Delfield | 186114 BUC | Installation manual | Delfield 186114 BUC Installation manual

18000 Series and CTP-NB
Service and Installation Manual
Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all
components immediately. See page 3.
CTP-NB
Countertop Condiment Rail
N
CAUTIO
18000-BUC
Work Tables
18000-PTB
Pizza Tables with Raised Rail
ION
T
A
M
R
INFO
T
N
A
T
R
USE
IMPO
E
R
O
F
E
NS!
O
I
T
C
READ B
U
NSTR
I
E
S
E
H
VE T
A
S
E
S
A
PLE
Effective May 2003
18000 and CTP-NB Series Service and Installation Manual
CONTENTS
SERIAL NUMBER INFORMATION
SPECIFICATIONS................................................................................... 2
RECEIVING & INSPECTING EQUIPMENT ............................................ 3
INSTALLATION ..................................................................................... 3
OPERATION
18000 PTB Series .............................................................................. 4
18000 BUC Series ............................................................................. 4
CTP-NB Series ................................................................................... 4
REFG. CHARGES & PRESSURE CONTROL SETTINGS ....................... 5
WIRING DIAGRAM
18000 PTB Series .............................................................................. 6
18000 BUC Series ............................................................................. 6
CTP-NB Series ................................................................................... 6
REFRIGERATION SYSTEM
18000 PTB Series .............................................................................. 7
18000 BUC Series ............................................................................. 7
CTP-NB Series ................................................................................... 8
PARTS REPLACEMENT LIST ................................................................ 8
STANDARD WARRANTIES ............................................................10-11
AUTHORIZED PARTS DEPOTS ..............................................back cover
The serial number on 18000 PTB & 18000 BUC Series units
is located on the electrical specifications tag affixed inside the
compressor section next to the pressure control.
The serial number on CTP-NB Series units is located on the front of
the unit.
Always have the serial number of your unit available when calling for
parts or service. A complete list of authorized Delfield parts depots is
shown on the back cover of this manual.
Warranty may be deemed invalid if other than
authorized OEM (original equipment manufacture)
replacement parts are used in Delfield equipment.
©2003 The Delfield Company. All rights reserved. Reproduction
without written permission is prohibited.
“Delfield” is a registered trademark of The Delfield Company.
SPECIFICATIONS
MODEL
NUMBER
# OF
DOORS
# OF
SHELVES
SHELF
AREA
18000 PTB series pizza tables with raised rail
18648 PTB
(1) 27"
1
3.36 ft2
18660 PTB
19" & 27"
2
5.63 ft2
18672 PTB
(2) 27"
2
7.72 ft2
18691 PTB (2) 27" & (1) 19" 3
9.99 ft2
18699 PTB
(3) 27"
3
11.58 ft2
186114 PTB
(4) 24"
4
13.22 ft2
MODEL
NUMBER
NUMBER OF
DOORS
18000 BUC series work tables
18648 BUC
(1) 27"
18660 BUC
19" & 27"
18672 BUC
(2) 27"
18691 BUC
(2) 27" & (1) 19"
18699 BUC
(3) 27"
186114 BUC
(4) 24"
MODEL
NUMBER
1/6 PAN SIZE
CAPACITY
STORAGE
CAPACITY
BTU LOAD
BASE/RAIL
BTU SYSTEM
CAP. BASE/RAIL
H.P.
AMPS
NEMA
PLUG
SHIP WEIGHT
LBS/KG
8.39 ft3
14.31 ft3
16.77 ft3
22.82 ft3
25.87 ft3
30.9 ft3
470/441
694/617
776/794
1062/1058
1144/1147
1297/1323
1903/971
2314/1121
3097/1544
3807/1839
5286/2191
5286/2411
1/4
1/3
1/2
1/2
3/4
3/4
10.0
12.0
14.0
14.0
16.0
16.0
5-15P
5-15P
5-20P
5-20P
5-20P
5-20P
520/236
575/260
635/288
770/350
805/365
927/420
# OF
SHELVES
SHELF
AREA
STORAGE
CAPACITY
BTU
LOAD
BTU
SYS. CAP.
H.P.
AMPS
NEMA
PLUG
SHIP WEIGHT
LBS/KG
1
2
2
3
3
4
3.95 ft2
6.51 ft2
7.90 ft2
10.29 ft2
11.85 ft2
14.42 ft2
9.77 ft3
14.31 ft3
17.79 ft3
23.05 ft3
25.82 ft3
27.58 ft3
475
686
856
1169
1220
1373
1462
1462
2261
2261
2591
2591
1/5
1/5
1/4
1/4
1/3
1/3
8.0
8.0
10.0
10.0
12.0
12.0
5-15P
5-15P
5-15P
5-15P
5-15P
5-15P
390/177
435/197
495/225
535/243
594/269
685/310
# OF
ADAPTER BARS
BTU
LOAD
BTU
SYS. CAP.
H.P.
AMPS
NEMA
PLUG
SHIP WEIGHT
LBS/KG
5
7
9
305
462
609
523
653
742
1/5
1/5
1/5
4.0
4.0
4.0
5-15P
5-15P
5-15P
121/54.9
158/71.7
197/89.4
CTP-NB Counter top condiment rail
CTP8146-NB
CTP8160-NB
CTP8175-NB
8
12
16
Volts/Hertz/Phase for all CTP-NB, 18000 PTB & 18000 BUC Series units is 115/60/1
2
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
18000 and CTP-NB Series Service and Installation Manual
RECEIVING AND INSPECTING THE EQUIPMENT
Even though most equipment is shipped crated, care should
be taken during unloading so the equipment is not damaged
while being moved into the building.
1.
2.
3.
4.
Visually inspect the exterior of the package and skid or
container. Any damage should be noted and reported
to the delivering carrier immediately.
If damaged, open and inspect the contents with the
carrier.
In the event that the exterior is not damaged, yet upon
opening, there is concealed damage to the equipment
notify the carrier. Notification should be made verbally
as well as in written form.
Request an inspection by the shipping company of the
damaged equipment. This should be done within 10
days from receipt of the equipment.
5.
6.
7.
8.
Check the lower portion of the unit to be sure legs or
casters are not bent.
Also open the compressor compartment housing and
visually inspect the refrigeration package. Be sure lines
are secure and base is still intact.
Freight carriers can supply the necessary damage forms
upon request.
Retain all crating material until an inspection has been
made or waived.
Uncrating the Equipment
First cut and remove the banding from around the crate.
Remove the front of the crate material, use of some tools will
be required. If the unit is on legs remove the top of the crate
and lift the unit off the skid. If the unit is on casters it can be
"rolled" off the skid.
INSTALLATION
Location
Be sure the location chosen has a floor strong enough to support
the total weight of the cabinet and contents. A fully loaded 72” long
model may weigh as much as 2000 pounds. Reinforce the floor as
necessary to provide for maximum loading.
For the most efficient refrigeration, be sure to provide good air
circulation inside and out.
Inside cabinet: Do not pack refrigerator so full that air cannot
circulate.
Outside cabinet: Be sure that the unit has access to ample air.
Avoid hot corners and locations near stoves and ovens.
It is recommended that the unit be installed no closer than 1 inch
from any wall.
Leveling
A level cabinet looks better and will perform better because the
drain pan will drain properly, the doors will line up with the frames
properly, and the cabinet will not be subject to undue strain.
Some models have casters for your convenience, for ease of
cleaning underneath and for mobility. It is important that the unit
be installed in a stable condition with the front casters locked
before operating.
Plumbing
Self-contained models are standard with a condensate evaporator.
If, for some reason, a unit does not have a condensate evaporator,
or the evaporator fails, the unit’s drain must have an outlet to an
appropriate drainage area or container.
CAUTION
Moisture collecting from improper drainage can
create a slippery surface on the floor and a hazard
to employees. It is the owner’s and operator’s
responsibility to provide a container or outlet for
drainage.
Electrical connection
Refer to the amperage data on page 2, the serial tag, your local
code or the National Electrical Code to be sure the unit is connected
to the proper power source. A protected circuit of the correct
voltage and amperage must be run for connection of the line cord,
or permanent connection to the unit.
Self-contained units with cord and plug have an ON/OFF switch
located directly behind the louvered machine compartment door.
Simply turn the switch to ON to begin operation.
The power switch must be turned to OFF and the
unit disconnected from the power source whenever
performing service or maintenance functions.
Never operate the unit without the louvered panel in
place!
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
3
18000 and CTP-NB Series Service and Installation Manual
OPERATION: 18000 PTB SERIES
Product should be loaded into the unit with care.
Failure to heed these recommendations could result
in damage to the interior of the cabinet or the blower
coil.
This unit is equipped with two on/off switches located behind the
louvered machine compartment door. The unit’s compressor and
all evaporator fans will begin operating when this switch is turned
to the “on” position. Temperature ranges for the base are 36° to
40° F.
The switch labeled rail is for the raised rail. Turning this switch
to the “on” position will activate the refrigeration for the rail.
Temperature ranges for the raised rail are 33°F to 41°F.
Product located in the rail must be removed to the
refrigerated base at the end of day. This allows you
to turn the rail off at night to save energy and the rail
will have time to defrost as needed. It also helps to
maintain product quality.
A minimum of one hour of off time per day with the pans
removed from the rail is required to properly defrost the rail. If pans
are left in the rail, it may take up to four hours to defrost under
the pans. Product left in the rail during a four hour off period will
experience a significant rise in temperature and may not be suitable
for use.
Be sure to turn the rail switch to the “on” position in the morning
when you return the pans to the raised rail.
The power must be turned to OFF and the unit
disconnected from the power source whenever
performing service or maintenance functions.
Never operate the unit without the louvered panel in
place!
All R404A models have a high pressure limiting device. Under
severe overloading conditions, or in the event of a condenser fan
failure or a plugged or blocked condenser, this device may shut
down the refrigeration system. This device will automatically reset,
but determining the cause of the high pressure condition should be
investigated by a qualified refrigeration technician.
OPERATION: 18000 BUC SERIES
After turning the ON/OFF switch to ON, the units compressor
will begin operating. Delfield refrigerated bases are designed to
maintain an operational temperature of 36°F to 40°F.
Product should be loaded into the unit with care.
Failure to heed these recommendations could result
in damage to the interior of the cabinet or the blower
coil.
Overloading the storage area, restricting the air flow
and continuous opening and closing of the doors and
drawers will hamper the units ability to maintain
operational temperature.
OPERATION: CTP-NB SERIES
The unit is equipped with one on/off switch located on the right
end of the unit. The unit’s compressor will begin operating when
this switch is turned to the “on” position. Temperature ranges for
the rail are 33° to 41° F.
Product located in the rail must be removed at the end of day.
This allows you to turn the rail off at night to save energy and the
rail will have time to defrost as needed. It also helps to maintain
product quality.
4
A minimum of one hour of off time per day with the pans removed
from the rail is required to properly defrost the rail. If pans are left
in the rail, it may take up to four hours to defrost under the pans.
Product left in the rail during a four hour off period will experience a
significant rise in temperature and may not be suitable for use.
Be sure to turn the rail switch to the “on” position in the morning
when you return the pans to the raised rail.
The power switch must be turned to OFF and the
unit disconnected from the power source whenever
performing service or maintenance functions.
Never operate the unit without the louvered panel in
place!
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
18000 and CTP-NB Series Service and Installation Manual
REFRIGERANT CHARGES AND PRESSURE CONTROL SETTINGS
Refrigerant Charges For 18000 Series Units:
18648-PTB . . . . . . . . . . . . . . . . . . . . . . .16 oz.
18660-PTB . . . . . . . . . . . . . . . . . . . . . . .24 oz.
18672-PTB . . . . . . . . . . . . . . . . . . . . . . .32 oz.
18691-PTB . . . . . . . . . . . . . . . . . . . . . . .32 oz.
18699-PTB . . . . . . . . . . . . . . . . . . . . . . .48 oz.
186114-PTB . . . . . . . . . . . . . . . . . . . . . .48 oz.
18648-BUC . . . . . . . . . . . . . . . . . . . . . . .16 oz.
18660-BUC . . . . . . . . . . . . . . . . . . . . . . .16 oz.
18672-BUC . . . . . . . . . . . . . . . . . . . . . . .16 oz.
18691-BUC . . . . . . . . . . . . . . . . . . . . . . .16 oz.
18699-BUC . . . . . . . . . . . . . . . . . . . . . . .24 oz.
186114-BUC . . . . . . . . . . . . . . . . . . . . . .24 oz.
Refrigerant Charges For CTP-NB Series Units:
CTP8146-NB . . . . . . . . . . . . . . . . . . . . . . .8 oz.
CTP8160-NB . . . . . . . . . . . . . . . . . . . . . . .8 oz.
CTP8175-NB . . . . . . . . . . . . . . . . . . . . . . .8 oz.
PRESSURE CONTROL SETTINGS
Pressure Control Settings
The factory recommended low-pressure control settings for 18000-PTB’s are: 55# cut-in and 30# cut-out to maintain
proper temperature for product in the rail. The interior temperature is controlled by the thermostat mounted on the
evaporator coil housing.
The factory recommended low-pressure control settings for 18000-BUC’s are: 82# cut-in and 57# cut-out to maintain
proper temperature.
All Delfield refrigerated models come equipped with
115-volt, 60 cycle, single phase refrigeration units. The
refrigeration valves are open and ready to operate as soon
as the power supply cord is plugged into the standard 115volt, grounded electrical outlet.
Pressure Control
The temperature is controlled by an adjustable pressure
control located in the machine compartment. An adjustable
control has the word COLDER near the knob, with an arrow
to indicate the adjustment direction. These controls are
field adjustable and do not require a service agent. If you
have any questions, feel free to contact the Delfield Service
Department.
In attempting to adjust the pressure control,
you can do damage to your unit by accidentally
adjusting the differential. Please make small
incremental adjustments if a temperature
adjustment is necessary, please contact the
service department at Delfield (800) 733-8821
or your local service agent. Delfield is not
responsible for charges incurred while having
the pressure control adjusted.
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
5
18000 and CTP-NB Series Service and Installation Manual
WIRING DIAGRAM - 18000 PTB SERIES
L1
ON 115 VOLT MODELS ONLY
L2 IS THE NEUTRAL
L2
G
ON/OFF SWITCH
CONDENSING UNIT
PRESSURE CONTROL
POWER CORD
PROVIDED ON
SELF-CONTAINED
MODELS
BASE
EVAPORATOR FAN(S)
T'STAT
RAIL
SWITCH
SOLENOID VALVE(S)
SOLENOID VALVE
RECEPTACLE FOR OPTIONAL
FAN PACKAGE
6
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
18000 and CTP-NB Series Service and Installation Manual
WIRING DIAGRAM - 18000 BUC SERIES
L1
N
G
POWER SWITCH
CONDENSING UNIT
POWER CORD
STANDARD ON
ALL MODELS
BASE COIL 1
BASE COIL 2
(where used)
PRESSURE SWITCH CONTROLS ONLY THE CONDENSING UNIT
WIRING DIAGRAM - CTP-NB SERIES
N
L1
POWER SWITCH
G
POWER CORD
IS STANDARD ON
CTP SERIES
CONDENSING UNIT
TEMPERATURE CONTROLS THE CONDENSING UNIT
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
7
18000 and CTP-NB Series Service and Installation Manual
REFRIGERATION SYSTEM- 18000 PTB SERIES
WRAPPED RAIL
EVAPORATOR
COIL
THERMOSTAT
EVAPORATOR
COIL
SOLENOID
VALVE
AT
OST
RM
EXPANSION VALVE
THE
SOLENOID
VALVE
EXPANSION VALVE
LOW PRESSURE CONTROL
FILTER DRYER
HI-PRESSURE SAFETY SWITCH
CONDENSING UNIT
REFRIGERATION SYSTEM- 18000 BUC SERIES
EVAPORATOR
COIL
EVAPORATOR
COIL
EXPANSION VALVE
EXPANSION VALVE
LOW PRESSURE CONTROL
FILTER DRYER
HI-PRESSURE SAFETY SWITCH
CONDENSING UNIT
8
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
EXPANSION
VALVE
18000 and CTP-NB Series Service and Installation Manual
REFRIGERATION SYSTEM- CTP-NB SERIES
WRAPPED RAIL
THERMOSTAT
TUBE FOR
THERMOSTAT BULB
CONDENSING
UNIT
ON/OFF SWITCH
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
9
18000 and CTP-NB Series Service and Installation Manual
PARTS REPLACEMENT LIST
PART #
3526747
3526745
3526746
3526731
3526732
3516101
3234072
3234073
3234391
9321107
0392310000
(PMK00036)
2162691
3516172
3516173
3516095
3516273
3516273
3516102
3516103
2193927
2194536
3234161
3234546
3977984
3978014
3977983
1701183
1701185
1701186
9321374
9321041
3234266
3234282
3234392
2190154
10
DESCRIPTION
Condensing unit 1/5 HP
Condensing unit 1/4 HP 115v. 404A
Condensing unit 1/3 HP 115v. 404A
Condensing unit 1/2 HP 115v. 404A
Condensing unit 3/4 HP 115v 404A
Filter dryer
Hinge bracket
Hinge Bracket
L-Shape hinge bracket
Bushing
ADDITIONAL PARTS FOR THE CTP SERIES ONLY
PART #
DESCRIPTION
352-6694
Compressor
351-6082
Cond. coil
351-6047
Temp. control
218-3304
Power cord
Cap. tube specs - 0.036 “ID x 72” long
Evaporator drain pan
Evaporator fan motor
Evaporator fan blade
Evaporator fan guard
Evaporator coil
Expansion valve (base) 1/4 ton, HI 404A
Expansion valve (rail) 1/4 ton, 404A
Solenoid valve 1/2 ODF
Solenoid coil 120v
Pressure control, low
Temp control (base)
Caster
Leg 6”
Wire shelf 19” door
Wire shelf 27” door
Wire shelf 32” door
Door gasket 19”
Door gasket 27”
Door gasket 32”
Salad pan cover pin hinge
Chrome acorn nut #10-24
Lid bracket right hand
Lid bracket left hand
Lid bracket center
On/Off switch and rail switch
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
18000 and CTP-NB Series Service and Installation Manual
STANDARD LABOR GUIDELINES TO REPAIR OR REPLACE PARTS ON DELFIELD EQUIPMENT
Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage.
• A maximum of 1-hour is allowed to diagnose a defective component.
• A maximum of 1-hour is allowed for retrieval of parts not in stock.
• A maximum travel distance of 100 miles round trip and 2-hours will be reimbursed.
• Overtime, installation/start-up, normal control adjustments, general maintenance, glass breakage, freight damage, and/or
correcting and end-user installation error will not be reimbursed under warranty unless pre-approved with a Service Work
Authorization from Delfield. You must submit the number with the service claim.
LABOR OF 1-HOUR IS ALLOWED TO REPLACE:
• Thermostat
• Infinite Switch
• Door Jamb Switch
• Solenoid Coil
• Hi-limit/Thermal Protector Switch
• Fan Delay/Defrost Termination Switch
• Compressor Start Components and Overload Protector
• Defrost Timer
• Thermometer
• Gear Box
•
•
•
•
•
•
•
•
•
Contactor/Relay
Transformer
Evaporator/Condenser Fan Motor and Blade
Circulating Fan Motor and Blade
Microprocessor Control
Water Level Sensor/Probe
Door Hinges, Locks, and Gaskets
Condensate Element
Springs/Lowerator
LABOR OF 2 HOURS TO REPLACE:
• Drawer Tracks/Cartridges
• Defrost Element
• Pressure Control
• Heating Element
• Solenoid Valve
• Locate/Repair Leak
LABOR OF 3 HOURS TO REPLACE:
• EPR or CPR Valve
• Condenser or Evaporator Coil
• Expansion Valve
LABOR OF 4 HOURS TO REPLACE
• Compressor
This includes recovery of refrigerant and leak check.
$35.00 maximum reimbursement for refrigerant recovery (includes recovery machine, pump, torch, oil, flux, minor fittings,
solder, brazing rod, nitrogen, or similar fees.)
REFRIGERANTS
• R22 A maximum of $4.00/lb. or 25¢/oz. will be reimbursed.
• R134A A maximum of $5.00/lb. or 31¢/oz. will be reimbursed.
• R404A A maximum of $12.00/lb. or 75¢/oz. will be reimbursed.
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
11
18000 and CTP-NB Series Service and Installation Manual
STANDARD ONE YEAR WARRANTY (One year parts, 90 days labor.)
The Delfield Company (“Delfield”) warrants to the Original Purchaser
of the Delfield product (herein called the “Unit”) that such Unit, and all
parts thereof, will be free from defects in material and workmanship
under normal use and service for a period of one (1) year from
the date of shipment of the Unit to the Original Purchaser or, if the
Original Purchaser returns the warranty card completely filled out
including the date of installation within thirty (30) days of receipt
of the Unit, one (1) year from the date of installation. During this
one year warranty period, Delfield will repair or replace any defective
part or portion there of returned to Delfield by the Original Purchaser
which Delfield determines was defective due to faulty material or
workmanship. The Original purchaser will pay all labor, crating, freight
and related costs incurred in the removal of the Unit of defective
component and shipment to Delfield, except that during a period of
either ninety (90) days from the date of shipment of the Unit to the
Original Purchaser or, if the Original Purchaser returns the warranty
card completely filled out including the date of installation within thirty
(30) days of receipt of the Unit, ninety (90) days from the date of
installation Delfield will pay all related labor costs. Delfield will pay the
return costs if the Unit or part thereof was defective.
The term “Original Purchaser” as used herein means that person, firm,
association, or corporation for whom the Unit was originally installed.
This warranty does not apply to any Unit or part thereof that has
been subjected to misuse, neglect, alteration, or accident, such as
accidental damage to the exterior finish, operated contrary to the
recommendations specified by Delfield; or repaired or altered by anyone
other than Delfield in any way so as to, in Delfield’s sole judgement,
affect its quality or efficiency. This warranty does not apply to any Unit
that has been moved from the location where it was originally installed.
This warranty also does not cover the refrigerator drier or the light
bulbs used in the Unit. The warranty is subject to the user’s normal
maintenance and care responsibility as set forth in the Service and
Installation Manual, such as cleaning the condenser coil, and is in
lieu of all other obligations of Delfield. Delfield neither assumes, nor
authorizes any other person to assume for Delfield, any other liability
in connection with Delfield’s products.
Removal or defacement of the original Serial Number or Model Number
from any Unit shall be deemed to release Delfield from all obligations
hereunder or any other obligations, express or implied.
Parts furnished by suppliers to Delfield are guaranteed by Delfield only
to the extent of the original manufacturer’s express warranty to Delfield.
Failure of the Original Purchaser to receive such manufacturer’s express
warranty to Delfield. Failure of the Original Purchaser to receive such
manufacturers warranty shall in no way create any warranty, expressed
or implied, or any other obligation or liability on Delfield’s part in respect
thereof.
IF THE CUSTOMER IS USING A PART THAT RESULTS IN A VOIDED
WARRANTY AND A DELFIELD AUTHORIZED REPRESENTATIVE
TRAVELS TO THE INSTALLATION ADDRESS TO PERFORM WARRANTY
SERVICE, THE SERVICE REPRESENTATIVE WILL ADVISE CUSTOMER
THE WARRANTY IS VOID. SUCH SERVICE CALLS WILL BE BILLED
TO CUSTOMER AT THE AUTHORIZED SERVICE CENTER’S THEN
APPLICABLE TIME AND MATERIALS RATES. CONSIDER: CUSTOMER
MAY INITIATE A SERVICE AGREEMENT WITHOUT PARTS COVERAGE.
If shipment of a replacement part is requested prior to the arrival in
the Delfield factory of the part claimed to be defective, the Original
Purchaser must accept delivery of the replacement part of a C.O.D.
basis, with credit being issued after the part has been received and
12
inspected at Delfield’s plant and determined by Delfield to be within
this warranty.
Under no condition does this warranty give the Original Purchaser the
right to replace the defective Unit with a complete Unit of the same
manufacturer or of another make. Unless authorized by Delfield in
writing, this warranty does not permit the replacement of any part,
including the motor-compressor, to be made with the part of another
make or manufacturer.
No claims can be made under this warranty for spoilage of any
products for any reason, including system failure.
The installation contractor shall be responsible for building access,
entrance and field conditions to insure sufficient clearance to allow
any hood(s), vent(s), or Unit(s) if necessary, to be brought into the
building. Delfield will not be responsible for structural changes
or damages incurred during installation of the Unit or any exhaust
system.
Delfield shall not be liable in any manner for any default or delay in
performance hereunder caused by or resulting from any contingency
beyond Delfield’s control, including, but not limited to, war,
governmental restrictions or restraints, strike, lockouts, injunctions,
fire, flood, acts of nature, short or reduced supply of raw materials, or
discontinuance of the parts by the original part manufacturer.
Except as provided in any Additional Four Year Protection Plan,
if applicable, and the Service Labor Contract, if applicable, the
foregoing is exclusive and in lieu of all other warranties, whether
written or oral, express or implied. This warranty supersedes
and excludes any prior oral or written representations or
warranties. Delfield expressly disclaims any implied warranties
of merchantability, fitness for a particular purpose of compliance
with any law, treaty, rule or regulation relating to the discharge of
substances into the environment. The sole and exclusive remedies
of any person relating to the Unit, and the full liability of Delfield
for any breach of this warranty, will be as provided in this warranty.
Other than this Delfield Standard One Year Limited Warranty, any
applicable Delfield Additional Four Year Protection Plan or applicable
Delfield Service Labor Contract, the Original Purchaser agrees and
acknowledges that no other warranties are offered or provided in
connection with or for the unit or any other part thereof.
In no event will Delfield be liable for special, incidental or
consequential damages, or for damages in the nature of penalties.
IF DURING THE WARRANTY PERIOD, CUSTOMER USES A PART
FOR THIS DELFIELD EQUIPMENT OTHER THAN AN UNMODIFIED
NEW OR RECYCLED PART PURCHASED DIRECTLY FROM DELFIELD
OR ANY OF ITS AUTHORIZED SERVICE CENTERS AND/OR THE PART
BEING USED IS MODIFIED FROM ITS ORIGINAL CONFIGURATION,
THIS WARRANTY WILL BE VOID. FURTHER, DELFIELD AND ITS
AFFILIATES WILL NOT BE LIABLE FOR ANY CLAIMS DAMAGES
OR EXPENSES INCURRED BY THE CUSTOMER WHICH ARISE
DIRECTLY OR INDIRECTLY, IN WHOLE OR IN PART, DUE TO THE
INSTALLATION OF ANY MODIFIED PART AND/OR PART RECEIVED
FROM AN UNAUTHORIZED SERVICE CENTER. If the warranty
becomes void, Customer may purchase from Delfield, if available,
a Service Agreement or service at the then current time and
materials rate.
For more information on Delfield warranty’s log on and check out the
service section of our web site at www.delfield.com.
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
18000 and CTP-NB Series Service and Installation Manual
ADDITIONAL FOUR YEAR PROTECTION PLAN
Delfield Model#
Serial #
Installation
Date
In addition to the Standard One Year Warranty on the MotorCompressor contained in the above listed Delfield product (the
“Unit”), The Delfield Company (“Delfield”) also agrees to repair, or
exchange with similar or interchangeable parts in design and capacity
at Delfield’s option, the defective Motor-Compressor contained in the
Unit (the “Motor-Compressor), or any part thereof, for the Original
Purchaser only, at any time during the four (4) years following the
initial one (1) year period commencing on the date of installation for
the Original Purchaser. Failure of the Original Purchaser to register
the registration card containing the Original Purchasers name,
address, date of installation, model number and serial number of
the Unit containing the Motor-Compressor within 30 days from the
date of installation shall void this warranty. This additional warranty
is only available if the Motor-Compressor is inoperative due to defects
in material or factory workmanship, as determined by Delfield in
its sole judgement and discretion. The Original Purchaser shall be
responsible for returning the defective Motor-Compressor to Delfield
prepaid, F.O.B. at the address shown on the back cover of this manual.
The term “Original Purchaser” as used herein means that person, firm,
association, or corporation for whom the Unit was originally installed.
The term “Motor-Compressor” as used herein does not include unit
base, air or water cooled condenser, receiver, electrical accessories
such as relay, capacitors, refrigerant controls, or condenser fan/motor
assembly. This warranty does not cover labor charges incidental to
the replacement of parts. This warranty further does not include
any equipment to which said condensing unit is connected, such as
cooling coils, temperature controls or refrigerant metering devices.
This warranty shall be void if the Motor-Compressor, in Delfield’s
sole judgement, has been subjected to misuse, neglect, alteration
or accident, operated contrary to the recommendations specified
by the Unit manufacturer, repaired or altered by anyone other than
Delfield in any way so as, in Delfield’s sole judgment, to affect its
quality or efficiency or if the serial number has been altered, defaced
or removed. This Warranty does not apply to a Motor-Compressor in
any Unit that has been moved from the location where it was originally
installed. The addition of methyl chloride to the condensing unit or
refrigeration system shall void this warranty.
(for Motor-Compressor only)
General Conditions
Delfield shall not be liable in any manner for any default or delay
in performance hereunder caused by or resulting from any
contingency beyond Delfield’s control, including, but not limited
to, war, governmental restrictions or restraints, strike, lockouts,
injunctions, fire, flood, acts of nature, short or reduced supply
of raw materials, or discontinuance of any part or the MotorCompressor by the unit manufacturer.
Replacement of a defective Motor-Compressor is limited to one (1)
Motor-Compressor by us during the four (4) year period. Delfield
shall replace the Motor-Compressor at no charge.
This warranty does not give the Original Purchaser of the MotorCompressor the right to purchase a complete replacement MotorCompressor of the same make or of another make. It further does
not permit the replacement to be made with a Motor-Compressor
of another kind unless authorized by Delfield. In the event Delfield
authorizes the Original Purchaser to purchase a replacement
Motor-Compressor locally, only the wholesale cost of the MotorCompressor is refundable.
Expressly excluded from this warranty are damages resulting from
spoilage of goods.
Except as provided in any applicable Standard One Year Limited
Warranty or applicable Service Labor Contract, the foregoing
is exclusive and in lieu of all other warranties, whether written
or oral, express or implied. This Warranty supersedes and
excludes any prior oral or written representations or warranties.
Delfield expressly disclaims any implied warranties of
merchantability, fitness for a particular purpose or compliance
with any law, treaty, rule or regulation relating to the MotorCompressor, and the full liability of Delfield for any breach of this
warranty, will be as provided in this warranty.
Other than any applicable Delfield Standard One year Limited
Warranty, this Delfield Additional Four Year Protection Plan and any
applicable Delfield Service Labor Contract, the Original Purchaser
agrees and acknowledges that no other warranties are offered or
provided in connection with or for the Motor-Compressor or any
part thereof.
In no event will Delfield be liable for special, incidental or
consequential damages, or for damages in the nature of penalties.
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
13
18000 and CTP-NB Series Service and Installation Manual
NOTES:
14
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
18000 and CTP-NB Series Service and Installation Manual
NOTES:
For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com
15
Delfield Authorized Parts Depots
NORTH
AMERICA
12
10
1
11
6
4
4
8
5
2
3
14
13
7
9
12
1) The Delfield Company
980 South Isabella Road
Mt. Pleasant, MI 48858
800.733.8829
989.773.7981
989.773.3210 FAX
custom parts direct from Delfield
5) Contract Ice
2) A.I.S. Commercial Parts & Service
3) Appliance Installation Service
4) Pacific Coast Parts
1816 West 26th Street
Erie, PA 16508-1149
800.332.3732
814.456.3732
814.452.4843 FAX
1336 Main Street
Buffalo, NY 14209
800.722.1252
716.884.7425
716. 884.0410 FAX
serves: MD, NJ, OH, PA, VA, WV
serves: CT, DC, DE, MA, MD, ME,
15024 Staff Court
Gardena, CA 90248
1.800.531.1111
1.800.782.5747
Email: orders@pacparts.com
www.pacparts.com
NH, NJ, NY, PA, RI, VA, VT, WV
serves: AZ, CA, HI, NV, OR
6) E.M.C.O. Sales & Distributors
7) Stove Parts Supply/GCS Service
14450 Ewing Ave S. #100
Burnsville, MN 55306
800.422.2823
952.894.4427
952.894.2164 FAX
3909 St. Timothy Lane
St. Ann, MO 63074
800.972.7670
314.427.7477
314. 427.8190 FAX
2120 Solona St.
PO Box 14009
Fort Worth, TX 76117-0009
1.800.433.1804 toll free
1.800.272.7358 fax
serves: IA, MN, MT, ND, SD, WI
serves: AR, IA, IL, KS,
serves: AR, LA, NM, OK, TX
8) Garland Group
1177 Kamato Road
Mississauga, Ontario L4W1X4
800.427.6668
800.361.7745 FAX
serves: Canada
KY, MO, NE, OK, TX, NM, LA
9) Global Parts and Supplies
11) MicroDine, Inc.
10) Hawkins Commercial Appl. Serv.
2920 N.W. 109th Avenue
Miami, FL 33172
305 994.9994
305.994.9992 FAX
3000 S. Wyandot
Englewood, CO 80110
(800) 624-2117
(303) 7618861 FAX
International parts depot
serves: AZ, CO, KS, NE, NM, OK, UT, WY
44792 Helm
Plymouth, MI 48170
888.828.4454
734.451.2043
734.451.3215 FAX
serves: MI, IN, WI, OH
13) Southeastern Restaurant Services
14) T.M.A.
2200 Norcross Parkway, Suite 210
Atlanta, GA 30071
800.235.6516
770.446.6177
770.446.3157 FAX
2916 Sidco Drive
Nashville, TN 37204
615.726.0351
800.737.0351
615.259.4100 FAX
serves: FL, GA, MS, NC, SC, VA
serves: TN, AL
12) Performance Refrigeration Parts
9923 S.W. 178th St.
Vashon, WA 98070
888.872.2465
206-463-1772
206.463.4431 FAX
serves: AK, HI, ID, MT, OR, WA
Delfield has 14 conveniently located Parts Depots to
ensure parts are handled promptly and accurately.
Delfield reserves the right to update or make changes
to this list without prior notice
Please call 1-800-733-8829 or check the web at www.delfield.com
for a list of the current Parts Depots.
980 S. Isabella Rd., Mt. Pleasant, MI 48804-0470, U.S.A. • (989) 773-7981 or (800) 733-8821 • Fax (800) 669-0619 • www.delfield.com
Delfield reserves the right to make changes in design or specifications without prior notice. 2003 The Delfield Company. All rights reserved. Printed in the U.S.A.
DM18PTB_BUC 02/05
Download PDF

advertising