842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 1

OWNER’S MANUAL

SINGLE BURNER

PROPANE STOVE

WARNING

FAILURE TO FOLLOW ALL WARNINGS

AND INSTRUCTIONS IN THIS MANUAL

COULD LEAD TO PERSONAL INJURY,

INCLUDING DEATH.

RETAIN THIS MANUAL FOR

FUTURE REFERENCE.

DESIGN

CERTIFIED ™

Propane cylinder not included.

842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 2

FOR YOUR SAFETY:

IF YOU SMELL GAS:

1. DO NOT attempt to light appliance.

2. Extinguish any open flame.

3. Disconnect from fuel supply.

FOR YOUR SAFETY:

DO NOT store or use gasoline or other liquids with flammable vapors in the vicinity of this or any other appliances.

IMPORTANT SAFETY WARNINGS

WARNING

• FOR OUTDOOR USE ONLY. DO NOT operate indoors (house, tent, garage) or in any unventilated or enclosed area.

• All burning appliances consume oxygen. This stove uses oxygen from the air and may produce CO (Carbon Monoxide), which is a colorless, odorless gas that can kill you. Ample ventilation must be provided to avoid endangering your life. Be certain that the area in which this appliance is used is properly ventilated at all times.

• DO NOT use as a space heater.

• DO NOT leave stove unattended when hot or in use. Only adults are to operate this stove; keep children and pets safely away. Carefully monitor all activity around stove to avoid burns or other injuries.

842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 3

WARNING

• Never place more than 15 pounds on stove.

• DO NOT operate stove within 36" from any combustible material including walls and ceiling.

• DO NOT use on/in apartment complex balconies or patios, recreational vehicles, campers or boats.

• Propane gas is extremely flammable, follow these instructions:

• DO NOT store or use gasoline or other liquids/aerosols with flammable vapors in the vicinity of this appliance.

• Use only 16.4 oz. LP-gas cylinder(s) constructed and marked in accordance with the specifications for LP-gas cylinders of the United States Department of Transportation

(DOT) or Transport Canada, CAN/CSA 339. DO NOT use fuel other than propane.

• Always attach or detach propane cylinder outdoors away from flame, pilot lights or other sources of ignition and only when appliance is cool to touch.

• Read and follow all warnings and instructions on or accompanying propane cylinder.

• Always inspect appliance, propane cylinder and propane connections for damage, dirt or debris before attaching propane cylinder. DO NOT use if either has been damaged or modified.

• Follow directions in the "Gas Leak Testing" section on page 4 of this manual. Never test for gas leaks with a lit match or open flame. DO NOT operate the stove with a gas leak.

• When transporting, not using, or storing stove always disconnect propane cylinder.

• Propane cylinder should remain upright to prevent liquid propane flare-up.

• DO NOT connect to a remote gas supply such as natural gas or a refillable propane cylinder.

• In case of fire, turn gas "OFF" at burner control knob and use Type 'BC' fire extinguisher or other appropriate means to extinguish flame.

• Keep hands, face and hair away from burner. Use matches or long-nosed lighter to light the burner. DO NOT wear loose clothing or allow long hair to hang freely while lighting or using stove.

• Always snap down legs to locked position, before installing propane cylinder. Use only on a flat surface.

• DO NOT move stove while in use. Avoid touching hot surfaces.

• Only use replacement/accessory parts manufactured by The Brinkmann Corporation.

Repairs should be performed by The Brinkmann Corporation. For parts or repairs contact

The Brinkmann Corporation’s Customer Service Department at 1-800-527-0717.

• Properly dispose of all packaging materials.

2

842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 4

ASSEMBLY INSTRUCTIONS

READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS

CAREFULLY BEFORE ASSEMBLING OR OPERATING YOUR STOVE.

Inspect contents of the box to ensure all parts are included and undamaged.

FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 1-800-527-0717.

(Proof of purchase will be required.)

Step 1

Extend legs to locked position.

Leg

Control Knob

Step 2

Make sure burner control knob is in "OFF" position.

Step 3

Attach propane cylinder to stove fitting.

HAND TIGHTEN ONLY. Do not cross-thread connections.

Step 4

Follow "Gas Leak Testing" instructions on page 4 of this manual.

WARNING: Always extend legs to locked position, before installing propane cylinder. Use only on a flat surface.

Attach Detach

3

842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 5

GAS LEAK TESTING

WARNING

• Gas leak testing must be performed outdoors in a well ventilated area every time cylinder is connected to stove.

• Always keep unit away from open flames, sparks or lit cigarettes.

• Never use a flame to check for gas leaks.

• The control knob is used when lighting the burner and to adjust the flame.

• Never use a unit that has a gas leak. Contact The Brinkmann Corporation’s Customer Service

Department for replacement parts or repairs at 1-800-527-0717.

Step 1

Assemble stove per "Assembly Instructions" on page 3 of this manual. Make sure burner control knob is in "OFF" position.

Watch for Bubbles

Step 2

Prepare a soapy water solution (one part dishwashing liquid to three parts water) to test for gas leaks in the connection. Apply a generous amount of the soapy mixture to the propane cylinder and stove fitting (located underneath stove).

Step 3

With the burner control knob in the "OFF" position, check for bubbles where propane canister attaches to stove fitting. If soapy mixture starts bubbling, gas is leaking through the connection. Disconnect the propane canister.

Retighten the connection that is leaking gas.

Repeat procedure with soapy mixture until gas no longer leaks. NEVER USE A FLAME TO CHECK

FOR GAS LEAKS.

Step 4

Once all gas leaks have been sealed, WAIT AT

LEAST 5 MINUTES FOR GAS FUMES TO

DISSIPATE BEFORE LIGHTING THE BURNER.

Carefully follow "Operating Instructions" to light the burner and properly operate this unit.

4

842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 6

5

OPERATING INSTRUCTIONS

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY.

WARNING

• DO NOT allow gasoline or other flammable vapors or liquids to come in contact with stove while lighting or at any time during use of stove.

Step 1

Make sure "Gas Leak Testing" from page 4 was completed and the burner control knob is in the "OFF" position and stove is on a flat surface away from combustible material.

Minimum clearance to combustibles 36 inches from top and side of stove burners

36"

Step 2

Using a match, hold the flame beside burner. Turn the burner control knob SLOWLY counter-clockwise until the burner lights.

36"

WARNING: If the burner does not light within 5 seconds, turn the burner control knob "OFF" immediately. Wait at least 5 minutes until gas fumes have dissipated before attempting to light burner again.

Step 3

Adjust burner flame as necessary by using burner control knob. Turn stove "OFF" using burner control knob when stove is not in use.

Step 4

Allow stove to cool completely, then follow instructions in the "After-Use Safety" and "Proper Care & Maintenance" sections of this manual.

Match

Perimeter of base of stove

Control Knob

ON / Larger Flame

OFF

ON

OFF / Smaller Flame

NOTE: Observe flame height and color when lit. Flame should have a blue center and a slight yellow tip.

Burner

Yellow

Blue

842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 7

AFTER-USE SAFETY

• Always allow the stove to cool completely before handling.

• When disconnecting propane cylinder, a small amount of LP gas is released until cylinder is completely removed. Cylinder contains a self-sealing valve.

• Always disconnect the propane cylinder from stove when not in use - Replace cap on the propane cylinder.

• Store propane cylinder in a well ventilated area away from any heat source or open flame.

• Fold legs underneath stove body.

PROPER CARE & MAINTENANCE

• Wipe exposed parts of stove with damp cloth. Do not use abrasive materials.

• To protect your stove, the unit must be kept clean and covered at all times when not in use.

• Only use replacement/accessory parts manufactured by The Brinkmann Corporation. Repairs should be performed by The Brinkmann Corporation. For parts or repairs, contact The Brinkmann Corporation’s

Customer Service Department at 1-800-527-0717.

• Cover and store stove in a protected area away from children and pets.

• After product has been stored and prior to reusing, verify that burner is free from leaves, insects, spider webs, dirt, etc. as these items can obstruct the flow of combustion air.

• Prior to each use, visually check the burner flame for proper operation as described on page 5.

DO NOT use if burner/flame is not operating properly.

• This stove requires an unobstructed airflow to operate correctly.

• During use or storage, always keep the stove area clear and free of combustible materials, gasoline and other flammable vapors and liquids.

NOTE: Due to the intense heat from burner, it is normal for discoloration to occur on stove during the first few uses.

6

842-0010-S_OneBurnerStove.qxd 1/5/05 4:50 PM Page 8

©2003 The Brinkmann Corporation

Dallas, Texas 75244 U.S.A

www.brinkmanncorp.com

1-YEAR LIMITED WARRANTY

For 1-year from date of purchase, The Brinkmann Corporation warrants the Single Burner Propane Stove against defects due to workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligations under this warranty are limited to the following guidelines:

• This warranty does not cover stoves that have been altered or damaged due to: normal wear, abuse, improper maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an authorized employee of

The Brinkmann Corporation.

• This warranty does not cover surface scratching or heat damage to the finish, which is considered normal wear.

• The Brinkmann Corporation may elect to repair or replace damaged units covered by the terms of this warranty.

• This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers.

The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you retain your sales receipt or invoice. To obtain replacement parts for your Single Burner Propane Stove under the terms of this warranty, please call Customer Service Department at 1-800-527-0717 for a Return Authorization Number and further instructions. A receipt or

proof of purchase will be required. Units returned to Brinkmann (without propane cylinder) must include your name, address and telephone number. Please make sure product is properly packed, postage prepaid and insured. The Brinkmann Corporation will not be responsible for any products forwarded to us without prior authorization.

EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.

THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION

TO 1-YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED

WARRANTY LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.

ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE SINGLE

BURNER PROPANE STOVE TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED. CUSTOMER

ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE WARRANTY

SET OUT ABOVE. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL

DAMAGES, SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC

LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.

140-0010-O

11/03, 7/04, 9/04

Owner’s Manual for Models

842-0010-0, 842-0010-S