Powered by NEF45 SM2 4.5 Liter Turbocharged
Powered by
NEF45 SM2
4.5 Liter
Turbocharged
Electrical Output 62kW/78kVa
oltage
V
Amperes
Cycles
Phase
kW
kVa
pf
120/240
225*
60
1
56
56
1.0
120/208
217
60
3
62
78
0.8
120/240
187
60
3
62
78
0.8
277/480
94
60
3
62
78
0.8
* Available amperage at terminal block connection - additional amperage available at receptacle panel for single phase output.
STANDARD FEATURES
• FPT 4.5 Liter 1800 RPM Engine (Division of FIAT Motors)
- Meets EPA / CARB Tier 3 Emissions
- Mechanical Governor
- Fuel/Water Separator
- Oil Drain Extension with Valve
• BASLER DGC-2020 Digital Controller with Automatic Safety
Shutdowns and Digital Readouts for Low Oil Pressure, High Water
Temp, Engine Overcrank and Engine Overspeed, Low Fuel Level
Shutdown, Battery Disconnect Switch
• Brushless Alternator / Class H Insulation
–Standby Output: 62kW (80kVA)
–Prime Output: 58.5kW (72kVA)
–Motor Starting Capability: 25 h.p. Code G
–Voltage Regulation: 1.5% / < 5% Total Harmonic Distortion
• SWITCHABLE 4-Position Voltage Selector Switch with
Automatic Safety Shutdown and Safety Lock Out
− AC Voltages - 3 Phase: 208, 220, 240, 416, 440, 460, 480V
− AC Voltages - 1 Phase: 120, 139, 208, 220, 240V
Amps:
- Single Phase 240V: 225A (at terminal block)
- Three Phase 208V: 217A
- Three Phase 240V: 187A
- Three Phase 480V: 94A
• Illuminated Instrumentation Panel and Connection Box
• Receptacle Package:
- 2-50amp 120/240V Twistlock Receptacles
- 2-20amp 120V GFCI Duplex Receptacles
- 1-Terminal Block for Full Connection with Safety Shut Off
• Shore Power Inlet for Easy Connection to Block Heater
and Battery Charger
• Pre-wired for Remote Emergency Stop (Optional Button Available)
• Two Wire Remote Start Capability
• Selectable High or Low Voltage Mainline Circuit Breakers
for Main Power Connection
• Circuit Breakers for Single Phase Receptacles
• 14-gauge Galvanneal Steel Sound Attenuated Enclosure
with Critical Muffler
• Sound Level: 70 dB(A) @ 7 Meters, Full Load
• Durable Powder Coat Paint Finish / Stainless Steel Fasteners
• Large Lockable Doors for Maintenance Access
• Single Point Lifting Eye
• Full Fluid Containment System with Drains
• Lockable Fuel Access Door
• Six Bolts to Remove Generator Assembly from Trailer
• DOT Approved Trailer & Tank, 7,000 lb. Capacity,
Electric Brakes with Break-Away Kit, Single Axle,
Torsion Bar Suspension, Front Leveling Jack, Rear
Stabilization Jacks, Running Lights, Lighted License Plate Bracket
• 110-gallon, 7-gauge Steel Fuel Tank
• Fuel Consumption: • Run Time:
Full Load..........4.64 gal/hr
Full Load.......24 hours
75% Load.........3.48 gal/hr
75% Load......32 hours
50% Load.........2.41 gal/hr
50% Load......46 hours
• Removable and Adjustable Hitch
• 3” Pintle Hitch and 2 5/16” Ball Hitch both come Standard
• Large Front Lockable Storage Compartment
• Dimensions: Generator with Trailer - 150” x 66” x 83”
• Weight: Generator with Dry Fuel Tank and Trailer - 4950 lbs
• Warranty: Complete Unit - 1 Year; Engine - 2 Year Limited
APPLICATION &
ENGINEERING DATA
GENSET CONTROL
EXPERIENCED DESIGN
• BASLER DGC-2020 DIGITAL CONTROLLER
• GENERATOR PROTECTION AND METERING
• EVENT FAULT LOG RECORDING
• DEDICATED RELAYS FOR FUEL SOLENOIDS,
GLOW PLUGS AND STARTER SOLE-
• OVER 85 YEARS EXPERIENCE IN
THE GENERATOR INDUSTRY
• DESIGNED FOR LONG LIFE
TO MAXIMIZE RETURN
ON INVESTMENT
• REACTIVE L0AD BANK
TESTED / SINGLE STEP 100%
LOAD TESTED
• “ORIGINATOR” OF THE MOBILE
NOID
• AUTOMATIC SAFETY SHUTDOWN
• DIGITAL READOUTS FOR LOW OIL PRESSURE,
HIGH WATER TEMP, ENGINE OVERCRANK
AND ENGINE OVERSPEED
• LOW FUEL LEVEL SHUTDOWN AND FUEL LEAK
DETECTION ALARM
DIESEL GENERATOR
ENGINE SPECIFICATIONS
GENERATOR SPECIFICATIONS
• DIVISION OF FIAT MOTORS INC.
• EPA CARB TIER 3 COMPLIANT
• COMPLETE SERVICE NETWORK
• EFFICIENT LOW FUEL CONSUMPTION DESIGN
• BRUSHLESS ROTATING FIELD FOR LONG LIFE
AND LOW MAINTENANCE
• MEETS BS EN 60034, BS5000, VDE 0530
• NEMA MG1-32, ICE34, CSA C22.2-100, AS1359
• INCLUDES: HIGH EFFICIENCY SEMICONDUCTORS,
RECTIFIER SURGE PROTECTION
• STANDARD OUTPUT: 63kW, 78kVA (3-Phase)
• PRIME OUTPUT: 56.7kW, 70.2kVA (3-Phase)
• AMPS: 1-PHASE 240V - 225A at terminal block,
233 amps total, including receptacle panel
3-PHASE 208V - 217A
3-PHASE 240V - 187A
3-PHASE 480V - 94A
RATING..............................................(125/40°C) STANDBY
TYPE....................................4 POLE – REVOLVING FIELD
SPEED/FREQUENCY..................................1800 RPM/60HZ
INSULATION SYSTEM..........................................CLASS H
STATOR WINDINGS......DOUBLE LAYER CONCENTRIC
PITCH.................................................................................2/3
WAVEFORM DISTORTION...........................................1.5%
TELEPHONE INTERFERENCE..................................<2.0%
EFFICIENCY PEAK...................................................~92.5%
COUPLING..................................................FLEXIBLE DISC
BEARINGS (MAINTENANCE FREE).................................1
CONTROL...............(SX460 STANDARD) SELF EXCITED
REGULATION...........................................................+/- 1.5%
SINGLE PHASE RATING...............................................1.0pf
THREE PHASE RATING................................................0.8pf
MAKE..........................................................................................FPT
MODEL..........................................................................NEF45 SM2
TYPE.....................................................................................DIESEL
DIRECT INJECTION...............................................MECHANICAL
SPEED GOVERNOR...............................................MECHANICAL
CYLINDERS....................................................................................4
TOTAL DISPLACEMENT..........................................................4.5L
BORE X STROKE.....................................................mm 104 X 132
ASPIRATION/COOLING....................TURBOCHARGED/LIQUID......................................................................................................
RADIATOR CAPACITY....................................................2.25 GAL
TOTAL COOLING CAPACITY...........................................5.0 GAL
HOUSING................................................................................SAE 3
FLYWHEEL (TEETH 125)....................................................11½ in.
ROTATION...............................................................................CCW
LUBE OIL SPEC.......................................SAE TYPE, API CF-CH4
LUBE OIL CONSUMPTION.................................< 0.1% OF FUEL
OIL & FILTER REPLACEMENT........................................600 HRS
TOTAL OIL CAPACITY.............................................13.5 QUARTS
EXHAUST OUTLET SIZE @ MUFFLER..................................3.0”
ELECTRICAL SYSTEM (NEGATIVE GROUND)..............12 VDC
ALTERNATOR (BOSCH)..................................................90 AMPS
STARTER..............................................................................BOSCH
BATTERY (NOT INCLUDED BCI 24)..............................650 CCA
Tel: (507) 357-6821
Fax: (507) 357-4857
Sales: (800) 733-2112
E-Mail: [email protected]
Web Site: www.wincogen.com
RP80-0614
225 South Cordova Ave
Le Center MN 56057 USA
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement