Sony MDR-DS1000 DP-1000 Digital surround processor, MDR-DS1000 MDR-XD050 Stereo headphone Service Manual

DP-1000
SERVICE MANUAL
US Model
Canadian Model
AEP Model
Ver. 1.0 2006. 01
• The DP-1000 is the digital surround
processor that comprises the MDRDS1000.
* The digital surround processor for this system incorporates the Dolby Digital decoder, the Dolby Pro Logic II
decoder and the DTS decoder.
Manufactured under licence from Dolby Laboratories and Digital Theater Systems, Inc.
“Dolby,” “Pro Logic,” and the double-D symbol are trademarks of Dolby Laboratories.
“DTS” and “DTS VIRTUAL ” are trademarks of Digital Theater Systems, Inc.
• MDR-DS1000 consists of the following models respectively.
Stereo headphone
MDR-XD050
Digital surround processor
DP-1000
SPECIFICATIONS
Decoder functions
Virtual surround function
Frequency response
Distortion rate
Audio inputs
Audio outputs
Power requirements
Dimensions
Mass
Dolby Digital
Dolby Pro Logic II
DTS
OFF
CINEMA
MUSIC
12 – 22,000 Hz
1% or less (1 kHz)
Optical digital input
(rectangular-type) × 1
Analogue input (stereo mini-jack) × 1
Headphone jacks (stereo mini-jack) × 2
DC 9 V (from the supplied AC power
adaptor)
Approx. 120 × 35 × 120 mm
(4 3/4 × 1 7/16 × 4 3/4 in) (w/h/d)
Approx. 200 g
(7.06 oz)
Design and specifications are subject to change without notice.
DIGITAL SURROUND PROCESSOR
9-887-050-01
Sony Corporation
2006A02-1
Personal Audio Division
Published by Sony Techno Create Corporation
© 2006.01
DP-1000
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Unleaded solder
Boards requiring use of unleaded solder are printed with the lead
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
2
TABLE OF CONTENTS
Specifications ............................................................................ 1
1.
GENERAL ................................................................... 3
2.
DISASSEMBLY
2-1. Upper Cabinet .................................................................. 5
2-2. Front Panel, Panel Board ................................................. 5
3.
DIAGRAMS
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
Block Diagrams ............................................................... 7
Printed Wiring Board – DP Board (Side A) – ................. 8
Printed Wiring Board – DP Board (Side B) – ................. 9
Schematic Diagram – DP Board (1/3) – .......................... 10
Schematic Diagram – DP Board (2/3) – .......................... 11
Schematic Diagram – DP Board (3/3) – .......................... 12
Printed Wiring Board – Panel Board – ............................ 13
Schematic Diagram – Panel Board – ............................... 13
IC Pin Function Descriptions .......................................... 14
4.
EXPLODED VIEWS
4-1. Processor Section ............................................................ 15
5.
ELECTRICAL PARTS LIST .................................. 16
DP-1000
SECTION 1
GENERAL
This section is extracted
from instruction manual.
LOCATING THE CONTROLS
Front Panel of the Processor
LEVEL
DOLBY DIGITAL DOLBY PRO LOGIC
POWER
1 PHONES 2
DTS
INPUT SELECT
EFFECT
OFF
DIGITAL ANALOG CINEMA MUSIC
MIN
1 DECODE MODE indicators
2 POWER indicator
Lights green when the processor is turned
on.
POWER (power) switch
Press to turn the processor on/off.
3 PHONES jack
Connect the supplied headphones.
MAX
4 INPUT SELECT switch
Slide to select the input source
(ANALOG/DIGITAL).
5 EFFECT switch
Slide to select the sound field (CINEMA/
OFF/MUSIC).
6 Volume control
Adjusts the volume of the headphones
connected to the PHONES
3
DP-1000
Rear Panel of the Processor
DC IN9V
LINE IN
ATT
0dB
-8dB
DIGITAL IN
1 ATT (attenuator) switch
Set this switch to “0 dB” if the volume is
too low for analogue input. Normally, this
switch should be set to “–8 dB.”
2 LINE IN jack
Connect the audio output jacks on an
audio or video component (sold
separately), such as a video cassette
player or TV, to these jacks.
4
3 DIGITAL IN jack
Connect a DVD device or other digital
component (sold separately) to this jack.
4 DC IN 9V jack
Connect the supplied AC power adaptor
to this jack. (Be sure to use the supplied
AC power adaptor. Using products with a
different plug polarity or other
characteristics can cause a malfunction.)
DP-1000
SECTION 2
DISASSEMBLY
• This set can be disassembled in the order shown below.
2-1. UPPER CABINET
3 three claws
5 two claws
8 upper cabinet
6two claws
4 two claws
7
2 two screws (+B2.6)
1 two rubber foots
2-2.
FRONT PANEL, PANEL BOARD
6 two screws (+P2)
7 PANEL board
3 claw
4
5 front panel
2 claw
1 volume knob
5
DP-1000
SECTION 3
DIAGRAMS
NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
For schematic diagrams.
Note:
• All capacitors are in µF unless otherwise noted. (p: pF) 50 WV or
less are not indicated except for electrolytics and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise specified.
•
% : indicates tolerance.
•
f : internal component.
• C : panel designation.
• A : B+ Line.
• Power voltage is dc 9 V and fed with regulated dc power supply
from battery terminal.
• Voltages and waveforms are dc with respect to ground under nosignal conditions.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : ANALOG
J : DIGITAL
For printed wiring boards.
Note:
• X : parts extracted from the component side.
•
f : internal component.
•
: Pattern from the side which enables seeing.
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• Indication of transistor.
C
Q
These are omitted.
B E
• Waveforms
1 IC602
i; XO
1.6Vp-p
206 ns
0.5V/DIV, 0.1 µsec/DIV
2
IC103
4 OUT
3.9Vp-p
83.2 ns
1V/DIV, 20 nsec/DIV
• IC Block Diagrams
IC305 XC6365A253MR
5 V OUT
PWM
COMPARATOR
PHASE
COMPENSATION
ERROR AMP
.
+
+
EXT/
6
1
VDD
2
GND
3
BUFFER,
DRIVER
-
RAMP WAVE
GENERATOR
OSC
PWM/PFM
CONTROLLER
VREF WITH
SOFT START,
CE
4 CE
DP-1000
3-1. BLOCK DIAGRAM
IC203
AUDIO A/D,D/A
CONVERTER
IC202
LINE AMP
8 DACDAT
R-CH
J201
LINE IN
5
LOUT 16
ROUT 17
5
23 RLINEIN ADCDAT 10
27 SDIN
28 SCLK
CODEC_XCS
131 FSDATAN1
BCK 7
ADCLRC 11
MCLK 1
DIGITAL IN
26 CSB
IC102
DIR
12 RXIN
VOUT 1
DATAO
BCK
LRCK
CKOUT
DIRDATA
BCK
LRCK
MCK
22
20
21
19
IC501
LEVEL SHIFT
24 XIN
IC103
CLOCK OSC
ERROR
PD
CE
CL
DI
DO
E/INT
AUDIO
UGPI
2
3
5
6
7
8
9
10
11
DIR_ERR
DIR_XRST
DIR_XCS
SCK1
SDO1
SDI1
DIR_EMP
DIR_NAUD
DIR_XST
DSP_NOSG
DEC_INTREQ
SDI2
DSP_XINTREQ
DSP_HINBSY
J202
PHONES 1
7
R-CH
J203
PHONES 2
111 FSCLKN2
0dB
IC101
OPTICAL RECEIVER
6
134
119
117
98
87
FSCLKN1,STCCLK2
FLRCLKN1
FLRCLKN2
SCLK1
LRCLK1
118
104
108
99
FSDATAN2
SCLK0
LRCLK0
MCLK
5
15
110 DTO
18
16
14
12
9
2
4
6
8
11
31
16
7
3
141
GPIO15
XFINTREQ
FHS2,FSCDOUT
XINTREQ
HINBSY
127 CLKIN
2 IN OUT 4
IC401
DECODER,DSP
XRESET
SCCLK
SCDIN
SCCS
AFCS
FSCDIN
FSCCLK
SDO1
SCK1
S201
ATT
-8dB
7
Q201
MUTE
R-CH
R-CH
IC201
HEADPHONE AMP
R-CH
24 LLINEIN DACLRC 9
7
IC204
LINEAMP
RV201
LEVEL
144 142 136 135 15 4 6
D701
DTS
Q701
LED DRIVER
X101
12.288MHz
29 18 17 28 30
38
31
16
32
39
SDO1
SCK1
P62
P76
P74
SCK2
SOT2
P73
P75
DSP_NOSG
DEC_INTREQ
SDI2
DSP_XINTREQ
DSP_HINBSY
P45 22
P44 20
P43 19
P46 23
SIN2
P77
P63
57 SDO1
58 SCK1
50 P82
CODEC_XCS
DIR_ERR
DIR_XRST
DIR_XCS
SCK1
SDO1
SDI1
DIR_EMP
DIR_NAUD
DIR_XST
76 P57
66 PA2
67 PA3
56
73
74
72
S702
INPUT SELECT
DIGITAL
: ANALOG
: DIGITAL
D702
DOLBY PRO
LOGIC
Q703
LED DRIVER
D703
DOLBY
DIGITAL
Q704
LED DRIVER
D704
POWER
REG_9V
IC602
SYSTEM
CONTROLLER
SIN1
P55
P56
P54
Q301
SWITCHING
REG_2.5V
X0 80
X1 81
UNREG_9V
IC305
+2.5V REGULATOR
X601
5MHz
D302
1 EXT
IC301
+9V REGULATOR
2 VOUT VDD 2
2 OUT
P27
S701
EFFECT
MUSIC
13 P35
15 P37
OFF
14 P36
REG_5V
IC304
+3.3V REGULATOR
IC601
RESET
CINEMA
5 P26
XRST 75
S703
POWER
7
3 OUT
IN 2
IC302
+5V REGULATOR
Q302,303
B+ SWITCH
3 OUT
IN 1
IC303
+4.2V REGULATOR
D601
1 OUT
UNSW_REG_4.2V
DP-1000
REG_3.3V
1 OUT IN 2
VCC
7
-
MAPOW
6
J301
DC IN 9V
IN 1
CE
4
12 P34
ANALOG
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
P01 84
Q702
LED DRIVER
IN 3
+
DP-1000
3-2. PRINTED WIRING BOARD – DP BOARD (SIDE A) –
: Uses unleaded solder.
3
2
1
4
5
6
7
C227
R243
R211
R217
1
IC201
L401
C401
FB505
FB506
11
IC501
R506
R505
R254
C246
26
3
D301
Q301
5
1
C303
L301
3
4
C608
D302
C301
C316
C606
FB222
C244
R609
75
1
76
100
5
R610
C613
R611
C614
C243
C612
D222
D221
C604
X601
R604
IC303
C601
3
1
C309
C311
D601
1
SL601
4
4
C320
IC602
R602
R605
3
R608
C611
IC601
D220
LF202
FB223
25
FB221
C615
R253
C245
C609
C617
FB601
50
L302
R503
C616
10
51
C602
IC305
C317
5
R207 R212
8
R606
1
Q201
C418
C411 C415
C408
4
FB502 R502
R615
R614
C610
R613
R303 R302
20
R617
R612
R607
Q303
C321
R301
5
FB503
C619
R501
SL603
C618
C318
1
R616
R402
L502
R413
R411 R412
R403
C313
3
C501
FB401 R410
R405
36
FB402
SL604
C305
R213
C502
C405
C404
R414
R415
R416
FB501 FB504
R404 FB403
FB405
1
C312
LF301
R235
37
1
L202
L207
R220
C410
R418 C409
144
C406
E
G
C232
C414
R421
R109
IC304
F
R236
FB208
R224
R225
FB404
C235 C239
FB209
FB204
FB210
C224
1
C407
R417
R104
Q302
Q202
C209
L406
FB106
R242
R248
R422
R406
R103
R105
R102
C110
3
R100
C108
FB406
C109
C106
C103
1
R244
R237
R245 R240 R241
73
C419
R504
C105 5
R419
R115
R113
L108
R101
D
13
4
8
C603
12
R247
72
R401
R409
IC102
4
IC401
R408
R106
R223
109
R420
C107
R108
5
R239
C420
108
IC204
R249
14
FB206
• Semiconductor Location
Ref. No.
C250
L408
R111
R110
*IC203
8
FB407
C416
C413
C412
R112
IC103
L102
L201
C102 FB105
FB103
FB102
1
24
15
FB205
R114
R107
C101
7
R407
R216
D205
C
R233
R209
C230
21
L206
R214
C216
C214
R210
C211
R423
1
R221
C234
R228
C417
8
C241
R208
5
C225
IC202
R215
D202
D203
1
X101
C207 FB203
FB201
FB202
D206
D201
D204
4
C237
22
28
R226
L208
C212
B
FB101
R234
R219
C218
LF201
L205
R229
R230
C111 FB104
1
D207
R231
R218
R206
R204
C252 C236
R222
R205
R203
R201
C201
R202
C202
*QFN
(Quad Flat Non-Lead
package)
R227
R232
A
C229
DP BOARD (SIDE A)
L601
D303
1-867-716-
DP-1000
8
8
13
(13)
Location
D201
D202
D203
D204
D205
D206
D207
D220
D221
D222
D301
D302
D303
D601
C-1
B-2
C-2
C-1
C-2
B-1
B-1
E-7
F-7
F-6
F-2
F-3
G-2
F-4
IC102
IC103
IC201
IC202
IC203
IC204
IC303
IC304
IC305
IC401
IC501
IC601
IC602
D-2
D-2
C-6
B-2
B-4
B-5
G-3
E-2
F-3
C-4
D-5
F-4
F-5
Q201
Q202
Q301
Q302
Q303
B-6
B-7
F-3
E-2
F-2
DP-1000
3-3. PRINTED WIRING BOARD – DP BOARD (SIDE B) –
3
2
1
: Uses unleaded solder.
4
5
6
8
7
9
DP BOARD (SIDE B)
A
C228
C231
S201
C217
C251
ATT
C221
C205
0dB
t
RV201
C240
C233
C253
LEVEL
-8dB
C226
C238
C222
C247
B
C223
C220
C242
C219
C210
C248
C213
J201
C249
LINE IN
C208
C215
C206
C
C402
R204
C203
IC101
3
DIGITAL IN
1
D
PANEL
BOARD
(Page 13)
A
CN1
C403
C104
12
10
C307
C314
J203
C319
2
3
E
1
5
PHONES
IC302
C304
C306
1
J202
1
F
IC301
C315
C302
C607
1
J301
C308
DC IN 9V
C310
C605
4
13
1-867-716- (13)
G
DP-1000
9
9
DP-1000
3-4. SCHEMATIC DIAGRAM – DP BOARD (1/3) –
MCK
DSPOUT
BCK
LRCK
ADDATA
• See page 6 for IC Block Diagrams.
FB205
0UH
C205
10
16V
R208
22k
QFN
(Quad Flat Non-Lead package)
C211
0.1
R206
9.1k
S201
C223
100
16V
R209
47k
D201
1SS355TE-17
FB221
0UH
2
J203
C243
0.01
D220
MA3075WA
L206
15uH
C216
0.1
C232
0.1
C224
0.1
D207
1SS355TE-17
LF202
COM MODE
C209
0.1
C203
220
6.3V
C253
47
10V
C210
10
16V
R211
10k
R249
2.2k
R239
4.7k
R213
10k
R253
10k
FB223
0UH
C234
0.1
C250
0.1
C219
10
16V
C248
10
16V
C213
1
50V
R212
10k
R221
1k
Q201
UN2225-(TX)
MUTE
R242
22k
C229
0.0022
C220
10
16V
R248
22k
R244
2.2k
C247
47
10V
R220
1k
R241
22k
IC204
NJM2115M
C246
0.001
R207
10k
C228
10
16V
RV201
10k/10k
LINE AMP
C204
220
6.3V
C226
10
16V
R240
22k
C251
10
16V
HEADPHONE AMP
R254
10k
D221
MA3075WA
C227
0.0022
R236
4.7k
R243
22k
C242
R235 10
10k 16V
R217
0
AMUTE
Q202
UN2225-(TX)
MUTE
R237
4.7k
GND
BUS
LF301
LINE FILTER
J301
DC IN
C233 L207
10
16V 15uH
R247
22k
C249
10
16V
IC201
LM4809MA
D222
MA3075WA
R232
10k
R214
1k
FB222 0UH
PHONES
C231
10
16V
C237
0.01
L201
10uH
C245
0.001
C244
0.01
C225
0.1
D206
1SS355TE-17
D204
1SS355TE-17
1
R216
22k
C215
10
16V
R245
4.7k
D205
MA3075WA
J202
C208
100
6.3V
L205
10uH
C230
0.1
R231 1k
R210
22k
SCK1
R204
47k
R227 10k
C206
10
16V
CODEC_XCS R228 100
SDO1 R229 1k
C236
0.01
C222
R215 R233 22
470k 47k 16V
C214
180p
C202
100p
C240
10
16V
IC203
XWM8734SEFL/R
IC202
NJM4558M-TE2
C207
100p
D203
MA3075WA
R202
680k
FB204 C238
0UH 10
16V
R219 R234
470k 47k C221
22
16V
FB210 L208 C241
0UH 15uH 0.1
C239
0.1
*
R205
9.1k
FB202
0UH
FB203
0UH
FB208
0UH
C235
0.1
C218
180p
LF201
COM MODE
D202
MA3075WA
R218
22k
R203
47k
FB201
0UH
J201
R201
680k
C212
100p
R230
100
FB209
0UH
*
C201
100p
C217
10
16V
FB206
0UH
R222
1k
R226
1k
R225
1k
R223
1k
R224
1k
9V
C303
0.1
D301
RB051L-40TE25
C304
4700
25V
C306
4700
25V C301
0.1
Q302
2SB1690K
B+ SWITCH
R302
100k
L202
10uH
IC302
KIA78S05P-TP
Q303
DTC114EKAF
B+ SWITCH
IC303
XC6202P422PR
+9V REG
+5V REG
R301
10k
C321 C305
0.1 0.1
C307 C308
100 100
6.3V 6.3V
C309
0.1
D302
RB161M-20FTR
L301
22uH
L302
47uH
REG_2.5V
GND
IC305
XC6365A253MR
IC304
XC6206P332PR
+2.5V REG
+3.3V REG
+4.2V REG
C302
100
16V
Q301
RTQ035P02TR
SWITCHING
R303
1k
IC301
PQ09RD1SJ00H
D303
MA3075WA
UNREG_9V
MAPOW
UNSW_REG_4.2V
BUS
REG_3.3V
C310
100
16V
C312
0.1
C311
0.1
DP-1000
10
10
C313
0.1
C314
100
6.3V
C315
100
16V
C316
0.1
C320
0.1
C317
33
6.3V
C318
0.1
C319
2200
6.3V
DP
BOARD
(3/3)
(page 12)
DP
BOARD
(2/3)
(page 11)
DP-1000
OPTICAL RECEIVER
FB101
0UH
R103 1k
R104 1k
R101
100
IC101
TORX141L
C111
0.1
R108
10k
CLOCK OSC
R109
1M
C101
0.47
C105
0.0068
C102
0.1
L108 FB106
15uH 0UH
R107
10k
R102
150
C106
0.047
FB102 0UH
FB103 0UH
FB104 0UH
FB105 0UH
R111 330
R112 330
R113 330
R114 330
R402
330
SYSCK
DIRDATA
LRCK
BCK
MCK
R420
10k
R409
3.3k
R410
3.3k
R406
10k
FB402
0UH
FB404
0UH
R411
3.3k
IC401
CS494003-CQZ
R403
330
C104
47
10V
R412 R413
3.3k 3.3k
C405
0.1
R414
3.3k
C501
0.1
IC501
SN74LVC244APWR
DSP_NOSG_L
DEC_XINTREQ_L
DSPOUT
SDI2_L
R415
3.3k
R416
3.3k
L502
10uH
C502
0.1
R504 FB504
330 0UH
R404
DSP_NOSG_L 330
FB502
0UH
R502
330
DSP_NOSG
FB503
0UH
R503
330
DEC_XINTREQ
FB403
0UH
C403
470
6.3V
L406
10uH
DSPOUT_L
SDI2
DSP_XINTREQ_L
DSP_HINBSY
FB506 FB505 R505 R506
0UH 0UH 330 330
R501 FB501
330 0UH
DSP_XINTREQ
DSP_HINBSY_L
C406
0.1
L401
10uH
C401
0.1
C402
100
4V
REG_2.5V
BUS
GND
REG_3.3V
GND
BUS
C408
0.1
DP
BOARD
(3/3)
(page 12)
LRCK
BCK
MCK
BCK
DSPOUT_L
LRCK
DIRDATA
LRCK
SYSCK
ADDATA
SDO2
DSP_XCS
BCK
C419
0.1
FB401
0UH
DEC_XCS
DEC_XINTREQ_L
C103
0.1
C110
0.1
R115
100
R110
100
C420
0.1
C404
0.1
SCK2
SDI2_L
L102
10uH
FB407
0UH
R421
3k
R407
R408 3.3k
R401
330 FB405 3.3k
R405
0UH
DSP_XINTREQ_L
3.3k
SDO2
X101
12.288MHz
C109
27p
C416
0.0012
R423
1k
C414
2.2
10V
IC103
SN74AHC1GU04
IC102
LC89052TA-TLM-E
C417
0.1
L408
15uH C413
68p
C412
4.7
FB406
0UH
R100
330
C107
0.01
C410
0.1
R419
330
R417 C407
10k 0.001
C108
27p
C409
0.1
R418
3.3k
R105
10k
R106
10k
SCK2
DSP_HINBSY_L
DSP_XRST
• See page 6 for Waveforms.
DIR_XRST
DIR_ERR
DIR_XST
DIR_NAUD
DIR_EMP
SDI1
SDO1
SCK1
DIR_XCS
3-5. SCHEMATIC DIAGRAM – DP BOARD (2/3) –
DP
BOARD
(1/3)
(page 10)
DP-1000
11
11
C411
0.1
C415
0.1
R422
10k
C418
0.1
DP-1000
CODEC_XCS
SCK1
SDO1
SDI1
C603 0.1
LED_POW
LED_DTS
LED_PL2
LED_DD
SCK1
SDO1
SDI1
DIR ERR
DIR XCS
DIR XRST
DIR_ERR
DIR NAUD
DIR EMP
DIR XST
R612
10k
SW_INPUT
SW_EFF_OFF
SW_EFF_C
SW_EFF_M
SW_POWER
PANEL
BOARD
(page 13)
CODEC XCS
SL603
X601
5MHz
GND
UNREG_9V
BUS
3.3V
MAPOW
UNSW_REG_4.2V
R606
10k
R605 1k
CN1
12P
AMUTE
R616
10k
AMUTE
DSP_HINBSY
DSP_NOSG
DSP HINBSY
DSP NOSG
C607
C605
D601
1000 C606 L601 100
1SR154-400TE25 6.3V 0.1 15uH 6.3V
C608
0.1
FB601 0UH
C604
0.1
DSP_XINTREQ
DEC_XINTREQ
DEC_XCS
DSP_XRST
DSP_XCS
SW POWER
MAPOW
SW INPUT
SW EFF M
SW EFF C
SW EFF OFF
SDI2
SDO2
SCK2
LED DD
LED PL2
VCC5
LED DTS
LED POW
DSP XINTREQ
DEC XINTREQ
DEC XCS
DSP XRST
DSP XCS
IC601
BD5228G
SDO0
R614
10k
R615
10k
XRST
R602
4.7k
R608
R609
R610
R611
C611
C612
C613
C614
LED_DTS
LED_POW
SW_POWER
DP
BOARD
(2/3)
(page 11)
SW_INPUT
SW_EFF_M
SW_EFF_C
SW_EFF_OFF
SDI2
SDO2
SCK2
LED_DD
LED_PL2
GND
BUS
C609
0.1
DP-1000
12
12
C619
0.1
C618
0.001
R607
10k
IC602
MB904889FV
-G-182E1
C602
0.033
R617
10k
R613 SL604
10k
C610
0.001
R604
2.2k
SDI0
DP
BOARD
(1/3)
(page 10)
DIR_XCS
DIR_XRST
• See page 14 for IC Pin Function Discription.
DIR_XST
• See page 6 for Waveforms.
XRST
DIR_NAUD
DIR_EMP
3-6. SCHEMATIC DIAGRAM – DP BOARD (3/3) –
10k
10k
10k
10k
0.1
0.1
0.1
0.1
C615
0.1
C616
0.001
C617
0.001
DP-1000
3
CN701
12P
PANEL BOARD (SIDE B)
A
S701
EFFECT
C706
C701
D701
DTS
MUSIC
D701
D702
SLR-324VCT32 SLR-342VCT32
RED
RED
D703
SLR-324VCT32
RED
D704
SLR-342MCT32
GREEN
R701
2.2k
R703
2.2k
R704
1k
t
Q701
R702
2.2k
DTS
OFF
DOLBY PRO
LOGIC
DOLBY DIGITAL
VCC
LED_POW
LED_DTS
LED_PL2
LED_DD
SW_INPUT
SW_EFF_OFF
SW_EFF_C
SW_EFF_M
SW_POWER
C705
0.001
POWER
t
CINEMA
Q702
Q701
DTC123YUA
C703
0.001
SW_EFF_M
C704
0.001
Q702
DTC123YUA
Q703
DTC123YUA
Q701-704
LED DRIVER
C703
R703
D703
A
DP
BOARD
(Page 9)
DOLBY
DIGITAL
D
1
C704
Q704
S703
POWER
D704
POWER
C710
R705
C709
13
1-867-717- (13)
13
1-867-717- (13)
• Semiconductor Location
Ref. No.
DP-1000
C702
0.001
C710
0.1
CN701
C705
E
SW_EFF_OFF
S703
C701
0.001
12
R704
R705
10k
DIGITAL
C708
Q703
C
LED_POW
t
ANALOG
LED_DD
C702
LED_PL2
S702
INPUT
SELECT
C707
R702
D702
DOLBY PRO
LOGIC
LED_DTS
B
C706
0.001
C707
0.001
C708
0.001
C709
0.001
SW_EFF_C
R701
DP
BOARD
(3/3)
(page 11)
SW_POWER
PANEL BOARD (SIDE A)
4
VCC
2
1
3-8. SCHEMATIC DIAGRAM – PANEL BOARD –
: Uses unleaded solder.
SW_INPUT
3-7. PRINTED WIRING BOARD – PANEL BOARD –
Location
D701
D702
D703
D704
A-4
B-4
C-4
E-4
Q701
Q702
Q703
Q704
A-1
B-1
C-1
E-1
13
13
Q704
DTC123YUA
S701
S702
DP-1000
3-9. IC Pin Function Descriptions
• IC602 MB90488BPFV-G-182E1 (SYSTEM CONTROLLER) (DP BOARD)
Pin No.
Pin Name
I/O
68 to 71
P50 to P53
—
72
DIR XST
I
Function setting signal input
73
DIR EMP
I
Emphasis signal input
Not used (Open)
74
DIR NAUD
I
Audio select signal input
Pin No.
Pin Name
I/O
1 to 4
P22 to P25
—
Description
5
SW POWER
I
Power switch ON/OFF signal input
6
MAPOW
O
REG 9V main power ON/OFF signal output
7,8
P30,P31
—
Not used (Open)
Description
Not used (Open)
9
VSS
—
Ground
75
XRST
I
System reset signal input
10,11
P32,P33
—
Not used (Open)
76
DIR ERR
I
Error signal input
12
SW INPUT
I
INPUT SELECT switch signal input
77
X1A
—
Not used (Open)
13
SW EFF M
I
EFFECT switch signal input (L : MUSIC)
78
X0A
—
Not used (Connected to ground)
14
SW EFF C
I
EFFECT switch signal input (L : CINEMA)
79
VSS
—
Ground
15
SW EFF OFF
I
EFFECT switch signal input (L : EFFECT OFF)
80
XO
O
Clock output (5MHz)
16
SDI2
I
Serial data input 2
81
XI
I
Clock input (5MHz)
17
SDO2
O
Serial data output 2
82
VCC3
—
Power supply (+3.3V)
18
SCK2
O
Serial clock output 2
83
P00
—
Not used (Open)
19
LED DD
O
DOLBY DIGITAL LED drive signal output
84
AMUTE
O
Audio mute signal output
20
LED PL2
O
DOLBY PRO LOGIC II LED drive signal output
85 to 90
P02 to P07
—
Not used (Open)
21
VCC5
—
Power supply (+3.3V)
91 to 98
P10 to P17
—
Not used (Open)
99,100
P20,P21
—
Not used (Open)
22
LED DTS
O
DTS LED drive signal output
23
LED POW
O
POWER LED drive signal output
24
P47
—
Not used (Open)
25
SDI0
—
Not used (Open)
26
SDO0
—
Not used (Open)
27
SCK0
—
Not used (Open)
28
DSP XCS
O
DSP chip select signal output
29
DSP XRST
O
DSP reset signal output
30
DEC XCS
O
Decoder chip select signal output
31
DEC XINTREQ
I
DEC interruption request signal input
32
DSP XINTREQ
I
DSP interruption request signal input
33
AVCC
—
34
AVRH
I
35
AVSS
—
Ground
36,37
AN0,AN1
—
Not used (Open)
38
DSP NOSG
I
DSP NOSG signal input
39
DSP HINBSY
I
DSP HINBSY signal input
40
VSS
—
Ground
41 to 44
P64 to P67
—
Not used (Open)
45
P80
—
Not used (Pull up)
46
P81
—
Not used (Pull down)
Power supply (+3.3V)
A/D converter outside standard power supply input
47 to 49
MD0 to MD2
I
Mode select terminal
50
CODEC XCS
O
CODEC chip select signal output
51 to 55
P83 to P87
—
Not used (Open)
56
SDI1
I
Serial data input 1
57
SDO1
O
Serial data output 1
58
SCK1
O
Serial clock output 1
59
P93
—
Not used (Pull down)
60 to 63
P94 to P97
—
Not used (Open)
64,65
PA0,PA1
—
Not used (Open)
66
DIR XRST
O
DIR reset signal output
67
DIR XCS
O
DIR chip select signal output
DP-1000
14
14
DP-1000
SECTION 4
EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
•
The mechanical parts with no reference number
in the exploded views are not supplied.
Accessories are given in the last of this parts
list.
•
4-1. PROCESSOR SECTION
7
13
not supplied
5
4
8
6
not
supplied
3
2
9
1
10
11
12
Ref. No.
1
2
3
4
5
6
7
Part No.
2-634-815-01
2-634-813-01
2-634-816-01
2-634-814-01
A-1127-594-A
Description
KNOB, VOLUME
PANEL, FRONT
KNOB, SLIDE
KNOB, POWER
PANEL BOARD, COMPLETE
3-255-458-21 SCREW (DIA.2), TAPPING
2-634-812-01 CABINET, UPPER
Remarks
Ref. No.
Part No.
Description
8
9
10
A-1127-593-A DP BOARD, COMPLETE
2-634-811-01 CABINET, LOWER
2-639-049-01 RUBBER (BACK), FOOT
11
12
13
3-254-151-01 SCREW (B2.6), (+) P TAPPING
2-636-697-01 RUBBER, FOOT
3-257-555-11 CUSHION (S/W)
Remarks
15
DP-1000
DP
SECTION 5
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX, -X mean standardized parts, so they
may have some difference from the original
one.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
• CAPACITORS:
uF: µF
Ref. No.
Part No.
•
•
•
RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
COILS
uH: µH
SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
Description
Remarks
A-1127-593-A DP BOARD, COMPLETE
******************
< CAPACITOR >
C101
C102
C103
C104
C105
1-125-891-11
1-107-826-11
1-107-826-11
1-124-589-11
1-162-969-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.47uF
0.1uF
0.1uF
47uF
0.0068uF
10%
10%
10%
20%
10%
10V
16V
16V
16V
25V
C106
C107
C108
C109
C110
1-165-176-11
1-162-970-11
1-162-920-11
1-162-920-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
0.01uF
27PF
27PF
0.1uF
10%
10%
5%
5%
10%
16V
25V
50V
50V
16V
C111
C201
C202
C203
C204
1-107-826-11
1-162-953-11
1-162-953-11
1-124-635-00
1-124-635-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.1uF
100PF
100PF
220uF
220uF
10%
5%
5%
20%
20%
16V
50V
50V
6.3V
6.3V
C205
C206
C207
C208
C209
1-124-233-11
1-124-233-11
1-162-953-11
1-124-584-00
1-107-826-11
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
10uF
10uF
100PF
100uF
0.1uF
20%
20%
5%
20%
10%
16V
16V
50V
6.3V
16V
C210
C211
C212
C213
C214
1-124-233-11
1-107-826-11
1-162-953-11
1-126-160-11
1-164-218-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
10uF
0.1uF
100PF
1uF
180PF
20%
10%
5%
20%
5%
16V
16V
50V
50V
50V
C215
C216
C217
C218
C219
1-124-233-11
1-107-826-11
1-124-233-11
1-164-218-11
1-124-233-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
10uF
0.1uF
10uF
180PF
10uF
20%
10%
20%
5%
20%
16V
16V
16V
50V
16V
C220
C221
C222
C223
C224
1-124-233-11
1-124-234-00
1-124-234-00
1-125-972-61
1-107-826-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
10uF
22uF
22uF
100uF
0.1uF
20%
20%
20%
20%
10%
16V
16V
16V
16V
16V
C225
C226
C227
C228
C229
1-107-826-11
1-124-233-11
1-162-966-11
1-124-233-11
1-162-966-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
10uF
0.0022uF
10uF
0.0022uF
10%
20%
10%
20%
10%
16V
16V
50V
16V
50V
16
Ref. No.
When indicating parts by reference
number, please include the board.
Part No.
Description
C230
C231
C232
C233
C234
1-107-826-11
1-124-233-11
1-107-826-11
1-124-233-11
1-107-826-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
10uF
0.1uF
10uF
0.1uF
10%
20%
10%
20%
10%
16V
16V
16V
16V
16V
Remarks
C235
C236
C237
C238
C239
1-107-826-11
1-162-970-11
1-162-970-11
1-124-233-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.01uF
0.01uF
10uF
0.1uF
10%
10%
10%
20%
10%
16V
25V
25V
16V
16V
C240
C241
C242
C243
C244
1-124-233-11
1-107-826-11
1-124-233-11
1-162-970-11
1-162-970-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
10uF
0.01uF
0.01uF
20%
10%
20%
10%
10%
16V
16V
16V
25V
25V
C245
C246
C247
C248
C249
1-162-964-11
1-162-964-11
1-124-589-11
1-124-233-11
1-124-233-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
0.001uF
0.001uF
47uF
10uF
10uF
10%
10%
20%
20%
20%
50V
50V
16V
16V
16V
C250
C251
C253
C301
C302
1-107-826-11
1-124-233-11
1-124-589-11
1-107-826-11
1-125-972-61
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
ELECT
0.1uF
10uF
47uF
0.1uF
100uF
10%
20%
20%
10%
20%
16V
16V
16V
16V
16V
C303
C304
C305
C306
C307
1-107-826-11
1-128-548-11
1-107-826-11
1-128-548-11
1-124-584-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
0.1uF
4700uF
0.1uF
4700uF
100uF
10%
20%
10%
20%
20%
16V
25V
16V
25V
6.3V
C308
C309
C310
C311
C312
1-124-584-00
1-107-826-11
1-125-972-61
1-107-826-11
1-107-826-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
100uF
0.1uF
0.1uF
20%
10%
20%
10%
10%
6.3V
16V
16V
16V
16V
C313
C314
C315
C316
C317
1-107-826-11
1-124-584-00
1-125-972-61
1-107-826-11
1-104-752-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
TANTAL. CHIP
0.1uF
100uF
100uF
0.1uF
33uF
10%
20%
20%
10%
20%
16V
6.3V
16V
16V
6.3V
C318
C319
C320
C321
1-107-826-11
1-104-656-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
2200uF
0.1uF
0.1uF
10%
20%
10%
10%
16V
6.3V
16V
16V
DP-1000
DP
Ref. No.
Part No.
Description
Remarks
C401
1-107-826-11 CERAMIC CHIP
0.1uF
10%
16V
C402
C403
C404
C405
C406
1-124-584-00
1-104-655-91
1-107-826-11
1-107-826-11
1-107-826-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
470uF
0.1uF
0.1uF
0.1uF
20%
20%
10%
10%
10%
4V
6.3V
16V
16V
16V
C407
C408
C409
C410
C411
1-162-964-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
16V
16V
16V
16V
C412
C413
C414
C415
C416
1-100-507-91
1-162-925-11
1-135-149-21
1-107-826-11
1-164-730-11
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
68PF
2.2uF
0.1uF
0.0012uF
20%
5%
20%
10%
10%
6.3V
50V
10V
16V
50V
C417
C418
C419
C420
C501
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C502
C601
C602
C603
C604
1-107-826-11
1-107-826-11
1-164-677-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.033uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C605
C606
C607
C608
C609
1-124-584-00
1-107-826-11
1-126-916-11
1-107-826-11
1-107-826-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
1000uF
0.1uF
0.1uF
20%
10%
20%
10%
10%
6.3V
16V
6.3V
16V
16V
C610
C611
C612
C613
C614
1-162-964-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
16V
16V
16V
16V
C615
C616
C617
C618
C619
1-107-826-11
1-162-964-11
1-162-964-11
1-162-964-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.001uF
0.001uF
0.001uF
0.1uF
10%
10%
10%
10%
10%
16V
50V
50V
50V
16V
< CONNECTOR >
CN1
Ref. No.
D302
D303
D601
Part No.
Description
Remarks
6-500-220-11 DIODE RB161M-20FTR
8-719-420-83 DIODE MA3075WA-TX
8-719-053-18 DIODE 1SR154-400TE-25
< FERRITE BEAD >
FB101
FB102
FB103
FB104
FB105
1-414-234-22
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
FB106
FB201
FB202
FB203
FB204
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
FB205
FB206
FB208
FB209
FB210
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
FB221
FB222
FB223
FB401
FB402
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
FB403
FB404
FB405
FB406
FB407
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
FB501
FB502
FB503
FB504
FB505
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
1-414-760-21
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
FB506
FB601
1-414-760-21 INDUCTOR, FERRITE BEAD
1-414-760-21 INDUCTOR, FERRITE BEAD
< IC >
IC101
IC102
IC103
IC201
IC202
6-600-466-01
6-703-373-01
8-759-649-50
6-705-331-01
8-759-100-96
IC
IC
IC
IC
IC
TORX147L
LC89052T-TLM-E
SN74AHC1GU04DCKR
LM4809MA
uPC4558G2
IC203
IC204
IC301
IC302
IC303
6-705-014-01
8-759-357-68
6-703-479-01
8-759-537-90
6-707-194-01
IC
IC
IC
IC
IC
XWM8734SEFL/R
NJM2115M-TE2
PQ09RD1SJ00H
KIA78S05P-TP
XC6202P422PR
IC304
IC305
IC401
IC501
IC601
6-704-529-01
6-705-016-01
6-705-015-01
8-759-679-53
6-705-507-01
IC
IC
IC
IC
IC
XC6206P332PR
XC6365A253MR
CS494003-CQZ
SN74LVC244APWR
BD5228G
IC602
6-806-183-01 IC MB90488BPFV-G-182E1
1-785-324-11 PIN, CONNECTOR (STRAIGHT) 12P
< DIODE >
D201
D202
D203
D204
D205
8-719-988-61
8-719-420-83
8-719-420-83
8-719-988-61
8-719-420-83
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
MA3075WA-TX
MA3075WA-TX
1SS355TE-17
MA3075WA-TX
D206
D207
D220
D221
D222
8-719-988-61
8-719-988-61
8-719-420-83
8-719-420-83
8-719-420-83
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
MA3075WA-TX
MA3075WA-TX
MA3075WA-TX
D301
8-719-066-98 DIODE RB051L-40TE25
17
DP-1000
DP
Ref. No.
Part No.
Description
Remarks
< JACK >
J201
J202
J203
J301
1-566-822-51
1-566-822-51
1-566-822-51
1-785-066-11
JACK (LINE IN)
JACK (PHONES 1)
JACK (PHONES 2)
JACK, DC (POLARITY UNIFIED TYPE) (DC IN 9V)
< COIL >
L102
L108
L201
L202
L205
1-414-078-11
1-412-953-11
1-414-078-11
1-414-078-11
1-414-078-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
15uH
10uH
10uH
10uH
L206
L207
L208
L301
L302
1-412-953-11
1-412-953-11
1-412-953-11
1-416-669-11
1-419-881-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
15uH
15uH
15uH
22uH
47uH
L401
L406
L408
L502
L601
1-419-353-21
1-419-353-21
1-412-953-11
1-414-078-11
1-412-953-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
10uH
15uH
10uH
15uH
Ref. No.
Part No.
Description
Remarks
R207
R208
R209
1-216-833-11 METAL CHIP
1-216-837-11 METAL CHIP
1-216-841-11 METAL CHIP
10K
22K
47K
5%
5%
5%
1/10W
1/10W
1/10W
R210
R211
R212
R213
R214
1-216-837-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
10K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R215
R216
R217
R218
R219
1-216-853-11
1-216-837-11
1-216-864-11
1-216-837-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470K
22K
0
22K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R220
R221
R222
R223
R224
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R225
R226
R227
R228
R229
1-216-821-11
1-216-821-11
1-216-833-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
10K
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R230
R231
R232
R233
R234
1-216-809-11
1-216-821-11
1-216-833-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
10K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R235
R236
R237
R239
R240
1-216-833-11
1-216-829-11
1-216-829-11
1-216-829-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
4.7K
4.7K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R241
R242
R243
R244
R245
1-216-837-11
1-216-837-11
1-216-837-11
1-216-825-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
22K
2.2K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R247
R248
R249
R253
R254
1-216-837-11
1-216-837-11
1-216-825-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
2.2K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R301
R302
R303
R401
R402
1-216-833-11
1-216-845-11
1-216-821-11
1-216-815-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
1K
330
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R403
R404
R405
R406
R407
1-216-815-11
1-216-815-11
1-216-827-11
1-216-833-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
330
3.3K
10K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R408
R409
R410
R411
R412
1-216-827-11
1-216-827-11
1-216-827-11
1-216-827-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
3.3K
3.3K
3.3K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< LINE FILTER >
LF201
LF202
LF301
1-403-601-21 FILTER, COMMON MODE
1-403-601-21 FILTER, COMMON MODE
1-416-846-21 COIL, LINE FILTER
< TRANSISTOR >
Q201
Q202
Q301
Q302
Q303
8-729-043-69
8-729-043-69
6-550-354-01
6-550-363-01
1-801-806-11
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2225-(TX).S0
UN2225-(TX).S0
RTQ035P02TR
2SB1690KT146
DTC144EKA
< RESISTOR >
R100
R101
R102
R103
R104
1-216-815-11
1-216-809-11
1-216-811-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
100
150
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R105
R106
R107
R108
R109
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R110
R111
R112
R113
R114
1-216-809-11
1-216-815-11
1-216-815-11
1-216-815-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
330
330
330
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R115
R201
R202
R203
R204
1-216-809-11
1-216-855-11
1-216-855-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
680K
680K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R205
R206
1-216-829-11 METAL CHIP
1-216-829-11 METAL CHIP
4.7K
4.7K
5%
5%
1/10W
1/10W
18
DP-1000
DP
Ref. No.
Part No.
Description
R413
R414
R415
R416
R417
1-216-827-11
1-216-827-11
1-216-827-11
1-216-827-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
3.3K
3.3K
3.3K
10K
5%
5%
5%
5%
5%
Remarks
1/10W
1/10W
1/10W
1/10W
1/10W
R418
R419
R420
R421
R422
1-216-827-11
1-216-815-11
1-216-833-11
1-216-865-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
330
10K
3K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R423
R501
R502
R503
R504
1-216-821-11
1-216-815-11
1-216-815-11
1-216-815-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
330
330
330
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R505
R506
R602
R604
R605
1-216-815-11
1-216-815-11
1-216-829-11
1-216-825-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
330
4.7K
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R606
R607
R608
R609
R610
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R611
R612
R613
R614
R615
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R616
R617
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
10K
10K
5%
5%
1/10W
1/10W
Ref. No.
C710
Part No.
Description
PANEL
Remarks
1-107-826-11 CERAMIC CHIP
0.1uF
10%
16V
< DIODE >
D701
D702
D703
D704
8-719-070-73
8-719-070-73
8-719-070-73
8-719-070-74
DIODE
DIODE
DIODE
DIODE
SLR-342VCT32 (DTS)
SLR-342VCT32 (DOLBY PRO LOGIC II)
SLR-342VCT32 (DOLBY DIGITAL)
SLR-342MCT32 (POWER)
< TRANSISTOR >
Q701
Q702
Q703
Q704
8-729-924-65
8-729-924-65
8-729-924-65
8-729-924-65
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC123YU
DTC123YU
DTC123YU
DTC123YU
< RESISTOR >
R701
R702
R703
R704
R705
1-216-825-11
1-216-825-11
1-216-825-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
2.2K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S701
S702
S703
1-692-591-21 SWITCH, SLIDE (EFFECT)
1-771-350-21 SWITCH, SLIDE (INPUT SELECT)
1-771-410-21 SWITCH, TACTILE (POWER)
< VARIABLE RESISTOR >
RV201
1-227-713-11 RES, VAR, CARBON
10K/10K (LEVEL)
< SWITCH >
S201
1-571-478-11 SWITCH, SLIDE (ATT)
< VIBRATOR >
X101
1-767-878-11 VIBRATOR, CRYSTAL (12.288 MHz)
X601
1-795-121-21 VIBRATOR, CERAMIC (5 MHz)
************************************************************
A-1127-594-A PANEL BOARD, COMPLETE
*********************
< CAPACITOR >
C701
C702
C703
C704
C705
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C706
C707
C708
C709
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
50V
50V
50V
50V
19
DP-1000
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
Date
1.0
2006.01
Description of Revision
New