs from Mobile Tele-communications Equipment (M.T.E.) in the Frequency Range 30MHz - 6GHz (E.M.F - Electromagnetic Fields)
*IMR-414*
IMR414
8000 West Sunrise Boulevard, Fort Lauderdale, Florida 33322-9934
June, 1998
- To assure optimal radio performance and that human exposure to radio frequency electromagnetic energy is within the
guidelines set forth in the above standards, always adhere to the following procedures:
•When transmitting with a portable radio, hold the radio in a vertical position with its microphone 1 to 2 inches (2.5 to
5.0 centimeters) away from your mouth. Keep antenna at least 1 inch (2.5 centimeters) from your head and body.
•If you wear a portable two-way radio on your body ensure that the antenna is at least 1 inch (2.5 centimeters) from your
body when transmitting.
ElectroMagnetic Interference/Compatibility
NOTE: Nearly every electronic device is susceptible to electro-magnetic interference (EMI) if inadequately shielded,
designed or otherwise configured for electromagnetic compatibility.
•To avoid electromagnetic interference and/or compatibility conflicts, turn off your radio in any facility where posted
notices instruct you to do so. Hospitals or health care facilities may be using equipment that is sensitive to external RF
energy.
•When instructed to do so, turn off your radio when on board an aircraft. Any use of a radio must be in accordance with
airline regulations or crew instructions.
OPERATIONAL WARNING
For Vehicles with AirBags
Do not place a portable radio in the area over an air bag or in the air bag deployment area. Air bags inflate with great
force. If a portable radio is placed in the air bag deployment area and the air bag inflates, the radio may be propelled with
great force and cause serious injury to occupants of the vehicle.
Potentially Explosive Atmospheres
Turn off your two-way radio when you are in any area with a potentially explosive atmosphere, unless it is a radio type
especially qualified for use in such areas (for example, Factory Mutual Approved). Sparks in a potentially explosive
atmosphere can cause an explosion or fire resulting in bodily injury or even death.
Batteries
Do not replace or charge batteries in a potentially explosive atmosphere. Contact sparking may occur while installing or
removing batteries and cause an explosion.
Blasting Caps and Areas
To avoid possible interference with blasting operations, turn off your radio when you are near electrical blasting caps, in
a blasting area, or in areas posted: “Turn off two-way radio”. Obey all signs and instructions.
NOTE:
The areas with potentially explosive atmospheres referred to above include fueling areas such as: below decks on boats;
fuel or chemical transfer or storage facilities; areas where the air contains chemical or particles, such as grain, dust or
metal powders; and any other area where you would normally be advised to turn off your vehicle engine. Areas with
potentially explosive atmospheres are often but not always posted.
Damaged Antennas
Do not use any portable two-way radio that has a damaged antenna. If a damaged antenna comes into contact with your
skin, a minor burn can result.
2
Batteries
All batteries can cause property damage and/or bodily injury such as burns if a conductive material such as jewelry, keys,
or beaded chains touch exposed terminals. The conductive material may complete an electrical circuit (short circuit) and
become quite hot. Exercise care in handling any charged battery, particularly when placing it inside a pocket, purse, or
other container with metal objects.
2) Replace the model charts which appear on page v and vi with the following Model Charts:
GTX Portable Radio Model Chart
GTX Portable Radio, H11WCD4CB1AN
FUF1194A
900 MHz 1.5 ppm Portable Radio
HNN9628
Battery (7.5 rechargeable)
NAF5038
900 MHz 1/2 Wavelength Whip
KIT BREAKDOWN
FUF1194A 900 MHz 1.5ppm Portable Radio
FLN2436A
Front Unit
FUF1196A
1.5ppm RF Unit
FLN8577A
Miscellaneous Parts
FLN2436A Front Housing
FHN5873A
Housing
FEN1656A
Logic Board & I/O Unit
FSN5509A
Speaker & Microphone Assembly
FLN8574A
Miscellaneous Parts
FEN1650A Logic Board & I/O Unit
FLN8836A
Logic Board
FLN8515A
I/O Hardware
FUF1196A 2.5 ppm RF Unit
FUF5690A
1.5 ppm RF Unit
FLN2394A
Chassis Assembly
FLN8575A
Shields & Parts
FLN2394A Chassis Assembly
FLN8517A
Battery Filter Board
FLN8518A
Chassis Hardware
3
GTX LTR Portable Radio Model Chart
GTX LTR Portable Radio, H11WCD4CU1AN
FUF1199B
900 MHz 1.5 ppm Portable Radio
HNN9628
Battery (7.5 rechargeable)
NAF5038
900 MHz 1/2 Wavelength Whip
KIT BREAKDOWN
FUF1199B 900 MHz 1.5ppm Portable Radio
FLN2540A
Front Unit
FUF1196A
1.5ppm RF Unit
FLN8577A
Miscellaneous Parts
FLN2540A Front Housing
FHN5873A
Housing
FEN1662A
Logic Board & I/O Unit
FSN5509A
Speaker & Microphone Assembly
FLN8574A
Miscellaneous Parts
FEN1662A Logic Board & I/O Unit
FLN9952A
Logic Board
FLN8515A
I/O Hardware
FUF1196A 2.5 ppm RF Unit
FUF5690A
1.5 ppm RF Unit
FLN2394A
Chassis Assembly
FLN8575A
Shields & Parts
FLN2394A Chassis Assembly
FLN8517A
Battery Filter Board
FLN8518A
Chassis Hardware
Not all kits on this page will be available from the Americas Parts Division
4
LTS 2000 Portable Radio Model Chart
LTS 2000 Portable Radio, H10WCH4DC5AN
FUF1195A
900 MHz 1.5 ppm Portable Radio
HNN9628
Battery (7.5 rechargeable)
HLN8255
Belt Clip
NAF5038
900 MHz 1/2 Wavelength Whip
KIT BREAKDOWN
FUF1195A 900 MHz 1.5ppm Portable Radio
FLN2437A
Front Unit
FUF1196A
1.5ppm RF Unit
FLN8665A
Miscellaneous Parts
FLN2437A Front Housing
FHN5874A
Housing
FEN1651A
Logic Board & I/O Unit
FSN5509A
Speaker & Microphone Assembly
FLN8576A
Miscellaneous Parts
FEN1651A Logic Board & I/O Unit
FLN8836A
Logic Board
FLN8515A
I/O Hardware
FUF1196A 1.5 ppm RF Unit
FUF5690A
1.5 ppm RF Unit
FLN2394A
Chassis Assembly
FLN8575A
Shields & Parts
FLN2394A Chassis Assembly
FLN8517A
Battery Filter Board
FLN8518A
Chassis Hardware
Not all kits on this page will be available from the Americas Parts Division
5
LTS 2000 (SmartNet Plus) Portable Radio Model Chart
LTS 2000 (SmartNet Plus) Portable Radio, H10WCH4DC5BN
FUF1195B
900 MHz 1.5 ppm Portable Radio
HNN9628
Battery (7.5 rechargeable)
HLN8255
Belt Clip
NAF5038
900 MHz 1/2 Wavelength Whip
KIT BREAKDOWN
FUF1195B 900 MHz 1.5ppm Portable Radio
FLN2591A
Front Unit
FUF1196A
1.5ppm RF Unit
FLN9171A
Miscellaneous Parts
FLN2591A Front Housing
FHN6001A
Housing
FEN1664A
Logic Board & I/O Unit
FSN5509A
Speaker & Microphone Assembly
FLN8576A
Miscellaneous Parts
FEN1664A Logic Board & I/O Unit
FLN9054A
Logic Board
FLN8515A
I/O Hardware
FUF1196A 1.5 ppm RF Unit
FUF5690A
1.5 ppm RF Unit
FLN2394A
Chassis Assembly
FLN8575A
Shields & Parts
FLN2394A Chassis Assembly
FLN8517A
Battery Filter Board
FLN8518A
Chassis Hardware
Not all kits on this page will be available from the Americas Parts Division
NOTE: Items with suffix may be upgraded in the future
6
LTS 2000 (SmartZone) Portable Radio Model Chart
LTS 2000 (SmartZone) Portable Radio, H10WCH4DC5BN
FUF1495A
900 MHz 1.5 ppm Portable Radio
HNN9628
Battery (7.5 rechargeable)
HLN8255
Belt Clip
NAF5038
900 MHz 1/2 Wavelength Whip
KIT BREAKDOWN
FUF1495A 900 MHz 1.5ppm Portable Radio
FLN2437B
Front Unit
FUF1196A
1.5ppm RF Unit
FLN8665B
Miscellaneous Parts
FLN2437B Front Housing
FHN5978A
Housing
FEN1651B
Logic Board & I/O Unit
FSN5509A
Speaker & Microphone Assembly
FLN8576A
Miscellaneous Parts
FEN1651B Logic Board & I/O Unit
FLN9054A
Logic Board
FLN8515A
I/O Hardware
FUF1196A 1.5 ppm RF Unit
FUF5690A
1.5 ppm RF Unit
FLN2394A
Chassis Assembly
FLN8575A
Shields & Parts
FLN2394A Chassis Assembly
FLN8517A
Battery Filter Board
FLN8518A
Chassis Hardware
Not all kits on this page will be available from the Americas Parts Division
NOTE: Items with suffix may be upgraded in the future
7
LTS 2000 (Tomba) Portable Radio Model Chart
LTS 2000 (Tomba) Portable Radio, H10WCH4DC5BN
FUF1496A
900 MHz 1.5 ppm Portable Radio for Tomba
HNN9628
Battery (7.5 rechargeable)
HLN8255
Belt Clip
NAF5038
900 MHz 1/2 Wavelength Whip
KIT BREAKDOWN
FUF1496A 900 MHz 1.5ppm Portable Radio for Tomba
FLN2607A
Front Unit
FUF1196A
1.5ppm RF Unit
FLN8665B
Miscellaneous Parts
FLN2607A Front Housing
FHN5978A
Housing
FEN1668A
Logic Board & I/O Unit
FSN5509A
Speaker & Microphone Assembly
FLN8576A
Miscellaneous Parts
FEN1668A Logic Board & I/O Unit
FLN9054A
Logic Board
FLN8515A
I/O Hardware
FUF1196A 1.5 ppm RF Unit
FUF5690A
1.5 ppm RF Unit
FLN2394A
Chassis Assembly
FLN8575A
Shields & Parts
FLN2394A Chassis Assembly
FLN8517A
Battery Filter Board
FLN8518A
Chassis Hardware
Not all kits on this page will be available from the Americas Parts Division
NOTE: Items with suffix may be upgraded in the future
8
3) On page viii under “Chargers Pick-ups” change the part number of HTN9630 to HTN9042.
4) On page viii under “Antenna Pick-ups” change the part number of NAF5039 to NAF5038.
5) On page viii under “Audio/RF Accessories” change the part number of HMN9725 to HMN9030.
6) On page ix under Documentation Kits add:
68P02945C85-B LTS 2000 Portable Radio User’s Guide
7) On page ix under Radio Service Software (RSS) change:
RVN4150B to RVN4150D and
RVN4156B to RVN4156F
8) On page xi under Service Aids:
Delete RLN4460 including the description and application
9) On page xviii change the address of the Motorola
From 3651 South Central Avenue to 3761 South Central Avenue
10) Section 3: Accessories change the following:
On page 3-1 under “Description” change the Model number of the Remote Speaker Microphone to HMN9030
On page 3-2 under “Electrical Parts List” change HMN9725 to HMN9030 and replace the complete electrical part list
with the following:
HMN9030 Electrical Parts List
REFERENCE MOTOROLA
SYMBOL
PART NO.
DESCRIPTION
capacitor, fixed:
82 pF, ±30%, 50V
330 pF, ±30%, 50 V
.022 uF, ±5%, 50V
0.1 uF, ±5%, 50V
C1
C2
C3
C4
2113740A53
2113740A67
2113741A53
2113741B69
L1 thru 4
coil, inductor:
2462575A02 680 nH, ±10%
0909897T02
header:
4-pin
S1
switch:
3905834K06 Dome, PTT
MK1
LS1
miscellaneous:
0180706Y83 Microphone assembly
5005910P05 Speaker
9
On page 3-3 change the mechanical parts list and Figure 3-3, exploded view with the following:
HMN9030 Mechanical Parts List
REFERENCE MOTOROLA
SYMBOL
PART NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
10
1580617U01
3580619U01
0180709Y90
7580418D04
3280621U01
1580618U01
5480622U01
0310945A12
0484345A06
3880620U01
3805248Q01
3080417E21
4205823V01
DESCRIPTION
HOUSING, front
BAFFLE, felt
ASSY, microphone, speaker, & PCB
BUSHING, retainer
GASKET
HOUSING, rear
LABEL
SCREW, thread forming
WASHER
PTT, pushbutton
ACTUATOR, PTT
CORD
CLIP, slide-on
11) Section 6: Maintenance:
Page 6-2 after “Rigid Circuit Boards” add the following:
RF Board (Main Board) Replacement Procedures
1) Disassemble the radio as given in Section 1: Radio Disassembly/Assembly - Main Board Removal.
2) Replace the old RF Board with the new one.
3) Reassemble the RF Board as given in Section 1: Radio Disassembly/Assembly - Chassis Reassembly.
4 Reassemble the radio as given in Section 1: Radio Disassembly/Assembly - Radio Reassembly.
5) Turn the radio ON.
6) Tune the radio as given in section 7: Radio Tuning Procedure.
Logic Board and I/O Unit (Front Housing Board) Replacement Procedures
1) Disassemble the radio as given in Section 1: Radio Disassembly/Assembly - Front Housing Board Removal.
2) Replace the old Logic Board and I/O Unit with the new one.
3) Reassemble the Front Housing as given in Section 1: Radio Disassembly/Assembly - Front Housing Reassembly.
4) Reassemble the radio as given in Section 1: Radio Disassembly/Assembly - Radio Reassembly.
5) Turn the radio ON.
Note: The radio will display “ERROR 06” with an illegal continuous tone.
6) Carry out the “Blank Board Initialization” Procedure as given in the LCS/LTS 2000 Radios RSS User’s Guide (page
24)
or in the GTX/LTR Radios RSS User’s Guide (page 24).
7) Make the calibrations according to the “Logic or RF Board Replacement” Procedure as given in the RSS User’s Guide
mentioned in item 6.
12) Section 7: Radio Tuning Procedure:
On page 7-3, after the ‘Squelch Description” add the following RSSI (Received Signal Strength Indicator) tuning procedure for the SmartZone and Tomba Models:
1. Press F2 to select LOGIC OR RF BOARD.
2. Press F8 to select SQUELCH/RSSI.
3. Press F10 to select RSSI.
4. Set Signal Generator to 941.5 MHz.
5. Set RF level to -106dBm.
6. Press F4 to read the RSSI digital value displayed on the top right side of the screen.
7. Type this value in the appropriate place on the screen.
11
8. Repeat steps 6 to 7 with RF levels of -90dBm and -74dBm.
9. Press F8 to program the values.
13) Section 7: Radio Tuning Procedure: under “Transmitter Deviation Limit”
Change the part number of the Test Box from 4460A to Test Box RTX4005.
14) Schematic Diagrams, Circuit Board Details & Parts List Section change the following:
On page 7 and 8 under “FUF5690A RF Board” change the part number of the following components:
C225 from 2311049J12 to 2311049J11
C563 from 2113741A33 to 2113741A25 and the description from 3.3.nF to 1500 µF
C564 from 2113741A33 to 2113741A25 and the description from 3.3.nF to 1500 µF
J5 from 0180159R03 to 0180195R03
U101 from 5108038H16 to 5105385Y13
U220 from 5105457W46 to 5105457W80
U420 from 5113816A23 to 5113816A29
PB1 -PB3 from 4080485C05 to PB401-PB403 4080447U05
On page 9 under “FLN8517A Battery Filter Board” change the part number of F1 from 6580561D01 to 6580561D02
On page 10 under “FLN8836A Logic Board” change the part number of the following components:
U705 from 5105662U54 to 5108444S61
U706 from 5108444S41 to 5108444S67.
On page 10 after “FLN8836A Logic Board” parts list, add:
FLN9054A Logic Board
REFERENCE MOTOROLA
SYMBOL
PART NO.
DESCRIPTION
All parts listed for FLN9054A are identical to those
listed for FLN8836A except for the following change:
integrated circuits: (see note 1)
U703
5108444S71 X253320
FLN9952A Logic Board
REFERENCE MOTOROLA
SYMBOL
PART NO.
DESCRIPTION
All parts listed for FLN9952A are identical to those
listed for FLN8836A except for the following change:
integrated circuits: (see note 1)
C716
2113743F12 0.33 pF
12
On page 13 replace the GTX/GTX LTR Radio Exploded View with the Exploded View given below:
13
On page 15 replace the LTS 2000 Radio Exploded View with the exploded view given below:
On page 15 replace the LTS 2000 Radio Exploded View with the exploded view given below:
14
14
On page 12 replace the GTX/GTX LTR Mechanical
Parts list with the parts list given below:
On page 14 replace the LTS 2000 Mechanical Parts
list with the parts list given below:
LTS 2000 Mechanical Parts List
GTX/GTX LTR Mechanical Parts List
REFERENCE
SYMBOL
MOTOROLA
PART NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25*
26*
27
1580421K01
lens
3380425K01
7580437C01
1380159S01
3286074C01
3880428C01
6180968Y01
3280960Y01
1386080C01
5880636V01
8505241U04
3680448K01
3680447K01
3580998Z04
3080560D01
1480577C01
5013920A03
5005589U05
7580506C02
3286062C01
3980546B02
7580685K01
7580427K01
8408050Y01
7204616J01
FLN8836A
FLN9952A
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
6180687K01
2680402K01
4105944K01
5580438B01
4280190R04
2680532C01
8408051Y01
FUF5690A
3286063C01
1480610B01
2780549B01
3286213C01
5480673K02
3980188R01
FLN8517A
3202386L03
HNN9628
HLN9724/
HLN8255
* Not field repairable
REFERENCE
SYMBOL
MOTOROLA
PART NO.
1
2
3
4
5
6
7
8
9
10
1580422K02
------LENS
3380455K01
7580430K01
1380431K01
3286074C01
3880428C01
6180968Y01
3280960Y01
1380463K01
DESCRIPTION
DESCRIPTION
front housing
cannot be ordered separately
name plate
PTT keypad
PTT bezel
PTT chim
dust cap
light pipe
seal, 2 used
escutcheon
antenna adapter
antenna whip
frequency knob
volume knob
speaker felt
speaker/mic cable
microphone boot
microphone
speaker
speaker pad
speaker chim
front-shield ground contact
pad
keypad
heat-sealed flexible cable
LCD
logic board, assembled
(used in FUF1194A)
logic board, assembled
(used in FUF1199B)
reflector
logic board shield
battery latch spring, 2 used
latch
shield clip, 4 used
front shield
RF-to-Logic flexible circuit
RF board, assembled
O-ring gasket
chassis insulator
chassis
handie talkie label
FCC label
contact, B+/Bbattery filter board, assembled
shield RFI
battery
standard belt clip
1380463K02
11
12
13
5880636V01
8505241U04
3680433K01
3680433K02
14
15
16
17
18
19
20
21
22
23
24
25*
26*
27
3680432K01
3580998Z04
3080560D01
1480577C01
5013920A03
5005589U05
7580506C02
3286062C01
3980546B02
7580685K01
7580428K02
8408050Y01
7204616J01
FLN8836A
FLN9054A
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
6180687K01
2680402K01
4105944K01
5580438B01
4280190R04
2680532C01
8408051Y01
FUF5690A
3286063C01
1480610B01
2780549B01
3286213C01
5480673K02
3986132F01
FLN8517A
3202386L03
HNN9628
HLN9724/
HLN8255
front housing
cannot be ordered separately
name plate
PTT keypad
PTT bezel
PTT chim
dust cap
light pipe
seal, 2 used
escutcheon (8 positions)
(used in FUF1195A & FUF1195B)
escutcheon (16 positions)
(used in FUF1495A & FUF1496A)
antenna adapter
antenna whip
frequency knob (8 positions)
(used in FUF1195A & FUF1195B)
frequency knob (16 positions)
(used in FUF1495A & FUF1496A)
volume knob
speaker felt
speaker/mic cable
microphone boot
microphone
speaker
speaker pad
speaker chim
front-shield ground contact
pad
keypad
heat-sealed flexible cable
LCD
logic board, assembled
(used in FUF1195A)
logic board, assembled
(used in FUF1195B, FUF1495A &
FUF1496A)
reflector
logic board shield
battery latch spring, 2 used
latch
shield clip, 4 used
front shield
RF-to-logic flexible circuit
RF board, assembled
O-ring gasket
chassis insulator
chassis
handie talkie label
FCC label
contact, B+/Bbattery filter board
shield RFI
battery
standard belt clip
* Not field repairable
15
Replace the Miscellaneous Parts List located on page 16 and 17, with the following:
miscellaneous parts lists
FHN6001A Housing (LTS 2000 SmartNet Plus)
REFERENCE
FHN5873A Housing (GTX/GTX LTR)
REFERENCE
SYMBOL
Qty
1
1
1
2
1
1
1
1
2
1
1
1
1
MOTOROLA
PART NO.
SYMBOL
DESCRIPTION
non-referenced items:
1380159S01
PTT bezel
1386080C01
escutcheon
1580421K01
housing
3280960Y01
seal
3286074C01
PTT chim
3380425K01
logo
3580998Z04
speaker felt
3880428C01
dust cap
4105944K01
battery latch spring
5580438B01
latch
5880376L01
adapter antenna
6180968Y01
light pipe led
7580437C01
PTT keypad
MOTOROLA
DESCRIPTION
PART NO.
Qty
non-referenced items:
1
1380431K01
PTT bezel
1
1380463K01
top escutcheon16 pos.
1
1580422K02
HOUSING, front hsng
2
3280960Y01
seal vol
1
3286074C01
PTT chim
1
3380455K01
logo
1
3580998Z04
speaker felt
1
3880428C01
dust cap
2
4105944K01
battery latch spring
1
5580438B01
latch
1
5880376L01
adapter antenna
1
6180968Y01
light pipe led
1
7580430K01
PTT keypad
FHN5874A Housing (LTS 2000)
REFERENCE
SYMBOL
MOTOROLA
PART NO.
DESCRIPTION
Qty
1
1
1
1
1
1
1
1
2
1
1
1
1
non-referenced items:
1380431K01
PTT bezel
1380463K01
top esc
1580422K02
housing
3280960Y01
seal
3286074C01
PTT chim
3380455K01
logo
3580998Z04
speaker felt
3880428C01
dust cap
4105944K01
battery latch spring
5580438B01
latch
5880376L01
adapter antenna
6180968Y01
light pipe led
7580430K01
PTT keypad
FLN8515A I/O Hardware
REFERENCE
SYMBOL
Qty
1
1
1
2
1
1
1
1
2
1
1
1
1
16
PART NO.
non-referenced items:
1
7204616J01
lcd display
1
8408050Y01
flexible circuit
J01FLN8518A Chassis Hardware
REFERENCE
MOTOROLA
PART NO.
DESCRIPTION
Qty
FHN5978A Housing (LTS 2000 Full SmartZone and Tomba)
REFERENCE
SYMBOL
MOTOROLA
SYMBOL
MOTOROLA
DESCRIPTION
PART NO.
DESCRIPTION
non-referenced items:
1380431K01
PTT bezel
1380463K02
top escutcheon 16 pos.
1580422K02
housing, front hsng
3280960Y01
seal vol
3286074C01
PTT chim
3380455K01
logo
3580998Z04
speaker felt
3880428C01
dust cap
4105944K01
battery latch spring
5580438B01
latch
5880376L01
adapter antenna
6180968Y01
light pipe led
7580430K01
PTT keypad
Qty
non-referenced items:
1
1480610B01
1
2780549B01
chassis
1
3286213C01
label
2
3986132f01
contact, B+/B-
insulator, chassis
miscellaneous parts lists (cont.)
FLN8574A Housing Miscellaneous Parts (GTX/GTX LTR)
FLN9171A Miscellaneous Parts (LTS 2000 SmartNet Plus)
REFERENCE
SYMBOL
MOTOROLA
PART NO.
REFERENCE
Qty
1
0.2
1
1
1
non-referenced items:
2680402K01
logic board shield
3202386L03
RFI shield
6180687K01
LCD light reflector
7580427K01
main keypad
7580685K01
pad
DESCRIPTION
MOTOROLA
SYMBOL
DESCRIPTION
PART NO.
Qty
non-referenced items:
1
3286063C01
O-ring gasket
1
3380184R01
FCC label
1
3680432K01
volume knob
1
3680433K01
frequency knob
FLN8576A Housing Miscellaneous Parts (LTS 2000)
1
8408051Y01
rf-to-logic flexible circuit
REFERENCE
SYMBOL
MOTOROLA
PART NO.
FLN8665B Misc.Parts (LTS 2000 Full SmartZone and Tomba)
Qty
1
0.2
1
1
1
non-referenced items:
2680402K01
logic board shield
3202386L03
RFI shield
6180687K01
LCD light reflector
7580428K02
main keypad
7580685K01
pad
DESCRIPTION
FLN8575A Shield & Parts
REFERENCE
SYMBOL
MOTOROLA
PART NO.
DESCRIPTION
Qty
1
4
non-referenced items:
2680532C01
front shield
4280190R04
shield clip
FLN8577A Miscellaneous Parts (GTX/GTX LTR)
REFERENCE
MOTOROLA
SYMBOL
Qty
non-referenced items:
1
3286063C01
O-ring gasket
1
3380184R01
FCC label
1
3680432K01
volume knob
1
3680433K02
frequency knob 16 pos.
1
8408051Y01
rf-to-logic flexible circuit
FSN5509A Speaker & Microphone Assembly
REFERENCE
MOTOROLA
SYMBOL
REFERENCE
SYMBOL
Qty
1
1
1
1
1
MOTOROLA
PART NO.
DESCRIPTION
PART NO.
DESCRIPTION
PART NO.
DESCRIPTION
Qty
non-referenced items:
3286063C01
O-ring, gasket
3380184R01
FCC label
3680447K01
volume knob
3680448K01
frequency knob
8408051Y01
rf-to-logic flexible circuit
FLN8665A Miscellaneous Parts (LTS 2000)
REFERENCE
SYMBOL
MOTOROLA
PART NO.
Qty
1
1
1
1
1
non-referenced items:
3286063C01
O-ring, gasket
3380184R01
FCC label
3680432K01
volume knob
3680433K01
frequency knob
8408051Y01
rf-to-logic flexible circuit
non-referenced items:
1
1480577C01
1
2113740F41
microphone boot
chip capacitor, 39 µF±5% 50V
1
3080560D01
speaker mic cable
1
3286062C01
speaker chim
1
3980546B01
front shield ground contact
1
5005589U05
speaker
1
5013920A03
microphone
1
7580506C02
speaker pad
DESCRIPTION
NAF5038A Antenna
REFERENCE
SYMBOL
Qty
1
MOTOROLA
DESCRIPTION
PART NO.
non-referenced item:
8505241U04
whip antenna, 900 MHz
17
Download PDF