APW Wyott | RCW-11 | User manual | Round Cooker Warmer RCW 7-11.cdr

R
INSTALLATION
AND
OPERATING
INSTRUCTIONS
COUNTERTOP
ROUND COOKER WARMER
Models:
RCW - 7
RCW - 11
(7 Qt. Capacity)
(11 Qt. Capacity)
P/N 79967149 9/07
Phone:
Fax:
Toll Free:
Website:
E-mail:
+1 (214) 421-7366
+1 (214) 565-0976
+1 (800) 527-2100
www.apwwyott.com
[email protected]
APW WYOTT
729 Third Avenue
Dallas, TX 75226
1
TABLE OF CONTENTS
Owner's Information
General Installation
General Operating Instructions
General Cleaning Instructions
General Troubleshooting
Specifications
Installation, Elec
Operations, Cleaning
2
2
2
2
2
3
3
3
Service Information
Wiring Diagram
Parts List w/Exploded View
Warranty
3-4
4
5
7
OWNER'S INFORMATION
General Installation
1.
Always clean equipment thoroughly before first use. (See general cleaning instructions.)
2.
Check rating label for your model designation & electrical rating.
3.
Locate equipment on level counter and plug into a grounded outlet so that the plug is
accessible. (See individual description for electrical loads.) On units bearing the CE
marking the appliance must be connected by an earthing cable to all other units in the
complete installation and hence to an independent earth connection.
General Operating Instructions
1.
2.
3.
4.
5.
All foodservice equipment should be operated by trained personnel.
Do not allow your customers to come in contact with any surface labeled "CAUTION
HOT.”
Where applicable, do not cook, warm or hold food directly in liner pans (well pans). Always
use steam table pans/insets, etc.
Never hold food below 150°F (66°C)
Cold food cannot be inserted for rethermalization while hot food is being held.
General Cleaning Instructions
1.
2.
3.
4.
NEVER clean any electrical unit by immersing it in water. Unplug unit before surface
cleaning. NEVER POUR COLD WATER INTO DRY HEATED UNITS.
Always clean equipment thoroughly before first use. Clean unit daily. Except where noted on
charts: Use warm, soapy water. Mild cleansers & PLASTIC scouring pads may be used to
remove baked-on food & water scale.
Unplug all units before cleaning or servicing. All service should be performed by an APW
authorized service agency.
Do not use chlorides or chloride-based products in this unit. Always clean equipment before
first use. Clean unit daily. Use warm, soapy water. Rinse thoroughly to remove all residue.
Chlorides, chloride-based products and improper cleaning may cause corrosion and pitting.
FAILURE TO COMPLY WITH THESE INSTRUCTIONS MAY VOID UNIT WARRANTY.
GENERAL TROUBLESHOOTING
Always ask & check:
1.
2.
3.
4.
Is the unit plugged in?
Check circuit breaker.
Is power switch on & pilot light glowing?
Check rating label. Are you operating unit on proper voltage?
If the supply cord is damaged, it should only be replaced by an identical supply cord.
If the above checks out, and you still have problems, call an APW authorized service agency.
2
SPECIFICATIONS
Installation:
Follow General Instructions on previous page.
RCW-7 (7qt.).............. 120 volt outlet-8.3 amp load or 230 volt - 4.0 amp.
RCW-11 (11qt.).......... 120 volt outlet-10 amp load or 230 volt - 4.8 amp.
Operations:
Follow General Operating Instructions on previous page.
1.
Add hot water-120°-140° (50°-60° C) to well pan. RCW-7 uses 3 cups (0.7 litre); RCW-11
uses 5 cups (1.2 litre).
2.
Turn thermostat to "High" position and preheat for approximately 10 minutes.
3.
Place covered inset with refrigerated or preheated product into well. Cook on "High"; if using
refrigerated product, stir frequently.
4.
o keep warm, re-adjust control to "Low" - "Medium" setting depending upon the amount and
thickness of product in inset.
5.
Keep covered to maintain ideal serving temperature.
Cleaning:
Daily Cleaning
1.
Refrigerate remaining product.
2.
Follow General Cleaning Instructions on previous page.
SERVICE INFORMATION
IF A SHORTAGE OR A PROBLEM CALL - in the USA 1-888-279-7493
PLEASE FOLLOW THESE INSTRUCTIONS:
A.
ON ALL CALLS YOU WILL NEED TO GIVE THE FOLLOWING INFORMATION.
1.
Name and title of person calling
2.
Phone number of person calling
3.
Business name
4.
Street address
5.
City, State, Zip
6.
Model Number (from serial plate)
7.
Serial Number (from serial plate)
8.
Date purchased (if serial number indicates date of manufacture is over 13 months
old you will be asked to supply proof of purchase)
9.
Purchased from
B.
FOR SHORTAGE - SUPPLY THE ABOVE INFORMATION AND FULLY EXPLAIN WHAT IS
MISSING. It will be sent immediately - prepaid via UPS or equivalent. (Next Day Air or
Priority shipments available at customer's expense)
C.
FOR EQUIPMENT PROBLEM - IF WITHIN ONE YEAR FROM DATE OF PURCHASE THIS
UNIT FAILS TO FUNCTION YOU ARE ENTITLED TO - YOUR CHOICE I - 2 or 3.
1.
APW Wyott will replace the unit.
When calling the factory, besides the above information you will need Electrical
Characteristics, voltage and phase; describe the problems the best you can. The
factory will require a *Visa or Master Card number and expiration date of same to
assure return and/or validity of condition. Upon validation of credit card information,
factory will strive to ship a replacement unit the same day if call is received before
3
3:00 p.m. Central Time or the next day if later. The replacement unit will be shipped
prepaid regular UPS or equivalent. If requested Next Day Air or Priority, shipment will
be made at customers expense. Upon receipt it is the customers responsibility to
unpack the new unit taking care to preserve the packaging. Repack the unit being
replaced in the same container using caution to pack properly and return this unit to
the factory following the instructions supplied. Factory will supply return label and
UPS call tag, both must be used. If original unit is returned within 30 days and is as
represented the credit card validation will be cancelled.
*IMPORTANT - If factory does not receive the unit to be returned within 30 days, the unit will be billed
to the credit card number supplied. If the returned unit is not as represented - i.e. out of warranty,
customer abuse, then it will be billed to the credit card number supplied. In these cases the person
calling in the problem will be contacted and if applicable the returned unit if charged for will be
returned to the original owner if requested.
2.
You may take this unit to the APW Wyott Authorized Service Distributor. List of same
is included with each product. If the problem is covered under warranty the unit will
be repaired at no cost to you. If the Authorized Agency cannot repair same within a
reasonable time while you wait, it will be returned to you prepaid, via UPS.
3.
You can request the Authorized Service Distributor to service the equipment on site.
If problem is covered under the warranty the parts and labor will be billed to the
factory, the mileage and travel time will be responsibility of the owner.
THIS REPLACEMENT WARRANTY IS ONLY AVAILABLE ON SELECTED PRODUCTS SHIPPED WITHIN THE
CONTINENTAL USA, ALASKA, HAWAII AND CANADA. AS WITH MOST WARRANTIES - WARRANTY IS ONLY
VALID TO THE ORIGINAL END-USER OWNER.
INSTRUCTIONS AND PROCEDURES MUST BE FOLLOWED OR THE WARRANTY IS VOID.
RCW-7, 11 & RW-7, 11 WIRING DIAGRAM
WIRE NUT
Green
White
Black
# 4 - 5 ½”
# 1 - 5 ½”
WIRE NUT
# 3 - 5 ½”
Element
Hi Limit
# 2 - 5 ½”
Adjustable
Thermostat
4
Cord
R
RCW-7 & RCW-11
Toll Free:
Website:
Round Cooker Warmers
729 Third Avenue
Dallas, TX 75226
Phone:
Fax:
E-mail:
(214) 421-7366
(214) 565-0976
(800) 527-2100
www.apwwyott.com
[email protected]
REPLACEMENT PARTS CATALOG & WIRING DIAGRAM
Model Capacity Voltage/Hz Wattage
RCW-7
RCW-11
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
7 Quart
11 Quart
P/N
85871
85854
85874
85857
85884
85887
85885
85889
85879
85886
85858
85888
85876
85859
85878
85861
69131
85877
85862
PS0009
69139
87068
87146
85869
85852
85873
85856
89101
55947
85645
89487
85864
89425
60104
88961
89100
89054
89061
88909
76193
76194
120V, 60
120V, 60
1000W
1200W
Model Capacity Voltage/Hz Wattage
P/N
RCW71
RCW111
RCW-7
RCW-11
Description
7 Qt Well Pan
11 Qt Well Pan
7 Qt Heat Transfer Plate
11 Qt Heat Transfer Plate
RW-7 Qt, 120V, 600W Heating Element
RW-7 Qt, 240V, 600W Heating Element
RW-11 Qt 120V, 900W Heating Element
RW-11 Qt, 240V, 900W Heating Element
RCW-7 Qt 120V, 1000W Heating Element
RCW-7 Qt, 240V, 1000W Heating Element
RCW-11 Qt 120V, 1200W Heating Element
RCW-11 Qt, 240V, 1200W Heating Element
7 Qt Element Clamp
11 Qt Element Clamp
7 Qt Element Cover
11 Qt Element Cover
Fixed Limit Control
7 Qt Bottom Bracket
11 Qt Bottom Bracket
Adj. T'stat & Knob Kit Replacement For P/N 69133
Adj. Thermostat W/Knob Mounting Spring Clip
Thermostat Knob W/Set Screw
T'stat Knob Without Set Screw Use With 69138 T'stat
7 Qt Wrapper
11 Qt Wrapper
7 Qt Base Assembly
11 Qt Base Assembly
Cord Strain Relief
120V Cordset
230V US Cordset
Wire Nuts 33 Hi Temp
7 Quart
11 Quart
230V, 50/60
230V, 50/60
1000W
1200W
P/N
RCW73
RCW113
1
2
3
4
5
6
7
14
8
9
10
Parts Not Shown
Wiring Set
Sleeving For Cordset Leads
11 Qt Insulation
#10-24 Hex Nut, Green-ground
#6-32 X 3/8 Phil Screw
#6-32 Keps Nut For Thermostat
#10-24 Hex Nut
#8-18 X 1/2 Slotted Truss Sms
Insulation 7 Qt
Insulation 11 Qt
13
12
11
Note: When ordering, ALWAYS specify Part #, Model #, Serial #, Voltage & Phase.
5
Notes:
6
APW WYOTT EQUIPMENT LIMITED WARRANTY
APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the
following conditions:
This warranty applies to the original owner only and is not assignable.
Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of
APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency. APW Wyott will only be
responsible for charges incurred or service performed by its Authorized Service Agencies. The use of other than APW Wyott
Authorized Service Agencies will void this warranty and APW Wyott will not be responsible for such work or any charges associated
with same. The closest APW Wyott Authorized Service Agent must be used.
This warranty covers products shipped into the 48 contiguous United States, Hawaii, metropolitan areas of Alaska and Canada. There
will be no labor coverage for equipment located on any island not connected by roadway to the mainland.
Warranty coverage on products used outside the 48 contiguous United States, Hawaii, and metropolitan areas of Alaska and Canada
may vary. Contact the international APW Wyott distributor, dealer, or service agency for details.
Time Period
One year for parts and one year for labor, effective from the date of purchase by the original owner. The Authorized Service Agency
may, at their option, require proof of purchase. Parts replaced under this warranty are warranted for the un-expired portion of the
original product warranty only.
Exceptions
*Gas/Electric Cookline: Models GCB, GCRB, GF, GGM, GGT, CHP-H, EF, EG, EHP. Three (3) Year Warranty on all
component parts, except switches and thermostats. (2 additional years on parts only. No labor on second or third year.)
*Broiler Briquettes, Rock Grates, Cooking Grates, Burner Shields, Fireboxes: 90 Day Material Only. No Labor.
*Heat Strips: Models FD, FDL, FDD, FDDL. Two (2) Year Warranty on element only. No labor second year.
*Glass Windows, Doors, Seals, Rubber Seals, Light Bulbs: 90 Day Material Only. No Labor.
In all cases, parts covered by extended warranty will be shipped FOB the factory after the first year.
Portable Carry In Products
Equipment weighing over 70 pounds or permanently installed will be serviced on-site as per the terms of this warranty. Equipment
weighing 70 pounds or under, and which is not permanently installed, i.e. with cord and plug, is considered portable and is subject to
the following warranty handling limitations. If portable equipment fails to operate in its intended manner on the first day of
connection, or use, at APW Wyott's option or its Authorized Service Agency, it will be serviced on site or replaced.
From day two through the conclusion of this warranty period, portable units must be taken to or sent prepaid to the APW Wyott
Authorized Service Agency for in-warranty repairs. No mileage or travel charges are allowed on portable units after the first day of use.
If the customer wants on-site service, they may receive same by paying the travel and mileage charges. Exceptions to this rule: (1)
countertop warmers and cookers, which are covered under the Enhanced Warranty Program, and (2) toasters or rollergrills which have
in store service.
Exclusions
The following conditions are not covered by warranty:
*Equipment failure relating to improper installation, improper utility connection or supply and problems due to
ventilation.
*Equipment that has not been properly maintained, calibration of controls, adjustments, damage from improper cleaning
and water damage to controls.
*Equipment that has not been used in an appropriate manner, or has been subject to misuse or misapplication, neglect,
abuse, accident, alteration, negligence, damage during transit, delivery or installation, fire, flood, riot or act of god.
*Equipment that has the model number or serial number removed or altered.
If the equipment has been changed, altered, modified or repaired by other than an Authorized Service Agency during or after the
warranty period, then the manufacturer shall not be liable for any damages to any person or to any property, which may result from the
use of the equipment thereafter.
This warranty does not cover services performed at overtime or premium labor rates. Should service be required at times which
normally involve overtime or premium labor rates, the owner shall be charged for the difference between normal service rates and such
premium rates. APW Wyott does not assume any liability for extended delays in replacing or repairing any items beyond its control.
In all cases, the use of other than APW Wyott Authorized OEM Replacement Parts will void this warranty.
This equipment is intended for commercial use only. Warranty is void if equipment is installed in other than commercial application.
Water Quality Requirements
Water supply intended for a unit that has in excess of 3.0 grains of hardness per gallon (GPG) must be treated or softened before
being used. Water containing over 3.0 GPG will decrease the efficiency and reduce the operation life of the unit.
Note: Product failure caused by liming or sediment buildup is not covered under warranty.
“THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL OTHER WARRANTIES EXPRESSED OR IMPLIED
INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSES
AND CONSTITUTES THE ENTIRE LIABILITY OF APW WYOTT. IN NO EVENT DOES THE LIMITED WARRANTY
EXTEND BEYOND THE TERMS STATED HEREIN.”
9/05
7
R
Phone:
Fax:
Toll Free:
Website:
E-mail:
+1 (214) 421-7366
+1 (214) 565-0976
+1 (800) 527-2100
www.apwwyott.com
[email protected]
APW WYOTT
729 Third Avenue
Dallas, TX 75226
8