Specifications | American DJ 700TM DJ Equipment User Manual

American DJ
®
Series
Fog Storm™ Series
Introduction
Introduction: Congratulations, you have just purchased one of
the most reliable fog machines on the market today! The Fog Storm™
Series commercial fog machines have been designed to perform reliably for years when the guidelines in this booklet are followed. Please
read and understand the instructions in this manual carefully and
thoroughly before attempting to operate this unit. These instructions
contain important information regarding safety during use and maintenance.
Customer Support: American DJ® provides a toll free customer
support line, to provide set up help and to answer any question should
you encounter problems during your set up or initial operation. You
may also visit us on the web at www.americandj.com for any comments or suggestions. For service related issue please contact American DJ®. Service Hours are Monday through Friday 9:00 a.m. to 5:00
p.m. Pacific Standard Time.
Voice:
(800) 322-6337
Fax:
(323) 582-2610
E-mail:
support@americandj.com
To purchase parts online visit http://parts.americandj.com
Warning! To prevent or reduce the risk of electrical shock or fire, do
not expose this unit to rain or moisture.
Caution! There are no user serviceable parts inside this unit. Do
not attempt any repairs yourself, doing so will void your manufactures
warranty. In the unlikely event your unit may require service please
contact American DJ®.
Do not discard the shipping cartoon in the trash. Please recycle when
ever possible.
SAFETY ISSUES:
User Instructions
American DJ
Rev 12/03
4295 Charter Street
Los Angeles Ca. 90058
www.americandj.com
NEVER POINT OR AIM A FOG MACHINE TOWARDS PEOPLE OR
THEIR CLOTHING. THIS UNIT EMITS HOT VAPOR AND SHOULD
BE USED WITH THE SAME CARE THAT YOU WOULD OBSERVE
WHEN USING AN ELECTRIC KETTLE OR IRON.
Please Note: Specifications and improvements in the design of
this unit and this manual are subject to change without any prior
written notice.
©American
DJ Supply® - Fog Storm™ Series - Instruction Manual Page 2
Fog Storm™ Series
Safety Precautions
• Be sure to save the packing carton in the unlikely event the unit
may have to be returned for service
• Do not spill water or other liquids into or on to your fogger. Be
sure that all the fog fluid is kept inside the fluid reservoir
• Be sure that the local power outlet match that or the required
voltage for your fog machine
• Do not remove the top cover under any conditions. There are no
user serviceable parts inside
• Disconnect the unit’s main power when left unused for long periods of time
• Never connect this unit to a dimmer pack
• Do not attempt to operate this unit, if it becomes damaged in anyway
• Never operate this unit when it’s cover is removed
• To reduce the risk of electrical shock or fire, do not expose this
unit rain or moisture
• Do not attempt to operate this unit if the power cord has been frayed or broken. Do not attempt to remove or break off the ground
prong from the electrical cord. This prong is used to reduce the
risk of electrical shock and fire in case of an internal short
• Disconnect from main power before making any type of connection
• Never block the ventilation holes. Always be sure to mount this
unit in an area that will allow proper ventilation. Allow about 6”
(15cm) between this device and a wall
• This unit is intended for indoor use only, use of this product outdoors voids all warranties
• Always mount this unit in a safe and stable matter
• Please route your power cord out of the way of foot traffic. Power
cords should be routed so they are not likely to be walked on,
pinched by items placed upon or against them
• Cleaning -The fixture should be cleaned only as recommended by
the manufacturer. See page 7 for cleaning details
• The unit should only be serviced by qualified service personnel
when:
A. The power-supply cord or the plug has been damaged.
B. Objects have fallen, or liquid has been spilled into the unit.
C. The unit has been exposed to rain or water.
D. The appliance does not appear to operate normally or
exhibits a marked change in performance.
©American
DJ Supply® - Fog Storm™ Series Instruction Manual Page 3
Fog Storm™ Series
Description
The new Fog Storm™ Series fog machines included a revolutionary
new heating element that has been specially designed to prevent
excessive particle build up that can cause premature fogger failure.
Each of the fog machines in this series include a wide-angle spray
nozzle and long-life pump that was specially designed for high performance fogger output. Each of the fog machines also includes a 25
foot (eight meters) remote control, that may be removed for periods
on non-use. An optional wireless remote control is also available from
American DJ® for each of the fog machines and increases the functionality of the fogger greatly.
Fog Storm™ Series
Set-Up
1. Open the shipping carton and carefully remove the unit from the
shipping carton.
2. Be sure to remove all the packing material especially around the
nozzle.
3. Set the fog machine on a flat dry surface. Locate the included
bracket from the package and install it using the supplied hardware to the side casing. Note: The bracket is an optional accessory and may not be used if desired, however if you intend to suspend the unit from truss the bracket must be used.
4. Remove the fluid reservoir and fill it with American DJ® branded
fog juice only and replace the reservoir.
5. Place the feeder tube with the filter deep in side the reservoir and
tighten the cap.
6. Firmly attache the remote control unit to the rear remote control
socket on the unit.
7. Plug the unit in to a matching power supply. Wait approximately
five minitues for the fogger to reach normal operating temperature.
8. Follow the operating instructions on the next page for proper
operation.
©American
DJ Supply® - Fog Storm™ Series Instruction Manual Page 4
Fog Storm™ Series
Operating Instructions
Always be sure to maintain an adequate supply of American
DJ® Brand Fog Juice™ in the fluid reservoir. Running the fog
machine dry will cause pump failure and or clogging. This is the
largest cause of failure in fog and haze machines. Only American
Fog Juice™ is recommended and not all fog juice is created
equal.
Remote Operation: The remote control comes connected to the
fog machine but can be removed to access the 25 foot cord. Once
the machine is plugged in and turned on, a red power L.E.D. on the
remote will glow indicating the unit is receiving power. The unit has
a warm up time of five (5) minutes. After the unit has warmed up, a
GREEN L.E.D. on the remote will light indicating the unit is ready to
emit fog. To emit fog, simply press the green button on the remote
for desired length of time. If the GREEN L.E.D. is on and fog does
not come out after holding the button down for 30 seconds, check
the fluid tank and hose to make sure there is fluid going through the
hose.
Optional Timer: You can also operate the fog output automatically
by purchasing the optional timer remote. The timer function allows
haze to be emitted at designated intervals. The remote has three
(3) L.E.D.s that indicate different functions; The YELLOW L.E.D. will
indicate the timer is off and not activated. The RED L.E.D. indicates
power is on. The GREEN L.E.D. indicates fog output is available. The
remote also contains two rotary knobs. The Duration knob serves
two functions 1) Turns the timer on and off. 2) Sets the timers duration (Length of fog output). The interval knob sets the amount of time
in between fog output from 30 seconds to 10 minutes. Turing these
knobs in a clockwise direction will increase there values, turning
them in a counter-clockwise direction will decrease their values.
Caution: Before removing or replacing the remote control unit
Fog Storm™ Series
Clean Machine
To help prevent the unit from clogging, use American DJ ® Clean
Machine™ liquid. Clean Machine is recommended when storing your
fogger for more than 1 week, or at least once a month as normal
maintenance under regular usage. Clean Machine removes particle
build up in the heater and gives longer life to the fog machine. Clean
Machine is like a tune up for your fog machine! Clean Machine is
available in gallon or quart bottles.
Fog Storm™ Series
Warranty Registration
The Fog Strom™ series fog machines carries a one year (365 days)
limited warranty. Please fill out the enclosed warranty card to validate
your purchase. All returned service items whether under warranty or
not, must be freight pre-paid and accompany a return authorization
(R.A.) number. The R.A. number must be clearly written on the outside of the return package. A brief description of the problem as well
as the R.A. number must also be written down on a piece of paper
and included in the shipping container. If the unit is under warranty,
you must provide a copy of your proof of purchase invoice. You may
obtain a R.A. number by contacting customer support at (800) 3226337.
Fog Storm™ Series
Trouble Shooting
If you experience low fog output, pump noise, or no fog output at all,
disconnect and discontinue use immediately. Do not attempt to continue pushing the remote control’s activation button as this may damage the fog machine. Check fluid level, the external fuse or breaker,
remote connection, and be sure the wall outlet is sending power. If
all of the above appear to be okay, and the unit fails to operate correctly, the unit will require service. Return the machine to an American
DJ® authorized dealer or service center.
disconnect the power supply.
©American
DJ Supply® - Fog Storm™ Series Instruction Manual Page 5
©American
DJ Supply® - Fog Storm™ Series Instruction Manual Page 6
Fog Storm™ Series
Warranty
1 YEAR LIMITED WARRANTY
A. American DJ® hereby warrants, to the original purchaser, American DJ® products to be
free of manufacturing defects in material and workmanship for a period of one year (365
days) from the date of purchase. This warranty shall be valid only if the product is purchased
within the United States of America, including possessions and territories. It is the ownerʼs
responsibility to establish the date and place of purchase by acceptable evidence, at the
time service is sought.
B. For warranty service, send the product only to the American DJ® factory. All shipping
charges must be pre-paid. If the requested repairs or service (including parts replacement)
are within the terms of this warranty, American DJ® will pay return shipping charges only to a
designated point within the United States. If the entire instrument is sent, it must be shipped
in its original package. No accessories should be shipped with the product. If any accessories are shipped with the product, American DJ® shall have no liability whatsoever for loss
of or damage to any such accessories, nor for the safe return thereof.
C. This warranty is void if the serial number has been altered or removed; if the product
is modified in any manner which American DJ® concludes, after inspection, affects the reliability of the product; if the product has been repaired or serviced by anyone other than
the American DJ® factory unless prior written authorization was issued to purchaser by
American DJ®; if the product is damaged because not properly maintained as set forth in the
instruction manual.
D. This is not a service contract, and this warranty does not include maintenance, cleaning
or periodic check-up. During the period specified above, American DJ® will replace defective
parts at its expense, and will absorb all expenses for warranty service and repair labor by
reason of defects in material or workmanship. The sole responsibility of American DJ® under
this warranty shall be limited to the repair of the product, or replacement thereof, including
parts, at the sole discretion of American DJ®. All products covered by this warranty were
manufactured after January 1, 1990, and bear identifying marks to that effect.
E. American DJ® reserves the right to make changes in design and/or improvements upon
its products without any obligation to include these changes in any products theretofore
manufactured.
F. No warranty, whether expressed or implied, is given or made with respect to any accessory supplied with products described above. Except to the extent prohibited by applicable
law, all implied warranties made by American DJ® in connection with this product, including
warranties of merchantability or fitness, are limited in duration to the warranty period set forth
above. And no warranties, whether expressed or implied, including warranties of merchantability or fitness, shall apply to this product after said period has expired. The consumerʼs
and or Dealerʼs sole remedy shall be such repair or replacement as is expressly provided
above; and under no circumstances shall American DJ® be liable for any loss or damage,
direct or consequential, arising out of the use of, or inability to use, this product.
G. This warranty is the only written warranty applicable to American DJ® Products and
supersedes all prior warranties and written descriptions of warranty terms and conditions
heretofore published.
H. Lamps are not covered under this warranty.
©American
DJ Supply® - Fog Storm™ Series - Instruction Manual Page 7
Fog Storm™ Series
MODEL - Fog Storm 700™
VOLTAGE*:
WEIGHT:
DIMENSIONS:
FUSE:
WARM UP TIME:
TANK CAPACITY:
OUTPUT:
FLUID TYPE:
DUTY CYCLE:
HEATER:
Specifications
120v~50/60Hz or 230v~50Hz
8 Lbs. / 3.5 Kgs
9.5" x 6” x 5.25” / 240 x 150 x 130 mm
120v=10A/30mm or 230v=5A/30mm
5 Minutes
1 Liter Removable
3500 cubic feet per minute
Water Base American DJ Fog Juice™
Not to exceed 6 hours turned on.
700 watt
*Voltage is preset at the factory and may not be changed
MODEL - Fog Storm 1200™
VOLTAGE*:
WEIGHT:
DIMENSIONS:
FUSE:
WARM UP TIME:
TANK CAPACITY:
OUTPUT:
FLUID TYPE:
DUTY CYCLE:
HEATER:
120v~50/60Hz or 230v~50Hz
12 Lbs. / 5.4 Kgs
12" x 8.75 x 6.5” / 300 x 220 x 160 mm
120v=12A/30mm or 230v=7A/30mm
8 Minutes
2.5 Liter Removable
7000 cubic feet per minute
Water Base American DJ Fog Juice™
Not to exceed 6 hours turned on.
1200 watt
*Voltage is preset at the factory and may not be changed
MODEL - Fog Storm 1700™
VOLTAGE*:
WEIGHT:
DIMENSIONS:
BREAKER:
WARM UP TIME:
TANK CAPACITY:
OUTPUT:
FLUID TYPE:
DUTY CYCLE:
HEATER:
120v~50/60Hz or 230v~50Hz
22 Lbs. / 10 Kgs
17.25" x 11” x 11.5”/435 x 280 x 290 mm
120v = 20A NFB / 230v = 10A NFB
7 Minutes
5 Liter Removable
15000 cubic feet per minute
Water Base American DJ Fog Juice™
Not to exceed 6 hours turned on.
1700 watt
*Voltage is preset at the factory and may not be changed
©American DJ Supply®
A Division of the American DJ Group of Companies
American DJ World Headquarters:
4295 Charter Street Los Angeles, CA 90058 USA
Tel: 323-582-2650 / Fax: 323-582-2610
Web: www.americandj.com / E-mail: info@americandj.com
Download PDF

advertising